WQ0005271_Final Permit_19910816

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27626-0535
James G. Martin, Governor
William W. Cobey, Jr., Secretary
George T. Everett,Ph.D.
Director
August 16, 1991
Mr. Irvin M. Allen
Cleveland County Health Department
315 Grove Street
Shelby, North Carolina 28150
Subject: Permit No. WQ0005271
Cleveland County Manned Solid
Waste/Recycling Site # 4, Mid -Pines
Subsurface Disposal System
Cleveland County
Dear Mr. Allen:
In accordance with your application received June 24, 1991, we are forwarding herewith
Permit No. WQ0005271, dated August 16, 1991, to County of Cleveland for the construction and
operation of a 100 GPD septic tank subsurface wastewater disposal system.
This permit shall be effective from the date of issuance until rescinded, and shall be subject
to the conditions and limitations as specified therein- Please pay particular attention to the
monitoring requirements in this permit. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable to you,
you have the right to request an adjudicatory hearing upon written request within 30 days
following receipt of this permit. This request must be in the form of a written petition,
conforming to Chapter 150B of North Carolina General Statutes, and filed with the Office of
Administrative Hearings, P.O. Drawer 27447, Raleigh, NC 27611-7447. Unless such demands
are made this permit shall be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need
additional information concerning this matter, ple contact Mr. John Seymour at 919/ 733-5083.
Since ely,
U)/J'V
George T. Everet
r
cc: Cleveland County Health Department
Mooresville Regional Office
Groundwater Section
Pollution Prevention Pays
P.O_ Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

C*� NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
SUBSURFACE DISPOSAL SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 1.43, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
County of Cleveland
Cleveland County
FOR THE
construction and operation of a 100 GPD septic tank subsurface wastewater disposal system
consisting of a 1.,000 gallon septic tank, a nitrification field with two 45 foot long 4 inch
nitrification lines and associated piping, valves and appurtenances to serve the one man bathroom
facility at Cleveland County Manned Solid Waste/ Recycle Site # 4 called Mid -Pines with no
discharge of wastes to the surface waters, pursuant to the application received June 24, 1991 and
in conformity with the project plan, specifications, and other supporting data subsequently filed
and approved by the Department of Environment, Health and Natural Resources and considered a
part of this permit.
This permit shall be effective from the date of issuance until recinded and shall be subject to
the following specified conditions and limitations;
1. PERFORMANCE STANDARDS
1. Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the
permitted facility has been installed in accordance with this permit, the approved
plans and specifications. Mail the Certification to the Permits and Engineering
Unit, P.O. Box 29535, Raleigh, NC 27626-0535.
2, The Mooresville Regional Office, phone no. 704/ 663-1699, shall be notified at
least forty-eight (48) hours in advance of backfilling of the installed facilities so
that an in-place inspection can be made. Such notification to the regional supervisor
shall be made during the normal office hours from 8:00 a.m. until 5:00 p.m. on
Monday through Friday, excluding State Holidays.
3. In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as construction of additional or
replacement wastewater treatment or disposal facilities.
4. The issuance of this permit shall not relieve the Permittee of the responsibility for
damages to surface or groundwaters resulting from the operation of this facility.

CZ'
5. This permit shall become voidable if the soils fail to adequately absorb the wastes
and may be rescinded unless the facilities are installed, maintained, and operated in
a manner which will protect the assigned water quality standards of the surface
waters and ground waters.
6. Adequate measures shall be taken to divert stormwater from the disposal area and
prevent wastewater runoff from the subsurface disposal field.
7. The sludge generated from these treatment facilities must be disposed of in
accordance with General Statute 143-215.1 and in a manner approved by the North
Carolina Division of Environmental Management-
8.
anagement_8. A usable reserve area shall be maintained for wastewater disposal. The reserve area
shall have the capability of accommodating the average daily flow of the facility
being served without exceeding the loading rates of the reserve area while meeting
all required buffer requirements.
9. Diversion or bypassing of the untreated wastewater from the treatment facilities is
prohibited.
10. The following buffers shall be maintained:
a) 100 feet between disposal area and any public or private water supply including
wells
b) 100 feet between disposal area and "SA and SB" classified surface waters
c) 50 feet between disposal area and any stream, lake, river or natural drainageway
d) 10 feet between disposal area and property lines (as per variance)
e) 10 feet between disposal area and surface water interceptor drains or diversions
(upslope)
f) 25 feet between disposal area and surface water interceptor drains or diversions
(downslope) and groundwater drainage systems.
11. A leakage test shall be performed on the septic tank and dosing tank to insure that
any exfiltration occurs at a rate which does not exceed twenty (20) gallons per
twenty-four (24) hour per 1,000 gallons of tank capacity. The engineer's
certification will serve as proof of compliance with this condition.
H. OPERATIONAND MAINTENANCE RE, OUIRENIENTS
The facilities shall be properly maintained and operated at all times.
2. The application rates to the disposal field shall not exceed 0.4 gallons per square
foot/ day.
3. The facilities shall be effectively maintained and operated as a non -discharge system
to prevent the discharge of any wastewater resulting from the operation of this
facility.
4. No traffic or equipment shall be allowed on the disposal area except while
installation occurs or while normal maintenance is being performed.
2

11f 1. MONITORING AND REPORTING REQUIREMENTS
1. Any monitoring deemed necessary by the Division of Environmental Management
to insure surface and ground water protection will be established and an acceptable
sampling reporting schedule shall be followed.
If Groundwater sampling indicates or predicts problems with the compliance with
Groundwater Standards, this permit will be modified to include additional and/or
more restrictive Iimitations.
2. A record shall be maintained of all residuals removed from this facility. This record
shall include the name of the hauler, permit authorizing the disposal or a letter from
a municipality agreeing to accept the residuals, date the residuals were hauled, and
volume of residuals removed.
Noncompliance Notification:
The Permittee shall report by telephone to the Mooresville Regional Office,
telephone no. 704/ 663-1699, as soon as possible, but in no case more than 24
hours or on the next working day following the occurrence or first knowledge of
the occurrence of any of the following:
Any occurrence at the wastewater treatment facility which results in the
treatment of significant amounts of wastes which are abnormal in quantity
or characteristic, such as the dumping of the contents of a basin or tank; the
known passage of a slug of hazardous substance through the facility; or any
other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render the
facility incapable of adequate wastewater treatment such as mechanical or
electrical failures of pumps, aerators, compressors, etc.
Any failure of a pumping station, sewer line, or treatment facility resulting
in a by-pass of all or any portion of the influent to such station or facility.
d. Any time that self-monitoring information indicates that the facility has gone
out of compliance with its permit limitations.
Persons reporting such occurrences by telephone shall also.file a written report in
letter form within 15 days following first knowledge of the occurrence. This report
must outline the actions taken or proposed to be taken to ensure that the problem
does not recur.
IV. GROUND -WATER REQUIREMENTS
1. Any groundwater quality monitoring as deemed necessary by the Division of
Environmental Management shall be provided.
V. INSPECTInNS
1. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee
to insure proper operation of the subject facilities.
3

2. The Permittee or his designee shall inspect the wastewater treatment and disposal
facilities to prevent malfunctions and deterioration, operator errors and discharges
which may cause or lead to the release of wastes to the environment, a threat to
human health, or a nuisance. The Permittee shall keep an inspection log or
summary including at least the date and time of inspection, observations made, and
any maintenance, repairs, or corrective actions taken by the Permittee. This log of
inspections shall be maintained by the Permittee for a period of three years from the
date of the inspection and shall be made available upon request to the Division of
Environmental Management or other permitting authority.
3. Any duly authorized officer, employee, or representative of the Division of
Environmental Management may, upon presentation of credentials, enter and
inspect any property, premises or place on or related to the disposal site and facility
at any reasonable time for the purpose of determining compliance with this permit;
may inspect or copy any records that must be kept under the terms and conditions
of this permit; or may obtain samples of groundwater, surface water, or leachate.
VI. GENERAL CONDITIONS
1. This pemait shall become voidable unless the facilities are constructed in accordance
with the conditions of this permit, the approved plans, specifications and other
supporting data.
2. This permit is effective only with respect to the nature and volume of wastes
described in the application and other supporting data.
3. This permit is not transferable. In the event there is desire for the facilities to
change ownership, or there is a name change of the Permittee, a formai permit
request must be submitted to the Division of Environmental Management
accompanied by an application fee, documentation from the parries involved, and
other supporting materials as may be appropriate. The approval of this request will
be considered on its merits and may or may not be approved.
4. Prior to any transfer of this land, a notice shall be given to the new owner that gives
full details of the materials applied or incorporated at this site.
5. A set of approved plans and specifications for the subject project must be retained
by the applicant for the life of the project.
6. Failure to abide by the conditions and limitations contained in this permit may
subject the Permittee to an enforcement action by the Division of Environmental
Management in accordance with North Carolina General Statute 143-215.6.
7. The subject wastewater treatment and disposal facilities shall be connected to an
operational publicly owned wastewater collection system within 180 days of its
availability to the subject facilities, if the subject wastewater treatment or disposal
terms and conditions of this non -discharge permit or the governing statutes or
regulations.
Prior to the initiation of these connection activities, appropriate approval must be
received from this Division.
8. The issuance of this permit does not preclude the Permittee from complying with
any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
4

t� w
Permit issued this the 16th day of August, 1991
'IH CAROLINA
George T. Ever t, .
Division of Envikfl
By Authority of the
L MANAGEMENT COMMISSION
Management Commission

Permit No. WQ0005271
August 1.6, 1991
Engineer's Certification
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of
the
project, for the
Project Name Location
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within
substantial compliance and intent of the approved plans and specifications.
Signature
Date
D
Registration No.
f�;

•'!�
zr
vis
IV
'1. ; /�� OI —_ y - � ' r �� \ /1 1 ,1` _ • rte. -
�. � •: �• - :� -,.._ F, f. r � - - '.\ � 1. _.
co
1 _• J= -
,
13 MI. I-+ •o r _, T O. S••7' m '"' � cn GAS:ON IA !4
rE 3> F,• N tO r opo w Z u YCHARLOTTE 3f •_.'I
W (7 O
T
A wl,c4hm Ala . u1rs d D05".Z 7�