WQ0028653_Inspection_20190124

State of North Carolina
Division of Water Resources
Water Quality Regional Operations Section
Environmental Staff Report
Quality
To: ❑ NPDES Unit ® Non -Discharge Unit Application No.: WQ0028653
Attn: Troy Doby, RCO Facility: Pilgrim's Pride Corp.
Distribution of CIass A Residuals
From: Thomas McKinney, RRO Alum Water Treatment Plant Residuals
County: Lee
Note: This form has been adapted from the non -discharge facility staff report to document the review of both non -
discharge and NPDES permit applications and/or renewals. Please complete all sections as they are applicable.
I. GENERAL AND SITE VISIT INFORMATION
1. Was a site visit conducted? ® Yes or ❑ No
a. Date of site visit: 01/24/2019
b. Site visit conducted by: T. McKinney
c. Inspection report attached? ❑ Yes or ®No
d. Contacted: Tina Pedley [phone] ([e-mail])
e. Directions: From Raleigh, Hwy Ito Pittsboro, 421 North at Pittsboro, exit north Cumnock Rd., plant on right.
2. Discharge Point(s): NA non -discharge
Latitude: Longitude:
Latitude: Longitude:
3. Receiving stream or affected surface waters: NA
Classification: NA
River Basin and Sub -basin No. NA
Describe receiving stream features and pertinent downstream uses: NA
H. EXISTING FACILITIES: RENEWAL APPLICATION
Are there appropriately certified Operators in Charge (ORCs) for the facility? ❑ Yes ❑ No ® NIA
ORC: Tina Pedley for Class B permit Certificate #: LA 995896
1. Are the design, maintenance and operation of the treatment facilities adequate for the type of waste and disposal
system? ® Yes or ❑ No
FORM: WQROSSR 04-14 Page 1 of 4

2. Explain anything observed during the site visit that needs to be addressed by the permit, or that maybe important
for the permit writer to know.
No changes needed.
3. Are the site conditions (e.g., soils, topography, depth to water table, etc.) maintained appropriately and adequately
assimilating the waste? ® Yes or ❑ No
If no, please explain:
4. Has the site changed in any way that may affect the permit (e.g., drainage added, new wells inside the compliance
boundary, new development, etc.)? ❑ Yes or ® No
If yes, please explain:
5. Is the residuals management plan adequate? ® Yes or ❑ No
If no, please explain:
6. Are the existing application rates (e.g., hydraulic, nutrient) still acceptable? ® Yes or ❑ No
If no, please explain:
7. Is the existing groundwater monitoring program adequate? ❑ Yes ❑ No ® NIA
If no, explain and recommend any changes to the groundwater monitoring program:
r
8. Are there any setback conflicts for existing treatment, storage and disposal sites? ❑ Yes or ® No
If yes, attach a map showing conflict areas.
9. Is the description of the facilities as written in the existing permit correct? ® Yes or ❑ No
If no, please explain:
10. Monitoring wells properly constructed and located? ❑ Yes ❑ No ® NIA
If no, please explain:
FORM: WQROSSR 04-14 Page 2 of 4

IV. ADDITIONAL REGIONAL STAFF REVIEW ITEMS
1. The facility's two WTP alum lagoons, with wastewater from the clarifier and sand filter backwash, both appear to
be in good condition.
2. The facility maintains the required records of land application events for the Class A residuals.
3. The facility has been submitting annual reports with proper analysis for metals, non -hazardous determination, and
pathogen reduction. The non -hazardous detemunation is now required only once per permit cycle.
FORM: WQROSSR 04-14 Page 4 of 4

III. REGIONAL OFFICE RECOMMENDATIONS
1. Do you foresee any problems with issuance/renewal of this permit? ❑ Yes or ® No
No violations or problems indicated in BIMS database.
2. List any items that you would like the NPDES Unit or Non -Discharge Unit Central Office to obtain through an
additional information request:
Item Reason
3. List specific permit conditions recommended to be removed from the permit when issued:
Condition Reason
4. List specific special conditions or compliance schedules recommended to be included in the permit when issued:
Condition Reason
5. Recommendation: ❑ Hold, pending receipt and review of additional information by regional office
❑ Hold, pending review of draft permit by regional office
❑ Issue upon receipt of needed additional information
® Issue
❑ Deny (Please state reasons: }
6. Signature of report preparer:
Signature of regional supervis
Date:
FORM: WQROSSR 04-14 Page 3 of 4