HomeMy WebLinkAboutWQ0013205_Final Permit_19970121State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
January 21, 1997
Mr. Mike Wilkes
156 Shady Lane
Winston-Salem, North Carolina 27107
01�0 % A0001�%
[DEHNR
Subject: Permit No. WQ0013205
Mr. Mike Wilkes
Single Family Wastewater
Spray Irrigation Facility
Davidson County
Dear Mr. Wilkes:
In accordance with your application received November 22, 1996, we are forwarding herewith
Permit No. WQ0013205, dated January 21, 1997, to you for the construction and operation of the subject
single family wastewater treatment and spray irrigation facilities.
This permit shall be effective from the date of issuance until December 31, 2001 and shall be
subject to the conditions and Iimitations as specified therein. PIease pay particular attention to the
monitoring requirements in this permit. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within thirty (30) days following receipt of
this permit. This request must be in the form of a written petition, conforming to Chapter 150B of the
North Carolina General Statutes, and filed with the Office of Administrative Hearings, P.O. Drawer
27447, Raleigh, NC 27611-7447. Unless such demands are made this permit shall be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this matter, please contact Rick Moore at (919) 733-5083 extension 527.
Sincerely,
fi�/r.-
A. Preston Howard, Jr., P.E.
cc: Davidson County Health Department
Winston-Salem Regional Office, Water Quality Section
Training and Certification Unit
Facilities Assessment Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone (919) 733-5083 FAX (9 19) 733-0719
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper
NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
SINGLE FAMILY SPRAY IRRIGATION PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Mr. Mike Wilkes
Davidson County
FOR THE
construction and operation of a 480 GPD spray irrigation wastewater treatment and disposal system
consisting of a 1,200 gallon baffled septic tank, a 420 ft2 primary subsurface sand filter in series with a
210 ft2 subsurface sand filter, a tablet chlorinator, two 1,200 gallon tanks in series to serve as a storage
and pump tank combination, and a 9,583 ft2 spray irrigation area to serve the Wilkes Residence, with no
discharge of wastes to the surface waters, pursuant to the application received November 22, 1996, and in
conformity with the project plan, specifications, and other supporting data subsequently filed and
approved by the Department of Environment, Health and Natural Resources and considered a part of this
permit.
This permit shall be effective from the date of issuance until December 31, 2001 and shall be
subject to the following specified conditions and limitations:
I. PERFORMANCE STANDARDS
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted
facility has been installed in accordance with this permit, the approved plans and
specifications, and other supporting materials. Mail the Certification to the Water Quality
Permits and Engineering Unit, P.O. Box 2.9535, Raleigh, NC 27526-0535.
2. The Winston-Salem Regional Office, telephone number (910) 771-4600 shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an in-
place inspection can be made. Such notification to the regional supervisor shall be made
during the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday,
excluding State Holidays.
3 . The spray irrigation facilities shall be effectively maintained and operated at all times so that
there is no discharge to the surface waters, nor any contamination of ground waters which
will render them unsatisfactory for normal use. In the event that the facilities fail to
perform satisfactorily, including the creation of nuisance conditions or failure of the
irrigation area to adequately assimilate the wastewater, the Permittee shall take immediate
corrective actions including those actions that may be required by the Division of Water
Quality, such as the construction of additional or replacement wastewater treatment and
disposal facilities.
4. The issuance of this permit shall not relieve the Permittee of the responsibility for damages
to surface or groundwaters resulting from the operation of this facility.
5. The sand media of the subsurface sandfilters must comply with the Division's sand
specifications. The engineer's certification will serve as evidence that these specifications
have been met.
6. A leakage test shall be performed on the septic tank and dosing tank to insure that any
exfiltration occurs at a rate which does not exceed twenty (20) gallons per twenty-four (24)
hours per 1,000 gallons of tank capacity. The engineer's certification will serve as proof of
compliance with this condition.
7. If excavation into bedrock is required for the installation of the septic tank or sand inter, the
pit shall be lined with a 10 mil synthetic liner.
8. A sanitary tee shall be installed on the effluent pipe of the septic tank. The engineer's
certification will serve as evidence that these specifications have been met.
9. The residuals generated from these treatment facilities must be disposed in accordance with
General Statute 143-215.1 and in a manner approved by the North Carolina Division of
Water Quality.
10_ Diversion or bypassing of the untreated wastewater from the treatment facilities is
prohibited.
11. The following buffers shall be maintained:
a) 400 feet between wetted area and any residence or places of public assembly under
separate ownership,
b) 150 feet between wetted area and property lines,
c) 100 feet between wetted area and wells,
d) 100 feet between wetted area and drainageways or surface water bodies,
e) 50 feet between wetted area and public right of ways,
f) 100 feet between treatment/storage units and any wells, and
g) 50 feet between treatment units and property lines.
H. OPERATION AND MAINTENANCE REQUIREMENTS
1. The facilities shall be properly maintained and operated at all times.
2. Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of
the wastewater treatment facilities. The operator must hold a certificate of the type and
grade at least equivalent to or greater than the classification assigned to the wastewater
treatment facilities by the Certification Commission. The Permittee must also employ a
certified back-up operator of the appropriate type and grade to comply with the conditions
of Title 15A, Chapter 8A, .0202_ The ORC of the facility must visit each Class I facility at
least weekly and each Class 11, III, and IV facility at least daily, excluding weekends and
holidays, and must properly manage and document daily operation and maintenance of the
facility and must comply with all other conditions of Title 15A, Chapter 8A, .0202.
3. A suitable vegetative cover of hardwoods and undergrowth shall be maintained.
4. Irrigation shall not be performed during inclement weather or when the ground is in a
condition that will cause runoff.
5. Adequate measures shall be taken to prevent wastewater runoff from the spray field.
6. The application rate shall not exceed a cumulative loading of 34.74 inches over any twelve
(12) month period at an instantaneous application rate not to exceed 0.4 inches per hour.
7. The facilities shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of any wastewater resulting from the operation of this facility.
8. No type of wastewater other than that from the Wilkes Residence shall be sprayed onto the
irrigation area.
9. In the event that the sprinkler heads fail to achieve the design diameter of 60 feet due to
obstructions, the obstructions shall be removed or the sprinkler heads shall be raised and
supported to such height that the design diameter is achieved.
10. No traffic or equipment shall be allowed on the disposal area except while installation
occurs or while normal maintenance is being performed.
11. The spray irrigation field shall be fenced with at least a two strand wire fence.
12. The Permittee is responsible for the operation and maintenance of the entire treatment and
disposal system including, but not limited to, the following items:
a. The septic tank shall be checked annually and pumped out as needed.
b. The tablet chlorinator shall be checked every week. Tablets shall be added so as to
provide proper chlorination.
c. The storage, pump, and alarm systems shall be inspected weekly. The scum layer shall
be removed at the same interval as the septic tank is cleaned out.
d. The spray system shall be inspected weekly to make certain of the sprayers proper
operation, that the vegetative growth allows a proper spray pattern, that the soil is
assimilating the disposed treated wastewater with no surface runoff, and that no
objectionable odors are being generated.
III. MONITORING AND REPORTING REQUIREMENTS
1. Any monitoring deemed necessary by the Division of Water Quality to insure surface and
ground water protection will be established and an acceptable sampling reporting schedule
shall be followed.
2. The Permittee shall maintain records of all maintenance performed on the system and
irrigation area, as required in Condition 11 12 for a minimum of five years. This
information shall be provided to the Division of Water Quality upon request. .
3. Noncompliance Notification:
The Permittee shall report by telephone to the Winston-Salem Regional Office, telephone
number (910) 771-4600 as soon as possible, but in no case more than 24 hours or on the
next working day following the occurrence or first knowledge of the occurrence of any of
the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility
incapable of adequate wastewater treatment, such as mechanical or electrical failures of
pumps, spray heads, etc.; or
b. Any failure of a pumping station or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or
facility.
Persons reporting such occurrences by telephone shall also file a written report in letter
form within five (5) days following first knowledge of the occurrence. This report must
outline the actions taken or proposed to be taken to ensure that the problem does not recur.
IV. INSPECTIONS
1. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to
insure proper operation of the subject facilities.
2. Any duly authorized officer, employee, or representative of the Division of Water Quality
may, upon presentation of credentials, enter and inspect any property, premises or place on
or related to the disposal site or facility at any reasonable time for the purpose of
determining compliance with this permit, may inspect or copy any records that must be
maintained under the terms and conditions of this permit, and may obtain samples of
groundwater, surface water, or leachate.
V. GENERAL CONDITIONS
This permit shall become voidable unless the facilities are constructed in accordance with
the conditions of this permit, the approved plans and specifications, and other supporting
data.
2. This permit is effective only with respect to the nature and volume of wastes described in
the application and other supporting data.
3. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be
submitted to the Division of Water Quality accompanied by an application fee,
documentation from the parties involved, and other supporting materials as may be
appropriate. The approval of this request will be considered on its merits and may or may
not be approved.
4. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division of Water Quality in accordance with
North Carolina General Statute 143-215.6(a) to 143-215.6(c).
5. The issuance of this permit does not preclude the Permittee from complying with any and
all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.
6. This permit may be revoked if the Permittee fails to abide by the conditions of the
"Operation and Maintenance Agreement" previously signed by the Pem-iittee.
4
7. A set of approved plans and specifications for the subject project must be retained by the
Permittee for the life of the project.
8. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the
facilities described therein, and if warranted, will extend the Permit for such period of time
and under such conditions and limitations as it may deem appropriate.
9. The potable water supply well shall not be located within 100 feet of any of the collection,
treatment and disposal system.
Permit issued this the 21 st day of January, 1997.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
Zvi—
Prestooward, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ001.3205
Permit No. WQOO13205
January 21, 1997
ENGINEER'S CERTIFICATION
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project,
Project Name
Location
for the
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the construction such that the construction was observed to be built within substantial compliance and
intent of this permit, the approved plans and specifications, and other supporting materials.
Signature
Date
C7
Registration No.
n
r
0
IV
0
M
c
E
MT,-
%drv-,Vwo�\ �
� Illi
c
OPERATION AND MAINTENANCE AGREEMENT FOR THE
DIVISION OF ENVIRONMENTAL MANAGEMENT
Mr. Mike Wilkes
156 Shady Lane
Winston-Salem, NC 27107
Single Family Residence Wastewater Treatment System
Final Disposal by Spray Irrigation
Permit No. WQ W 13205
Davidson County
I agree to operate and maintain the wastewater treatment system as follows:
1. The Permittee is responsible for the operation and
maintenance of the entire treatment and disposal system
including, but not limited to, the following items:
a. Septic tank shall be inspected at least once every six
months. Sludge shall be pumped out when the tank is 1/3
full of sludge, or every three years, whichever comes first.
b. The tablet chlorinator shall be checked every week until the
actual usage rate is established and thence on a monthly
basis. Tablets shall be added so as to provide proper
chlorination.
C. The storage system, pump system, and alarm system shall be
inspected monthly. The scum layer shall be removed at the
same interval as the septic tank is cleaned out.
d. The spray system shall be inspected monthly to make certain
of the spray nozzles's proper operation, that the vegetative
growth allows proper spray patterns, that the soil is
absorbing the disposed treated wastewater with no surface
runoff, and that no objectionable odors are being generated.
2. Failure of the Permittee to properly operate this system is
subject to a penalty up to $10,000 per day.
3. Failure to meet permit conditions or violation of the State's
surface or groundwater regulations will require cessation of
occupancy of the residence.
I understand that failure to comply with these conditions along with the
permit conditions may result in voiding the permit.
Signatures Date; 'ev4,C u
Mike Wilkes
Notary Seal
Notary Signature: Date:
NOTARY PUSt►C, NORM CAROLINA
r COUNTY OF DAYMSON
} WILLIAM K RUSSELL
Mb Cp(s Issin Expires AQgO 2L, /199
RATING SCALE FOR CLASSIFICATION OF WATER POLLUTION CONTROL SYSTEMS
Name of Facilitv.
Owner or Contac
Mailing Address:
County:
Present
NPDES
'�Z/ 1,f���/'� - .,. Telephone:
Classification: New FacilityExisting Facility
Per. No. NCOO Nondisc. Per. No.WQ / Health Dept.Per No.
Rated by: Telephone:
Reviewed by: _ Health Dept. Telephone:
Regional Office
Central Office
ORC: Grad
Check Classification (s): Subsurface j/ Spray Irrigation
Wastewater Classification: (Circle One) 1 it 111 IV
Telephone: 77/- ' — e,` 9/ej
Telephone:
Telephone:
Land Application
Total Points:
'%1F41#1d;I;:01 11 '��►���i�t�:l ! ►11'wl� a�. ir��3►l al�:�a: :\ 111r. �:1 ►! �1: :I`w�i* Iii\"�: ►�
t�,�� ! ! I �. 1 l� : L�\I a�w 1 : af� �i iv • �\ .� 1. :.0 1 +�� �� y \.►: �i JI. , 4►�•
:►■ -:: Ill ►111: �.: 1�► ► :: � „J �aw,,i :� �.: �►
SUBSURFACE CIASSIF)CATION
(check all units that apply)
1. septic tanks
2. pump tanks
3. siphon or pump -dosing systems
4. sand filters
5. grease traplinierceptor
6. oil/water separators
7. gravity subsurface treatment and disposal:
8. pressure subsurface treatment and disposal:
SPRAY IRRIGATION CtASSIFiC»ATION
(check all units that apply)
1. preliminary treatment (definition no. 32 )
2. Dans
3. septic tanks
4. - p tanks
5,��ps
6.:Lsand filters
7. grease trapinterceptor
water separators
9. disinfection
10, chemical addition for nutrient/algae control
11. spray irrigation of wastewater
In addition to the above classifications, pretreatment of wastewater in excess of these components shall
be rated using the point rating system and will require an operator with an appropriate dual certification.
LAND APPLICATIONIRESIDUALS CLASSIFICATION (Applies only to permit holder)
1. Land application of biosolids, residuals or contaminated soils on a designated site.
-------------------------
WASTEWATER TREATMENT TT FACILITY CLASSIFICATION
The following systems shall be assigned a Class I classification, unless the flow is of a significant quantity or the technology is unusually
complex, to require consideration by the Commission on a case-by-case basis: (Check if Appropriate)
1. Oit/water Separator Systems consisting only of physical separation, pumps and disposal;
2. Septic Tank/Sand Filter Systems consisting only of septic tanks, dosing apparatus, pumps,sand filters, disinfection
and direct discharge;
3. lagoon Systems consisting only of preliminary treatment, lagoons, pumps, disinfection, necessary chemical treatment for
algae or nutrient control, and direct discharge;
4. Closed-loop Recycle Systems;
5. Groundwaler Remediation Systems consisting only of oil/water separators, pumps, air -stripping, carbon adsorption, disinfection
and disposal;
6. Aquaculture operations whh discharge to surface waters;
7. Water Plant sludge handling and back -wash water treatment;
a. Seafood processing consisting of screening and disposal.
9. Single-family discharging systems, with the exception of Aerobic Treatment Units, will be classified if permitted after July 1,
1993 or H upon inspection by the Division, H is found that the system is not being adequately operated or maintained. Such
systems will be notified of the classification or reclassification by the Commission, in writing.