820098_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

WASTE UTILIZATION PLAN
Coharie Hog Farm
Tuesday, July 31, 2001
Producer: - F & B Farms
Fame Name :
Telephone # :
Type of Operation:
F & B Farms 82-98
2182 Boykin Bridge Rd,
Clinton,NC 28328
[phone]
Feeder to Finish swine
Number of Animals : 3720 frogs design capacity
Application Method: Irrigation
RECEIVED ! DENR I DWQ
AQUF R*PRnTFr'nAN FC
MAR 2 3 2009
RECEIVED
IAR ) 5 2M
0W-FAYEf1EviLU RMfIW 0fflGF
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananiysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
Page . of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3720 hogs X 1.9 tons wastelhogslyear = 7068 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3720 hogs'X 2.3 Ibs PAN/hogs/year = 8556 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application. - _ -
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE NIACRE WACRE USED TIME
7450
2
INORFOLK 0-2%
BH
6.5
325
0
17.23
5599.75
MAR-OCT
7450
2
NORFOLK 0-2%
SG
1
50
0
17.23
861.5
SEP-MAY
7450
5
INORFOLK 0-2%
BH
6.5
325
0
4.34
1410.5
MAR-OCT
7450
- 5
NORFOLK 0-2%
SG
1
50
0
4.341
217
SEP-MAY
7250
7
NORFOLK 0-2%
BH
6.5
3251
0
4.29
1394.25
MAR-OCT
7250
7
NORFOLK 0-2%
SG
1
501
01
4.29
214.5
SEP-MAY
TOTALS: 9697.5
— Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require fanners in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
r
Page 2 of 9

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or.winter annuals follow
summer annuals.
" Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP
BH HYBRID BERMUDAGRASS-HAY
SG SMALL GRAIN OVERSEEDED
UNITS LBS NlUNIT
TONS 50
AC 50
Page 3 of 9

TOTALS FROM TABLES I AND 2
ACRES LBS AW
N USED
TABLE 1 25.66 9,698
TOTALS: 25.861 9,698
AMOUNT OF N PRODUCED: 8,556
"BALANCE -1,142
' This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 1376.4 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1,58 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts -
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (inlhr) AMT (inches)
7250
-7
NORFOLK 0-2%
SG
0.50
'1
7250
7
NORFOLK 0-2%
BH
0.50
"1
7450
-2.-5
NORFOLK 0-2%
SG
0.50
'1
7450
2,5
NORFOLK 0-2%
BH
0.50
'1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
appiicaiion amouni shown can be applied under optimum soil conditions.
Page 4 3s 9

NARRATIVE OF OPERATION
Acreages based on a wettable acreage determination completed on 8-3-01 & updated 4-20-
06
Page 5 of g

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose. of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 40 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carciina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control conditions conducive
to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit erowth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
mmimum ana a suitaole winter cover crop piameo to ?arse up released nutrients. Waste snail
got be applied more than �0 days prior to planting et a crop on bare soil.
i 1. Any new swine facility sited cn or after October 1. 190-5 shall comply with the following:
the outer oerimeter of the [and area onto which waste is applied from a lagoon that is a
component of a swine t'arm shall be at least 56 reet frorn anv residential orooerty boundary
Page 6 of 9

and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist"_
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no. runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
�)? WasiP. sh;;Ii hP rpSiPd wiihin 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels, pH shall be adjusted for
optimum cror) production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Pouitry dry waste application records shall be maintained for three (3) years.
!Haste application recores for ail other waste shall be maintained for five (5) vears.
Page 7 of 9

23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 8 of 9

NAME OF FARM: F & B Farms
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
Plan and a new certification to be submitted to DEM before the new animals are stocked.
(we) understand that 1 must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the'land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACIL TY OWNER: & B arms
SIGNATURE: DATE:
NAME OF MANAGER (if different from owner):
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: Curtis Barwick
AFFILIATION: Coharie Hog Farm
ADDRESS (AGENCY): 300 Westover Rd.
Clinton, NC 28328
1O) 5 -172
SIGNATURE: DATE:
�'--1 -0(
please print
L110 -06
Page 9 of 9

P'W
I )V... i , I
I LA
IL :,k
Aft

1 OF W A
7 �
O -�C
,;? — ? P
Curtis Barwick
Coharie Farms
300 Westover Road
Clinton, North Carolina 28328
Dear Mr. Barwick:
January 28, 2008
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
0b41A-FAM TEvLC£kfU0NAL0FHCE
Subject: Sludge Survey Testing Dates
Coharie Farms
Animal Waste Management System
The Division of Water Quality (Division) received your sludge surveys information on January 16„ 2008.
With your results, you requested that the numerous lagoons be exempt from further sludge surveys for the
life of the current permits. Due to the amounts of treatment volume available, the Division agrees
that a sludge survey is not needed until 2009 for the lagoons that are listed on the attached table.
For these lagoons, the results of the 2009 sludge survey are to be submitted by March 1, 2010.
Thank you for your attention to this matter. If you have any questions, please call me at (919)
715-693 7.
Sincerely;
Miressa D. Garoma
Animal Feeding Operations Unit
ec: Wilmington Regional Office, Aquifer Protection Section
Raleigh Regional Office, Aquifer Protection Section
Fayetteville Regional Office, Aquifer Protection Section
Washington Regional Office, Aquifer Protection Section
Central Files
Aquifer Protection Section 1636 Mail Service Center
Intemet: www.newate�ra Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer- 50% Recycledl10% Post Consumer Paper
lvorthCarolina
)Vaturally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

1
COHARIE FARMS SLUDGE SURVEY EXEMPTIONS APPROVAL
January 28, 2008
FARM NO.
FARM NAME
Owner Name
COUNTY
REGIONAL
OFFICE
LAGOON ID
EXTENSION
APPROVAL TO 2009
1
AWS820183
Coharie C-10 i
D M Faircloth
Sampson
Fayetteville
L#3 only
Yes
2
AWS820237
Coharie Farms C-I i
Coharie hog farm
Sampson
Fayetteville
1
Yes
3
AWS820667
Hall Farm
Coharie hog farm
Sampson
Fayetteville
1
Yes
4
AWS820081
Coharie Farms C-12
Coharie hog farm
Sampson
Fayetteville
L#2 only
Yes
5
AWS820098
F & B Farms
Graham Freddie
Sampson
Fayetteville
1
Yes
6
AWS820132
Sam Hope farm
Samuel Hoe
Sampson
Fayetteville
I
Yes
7
AWS820377
ADJ Nursery #2
ADJ Farms Inc
Sampson
Fayetteville
1
Yes
8
AWS820053
F & B Farms
F & W Farms
Sampson
Fayetteville
I
Yes
9
AWS820188
F & B Farms
James Faircloth
Sampson
Fayetteville
1
Yes
10
AWS820061
Knotty Pine Farm
Michael Herring
Sampson
Fayetteville
L#1 & L#2
Yes
11
AWS820090
Quarter D Farms
Quarter D Farms
Sampson
Fa etteville
L#1 & L#2
Yes
12
AWS820229
P & J Farms
Nelson Porter
Sampson
Fayetteville
L#2 only
Yes
13
AWS820392
Running Branch #2
Joel Parker
Sampson
Fayetteville
1
Yes
14
AWS820606
Goshen Farms
Nelson Waters
Sampson
Fayetteville
1,31, L#2, & L#3
Yes
15
AWS820042
John Royal #1-8
John Royal
Sampson
Fayetteville
L31, L#2, & L#3
Yes
16
AWS510028
J & M Hog Farm
J & M Hog Farm
Johnston
Raleigh
1
Yes
17
AWS310162
Glade Ride
Charles Edwards
Duplin
Wilmington
L# 1 & L#2
Yes
18
AWS710052
M & D Sow Farm
Mike Hope
Pender
Wilmington
1
Yes
19
AWS960028
Bennie Barwick Farm
Bennie Barwick
Wayne
Washington
1
Yes
20
AWS260059
Collier Farms
David Collier
Cumberland
Fayetteville
1
Yes
21
AWS820711
HenryMoore Farm
Henry Moore
Sampson
Fayetteville
1
Yes
22
AWS310655
Sloan Brothers
Troy Sloan
Duplin
Wilmington
1
Yes
23
IAWS510041
Spring Meadow Farms
Whitley Stephenson
lJohnston
1 Raleigh
I 1
Yes
1/29/2008 mdg

o=0 wAr�9p�
� Y
Graham Freddie Fredrick Butler
F&B Farms
2162 Boykin Bridge Rd
Clinton, NC 28329
Dear Graham Freddie Fredrick Butler:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007
Subject: Certificate of Coverage No. AWS820098
F&B Farms
Animal Waste Management System
Sampson County
In accordance with your application received on 4-Jan-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Graham Freddie Fredrick Butler, authorizing the operation of the
subject animal waste management system in accordance with General Permit AWG100000,
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the F&B Farms, located in Sampson County, with an animal capacity of no greater
than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 3720 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition M.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pav
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: Www.ncwatemuality.ora Location: 2728 Capital Boulevard
An Equal Opportunq/Afirmatnre Anion Employer- 50% Recycled/1 D% Post Consumer Paper
l%�Carolina
dVaturally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS820098

A W A rF9PG Michael F. Easley, Governor
cl
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
.r Alan W. Klimek, P.E. Director
Division of Water Quality
August 23, 2005
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
RECEIPT # 7002 2410 0003 0272 8637
Mr. Freddie Butler
F&B Farms
2162 Boykin Bridge Rd
Clinton, NC 28328
RE: Sludge Survey Testing Dates
Facility # 82-98
Sampson County
Dear Freddie Butler:
The Division of Water Quality (DWQ) received sludge survey information on July 27,,
2005. With your results you requested an extension of the sludge survey requirement for the
lagoons at F&B Farms until 2007. Due to the amount of treatment volume available, DWQ agrees that a sludge survey is not needed until 2007. The results of the 2007 sludge surveys are
to be submitted with the Annual Certification Form that will be due on March 1, 2008.
Thank you for your attention to this matter. If you have any questions, please call me at
[phone].
Sincerely,
Keith Larick
Animal Feeding Operations Unit
cc: File# 82-98
Fayetteville Regional Office
1Por�nnCarol ina
✓vrrtura!!y
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh. NC 27699-1617 Phone [phone] Customer Service
fnternet: h2o.ennstate.ne.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

rage t of
Curtis Barwick
From: Keith Larick [[e-mail]]
Sent: Friday, August 05, 2005 9:08 AM
To: Curtis Barwick
Subject: Re: Sludge Survey Exemptions
Curtis,
1 have added the due date of the next sludge survey to the spreadsheet. Let me know if you have any questions.
Thanks,
Keith
Curtis Bar.Nick wrote:
Thank you Keith. I look forward to hearing from you.
CURTIS
-----Original Message ------
From: Keith I,arick (mailto:keith.larick@ncmail-net]
Sent: Wednesday, July 27, 2005 5:35 PM
To: Curtis Barwick
Subject: Re: Sludge Survey Exemptions
Curtis,
I got the mailing, and should get to it soon.
Keith
Cur'cis Barwick wrote:
Keith,
Please see the attached list of farms that I am asking for exemptions from
the annual sludge survey. I am sending via USPS the information sheets for
each individual farm. I am emailing this list so that you can reply back
after you have finished, with the due date for the next survey (if granted
an extension). This should save you having to send a letter to me about it.
Hopefully this will make it easier for you.
I look forward to hearing from you.
Thanks, CURTIS.

i
SLUDGE SURVEY EXEMPTION_ LIST
CURTIS BARWICK
1
910 590-6314
Counly # Facility# Farm Name
First Name
Last Name {
County
Type Next Survey
Due
26
59 David Collier Farm
David
Collier
Cumberland
Finish
2007
51
28 J & M Hog Farm
J & M Hog Farm
i
Johnston
Finish
2007
AGOON 1 & 3 51
41 Spring Meadow Farm Unit 1
Whitley
Stephenson
Johnston
Sow
2008
51
46 Sandy Ridge Pork
Whitley
Stephenson
I
Johnston
Sow
2009
AGOON #2 Or 82
42 John O Royal #1-8
Johq
1
Royal
'Sampson
Finish
2007
82
53 F & W Farms I B - T Farm
F & W Farms,
Sampson
Finish
2007
82
74 Linoard Howard & Son (New Farm
Linoard
Howard j
Sampson
Finish
2005
82
98 F&B Farms
Harold Frederick & Freddl
Butler,
Sampson
Finish
2007
82
132 Sam Hope Farms
Samuel J.
Hope i
Sampson
Finish
2007
82
188 F&W Farms
James
Faircloth
Sampson
Finish
2007
82
190 Billy Lockamy Farm
Billy
Lockamy
Sampson
Finish
2006
82
202 Simmons Hog Farm
Ray
Simmons
Sampson
Finish
2006
82
215 T&T Farms
Frederick
Thornton
Sampson
Finish
2007
82
606 Goshen Farms
W. Nelson
Waters Jr
Sampson
Finish
2007
:
: � 666;`Johriny.Hope'-Farms=•'
.'John A.-
Hope -:
Sampson
Finish
2006
82
667 Hall Farm
Coharie Hog Farm
Sampson
Finish
2007
82
725 C-7
Coharle Hog Farm
Sampson
Finish
200E
B2
61 Knotty Pine Farm
Mike
Herring
Sampson
Finish
2007
AGOON #2 Or B2
315 Bobcat Farms
Henry
Moore
Sampson
Sow
2007
82
711 Henry Moore Finisher/Bad Branch
Henry
Moore
Sampson
Finish
2007
82
714 SHW Sow Farm LLC _
SHW Sow Farm LLC
i
Sampson
Sow
2009
96
28 Bennie Barwick Finishing
Bennie
Barwick
Wayne
Finish
2007
i
-
1

i
Curtis Barwick-.4,�.,�A
From: Keith I_arick [[e-mail] F^ '
Sent: Friday, August 05, 2005 9:08 AM
E
To: Curtis Barwick
Subject: Re: Sludge Survey Exemptions
Curtis,
I have added the due date of the next sludge survey to the spreadsheet. Let me know if you have any questions.
Thanks,
Keith ;
Curtis Barwick wrote:
Thank you Keith. I look forward to hearing from you.
CURTIS
-----Original Message ------
From: Keith Larick [mailto:[e-mail]]
Sent: Wednesday, July 2.7, 2005 5:35 PM
To: Curtis Barwick
Subject: Re: Sludge Survey Exemptions
Curtis,
I got the mailing, and should get to it soon.
Keith
Cui:Lis Barwick wrote:
{
Keith,
Please see the attached list of farms that I am asking for exemptions from
the annual sludge survey. I am sending via USPS the information sheets for
each individual farm. I am emailing this list so that you can reply back
after you have finished, with the due date for the next survey (if granted
an extension). This should save you having to send a letter to me about it.
Hopefully this will make it easier for you.
1 look forward to hearing from you.
Thanks, CURTIS.
n r7 n 17 nn4

f
G
a
SLUDGE SURVEY EXEMPTION LIST"
CURTIS BARWICK
910 590-6314
County # Facility # Farm Name
First Name
Last Name
County
Type Next Survey
Due'
26
59 David Collier Farm
David
Collier
Cumberland
Finish
200'
51
28 J & M Hog Farm
J & M Hog Farm
Johnston
Finish
200'
,,GOON 1 & 3 51
41 Spring Meadow Farm Unit 1
Whitley
Stephenson j
Johnston
Sow
200!
51
46 Sandy Ridge Pork
Whitley
Stephenson
Johnston
Sow
200!
gGOON #2$r'3 t2
42 John O Royal; #1-8
Johq
Royal
Sampson
Finish
200'
�G„��0aln 82
53 F & W Farms 1 B - T Farm
F & W Farms
Sampson
Finish
200'
82
74 Linoard Howard & Son (New Farr- Linoard
Howard I
Sampson
Finish
200
82
98 F&B Farms
Harold Frederick & Freddi Butler
Sampson
Finish
200
82
132 Sam Hope Farms
Samuel J.
Hope
Sampson
Finish
200
82
188 F&W Farms
James
Faircloth
Sampson
Finish
200
82
190 Billy Lockamy Farm
Billy
Lockamy
Sampson
Finish
200
82
202 Simmons Hog Farm
Ray
Simmons
Sampson
Finish
200
82
215 T&T Farms
Frederick
Thornton
Sampson
Finish
200
82
606 Goshen Farms
W Nelson
Waters Jr
SampsonSarn
Finish
200
:82 _..:..
.._...Y p
66::Johnn 'Ho a IFarms
John A�
�... _
ope Y ,
t..,p_.
Sam' son.
Firilsh
200
62
667 Hall Farm
Coharie Hog Farm
!
Sampson
Finish
200
82
725 C-7
Coharle Hog Farm
Sampson
Finish
200
82
61 Knotty Pine Farm
Mike
Herring
Sampson
Finish
200
AGOON #2 Or 82
315 Bobcat Farms
Henry
Moore
Sampson
Sow
200
B2
711 Henry Moore Finisher/Bad Branch Henry
Moore
Sampson
Finish
20C
82
714 SHW Sow Farm LLC
SHW Sow Farm LLC
Sampson
Sow
20[
96
28 Bennie Barwick Finishing
Bennie
Barwick
Wayne
Finish
20C

December 1, 2006
CERTMED MAIL
RETURN RECEIPT REQUESTED
Freddie Butler
F&B Farms
2162 Boykin Bridge Rd
Clinton, NC 28329
Michael F_ Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Alan W. Klimek, P.E. Director
Division of Water Quality
RECEIVE
DEC 06 M
�fl-fAYEiiEYE�IE i;�iAL �(�
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at ht!p//h2o.enr.state.nc.uslaps/afou/downloads.htm or by writing or calling:
NCDENR - DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under one of these two types of general permits, you must submit an application for permit
coverage to the Division. Enclosed you will find a `Request for Certificate of Coverage Facility Currently Covered by an Expirine
NPDES General Permit.' The application form must be completed and returned by January 2, 2007. Please note -you must include
two (2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 820098
Coharie Farms
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwaterquali .org Location: 2728 Capital Boulevard
An Equal OpportunitylAftinnaWe Action Employer— 50% Recydedl10% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone:
Raleigh, NC 27604 Fax 1:
Fax 2:
Customer Service:
o-
No Carolina
. (919) _ QtuTally
[phone]
[phone]
[phone]

1NATlc9 Michael F. Easley, Govemor
William G. Ross Jr., secretary
rNorth Carolina Department of Environment and Natural Resources
Q Alan W. Klimek, P.E. Director
Division of Water Quality
August 23, 2005
CERTIFIED MA1L
RETURN RECEIPT REQUESTED
RECEIPT # 7002 2410 0003 0272 8637
Mr. Freddie Butler
F&B Farms
2162 Boykin Bridge Rd
Clinton, NC 28328
RE: Sludge Survey Testing Dates
Facility # 82-98
Sampson County
Dear Freddie Butler:
RECEIVED-
AUG 2 4 2Z,-, i
OENR - FAYMPILLE REGIONAL OFRCE
The Division of Water Quality (DWQ) received sludge survey information on July 27,
2005. With your results you requested an extension of the sludge survey requirement for the
lagoons at F&B Farms until 2007. Due to the amount of treatment volume available, DWQ
agrees that a sludge survey is not needed until 2007. The results of the 2007 sludge surveys are
to be submitted with the Annual Certification Form that will be due on March 1, 2008.
Thank you for your attention to this matter. If you have any questions, please call me at
[phone].
Sincerely,
�ze
Keith Larick
Animal Feeding Operations Unit
cc: File# 82-98
Fayetteville Regional Office
N5a�" tCarolina
.. )Vaiurdly
North Carolina Division of Water Quality 1617 Mail Service Centcr Raleigh, NC 27699-1617 Phone [phone] Customer Service
Intemet: h2o.enr.state.ne.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal OpportunitylAffimtaWe Action Employer— 50% Recydedl10% Post Consumer Paper

'ANIMAL FA.CILITY_ANNUAL:CERTIFICATION FORM_
Certificate of Caverage or Permit Number N�'-A a FROgF County df}• -�So,J year 200,S
Facility Name (as shown on Certificate of Coverage or Permit)
Operator in Charge for this Facility Certification
Land plication of animal waste_as. allo..wed b-y-he_above permit._occurred-during thepast-calendar_year
waYES NO. If NO, skip Part I and Part II tt zlie certification. Also, if animal waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Information:
I. Total number of application Fields Rllor Pulls ❑ (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAVJMP): Total Useable Acres approved in the CAV72vT
d- 3#
2. Total number of Fields R` r Pulls ❑ (please check the appropriate box) on which land application
'7Z/.
occurred during the year: Total Acres on which waste was applied /� T
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
4. Total pounds of Plant Available Nitrogen (PAN) allovfed. to ra l?nd applied annually ­by the CAWNT and
the permit: 9f cwr_ a
5. Estimated amount of total manure, litter and process wastewater -sold or given -to other persons -and-taken
off site during the year tons ❑ or gallons ❑ (please check the appropriate box)
5. Annual average number of animals by type at this facility during the previous year:
3195 FEEDER_ To Fvi.50
7. Largest and smallest number of animals by type at.this facility at any one time during the previous year:
Largest 9eZp
Smallest '76-Y
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facilityis the annual average numbers)
8. Facility's Integrator if applicable: [f •4•e-f c FADS
Part H: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLLANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO_BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1- Only aniinal waste generated at this facility was applied to the
the past calendar year.
AFACF 3-14-03 1
Yes ❑ No
FEB 17 20

The facility was operated in such a way -that there was no direct runoff of waste from
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year -
I There was no discharge of waste to surface water from this facility during the past
calendar year.
4- There was no freeboard violation in any lagoons or storage ponds at this facility during
- - --. -the .-Past.calendar year.
5. There was no PAN application to any fields or crops 'ai this facility: greater than .the
-' levels specified in this facility's CAWNIP during the past calendar„year.
6. All land application equipment was calibrated at least once during the past calendar year.
-7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon,
was desir. `` , �Rn� ' -n;-� -~ - f-e� �- + ro'_ �.�lc to less than the volume
for which the lagoon was designed.
S- A copy of the Annual Sludge Survey Form for this facility is attached to this Certification-
9. Annual soils analysis were performed on each field receiving animal waste during the
past calendar year.
1 D. Soil pH was maintained as specified in the permit during the past calendar Year?
11. All required monitoring and reporting -was performed in accordance with the facility's
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with dur? lg
the -past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality:
13. Crops as specified in the CAWMP were maintained during the past calendar year on all
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were
maintained during each application of animal waste during the past calendar year.
L_ Yes l No
�l Yes ❑ ANo
Vyes ❑ No _:..
"s .❑ No
e'Yes
❑ No
Yes
❑ No'
R/Yes
❑ No
L�'Yes
❑ No
Lam' Y es
❑ No
2-yes
❑ No
F-yes
❑ No
Er Yes ❑ No
RYes []No
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system-, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
HAS F
ittee Name ar
or print
a-9-r%
Date
a-9-a"
Date
(if different from Permittee)
AFACF 3-14-03 2

F9
OHO -
CO
>_
❑ `C
Michael F. Easley, Governor
William G. Ross Jr., Secretary -
North Carolina Department of Environment and Natural Resources -
Alan W. Klimek, P.E. Director
Division of Water Quality
August 23, 2005
r
CERTIFIED NAIL
RETURN RECEIPT REQUESTED
RECEIPT # 7002 2410 0003 0272 8637
Mr. Freddie Butler
F&B Farms
2162 Boykin Bridge Rd
Clinton, NC 28328
RE: Sludge Survey Testing Dates
Facility # 82-98
Sampson County
Dear Freddie Butler:
The Division of Water Quality (DWQ) received sludge survey information on July 27,
2005. With your results you requested an extension of the sludge survey requirement for the
lagoons at F&B Farms until 2007. Due to the amount of treatment volume available, DWQ
agrees that a sludge survey is not needed until 2007. The results of the 2007 sludge surveys are
to be submitted with the Annual Certification Form that will be due on March 1, 2008.
Thank you for your attention to this matter. If you have any questions, please call me at
[phone].
Sincerely,
Keith Larick
Animal Feeding Operations Unit
CC.' File# 82-98
Fayetteville Regional Office
Caro ina tura�lr�
North Carolina Division of Water Quality 1617 Wail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.nems 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Rerycledl10°% Post Consumer Paper

R
3
ANIMAL FACILITY ANNUAL CERTIFICATION FORM E
Certificate of Coverage or Permit Number County 154WL&PsOJ Year 2001 10
Facility Name (as shown on Certificate of Coverage or Permit) F-t•a I AA/k S
Operator in Charge for this Facility A+AcxD D FAgy 2r cx Certification /7S
Land application of animal waste as allowed by the above_ permit occurred during the past calendar year
✓ YES NO. If NO, skip Part I and Part II and proceed io the certification. Also, if animal waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : FacHilE Information:
1. Total number of application Fields Q or Pulls 0 (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): 3 Total Useable Acres approved in the CAWMP
a�. 34
2. Total number of Fields 0 or Pulls ❑ (please check the appropriate box) on which land application
occurred during the year: i Total Acres on which waste was applied a24. 34
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAV;Ne and
the permit�1
5. Estimated amount of total manure, litter and process wastewater -sold or -given -to other persons and taken
off site during the year A10A)Lr' tons ❑ or gallons ❑ (please check the appropriate box)
6. Annual averager number of animals by type at this facility during the previous year:
3411 FEEDE2 To
7. Largest and smallest number of animals by type at this facility at any one time .during the previous year:
Largest _ Ji 7�
Smallest / 5r/a
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Facility's Integrator if applicable: �otrR+2�E!}5
Part H: Faeflity Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during Ri"Yes LI No
the past calendar year.
rGOVED
AFACF 3-14-03 1 1 FEB 15 2005
ON"TT*i1If LLC REGIONAL O1RGE

2. The facility was operated in such a way that there was no direct runoff of waste from L'Y es L No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3. There was no discharge of waste to surface water from this facility during the pastes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during L7 Yes [IN o
.the past calendar. -year.
a. There was no PAN application to any fields or crops at this facility greater than the L Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6. All land application equipment was calibrated at least once during the past calendar year. Yes ❑ No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon P' Yes ❑ No
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed.
8. A copy of the Annual Sludge Survey Form for this facility is attached to this Certification. E Yes ❑ No
9. Annual soils analysis were performed on each field receiving animal waste during the Q"Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? Yes ❑ No
11. All required monitoring and reporting -was performed in accordance with the facility's R-'�es ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during Yes ❑ No
the -past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality. -
13. Crops as specified in the CAWMP were maintained during the past calendar year on all ®lYes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were 9"Ves ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
ez"a"Ut IF
Permittee Name
Permittee
M"NO.2,102
(if different from Permittee)
co - cc.a&AF�
AFACF 3-14-03 2
a- $-oS
Date
�,g- -G�
Date

Appendix 3. Lauoon Sludge Survey Form _ G
A. Farm Permit or DWQ identification Number t 16
B. Lagoon Identification r OL-
C. Person(s) taking Measurements _ C t,�s _ .e6FV-1.1&z
D. Date of Measurements Lt --0
E. Methods/Devices Used for Measurmnent of:
a. Distance from the lagoon liquid surface to the top of the sludge layer:
b. Distance from the lagoon liquid surface to the bottom (soil) lagoon
V c-
c. Thickness of the sludge layer. if makdng a. direct measurement with "core sampled':
F. Lagoon Surface Area (using dimensions at inside top of bank): A fl (acres)
(Draw sketch of lagoon on a separate sheet and list dimensions, and calculate surface area )
G. Estimate number of sampling points: - -
a_ - Less than I.33 acre: Use 8 points
b. If more than 1.33 acre, f;�- acres x 6 with maximum of 24.
(Using sketch and dimensions, develop a uniform "grid" that has ntunber of intersection points that match
most closely with the estimated number of sampling points needed. Number the grid intersection points on
the lagoon grid to correspond with the data to be recorded for points of measurement)
H.
Conduct sludge survey and record data on "Sludge Survey Data Sheet".
I.
At time of sludge survey, also measure the distance from the Maximum Liquid Level
,
to the Present Liquid Level (measure at the lagoon gage pole):
],
Determine distance from Maximum Liquid Level to Minimum Liquid Level:
11.0
(Determine from Plan or other lagoon records)
K
Calculate distance from present liquid surface level to Minimum Liquid
level: Item J - item I, assuming present liquid level is below Max. Liq. Level:
i .Z
L.
Record from sludge survey data sheet the distance from the present liquid surface level
to the lagoon bottom for
A i
(average all the measurement points):
M.
Record from sludge survey data sheet the distance from the present liquid surface level
` S
►a
to the top of the sludge layer (average for all the measurement points):
_
N.
Record from sludge survey data sheet the average -thickness of the sludge layer.
0.
.-Calculate the thickness of the existing Liquid.Treatment Zone (Item.M - Item K-):
3
(Note: If ltcm 0 is less than 4 ft., a sludge removal and utilization plan may be required by
N. C. DWQ, See your specific permit or contact DWQ for more information.)
P_
Proceed to Sludge Volume Worl:sheet if desire to calculate sludge volume for rectangular shaped
lagoon with uniformm side slope.
7
/
Completed by:) C.��, S l,- 64,4 , t `7- z 9,6./ Date:
ey—e y
Print Name Signature
13

Appendix 4
Sludge SurveX Data Sheet
Lagoon ID
:F & B Farms
82-98
Completed by
Curtis G Barwick
Date 418/2004
A
B
c
C-B
Grid Pt Dist. To top of sludge
Dist to lagoon
bottom
Thickness of sludge layer
feet(tenth)
feet(tenth)
feet(tenth)
1
6.9
10.6
3.7
2
6.0
11.6
5.6
3
7.3
12.1
4.8
4
7.1
11.2
4.1
5
7.0
10.4
3.4
-g -
- -- -6.2
_ _T-
11.7-
5:5--
7
6.2
12.2
6.0
8
3.5
11.5
8.0
9
6.9
13.5
6.6
10
7.0
13.1
6.1
11
7.1
12.9
5.8
12
7.0
11.0
4.0
13
0.0
0.0
0.0
14
0.0
0.0
0.0
15
0.0
16
0.0
17
0.0
18
0.0
19
0.0
20
0.0
21
0.0
22
0.0
23
0.0
24
0.0
AVERAGE
6.5
11.8
5.3

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Freddie Butler
F&B Farms
2162 Boykin Bridge Rd.
Clinton NC 28238
Dear Freddie Butler:
A �- T-T
01,
NCDENR
ENVIRONMma `f ES
September 9, 1998
S f P 1 5 1998
FAYETi Elll!-1_E
REG. CF- ICE
Subject: Certificate of Coverage No. AWS820098
F&B Farms
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on July 2, 1998, we are forwarding this Certificate
of Coverage (COC) issued to Harold Frederick & Freddie Butler, authorizing the operation of the
subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the F&B Farms, located in Sampson County, with
an animal capacity of no greater than 3720 Feeder to Finish and the application to land as specified in
the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
P.O. Box 29535, Raleigh, North Carolina 276264)535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled) 10% post -consumer paper

Certificate of Coverage AWS820098
F&B Farms
Page 2
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone], if you need additional information concerning this
COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerel ,
9 A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File

State of North Carolina
22dPOP60
Department of Environment and Natural Resources
O
Division of Water Quality
Non -Discharge Permit Application Form
• ('PHIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Operations
. The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: F&B Farms
1.2 Print Land Owner's name: Harold Frederick & Freddie Butler
1.3 Mailing address: 2162 Boykin Bridge Rd. _
City, State: Clinton NC Zip: 20236
Telephone Number (include area code): 910-592-5301 or 533-2364
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Hwy. 403 East. go 3 miles turn right onto SR 1904,
Go I mile & turn at 2nd paved road to right SR 1917, farm is 1/4 mile on right.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Prestage Farms
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _82(county number); 98 (facility number).
2.2 Operation Description_: Swine operation
Femme er to Finish
3720- Certified Design Capacity
Is the above information correct? -yes; F—Ino. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num ear for which the waste management structures were designed.
Type of Swine No. of Animals
Wean to Feeder
Feeder to Finish
Farrow to Wean (# sow)
Farrow to Feeder (4 sow)
Farrow to Finish (9 sow)
Other Type of Livestock on the farm:
FORM: AWO-G-E 5/28/98
Type of Poultry No. of Animals
Layer
Non -Layer
Turkey
Page 1 of 4 82 - 98
Type of Cattle No. of Animals
Dairy
Beef
No. of Animals:

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 24.6 ; Required Acreage (as listed in the AWMP): 24.6
2.4 Number q6goons torage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES o NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRC dards, etc.) (Swine Only)
CYE I or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 7— g—/ 7qf
What was the date that this facility's land application areas were sited? 7—S -_j j49 _ ^
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials_
3.1 One completed and signed original_ and one copy of the application for General Permit - Animal
Waste Operations; F151.
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CA WMP, it must be completed prior to submittal of a general permit �Q
application for animal waste operations. P>
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management.practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 82 - 98

Facility Number: 82 - 98
Facility Name: F&B Farms
4. APPLICANT'S CERTIFICATION:
1, t'DD�E dJc�T� (Land Owner's name listed in question 1.2), attest that
this application for F t 43 S (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be repajned to me as incomplete.
W om
,� , .-
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
M
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 82 - 98

• DIVISION OF WATER QUALITY REGIONAL OFFICES (1/98)
Asheville Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 28801
[phone]
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
C: ^rokce
Dole
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bertie
Lenoir
Camden
Martin
Chowan
Pamlico
crmven .
pasquma ik
Currituck
Perquimans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
9I9 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27611
(919) 57 L-4700
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
- Vance
Halifax
Wake
Johnston
Warren
Lee
Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Brunswick New Hanover
Bladen
Richmond
Cabarrus
Mecklenburg
Carteret Onslow
Cumberland
Robeson
Catawba
Rowan
Columbus Pender
Harnett
Sampson
Cleveland
Staniy
Duplin
Hoke
Scotland
Gaston
Union
Montgomery
Iredell
Winston-Salem Regional WQ Supervisor
585 Waaghtown St --et
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alamance
Rockingham
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FORM: AWO-G-E 5/28/98 Page 4 of 4

171.E
Lill Mal reChap
lilt d lru l791 7 40 1I Q
lIl] Olddaan,ll 1Li� IA fI71 I M ''+ l»i r� h JWI
AA NowHOd+.J
Lai N I I� A O kill Ora. �
•. Rl! IIiL LlJI! 'ter 4 r•. 11L 1�.. t
' kill JI.IL .� L h !t llll ' i �,�•}}1 �J , Q a , yam,
J Merpra_n Inc
kill 1Ill Gaawsadl� 1•Illl q �' �A 1a1 c4 QV
71 ' C! illi �..i W 1
im
an y f
MI,� v . YAL
�[Il Iw LI31 L J I V
r I !i IJU
Im lz:t ' 7 ° llel 1t:1 ,� 1J91 i l 4"
v � 'Ill lilt ..r MtCJa, "� "L! ,LLra ''' lu7 ^
MIA
mOft L ` Oak 1 q
lr>; !• RJl
uw
r a4 171I 'v im LIU Mahm Ale I I +° kill
Ibbbkn a 11w .'. f 11A1 ti
•
Lw Jta
1RlI Ij t Illi • f * t��ew • v 1I1! i Jlnt 1711 Lill
1.7 !lI! !1!I anIJ 111t EI j ,� .r �:•, •*{� It a +9 Am . LU > > '1 to
4 1 i! 1111 I r �' .ltu f 1>!71 {a r ll4
•. ati llll .a . Illl - 74
7
t t+ Iv{ 1711 ,{ 1
IF �
n{ '�, 7!1 11!! i: I 1 •r 79 �'IL� y lLi7. �
7 .7,r •r ;jl 'r 11n � I �{ I ` LAr� .+ led Mo
~�Y Llil Illl N� 11K 7 / a.a
/•� Liu Alta 79 no Sill
IM
7I.11 NNI {Q
L177 � ° iTsi SUL
1172. '• I �1
IL9i Lill , 17 •, a '
Swamp
llll r,
7 ° .e , S4? q 11f! llll y
]ln LLS
r kill „ Irh ► ,. GLdNiO Ill
ra 13 ? N . ►,1J7 11,,7'•' :ii aft"•� Ca,M►� Lbam
bull wti�Mm� Y ✓ .r fUi 11L1 th 74• '�: Gaara+dr 1111
.1 J flil 1>
Crallraoalr �•� LULLM
L;I h �° - Rrd 1111 kill _
.r !rIJ! ✓ •�• ? l/il ltlt'a �• Tea} 1711
Jill ; Lll LLl fllhi f,1
{►r 4, 11M LU1 ull
r71 kill 1,1 'SLR i � '7 o�y
HI
,3 V V kill
I, K37 A crorr"wd,
� � UlfK
7al.r 1>• .. �
1JI71
Lit Lll �
r
Lilly
�Ilil `?
v
1
�� , 117(
toll
LM
Litz
Y JIAr
wt a' a., w lILL
Y Y
911 ~ "MAIN
'l�
{ � �� .�f
} 7u
too
UUlill
1I1I`
All
I1N 1771 y
�0,
LLi
1/11
;�
.7
f.n
fa
1111 liLi
>
Calmed
T
r,V r •r
rt
\
i U
Lul
1� "
ML.
> 7barllnl 7,
Ills
un
!!• ll}{,
•71
1t77
�lllr ) ' Luc
,7 �. 4ii1�
13rankfn
a
llll
1 ,r
14 J17a
, r
Is
"tocrsn.
'.0 1�I •l' w Illr
Jl7f
DU
dl�l

WASTE UTILIZATION PLAN
----------------------
Owners name--:HAROLD FREDERICK County:SAMPSON
Mail Address—:CLINTON, NC
Type of production unit---- :FINISHING
Type of waste facility ----- :Anaerobic Lagoon
Your animal waste management facility has been designed for a
given storage capacity. When the waste reaches the designed
level, it must•be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
Amount of Waste Produced Per Year:
----------------------------------
3720 animals x 1.9 tons waste/animal/yr= 7068 tons
total waste

FAmount of Plant Available Nitrogen Produced Per Year: Page 2
-----------------------------------------------------
3720 animals x 2.30 lbs. N/animal/year = 8556 lbs./yr
Available N
• Applying
the
above
amount of
waste
is a big
,fob.
You should
plan time
and
have
appropriate
equipment
to
apply
the waste in
a timely
manner.
Your
facility
is
designed
for
180
days of
' storage.
Therefore,
it will
need to
be pumped
every
6
months.
Tract. Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type
Code
Per Ac.
Used
Apply
4450
6
GoA
2
100 Bu.
150
2.9
430.5
MAR-JULY
4450
5
WaG
6
7 Tons
400
9.1
3620
MAR-AUG
4450
4
NoA
2
100 Bu.
150
0.8
120
MAR-JULY
4450
3
NoA
2
100 Bu.
150
13.5
2019
MAR-JULY
4450
2
GoA
2
100 Bu.
150
21.0
3154.5
MAR-JULY
4450
1
GoA
2
100 Bu.
150
2.0
303
MAR-JULY
Total
49.2
9647
Available
Nitrogen
8556
Surplus
Or Deficit
-1091
Crop codes: 1=Cereal grain; 2=Corn; 3=Fescue; 4=Range Gr. Bermuda
5=Control Grazed Bermuda; 6=Hayland Bermuda
Narrative of Operation:
-----------------------
Call the Soil and Water Conservation District Office after you
receive waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
waste.
Prepared by: ..!% i%L1??LL�_-- _--__—_—
Name Title Date
Concurred in by: _ lr..l.�3�
— — --— Date
---------- --
� P -- --- er te
(Copy to producer and copy to case file)

Animal Waste Management Plan Certification T ,- r 1 V E 0
"CIICI-ill AI11UrlIl'dllVIl: V`r''
Name of Farm:. _V- 4-
Owner(s) Name:, �1o�9\�Fce ectic ter �cc '.e v. _Phone No: u 53Q1
Mailing Address: M► Orc\n Ir%% 2-` i�. \:n�o(\, 3Zb -- ----
Farm Location: County Farm is located in:
Latitude and Longitude:35� 0 t � ° 5F �gge- �� / � �� `� Integrator: �'e..S�C
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): w �'�-S e. 5 Si. K cc% OACA
c oara the. KSN�-3 1-SK V\X' ► c
C.—
Ooeration Description:
Type of Swine No. of Animals
O Wean to Feeder
STeeder to Finish 312►C)
0 Farrow to Wean
0 Farrow to Feeder
O Farrow to Finish
❑ Gilts
Boars
Type of Poultry No. of Animals
❑ Layer
❑ Pullets
Other Type of livestock.
Type of Cattle
a Dairy
❑ Beef
No. of Animals
Number of Animals:
Acreage Available for Application: al� , (o Required Acreage: aA, (D
Number of Lagoons / Storage Ponds : Total Capacity: to% Cubic Feet (ft3)
Are subsurface drains present on the farm: YES or �J (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation
and maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the
application of animal waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be
minimized using technical standards developed by the Natural Resources Conservation Service. The approved plan will be
filed at the farm and at the office of the local Soil and Water Conservation District. I (we) know that any modification
must be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to
implementation. A change in land ownership requires written notification to DEM or a new certification (if the approved
plan is changed) within 60 days of a ' transfer.
Name of Land O ner
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
AWC -- August 1, 1997

Technical Specialist Certification 04
L As a technical specialist designated by the North Carolina Soil and Water Conservation Comwision pi rsnani to 15A
NCAC 6F .0005,. I certifythat the animal waste management system for the, farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Environmental rNlanagement
(DEM) as specified in 15A NCAC 2H.0217 and the USDA -Natural Resources Conservation Ssetrvice '("RCS) and/or the
North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and I5A NCAC 6F .0001-
.0005. The following elements are included in the plan as applicable. While each category designates a technical specialist
who may sign each certification (SD, Si, WUP, RC,1), the technical specialist should only certify parts for which they are
technically competent.
IL Certification of Design
A) Collection, Storage, Treatment Svstem
Check the appropriate box
Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
❑ New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print):_
Affiliation_N�Q-' S _ _ !, Date Work Completed:
Address (Agent k, a. Phone No.: to 59R963
Signature: Date: f A
B) Land AQ _Iication Site (WUP) '
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): fof .CO-T a .-ds
Affiliation JVC Date Work Completed, 2-2:S2j y7
Address (Agnycy): &0 BoX(_ 90 / xin/M „i AIC - --) Ma --quo / Phone No.: 9/ 9 S2-3 2 9;9
S
C) Runoff Controls from Exterior Lots
Check the appropriate box
9-'* Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facilily with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by MRCS.
Name of Technical Specialist (Please Print): C . )
Affiliation- V)AcS Date Work Completed:
Address (Agency): v1 ,C'1. a13a Phone No.: r
Signature: Date:_ 114 2
AWC -- August 1, 1997 2

D). Application and Handling Equipment
Check the appropriate box
Existinx or exnal dine facility with existing waste application eauinmenl (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
w i 'n w n equiMent for spray irrigation. (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
.contained as part of the plan).
w without
sorav irriQatian. (WUP or 1)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan). _
Name of Technical Specialist (Please
�.. i1rDnc-
Address (Agency):
Signature: r
Date Work Completed:
oe, Q832a Phone No.: 4) sm — 196
Date: Z,o �—
E) Odor Control, Insect Control. Mortality Management and Emereencv Action Plan (SD
SI, WUP, RC or I?
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect
Control Checklist, a Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and
insects have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Management Practices to Control Insects have been selected and included in the waste management plan. Both the
Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): C W� ionS�)Ca-
Address (Agency,
Work Completed:
Phone No.: 0) S — %3
F) Written Notice of New or Expanding Swine Farm
The following signature block Is only to be used for new or expanding swine farms that begin construction after June
21, 1996. 1f the facility was built before June 21, 1996, when was It constructed or last
expanded
I (we) certify that I (we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice was
in compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attached.
Name of Land Owner:
Signature:
Date:
Name of Manager (if different from owner):
Signature: Date:
AWC -- August 1, 1997 3

III. Certification of Installation E C E! V E D
A) Collection Storage Treatment Installation
r1�?r;! f iY 4'�U � Div
New, expanded or retrofitted facility (Sn l 198
Animal waste storage and treatment structures, such as but not limited to lagoons anud`pon&, �avee been installed
in accordance with the approved plan to meet or exceed the minimum standards and, specifications.
Icon-lfischargo Permitting
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation - Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
B) Land Application Site (VVUP)
Check the appropriate box
El The cropping system is in place on all land as specified in the animal waste management plan.
(B' Conditional Approval: all required Iand as specified in the plan is cleared for planting; the cropping system
as specified in the waste utilization plan has not been established and the owner has committed to establish the
vegetation as specified in the plan by 5 -30 (month/day/year); the proposed cover crop is
appropriate for compliance with the wasteutilization plan.
© Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days
of this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist (Please Print): drencer
Affiliation Date Work Completed:
Address (Agency): ,� WU d, UAL6j2o kX. WO Phone No.: :J963
Signature
4
This following signature block is only to be used when the box for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan,
and if appropriate to establish the interim crop for erosion control, and will submit to DEM a verification of completion
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I (we)
realize that failure to submit this verification is a violation of the waste management plan and will subject me (us) to an
enforcement action from DEM.
Name of Land
Date: /t-13-17
Name of Manager (if different from owner):
Signature:_ _ _ Date:
AWC -- August 1, 1997 4

C) Runoff' Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
Far facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
D) Auplication and Handling Equipment Imtallation (WUP or I)
Check the appropriate block
I�r Animal waste application and handling equipment specified in the plan is on site and ready for use;
calibration and adjustment materials have been provided to the owners and are contained as part of the plan_
❑ Animal waste application and handling equipment specified in the plan has not been installed but the owner
has proposed leasing or third party application and has provided a signed contract: equipment specified in
the contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as part of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the plan has
been purchased and will be on site and installed by (month/day/year); there is adequate
storage to hold the waste until the equipment is installed and until the waste can be land applied in
accordance with the cropping system contained in the plan; and calibration and adjustment guidance have
been provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please
Address (Agency): -N
Work Completed:
3. -Phone No.: 10) 5 .3
Date: �l4 ci 2
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to DEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and will subject me
(us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: _ _ Date:
E) Odor Control, Insect Control and Mortalitv Management (SD, SI, WUP. RC or
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print):
Work Completed:
Address (Agency):
AWC -- August 1, 1997

Please return the completed form to the Division of Water Quality at the following address:
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Non -Discharge Branch, Compliance Unit
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy
in your flies with your Animal Waste Management Plan.
AWC -- August 1, 1997 6

�' -v (1 �� � i :1 �� <�,' ��''� Y. � � . �� •�._ (�� ,..� , �r �� SIP � •
1• �1 t� ' M,, � r' ;� s`s � 'l, '�� .!YID' �\l �- } I YI
! r oEll
° �' , ; , _� �� � •• � , f �ti' �I - =1 pry
YJ
PI
NI l
� � �I � + '%% 1 •I gyp, i� i•ry II�Ltl � `• a• 9 �• .I; � }
�'�''+ .1 �� •� :.�, ,� � � .� •:, ' • � ^'

Nutrient Management Plan
Producer: F&B Farms -Freddie Butler and Harold Frederick
Address: 763 Seaver Road, Clinton NC 28328
Telephone #: [phone]
Facility #. 82-98
Farm Location: Hwy 403 East-0.5 miles SE of the intersection of SR 1904 and SR 1918 on SR 1918
Type Operation: Feeder to Finish
Table 1: Waste Calculations*
Type production
Animal units(^A, 1� Ibs N/year
Gals waste/ye
$ludae N! r
wean to feeder
0 0.00
0.00
0.00
feeder to finish
3720 8,556.00
3,448,440.00
1,339.20
farrow to wean
0 0.00
0.00
0.00
farrow to feeder
0 0.00
0.00
0.00
farrow to finish
0 0.00
0,00
0.00
Total N per year 8,556.00
Total gallons waste/year
3,448,440.00
Acre inches/year
127.00
Total N from sludge producedlyear
1,339.20
`Calculations based on animal units with waste applied by irrigation
Several factors are important in implementing this plan to maximize the fertilizer value of the waste and to
ensure that the waste is applied in an environmentally safe manner. Factors included are:
1: Always apply wastes based on crop needs and the nutrient content of the waste.
2: Do not over apply nitrogen.
3: Do not apply wastes on saturated soils, when it is raining, or when the ground is frozen, either could
cause surface runoff.
4: Consider wind conditions to avoid drift and down wind odor problems.
5: Wastes can only be applied to actively growing crops or not more than 30 days prior to planting or to
forages breaking dormancy.
6: This plan uses nitrogen as the limiting nutrient_
7: This plan is based on wastes being applied using irrigation. If the application method is changed,
this plan will need to be revised because the nutrient content varies depending upon the application
method.
8: Waste samples are required to be taken and analyzed at least 60 days within the application date.
9: Soil samples are required to be taken and analyzed annually. These analyses are used to balance all
nutrients for optimum growth and to monitor metal levels in the soil, especially copper and zinc.
Page 1

TABLE 2: Application Agronomics
Tra-t_
Field_
oil Tyke, roc
Lbs N/Acre
Acres
f_bs N/Fiel
Month To A��
7450
2
NoA
SH
305.00
15.00
4575.00
Mar -Oct
-2
NoA
OSH
50.00
15.00
750.00
Sept -March
7450
5
NoA
OH
305.00
5.60
1708.00
Mar -Oct
-•5
NoA
OSH
50.00
5.60
280.00
Sept -May
7450
7
NoA
BH
305.00
4.00
1220.00
Mar -Oct
-r7
NoA
OSH
50.00
4.00
200.00
Sept -May
Total Acres
24.60
Total N Used
8733.00
BH=Bermuda-hay; OSH=Small grain-Overseeded-Hay
Table 3: Nitrogen Balance
Total N Used 8733.00
Total N Produced 8556.00
Surplus or Deficit-177.00
The nitrogen balance shown in table 3 should be equal to of less than 0 to fully utilize the nutrients
produced by the swine from this farm. To produce crops at the RYE'S shown may require the use
of commercial fertilizer to balance fertilization rates in crop rotations. This farm is producing
8556 Ibs of nitrogen per year in the waste water and an additional 1339.2
lbs of nitrogen accumulates annually as sludge. To land apply the liquid portion in an acceptable manner
requires the irrigation system to pump and spread 3448440 total gallons annually.
Table 4: Irrigation Application Rates
Application Rate
Application Rate
Field oil T e
Crop
IncheslHr
Inrt�slAppfication
2 NoA
Bermuda
0.5
1.3
-2 NoA
Sm Grain
0.4
1.2
5 NoA
Bermuda
0.5
1.3
-5 NoA
Sm Grain
0.4
1.2
7 NoA
Bermuda
0.5
1.3
_7 NoA
Sm Grain
0.4
1.2
The irrigation application rate should not exceed the infiltration rate of the soil at the time of irrigation such
Page 2

that runoff or ponding occurs. The application amount should not exceed the available water holding
capacity of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the
nitrogen needs of the crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on
the average of once every fi months. In no instance should the volume of waste being stored in your
structure be higher than the upper pumping marker except in the event of a 25 year, 24 hour storm.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrigate the acres shown in
Table 2. Failure to apply the recommended rates and amounts of nitrogen shown in the tables make this
plan invalid..
Nafrative of Operation:
The application fields are marked in yellow on the attached maps. Bermudegrass will be grown in all fields
and cut for hay. Rye will be overseeded in the Fall and cut for hay also. There is a ditch on one side of field
2, marked in green on the map, and care should be taken when pumping to insure swine waste does not
enter this ditch.
Page 3

WASTE UTILIZATION PLAN AGREEMENT
Name o,ffFF M: F&B Farms
I (we) understand and will follow and implement the specifications, operation and maintenance
procedures established in the approved animal waste utilization plan for the farm named above. I
(we) know any expansion to the existing design capacity of the waste treatment and storage
system or construction of new facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality before the new animals are stocked I (we) also
understand there must be no discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24 hour storm. The approved plan will be
filed on -site at the farm office and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facili Owner: Fr die Butler and Harold Frederick
q-ate 47
Signature: Date: _ c� - as —� 1
Name of Manager (if different from owner):
Signature:
Name of Person Preparing Plan:
Affiliation:
Phone No.
Address (Agency):
Date:
Robert D Edwards
NCDA
919-523-2949
P0Box 801
Kinston NC 28502-0901
Signature: 9 &" _ _ Date: _ _ a a
&06 �� N%A&ML--

�. ly",4!' •r'•i=:._�`'' - 177 Jmw
: t[�r. `�.i; t.a• �" o-.;!''� -;c` -
'���Zi. .� 'i:J'Iy ILA•' - - '
• >: •r ': �,��}• •.�. ±,:}•-jig'_ ..Jr3�:,•u. _-� - _
`<. tl':• -f ,�f.. .•. .' .yam+' ��1 � _�•..- c. F•.
L4 ,,',,, •! fl; 4-'.'", l.r ..r,:����:. e/ i�lf YY ,Y Yr_'- � .�.
�;��`'�yl� :: •.i �!.i':f- .!T'�g,=;•�.N. ��//��'/i/�-'s p%•' - '- y, �•i:, •,p �= '�•�i _ '�'i:" _ 7
).DIY'„'. � _ •C...� I � 3ff���'''''117Y''� \ j.:! -•'r �•.-` .�'. � r`� •�` . _ Z�_-�rhw
=. s: •.,���' ��►, , •rJ�,^-. r+� � •t?�: -' ':; ti;. _ •' ' -- -,� �i+� r--yew ws a�
. •�F- Wit: J• T !•� 'a. • , i,^�• ',r.�7 _ �' '• l
�:� � t .'� i � �. _'r•'�;. - �e ^li,;..[. :~ •�i _ ,- is 'C' - - S!hl
:. i.' 6• :)-•- ! .:IJ ifil •� e.. /J -%' %a •�•'r'i'��'' - J F:r•. •f� - _ /r' _/.?.
-!L•� .-{. ..Sjti+:.i� 'r i � .. .. +.- - ..fr ,[- _ ram.
_� .!j ''G S '�f�,y� �• .1.'... r'.',�.i ''+.lti: - ~-} '�l' - -•� �f,t1
� _- `. �' .�-. `-:.� .pit a. D, -�.'• r. -. '. _ ''' �,'' - _ -rt
_ h is /•/. � ': t'• ,,,.' ._ 4. !.".
«.I /.`. 1 b 'F•+�c�� '., �_ ��f'�.. }.•.� _ ���� y.'t. '. may:; `f•,.
f !O � w '' t. _ ems. .�. ••� �._r � -.. _ : �•. J
:.4 A •' 1a a

r'I �7 ' J • �'•'� +� I r r
`
t• r _ � � 'I'y
1N � ' i- fi -phi � -� 'I�' •
K. �`' �,'4� �� `�l• •'%r � *- 11 `ram
144.
I � '` I. ��, _ l •'ter � f O�A�• '.
V
J.F"P-���� .J a} V�.Y V,� �� �7: �/ �, w`�(� "�4.y �'�Ii "r..r•.''�•ul
�. =4 lti •�l r eF,' :�J e J I �r•� ftrt. , f I i `� ,. tl la J%'`4r.. ..
.•�,rrY•'.FF �_'t
i sa.� ,� ® , fit• � . I �:,.,

„y,Nr .�,
= - .\ ��
� _. \.�-
_
nl 1
�I
ryf
y
ryf r• rvl�
jq, ,' � J �
� �� r aft•
P /
� , •. I -
r•/�
°- - y
O
�,
`�•
� of
- N
Nf, J �
•
NI
• �I
.� � \ ` ” F•'i �!
of � I
_
• y r
�
. A� / r pf
�
+
�
RCS
!`t ��
�f I
�
} —
� �"I
� 4'. '
p� i
�
— �� I •
`'
}I
r1
,' .yl'y
-"-�
I �I
'F
^I •
, Al-
- .
a
IR
1
_� -'
�
+_
�
ii
+1r
•
a �f # :�• r
\
^I �
�
•V~
--f ice_: —)
�
•�
•y
pu
1,'•�
Q
P!' � � '.l` �� O
^ '�'
JI k
y �I,.y;
�I
�}
�` � �I
,`•1
�
�
•�f 'f � •�f . � i� -
mJ
-lJ,
�
-
al

0 V V "'J f, 'N:
RAO 4
Grower Frederick, Haro
881 hearer Rd.
Clinton, NC 28328
Sod Test Report
Re rt No:: B.
Coptai to: County Exlension Areclor
Agronomist Comments:
A 3,12,
st
34MPSOM DUE (WOP
Yr TIA
crop or rear
LOW
N
12U5
AU
Mg
GO
Zn
B Mn
see more
21 Cotton
F
1st Crop: Cotton
I
0
50-70
0
0-20
0
0
0
1.0 0
3
2nd Crop: Corn, Grain
0
120460
0
0-20
0
0
0
0
3
Test Results
Sod Class Mf% WIV CEC BS% Ac pft P-1 K-1 CA Mg% Mn-1 Mn-Ai (1) Mn-Al (2) Zx-1 Zn-AI Cu-1 S-1 SS-1 NV9-N N&N Na
MIN 0.27 1.37 2.9 79.0 0.6 6.2 163 81 52.0 14.0 42 P 39 103 101 89 25 0.0
Samplo No. jW1 Crop
Ho Yr TIA
Crop or Year Lime N DO 5 A0 Mg Cu zn B Mn See Note
51 Berm Ilay/Pas,E
1st Crop: Berm Hay/Pas,M 0 180-220 0 80-100 0 0 0 0 12
2nd Crop:
Test Results
Soil Class Hhf% WIV CBC BS% Ac pH P-1 K-1 Ca% Mg% Mn-I Mn-Al (I)Mn-Al (2) Zn-j Zn-Al Ca-1 S-1 SS-1 NQvV NA-N Na
MIN 0.22 1.37 2.5 84.0 0.4 6.6 225 60 58.0 14.0 60 44 132 132 150 20 0.0
-J,
Samp to No. Last Crop
Mo Yr F/A
Crop or Year
Lime
N P205
ho Mg Cu zn B Mn See Note
71 Berm Hay/Pas,M
Isl Crop: Berm Hay/Pas,M
.5T
180-220 0
140-160 $ o o 0 12
2nd Crop:
Test Results
Sod Class Hhf% W/V CBC
BS%
Ac PH P-1 1C1 Ca% Mg%
Mx - I Mn-AI (1)Ma-Al (2) Zn -1
Zx -Al
Cu-1
S-1
SS-1 NQ8-1V N1b-N Na
MIN 0.13-- -1-39 1.7
65.0
0,6 5.9 143 46.0 9.0
32 29 142
142
t51
15
0.0
me
134
Sample No. Last Crop
He
Yr F/A
Crop or Year Lime
N A05 Ho
Mg Cu
Zn
B
Mn See Note
72 Bermllay/Pas,11
1st Crop: Berm Hay/Pas,M 0
180-220 0 10-30
0 0
0
0 12
2nd Crop:
Soil Class
1Df%
WIV
CBC
BS%
Ac
PH
P-1
K-1
Ca%
ft%
Mn-1 Mn-AI (1) Mn-A] (2)
zn-1
zn-Al
Cu-1
s-I
SSI N - NNa
Or-N NH- N
MIN
0.22
1.29
2.9
79.0
0.6
6.7
188
101
49.0
14.0
43 32
71
71
126
18
0.1

Agronomist
Grower: Frederick, Harold Copies to: County +sion Director
881 Beaver Rd.
Clinton, NC 28328
Soil Test Report
Farm:
SERVING N.C. CITIZENS FOR OVER 50 YEARS Sam son County its: SERVING
- 3, 12, #
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N ROs &0
Mg Cu
Zn
B
Mn
See Note
21 Cotton
1st Crop: Cotton
0
50-70 0 0-20
0 0
0
1.0
0
3
2nd Crop: Corn, Grain
0
120-160 0 0-20
0 0
0
0
3
Test Results
Soil Class HM% W/V CGC
BS%
Ac pH P-1 K 1
Ca%
Mg%
Mn-1 Mn-AI (1)Mn-AI (2) Zn4
Zn-AI
Cu-I
S-I
SS-1
NO-N AU-N
Na
MIN 0.27 1.37
.9
7.0
0.6 6.2 163 81
52.0
14.0
42 3 103
103
8
25
0.0
'Ff011 nformatloni '°
-�°'l dIti�tte
$R�cammendatio sIf
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N W5 go
Mg Cu
Zn
B
Mn
See Note
51 Berm Hay/Pas,E
1st Crop: Berm Hay/Pas,M
0
180-220 0 80-100
0 0
0
0
12
2nd Crop:
Test Results
Soil Class HM% W/V C8C
BS%
Ae pH P-1 K I
Ca%
Mg%
Mn-1 Mn-AI (1) Mn-AI (2) Tn-1
Zn-A1
Cu-I
S-1
SS I
NQ-N NIO-N
Ara
MIN 0.22 1.7
2.5
84.0
0.4 6.6 225 60
58.0
14.0
60 44 132
132
150
20
0.0
>} ormati n
,""..lied I:ime.
Reca"`"'min Ada#ions..
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N h05 AO
Mg Cu
Zn
B
Mn
See Note
71 Berm Hay/Pas,M
1st Crop: Berm Hay/Pas,M
.5T
180-220 0 140-160
$ 0
0
0
12
2nd Crop:
Test Results
,
Soil Class HM% W/V CBC
BS%
Ac pH P-1 K-I
Ca%
Mg%
Mn4 Mn-AI (1)Mn-AI (2) Zn-1
Zn-AI
Cu-1
S-1
SS I
NQ8-N NM&N
Na
MIN 0.13 1.3
1.7
65.0
0.6 5, 143 34
46.0
.0
32 2 142
142
151
15
0.0
;Fic n urmadon
liedLimeRecgmmendaHq�
.
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N PdO5 KO
Mg Cu
Zn
B
Mn
See Note
72 Berm Hay/Pas,E
1st Crop: Berm Hay/Pas,M
0
180-220 0 10-30
0 0
0
0
12
2nd Crop:
Test Results
Soil Class HM% W/V CFsC
BS%
Ac pH P-1 K-1
Ca%
Mg%
Mn-1 Mn-AI (1)Mn-AI (2) Zm1
Zn-AI
Cu-1
S-1
SS-1
N(b-N NIW-N
Na
MIN 0.22 1.29 2.9
79.0
0.6 6.7 188 101
49.0
14.0
43 32 71
71
126
18
0.1

.t=VC 276077 25. N 04NDAicDivisiodyRtr9#' r F-•.�:'�"`
Grower: F & B Farms Copies To: Count} ..ension Director
A:
763 Beaver Rd. USDA -MRCS -Sampson
Clinton, NC 28328
-�
dste nal sis effort Farm:
y
5/18/98
Sampson County
�>�,z..a, �x... -_-
ys <s.:•«. >`-.,.,.: :�--x-'=i�d a. a�rA.sa-. ."=t-.�.n-�«, «-'��:.. _ �'W� a ,^,� �'."•' ��^�-��;,y-e �. i�� ?"J �.r �3 �'i:$�:
Sample ID:
N
P K Ca Mg S Fe Mn Zn Cu B Mo Cl C
NO
Total 784 M
76.4 843 102 - 27.0 21.7 5.77 0.39 0.77 1.00 1.00
IN -N
M H M M M M M M M M
Waste Code:
NH4
ALS
NO3
Na Ni Cd A Al Se Li PH SS C'N DM% CCE% ALE K al
185 7.85
Description:
OR-N
Swine L oon Li .
Urea
H
Recommendations.
.. , . A x,
N66ii is Available for'FirstaCro " ` 16s/1eeg�--allons ' I
OthcrEleit�ents � lbs/IQ00 �iillons M1w
. .. 9 ;..
Gcation Metbod N NP205 ]i 20: • : . E.Mo
Irri io}n 33' lA. .'= 6.8 0.5 pC0:16:.: O.i3 003` T O;fl1 O,OI
C)
� I12-1
CO
T
w f!
Q+
cm
a
C) T'
al
!r
s
�

NCDA&G anemic Division 4300 Reedy Creek Raid Raleigh, NC 27607.6465
Il�,�
'�'=• ., nderstandin the aste nal sis
g y
19) 733.2655
a
�Eort
Waste products crust be disposed of in ways that protect soil and water resources. The keys to proper disposal include analyzing the waste product and planning application
rates based on crop requirements. The Waste Analysis Report provides information necessary to use these materials as a resource while protecting the environment.
Sample Info This section contains sample identifiers, specifically the sample identification number, waste code, and description. These data are
Key to Abbreviations
supplied by the grower on the information sheel submitted with each sample.
Al
Aluminum
Laboratory Results Wastes are analyzed for up to 21 elements. Some are essential for plant growth—C, major nutrients (N, P, K), secondary nutrients
ALE
Agricultural lime equivalent
(Ca, Mg, S), and micronutrienis (Fe, Mn, `Ln, Cu, B, Mo, Cl); others can permanently damage the soil or significantly impact production if allowed to
'$
Boron
increase to toxic levels (Na, Ni, Cd, Pb, Al, Se, Li). Results are reported in parts per million, and these amounts are ranked as ven, high 011), high (H),
C
Carbon
medium (M), low (L), or very low(F9.) in relation to all other waste of that type. If the sample is a compost or compost ingredient, values for pH, SS, and
Ca
Calcium
C:N are reported. DhI% is reported for solid samples. CCE% and ALE are reported for waste products that have neutralizing tialue.
CCE96
Cd
CaCO3 equivalence
Cadmium,, ...
Recommendations This section can have three parts: (1) Nutrients Available for First Crop based on application method; (2) Other Elements that
cl' yChlarine ' a
may impact application; and (3) agronomic comments indicating precautions that should be taken when using the waste.
DM%; : Percent drymatter
(1) Predictions of nutrients available for the first crop are based on estimates of mineralization rate and nutrient loss, depending on application method.
Fe
-iron,"
Estimates are reported in lbs/ton for solid wastes and Ibs/1000 gallons for liquid wastes. "T" indicates that an element is present in a "trace"
K .:
sPota'ssium
quantity (< 0,005 lb per measured unit).
V `
Potash x
Within the first month after waste application, 50-75% of the nutrient quantities listed will become available for the crop. Therefore, plan to apply
'.'Li
Lilhium .,
wastes near the lime that plants will require nutrients. The remaining nutrients gradually become available over the neat three months.
Mg
:Magnesium. -'
Nutrients not available for the first crop are mineralized to mailable forms overtime, usually years. Significant quantities of nutrients can accumulate
Mn
Manganese
in soils that do not leach readily with heavy rainfall. If waste is routinely applied, lake soil samples at least once every two years to monitor nutrient
N
N
NitrogenMolybdenum
Nitrogen
accumulation. Some cropping systems and metal levels may necessitate annual sampling.
Na
Sodium
ALE and CCE% are reported for wastes that may have neutralizing value. ALE indicates the amount of the waste product required to equal 1 ton of
NH4
Ammonium nitrogen
good quality agricultural lime (CCE%=90). If waste materials have significant neutralizing value, apply them only at rates necessary to optimize pH.
Ni
Nickel
For flexibility, the information sheet provides two choices for application method. Predictions of available nutrients are based on the type of waste
NU,
Nitrate nitrogen
and the method of application, if you decide to change the application method after the analysis is complete, contact your local regional agronomist
P
"Phosphorus
or the Agronomic Division at [phone] for a revised recommendation.
P205
Phosphate
(2) Quantities of other elements that are polentially harmful—Na, Ni, Cd, Pb, A1, Se, and Li —indicate the likelihood of touc buildup in the soil. Like
Pb
pH
Lead-
Measure of acidify oralkalinity
nutrients, they are reported in lbs/lon for solid wastes and Ibs/1000 gallons for liquid wastes.
S
Sulfur
(3) Sometimes the recommendations section includes agronomic comments, These provide general information on the waste product and alert the user
Se
Selenium
when heavy metals or other elements are high enough to warrant special precautions when applAng the waste. For diagnostic samples, site -specific
SS
Soluble salts
recommendations are provided based on information sheet data. The more thoroughly the problem and its unique conditions are described on the
T
Trace
• information sheet, the more pertinent and site specific the recommendations will be.
Zn
Zinc
10,000 copies of this public document were printed at a cost of $204.22 or $0,02 per copy.

Grower.- Fredrick, Harold Copies To: Count) nsion Director
881 Beaver Rd. USDA-NRCS-Sampson
Clinton, NC 28328
�rrn w� is
aste naly se ort fprm:
.�
9/3W97 Sampson County
Sam to lafa.: ,��� �I;aborato iResul�s' � � [lioa nnlessathe wish noted .
Sam le ID., N P E Ca mg S Pe Mn Zn Cu 8 Mo C! C
0q1 Total 448 M 66.2 768 69.8 20.8 20.3 4.65 0.30 0.63 1.01 0.82
INN M H M M M M M M M M
Waste Code: NH4
ALS NO3 Na Ni Cd A Al Se Li PH SS C.N DM% CCE% ALE X a!
Description: OR-N 168 7.8
Swine Lagoon Liq. Urea M

:r.'..a-i �,A,. ".v.. 'u y,3 �'..�^ ..i e,7�- S'Y .. r.'-'.s. _s. ,.�. ers ,. Yt 4� '. .h''� — �iA �%i's 'x: Y ��'E. �E a'� ii �� "iia�' 2_i . ..:1r. J.j' �p '�
NCpAA onomicnivision4300eReedyCreek'Road Ra?�i�tt, EVC71f07G,�tGS (9.19)?7;33-ZG55r� ;:�� �Re or#;No IW,0213.7W
_.
,rower: F & B Farms Copies To: County Gxte, Director
763 Beaver Rd.
`. Clinton, NC 28328
USDA-NRCS-a,.@,ipson
Ji�nwdY�
aste nalysis e ort Fann:
USDA-NRCS-Sampson
New Agricultural Building
r
84 County Complex lex Rd.
4/7/97 Sampson County
Clinton, NC 283284727
T.:e.:a k:r. ,� 'w,sxia:s.ii:�a•.Ski�
Sam le I>ofo'Yd2,-� °`
�-.a ' rr.,'u:
li:aliorato vltesults arts cAmilEion t�nles§=otherwise:n
Sample 1D:
N
P K Ca MR S Fe Mn Zn Cu
B 3fo CI C
Total 952 11
129 9" 164 52.9 41.3 11.0 2.15 4.77 5,12
2.35
Waste Code:
IN -N
II 11 H II H M If 11 H
VI!
Na Ni Cd A Al Se Li pH SS
C.eN DM% CCE% ALE K aI
ALS
OR-N
213 7.67
Description:
Swine Lagoon I.i .
H
:H.r�:.x.:.:^H..M•au. .-9.@s,e... -:�.. �. z•, er :..ra. w,. ... �. »... .. ..... .��,_.._-ns,..rrc..-arr� ,w - �:> ';.yyo-d.., +,+w:R'S";'L•, - .a:8' �•;i.s y..s
Recommendations: s.g tNutrients:Availab[e;for.Firs[Cro I1;s71000.. allons
Otber.?I?lemenfs
,5. 2^'K '9,. o;:g.n"
. lbs/IpOU- allows
.., . eR •��,_r :.. `a; ,wn.:„' ...-.-,*, � -. _x�:-p: r� 2:� '�.,,•. p t � .. � �'.a, ..r ..;. ..,y . �'. �n",9i "'. "`l :•r 'k�
f
AppllcahomMetbortr N `'� PAS ��KzQi. Ca .� Mg Sb � �Fe. �•Mna zn Cu � B Ma ��.' Cl� �'
r
��Irrigatigri��, ,3 6. a,F ,117 8:Q : °� � � . 4'�I Q-24 •- �¢� t)G t};UI 0.03 . ;Q� 3 . _ Q�,Q1 � �
'�'
�11►a `
, t;8
� .3� ,rs: ..'Y.4"
�Yl.� � � eGd� ,�dw` AI.F�: �, L!

NCAA Agt iic Divisioa , �, !, ; 434o•Reedy Creek Rd E " x :` Raleigh;,NC:27G07-6465' , '4) 733-2655
., ws ,
w� 'fit; 'Understc�ndin the Este nil sisRe�hort
,fi� � ;g y
Waste products must be disposed of In ways that protect soil and water resources. The keys to proper disposal include analyzing the waste product and planning application
rates based on crop requirements. The Waste Analysis Report provides information necessary to use these materials as a resource while protecting the environment.
Sample Info This section contains sample identifiers, specifically the sample identification number, waste code and waste description. These data are
supplied by the grower on the information sheet submitted with each sample.
Laboratory Results This section lists concentrations (parts per million) of elements found in the waste. These include elements that are essential for
plant growth --- major nutrients (N, P, K), secondary nutrients (Ca, Mg, S) and micronutrients (Fe, Mn, Zn, Cu, B, Mo, CI); as well as elements
potentially harmful to plants (Ni, Cd, Pb , Na). This last group can permanently damage the soil if allowed to increase to toxic levels. DM% is reported for
solid samples. CCE is reported for waste products that have neutralizing value.
Nutrients Available for First Crop These predictions are based on estimates of mineralization rate and nutrient loss, depending oil application
method. Estimates are reported in IbsAon for solid wastes and Ibs/1000 gallons for liquid wastes. "T" indicates that an element is present in a "trace"
quantity (< 0.005 lb per measured unit).
Within the first month after waste application, 50-75% of the nutrient quantities listed will become available for the crop. Therefore, plan to apply
wastes near the time that plants will require nutrients. The remaining nutrients gradually become available over the next three months.
Nutrients not available for the first crop are mineralized to available forms over time, usually years. Significant quantities of nutrients can accumulate
in soils that do not leach readily with heavy rainfall. If waste is routinely applied, take soil samples at least once every two years to monitor nutrient
accumulation. Some cropping systems and metal levels may necessitate annual sampling.
An ALE value is reported for wastes that may have a neutralizing value. This value indicates the amount of the waste product required to equal 1 ton
of good quality agricultural lime (90% CCE). If waste materials have significant neutralizing value, apply them only at rates necessary to optimize pH.
For flexibility, the information sheet provides two choices for application method. Predictions of available nutrients are based on the type of waste and
the method of application. If you decide to change the application method after the analysis is complete, contact your local Regional Agronomist or the
Agronomic Division at [phone].
Other Elements Quantities of the potentially harmful elements Ni, Cd, Pb, and Na indicate their potential for build-up in the soil. Like nutrients, they
are reported in Ibs/ton for solid wastes and Ibs/1000 gallons for liquid wastes,
Recommendations This section provides general information on the waste product and emphasizes unusual characteristics that must be considered
for safe disposal. if the analyzed sample is a composted material, values for pH and EC , or soluble salts, are reported here. Special notes are included
when heavy metals or other elements are high enougli to warrant special care in applying the waste. For diagnostic samples, site -specific recommendations
• ace provided based on information sheet data. The more thoroughly the problem and its unique conditions are described on the information sheet, the
more pertinent the recommendations on the'A'aste Analysis Report will be.
Essential Elements
B `Boron
'
Ca:<;
Calcium
CI . '
Chlorine, '..
Cti
Copper
Fe "
Iron''
K ` s
Potassium. -
Mg`
'Mn
Magnesium
:
Manganese. -
Mo,' >;; '.Molybdenum
N �- �
Nitrogen
P ` -Phosphorus
S
Sulfur
' Zn
Zinc '
Potentially harmful Elements
Cd'
Cadmium
Na
Sodium
Ni.
Nickel
Pb
Lead
Other Determinations
ALE
Agricultural lime
equivalent
CCE ,
,.CaCO3 equivalence
DM%`
'Percent dry matter
EC
Electrical conductivity
pH
Measure of acidity
or alkalinity on a
scale of 1 to 14
10.000 copies of this Public document were prialed at a cuss of $199.22 w $0412 per copy.

a
r
o
co
u
0
C
PL
s N
i17 I
ED
C.? _2 u
Laiidnwner-lbperator Name:
LL =
cAddress:
Telephone:
TABLE I - Irield Specifications
IRRIGATION SYSTEM DESIGN PARAMETERS
arold County, -SQ+K�3SflAl
*71P3 ei 4 NeY Q
pv, C.- .Z 3s Date:
CIO s.33 1736 q
ExHiBff D-1
Fleldl
Number
Approslmale
Maylmam
Unable Size
of Fleld2
strew
Soil Type
Slope
(%) t
Cro a
Mnlmum
Applleallon
Rate3
lnlhr
Madmum
Applleatlon
per Irrigation
Cyele3
tnchee
Comments
tsv
No
ila
, s
/, 3
Ale,
n/
A10
L
Bmtmu
7
D
0
Q' oZ
rr w« ,;6
I See atlached map,
2Total field acreage minus required buffer areas.
3Refer to N. C. Irrigation Guide, Field Office Technical Guide, Section H G. Annual application must not exceed llte agronomic rates for the soil and crop used. '
NRCS, NC
i1 M, 1996

ID

A. r E-1
FORM IRR-1 Lagoon Liquid Irrigation Fields Record
For Recording Irrigation Events on Different Fields
Facility Number
Field

E. sIT E-2
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Facility Number 2--
Irrigation Operator
Irrigation Operator's
Address Fes( -
Operator's Phone # 6
From Waste Utilization Plan
Crop Type Recommended PAN Loading
(lblacre) = (13) FToF
111 (91 (a] r41 (51 191 (71 (81 (91 (101 rill
Date
mnvddlyr
Irrigallon
Waste Analysis PAN'
(lbl1000 gall
PAN Applied
(Iblacre)
(a1Kr9)
1000
Nitrogen Balance '
(rb/acre)
Start Time
End Time
Total
Minutes
(3) - (2)
q of Sprinklers
Operating
Flow Rate
(gallmin)
Total Volume
(gallons)
(B) K (5) M (4)
Volume
per Acre
(gal/acre)
_
A
--5- g
:_ M
�.�;a*
� 5►
3 2 0
-
/& P7 k
ICooA
_ ba
b
/
20,6
Y2.000
L2.Da0
2 • U
1
-z3-9`r
:ovPAA
6�a Rvt
/Fo
ZOG
36Q0
/2oa6
- !?- 9
: oo -P
-aa
ob
2
/ S'o
g
4-Al-
Zia
� a
/Y-SEo
Crop Cycle Totals
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
i NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
a Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each irrigation event.

IBIT E-2
FORM IRR-2
Traci #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owners Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Facility Number 2- - -
Irrigation Operator
Irrigation Operators
Address,
Operators Phone N Z
From Waste Utilization Plan
Crop Type Recommended PAN Loading
reti v rep rai M IM rai 11M ft1]
Dale
mmlddlyr
Irrigation
Waste Analysis PAN '
(Ibl1000 gal)
PAN Applied
(lblacle)
IBI x (9
1000
Nitrogen Balance =
(Iblacre)
(B) • 00)
Start Time
End Time
Total
Minutes
(3) - (2)
# or Sprinklers
Operating
Flow Rate
(gallmin)
Total Volume
{gallons)
(a) K (5) K (4)
Volume
perAcre
{gaVacre)
XL
A
.mob
D
2aU
2 a
G
Crop Cycle Totals I
Owners Signature
Certified Operator (Print)
Operators Signature
Operators Certificallon No.
l NCDA Waste Anaylysis or Equivalent or MRCS Estimate, Technical Guide Section 633.
Enter the value received by subtracting column (10) from (8). Continue subtracting column (10) from column (11) following each irrigation event.

H. J E-1
FORM IRRA Lagoon Liquid Irrigation Fields Record
For Recording Irrigation Events on Different Fields
Farm Owner F Facility Number 2— -
Irrigation Operator
Date Field Size Irrigation Time -Number of
..
r�
r

E. JIT E-2
FORM IRR-2
. Traci #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Facility Number Z — -
Irrigation Operator
Irrigation Operator's
Address RV -.
Operator's Phone 0 1a
From Waste Utilization Plan
Crop Type Recommended PAN Loading
rC. (11vacre) a (a) J:�b
ell 171 /71 fdl 1.1 181 r71 M 1Gl eln% fill
Dale
Irrigation
Waste Analysis PAN'
(Ibr1000 gal)mmlddlyr
PAN Applied
(Iblacre)
8 k
1000
Nitrogen Balance'
(lblaere)
(B) • 00)
Start Time
End Time
Total
Minutes
(3) - (2)
N of Sprinklers
Operating
Flow Elate
(gaUmin)
Ttal Volume
a
(gallons)
(a) M (5) x (4)
Volume
per Acre
(gaVacre)
,-(ZL
(A
—��'
��
`� T
l4J a U
♦ L1
�Z.
r 26-
:�-Piv�
�a911
ZSL
2
3 z
v'S o
2.0
2 9
Crop Cycle Totals j
Owner's Signature
Certified Operator (Print)
Operator's Signature
Operator's Certification No.
1 NCDA Waste Anaylysis or Equivalent or N♦ZCS Estimate, Technical Guide Section 633.
2 Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each irrigation event.

H. f E-1
FORM IRR-1
Lagoon Liquid Irrigation Fields Record
For Recording Irrigation Events on Different Fields
-,Date..Field
_

E. 3IT E--2
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owners Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Field #
Facility Number -
Irrigation Operator
Irrigation Operator's
Address -
Operator's Phone # 6 — Z
From Waste Utilization Plan
Crop Type Recommended PAN Loading Q O
(lblac(a) s (8)
rn 12) (31 141 (51 (61 (7) (a) (9) (to) (11)
Date
mmlddlyr
Facility Number -
Irrigation Operator
Irrigation Operator's
Address -
Operator's Phone # 6 — Z
From Waste Utilization Plan
Crop Type Recommended PAN Loading Q O
(lblac(a) s (8)
rn 12) (31 141 (51 (61 (7) (a) (9) (to) (11)
Date
mmlddlyr
Irrigation
Waste Analysis PAN
{1b11000 gal)
PAN Applied
(Iblacre)
(al M (01
19oa
Nitrogen Balance'
(Iblacre)
(B) - (10)
Start Tama
End Time
Minutes
M - 0)
p of Sprinklers
Operating
Flow Rate
(gallmin)
Total Volume
(gallons)
(6) " (5) " (4)
Volume
per Acre
{geUacre)
�_
A
Q
Fr a
Y a
4 -
.?04
�Z�
L
Z
0 4
l4
If.�.2-
Y 6
Crop Cyc a Totals
Owner's SignaturOperator's Signature
r
Certified Operator (Print) ; G Operator's Certification No.
1rg3,�A
t NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
2 Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) From column (11) following each irrigation event.

E. tsTT E-2
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Facility Number -
Irrigation Operator
Irrigation Operators
Address 9-S-% 6 %Z
Operators Phone #
From Waste Utilization Plan
Crop Type p Recommended PAN Loading
:¢ (lblacre) n (B) 3 S`
r11 (2) (31 (41 (5) (6) (7) (8) (9) (10) 01)
Date
mm7ddlyr
Irrigation
Waste Analysis PAN '
{Ibllogq gal)
PAN Applied
(Iblacre)
181 K (91
1000
Nitrogen Balance'
pblacre)
19) • (ID)
Start Time
End Time
Total
Minutes
(3) • {2)
0 of Sprinklers
Operating
Ftow Rate
(gaVmin)
Total Volume
{gallons)
(8) x (5) x (4)
Volume
per Acre
(gallacre)
171
A
-14-9r
2: GP ,.
99b
4,14
a
2
/ 9,
lb
2
,
�� / %%Crop cle Totals
lYTlll�kS��.RfdQeP�,r ��•w—• p g 7
Owner's Signature O erators Signature
Certified Operator (Print) �G&Lrl f� . �eacf P�r'c Operators Certification No. l I','
/a-T-t
1 NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
2 Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) following each Irrigation event.

in
FORM IRR-2
Tract #
Field Size (acres) = (A)
Farm Owner
Owner's Address
Owner's Phone #
Lagoon Irrigation Fields Record
One Form for Each Field per Crop Cycle
Facility Number 2 —
Irrigation Operator
Irrigation Operator's •y,
Address
Operator's Phone #
From Waste Utilization Plan
Crop Typo Recommended PAN Loading /yD
(Iblacro) - (13) 3
(1) (2) (3) (4) (5) l (6) (7) (81 (9) (10) (11)
Date
mmldd/yr
Irrigation
Waste Analysis PAN'
(fbl1000 gel)
PAN Applied
(lb/scre)
10).18)
1000
Nitrogen Balance'
()blacre)
(B) - (10)
Start Time
End Time
Total
Minutes
(3) - (2)
4 of Sprinklers
Operating
Flow Rate
(gavmin)
"
Total Volume
(gallons)
(6) x (5) (4)
Volume
per Acre
(gavac(e)
_j7L
A
Q G
S=
S�G6
:36ca(
/ :5-6
/
z 3
3641
_
/14
46 99
/ 2
-
P/►�i
:?O
a-I3-
F0-��¢ /art
�2:?Mfy.
2VT-3z
o
l S�./rs '
l _
z, 4 .6 46
15"a
2---2b-Yr
7`30AI
14:36
6
I
i
.F.,r46
2�, IbG
/ • /S-
/2-2o-
fl,16,6AN
/: blPi
2.D
2 7
Z 40
/9 44
41, 66
Crop!cycle Totals
Owner's Si nature
Operator's Signature Z2,
Certified Operator (Print) Q �, f, �A �� Operator's Certification No. / -?L.4,
�S3�
NCDA Waste Anaylysis or Equivalent or NRCS Estimate, Technical Guide Section 633.
Enter the value received by subtracting column (10) from (B) Continue subtracting column (10) from column (11) following each irrigation event.

r E-1
FORM IRR-1
.. TA 'Zwak!W
Lagoon Liquid Irrigation Fields Record
For Recording Irrigation Events on Different Fields
Facility Number 2— YY I -
Date —..-----Field
AA AI !d
S•rinklers Operatina
l 111 11'
1• 11=
• �j 1
NMI 6�
'
•.' ...
KA
miss
r -�
�•

OPERATION & MAINTENANCE PLAN JUt 2 f9981
Proper lagoon liquid management should be a year-round priority. It is especjally� ��,�7
important to manage levels so that you do not have problems during extended rainy a'n§?Mvxnr�
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant.(such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brusly and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
';Taste Inlet Pipes, Recycling Pipes, and Overflow Pipes ---Nook for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface —look for:
1. undesirable vegetative growth
• . 2. ,floating or lodged debris
Embankment --look for:
1. - isettlement, cracking, or "jug" holes
2. side slope stability —slumps or bulges
3. yyvvet or damp areas on the back slope
•4. Erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewails, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to -a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts. -
Any of these features could lead to erosion and weakenirrg of the dam. If your lagoon has
any of these features, you should calf an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps —check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or -a large amount of vibration,- may indicate that the pump is in need or repair'or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoft) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
i _ adequate vegetation
2. diversion capacity
3.� ridge berm height
i

identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to b hours after the rain (assumes there is no pumping).' This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may -
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
i . Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking'care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
S. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
b. Maintain a periodic check on the lagoon liquid pH. Ir the pH falls below
7.0, add agricultural litre at the rate of 1 pound per 7300 Cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
Season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.
r,.

Practice water conservation —minimize building water..usage and
spillage from leaking waterers; broken pipes and washdown though
proper maintenance and water conservation. i
Minimize feed wastage and spirlage by keeping feeders'adjust �d'L This
will reduce the amount of solids entering the lagoon
Management:
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show thel
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower,that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequent lyremove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow or, lagoon darn or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure p,an to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can he reduced by:

V
• proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushedrwaste solids in an appropriately designed basin, or
- minimizing feed wastage,a'pd spillage.
Lagoon sludge that is removed annual'I rather than stored long term will:
have more nutrients,
have more odor, and I
require more land to properly use the nutrients.
Removal techniques.
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
` and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that fie'd and crop
.requirement. Waste application rates will be discussed in detail in Chapter 1
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. l:� you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are Sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably he applied to lard with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the %vind direction and other conditions which
could increase the concern of neighbors.

l
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge or wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which. may lead to lagoon failures. include:
Modification of the lagoon structure —an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels --high levels are a safety risk.
Failure to inspect and maintain the dam_
Excess surface water vowing into the lagcon_
Liner integrity --protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagcon liquid level below groundwater
table.
,,NOTE: if lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.

Swine Farm Waste Management Odor Control Checklist
Source _ —.� Cause 11M111 In Miufactize tldnr Silc tipccilic Practices
Talnlslell,t — — • swine produclanit n Vegeiative orwooded buMrs; — _-
Pr- Recommended hest management practices;
clr Gnnd judgment and common sense
Auiol•al holy surfaces 0 Dirty niauure-covered animals M pry floors
6 Wcl Immilic-covered 1711nrs j Iotted floors;
f Watcrers located over slotted floors;
bulimic 6111ccriult Nils • Urine;
• !'arlial microbial decotupositinn
V�110,511,lil rOaauA (,uls • V4)IMile gases;
I bast
laa,l„ul sui I��ices • l�+lst
~I'1W.11 t.u,t.s * Agivatinn of recycled lagonil
Cl feeders at high end of solid floors;
1"1 Scrape manure buildup froin floors;
fl Underfloor ventilatinn for drying
frequent manure removal by (lush, pit recharge,
or scrape;
n Underlloor ventilation
IT fan IuaiIII enatice,
R"' Efficient air ninvcment
R' Washdown hclween groups of animals;
n Feed additives;
n Feeder covers;
n Fecd cklfver'y dnwaaspnaal (AICIIars In lcedei
covers
0 flush lank covers;
tl,lidd whiles taliks arc falling
9
I:Xlelud fill lines,to near hnllnm ol'taul;s with
anti -siphon vents
I l,l,li Alcys
Agitation during waslewatcr
fl
Underfloor flush with underfloor ventilating
cnuveyance
Pii ac,'h.nge awiaias
Agiladou of recycled lagoon
f3
Emend rechurge lines to gear IwIlulll of-pils
licluid while pits are tilling
%vilh anti -siphon vents
Fill �I aii,ni� -
Agitaflon during smnp wa k
C1
Snmp lain: covers
filling and drawdown
tlallt.i,lc drain a:ollecliun
. Agilation (hiring waslewatcr
n
Box covers
w j1111clinu 1HINes
conveyauco
A Nl()(. - Huvvillhcr 1 1, 1996, I';age 3

S„urce Cause DMI's to Miniluixe odor Site Specific I*ruclices
End of dr:,inpipcs at • Agitation during wastewater C) Extend discharge Point of pipes underneath
lagoon conveyance lagoon liquid level
I.aguwl surfaces 0 Volatile gas enlissioits; Or Proper lagoon liquid capacity;
• Iliological mixing; ff""Correcl lagoon startup procedures;
• Agitation O" Minimum surface area -to -volume ratio;
FI Minimum agitation when.pumping;
I_ Mechanical aeration;
M Proven biological additives
III iLaliun spriAler 0 high pressure agitation; IT Irrigate on dry days with little or no %vied;
iu,trlcsG Wuu} drift m Minimum recommended operating pressure; -
Cl Pump intake near lagoon liquid surface;
C] Pump from second -stage lagoon
Sliiial;e taut: ur basin aPat decoulposhion; t 1 Ilnlloul or midlevel loudsllg;
'411 hce0 Mixing while filling; Cl Tank covers;
• Agitation when emptying n Ilasin surface mats of solids;
CI Proven biological additives or oxidants
Sclllir,g kOin s„rl'acc • I'artiaiIII i:(ohial decomposition; Cl Extcud drainpipe millets underneath lillllld
• Mixing while filbng; level;
Agitation when emptying
f�lei,i,rc, Slurry ur NI„+ILc • Agilalinn when spreading;
Sp,CadL:( rulllcI5 6 Vniatile gas emissinlls
I lurovered manure, Volatile gas emissions while
sImi- • nr sImIge on Iield drying
Sin hL:C5
Cl Remove settled solids regularly
Cl Soil injection of sherry/shldges;
ri Wash residual manure from spreader after use;
11- Proven biological additives or oxidants
Cl Soil injection ofslurry/sludges
n Soil incorpnration within 48 lirs.;
❑ Spread in Thin uniform laycrs for rapid dryinU;
O Proven biological additives or oxidants
Dead auimala 0 Carcass decomposition n !'raper disposition of carcasses
I3c,ul aniu,al Ji .lu,aal Carcass decoltlposition M Complete covering of carcasses ill 11111-i:ll pits;
IFiI>
Proper locution/construction ol'clisposal Ails
ln�.inci:��n,y Irlcomplcle CINnbllSOoll 171 Secondary stack burners
i%NH )t: - Hovemit; r 1 1. 1990, Page 4

Soul ce Cause: IIMI's to Miuiniize Odur Site Specific Pr•aclices
Standing %valrr around • Improper drainage; Pr Grade and landscape srlch that water drains
I'acifiliCs Microbial decomposition of away from facilities
organic platter
hl.uurrc tracked onto • Poorly maintained access roads - Farm access road maintenance
public ruaLis liunr farm
aCCe5s
Additional Infurntalion : AVikililIlIC Frnnr
Swing At.cnuru Manat;enrcnl ; 0200 It IAIMP Packet NCSI I, C,xrnty t:arensicul CCIIICI'
Swine I'ru(incaion Tanis Potential Odor Sources and Iteutedies ; FRAls Fact Sheet NCStI - BAH
Swine Prodreclion Facility Manure Management: Pit ltecilurge - Lagoon Treatment ; MAE 128-88 NCSII - BA
Swine 11nuloction facility Mamrre Management: Underfloor Flush - Lagoon Trealment ; r.nA[i 129-88 NCSI I - BAI:
Lagoon Design and Managenieul for Livestock Manure Treatment and Storage ; EHAF 103-83 NCSt I - I IA f i
calibration of Manure and Wasrewaler Application Equipment ; MIAE Fact Sheel NCSt I - IIAF
Coats olling Odors fron► Swine Ilrrildings ; Pil1-33 NCst I - Swine Extension
FIM(Minreoral Assurance Program ; NPl'C Manual NC: Pork Producers Assoc
Oplimis lirr Managint; Oclor, ; a report from the Swine Odor Task Force NCSO Agri C01111nr1111CaliOlIS
Plut.ance t.oncerns in Animal Marrure Management: Odors anti I, lies ; PRO107, 1995 Conference Proceedings Floritla Cooperalive lixtcusiort
AKIt►r• IiiwCIllbCr 11, 1996. 1`.Ige 5

Insect Control Checklist for Animal Operations
tiuurcc
Cause
RMPS la 011111rol Inseclsµ Silt: Specirle Practices
Liquid Syslelus
Flttslt (ituters
Accunwlalion ofsolids
gr Flush sysleni is designed and operated
sufficiently to remove accumulated solids from
tillers as designed.
Itemove bridging of acciinttllaied solids al
Iisdiarge
I.,igouns and fits
0 Cruslerl Solids
Maintain lagoons, stalling basins and pits where
pest breeding is apparent to minintize Ilse
crusting of solids to a depili of no more than fi -
1l inches over more than 30% of surface.^�^�
i:acessive Vegetative
• Decaying vegetation
—
Maintain vegetative control along hanks of
t irowth
Iagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along wager's edge on iMpoundnient's perimetcr.
Dry Sysleens
1-ce, eta • let Spillage!)csigtt, ulieratc and uiaiulain feed syslerus
hunkers and troughs) to minimize the
accuinulalion of decaying wastage.
M Clean up spillage on a routine basis (e.g., 7 - 10
day interval thiring stints er; 15-3{) day interval
_ during wiatcr).
Iced Slurtge Accumulations of feed resi{Tiles (_J Rethice moisiure acctuuulalion within and
around immediate perinicier of Iccd storage
areas by instiriiig drainage away from site
and/or providing adequate cone himent (e.g..
covered hip lisr brc+vcr's grain trntl similar liil;li
moislure grain products).
Inspect fiir anti remove or break up aectinuilated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page I

L "
CV
EMERGENCY ACTION PLAN , r99�
PHONE N-UN1BERS
DWQ 3 1'093
ENIERGE`CY IIAINAGEMENT SYSTEM /V S'92 g b
SW CD 9i o S9z 7?63
MRCS %o s9z 796,5
This plan will be implemented in the event that wastes from your operation are leaking.
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor. +
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields whe:-_ runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. CIose valves to eliminate further discharge.
d. Repair all leaks F-ior to resi2ningpumps.
D: Leakage from flush systems. houses. solid separators -action include:
a. Stop recycle pump.
b. Stop irn--ation pump.
c. Nlal:e sure no siphon occur_.
d. stop ail flow.; in the 10u,;e.or,70iid .<z�3raiors.

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage.
put in a submersible pump, and pump back to lagoon.
b. if holes are caused by burrowing animals. trap or remove animals and fid
holes and compact with a clay type soil.
c. Have a professional evaluate -the condition of the side walls and la_Qoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Anv damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f.. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. Durine normal business hours, call your DWQ (Division of Water Quality)
regional office: Phone - - . After hours, emergency number: 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number, -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local MRCS office for adviceltechnical assistance phone number - -
4: If none of the above works call 911 or the Sheriff s Department and explain your
problem to therm and ask: that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name:_
b. Contractors .Udrzss:
c. Contractors Phone:

r
6: Contact the technical specialist who certified the lagoon (MRCS, Consulting
Engineer. etc.)
a. Name:
b. Phone:
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectifx- the damage. repair the system. and reassess the waste management plan to
keep problems with release of wastes from happening again.

Mortality Management Methods
• (check which methed(s) arc being implemented)
J Burial three feat beneath the surface of the around within hours after
knowledge of the death. The bu�;al must be at least 300 feet from anv ;io��inv
• stream or public bod.., of water.
Rzmde na at a rende;;ng plant license? under C.S. I06-153.7
._1 Complete inc:re.arc❑
In the case of dead pcult,-v only. piacinc in a disposal pit of a size and design
approved by the Department of Agriculture
D Anv r;,ethod in the proffessional opinion na_ia:1 would
make possible the salvage of pan of a dead animal's value «iihout e,.:anae:ing
human or animal health. (V,'ritte:i approval of the State %'ete-=rarian must be
attached)

Amx-Ie1r&.�) /Jo. RR-046
3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 24.6—. Required Acreage (as listed in the AWMP): 24.6
lagoon
2.4 Number torage ponds (circle which is applicable): evi
2.5 Are subsurface drains present within 100' of any of the application fields? YES o NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRC
ndards, etc.) (Swine Only)
MYE or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?-7— V `—/770-
-
What was the date that this facility's land application areas were sited?
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
A licants Initials
FOS -
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.9 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.I2 bisect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
0
F6
FORM: A WO-G-E 5/28/98 Page 2 of 4 82 - 98

WASTE MANAGEMENT SYSTEM
FOR
HAROLD FREDERICK
CLINTON, NC
TABLE OF CONTENTS
RECEIVED
d DATER QUA-J_lrr' CECTION
O4W4-iC 7-1,,) A)6d ?=L-,q0qF
1. Cover Letter
GFd Rio-gd
2. Soils Map
3. SCS-ENG-538 (Soil Investigation>
4. NC-ENG-34 Hazard Classification
5. Lagoon Design Data
6. Nitrogen Content & Acres Needed For Effluent Disposal
7. Waste Utilization Plan
S. Seeding Specifications
9. Lagoon Size Computations
10. NC-ENG-12 (Excavation)
11. NC-ENG-12 (Embankment)
12. NC-ENG-12 (Pad)
13. NC-ENO-40 (Plan of Excavation Waste Storage Lagoon
14. Typical View of A One -Stage Lagoon
15. Operation and Main'::enanee Plan
16. Topographical Map W/Lagoon & Houses
17. Cross -Sections of Lagoon & Pad
1?Z

303—D
EAST
ROWAN STREET
DEPARTMENT OF
PHONE
---------------------------------------------------------------
(919)
592-7963
AGRICULTURE
OPERATOR: HAROLD FREDERICK
Please review the attached plan and specifications carefully.
Retain this plan for your use and records. It is strongly
recommended that you, your contractor and the Soil Conservation
Service personnel are in agreement as to how the waste lagoon
is to be constructed. SCS personnel will meet with all
concerned parties and wall: over the site to explain all flags
and markings. It is important .that everyone understands what is
expected so that final construction meets plans and
specifications and the job can be certified for payment (if ACP
cost —share is involved).
The pad dimensions and grades are the best estimate. The
builder o.r contractor is responsible for final layout and
design of the pads. SCS personnel will assist in a limited
capacity, as its major concern is the proper design and
construction of the waste treatment lagoon.
The actual amount of material required for pads and dam may
vary from the estimates. The design will attempt to balance
cuts and fills as close as possible. If additional material is
required after construction is complete on the lagoon, the
contractor and owner will negotiate on the price and location
of the borrow area.
It should be noted that certification of the lagoon will depend
upon :all specifications being met. Important items include
length, width, depth, slopes, topsoil placement, correct
elevations (top, bottom, discharge pipes), and seeding.
NOTE:
Design Requirement:
718,874
cu.ft
=26,624 cu.yds.
Estimate
of Excavation:
88,385
cu.ft
=3,274 cu.yds.
Estimate
of Pad:
0 cu.ft
= 0 cu.yds.
Estimate
of Dike:
45,529
cu.ft
=1,855 cu.yds.
Estimate
of Topsoil
Required:
100 cu.yds.
Ratio
0.0
: 1
.lob Class IV
Designed By HERMAN RIGGS
------------------
11/26/91
Date
Design Approval
/_ z.? -9z
n-4.-

All dams built with technical assistance from the Soil Conservation Service
must have a hazard classification assigned by the person responsible for
approving the design. Most farm ponds, except in borderline cases, can
_be classified after a complete field investigation without assuming failure
and making breach studies. -'This data sheet is to be used for rEcording
the information obtained through field studies and for documenting the
hazard classification. Where there is a possibility for loss of life or
major property damage from a dam failure, an approved breach routing
Procedure is to be used. (Consult with the area engineer.)
Hazard classifications of dams are made by evaluating the possibility
for loss of life and the extent of damage that would result if the dam
should suddenly breach--th,t is --a section of the dam be suddenly and
completely washed out. It is to be assured that a wall of water will be
released -equal to the height of the dam. This flood wave will be reduced
in height as it moves down the flood plain. The wave height (depth of
"flooding)should be evaluated for a sufficient distance downstream until.
ti;:!:estimated.flood level will not cause significant damage to improvements,
such as homes, buildings, roads, utilities, reservoirs, etc. she breach
flood level will be reduced depending on the valley storage, slope, and
openess of the flood plain; however, in a narrow steep valley sl-opes
__.._.steeper. .than .l0%-should be given special consideration. One method of :..
evaluation is to compare available valley storage (under flood conditions)
_ .__.to impoundment. storage. -(figured to the top of the dam) for each reach
evaluated With a judgment estimate made of the flood wave height at'all
_�...-• --- critical. paints. downstream.'.
- —• �•• Should -there ..be ..any. questions about the hazard classification for a dam,.
the area engineer. should be consulted before making design commitments.
y

U. ueparcment ui nyritut wts
Soil Conservation Service
Septembet 1980
Fi'e-Code: 210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner__ Harold Frederick ' � County Sampson
Community or Group No. Conservation Plan No.
Estimated-Depth of Water to -Top of Dam Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation 11
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. Elev.- :Es evat10n
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements Above loodwater Above
flood Plain: Flood Plain
'.. Ft. Ft. Ft.
2 ; — . . is �Ji•:!.)•
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach a SlT f1j� F.N F6T11j2R DE STRIJOITiRR W113. NOT RWnANGFR _
LIFE OR DAMAGE PUBLIC TRANSPORTATION. APPROX. 400 FEET FROM BEAVERDAM SWAMP
Hazard Classification of Dam (a, b, c) (see NEM-Part 520.21) cc -
Dam Classification (I, II, III, I.', v)
By Herman 0 Riggs
name) (title
Concurred B �C
name title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date 11/25/91
Da to 1 I 26 Iq

a
SGS.tNf, 53/ U. S. DEPARIMENT OF AQRICULTUR!
Rev. 5-70 SOIL CONSERVATION SERVI-�f
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE �
I
i
I
■■■■■■■■r
INS
==m
on
r■mi1■■■■■r■
■e■■■Ir■■■■
r■■rrr■■■■■■■
■ee■■�rr■r■
■■■■�
r■■■r■r■■■■■Irrnrr■1■r
SEEM
I
■r■■■■■■■■r■■■1■■■■e!
S■■■■■■
ON
SOMEONE
r■
■er
MONOS■■■■■■■■■■■■■■re
re■■.
rr■
■■■r■
MOM■EME
E■■r■■■■.
'■■■
■■■
■r■■■r■■■■r■er
�■■■■
■■■n
■■■■r■■■rr
■
, I■■r■r■■rr■
■■■■■■■err
■:
ONE
Emm
•
:. ..
Ina©�l0I.
IMIMIMIM13101MIUMMIMI©M:
1l�&M
Ir14'�,
'!'
I
■I�I�I!>IrI�rI■[rf�,rl■Ir�rlri
MUM
r�
69
low
lk�l��fl��,�l��
e�lrl�►
l�f�i■Iej
Ic�
L
eME
.
�
e!M.
WINZINIe
MUM
��■r�■NI■re�{■�i�tr!r�1■r��eltr;el
�■►�.►f�ss■,.e�■ei�
I[-147®■,r'r
■
■■
■■Iel■�rrl�■I■f
■ke.■�
�'■��'■r��■I■'r�■I■Ir�r�rl�'■fel��■�e�el®!!!!j
�re;r�rl■
e��
!MADE
I
�e
r�■■�;■
■'�■'■Ir1�'el�tr
®:■��
BY-1: SIGNATURE & TM

a
I
TYPES OF MATERIAL ENCOUNTERED IN BORINGS
.(Use one of systems below)
UNIFIED CLASSIFICATION
USDA CUSSIFICATION
GW- Well graded grovels; gravel, sand mix-
g - gravel
GP -Poorly graded gravels
a - sand
GM -Silty gravels; gravel -sand -silt mix.
vfs -very fine sand
GC- Clayey gravels; gravel -sand -clay mix
s I -sandy loam
SW -Well graded sands; sand-gr4vel mix
fah -fine sandy .loam
SP'Poorly graded sands
I -loam'
SM -Silty sand
gl- gravelly loam
SC -Clayey sands; sand -clay mixtures
si - silt
ML - Silts; silty, v. fine s-7,nds; sandy or clayey silt
sil- silt loam
CL - Clays of low to medium plasticity
cl -clay loam
CH -Inorganic clays of high plasticity
sicl -silty clay loam
MH -Elastic silts
scl -sandy clay loam
OL- Organic silts and silty clays, law plasticity
sic -silty clay
OH -Organic clays, medium to high plasticity
C-clay
L &-itable material for embankment is available EDYes. [DNo findicatow&m1owredonthe ske"an
srurrss s1dr)
REMARKS:
2. Paplain htzards requiring special attention in design (Se=ge, jprhw,,u& dri
GEMEERAL REMARKS:
24
25
w
V
28
29
30
1311132
33
34
35
361137
1 38
39
40
41
42
43
44
45
46
47
48
49
50
61
J,
a

c

~' CONSERVATION PLAN MAP
1
Owner i;arold Frederick Operator Same
t ..-
County Sampson State NC Date 11 / 25 / 91
Approximate acres Approximate scale
t Cooperating with Sargoson_Soil & Water_ _ Conservation District
Plan identification Photo number
is
Assisted by Herman Ries USDA Soil Conservation Service
Mm-
z*�
b � L
t,.. d� •
i
ir,�
ph04-Q
,i
1
A�z
"
-T,
Ir• {» ` �JJrr� '.- y�,, YA�.,i it 1�� �5S �- I� ��F�� .� , � I
.l ��� 'x `\ is �{ +�'L• Y r.�. ` / i-,
r .'rL-d' " t3�� i.r r. s�.'rS '"�°�•"` ta4�,i.:k•
� Y
41,
�7 •�/7 � .dam f ) �-'e�T��� 1 .g, ��r
�-� -
�yut11%. t %a

Operator:HAROLD FREDERICK County: SAMPSON
L7istance to nearest residence <other than owner):
1. STEADY STATE LIVE WEIGHT
Date: 11/22/91
1000.0 feet
0
sows
(farrow to
finish)
x 1417
lbs.
= 0
Ibs
0
sows
(farrow to
feeder)
x 522
tbs.
- 0
Ibs
3720
head
(finishing
only)
x 135
lbs.
= 502200
lbs
0
sows
(farrow to
wean)
x 433
tbs.
= 0
Ibs
0
head
(wean to feeder)
x 30
Ibs.
= 0
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 502200 lbs
1 2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 502200 tbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 502200 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner requests no sludge storage.
Sludge will be removed as needed."
4. TOTAL DESIGN VOLUME
Inside top length 520.0 feet Inside top width 155.0 feet
Top of dike at elevation 54.0 feet
Freeboard 1.3 feet ; Side slopes 3.0 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 52.7 feet
Bottom of lagoon elevation 38.0 feet
Seasonal high water table elevation 44.0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 512.2 147.2 14.7
AREA OF TOP
LENGTH * WIDTH =
512.2 147.2
AREA OF BOTTOM
LENGTH * WIDTH =
424.0 59.0
75395.8 (AREA OF TOP)
25016.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
468.1 103.1 193044.4 (AREA OF MIDSECTION * 4)
CU. FT. = CAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] DEPTH/6
75395.8 193044.4 25016.0 2.5
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 718968 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
520.0 155.0 80600.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 80600.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 502200 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 122640 cubic feet
56. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day 180 days storage/7.46 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall — 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 47016.7 cubic feet

5D. Volume of 25 year -- 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 47016.7 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 122640 cubic feet
58. 0 cubic feet
5C. 47017 cubic feet
5D. 47017 cubic feet
TOTAL 216674 cubic feet
6. SUMMARY
Total required volume 718874 cubic feet
Total design volume avail. 718968 cubiv feet
-Min. req. treatment volume plus sludge accumulation 502200 cubic feet
At elev. feet ; Volume is 529584 cubic feet (end pumping)
Total design volume less 25yr�24hr storm is 671951 cubic feet
At elev. 52.0 feet ; Volume is 667156 cubic feet (start pumping)
Seasonal high water table elevation 44.0 feet
7. DESIGNED BY: ��rjy�.0 95 APP40VED BY: z'4—
DATE:11/4/1/ DATE: /-23- `I x
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

e � i
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
• Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to -a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut—off Trench:
---------------
A cut—off trench (when specified) shall be installed as shown in
the plans.
Construction:
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or she eps—foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled anc
compacted with a suitable material (ie—CL,SC,iH)_ Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction.

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment with minimum odor
control.. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre —
charged to 1/2 its capacity to prevent excessive odors during
start—up. Pre —charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump —out of the lagoon when fluid level reaches eleva—
tion 52.0 as marked by permanent markers. Stop pump —out when
the fluid level reaches elevation 50.0 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any erc•ded areas or areas damaged by rodents and
estabIish.in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ—
mental Management, has the responsibility for enforcing this law.

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactcry disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut—off Trench:
---------------
A cut—off trench (when specified) shall be installed as shown in
the plans.
Construction:
Construction of excavated and earthfiII areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps—foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten 0 0) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfiIled and
compacted with a suitable material (ie—CL,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction.

i
SEEDING RECOMMENDATIONS
-----------------------
AREA TO BE SEEDED: 3.0 ACRES
USE THE SEED MIXTURE INDICATED:
0 LBS. FESCUE'GRASS @ 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. 'PENSACOLA' BAHIA GRASS @ 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
24 LBS. HULLED BERMUDA GRASS @ 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
O LBS. RYE GRAIN @ 30 LBS./ACRE (NURSERY FOR FESCUE)
0 LBS. RYE GRASS @ 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
3000 LBS. OF 10--10-10 FERTILIZER (1000 LBS./ACRE)
6 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
300 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING 13 COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
I. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

WASTE UTILIZATION PLAN
----------------------
Owners name--:HAROLD FREDERICK County:SAMPSON
Mail Address—:CLINTON, NC
Type of production unit---- :FINISHING
Type of waste facility -----:Anaerobic Lagoon
Your animal waste management facility has been designed for a
given storage capacity. When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of'surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be consic'ered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
Amount of Waste Produced Per Year:
----------------------------------
3720 animals x 1.9 tons waste/animal/yr= 7068 tons
total waste

Page 2
Amount of Plant Available Nitrogen Produced Per Year:
-----------------------------------------------------
3720 animals x 2.30 lbs. N/animal/year 8556 lbs./yr
Available N
Applying the above amount of waste is a big job. You should
plan time and have appropriate equipment to apply the waste in
a timely manner. Your facility is designed for 180 days of
storage. Therefore, it will need to be pumped every 6
months.
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type
Code
Per Ac.
Used
Apply
4450
6
GoA
2
100 Bu.
150
2.9
430.5
MAR-JULY
4450
5.WaG
6
7 Tons
400
9.1
3620
MAR-AUG
4450
4
NoA
2
100 Su.
150
0.8
120
MAR-JULY
4450
3
NoA
2
100 Bu.
150
13.5
2019
MAR-JULY
4450
2
GoA
2
100 Bu.
150
21.0
3154.5
MAR--JULY
4450
1
GoA
2
100 Bu.
150
2.0
303
MAR-JULY
Total
49.2
9647
Available
Nitrogen
8556
Surplus
Or Deficit
-1091
Crop codes: 1=Cereal grain; 2=Corn; 3=Fescue; 4=Range Gr. Bermuda
5=Control Grazed Bermuda; 6-Hayland Bermuda
Narrative of Operation:
-----------------------
Call the Soil and Water Conservaticn District Office after you
receive waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
waste. l 5�
Prepared by: - 1 %jiey -� _------ --- 1112t�s1
Name Title Date
Concurred in by: ----__-_ - --------------------
Producer Date
(Copy to producer and copy to case file)

SOIL CONSERVATION SERVICE
EARTHWORK COMPUTATION SHEET
EXCAVATION
NAME: HAROLD FREDERICK
'ADDRESS: CLINTON, NC
+--__------ +------------------------+
:STA.: END :SUM OF DIS.: DOUBLE
: : AREA :E.AREA : : VOLUMN
- ------+------+-------f------+----------+
1: 55: 0:-------+-----+----------+
+----+------+ 1292: 38: 49096:
2: 93 : 1292:--------{------+-----------+
+-----+------+ 2220: 20: 44400:
3: 113: 928:-------------------------
------------ 1 1726 : 39 : 67314 :
4: 152: 798:--------+-----+----------+
+-___+---_--+ 798: 20: 15960:
5: 172: 0:-------+-----+-----------+
+------------ 0: -172 : O:
6: 0: 0:--------------+----------+
+----+-------+ 01. 01. 0:
7: 0: o:-------------------------
------------- 0: a: 0:
8 : 0: 0:-------+-----+----------+
+----+------+ 0: 0: 0:
9: O ; O: -------+-------E------------a-
i-----+------+ 0: 0: 0:
10: 0: 0:-------+-----+----------+
+----+------+ o: 0: 0:
11: 0: 0:-------+-----+----------+
-------------------------
------------- 0: 01. o:
12: o: 0: ---- ---------- +--w----------
+----+-------+ 0: 0: o:
13: 0: 0:---------------+----------+
------------- 0: 0: 0:
14: 0: 0:--------+----------------+
+-----------+ 0: 0: 0:
15: 0: 0:-------+=---------- --+
+----+-------+ 0: 0: o:
16: 0: 0:-------+-----f----------+
+_---+------+ 0: 0: O:
17: 0: 0:--------+-----+-----------+
-----+------+ 0: 0: 0:
18: 0.1 0::-----_-•+_------,.------__-+
-----+------T 0: 0/ OI
191 0: 0:------- q------+----------+
f----+- ---i- 0: 0: 0:
20: 0: 0:-------+-----+----------+
+----f----------------------E----------f
TOTAL 176770:
+-----------------------------+-------------
DOUBLE VOL /2 =
VOLUME
88385 CU. FT.
- 3274 CU. YDS.
COMPUTED BY HERMAN RIGGS
--------------------
4ad �x ID r- f / /Z 3 11q a
DATE 11/21/91

00it_ LCAN LR VA t 1 N �>tK V l Ltr
NAME:
ADDRESS:
EARTHWORK COMPUTATION SHEET
EMBANKMENT
-a----+-------+-------+-----+----------+
:STA.: END :SUM OF DIS.: DOUBLE ;
: AREA :E.AREA : VOLUMN
+----+------+-------+------+-----------+
1: 0: 0+--------+------+-_- -----+
+-----+------+ 241; 77: 18557:
2: 77: 241 ;---------+-----+----------+
+------+------+ 592: 78: 46176:
3: 155 : 351 ;-------+-----+-------------+
+--------------+ 351: 75: 26325:
4: 230: 0:--------+-----+-----------+
+---_+------+ 0: -230: 0:
5: 0: 0:-------+-----+----------+
+----+-___--+ 0: 0: 0:
6: 0: 0:-------+-----+---_------+
+----+------+ 0: 0: 0:
7: 0: 0:-------+-----+----------+
+----+------+ 0: 0; 0:
8: 0: 0:--------+-----+----------+
+----+------+ 0: 0: 0:
9; 0: 0:-------+-----+-----------+
+----+------+ 0: 0; 0:
---- -----------
+-----+------+ 0: 0: 0:
11: 0: 0:--------+-----+----------+
+----+-- --+ 0: 0: 0:
12: 01, 0: -------+------+----_---__-+
+----+-------+ 01. 0: 0:
13: 0: 0: -------+-----+------------+
0: 0:
14: 0: 0:---------+-----+------------+
----T+___--_+ 0: 0: 0:
15 : 0: 0:--------+-----+-----------+
16; 0: 0:-------+------F----_--__-+
+------------+ 0: 0: 0:
17; 0: 0:-------+-----+----------+
+-----+------+ 0: 0: 0:
18: 0: 0:-------+__--_f--___-----+
+------+------ 0: 0: 0:
19: 0: 0:-------+-----+-_------- ----+
+----+-------+ 01, 0: 0:
20: 0 ; 0:-------+------+-------------+
+-----+-------+-------------+-----------
:TOTAL 91058:
+-------------------------+-------------+
DOUBLE VOL /2 = 45529'CU. FT.
VOLUME OF EMBANKMENT = 1686 CU. YDS.
PLUS 10% SETTLEMENT = 169
TOTAL = 1855 CU. YDS.
COMPUTED BY HERMAN RIGGS DATE 7/17/90

I LI1,E: 0f93 =- F
1
2
3
4
5
6
7
3 9
54.0:
55.5:
38.0:
38.01
54.0:
0.0:
0.0;
0.0: 0.0:
0.01,
FJ:
1001
148:
731
H;
0:
0;
01 0:
0;
1
2 LIM: 1+13 G- G
1 2 3 4 5 6 7 $ 9
1 49.91' 50.0: 54.0: 32.0: 38.01 49.91 0.0: 0.0: 0.0: 0.0:
1 -1 l __-_1--_
1 43: 00: 10o: 1431, 731 43: 0: 0: 01 0:
3 LINE: I+52 f/-1-1
s Z 3 4 5 6 7 8 9
: 44.51 54.0: 54.0: 3$.0: 33.0: 44.51 0.0: 0.01, 0.L': 0.0:
1 641 92: 100: 148: 73: 64: 01 0: 0: 0:
1
'
1:
5400:
2:
3$00:
2:
8214.
5E?4:
3:
2774:
4:
3?C
4:
950:
5:
0:
51
1
0:
1
6:
0:
6:,
0:
7:
0:
7:
0:
s1
o1
2:
0:
9i
0:
'
k
14154;
1
1T -2:
129't:
f 1
1
,
1:
2150:
11
3992:
2:
4KO:
2:
10
31
30001,
31
799_1
4:
56241
4:
2T74:
3643:
51
1634:
6:
01
6:
0:
7:
01
7:
0:
8:
0:
-
0:
91
0:
91
0:
:
19537:
1
Z139�t:
1
1: 3456:
1:
4094,
21 4968:
2:
54001
31 3"0001
3:
7992:
4: 5e24:
4:
2774:
5: 3249:
51
Z43Z:
6: 0:
6:
0:
71 0:
7:
01
8: 01
8:
01
91 01
91
0:
: Z1097:
1
226921
1 1
798:

U. S. DEPARTMT Or AGRICULTURE IC-ENG-40
Soil Canso m tion Service Rev. 7/91
PLAN OR EXCAVATED WASTE STORAGE PIT
NAME: Harold Frederick Date: 11/25/91
County: Sampson
Address: Clinton, NC 28328 . "
520T LENGTH
1 SIDE SLOPE -ITO 1
1 /
AVE. TOP ELEV.
SEOTIOM
I
38
cb
I
AYE. NOTTOW ELEV. r
r
(Sea back for voluss calculations)
Use of facility: Swine Waste
capacity: . Gallons F't3
Soil Type: Wa ram
tench Mark Description- 16 nail:in NW post of 1,�adin2 chute
Bottom.
Normal Liquid Level
Storage for normal Precip.
Maximum "Liquid Level
25 err. Storm Storage
Crest ESW
Max -Flow Depth
Fraeboard
Top of Dam
--M pl
Elev.
380
Elev.
(+)
Ft.
Elev.
52.0
(+)
.7
Ft.
Elev.
(+)
Ft.
(+)
1.3
Ft.
Elev.
54.0
SS• 5,,

VOLUME OF A T71APEZOIDAL PIT
One equation for calculating the volume of a trapezoidal pit is:
Volume - depth [(area of top) + (area of bottom) + (4 * area
6
of midsection) ) _. Ft3
Another equation for determining the volume of a trapezoidal
excavated pit with constant side slopes is:
V wdL + Zd2(�/3 Zd - w - L)
where:
V = total volume of the pit in ft3.
w = width of the pit at top :.n feet..
d = depth of the pit at top in feet.
L = length of the pit at top in feet.
Z = side slope
for 1 to 1' use Z 2
for 21/2 to 1 use Z 21/z
NOTE:
Dimensions used must be constructable. check for narrow,
deep pits. For correct results the following must -be true.
w must be greater than 2Zd
L must -be greater than .2Zd

Confinement Building
Pit
TYPICAL VIEW OF A ONE -STAGE LAGOON SYSTEM
Top Width 1.;2
" Pipe (Needs to be adequately
supported)
Settled Top Elevation 5•
Fluid Elevation 52,Q
t
�i SS _ SS:3-_ 1
1 i
,
" TREATMENT
LAGOON
Depth =
Bottom Elevation .38.0
SS ' I'-;_L
0

1 :.?_t � �. I_ ; i., 'l ; . ; 4 : a i � � i !` ; } � � i i j i { � � 1 '11 ; i � j � { �__; � i } � } � ; } , } � �T ;-
7
i- .., l-� _ I I i � ,_t !! ' i ��{� ' C-� i i' i - 'r i .j f...i. _;--- ( 1 1-r ��"i 1 i f i II I
t i
.�i i-i !-'j-'t r f j , ( r t � i' ! I` - - t-' ;--r-; I �_-• i
T T I
U44 I - - —.} T� I +-����� t i. � I �,�,-? � i I..� t E" i i :� T� I�- tt� -
It
7-. k N
t.
all4
C1
:
)it
-T
.j':i�t-, '.:} ;,4i,, ;,,��,rT;�..' 'i#f':;: 'i i—�_I=:(I'ii �_�.'..�.zl_ij i•'.'(;i;;� i.; ....:�...,.
171 -1-1
Ik
t
tf]
r4 -
ITJ
, r
TMI,

r
r
r-
.
'r
1_
' — — .— ._ _----- — _. - — . Y � � { , � - •_. I _� -�.'_ � � �.__- ""- !llllllll .__-- tT .-��j . ti-
V.
0—
�' C
r
1 f �
}
_t
. r
_ r
f
_
1
9 _
-r
t
a
t HAROLD FREDERZCK
` ANIMAL WASTE LAGOON
r SCALE
loor
NTENT OF AGRICULTT-T, F.
'LT
- f rr _
rrL ','71;r.-Sat _ ~� 1._•�
_.�
------ --- ----- t---------
_ , r

T i '1->-
�;-t,-r—,
j i I i:l !
i_I�_I-•�I.
i i i
T 1 i t !
�I
., tf�.! I
'�I
;i:f�Tj 'a
-j�—r�,l
y_l� .f_
r�.l ,.•
� : � r � t-+
� ! , 1 l
T..
1 � ` ii f.��' f
".�_i--;-•-�'�'
� I � ! I , i
_ ? ''"�''�T
i t I.j• -i
j 1'- �.�
1-_ I!
I
T
-f-i,...i_1'�
�.f T_l_I•.i-! i
I ; �. ? l.� i
- , S1 1 r , i
; , f i, , , i
i!,- , ; I i
I
I I L r
•� i r
11{
-F ,•'� ,i '1
� I
I I � i
�4
r j I I�1 i1i
' I i �r
!
_
I .f �: ,- i'-; -
_ r .I i i
� �' I 1 I I
� � � r-• I
I -� I ; I'
-� i !
7-7
I:
4.
1
I
I t
i:
I I
[
�: L.. •I-
I'� }' l i i
-i-i 1 i I
j I�Y I' i
}-� i
I
i �
1 i i � �
i
i..�-
I �.�-_-_
!. _ _
_;i -{•�` 1�
.i_ fs�
111 t}! III
� � �I }'' I I
i►illf �
I -I- -I- I '
Iilf.}-(�i
i- -i t-- i 'I�
; ; li;��l
-1'.. -t - ..•I
f•V-
-ri
? 1
! r�,-i I
r-; ,
-q �-
11
i I
3
I
r}
i � r I
-I-�'
-
-!
�ll�l_.I
��.Ifi.�f- I
- •41{_�:_i-II_�:
,',� , i
I� -��I;
4_�-I'1��1lIII`I
�-;I►►�;
i i�•.
���i.f-�iiili
!,II ;!
,II�lI
��ii.l :
ill i,
��
;,-I5� fll
II ���I
(fi, 'I
i��' 1
��+•!
'
;,, -r�.! -}-
I iC I�}}1
j
I�i� .f?I
I-�;� l�I�
,f�; f-i�
'li.i;•I.l:_�I
�,? iii
II I ��
'lii ;I
I! �+�
.!_ ,I
.li-{� .�_�'
illr �
{•i I � I
f i.l 11 II
'
��, �fil
II flM1
7��1 I li
ill
.fiili�'I
lf��--�'!
i-III
II � ;IIi
f► !!�
tj,
'III.
!•!•lii;tl:
II �;
,li,ii'i,
'a i
{� I �{
i!
I
�-'
'I !
i 1 1 1 I
I' 1•� 1!
•
�
(n s
�.,-�
r
�.{ .�f.i
!
i
i_•i ��
II
;I•Il..r.:i
1
, i�ilril
13
I
I. i
.`..�_I
3 I ,
•�
y � � �
� � j r f 1 i
+ � i � I �I 1 1"1
i j...l
i
{ f `
.`�•�
jji�.
I
n H0��
': T ._ ..;r -.._ �
�• 'l.;
rJ Cj . i. � I
l
; . I i
I , ! . '� �
I
i 1 ? '' '
i; 1
I
-• I
"yam
Y t
i i
I I
i
[i !! II
i
I
-
>
�.,�7
:I -� ►:.;
�
i.i i._E:�.
1_�:.i::'..,_l-.,.�_.
,� I
I � l..i
� I_.i
I
+
IMLtir `1&L.a�I:
»'K6r JJ'�77i:i. S
I4A�iY1::� � x.,]'Y�1-.. �
, _.o.- , �
BiLa' 4 . .j e.` :. ' i
SdJ• .- -� �.� n

- t -� l _i - •��• t � � }_�_ f_i =, ,_ I
��- _, -i i _ _��_ -t � I I
.t_,
�__t. j r-.{. I
'I _ -f t I , _: t •_
-
i-
-�-r—j
.._i :-,�.� `-'
i-{ ,- (� : ;--
- - �t - - -� �_
t-�--;--1_.:
, •(�-(_, I ' -1-,. !_
_3--, - -f ��-T�
, i
t t � ! •,
; , -t r�
t
..
•
,� }� �_ •'( _�: - -j•}- ('�t . #.:t .( �=':=t-t- ','I=
-I_{:' { t !_t t-1-
-�-1 ' T '-� '-=-r
�_
r.-
-,-`-T-` - -�"! :•
�.
��_I i �-'�
: ' ,
;-
rT
_i-i
- -
t
��_ - — _ -� ..,.,-�_ _{_ , �- i f t.l-I
•;=1 � �
t ... - .�- -i-I�
I
_r: .�..�..'_.� .+.
L 1. ,_, � i_1 � �
i
_t -- -
1.1
_I
i r
�
!:.(-I
i i I � ' ;
-,-+-- i t I'I ' j I --; � t I-
..{_-I-1-j-;. t ; C- .I f .t. �_. ; I i..� -t I'-,..; ,
-,- - I: !" I I -I t, 1 i t i I
-i •f i i ;
► i .{ p
.i - {• S
-I'j`�-} { '-I�
-;-,-. , ,
I I --i" --
-i'-f�-, i'i -I t
-i-,-1., I I- I i
-i I -'
1Y1 � I (-I� j
� , i { .
II- I i ! f
� � � i
I 1 I • r
i I
.�
r'- t ; F•I- t !.-j .I
I , ;
r- {-j-t-
I I ! I' �
1_ '
; ! I ,f I
_L.
I.1-- i r ��itom' I
�1 4 I ' ' I � I-i i i-i I !
i
! •' �t j ' � �
; I!; i
' i ; ��
I�!
� - f t . -I
�;
'
, i
_,_L_t. I {I I ,_
j-.
� -{-
.;{`�
j
I--i�i 1
! i
I'ff-ii�� •
t-
!E
�. __t. # _ �`�- � t
I-' �';-il---,�.i
:i...Cl
j,-
�#•• !;
i I
.ill
., ,
I -.-9 I -I '` i l_r
�-
�...I- I-
.I � �_.I
i '.f-- •�� I-
-11-1�I I1 � I ` �
1 i � i
�l a .
_ I _ I _ i '
,
t -7
•t i }"T• �-;-'�
_I �
`f`TL�I lei--r�.-
-
-�--.i� .l- ..I.� rj{ il�� {I
�..�, tl
��
- � 'ji`i
� f+. i
'. I
Ilhji•;�
;,`
_ .{ ..� i � { I , ��_� i i'{ � i �
r 7-1
f-i j' i• {- I I! 11. I ?
I•i � i I ` i
•..T.- .._
I} i .. T;
-� ;.i...} i � l�l
: i ; ;_ I i i i
�'i-• I-��- i-'�I�I
(_ i I i_!. 1 t
j � � I � ! �
-� ;, i!
� f � ' � !
• �- - �_ -_ � - i -� , � � - '-i. • .
�.-�-�t ':� �:: �il:j���k��l,��_-
:�- _ _I � . _
•�- I-_
- . I _i.�_ �..f.
-� -� � __
- _ .:�- #-' �=4 :
t II
C:-}..�: t # �
i � ( , i + { i
i!'I
-� ! I
�,-II
I- •I. � I l- i
f II
-
J
i i
;'
IT
:I
id}
'j
',i
�':;
►.II'!! I
_ {�, tl,ll t;:
1- � { { (� � 'I { 1 � i t E i � � � � { � � � �
;! i,'�,�
i t !
.;�.j I.�
.I , :. � I. j _ I i
.�:I.�
. s i �- i • I --I- I
.'I,,'
, ! i i -' r
r_'
� :
i
CD
.}
FT
4
� �
�.
Ji-�'�,-I �
� F-•I
� { �
�� H � � � o �
i I 'I i i �
I�� I•I i•
i.•:i kk .,.r i
I f } ' ! ,
�
-� I , 1-' �.I.
' � I
i . -
E i t' !
i ; , ,.I i
• '�°.iyr� � �� .�..I_t.ji,
.I; .,.,,.,I
�"I-I,',.I-i
L
_�:.: '�.
', '.
H Ij
oFITt
�t_t,i
i_i-�_i3}
I iI ..�
�
,�
� I� ,-,
-•�--
t
71
#�;
It
�
�� ,,-i-•
I
���,�
�.�i�il�!
i�l".�..!{l
tj_i_ I I- t
1i�'rt
,
j. I �
I
Ii.
�iLL��.i .. �Ya s.,-� � �iFair.:�s" ��N,�l�..
•- }M� .l�L,�{i, �•r., irk
• ~ �' '%?iE1NL�
r
I I � • 4 '..f �:o.
�i � '•' 1
•'S�. ,x�J
,

&r-4 S--io -98-
TABLE
2: Application Agronomics
_Tract
Field
6oil Type Crop
lbs N/Acre
Acres
7450
2
NoA
BH
305.00
15.00
-2
NoA
OSH
50.00
15.00
7450
5
NoA
BH
305.00
5.60
--5
NoA
OSH
50.00
5.60
7450
7
NoA
BH
305.00
4.00
-7
NoA
OSH
50.00
4.00
Total Acres
24.60
Total N Used
BH=Bermuda-hay; OSH=Small grain-Overseeded-Hay
Table 3: Nitrogen Balance
Total N Used 8733.00
Total N Produced 8556.00
Surplus or Deficit-177.00
Lbs N/Field
Month To Apply
4575.00
mar -Oct
750.00
Sept -Mardi
1708.00
Mar -Oct
280.00
Sept -May
1220.00
Mar -Oct
200.00
Sept -May
8733.00
The nitrogen balance shown in table 3 should be equal to of less than 0 to fully utilize the nutrients
produced by the swine from this farm. To produce crops at the RYE'S shown may require the use
of commercial fertilizer to balance fertilization rates in crop rotations. This farm is producing
8556 lbs of nitrogen per year in the waste water and an additional 1339.2
lbs of nitrogen accumulates annually as sludge_ To land apply the liquid portion in an acceptable manner
requires the irrigation system to pump and spread 3448440 total gallons annually.
Table 4: Irtigation Application Rates
Application Rate
Field oil TMe Crop Inches/Hr
2 NoA Bermuda 0.5
-2 NoA Sm Grain 0.4
5 NoA
Bermuda
0.5
-5 NoA
Sm Grain
0.4
7 NoA
Bermuda
0.5
-7 NoA
Sm Grain
0.4
Application Rate
Inches/Applicatton 66C, 8/1•/�
IIX 1.0 1.o Gf8 F"` g
J,r1,0
� l,o
1.0
r, o
The irrigation application rate should not exceed the infiltration rate of the soil at the time of irrigation such
�'" Page 2

WASTE IITILIZATION PLAN �.ti .= � _:1 v ti 0
- `LCiION
REQUIRED SPECIFICATIONS 'AUG' 1 21998
1. Animal waste shall not reach surface waters of the state by u
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
b. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed to soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause dri-ft from
the site during application. No ponding should occur in order
to contrcl odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste small be applied on actively growing crops in such
a manner that tine crop is not covered with waste to a depth that
would in__bit growth. The potential for salt damage from animal
waste should also be considered.

WASTE UTILIZATION PLAN
w
REQUIRED SPECIFICATIONS
10. waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take uo released nutrients. Waste shall not be applied more
than 30 nays prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm -shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips) .
12. Animal waste shall not be applied closer than-100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on other grassed waterways, waste shall be applied at f`
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriat_. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion_, leakage or discharge_

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible fcr obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution -and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the ton and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required -to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when then
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
Years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.