090159_CORRESPONDENCE_20171231

r
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
May 10, 1999
Paul McKeithan
Paul McKeithan Farm
PO Box 1313
Bladenboro NC 28320
E10 •
1�
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RE-50URGES
Subject: Certificate of Coverage No. AWS090159
Paul McKeithan Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Paul McKeithan:
In accordance with your application received on March 12, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Paul McKeithan, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG 100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Paul McKeithan Farm, located in Bladen County, with an
animal capacity of no greater than 6080 Wean to Feeder and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS090159
Paul McKeithan Farm
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
RECEIVED Sincerely, -----
MAY 1 7 1499
FAY E'T7'RI LLE �-
�iEG. QEiE Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Fayetteville Regional Office, Water Quality Section
Bladen County Soil and Water Conservation District
Permit File
NDPU Files

= State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS F)R.H U4 Y BE PHOTOCOPIED FOR USE ,4S.4N ORIGIN.4L)
General Permit - Existing Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as �oBeAo�
any question unanswered.
I. GENERAL INFORMATION:
MAY 1 7 1999
1.1 Facility Name: Paul McKeithan Farm
1.2 Print Land Owner's name: Paul McKeithan E
1.3 Mailing address. PO 13ex 1313
City, State: Bladenboro NC
Telephone Number (include area code): 648-2612
1.4 County where facility is located: Bladen
Zip: 28320
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): From Clarkton, take Hwy 211 west to Wright Road,
turn right, go to the stop sign turn right and farm on left approx. lmile.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Prestage Farms
1.8 Date Facility Originally Began Operation:
159S
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _09_ (county number); 159 (facility number).
2.2 Operation Description: Swine operation
Ito Feeder
6080- Certified Design Capacity
Is the above information correct? 0 yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (4 sow)
0 Farrow to Finish (4 sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 09 - 159

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 17-5 Required Acreage (as listed in the AWMP): 1 I
2.4 Number o asoo / storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or(:O (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or(please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
or NO (please circle one}
What was the date that this facility's swine houses and lagoon were sited? 411319%
What was the date that this facility's land application areas were sited? 4-/3 .9
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
32 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility,
3.32 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.110 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 09 - 159

Facility Number: 09 - 159
Facility Name: Paul McKeithan Farm
4. APPLICANT'S CERTIFICATION:
UL MG kE f ,V A /1 (Land Owner's name listed in question 1.2), attest that
this application for AUL MG,ki�17 4 AM (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be xe"ed to me as incorplete_
Signature
Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
11
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 09 - 159

- ®ra
gjl
3
of
N

m l

WASTE UTILIZATION PLAN
September 15, 1995
% PRODUCER: PAUL MCKEITHAN
LOCATION: P.O. BOX 1313
BLADENBORO NC 28320
TELEPHONE: [phone]
TYPE OPERATION: Wean to Feeder Swine
NUMBER OF ANIMALS: 6080 pigs design capacity
PAGE 1
RECEIVED
M. AY 1 7 1999
FAYE rTE!l1LLE
REG. OFFICE
The waste from your animal facility must be land applied at a specified
rate to prevent.pollution of surface and/or groundwater. The plant
nutrients in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops in the fields where waste
is to be.applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application
cycle. Annual soil tests are strongly encouraged so that all plant.
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner. Always
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can
utilize. Soil types are important as they have different infilitration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. with special pre-
cautions, waste may be applied to land eroding at up to 10 tons per
acre per year. Do not apply waste on saturated soils, when it is
raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of the nutrients
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare ground
not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage require-
ments should be based on the waste analysis report from your waste
management facility. Attached you will find information on proper
sampling techniques, pr-paration, and transfer of waste samples to
the lab for analysis.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H.0217 adopted by the Environmental
Management Commission.

WASTE UTILIZATION PLAN PAGE 2
AMOUNT -OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
6080 pigs x .40 tons waste/pigs/year = 2432 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
6080 pigs x .48 lbs PAN/pigs/year = 2918.4 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW
PER AC
AC
USED
APPLIC.
TIME
9482
1
STALLINGS
BH
5.5
275
0
11
3025
APR-SEP
EN
TOTAL 3025
- Indicates that this field is being overseeded.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirments. Beginning in 1996 the Coastal Zone
Management Act will require farmers in some eastern counties of NC to
have a nutrient management plan that addresses all nutrients. This
plan only addresses Nitrogen.

WASTE UTILIZATION PLAN PAGE 3
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(agreement with adjacent landowners must be attached)
(Required only if operator does not own adequate
land. see required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW
PER AC
AC
USED
APPLIC
TIME
END
TOTAL 0
Indicates that this field is being overseeded. If overseeded small
grain is used for HAY, careful management is required to ensure that
small grain does not suppress coastal bermudagrass. This suppres-
sion could lead to loss of stand and result in less nitrogen being
utilized by coastal bermudagrass as a result of reduced yields.
* Acreage figures may exceed total acreage in fields due to
overseeding.
** lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
LBS N
PER UNIT
50
BH
HYBRID BERMUDAGRASS-HAY
TONS
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES ) LBS AW N USED
1 11 1 3025
0 1 0
11 1 3025
AMOUNT OF N PRODUCED) 2918.4
*** BALANCE 1 -106.6
*** This number must be less than or equal to 0 in order to

WASTE UTILIZATION PLAN
PATE 4
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in- the fields listed may, and most likely will be, more than
the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 462.08 pounds of plant
available nitrogen per year in the sludge that will need to be
removed on a periodic basis. This figure is PAN when broadcasting
the sludge. Please be aware that additional acres of land, as well
special equipment, may be needed when you remove this sludge.
See attached map showing the fields to be used for the utilization of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of
the soil at the time of irrigation such that runoff or ponding occurs.
This rate is limited by initial soil moisture content, soil structure,
soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the
soil at the time of irrigation nor should the plant available nitrogen
applied exceed the nitrogen needs of the crop.
Your facility is designed for 180 days of temporary storage
and the temporary storage must be removed on the average of once every
6 months. In no instance should the volume of waste being stored in
your structure be within 1.7 feet of the top of the dike.
if surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper
application rate prior to applying the waste.

WASTE UTILIZATION PLAN PAGE 5
NARRATIVE OF OPERATION:

WASTE UTILIZATION PLAN PAGE 6
Plans and Specifications
1. Animal waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division
of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that
the producer either has owns or has long term access to adequate
land to properly dispose of waste. If the producer does not own
adequate land to properly dispose of waste, he shall provide NRCS
with a copy of a written agreement with a landowner who is within
a reasonable proximity, allowing him/her the use of the land for
waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility
to secure an update of the Waste Utilization Plan when there is
a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
Nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and
level of management, unless there are regulations that
restrict the rate of application for other nutrients.
4. Animal waste may be applied to land that has a Resource
Management System (RMS) or an Alternative Conservation System
(ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips
will be used where runoff leaves the field. These filter
strips will be in addition to "Suffers" required by DEM.
(See FOTG Standard 393 - Filter Strips and Standard 390
Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when the
wind is blowing.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the
application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment file for guidance.
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or
to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur
in order to control conditions conducive to odor or flies
and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in
such a manner that no more than 20 to 25 percent of the leaf
area is covered.

WASTE UTILIZATION PLAN
10. waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a
crop -on bare soil.
11. Animal waste shall not be applied closer than 25 feet to
surface water. This distance may be reduced for waters that
are not perennial provided adequate vegetative filter strips
are present. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other
property and public right -of ways.
15. Animal waste shall not be discharged into surface wasters,
drainageways, or wetlands by discharge or by over -spraying.
Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site
by a "technical specialist". Animal waste should not be
applied on grassed waterways that discharge into water
courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system.
17. Lagoons and other uncovered waste containment structures
must maintain a maximum operating level to provide adequate
storage for a 25-year, 24-hour storm event in addition to
one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments,
berms, pipe runs, etc.). If needed, special vegetation
shall be provided for these areas and shall be fenced, as
necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc. are limited to
areas where considered appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms and structures
should be inspected regularly for evidence of erosion, leakage
or discharge.
19. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and imple-
menting a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.
PAGE 7

WASTE UTILIZATION'PLAN PAGE 8
NAME OF FARM: PAUL MCKEITHAN
OWNER / MANAGER AGREEMENT
8
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the ap-
proved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
I (we) understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the'animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from'the .lagoon in a 25-year 1-day storm event. I also cer-
tify that the waste will be applied on the land according to this
plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: PAUL MCKEITHAN
SIGNATURE: DATE: -2 J
NAME OF MANAGER (if different from owner):
please print
SIGNATURE:
DATE:
NAME OF TECHNICAL SPECIALIST: Samuel G. Warren
AFFILIATION: USDA- NRCS
ADDRESS (AGENCY): 122 Ag. Service Ctr.
Elizabethtown NC 28337
SIGNATURE: / j, �X__ 6, 0 "AA61 , DATE: I -lf C/J

• � � ^�� ��OLJ� r� � � �•3 �� (.�r�(i �,..',hr!n�1r�Af'f! :-1-.�� �" -•n
ll r,, 111, i�,..y p '._ O :n +�.r�• ,,. f. i3v �q '3� ��Y l[•�' }� T�� � h I ,,.r1 •"*s'yF r "�' +�� y _ry J ..
w�`'� \ /
I>+ :'1C 8 • ! f • +r r ,� �/J, .,� ` { f-C';•�L..s. r. - t l r 1_l ...r i
' -Mr n. L•�If r - .+�'� ': y •. - .�f;±rf', ',fgfi �'�✓� ��11 L.,t"v`�' •�;-i � r�1.Y e�f3,y r>.' ! ,a 4�r��•:• y t',,{Z .,.: tr n
th'IL Ja t4 s7' -,t y, .ti. •n/1 r , ,[rl+ ,n'�i� R,:,
',Y;{rr}f;., 'r �+,+ ,Fy1'1��7 � rN��31;rY ;.is/'✓•"" JfJ _l" �r,''1!,`V?�'I't�+'+ �++ �•A a! i'.1 :�'l,'�7r +.�.ry.s.J , v x'.J'L" •,r rw 1k1
ZK;^t7r,Jp4 :; E�+.:r?`.•ltvi"',�'/ ,• :f" tl' rr� �``�� t{ I,' 'r.`j't .ly' r.a-.•a,F�St :7'Y..!r k
h tr,,
:TJ Y'i`" R �xn.+:. y'{k:. .r ., : � �yr�'r�1' �i Y+i�; :,•Y � S 1 , ,`+..
,� � !♦ - '•r s 1 Y+ •L;�a -,' i ,r� Tir N 'S'' �. ttL �,"�`'• }�r+15 �, �,���,4tti�i41f;: �v!i„�+ 'w: $ r �� + '�3� • �. }1'.;_ • 'f i. t r•= �,,�� �a^ it '�.3"LIR ilvT ,Z, iti�:'r'I ;. �1��- •.
-}l ,r, '17. �__•-�r.�„+ -�rJ �"�«r..l,1sa: '•r5t,a :.r.a; /�„1?S,l:.'�7�C. nT..•'t' ^';. � _ •.e
j,i ri. 5r1• ^,:�. •4rx+„li T ��� .I:.L';.k` :1 .1' •'l'.f �ty.r '� I ->, Y.,.� .r.....• t£-: :;u ��f".. `I�kky._:•_ - .'c�Rt,. `. ��+�� i. ;1. t y� 's'�
.F 5H.1+, � _ ! t � ' ' �'{ st. i-{i r•�l ., "; i,;,,, r� •Ty f �, y�� �... rye �
,..1.j.;��. /:'., a•• �-Ytl1� � :$�•],�4'--- '� t � T1 ;f;Kf,.1 '''l...fiiC� ::tti;l f,,,t: R..;hir'6q.Srl��" ,rf'fr���! "1. ��5":�a.•.:r -l''h-.rT�r't�,`1,�;�,
,Y .�..� " f�. - l-.f�•-�i.� 1 � #C�r �,. -t�.', f �..;: 1 !1 _rV }knt . r'�'- '� �..v...i., i� i A v.� '7i'
} � A I," .rf, r+'�„ ` . L•f.{,i Y ti} . � :� i a� a. t ^3; i 1 + . 5 �e i.�' r} � � •�' I, � �7 . il-' i� ' ,e
1 a.h�; � �i. �''. • 7' L"��, 4 , �. cC ly5 1' 4 '�, �I ;d�yf.yl�;ry'' � j i
� T�f a• ' 1 , .� M 5{1 } r- 'it7 }^ '.� li.�l. 3N.' '� `l 5 4.}1- � Y `. 5':,ri
r ;'► *e;t r , 3; In , r it ,E-, *5' }:' ii•
1 �'w f tr` r,��++' {a:. }. f •�1;+ �". �'• �' .i .�, . h r11, r13 , � � .- 4 t r tl�,.�7t� S ,:t:''71 � ,,;� ,r,t
E��"'-' •;,,,,55``' .' '71k�,'ir` �frr,,;,. I1: 1: .r}Y` r.r?'•:+�ht,+r,,S.•`.'I',t,'4, r•.4-Z:t.3.,'.,rirrs� +- -r' .f., i�•5. y.t- J+lfr'!:`I;,t t`Iw fa r'"+iik,•f^S••' ,�,• �;
';i'�• fi i ` 'i • 1. y:w� -_ a •4 ;..., r f Lt;. � f� ,• a q1E ♦ ?_y!+' :w• t;l�.
V"T r* ?. fl r,Y.-1- 17!ii••�. ',iiyt"�+,�1�Y ..-�i} ,J'uw,f,r 'l �Z,•' It.r ��r, ��wF11 1T'ti J 'M ice♦ l4�1. 1 l
r�/5� rf! f t{,L'p, � r f ti•,yJl. ...j.t':' �.� 'v •rt 'k h�, ,� �
•c�.�Sr1 H iP]�^ L(•, f • t ri"..-..� Sy-?F.'�" .1!� Ylijr- - f� Y =,.0 r +`..�ot I 1; 7 ,•� T„n��l'1• i a,l�'' 4' 1.t• .:.
KrvF! 1 /j 4,lr��yy
Y•�,' 4 If tii5'K`3' -i ,�"' a.l . „� jl . t, 'L �.• - '"-. , r� („�' S _ ,�.�. _ .f_+:,^A` r,,• 5,y, r�1L-t' j�
�i1 ,:f' r wfr,8, ti ,t? �•`• yy y,; ,;y y j,•i ♦r} I. �;r.,._1 f r'l +,Z,�'" .�••:, Y•�.*� '"n
.. r�yt ;�'T�•. � iJy4. �:�j .1�•�a; -•+ x , jJ. "'- /t-".1''r 'r'; Sr,�� .r k3. L�t' n+ - :, r�i �:-T�,l: t.7� ,•... 1 �' :�'+.,+=�t,•i?.�f ;! , t.'ti
o y.;;�;{;tt, .'4�,�'s-�i. R, r.•ya. �.,; f., ��;' 4+!' �1 f!1 i�• ��•� rw.. ,�•. �ro' •lr }.'. i' �'�,rtf,', r -t �YLI. �'P"1'•�t-•3i�,+;��
'a..&�>w:.4 1i ;}Jr-- � t w ,l. � �t•,.t •�� +,_ _ � In ?' 'i'�yr',. 1>~' I'•r ti,'1,.} ♦• r
:�a v��� V 1 {� •'1�.►i�, f 1 1 A+IR 7' j� `' �
�y,� � • r rr -� ti, ' _ r > el stir , - � Y P 'r, r f r 1.',:. r �' r .~rS °y ,5 9]•" t
' `- +t .#+lr'.4 �{ t :�"�`r''�` tl jr .e ,�.i+a..�� � > `' •nds I r. p y. .' �''� T ti y!•1J,. e4 "i:f`� W.
, M s � 14 al; ":Eyyx,�r: •ly�, a7 pk+:r['ir ,� i1 rr••�yn.� ,"�� ! .M, 'y i-`}''= a- � +,.` 1'•-, r,.. ,�. ., t �;,
','-C,,, I 1---7 A}r:}• " 2'i +y' =r " $ +• -Ll i" .'-C. �`�.Lr"! t+' tl . 't. - _ r •r, r. 13'•.t,}
-yT .{'r ` / .S r�l .F• �'1 y. �..' '+rl , 1', ir• - f 1M i `,{.- x r �1,.. ,; 'a.
:?'Tt i%: !J a!��i } �• '? q? r4 h'�►�.'w Zvl%. i64.
-•.
:.,y .. , -+F �'- to :F 7r r ++` , i'+t '�1 ai' Fyn ,�-,A[y, .J;;:"{''� a ,,. r,Z t.9.'• t \ �t <- ,l•'� t•
'r.. 1 .. i�:'.'r3r... of ilr:?6:: *...:i. �, ri 4;•i ti " 'T`� + L,.: y'i: "�5 T
• ';%ri.: �SL, r- `!,: 'r � � 1 ,k �' , ,^.--'' iY + �;,A .«,: ': t''.•: �6,y 1:. ar•' •1!+� 1i,, r�y��,(•.�,,t,,
;•,;/-� _ fF�.'},:l !n 't` r.. �i7." i1 �i:. ��., Y.i-l�-..Y >fTii `' [ir`C•� t"`,Y:
i r, '-;•1 '{ -'%� 'y, ti:J „r.. .,
� �._,_.. _ �v ,-Y e,'1 - �•!'�i�' �'i � •l Y S+ 1 Tom'
"' f}. rill lJ � �\ \.• �j ��,(�. +.�;, r„ � _ .�(1 � -fir, �r ''ram t,� ' A11� } ♦ . 4 Y,y�`�1 �z�, �I'' ry �.
' �1� _�. T ' �1 �', - i.-i+,��• :i �L• E I �,1;, Z^ �- � �(. �l.�tV�,'��rrt�.,k �; ' fiYw�- 5i N•�,
• 1 , _5y � - ft � � t ��.' r� 'a,, y1t� � e •• ,V .i• `� 'Z' ul, .,y '+rY ,' :,1t� •h`�. t� i.
:rt• ' � '-Fi.r'.x".i� 1�tiw! '.�C"'i� R''•° �T'r" ��"'"'1''"Y A . ;j. to +i/ ,1 M• Yt�� i,"[�', /�1 �«: .y( _l,j�5�r�*riz t��,i. ��.+.i '?;Yt`it�"h
, ., r;"5.,15''iT?r ;-q, ,4-i✓ �,1 Y,, �.+r � ,�X .. ' Z �i.S• �y 14�-.:t '�- C r: 7•.�'rlrly t� l Z'i fir'., ly! 7t' .t.- r-, 6
„;'�+n� [ "•�{�,�w'{'Er !''".: 7'���' �}w Z*' r,�ri_ -a• ��Fr .fr - '��, ,: s, {`' 1l;'i5�r� ,a,.a� .'L .1j '!rt �3j?:l ���a �� �;'�; ,��;W.� `�l
r�'�'^y4r: �t.�.{,i '�^'jY. I�jf�'''1j fr�T•,'1fy51wliy�- ,+1"r^"!#r 7 t ,,,,,�' ��'` rf. ✓ f t l 'til•�,•hAa�,�l'=�ZI �:f.'i:•1}f.�a'�� .,�t�'r."t;+lt••�'Lfi
;Sir '�.. a ,�, jFF,'t;;il •�-,[ v_ �. r r�l` :5 �+ J�, '!•. ,,{• x'y. , s A3' )C+," "' 'S' lr+ j,< .:ti,_,I. r� , �..y,Y ,,�y tt. ,L �,:, �,. ,� .
t"� .r...''7 ��c s y'!'r -.�- .�•� 5 �:f�,'�.�( .�/ �1,4 ��E,ti.,;• ,rf� (`,t�Tl - if' _ ,flq f�l� t� :;.'.�; r•_. �•' 1 t,ry,^.:.I.,lf::•,i�+,� ,.��,,,.�.-t s '�
'2J .�y^a nr+r 5 /'��'I r�G�a "•! { r.€rl; �rs' � �,ti;' ,I• l' ,��-'{+ ;;4 ' _ •.y� `,n' ��l[ � �.N I��.sa�;1:'T;th •� � -c1",\,-+ .,•?r:. 7"; ;:''1'ti- ��rirY4v:n�� +^ - •��y
1 • r' L � ��A'1� r a •a' I�I't' ;. r ti •, n w -� 1+1, r •' 1'7' '�, �
I r rJ , t� �l , ,'!r ,�` "'TTBir�' tr. 3 -, f2'�i 1 lf'�i,"L +•1'., � n r r47:�;r r
tt; C f "} •,g > tf'' „ •` �L� r`.FM I{,wl, I e^ a_ ! 'tom rt r,l '' a 5 1�. �I..a.�,lY�:.},•..�.s:+-
iE'?,�'t! �� '�, _ •';��"£�;°., •. 1'1+ �f� '1' i� v'[ .. E �t�y-.,•�� � ' L' r 4 � 't ,E'•. '�-'a!-Pt • �: G O •+a I{ , a .�- ^^ 1 Cr►`q1�,�r
,.
TD,'+�,
'!.�i."'i^ 6r ,.?^ w•r' + fr' - 1 �j �-r ,S' � � 11` tl'-.tip �Ytr.-at!!�� { eit
- • r.. �..'F Id M :�. _ — --, - .�t t sa ) _ M'.+��,;•+; ti., r r ey I.H 1•J tiiar" la'Tt'1P
..,)I;0s
t i � il;� •; !/ , -eh' fP' � • 'Sf'� r'�I �' ,, z fI UE ` �f'r , 7 s � r r',_7 tr � -1.
� ?r5ljj�r%L'a V 4 �x+ r/ CI"'°`; -. 11 .I! j�il'�. 0��r� � /1l� :� ,..; �;vY;y 1� . � , .,, J: _. .i -r.l .�' •`'
,A ,r'f1r,J�"V�•t.� } �!'• �Jt i »' �r •�,� r tfl`{<yS', f'�•'i1L r f yx.�•'` `� _ __ _ y � + e ;�Y���� ' ti � +S"ti{ I ! � � � rr�sr:.-'1',
lt�, } r ,J'j � .i r4C' ,-,iff •!> ,+ , ,'s.;. �;� ;t' Y f''�` ,� 1 e / b• ,�-t'+_.
rpJ.t.; !} NSA',• 'a'1$ ' afAkr ���� f'" - � �' "tee
r_ f• f 1 , , - „V4 l • r �
t�t'Sr.y h r f -. 7,•!G YL i:'�:- ,,fir,. �'ihltC'f,� Srr'Y.'�A ; ��°'ht�' ,i t"�^' �% r +t ir% ,O T, I 1 �`.`+��"}'y�� .�'rl!�t I y' _ irE _ 1 l ,T•.
•�,,,"SN•''�Fy,`'1; t�rll.r ',5�.'iy{•t't-� }�'�i� �{�f4,.7ii'I tlf.4 r�.� Y .�� r � �' �.f`�7.L;..1F 1.rT'�''L.. •'ti.-r4 } '+:�'6'7 r, i. �� ',r..�'
. h.�� I ,•i�'� � `• � �r.ti Ni -W�!r, Ir JaP. - _ "yi�•r�T hid ..,�{. Flil{ •§6,%; '$� x� i i. �� �t -'J r' -
� `'�,;�•'''�' i,;.�'yl .i`' �4,:��'!• -Y!•. �+r!'t'i.�':+�,r,t�, �r4 � 1 I--+r.,tt'_ _ _ _ ""�� � 5 . F'.$ ._ at' �' F'�I Y.. ,-}I •�; r,I��' ; ti r �,� /' r
. ��r�_-, 1�+� i _ "5, i'� � 1F.��•i''')T�k�,,�rsM 'i ir'��•r '.1li I ., �r +I �l.:f '!I,tT Win., 1�; f l- .� 3..+Y-1 �} �\�+)--1':��' l'. h..,7'` tr V"Sa•r f tyr 11 trl;S•1 fflif I Nj .y,�. K., t!i'rilr3 1 Nf:rly`•;i;, �� .r ,1
4 •,w4'1 �.� J` ,�, �,. c, 4.v ;y', , 1. N .:l"". -..+r. e+,.� .E, yy 1 1;e, � �f '`� _.'4•_.ti ., ,• Y '.,.� ,
;tii++ ,� .�• .� -� : ra.r•f'�, ' iYy¢ S L°,e.:• t r T :�' r�3•• 'i -, '�r�i,, !'.1"
. :�:'J�",� rl i, + ,5�f?•rt+�1�(��{��ff+'I�i.' r :,.!���/ul,,'�;'� 'lam_`-�_y� �; f� F�':'�y���� .{h�'! ;yY'� �T •{,•�•.�; /��, , r ►.r } ,,' ir, ';'��F�q,•. r � ..
'•- di�4'i/�p I�rA. � `S�M6 f-.��r3� { t�.�i.'i'•�� ___ �_�'- •.. 1••� '�'�1' ,'�.'N�.i�� � Jy NF� ? ��7�rr ��G�� �,�� �,_ *j ►�� - � Y' �: r•N
jr jr I �% ceo r.•R; r. Ijl �. . Ei1�• y 1 3 t 7 '1IN
r i �'�, }w�• c���ri .- J� t � � '' G,t, y b"'t' a �•�a a-�•�$ ��j. •.r' �',- '" 'i7i�
i.i 5f '�%� :a,�':� fi��y a 'tr f� 'r[3,r',L. 'u' • S•' -.f .. r J + � s af�` ��� 'r t', r�i '�' [•:�fr a y-
.``, � � [i . �y�{?I � ,a._.-vr�r � R',+ ,,r F'n� 31.�.5 '- j� I f" �,Y7 s.".t ,� � 'r.� ,. -5r'- �F•��' ri .��1�� �f�'K K . ,a l I
` 'o?,r
- `� ,%�E'+ i v'• ,,,�` t� F'i, ,'!,' + �t'f-,•..3� , , a�� jr 1 J x 'L.c '=ig��,r,�i -t:�i . �5:j
iY* , S�, �' ;� f, �Ji- �, '' � ?•'�"�} ,},. r ...� .�1� � 7rljSj+r. -Z - . r-? �' ir-',F;rT. tir., Fsy -x -v�". '.�
ti,+� �'.- ` rf� i ;'•- �, ..��r, �,-, a�:�'rr`;v ,=f.:-:a�;.�,,r�•�';Y�;,', I �". i, r;, • �,.�fwr�� �k �, �,� � :,iy �'• � .�.T.,,,�, �"i� ''z� f�.�.'� f,•
1Y + - r .r►I evs• ."+.S•A Y� r,.n S `S " Z
t Y .. `•;ra�'i r •"�'.J•�t 4 • u t is.,s,,'S'. t r 3r�f �1 `�
� 1--•� w4A�'a J' r} �r� .PY a � �}^t�A' r �� ; - t{-�. �: .rw_d n �.c.�•'3t ,s+.a iX PY. I\ed' S�'+�;'ii�l/�y�y,;r J�:ii.[;'
r �; ,. r S �}'4; t r;� uL'I `•Y, if: ,
I0 .Q Ay
q}+I r' l p y�Pj/J �: w l y �.n . , l}7`[a�{,: ;I_i •-.'�
�'+ 1' ,'1111 , ,.r -.. j}?����.y \ ���."r ''.�,�. ��' !. 17.+-J �sQ.� � u•'r 1_iyy , h} i 1 • rr ;,},.1i'1 a, � I c•
ti,� l,' '4:, ,! ,! / "� ,'�F' T'�Y' E �5.. .+�Yy �4 •�� �! 1'K' Li�; *..n. r• r +.�' Y•�S.r-.+_.�e���.
I �::, `r ,; _ ��+., i. ��t��v S�/,G.,i:' Yl�:�,. '.I 5 �•-7.'ii� {. .!?.1� �l. •I.i_
r tt 141 ',�I' v r,yr�"`r�'f r � '•�fy�-"},�1,y�f,;glyt•, i'• ,/ j�1� �t{-�I 't I�.— !'• ,
_ ''? -f�cr � n t- r, � r, �.,�.r„�<li •'���� _� If� r ��� cr 'h4i {��`"r!,` 7 f.+f' rt yi��.,. '.?yj,y'.:i' "" .µ• \.
'r tI Il•�', r.1 Aa': .�,a� t '/ '1, fr-F'r :.ti:' c^^"""-r'ti•�'• `-r-
•F'i _ .h't.,11,�{�•��.t17+ �"�., t�'•S �?'a� �1-- "•• �'F�'�STi,�` �Z 4aw.-•� _,�'- �"�,��•
4 �,a�� -r r4 lri Fa r'1,}yy,4 �f`p,/•,f � +1 .r i•, ..• Y,�r+;L.,� �f:l'r Ir 31 +•;.��:, r .'iv u.ti, �; .,.;,!\ ... !� p: ►., �. \

AFc
St'
uA
_e
oA x W, t t
GbA. NoA
GbA
GbA
�LIA WaB NoA GbA FQ. F-9
Ra GbA
ta
n
P. P—"
i.
NOA Ov
Gb Ln
��7�lff
uA GbA
NoA
Nc
Fo Tr
�7.
GbA Fo
SuA IN UA
r
BuA
.9'tts`s
St
Ra
Wo--- wo Fo. wo
V�
r%eA
BuA WgS BnB SUA
Fo AuA $uA
BuA
wgs;
Fo
F4
�JW
Fol
-;4
A-
4
A-r
0
ip
fr Wit
-4
NOA
sod
ibA GbA .0
T
0 AuA NO;
Tr --j.
L N.A
WCFWas
WO
BuA
F, W 0
r
Fo BuA oc Wo
BuA•Fo Fo Wa Au,:
uA
NnR

Mar-09-99 08:21A usda service center
.,....JNJV- FORM 99 (7-go)
FAX TRANSMITTAL
T911 t ^ ► C . FrOm
Fax 0
Fa 0
9108626447
0uP"".
NSN 7SQ-01 _317-rUM SM-101 GENERAL SERVICES
P_01

BLADEN COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER DUALITY (DWO) 910-466-15'41
EMERGENCY MANAGEMENT SERVICES (EMS) 910_8b;:�-6r60
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-86 —693b
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 91-tib�-6y;sa
COOPERATIVE EXTENSION SERVICE (CES) 910-662-4591
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facilitj. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be possible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Rump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type sail.
c. Have a professional evaluate the condition bf the side
walls and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish kills, or
property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off of
the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of
Water Quality) regional office, at 910-486-1541, after
hours, emergency number:919-733-394`. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-862-6760.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District
(SWCD), Natural Resources Conservation Service
(NRCS) office at 910-862-6936 and Cooperative Extension
Service (CES) at 910-862-4591 for advice/technical
assistance.
4. If none of the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies for you.

5. Contact the contractor of your choice to begin repair of the
problem to minimize off -site damage.
a_ Contractors Name; Srnera ae.os:.
b.-Contractors Address;
LADEAI$oALa nf.C...
e. Contractors Phone; 910- 8"- Sti3
6. Contact the technical specialist who certified the lagoon (NRCS,
Consulting Engineer, etc.)
a. Name; {;,LENLrGToA/
b. Phone: 9i0-5- 77
7. Implement procedures as advised by DWQ and technical assistance
agencies to rectify the damage, repair the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again. .
8. If you are a contract swine grower associated with a swine
company integrator, contact the company representative at
1-910-592-5771

Insect Control Checklist for Animal Operations
Source Cause QMPs to Control Insects Site Specific Practices
Liquid Systems
Flush Gutters • Accumulation of solids( Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
Remove bridging of accumulated solids at
discharge
Lagoons and Pits + Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along waters edge on impoundment's perimeter.
tems
Feeders • Feed Spillage 0 Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
❑ Clean up spillage on a routine basis (e.g., T - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage + Accumulations of feed residues ❑ Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
❑ Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AM IC -November 11. 1996, Page I

Swine Farm Waste Management Odor Control Checklist
Source Cause DMPs to Minimize Odor Site Specific Practices
Farmilead • Swine production Vegetative or wooded buffers;
Recommended best management practices;
Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals Dry' floors
Floor surfaces + Wet manure -covered floors Slotted floors;
Waterers located over slotted floors;
Cl Feeders at high end of solid floors;
❑ Scrape manure buildup from floors;
❑ Underfloor ventilation for drying
Manure collection pits • Urine; ❑ Frequent manure removal by flush, pit recharge,
* Partial microbial decomposition or scrape;
0 Underfloor ventilation
Ventilation exhaust fans • Volatile gases; ,l§� Fan maintenance;
Dust Efficient air movement
Indoor surfaces
0 Washdown between groups of animals;
0 Feed additives;
❑ Feeder covers;
Cl Feed delivery downspout extenders to feeder
covers
Flush tanks
• Agitation of recycled lagoon
❑
Flush lank covers;
liquid while tanks are filling
0
•
Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys
• Agitation during wastewater
❑
Underfloor flush with underfloor vcnlilalion
conveyance
Pit recharge points
• Agitation of recycled lagoon
❑
Extend recharge lines to near bottom of pits
liquid while pits are filling
Willi anli-siphon vents
Lift stations
• Agitation during sump lank
❑
Sump lank covers
filling and drawdown
Outside drain collection • Agitation during wastewater ❑ Box covers
orjunction boxes conveyance
AMOC -November 11, 1996, Page 3

Source Cause BMI's to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater ❑ Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
agoon surfaces + Volatile gas emissions;
• Biological mixing;
• Agitation
Proper lagoon liquid capacity;
Correct lagoon startup procedures;
Minimum surface area -to -volume ratio;
' Minimum agitation when.pumping;
❑ Mechanical aeration;
❑ Proven biological additives
Irrigation sprinkler + High pressure agitation; Irrigate on dry days with little or no wind;
nozzles + Wind drill Minimum recommended operating pressure;.
h� Pump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; (3 Bottom or midlevel loading;
surface • Mixing while Filling; ❑ Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑
Proven biological additives or oxidants
Settling basin surface
Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
•
Agitation when emptying
❑
Remove settled solids regularly
Manure, slurry or sludge +
Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader outlets +
Volatile gas emissions
❑
Wash residual manure from spreader after usc;
❑
Proven biological additives or oxidants
Uncovered manure, •
Volatile gas emissions while
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil incorporation within 48 hrs.;
surfaces
O
Spread in thin uniform layers for rapid drying;
❑ Proven biological additives or oxidants
Dead animals • Carcass decomposition )q Proper disposition of carcaucs
animal disposal • Carcass decomposition Ph —Complete covering of carcasses in burial pits;
pits O Proper location/construction of disposal pits
Incinerators • incomplete combustion ❑ Secondary stack burners
AMOC -November 11, 1996, Page 4

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices.
Manure tracked onto • Poorly maintained access S' Farm access road maintenance
public roads from roads
farm access
Additional Information: _
Swine Manure Management; .0200 RuIeBMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush --Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PII-1-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO 107, 1995 Conference Proceedings
Available From:
NCSU, County Extension Center
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make -possible the salvage- of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

Operator:Faul McKeithan County: BLADEN
Date:
06//2j S-
Distance to nearest residence (other than owner):
1500
feet
1. AVERAGE -LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417
lbs. =
0
lbs
0 sows (farrow to feeder) x 522
lbs. -
0
lbs
0 head (finishing only) x 135
lbs. -
0
lbs
0 sows (farrow to wean) x 433
lbs. =
0
lbs.
6080 head (wean to feeder) x 30
lbs. =
182400
lbs
Describe other :
0
lbs
Total verage Live
Weig
182400
lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 182400 lbs. ALW x Treatment Volume(CF)/lb.
ALW
Treatment Volume(CF)/lb. ALW =
1 CF/lb. ALW
Volume = 182400 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 91200 cubic feet
4. TOTAL DESIGNED VOLUME_<
Inside top length (feet)--------------------- 392.0
Inside top width (feet)---------------------- 189.0
Top of dike elevation (feet)----------------- 52.0
Bottom of lagoon elevation (feet)------------ 39.5
Freeboard (feet) --------•-------------------- 1.0
Side slopes (inside lagoon)------------------ 3.0 . 1
Total design volume using prismoidal formula
SS/ENDI SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 386.0 183.0 11.5
AREA OF TOP
LENGTH * WIDTH =
386.0 183.0 70638 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
317.0 114.0 36138 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
351.5 148.5 208791 (AREA OF MIDSECTION * 4)
CU. FT. = (AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
70638.0 208791.0 36138.0 1.9
Total Designed Volume Available=604836.75 CU. FT
f
IO' d zVV9Z98016 a0q.UaD 001. n.Aas Vpsn dVE: VO 66-80--AEW

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
392.0 189.0
74088.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 74088.0 square feet
Design temporary storage period to be
5A. Volume of waste produced
Describe this area.
180 days.
Feces & urine production in gal./day per 135 lb. ALW 1.37 .
Volume = 182400 lbs. ALW/135 lbs ALW * 1.37 gal/day 180 days
Volume = 333164 gals. or 44543.3 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system or excess water. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Volume = 300.0 gallons/day * 180 days storage/7.48 gallon
per CF
Volume = 7219.3 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
180 days excess rainfall = 7.0 inches
Volume = 7.0 inches * DA / 12 inches per foot
Volume = 43218.0 cubic feet
5D. Volume of 25 year -- 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 43218.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
44543
cubic
feet
5B.
7219
cubic
feet
5C.
43218
cubic
feet
5D.
43218
cubic
feet
TOTAL 138199 cubic feet
/V
ZO"d LVV9z980T6-4a-4uaD ODLLA-kas vpsn dSC:V0 66-80--AvW

6. SUMMARY
Temporary storage period===========__======_>
180
days
Rainfall in excess of evaporation ==========>
7.0
inches
25 year - 24 hour rainfall== __========�=-===>
7.0
inches
1.0
feet
Side slopes_ ____ __________________________>
3.0
1
Inside top
392.0
feet
Inside top width== =___=_= ==_=-__=_=_=__>
189.0
feet
Top of dike elevation=== =__===__==========>
52.0
feet
Bottom of lagoon elevation =_== =_—_=====->
39.5
feet
Total required volume====_= =___=___=___ =>
411799
cu. ft.
Actual design
604837
cu. ft.
Seasonal high watertable elevation (SHWT)==>
48.0
feet
Stop pumping elev.===—_____-_-__---_--_ =>
46.5
feet
Must -be > or = to the SHWT elev.==�� _==>
48.0
feet
Must be > or = to min. req. treatment el.=>
45.5
feet
Required minimum treatment volume==�=== --- ==>
273600
cu. ft.
Volume at stop pumping elevation==== =====—­=>
320439
cu. ft.
Start pumping elev.===T-==---_____=__=__>
50.3
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr - 24 hr rainfall===> 561619 cu. ft.
Volume at start pumping elevation==========> 556222 cu. ft.
Required volume to be pumped== _===== === > 94981 cu. ft.
Actual volume to be dumped=== —_======== =_=> 235783 cu. ft.
Min. thickness of soil liner when required=--> 1.8 feet
7. P-DESIGNED BY: APPROVED BY:
DATE: 6 _., Z 1 f J-_
DATE: jf_12 -5 C_
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:
/ e4,,,C
i1
co, d Lbb9Z980t6 .Aa'}ua:) a�!rn..las epsn d9E: V0 66-80--Avw

_--
DEPARTMENT OF CONSERVATION Elizabetbtown, NC 28337
AGRICULTURE SERVICE 910-862-6936
WASTE MANAGEMENT FACILITY SITE EVALUATION CEWE-m
GENERAL INFORMATION
NAME l V fie.
-c. _
LLCr C Z-i't C,
TELEPHONE
' 1 7 1999
LOCATION 5,e i FA' "ETTEVILLE
6a u RE G" OFFICE
SIZE OPERATION 2eJ
PiA,6
LOCATION DATA
DISTANCE FROM NE.-�REST RESIDENCE NOT OWNED BY PRODUCER /Jyy FT.
IS SITE WITHIN 100-YEAR FLOOD PLAIN? YE-S NO_2�__
If yes, SCS cannot provide :assistance.
IS SITE AT LEAST 100 FT. FROM A "BLUE LINE" PERE,NMAL
STREAM? YES— � NO
If no, site must be rdamted.
IS SITE WITHIN I MILE ZONING JURISDICTION OF A
MUNICIPALITY? YES NO X
If yes, landowner should consult with local zoning board about required permits.
Permits must be obtained prior to design approval.
ARE UTILITIES IN CONSTRUCTION AREA? YES NO_[`
If yes, see Part 503 of the National Engineering Manual and follow policy.
(Copies of maps or other reference materiak may be attached to site evaluation.)
WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY NON -CROPLAND'?
YES W _ NO
If yes, producer must complete a Fomi A 0-10'6. �.
WILL ACTION RESULT IN SWAI`iPBUSTES N::
IF WETLANDS ARE EN OLVED, IT 11; Tr-ie RESPONSIBIL11-Y OF THE P!ZoD.;CER TO f
r
CONTACT THE 3 `S ARItiIYCORP OF E,ti INEFRS AND THE
ENVIRONMENTAL \,AN'AGEh1ENT TO D[ TERNIINE IF ADDITIONAL PERMITS ARE !
RFQiJIREU, NC, "'E"1;.,a;NI;S. S140u,I_D B :1LTERED UNTIL PR '.":'FIVES j
'•� R, 1 , EN API �.C) , FROM ROM SCS. t S .AI't:.; }: 'C Rs S�f ENGItiI.._
ENVIRO,tiNIENTAL hiANAGEMENJ
(A copy of AD-1026 and CPA-026 should be attached to site evalaatic ci.1- --��
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER .............
.............. PREDOMINANT WIND DIRECTION? YESf" NO
....... POSSIBLE EXPANS[ON OF TREATMENT VOLUN41- FROM 1 ('U.FT. UPWARDS
......... TO 3 CU. FT.II.ii, OF ANIMAL:' YFS � NO
PRECHARGINC; I_?.GOON WITH -rRFSH WATER TO AT LL:,,S's !/2 OF T11h
.............. CAPACITY) YF_'ti N() �
1JSING GOOD S(1UND JL:i1T IN L.AN'D A."I'I..iC'M.'S'Ii.1N F
.... ........ WASTE? YES x N0.... _.__..... �
s

OTHER ]ENVIRONMENTAL FACTORS
IS -ENDANGERED AND/OR THREATENED SPECIES HABITAT PRESENT?
YES NO _
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE PLANNING
AREA OR WILL PLANNED ACTIONS IMPACT ON AN ADJACENT NATURAL
SCENIC AREA? YES ' NO
IS AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE PLANNED
AREA? YE5 NO V
ARE THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT FARMLANDS IN THE
OPERATING UNIT? YES NO--k-
WILL THE ACTION RESULT IN SODBUSTING? YES NO Y
If yes to any of these questions, refer to form NC-CPA-16 for policy sources. The form does not
need to be completed.
WASTE MANAGEMENT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY LAND
APPLY WASTE? YES NO
IF NO, DOES PRODUCER HAVE ACCESS TO MORE LAND?
YES NO
IF LAND IS NOT OWNED BY PRODUCER, CAN PRODUCER GET AGREEMENT ON
LAND ON WHICH TO APPLY WASTE? YES NO
(Attach Waste Utilization Plan to site evaluation.)
SOLI. INVESTIGATION - VALID ONLY IF SOIL INVESTIGATION STREET ATTACHED
IS SOIL SUITABLE FOR LAGOON?
IS A CLAY LINER REQUIRED?
IF YES, IS CLAY AVAILABLE ONSITE?
IS A CORE TRENCH REQUIRE 1'
(Attach soil investigation sh t to site evaluation-'
YES 1( NO
YES k NO
YES(__ NO
QUESTIONABLE:
YSS NO ,.
SITE APPROVED YES N--- NO - CONDITIOti: ^.L
i
C'O4,%TENTS
}._.
THIS SITE INVESTIGATION IS VALID AS LONG AS THE DESIGN AND CONSTRUCTION
OF LAGOON CONTINUES IN REASONABLE TIME PERIOD. UNDUE DELAYS OR
HESITANCY IN CONSTRUCTION MAY REQUIRE THAT SITE EVALUATION BE
INVALIDATED.
SIQNATLME - 1�_ �` _ _ DATE
_ LLz'
Page 2 at 2

`.i'!�'fl btlfY1C8
t.R1r1R Y 1 t 1
I' .1 , t If . *� ,Ii�l
- - , 4 1i 7.14 Ul`�
4. Name of UMM Agency of Per= Ihquee rig Determingtipn
John Dee McKeithan
P O Box 641
Bladenboro, NC 28320
S. Farm No. and Tract No.
SCS F#6894
5/20/93
3_ County
Bladen
T#9482
— I - HM Mi.Y ERODUILE LAND — -
6. Is serf surwynow available for a • erodible land doftwminafion? Yes ® No 0
FIELD NO.(s)
TOTAL ACRES
T. Are Owe wodoe sw maw waft on this farm? Yes ❑ NUIM'
8. list h% tdy erodible fields that, according to ASCS records, were used to prroduoe 2n agncuttvral commodity in any
crop t�� 1981-1985.
9_ List ta4lrht erodible fields float have been or will be oornmi ted for the producdon of agricultural commodities and,
ac=d V b ASCS records. were not used for this purpose in any crop year during 1981-1985: and were not
enrolled in a 11SDA set -aside or difersion program.
10. This d Eroe Land determination was Office Field completed in the: ❑
` ,
-
- SECTION 0 - WETILAND
_ T
' P,ELD N04s1
TOTAL ACHES
11. Are there hydric soils on this farm? Yes No
12. WeCarrds (W}. including abandoned wetlands, or Farmed Wstfarrds (FM or Farmed Wetlands Pasture (FWP).
! f
[ 3
WetlarKis may be farmed under natural conditions. Farmed Wetlands and Farmed Wetlands Pasture may be
2 i
3 �4
mm
laed and maintained in the same manner as they were prior to December 23. 1965, as long as they are not
j
3
z�
13. Prior Converted Cropland (PC). Wetlands that were'converted prior to December 23. 1985. The use, management,
drahW. and aeration of prior converted cropland (PC) are not subject to the wetland conservalion provisions uMess�
the tires reverts to wetland as a result of abandonment. ;
14. ArtlBcfat Wetiards (AW). Artificial wetlands includes irrigation -induced wetlands These wettands are not se�;ect
r
---
to the wetland conservation provisions.
is. M kirnw Ellett Wetlands (MWj. These wetlands are to be farmed according to the mirirnal-effet; agreement swell
at the farce Ire ffrumaf-effect deitsmunation was made. i I
—
—
16. Kfiga!!sn VAMands (MtW). Wetlands on which a person is actively mitigating a trequently cropped area of a wetland ! _
converted befiMeen December 23, 1985 and Novernt-er 28, 195-_
' 7. Restoration with Violation (RVW-year). A restored wetland that was ir, violation as a result of canv'ersion after
November 28, 1990, or the planting of an agriculturai ;ornmodity cr forage crop.-
-j. Aestot rl witt+out Violation (RSVI►). A restored wetland converted between December 23. 1985 a.od i t
November 28. 1990. on which an agncu;tural commodity rtias not been planted
' 3. Replacement tilet!ar: s i-s?W). lheVands which are converra� `::r. purposes other than to ir;,reasN !r `a c
wnere the wel.:and '.aiu'es are being repiac=d at a secr-i s::e.
^. Good Faith Wa'!a'ias ; WV Fyear:. Woi-o ;?nd� '-' h� : QS�: h-iC
Netland has t`Pc.r; :acanre::.
.. , ..:.riv..7C;aC! YVPP,)?r•', 1'; .-. 1'r Pnan.�_ �_.,.�.� -.:s 3ti3r flr+..��.... ... _ �,85 anti pr;Jr io Nc.2.f,
.,r;,.",: - ...�- arri' ae
.. 'r5�'r''1r iln•"L' .. n�n::J�;.iG?r .. ti1. ��. i. 'i��'r _?. n:.,- 'Y. _ - y .. n' ? i� a ..3 � ',ri:r f'. ,r. .: �,.
Converted WetlanC Tecn,nrr,al Errc: ;%rJ' _L Wer!acr
v' SCS
-'.5. -he pianned are: a!: -ea -ores on wenar-n; :n r, lru< are _cnsiiered -ta:n:r.:
ar • e and are :r: co:-no!:ar, :.
Nr=.h FSA
-- -..-.
n -:ra ;.uarrea aftera(ior, on-,etianas '': iielcs ---�---�-__ ......___ .-
�_ . ,gr= ^Ct ;,nnSrdEreC iU :,B r�aant_ �:-•,',;..,r'.^
!ally �vi!1 Cause !nN ;ring to r� ors t 3 Convartad'Aretia e ,c;YJt per derl 22 ;cr m: r; z r!!on opt CW.year,
l,e wetland ddtermr ,ation was comoieleo !n an: ,trice r �w : and was c�i.vered:� ,he aa*son on
crc�4 �'� G. .-. , 3 Ai �.+ Jt `k..A— ,1 n �; L+. + L�Q �. �t c1Y
:-. 1
wi-:c�:/O r-' r 71
K r�LuG-i l .'•: • :� :,: ...�. � _, - , ..r �-, ,.•, �� r li•{'�. •{-t ;,t�a,.(I
j='L
1. c'y v" _ ..
t
C��4 rLS L`:_ '!'.' i t a. u; lV A, c ?S Caw i . ._ r 4 ' r'
=--J
-. . ..ft_`•?=
_ .i%MulMeaN'r,_.. .,,:;rrr,rr.,::. <:, •r.i..,. rr:, rn. ,•r,. r<',rrrnrqV 3C 5igna'.[;tF.. `,[:SDistn tC:_r'r:':-ltr::rzr.::
'3f.
..r::'':r,r.'jr,r t:.Snt rr, , ,:..,: rrir., .,..,}:.f' ,. .. af,,: ,•r:':.!„ , . ;, , .., � �-
!. v,rno-el.r.eL,,c,.:
i r
"1r
R..l:.�P!J�ri� ,Y,XCr,lrru,r •si.r •:'�'•,�:r nq .11f :rr.•ur ..r, .<,r•n '
per./G -
! .�'%-
.�srb:•+v� xnrf Pragrart+ r,r rl±+ Sc?!f ;Dnsarr .!fen ti,,r•.. r.•:•.'a;lahlr, :,T!n:: rr r,+.gari±ro rx• a- rWipAnn. :.Oleo. "V +Ca ,.r-
Z

Q-00 9 ,,,... k..'r: Vv,
.. ^' .� 1+ O. Or Y _!
(.j �•^f
+A �} •'C;jri •: 1. 'it,li 4i�r
� "Fv .+�(} ate, � •' r.�1.;4 r y �+r�gryl,.l �'� '�� � r i I is ����� :'� � .1 . _.�.:
+ � �ly'�. rr.Ay � 4}} , _ �' 7.•�'v I I;�+ 1 (r �.� . �.. �i��} i.jy f ,� 1J.y�:( � �* * r�' -�X "� ,r.+-•r
i r. L;�iI Y ���-lip h y�•i �r. a i.'S''.� I `\I. ,`-' ,(I�. ' �-ti 'Vt'� 1 "••a3• ,��_ � —
�, � . � � r f t � •��y � y � � ^ i'-G y,�ti'l� � s t. r. yr i
*'I 41 1 .L ,; ls•Y J'r 41 r+, y I �]�n _
+ ,� rt, •lye �?t� K 1,'f � � 1 t+j~{"
• ::. , '' T� � - , '9 5 3 tirrl - - - �,.';n - - - i.ti.:{i1 rlt �F,• • f !: �''% i. 1 t�`'yxs°i$ ,Y
,R tY air•. }• .R - i ,y,� ,
' :• - �, +. i � � 4 Fy{,: ]f"� ,qr �' .y� Kr',.,,� ;i sjlr T (
��? - : ti .' SL � i r1j_ }'11 Y'iY II "i:l•T1f.. }•�.;s � �r: ,'� . i7-3,S;Y' -1' ;� T. 'r �. �'�[y,��''
rim L
. ��T- .,` �? Y .S - � '1' 1 yv' Y� .�.�tr �•; �_r� �_ �+..:� fit• �$�",ram
'_.�5. pyYq..7�1L•/4r !: �`�n�+:.Sire, x :� + .��+ _ , T
"'.G.:i•!`k''i -a°� _['rir r.••il•.yS •S` .fin., ' `r, r*.L�. , .!•�a'r.l - ,' .y' + �� r
r~ �- .-r � r ..r (. Ii�'4 sr+�,+...5.';{=.:. r •.�s`. �.hir',:a '��- y,.�, r \-
�. `' l: t . ^Y .� �. r• 1" j.,tr �. 'IR �.�r r1. 'r L?'. . 3��' �+"��.
.n�•�`3'i>'??itZro-�.,�n:r 1. �y {i'iK+ � ,1.� .�•��...�... .r F� 5 �4�;��Kr' rt:. �. }l, -c �ti,�`_{�,�r r�f"� :��,�.
talsi''�: [, t r � �• 1U�.,y; ` �. • i•:.:' ,� � ry+... '�' i 'ata7r �� .�� .Ji^v :. -y } ►E
,. + i i � ••�5��� •, yr. I „ •ii �.�, !.U• � `!}r, h'�.+� ' '{N� _
s.! ram, a a"i Y'r- - a. i •+ jr9l?. l' �' .P _ t ! � �rJ.�.. :.>j;!., I.•
:I.�"" :;1: rti>R�?i� .�rv`M1sST,.i'��:`/�{{ { •i; 's�t.�i► M�. � �`.�h�� s••�'a�L�� }tt-ry �c-.F� .x;....3 .nG�..
<yf'
�� r [ r a ,.•Z k', aG .y R1., �,Y,S'.t, .,M«�Y C W •,y...r * I s t .. _:..
a * � I. sr '� al ., ,- .. .. - ;�i } J [ j�;r,����. j.. r� 7 � • rr li�l'1 -7r� , .
�' *,. !_�:;�r�r. •; w �7�5�"k' i'rti'^'�/ij�''�rr �'Tr .c. .*J;.p + -a l„ i..r. flt,. ",l�ty•,1��.'
.fir .iti .y:` ��W Y� :'w, 1�;�'.'• L:i '1�iti �fti �; r� -� r.�. *;er �S' ��".I. '✓''t - •�,•%;e.�. n ,t
A,�x. "••4.�;:!'� ye�L:`ti..j �X.�.,"���� -
't +.t,*,� . � • ��'' � '� . P r : •�' }':: i ti'' +L 'k r' �H':j_y.. [ �+, �Vf s ',e
>' ''s'.J ,,� .1 r[ t�+,y i,ri :':+r.r• .ram • Sr�_. n r •.`�• � .,.�''\ 51} }r r
_ y"i�'�::!'.� l a .}' ',' ..� r�l� �i# it- .yr'..,.,. •�,��'C r�s•{� R�.I'i .'.+ � ,,, ...1• a l' �'Z f .•C;-
f�,"�( '.L. ,��r.�yS i :<� V1�n'�.j��tlJ' �>;:l_. :ri .'; •:� i`t..i•t�l'G�[�tl.^��✓:_�. 1•�1_ :1 .�'-' .Q:
`�•• �' ^��+'�i�-'.r~'?[,.i �'T'} �!�'!� � .L .. YI-y �`:' h...4pr" �ti�.a• �� f� Y• *': -' �v�`U•�•�.��p 1
'•r X(L.l.� ',i ..:��'�.L�• r:{ n�1 .�,n' - hr .�, iLr. �.: r;' JAL G:^! � •.•i �-."'. -. •:>'��L;,C•I ..- :;fir .L
,� L.:•r�'Si�y� '� 4•� ILYL �1r Vv'h7.'1�.K�,'. ;. 'ii rr :..y _ - '!�'fY F^SA'�Y.
r. • � +Z. 1 J ��iN. , ,/!,'Y� I ' .`. t�Fr ;hM1 r++t�; il r tar [`l. �T'1- x. �, � "wed �,Pu- j+-� '�('}•(i'�{] �.`�.
� `T c F �t •k-,'T~ �„��M1PI�r t'".... � 'Ltt' r � �,v ^�. �� .ter.' .. �I � �/ - '�J `;�!!�r � a'{ '
r- , i'!'[{'t;;- r �li'� � 'J• ' �i�)�(./ ' `I f J ''�,� `�J 14�}+L�1
YO
Cie
us+l1��rY�,Nf t?

U. S. Deart of Agriculture
Soil;Gst"M Service ll.,,1=;:
HAZIIAP �fyaASSI F I f AyIq 1 KA .SHEET Fqt MM.
an(J]o w - _-
Commni ty or
Estimated D **f, it fiiK Tok, ,6f. :: ` 2 Ft. ! €':)pf, f1a 1 • - - l °- - -Ft.
ling" 7 Date of Field �
Evaluation by reach of flood plain dovmstrem to the point of estimated minor effect
from sudden dasi failure.
of :I1 of @rluch
Reach: Length: lliidth: Sly:' Ltd' Use -Le its 9re :fao ter: Above
Fla Plain: Flood flair
t.
- . �.; _ ..._ . . '�`,�-tom:
2
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach n/n
Hazard Classification. of Dam (a, b, c) (See NEM-r.rt 520.21;
-,Dai`i'Classification. (i, 7I, I11, IV,
By
name
tit Te
Concurred Sy _
j�--------
NOTE: 1. Instructions on reverse ;ide,
2. Attach additional sheets as needed.
�dte �- -7 7
Date__T __ —._

SHEET 1 OF 2
OPERATION AND MAINTENANCE FLAN
------------------------------
Th is I ag -+or+ is des i gned f or waste treatment (permanent storage) and
18f_) days of temporary st:+r-age. The t ime requi red for the p l ar+ned
f 1 u i d I eve I (permanent and temporary star -age) to be reached may vary
due to s i to cc+nd i t i ons, weather-, f I ush i rig operat i +�r+s, and the amount
of fresh water added to the system.
The des i fined temporary storage cons. i sts of 120 days storage for:
(1) waste from animals and ( ) excess rainfall after- evaporation. Also
included is storage for the 25 year -- 'w4 hour- storm for the location.
The volume c+f waste generated from a giver, number- of animals will be
fairly cc+r+st-are t through*ut the year and fr-c+rn year- to year, but excess
ra i nfa l 1 will vary frcem year to year . The Zf year r-a i rlfa l I w i I I not
be a fac tor- to cons i der- i n an ar+nua I pump i Fig cyc I e, but th i s stc+ragie
vc'Iurne roust always be avai Iat+Ie.
A rnax imurn elevation is deter-rr+j ned in each design to begin
pump i ri3 and tir i s i s usua I I y the c+ut l et invert of F� i F'e () fr-C;rn
t+u i 1 d i ng (s) . If the outlet pipe is not installed at the e I evat i c+ri to
begin pumping, a permanent marker- must be installed at this elevation
to indicate when purnp i ng should begin. An e I evat i ._'r: be estab I i sheo'
t+_+ stc'P F+urnp i rig to ma i r,ta i n 1 a300n treatment depth.
Pumping car, be star-ted or stropped at any time bet'-:e r! these two
elevations for operating convenience -as site cond i t a _,!-i s permit, such as
weather, soils, crop, and eau!prnent ir, order to apply waste withe+ut
runoff or i each i n•; _
Land Hipp i 1 cat f !-r! of waste water" is r"e'_ :•-krn i F''_i as a;:
rf:ethod of disposal. Methods of appl ir_ati +r+ include svl Id
center - Fr i': -t, gurs—�, a -r!d tra',/e I i r+g yun i - -r' I ,—at i or, . f_ i.r C' �h,---U I d t,
tat• er' wJ —n aF+Fl l y i n3 wa 7, t4? t:- F'r-e'Ve t J.�rr-7. e F"_ Cf-
!
'.J :a t, is �. _.. ; , i-� _.. , i I : '.1 � � ? W i a `� ' - • I ' <, ' - _; '_ - _' i' - , - er ,• i.: �.:i - --
- _ .. .
t ! : r- r' : ` I. += '� I � 1-, -: r, i :_j ':I -1
I" t �= 1' i �, i t; :t I f i i i rl .q
�rlE i}tt:u-_: ': _':i .Ja to ut i I i -3.t :1r+ F, _.ii C+ci i i
FI I - r+ I {_ i rfl r? r, i 1 =.. i ut F+ i i 1 ,3 •3. n : j t e t I r i
r ! • ; r : i [' ro F' C., r -y. r- . 5r !; _: r.. ci '9 F' r'. ! i rfl F' li '... ;:. - i 1- "� .. .. - r .... r i i • 4 .. I
,. ..
f' �-• , ._ l .. i :. : _ .-. -: �-; t:. .. C'f7 - _ _ - -. :.; f .. .. - I �- i:. .. _• '-' .il
t_� 'i a t I L : _ ._"_-1 '- , _ •'i. I-:. �.' f' ill r.: _ : 1 .. „ . : t _ �1._ ... ._ _.:_ .- _
11

SHEET 2 OF 2
4 . T hiE: recommended me.."nded rllw nimum amount to apply per irrigation is
one { i, ) inch and the recommended maximum application rate is 0.
inch peY_ hour. Reier to the waste utilization plan for further details.
5b eyp :vegetation on the embankment and areas adjacent to the
lagoon mg"e_d annually. Vegetation should be fertilized as needed
to maintain a vigwrou_, stand.
L. Repair any eroded areas or areas damaged by rodents, and
establish in vegetation.
r". All surface runoff is to be diverted from the lagoon to stable
outlets.
n All
8. k::r;ep ca. minimum of 25 feet ref grass vegetated buff air. araeincl
kla5te utilization fields e?djace6t to perennial streams. WAs'_tE'•:.`1?J.1T1-.`.'.:•.."' .}`'r:
not be applied in open ditches. Do not pimp withi.meet
G+f: a.:,',, _'..•
r-•e•_;dence or within 100 'feet of a well . Waste shall. I' -'r
manner not to reach other property and public r3_�ht-Qf.=w�+js
9. The Clean Water- Act of 1977 prohibits the discharge of
pol lutents in Lo waters of the United States. The Department of
Environ!'ent9 Health, and Natural Resources, Division of Environ-, .
mentyl Nana.g__m nt, has the responsibility for enforcing this law.
9
iQCIO

• .A
SHEET t OF
SoiI finer rnaterial shaII come from an approved barrow area. The
minimum water content of the I i ner material .shall be opt i rnum_ rno i stare
content which relates to that moisture content when the soiI is kneaded
in the hand it wi I I f orrn a ba I I wh i ch does not read i I y separate. Water
sh,a I I be added to borrow as necessary to insure proper moisture content
during placement of the I i ner. The moisture content of the I i ner
rnater- i a I sha l I not be I ess than opt i rnurn water content dur i ng p I acernent.
The max i mum water- content re I ates to the so i I mater i a I be i rig too wet
for- of f i c i ent use of hau I i ng equ i prnerrt and proper ccrmpac t i on, Prcper
compaction of the liner incIudes prlacerner,t in 9 inch lifts and
compacted to at least 90 percent of the maximum ASTM D698'_ Dry Unit
Weight of the I i ner- rnater- i a l . When smooth or hard, the previous I i ft
sha I I be scar i f i ed and mc-i i steried as needed before placement rrf the next
lift.
The single rrrr_+5t important factor affectiri3 the r_rveral I cr_rrnpracted per-rft-'_
ab i I i ty of a clay I i ner, other- than the type of clay used for the
I i ner , is the of f i c i ent construct i on process i ng of the compacted I i rrer.
The sequence of equ i prrnerrt use and the rout i rig of equ i prnerrt i r, an estab-
b I i shed pattern he I ps assure un if ormi ty i n the who I e p I acernent art
cornpact i on pr*cess. For most clay so i Is, a tamping c r- sheepsfoot
r-r3l I er- i s the preferatr l e type of compact i r:rri equ i prnerrt.
The so i I I i ner- steal I be p.rotec tern tram the d i scharge of waste out I et
pripres. This car, tie dime by usirig s_rrne type of energy dissiratoriroc l::si
or- using fIex.ible r+utIets orl waste pf:pes.
A I ternat i ves to sir i I I i ners are synthet i s I i ners and beritun i to sea I ant.
Wher, these are spec i f i ed, add i t i ona I construe t t on. Spec i f i rat i C'ns are
iricIuded with this C0T;5tt_Licti-..r1 spec.ificatir_rn_
CUTOFF TRENCH:
A i_ tl t '-' f ? r e rt C rl rl rt I 1 1=r r
__ r_i {'! 4 r lr 1. t k'f"
t rf ;' }_' ii'. .:I a rl 1�- ril 7
a r' e a w' rI e t 1
a t:,p, , r a. I c r-I-: % .
se,_ t i _rn i r,
the •p 3i ... _ F i r1- !
= =pth o F I'-h .
[: L{ is _ T t �- Ir' rY i_- I.1 i r 7. 1i
'i.; r f71 ! 1 r [^, > [� -
.. _- ti r- �.' s i tI _- d s t? l"
J L: s r'j C r
A I I exF1 el aed eft. L1 a rr1 rrr k'r: L ::r IC'r ('ar f C F. ii•_ ,t- _ 4: t.'.
t_r the p i anned type E_rf tat i rrr, as = _ = r1 :ice `rr_, f_ i e tot' :o ri tr uC
t i I:: r, a C C 0r" J 1 r 1 '4 t I_I t f I r F=' r} I rl 5 F C C i T I r_ ?. ;. r-' L.l I IJ t' e p,-
�an J.r"E rL . ir{ tIIF r lli r:•i.1 I.
r"I , r_'- ar's
c; the Y"t:.' _: is f i I F:• f'I I::I B r_I f ° " t- f: i .1 r� .' r' 1: F, • j f^ T 7, t I :� r� Y 5 _- Ll �,: i ri r' � f. z ..
]:motes Frsr ❑eed I ng F'i✓rl;id!Ycrl vee i_ t i rr =iF, D Li ,j Dt= e i': ii: I S ,._'.J 35 S _ ti
! t rr,t ,J i.ise .
h;l fi#i lVA!.. i fig F;. I 'T iN(a T7.i....i:. ='i=; : f,N.:Fs
i-! h r
d r- <a i I I
i
-. s. r r:' ,. i , : �:• : i r, ! ,. , =� _ � , .. ., , � .. _.. i L
cl
C,
t 'rirpac t _•l7ri.-'r' d-

ANIMAL WASTE 1UUMGMMXT PLAN C39RTIFICATZON FOR Nirw OR EXPANDED FEEDLOTS
Please return the completed fors to the Division of Eavironmantal Management at
the add= ess on the reverse side of this for=.
Name of farm (Please print): Pom 1 Jut LAAW
Address: D.
t o Phone No.:
County: ZL.^a-
Farm location: Latitude and Longitude:I° 11 LV IV. st ' a (required)'. Also,
please attach a copy of a county road map with location identified.
Type of operation (swine, layer, dairy, etc.): s win - ns r C
Design capacity (number of animals): o O
Average size of operation"(12 month population avg.): D O
Average acreage needed for land application of waste (acres), l!
saass+aasaaaaa+s++sass+assesess:++asp+ssasasassaasasaaassasssa+s:asaaansasss+s
Technical. Specialist CarCificatioa •
As a technical specialist designated by the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 6F .0005, I certify that the n9se
r
expanded animal waste management system as installed for the fare named
has an animal waste management plan that meets the design, construcaMan,
operation and maintenance standards and specifications of the DivisioK f
Environmental Management and the USDA -Soil Conservation Service and/or the Ira n
Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.021�t3
15A NCAC 6F .0001-.0005. The following elements and their corresponding mi
criteria -haste -been verified by me or other designated technical specialists n
are included in the plans as applicable: minimum separations (buffers); liners or
equivalent for lagoons or waste storage ponds; waste storage capacity; adequate
quantity and amount of land for waste utilization (or use of third party) ; access
or ownership of proper waste application equipment; schedule for timing of
applications; application rates; loading rates; and the control of the discharge
of pollutants from stormwa er runoff�- if v is less severe than the ZS-year, 24-hour
storm. (gyp Acp�: ��r+ Spry {s not- n.s l�td� Qs!- •� -f -
Name of Technical Specialist (Please Print): EMS .ti a G•
Affiliation: V_S A- A)
Address (Agency) : I L c ..& Phone No. 62-6yJ'6
NC-
Signature�_2.1 �� _ �C ' Date:
a ssssaas+sa+saaa�taa+ease+aaaa+s+++saaasasa+sea+ass++a++aaasa=aaaaassaa
Cwner/2Sanager Agreement
I (we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any additional expansion to the existing
design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
surface waters of the state either through a man-made conveyance or through
ranoff from a storm event less severe than the 25-year, 24-hour storm. The
approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of Land owner (Please Print') :_ _Pxyu�{
Signature: ` Date:
Nam& of Hanager, if different from owner (Please print):
Signature: __— __ ___ _ _1 Date:
!tote: A change in land ownership requires notification or a new certification
(if the approved plan is changed) to be submitted to the Division of
Environmental Management within 60 days of a title transfer.
DES USE ONLY : ACITEP; #
0 9 -- is9

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Matt, Steve Hardee, Campbell
Big Bay Nursery
304 Westwood Drive
Elizabethtown NC 28337-7098
Alan W. Klimek, P. E., Director
Division of Water Quality
WEIVED
OCT 15 2004
OW -FAYI ii LLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS090159
Big Bay Nursery
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Matt, Steve Hardee, Campbell:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Matt,
Steve Hardee, Campbell, authorizing the operation of the subject animal waste collection, treatment,
storage and land application system in accordance with General Permit AWG 100000. The issuance of
this COC supercedes and terminates your previous COC Number AWS090159 which expires October 1,
2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Big Bay Nursery, located in Bladen County, with an animal capacity of no
greater than an annual average of 6080 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638 One
NorthCarolina
Phone: [phone] FAX: [phone] I Internet: h2o.enr. state.nc.us )Vatwrallff
An Equal OpportunitylAffirmative Action Employer — 50% Recycledl40% Post Consumer Paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 21-1 .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
v
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AWS090159
APS Central Files

PLO
oA .
NUTRIENT MANAGEMENT PLAN
Grower(s)-
Farm name:
County: 04
Farm Type:
Farm Capacity:
Storage Structure:
Storage Period:
Application Method:
Matt Hardee & Steve
Big Bay Nursery
Bladen
Wean -Feed
6080
Anaerobic Lagoon
180 days
Irrigation
RWO EV p
IARZg 20
R-I`AYEMla RCG a% QlpCf
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each apprcation cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1 _ Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are establisher!.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
Page: 1

problems.
6. To ma)dmize the value of the nutrients for crop production and to reduce the potential
�. for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages brealdng dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan_ Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility_ In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be fle)dble so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
1— 6080 animals X 222.65 gallanimal/year =
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
6080 animals X 0.48 Ibs/animallyear =
1353712 gallons
2,918.40 Ibs
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type, and surface application.
Tract tFiekl I Soil I Crop I Yield Ibs N I Acres I Lbs NfAc I Lbs N I Ibs N Time to
j Type Code IAc /unit Residual /Ac Required A widv
Page: 2

9482 1 St 1 L 5 5 1,10.00
50.00 1 025 1 50.0 512.50 SApril
Total ! 10.25 3331.25
Available N 2918.40
*Difference-412.85
—Indicates that this field is being overseeded (Le_ interplanted) or winter annuals follow summer
annuals.
"A negative number reflects the total lbs of additional nitrogen needed to achieve yields on
acreage listed in chart A positive number means additional acreage is required to utilize the
nitrogen produced by the farm.
NOTE:
This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements_
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of sic to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage jest before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Berrnudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
The following legend explains the crop codes listed in the table above:
Crop Code Crroo
Lbs N utilized / unit.yield
Page: 3

A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N I ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Com - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N I ton
H
Fescue- Hay
50 lbs N / ton
I
Oats
1.3 lbs N 1 bushel
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N / acre
t_
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N / bushel
Acres. shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map`showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 0.072 pounds of plant available nitrogen per animal per year in the
sludge based on the application method listed earlier_
tf you remove the sludge every 5 years, you will have approximately 2188.80
pounds of PAN to utilize. Assuming you apply this PAN to hybrid bermudagrass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 7.30 acres of land. If you apply
the sludge to com at a rate of 125 pounds per acre, you will need 17.51 acres of land_
Please be aware that these are only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil types, realistic yields, and
applications.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
Page: 4

If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Tract
Field
Soil
lypq
Crop
Application Rate
inlhr
Application Amount
inches
1
St
CL
0.50
0.95
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied_ In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions_
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsiabTity of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
Additional Comments:
Page: 5

I�
NUTRIENT MANAGEMENT PLAN CERTIFICATION
/6�6 Ag
— Name of Farm: Nursery
OwnerlManager Agent:
Uwe understand and wifl foDowr and implement the spins and the operation and
maintenance procedures established in the approved animal waste nutiiM management
plan for the farm named above. Uwe know that any expansion to the exisftV design capacity
of the waste Mmftnent ardor starage system, or cow of new fac1bes, wig require a
new nutrient management plan and a new certification to be suited to DWQ before the new
animals are stocked.
Uwe understand that k must own or hanre access to equiprfnt, pritnaul► won equipa mt,
to land apply the animal waste described in this nutrient ff aragement plan. This equipment
must be available at the appropriate purr4 ing time such that no discharge occurs frown the Jagoon
in the event of a 25 year 24 hour storm. l also certify thad the waste will be appfied on the land
according to this plan at the aWapriate fines and at rates which produce no nnwff.
This plan will be filed on site at the farm office and at the offie of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Fadi ft Owner:
Signature:
fil- O-Zf-
Name of Manager rd different from owner):
Signature:
Name of Technical Specialist:
Affiliation:
Address:
Signature:
Please Print
Sonya Johnson Barber
Harvest Net, Inc.
P.O. Box 32
Council, NC 28433
97-0
Date
2 ta�Q�
Page: 7

5W BraMn Road
Hope Mills NG 28346
910-423-2212
Fax
To: 'John R
Fam 0104860707
phone: [phone]
RL-- Lagoon lkeve�IS� fO
(urgent
( Pie Reply
FY==
Pa
Date: 411/03--.
cc:
For Review (Phubse Comment
please keCYCft
John, as recommended last week, this is a folkm-up on the lagoon levels reported on 321103.
I- GlennBrisson:
Crooked Branch Nursery
Big Bay Nursery -
�Ral&Mn Branch Nursery -
2. Jerry Graham Finishing Farm - I/z
3. Barry Billups,
_,Finwlillq faun - 7"",�
b. Nursery #1 at Ammon -
-- c, Nursery #2 at White Oak - rv-dwc +16- /A
4- Ronald Hutchinson - Iq
S. Mitchell Norris,
J-11 a. Farm 1 - /4 " (14 h
b. Farm 2 —
TO 3DVd NV9M AHIVA ZTZZEZV6T6 VZ-90 600Z/T0/170