780027_CORRESPONDENCE_20171231

ROY COOPER
cow"w
&9CHAEL S. REGAN
sft-WY
UNDA CULPEPPER
lntrr6A au rw
Murphy Brown, LLC
Farm 7681
PO Box 856
Warsaw, NC 28398
Dear Murphy Brown, LLC:
NORTH CAROLINA
Eadfrwunea od Quaft
October 5, 2018
DEOJDVVR
OCT 10 2OT8
ACROS
FAYE lPALLFR=r.Mkt J
Subject: Certificate of Coverage No. AWS780027
Farm 7681
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
In accordance with your September 4, 2018 Notification of Change of Ownership, we are hereby forwarding
to you this Certificate of Coverage (COC) issued to Murphy Brown, LLC, authorizing the operation of the
subject animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the continued operation of the existing animal waste management system
including, but not limited to, the management and land application of animal waste as specified in the
facility's Certified Animal Waste Management Plan (CAWMP) for Farm 7681, located in Robeson County,
with a swine animal capacity of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean: 2400 Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019 and shall hereby void
Certificate of Coverage Number AWS780027 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
yJ[Sn[(jyi �!
North Carolina Department of Environmental Quality I Division of Water Resources I AEOGW Section
512 North Salisbury Street 11636 Mail Service Center I Raleigh, North Carolina 27699-1636
919.707.9129

Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keepiniz and monitoring conditions in this it. Record keeping forms are unchan ed with this
General Permit. Please continue to use the same record keeping forms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property,
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC
National Weather Service office at (910) 7624289, or by visiting their website at: www.weather_pov/ilm/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at [phone]. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Linda Culpepper
Interim Director, Division of Water Resources
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS780027
North Carolina Department of Environmental Quality I Division of Water Resources IAFOGW Section
512 North Salisbury Street K 1636 Mail Service Center I Raleigh, North Carolina 27699-1636
919.707.9129

DECEIVED
Murphy --Brown,
c JUL 13 209
ON-FAYEii1:IrILLE
Grower(s):
Farm Name:
LIZATION PLAN
Murphy -Brown, LLC
7681
County: Robeson
Farm Ca aci
Farrow to Wean 2400
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
RECEIVED ! DENR / DWQ
Aquifer Protection Sectiotl
Anaerobic Lagoon
>180 days
Irrigation
APR D 6 2009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown_
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft', tons, etc.):
Capacity Type Waste Produced per Animal Total
2400
Farrow to Wean
3212 gaUyr
7,708,800 gal/yr
Farrow to Feeder
4015 gaVyr
gal/yr
Farrow to Finish
10585 gaVyr
gal/yr
Wean to Feeder
223 gal/yr
gal/yr
Feeder to Finish
986 gal/yr
gal/yr
Total 7,708,800 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
2400
Farrow to Wean
5.4 Ibs/yr
12,960 Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 lbs/yr
Ibs/yr
Wean to Feeder
0.48 Ibs/yr
Ibs/yr
Feeder to Finish
2.3 Ibs/yr
Ibs/yr
Total 12,960 lbs!
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 66.6
Total N Required 1st Year: 19777.975
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 19,777.98
Total Nitrogen Produced by Farm: 12,960.00
Nitrogen Balance for Crops: (6,817.98)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1stCrop IstCrop LbsNiAc Lbs N Total WIN,
Acreage Type Code al j
IFT.T. IRT.T.Iffidr.-Mrs
_
3(a) of 8

Reception Area Specifications
Tract Field Irrigated Soll 1st Crop Time to I st Crop ist Crop Lbs NIAc Lbs N Total lbs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs N/Ac Lbs N Total Ilas N
Acreage Typq Code Apply Yield Ibs N/Unit Residual /Ac UtIlized Code 4ppjy____ Yield Ibs NJUnIt Residual /Ac Utilized
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.5 Ibs N / bushel
50 Ibs N / ton
50 Ibs N I ton
1.25 Ibs N I bushel
12 Ibs N / ton
0.12 Ibs N / Ibs lint
50 Ibs N / ton
50 Ibs N / ton
1.3 lbs N I bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5lbsN/cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ Nanimal Farm Total1yr
2400 Farrow to Wean 0.84 2016
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2016 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 10080 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 33 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 80.64 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions_
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
3377 1 A
Ra
B
0.4
1
2A
Ra
B
0.4
1
2B
NoA
B
0.5
1
3A
Ra
B
0.4
1
3B
NoA
B
0.5
1
4A
Ra
B
0.4
1
4B
NoA
B
0.5
1
5A
Ra
B
0.4
1
5B
NoA
B
0.5
1
6A
NoA
B
0.5
1
613
NoA
B
0.5
7A
NoA
B
0.5
1
7B
NoA
B
0.5
1
8A
NoA
B
0.5
1
8B
NoA
B
0.5
1
9A
NoA
B
0.5
1
9B
NoA
B
0.5
1
6 of 8

Additional Comments:
The bermuda in this plan is a combination of hay & graze rates. At least half
the bermuda yield will be removed as hay.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 7681
Owner: Murphy -Brown, LLC
Manager:
Owner]Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and -a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Date
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC.
_
Address: _
2822_Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
(91 Q) 293-3434
Signature:
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, helshe shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing himlher the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land-
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies-
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells_
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

Tar Heel Hatchery, Inc.
7681
PO Box 150
Raeford NC 28376
Dear Tar Heel Hatchery, Inc.:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural'Resources
Alan W. Klimek, P_ E., Director
Division of Water Quality
October 1, 2004 ` ou 15 2004
DENR-FAY,TfE LLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS780027
7681
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Tar
Heel Hatchery, Inc., authorizing the operation of the subject animal waste collection, treatment, storage
and land application system in accordance with General Permit AWG100000. The issuance of this COC
supersedes and terminates your previous COC Number AWS780027 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the 7681, located in Robeson County, with an animal capacity of no greater than an
annual average of 2400 Farrow to Wean swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your
revised forms used for record keeping and reporting.
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
convenience is a package containing the new and
Please pay careful attention to the record kee in
Phone: [phone] FAX: [phone] / Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer— 50% Recycled/10% Post Consumer Paper
Nor thCarolina
Naturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply -wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
Permit File AWS780027
APS Central Files

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWN4P may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 1.80 days prior to expiration.
This COC is not automatically transferable. A namelownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located 'in"a-county-covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
ide K
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
Permit File AWS780027
NDPU Files

of \NArF9 Michael F. Easley, Governor
C� (� William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
cc 7
j r Alan W. Klimek, P. E., Director
❑ 'C
Division of Water Quality
May 1, 2003
Tar Heel Hatchery, Inc.
7681
PO Box 150
Raeford NC 28376
Subject: Certificate of Coverage No. AWS780027
7681
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
Dear Tar Heel Hatchery, Inc.:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date.of-the.Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733,.we are hereby forwarding to you this Certificate of Coverage (COC) issued to Tar
Heel Hatchery, Inc., authorizing the operation of the subject animal waste collection, treatment, storage
and land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS780027 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the 7681, located in Robeson County, with an animal capacity of no greater than an
annual average of 2400 Farrow to Wean swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. /�
Ll
N�aEn R
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1517
Customer Service Center
An Equal opportunity Action Employer
Internet httpJ/h2o.enr_state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

WASTE UTILIZATION PLAN
----------------------
Owners name--:CARROLLS FARM 81 County:ROBESON
Mail Address -:PO 856, WARSAW
Type of production unit ---- :FAR -WEAN
Number of animal units-----: 2400
Type of waste facility -----:Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 14626 tons/year
Amount of plant available N produced by animals-: 12960 lbs./year
Commercial N to apply on planned acreage -------- . 0 lbs./year
Your -animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil Crop
Yield Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type Code
/Acre /Unit
Used
Apply
0
0
0 A
0 1.60
0.0
0
S-APRIL
3377
2
RAINS L
N/A 133.00
20.0
2660
S-APRILd'
3377
2
NORFOLKL
N/A 133.00
34.9
4641.7
S-APRIL
3377
2
NORFOLKC
6.1 50.00
10.0
3050
MAR-OCT
3377
1
NORFOLKC
6.1 50.00
23.5
7167.5
MAR-OCT
-----
-----
----- -----
----- -----
Total
-----
88.4
-----
17519
------
Available Nitrogen
(includes commercial)
12960
Surplus Or
Deficit
-4559
Crop codes: Crop -unit
1 A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat--bu .
Y=Fescue(pasture)-tans
Z=Bermudagrass(pasture)--tons C
Bid
Pit
�v

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
Prepared by: po,y Title: �p Date:
Concurred in by. Date :
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
cam-_ Date:
l Producer
Technical Specialist: d. Date: 6-l--4s
(Copy to producer and copy to case file)

JUL-07-00 01:39 PM RICHMOND CO. CO-OP EMT. 910 997 8257 P.02
' FARM 7681
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the most recent waste
analysis report for your waste management facility.
YOUR WASTE. UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
PAN
Month
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
3377
lA
Ra
B
4.5
37.5/T
6.3
1063
Mar -Sep
3377
2A
Ra
B
4.5
37.5/T
5.6
945
Mar -Sep
3377
213
NOA
B
6.5
37.5/T
1.3
317
Mar -Sep
3377
3A
Ra
B
4.5
37.5/T
5.1
861
Mar -Sep
3377
3B
NoA
B
6.5
37.5/T
4.9
1194
Mar -Sep
3377
4A
Ra
B
4.5
37.5/T
4.7
793
Mar -Sep
3377
4B
NoA
B
6.5
37.5/T
4.6
1121
Mar -Sep
3377
5A
Ra
B
4.5
37.5/T
4.6
776
Mar -Sep
3377
5B
NoA
B
6.5
37.5/T
4.0
975
Mar -Sep
3377
6A
NoA
B
6.5
37.5/T
4.4
1072
Mar -Sep
3377
6B
NOA
B
6.5
37.5/T
2.2
536
Mar -Sep
3377
7A
NoA
B
6.5
37.5/T
4.0
975
Mar -Sep
3377
7B
NoA
B
6.5
37.5/T
3.5
853
Mar -Sep
3377
BA
NoA
B
6.5
37.5/T
2.8
683
Mar -Sep
3377
8B
NoA
B
6.5
37.5/T
3.0
731
Mar -Sep
3377
9A
NoA
B
6.5
37.5/T
3.5
853
Mar -Sep
3377
913
NoA
B
6.5
37.5/T
2.1
512
Mar -Sep
-----------------------------------------------------------------
Total:
66.6
14,260
OVERSEED
Tract
Field
Soil
Crop
Yield
Lbs_ N
Acres
PAN
Month
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
3377
lA
Ra
K
NA
50/A
6.3
315
Oct -Feb
3377
2A
Ra
K
NA
50/A
5.6
280
Oct -Feb
3377
2B
NoA
K
NA
50/A
1.3
65
OCt-Feb
3377
3A
Ra
K
NA
50/A
5.1
255
Oct -Feb
3377
3B
NOA
K
NA
50/A
4.9
245
Oct -Feb
3377
4A
Ra
K
NA
50/A
4.7
235
Oct -Feb
3377
4B
NOA
K
NA
50/A
4.6
230
Oct -Feb
3377
5A
Ra
K
NA
50/A
4.6
230
Oct -Feb
3377
5B
NOA
K
NA
50/A
4.0
200
Oct -Feb
3377
6A
NoA
K
NA
50/A
4.4
220
Oct -Feb
3377
6B
NoA
K
NA
50/A
2.2
110
Oct -Feb
3377
7A
NoA
K
NA
50/A
4.0
200
Oct -Feb
3377
7B
NoA
K
NA
50/A
3.5
175
Oct --Feb
3377
8A
NoA
K
NA
50/A
2.B
140
Oct -Feb
3377
8B
NoA
K
NA
50/A
3.0
150
Oct -Feb
337'/
9A
NOA
K
NA
50/A
3.5
175
Oct -Feb
3377
9B
NOA
K
NA
50/A
2.1
105
Oct -Feb

JUL-07-00 01:40 PM RICHMOND CO- CO-OP EXT_ 910 997 8257
P.03
Overseed Total: 66.6 3,330
Bermuda Pasture Total: 1-4,260
Overall Total: 17,590
Available Nitrogen (includes commercial): 12,960
Surplus or Deficit -4,630
Crop Codeu: Crop -unit
----------------------
B=Bermudagrass(graze)-tons
K=Small grain(graze) -acre
This Waste utilization Plan has been amended by Bert Coffer
(certified Technical Specialist-NCCES) on July, 7, 2000 to
reflect a change from hay to grazing and to include small grain
overseed. The nitrogen rate on the Bermuda has been reduced to
75t of the hay rate in accordance with NRCS requirements.
Nitrogen can be applied to the small grain overseed at the rate
of 50 lbs on N per acre during the indicated application window.
The overseeded small grain must be harvested before seedhead
formation. Fields are designated by irrigation pulls. Acreage
has been determined from pull measurements provided by manager_
Approximately 70% of the total acres are being used for waste
application.
Amended by ----- - - - -- - ----_ _ --- Date- )71
Affiliation: North Caroli Cooperative Ext.
Richmond County Center
123 Caroline St.
Rockingham, NC 28379

z
Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application. It is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre
per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
............_.1....... .. . ........... .... .--- I ...... ... ...... . _ .................. ............-............ ......... -- ........... - ..............
Preview Database Version 1.05 Date Printed: 11-17-2000 Specification Page 1

z
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not be
applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995,
shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
--..... ...-..................................................................... ....................... ....._..... ....... .-..-...... ........ ...................... ..... ............... ..._..-- -..-.....- ....
Preview Database Version 1.05 Date Printed: 11-17-2000 Specification Page 2

z
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when these
.............. ........ _ .................. ­ - .... ...-...... . -. ...................- .--------------................ ........ .............. ............... --.------ --.... ---
Preview Database Version 1.05 Date Printed: 11-17-2000 Specification Page 3

N
metals approach excessive levels. pH shall be adjusted and maintained for
optimum crop production. Soil and waste analysis records shall be kept
for a minimum of five years. Poultry dry waste application records shall
be maintained for a minimum of three years. Waste application records
for all other waste shall be maintained for a minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
-------- --------------------------------- ------------------ - --------------------------- ---------------------- �"----......--------d- --- .......-------------------------------
S" --- - --..-............-- -- -- ---...-------
Preview Database Version 1.05 Date Printed: 11-17-2000 Specification Page 4

Ff 0
State of North Carolina
yeP tment of Environment, Health and Natural Resources
' Division of Water Quality
_d 1`�``i� Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
RFC,, . ' ~ ral Permit - Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the
Division. Please review the information for completeness and make any corrections
which are appropriate. If a question has not been completed by the Division, please
complete as best as possible. Do not leave any question unanswered.
Application Date: - f 7
I. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials i
1. One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed; ` � l V d& M � 14 G
3. Two copies of the Certified Animal Waste ManagementPlan(CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
I. Farms name: 7681
2. Print Land Owner's name: Carroll's Foods Inc - L& r*s gg _Qj me tt . S W!i R } A NA AAA& +� d1kC_L
3. Land Owner's Mailing address: B�-�!L_ „htd X_RS b
City: 6—i Sii W C zip: 3 Laa0 _
Telephone Number: _6+3-mLl-}3 Q i 4 Z.G.3 - 343
4. County where farm is located: Robeson
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): From Red Springs take 71 o Shannon and turn Lt. on SR
1W1 and proceed 1.1 miles and turn Rt- on -SR 1702 (dirt road) and the farm entrance is 0.5 mile on the right.
6. Print Farm Manager's name (if different from Land Owner): 'C
7. Lessee's / integrator's name (if applicable; please circle which type is listed): Carroll's Foods In
78 - 27
FORM: AWO-G-E 2/26/97 Page I of 3

V %
III. OPERATION INFORMATION:
1. Farm No.: J$-27
2. Operation Description: Swine operation
Farrow to Wean
2400 - Certified Design Capacity
Is the above information correct? 1yes; 0 no. If no, correct below using the design capacity of the facility
Tyne of Swine No. of AniMWs T= of Poultry No. of Animals Tyke of CattleAnimals
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow) O
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
0 Layer 0 Dairy
0 Non -Layer 0 Beef
0 Turkey
Other Type of Livestock on the faun: f- () Ai No. of Animals
3. Acreage cleared and available for application: 95.40 ; Required Acreage (as listed in the CAWMP): 88
4. Number of Lagoons: j—_ ; Total Capacity: / 5a 7/ $0 Cubic Feet (ft3)
Number of Storage Ponds: ; Total Capacity:
Cubic Feet (0)
5. Is animal waste being th
applied on any field which has subsurface drains? YES or(please circle one)
6. Are subsurface drains present in the vicinity of or under e Iagoon? YES ors(please circle one)
IV. APPLICANT'S CERTIFICATION:
L�s5Ge
I, _ '' (Land Owner's name listed in question II.2), attest that
this application for C_JA "Q(1'— IbA riV1A IR _(Farm name listed in question H.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as incomplete.
Signature
V . MANAGER
CATION: (complete only if different from the Land Owner)
L tf a l t 1 19 '�S _ I (Manager's name listed in question II.6), attest that this
application for �w�-.0l rS P-A M� [ _ (Farm name listed in question II.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature _�' _ __ . Date _ 1-- 7 97
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO-G-E 2/26/97 Page 2 of 3

r
CARROLL'S FOODS, INC._
P. O. Drawer 856 rf '
WARSAW, NORTH CAROLINA 28398
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN
FARM NAME OR NUMBER
FARM DESCRIPTION
LOCATION
COMPANY FARM
CONTRACT GROWER
C Amotl'S PIAIIE V"L ti bsr
SHANNON 2400 MULTIPLIER
2400 FARROW TO WEAN
SHANNON, N.C.
YES
NO
k
i

07/10/97 THU 14:16 FAX [phone] CARROLL-S FOODS CARROLL'S WARSAW Z 001
JUL 10 '97 02'13PM
MASTS PLAN CwATir=CAT=0X FOR Z=S2== pS--aLOTS
Please retasa the completed fors to the Di%risioa of. ftvi--oamantal XaaaQamaat at
the add=us• oa the ravarse side of Chia tars,
��- Name of farm iPleasa print)
:Mailing Address:_ 0,,6. dwA&
LLJ..�" Jj C. -2a.vm _ Phone No.:
Councyao£ arm) o�v
Fam location: Latitude: and Longitude 122 (required) Also.
please attach a copy of a county road asap with location identified.
''-ype of operation (swine:" layer, daily, etc.) :
Design capacity (number of animalls) : N
Average -size of operation (12 month population avg.):
Average acreages needed for land application of waste (acres):
now asamama awaam=rrisariaa3srrram
Tachaical Speciaxiat Cartifiaatioa
As a technical specialist designated by. the North Carolina Soil and Water
Conservation Cossmsission pursuant to 1SA NCAC 6F ;0005, 1 certify that the
exi9ting animal waste management system for the farm named above has an animal
wasta waiiaseaLcrit plan that maeta t.''iC a=.:-_ti-n --_d Wince-manc_ ==a_ndr—r s and
specifications of the Division of Environmental Management and the USDA -Soil
Conservation service and/or the North Carolina Soil and dater Conservation_
Commission pursuant to I5A NCAC 2H.0217 and 15A NCAC 6P .0001-.0005. The
following elements and their corresponding minim usss criteria have been verified
by toe or other designated' technical spec: lusts and are included in the plan as
applicable: minimum separations -(buffers) ; adequate Quantity and amount of lased
fo= waste utilization (or° use of third partgr) ; access or ownership of proper
waste application equipment: schedule for timing of applications; application
sates; loading rates; and the control of the discharge of pollutants from
starmwacer runoff events less severe than the 25 year, 24-haur sterns.
Nam of Tachnica.1 specialist .(Please Print) : fdWAeo L 046-rdy .
Affiliation (Agency):
Add --ass; _ '00.9 ca l `.�- • /i� �8-�7 - _ phone
Signature:__ Z Rom`- _ Date:.��-
_ asrsawrswsawwl waaawawreaaar eestama ear=* ea rr sl aaawe iwarai wan ammmim ==zis A.S
Cwaar/!linagar aQraasssent -
I (we) understand the operation and maintenance procedures established in the
approved animal waste managemenc plat for the farm named above and will i=plemen=
chase procedures- I (we) know that any expansion to the existing design capacity
or the -waste treatme.1c aiid scfcrage system or cos7.struction of new facilities will
require a new certification to be submitted to the Division of Environmental
Management before the new°animais are stacked- I (we) also understand that there
must be no discharge of ai itQal waste from this system to surface waters of the
slate either directly through a maxi -made conveyance or r-hrough runuti rXOSII 4
storm event less severe than: the 25-year, 24-hour storm. The approved plan will
be filed at the farm and at the. office of the local Soil and water conservation
District.
Name of Lwn a.: (Please Print) : T �e7)uFlZ,Sl�tA
Signature: Dace:
- R Cf� 7M,ER71�t0 - t
Name of XasaQ if differen= from owner (please print) : l'
Signalt%;re: .. a-^� � .. - Date: -
.tote: A ch a in land owriership.requires notification or a new cart-fication
(i= the approved plan is changed) within 60 days of a title transfer.'
Doi RISE Get . e AC_#

TABLE OF CONTENTS
+Vicinity Map .............................................. 1
-ASCS Field Map ............................................ 2
Soils Map ........ ......................................... 3
Soil Investigation Worksheet 4
✓Waste Treatment Plan ...................................... 5
Taste Utilization Plan .................................... 6
Operation and Maintenance Plan ............................ 7
✓Construction Specifications For Lagoon .................... 8
-'Seeding Plan (Farm Site) .................................. 9
-Computer Drawing of Existing Ground .......................10
-Existing Elevations.......................................11
-Lagoon Cross Section Diagram..............................12
Computer Drawing of Proposed Lagoon & Building Pad ........13
Site Balance Report.......................................14
-tomputer Drawing - All Data - Proposed ....................15
✓Computer Drawing - Contour Lines ..........................16
Computer Drawing - Sloping Lines ..........................17
+Computer Drawing - Blow-up of Lagoon Corner ...............18
vBuilding Pad Elevations...................................19
wComputer Gross Section - Existing - Proposed - Balanced ...20
Facility Overlaid on Existing Topo Map ....................21

�1 k
1L k
.ynt�a�
t .-'11 G
puck
own by many local
mown being ground
ern marmot
ember of the widely
and is actually a big,
g member of the
familv. It seems
ate small -tailed,
iggir.y woodchuck
ender, tree -climbing
we remember also
Paphers, and ground
easier to understand.
onally reminds us
rel ancestry by dim-
s or to keep a better
ritory.
called typical hiber-
is. When the tam -
in late fall, about
chuck, fat as a
awls down to his
the hole in after him
the passage to the
nr the winter.
bemation, nothing is
eived to be converted
jdation of the blood
e contrary, the lungs
sere is an occasional
elation of breath -but
oxygen in the lungs
n by the slow heart
of gases. /
, woodchucks do %
viv, deep promp-
;ec, , to watch for /�, x•
v or earth as the case
become restless and
-equently during late
inally coming out to 1
; gone and tender
ields- S
O
P
J
P
SM
LM
W
�a
UK va
I
d�
1
,.
bw
�.Am

1955 ooa FEtT
ROBESON COUNTY, NORTH CAROLINA — SHEET NUMBER 5
POB
t .• T s-� �r't`.��'�q 5; � '1 � �'F>i• e`s1�r WaB .. � ...
°
;rf}�F§+•`'.:.~ 1 -ice _f Y s z ' T
Wks
�rY r °` r - -� "•���a.- -.:ss�i T- ': 1rr �f `'.+. �I No
4_s PS 'ay,:I WkB:' GoA
vti ��`t y •`-.`. d. Wa6,* �r NoA
B VTrl P°B
WksCL
r�M/a :. was
Ly
K i ,
Mc L� NoA Po8 s'kA'y" "izti Em `� 4s
GoA Y ' I
N°A' VYk$ Ra , Wk6
._. Mc
Wk$ WkB
y•
A 7hr "�•
Po
GaA Ra Wa8 .g7u31{ .t JFs�i
WkB
Wks
No t Wk
mc
Mc Ly
WkB, '4 ,r.• GoA' .�?:•'�-y .
'r r Mc
S' ly Y:• ^�yl '
Me' * Wks- '� .e
Wa8 NoA `�a�r4�y . N
.r. .. Wa8 • -r Me
-.: f., NoA .y^^. '✓�'.+l,::rs� xc..�-
9$ ' `r G ,r43 j ~� r�•:_ '
-•-.F '< .;;^'� �r- K •rk. � *} GoA
NoA, s . 131 ` NoA 5y;.
tr JJ.. h f NoA`
Go
K
A
a `Shannon- , . txr �Ra,
.. �•- GoA .-..t�:�
Was"+ ti s t GoA rJ GoA Ra r �' '�•� GOA t
vti�y'� .( NoAy GdA'z'
4 > NoA �. PA
Wa8Ra
s - • Ra' No s Go_Ar
Was m r ti Ra'
,. NoA NoA - .-�� s :�.
lac �JT —w I , Ly'
Wag 1 GA Ra \ GoA
1 Ly Ra
Ly
NoA Wa8 Ly Ly L
_ , Ra y

SCS-ENG•S3111 U. S. OEPARTMTNT OF AGRICULTURE
a". 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
~•
WOODLAND-ACRESWATERSHED AREA MEASUREMENTS
CROPLAND -ACRES PASTURE ACRES.
•
SKETCH OF • •SED POND SHOWINGBORINGS
■■■■NEE■■■■■
■■■NON■■■■■■■
■■■■■■
■■■■
■■■
■■NMN■■■
N■
1"
NONE
■■■
■■■N■■N■
■■
NOON-MEEN
!■■■■■EMENN
■■
■NON■■■ON■■N■Nl�i�1NEN
NOON■
■■■■■■■■■■■■■�■■�■■
NOON■■■
■■■
■■■■■■■■■■■■®■
■■NEON■
■■■
::FINOONN■Oli■■■E®
■■N■NE■NEE■E■■N■■■N■■E■■■■
■■■■■■E■ENE■E■N■E■ME
NONE■
■N
...
E�l�Fr'�N■■I■EN■■■■
NONE■
-GNtMB PROFILE 4
©
rJ
iEEIZEAT3
sinrXI
P3i©1
M 13
M
►MM■R■
00
Elie
■
■
■!n!■
m!■
■��!�
■!■°�!�!■
BORxNGs mA.DESIGNATURE TITLE

o-f
i -Z
z-3
3-4
u-s
S�G
7- g
8-9
q-/t
TYPES OF MATERIAL ENCOUNTERED IN BORINGS
(Use one of systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATION
GW- Well graded gravels; gravel, sand mix
g- gravel
GP -Poorly graded gravels
s-sand
GM -Silty gravels: gravel -sand -silt mix
vfs -very fine sand
GC -Clayey gravels; gravel -sand -clay mix
sl-sandy loam
SW -Well graded sands: sand -gravel mix
fsl - fine sandy loam
SP - Poorly graded sands
1- loam
SM-Silty sand
gl-gravelly loom '
SC -Clayey sands; sand -clay mixtures
si-silt
ML - Silts; silty, v, fine sands-, sandy or clayey silt
sil - silt loam
CL- Clays of love to medium plasticity
cl-clay loam
CH -Inorganic clays of high plasticity
sicl- silty clay loam
MH -Elastic silts
scl -sandy clay loam
OL - Organic silts and silty clays, low plasticity
sic -silty clay
OH -Organic clays. medium to high plasticity
c-clay
1. Suitable material for embankment is available QYe• Na (fndia¢f. ether. (".w a„ !h. fkek-A an
roans. ddl
J /
RF14ARKS:�/Q See Y/�� J' `i/h,4 e4 4r— i�/� �i (ail 44 fq 1)1�flT his
! 3 6
Z Explain hazards requiring special attention in design (s epta.. w.Ina..,o,k eftj
GENERAL REMARKS:
•
U
26
28
27
29
29
301131
1321133
1 34
351
36
137
38 1391140
41
42
43
44
45
46
47148149
60
61
c
c
II
Sc
sc
Sc
Sc
Sc
SM
Sp
7 /ter

Operator:CARROLL'S FOODS INCounty: ROBESON Date: 07/21/92
Distance to nearest residence (other than owner): 2000.0 feet
1. STEADY STATE LIVE WEIGHT
0
sows
(farrow to finish)
x 1417
lbs.
= 0
lbs
0
sows
(farrow to feeder)
x 522
lbs.
= 0
lbs
0
head
(finishing only)
x 235
lbs.
= 0
lbs
2400
sows
(farrow to wean)
x 433
lbs.
= 1039200
lbs
0
head
(wean to feeder)
x 30
lbs.
= 0
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 1039200 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 1039200 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= I CF/lb. SSLW
Volume = 1039200 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner requests no sludge storage_
Sludge will be removed as needed."
. TOTAL DESIGN VOLUME
AutahgL-- Lk--H,5*b, Auelk A,O_t wjd+%
Inside top length 460.0 feet ; Inside top width 410.0 feet
Top of dike at elevation 46.3 feet
Freeboard 1.0 feet ; Side slopes 2.5 : I (Inside lagoon)
Total design lagoon liquid level at elevation 45.3 feet
Bottom of lagoon elevation 36.0 feet
Seasonal high water table elevation 40.0 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 455.0 405.0 9.3
AREA OF TOP
LENGTH * WIDTH =
455.0 405.0
AREA OF BOTTOM
LENGTH * WIDTH =
408.8 358.8
184275.0 (AREA OF TOP)
146639.1 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
431.9 381.9 659689.1 (AREA OF MIDSECTION * 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMU * DEPTH/6
184275.0 659689.1 146639.1 1.5

VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 1527180 CU. FT.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
460.0 410.0 188600.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 188600.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 1039200 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 253779 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 110016.7 cubic feet

50. Volume of 2S year - 24 hour storm
Volume - 7.0 inches / 12 inches per foot * DA
Volume - 110016.7 cubic feet
TOTAL REQUIRED
TEMPORARY STORAGE
5A.
253779
cubic
feet
5B.
0
cubic
feet
Sc.
110017
cubic
feet
{ SD.
110017
cubic
feet
w TOTAL
473812
cubic
feet
6. SUMMARY
Total required volume 1S13012 cubic feet
Total design volume avail. 1S27180 cubic feet''
Min. req. treatment volume plus sludge accumulation
1039200 cubic feet
At elev. 42.6 feet ; Volume is 1053794 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 1417163 cubic feet
uV-?':
At elev. 44.6 feet ; Volume is 1399238 cubic feet (start pumping)
y�• 2-
Seasonal high water table elevation 4e.8 feet
7. DESIGNED BY: PROVED BY:..J�t'�-'��-1
DATE: .a 1 ���- DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
C

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 44.6 as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation 42.6 or before, fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
S. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Owners name--:CARROLL'S FOODS, INC. County:ROBESON
Mail Address -:PO BOX 856 WARSAW, NC
Type of production unit ---- :FAR -WEAN
Type of waste facility ----- :Anaerobic Lagoon
Your animal waste management facility has been designed for a
given storage capacity. When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in,runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
Amount of Waste Produced Per Year:
----------------------------------
2400 animals x 6.1 tons waste/animal/yr= 14626 tons
total waste

Page- 2
hmount of Plant Availablq Nitrogen Produced Per Year:
-----------------------------------------------------
2400 animals x S.40 lbs. N/animat/year - 12960 lbs./yr
Available N
Applying the above amount of waste is a big job. You should
plan time and have appropriate equipment to apply the waste in
a timely manner. Your facility is designed for 180 days of
storage. Therefore, it Will need to be pumped every 6
months.
Tract Field Soil Crop Yield Lbs. N Acres Lbs. N Month to
No. No. Type Code per Ac. Used Apply
e-9r T3377 2 NoA,r 4 5 Tons 275 �9�df7: MAR--AUG
T3377 1 NoA 4 S Tons 2754- 23.6_64 4 1_MAR-AUG
&410
V,
Total _-94E F5��QZ3 �f
Available Nitrogen 12
Surplus or Deficit 4-
-26d5 -
Crop codes: 1-Cereal graint 2-Corn; 3-Fescue= 4-Range Cr. Bermuda
S-Control Crazed Bermuda; 6-llayland Bermuda
Narrative of operations
Call the soil and Water Conservation District office after you
receive waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
waste.
Prepared bys
Name Title O e
Concurred in byt_�=
producer Date
(Copy to producer and copy to case file)

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut-off Trench:
---------------
A cut-off trench (when specified) shall be installed as shown in
the plans.
Construction:
-------------
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall.not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled and
compacted with a suitable material (ie-CL,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction_

SEEDING RECOMMENDATIONS
-----------------------
AREA TO BE SEEDED: 4.0 ACRES
USE THE SEED MIXTURE INDICATED:
O LBS. FESCUE GRASS S 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. 'PENSACOLA' BAHIA GRASS S 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
32 LBS. HULLED BERMUDA GRASS 5 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 To JULY 31
0 LBS. RYE GRAIN S 30 LBS./ACRE (NURSERY FOR FESCUE)
0 LBS. RYE GRASS S 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
4000 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
8 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
400 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
I. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

.00
48. 40
.40
X 44.00 X43.40 )K43.30 )K43.440) .40
46.00 46.20
)K44.80 X44.10 * 43. 70 )K43.20 )K43.80 )K45.60 X47.20 )K46.70 )E 6.20
46. 00)K 46. 06 X 44.70 )K44.40 )K 44. 10 X45.68 )K 46.60 )K46.80 )K45.40 )E 16W}A30
44 4, 70 X 46. 60 )K45.80 )K46.00 X46.20 )K46.10 X44.80 )K44.40 )K44.40 X
44.00
44.00 )K46.80 )K46.50 )K45.40 CIE 44. 80 )K43.70 X43.30 )K42.80 )K
44.70
ilE as . B A 31E 43.70 X43.40 31E 43. 10 # 42. BA X 4 0
42.90
0
31E 43. 10 )K42.80 # 42. 50 X 42. 60 42.8
.70
43.SO
X 42. 40 )K 42. 00 A . 10
42.40
DaWligh P 42.10
Plat of all data for the surface:
Existing
Project: SHANNON 2400 FAR/WEAN NPD
Drawing: SHT 1
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitework

Orientation: -46.0
48.0
47.0
46.0
45.0
44.0
43.0
42.0
Lower LeFt
Z Magnification: 62.0
30 Mesh Surface
Existing
Project: SHANNON 2400 FAR/WEAN NPD
Drawing: SH7 i
Number:
Location:
Bid Date:
Engineer:
Owner:
EBtimator:
Inclination: 20.0
3D Mesh Surface
Prepared bW: using Sitework

I,I4i::u�I -2'4L)lj 1-ki):.)j r VwEFtI H *U
s�R btiNig
>>iFIN�w���di'
}IiVERT DF-
1 G Ifs L. V 1P- D N S S
L Acs o 25 r van
\)LL PLU& D6sIGN
B0`TTONr Or- Sump'
�L6U• 'i .3b
To P viIwrH�
TOM bts IG R
SVKq t
jig sL»Pr�
130I II
�0'?PoaT
7 TNnF-t4T
Lnc no ni ,as: ,
tee,tH
13OTT 0VIA E L-E
I�yV��T or- t 1& Cit of
u4.ss
senLtvp TOP OP
b.15 wKa eIE V,
�t,A�kNctLh

�,kY�'�N r-W+R/ Wt-N1rq N tru
l
F1.t_AAP��'t
B,vjtu 4N��
+0P OF ORD F- L E Z5
i: 4� U, 4 5• b6
�a E
TyrpIC-A VpNP-� s
�v�.t< PLu6 ��sti�N
BD-�Tp+^n Os: svVr P
eLr--u. N 6. a
To P �prt tip_
ToT fi 1 Dps IG l
5�4�AG�
�.LEVys•��
° %. s�vpa
J*r
Su�POa�
L.+C900�
Oe�'tH
S30TT0VA, E(-IE U.
as'
y4, ss
5VT'r�c-p To? o F
L16.�6 U �K& elt V.
,s,3•0 . 1
l$ tq�„ 41 iV C ►�. A

I11s NI•lUk d.�4 u() v= Ak! Vj�-`A1s N k4L)
F h z:�ntN 1 ryG
. utI sz,
PI CAL VI �-WOF A m�,(E GjflG�
LAG CON SY5T E M
`ToP Vj1pYH a]' 1
A_ 6 S LL
x y 0 o ,
�v�PoRT
$ " PIPE
(30TTOM EL E✓N-i 10 l
1NY kT ot+ PINS
F LE VATI OI,I
7ZZPr�L a e5 IG Kk
1 St! TI E0
TdD P / ff L -E� VAT %0 Kl y b .). 5
-TRf-A7MIrSIT[
LA6 4athl
.D f }-I H � ,.15
Zb. v
BtAI+AWcLt o

s� M40t a-4DO 'PAk/ WiLtAN K� D
� a, + *a ,{
�i{lRkflWt}�9
oNFll�l F-M) nN-T
bulLOiN65
API CAL VI r--WOF A cvN(rz GTAGE
L. AG ooNI SYSTEM
ZLEVATCDI`I uy.se
T&TAL u E5 IO M
-To P WID-rH 5 E'TTZE
i ToP/aI rVAT►vN a5
N �� �15o k 3op
-SIT .�.IEVI�TIDN
Li�, �G
PI PE
aa-rTaM E L E VA-1 jor4
-rRF- AT M Ir WTI
I -AG vvrl
-p wl H z ?.
&6,D
a
- 0 ,
$ AL�Nc F-�

Orientation: -46.0
52.0
60.0
46.0
46.0
44.0
42.0
40.0
36.0
36.0
34.0
Lower Left
Z Maonification: 21.1
30 Mesh Surface
Balanced
Project: SHANNON 2400 FAR/WEAN NPD
Drawing: SHT 1
Number:
Location:
Bid Date:
Engineer;
Owner:
Estimator:
Prepared bW: using Sitework
Inclination: 20.0
3D Mesh Surface

Fill i 'nk/swell percent: 20.00 Cut shrink/owe zercents 0.00
Iterating to balancing within 10.0 cubic yards...
delta
Cut Fill
CUT - FILL
0.00
43745.09 65082.54
-21337.45
--1.08
50094.37 47185.12
2909.25
-0.95
49316.38 49313.22
3.16
-0.95
15.571 49315.45
0.13
I.buJ tCLt'44-493
-
Lower "Proposed" by
0.95 feet.n
l`
New surface called
"Balanced" has been created.
a aaaaaRRRRRVRaaacaRnneraanananaenalva
Project! SHANNON 2400 FAR/WEAN NPD
Drawings SHT 1
Number:
Location:
Bid Dare:
Engineer:
Owner:
Estimators
.
=aaaraaaaaaesaaaaaaaaaaaaaaaaaaaaaaa
Prepared by: using Sitework
ncnnc=aaaaaaaaaaaaaaaaasaamaaaaaaaam
t

Row Crop Gun Cart with galvanized body Is
standard equipment. An optional Low Profile
Gun Cart is also available.
Low Profile Gun Cart (Galvanized Body).
Performance Information
Model
FLow
INLET
SPRINKLER
•WMM
WE IM
ACREsW1
(G.P.M.)
PRESSURE
PRESSURE
WMTH
LENGrII
1 INCH -IN
(P.S.L)
(P.S.L)
(FL)
(Ft. - MA)g
5 DAYS
T40A
280
104
70
240
1370
. . 72
With
..300
107
70
250
1375
77
iLSO
NELSON
0
116
70
260
1380
g0
Sprinkler
_
400
126
70
270
1395
:1021..
450
138
: 70
: 280
1390
'115
480
_.
145
70
290 .:
_
.1395
23
T37A
-:?220
99
-.70
;220
_4160 "_.
° ;, 6
With
.
:250
104
70
23a
-116S
NELSON300
_113
70
245
1173 _ ...':
77
SR150R
. Sprinkler
350
'... ;
125 .
70 -
. 250
:i175
_ 90 .:
-' ..r.
"
400
:..13'r
70
255.. _t17s
. -''.
sZoz ;r
;1180
.
T30A~�
180 _
104
`:6D •r:
"Z10
;ram—
vim:
20Q
t1�:
=60 "
;= 215
sso°R
220
z9
_
,70
Y2xs„y09sss
Sprinkler"
�240
�3T
r 70 .rx
. ' 230
1095
6i , f
O
._1098
' Recommended width is based on 70% of the wetted diameter
t,Tade m U S A
Specifications
Model' _
'740A
---',T37A
130A
Number of AWsz
2
t
1
: PE Tube I.D. On.)
4.o
3.7
"3A
PE Tube Length (fL)
1250
1050
1000
. Drywalght Qbs.)
9100
' 7500
4300
weight with water Qbs.)
Ilwa0
12360
7270
Speed Range QnsJmins.)
10-40
10-60
: 740
Mrs Slan
11Lx15
12.SU15
11Lx15
Shipping dim-: (ft. In.)
Length
10-0
15.9
134
= 'Nlldth
" 9-10 =
9-3
;- 7.5
Height
12.6
11-10
10-0
• Note: T40Alr37A w/o wheels = 6:3 wide
Polyethelene Tube - Only PE tube designed and constructed
for the constant coiling and dragging is considered for use on
Ag-Rain Water -Reels. The tubing is backed by a 5-year
pro -rated warranty.
PE Tube Repair - A simple "screw -in" mender is available for
repairing the PE tube should it become damaged for any
reason.
PE Tube Lengths - Longer tube lengthes are available for all
models. Performance and delivery information available on
request.
Cckztah-oga.¢f9,vt�inn
A'G�01 ''� .
600 S. Schrader Ave., P.O. Box 290, Havana, IL 62644
Phone [phone] FAX [phone]
Standard Features
Radial inflow Turbine - The heart of the drive system.
This extremely efficient motor delivers quiet, smooth,
continuous power. All the water you pump goes through
the sprinkler. None of the water is wasted as in bellows
or piston drives.
Automatic Shutdown for the turbine motor.
Heavy Duty Chassis and frame.
Speedometer.
Pressure Gauge.
Infinitely Adjustable Speed Ranges.
Speed Compensator.
Miswrap Safety Stop.
PTO Rewind and Drive Shaft.
Gun Cart with adjustable wheel width.
Hose Guide to insure proper packing of hose.
Turntable.
Nelson Slow Reverse Gun with ring nozzles.
Lifting Mechanism for gun cart.
Stabilizer Legs - Heavy duty, crank down style.
4" Supply Hose x 30 ft. long with male ring lock
coupler.
Fixed Spool Brake requires no on/off adjustments.
Foolproof Cluth - Turbine and PTO drtves cannot be
engaged simultaneously.
Because of Cor4u =q p = 1lr,^,rT eme m Dm= of mamnes m Cns lealel may riot Lk KoerIDCai W cwrerd Pro&_x cn Pa peAorr..an utwrtaxn lrl Ns :ea.'.el 6 basso on ICES coracleo lnCa a (;a'bW& set m =�mbole. AGuel 66d per-
%V-ama may vary hom C+s aaca on vaaVe arryms=Ces of 9me. dace. �a,ler. Mynan F4geme""otter Iatton Sc�cawm arc W1 se aLiml Io d-wO --*A ruLce.
GK 94p6WR-0 Pnrmpl MUSA

WASTE UM 7ATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any discharge of waste which reaches surface water is
prohibited
2. There must be documentation in the design folder that the producer either owns or has a notarized aft for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of
waste, he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the owner of the facility ility to secure
an update of the Waste Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type,
available mo=we, historical data, climate conditions, and level of management, unless there are regulations that
restrict the rate of application for other nutrients. Actual yields may be used in lieu of realistic yield tables at the
discretion of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is
eroding at more than 5 tons but less than 10 tons per acre per year providing grass filter strips are installed where
runoff leaves the field (See FOTG Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when there
is danger of drift from the irrigation field.
6. When animas waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled
cropland When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur
in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen_
9. Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to
depth that would prohibit growth. The potential for salt damage from animal waste should also be considered_
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for leaching.
Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking
dormancy..
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer perimeter of the
land area onto which waste is applied from a lagoon that is a component of a swine farce shall be at least 50 feet from
any residential property boundary and from any perennial stream or river other than an irrigation ditch or canal.
MRCS, NC
JUNE, 1996

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ -I }
EMERGENCY MANAGEMENT SYSTEM 1 n - 1 - t3 %
SWCD _ 9, l _D - %)� 3(; Solt
NRCS - 3 -5 V
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not watt until wastes reach surface waters or
leave your property to consider that you have a problem. You should snake every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate-
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. incorporate waste to reduce runoff.
d- Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a- Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irngation pump.
c_ Make sure no siphon occurs.
d_ Stop all flows in the house, flush systems. or solid separators.
December 18, 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger {either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - After hours, emergency number. 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation"
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and Iocal NRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name: tAA,kniI `S IMG `i . - Le-sl't S 5
b. Contractors Address: 3 c 5
c" Contractors Phone: 4
2 December 18, 1996

North Carolina Agricultural Extension Service
Agri -Waste Management
Biological and Agricultural Engineering North Carolina State University
LIVESTOCK WASTE SAMPLING, ANALYSIS AND CALCULATION
OF LAND APPLICATION RATES
James C. Barker*
I. SAMPLE COLLECTION
A. Semi -Solid Lot Manure
i. Scraped directly from lot into spreader
a) From loaded spreader, collect about 2 Ibs of manure from different locations using
nonmetallic collectors.
ii. From Storage
a) Collect about 21bs of manure from under the surface crust avoiding bedding materials and
using nonmetallic collectors
B. Liquid Manure Slurry
i. Under -slotted -floor pit
a) Extend a'/2" nonmetallic conduit open on both ends into manure to pit floor.
b) Seal upper end of conduit (e.g., by placing a thumb over end of conduit) trapping manure
that has entered lower end, remove and empty slurry into plastic bucket or nonmetallic
container.
c) Take subsamples from 5 or more locations or at least 1 quart.
d) Mix and add about Y. pint to nonmetallic sample container.
ii. Exterior storage basin or tank
a) Make sure manure has been well mixed «ith a liquid manure chopper -agitator
pump or propeller agitator.
b) Take subsamples from about 5 pit locations, from agitator pump or from manure spreader
and place in a plastic bucket.
Professor and Extension Specialist, Biological and Agricultural Engineering
Department, North Carolina State University. Raleigh. NC

11. SAMPLE PREPARATION AND TRANSFER
A. Place sample into an expandable container that can be sealed. Rinse residues from container with
clean water but do not use disinfectants, soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as newspaper, box or package with
wrapping paper, and tape-
E. Commercial sample containers and mailers are also available, Contacts:
1. A& L Eastern Agricultural Lab, Inc.
7621 Whitepine Road
Richmond, VA 23237
Ph: [phone]
2. Fisher Scientific Co.
3315 Winton Road
Raleigh, NC 27604
Ph: [phone]
3. Polyfoam Packers Corp.
2320 S. Foster Avenue
Wheeling, II, 60090
Ph: [phone]
4. NASCO
901 Janesville Avenue
Fort Atkinson, WI 53538
Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
G. The NCDA provides this service for North Carolina residents.
i. Address: North Carolina Department of Agriculture
ii. Agronomic Division
Plant/WastelSolution Advisory Section
Blue Ridge Road Center
R O- Box 27647
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell
iii. Forward $4 along with the sample
iv. Include the following identification information with sample:
a) Livestock species (dairy, swine, turkey, etc.)
b) Livestock usage (swine -nursery, finishing, turkey -breeders, brooderhouse, grower, number
flocks grown on litter-, etc.)
c) Waste type (dairy -lot scraped manure, liquid slurry; sNirine-pit slurry, lagoon liquid, sludge;
broiler -house litter, stockpile)
v. Routine analyses performed on all samples: N, P, K, Ca. Mg, Ma, S, Fe, Mn, Zn, Cu, B
vi. Additional analyses performed upon request: DM, Mo, U, Ni, Pb

r .
Insect Control Checklist for Animal Operations
Source Cause 13MPs to Control Insects Site Specific practices
Flush Gutters • Accumulation of solids O Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
© Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
}excessive Vegetative • Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed Spillage 13 Design, operate and maintain feed systems (e.g..
bunkers and troughs) to minimize the
accumulation of decaying wastage.
0 Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
dyring winter).
Feed Storage • Accumulations of feed residues (a Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for Brewer's grain and similar high
moisture grain products),
d"lnspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AN'' - - November 11, 1996, Page I

Source Cause BMPs to Control insects. Site Specific Practices -
Animal Holding Areas • A
of animal wastes
and feed wastage
IT Eliminate low areas that trap moisture along
fences and other locations where waste
accumulates and disturbance by animals is
inimal.
Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
Dry Manure handling • Accumulations of animal wastes ❑ Remove spillage on a routine basis (e.g., 7 - 10
Systems day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
❑ Provide for adequate drainage around manure
stockpiles.
0 Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
AMV' ''ovember It, 1996, Page 2

Source Cause BMPs to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level •
Lagoon surfaces • Volatile gas emissions;
• Biological mixing;
• Agitation
fA'�Proper lagoon liquid capacity;
0- Correct lagoon startup procedures;
{ inimum surface area -to -volume ratio;
M-/MMinimum agitation when,pumping;
❑ Mechanical aeration;
❑ Proven biological additives
Irrigation sprinkler a High pressure agitation; M- Irrigate on dry days with little or no wind;
nozzles a Wind drift EY"Minimum recommended operating pressure;
0-1"Pump intake near lagoon liquid surface;
Cl Pump from second -stage lagoon
Storage tank or basin 0 Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface a Mixing while filling; ❑ Tank covers;
• Agitation when emptying O Basin surface mats of solids;
❑
Proven biological additives or oxidants
Settling basin surface
Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
• Mixing while filling;
level;
• Agitation when emptying.
C1
Remove settled solids regularly
Manure, slurry or sludge
• Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader outlets
Volatile gas cmissions
17
Wash residual manure from spreader after use;
❑
Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
0
Soil incorporation within 48 hrs.;
surfaces
❑ Spread in thin uniform layers for rapid drying;
❑ Proven biological additives or oxidants
Dead animals • Carcass decomposition Proper disposition of carcasses
Dead animal disposal • Carcass decomposition ❑ Complete covering of carcasses in burial pits;
pits ❑ proper location/consiruction of disposal pits
Incinerators • Incomplete combustion ❑ Secondary slack burners
A? " C' - November 11, 1996, Page 4

Source Cause BMPs to Minimize Odor Site Specific Practices '
Standing water around • Improper drainage; attrade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads Farm access road maintenance
public roads from farm
access
Additional Information:
Available From:
Swine Manure Management; 0200 Rule/BMP Packet
NCSU, County Extension Center
Swine Production farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88
NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33
NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual
NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PROW, 1995 Conference Proceedings
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
/ stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996