WQ0004058_Final Permit_19901113

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Environmental Management
512 North Salisbury Street - Raleigh, North Carolina 27611
James G. Martin, Governor
William W. Cabey, Jr., Secretary
Mr. William E. Frye,
Director of Maintenance
Stanly County Board of Education
Post Office Box 1399
Albermarle, North Carolina 28002-1399
Dear Mr. Frye:
George T. Evere01LD.
Director
November 13, 1990
Subject: Permit No. WQ0004058
Stanly County Board of Education
Ridgecrest Elementary School
Subsurface Disposal System
Stanly County
In accordance with your application received August 29, 1990, we are forwarding
herewith Permit No. WQ0004058, dated November 13, 1990, to Stanly County Board of
Education for the construction and operation of a 3,600 GPD low pressure pipe subsurface
wastewater disposal system.
This permit shall be effective from the date of issuance until October 31, 1995, and shall
be subject to the conditions and limitations as specified therein. Please pay particular attention to
the monitoring requirements in this permit. Failure to establish an adequate system for collecting
and maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable to you,
you have the right to request an adjudicatory hearing upon written request within 30 days
following receipt of this permit. This request must be in the form of a written petition,
conforming to Chapter 150B of North Carolina General Statutes, and filed with the Office of
Administrative Hearings, P.O. Box 11666, Raleigh, NC 27604. Unless such demands are made
this permit shall be final and binding.
One set of approved plans and spec
additional information concerning this matter
cc: Stanly County Health Department
Mooresville Regional Office
Groundwater Section
Training and Certification Unit
Mr. J. Thurman Horne, P.E.
s is being Zvi r` CU%A%d to yiit]. If you need
:ontact Mr. John Seymour at 9191733-5083.
George T.
Pollution Prevention Pays
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
RALEIGH
SUBSURFACE DISPOSAL SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Sfanly County Board of Education
Stanly County
!0, 1 •1,
construction and operation of a 3,600 GPD subsurface wastewater disposal system consisting of
an existing grease trap, an existing 5,300 gallon septic tank, a 145 GPM pump tank with dual
submersible pumps and high water alarms, dual 4 -inch force mains approximately 660 linear feet
and 800 linear feet, 2,800 linear feet of 1.25 -inch distribution lines ( total of 14,400 square feet at
5 feet between laterals) and associated valves, piping and appurtenances to serve Ridgecrest
Elementary School with no discharge of wastes to the surface waters, pursuant to the application
received August 29, 1990, and in conformity with the project plan, specifications, and other
supporting data subsequently filed and approved by the Department of Environment, Health and
Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until October 31, 1995, and shall be
subject to the following specified conditions and limitations:
UlEff ITeffiri ff-M,"M AM trala1;;1
1. Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the
permitted facility has been installed in accordance with this permit, the approved
plans and specifications. Mail the certification to the Permits and Engineering Unit,
P.O. Box 27687, Raleigh, NC 27611-7687.
2. The Mooresville Regional Office, phone no. 704/ 663-1699, shall be notified at
least forty-eight (48) hours in advance of backfilling of the installed facilities so
that an in-place inspection can be made. Such notification to the regional supervisor
shall be made during the normal office hours from 8:00 a.m. until 5:00 p.m. on
Monday through Friday, excluding State Holidays.
3. In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as construction of additional or
replacement wastewater treatment or disposal facilities.

4. The issuance of this permit shall not relieve the Permittee of the responsibility for
damages to surface or groundwaters resulting from the operation of this facility.
5. This permit shall become voidable if the soils fail to adequately absorb the wastes
and may be rescinded unless the facilities are installed, maintained, and operated in
a manner which will protect the assigned water quality standards of the surface
waters and ground waters.
6. Adequate measures shall be taken to divert stormwater from the disposal area and
prevent wastewater runoff from the subsurface disposal field.
7. The sludge generated from these treatment facilities must be disposed of in
accordance with General Statute 143-215.1 and in a manner approved by the North -
Carolina Division of Environmental Management.
8. A usable reserve area shall be maintained for wastewater disposal. The reserve area
shall have the capability of accommodating the average daily flow of the facility
being served without exceeding the loading rates of the reserve area while meeting
all required buffer requirements.
9. Diversion or bypassing of the untreated wastewater from the treatment facilities is
prohibited.
10. The following buffers shall be maintained:
a) 100 feet between disposal area and any public or private water supply including
wells
b) 100 feet between disposal area and "SA and SB" classified surface waters
c) 50 feet between disposal area and any stream, lake, river or natural drainageway
d) 50 feet between disposal area and property lines
e) 10 feet between disposal area and surface water interceptor drains or diversions
(upslope)
f) 25 feet between disposal area and surface water interceptor drains or diversions
(downslope) and groundwater drainage systems.
11. A leakage test shall be performed on the septic tank and dosing tank to insure that
any exfiltration occurs at a rate which does not exceed twenty (20) gallons per
twenty-four (24) hour per 1,000 gallons of tank capacity. The engineer's
certification will serve as proof of compliance with this condition.
1. The facilities shall be properly maintained and operated at all times.
2. The application rates to the disposal field shall not exceed 0.25 GPD per square
foot.
3. The facilities shall be effectively maintained and operated as a non -discharge system
to prevent the discharge of any wastewater resulting from the operation of this
facility.
4. No traffic or equipment shall be allowed on the disposal area except while
installation occurs or while normal maintenance is being performed..
5. A suitable cover shall be maintained on the LPP field(s) and the field(s) shall be
kept mowed. The clippings shall be removed to prevent the build up of thatch.
K

6. The low pressure lines shall be purged monthly using potable water or air pressure
and the pressure adjusted on the distribution lines to approved specifications.
u 1► 11 ► :►� '1' ► u.. ►
1. Any monitoring deemed necessary by the Division of Environmental Management
to insure surface and ground water protection will be established and an acceptable
sampling reporting schedule shall be followed.
2. Adequate records showing all maintenance shall be maintained by the Permittee.
These records should include but are not limited to the following:
Items LnUgg[ on E[QQuency
a) Individual dosing pump operation Weekly
b) Individual field rotation Weekly
c) High water alarms Weekly
d) Residual pressure on highest and
lowest lateral on each subfield Monthly
e) Residual pressure on all laterals Semi-annually
3. Three copies of all operation and maintenance records (as specified in condition III
2) and all effluent monitoring data (as specified in condition III 3) shall be
submitted on or before January 31 of the following year to the following address:
NC Division of Environmental Management
Water Quality Section
Facility Assessment Unit
PO Box 27687
Raleigh, NC 27611-7687
4. A record shall be maintained of all sludge removed from this facility. This record
shall include the name of the hauler, permit authorizing the disposal or a letter from
a municipality agreeing to accept the sludge, date the sludge was hauled, and
volume of sludge removed.
5. Noncompliance Notification:
The Permittee shall report by telephone to the Mooresville Regional Office,
telephone no. 704/ 663-1699, as soon as possible, but in no case more than 24
hours or on the next working day following the occurrence or first knowledge of
the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the
treatment of significant amounts of wastes which are abnormal in quantity
or characteristic, such as the dumping of the contents of a basin or tank; the
known passage of a slug of hazardous substance through the facility; or any
other unusual circumstances.
b. Any process unit failure, due to known or unknown reasons, that render the
facility incapable of adequate wastewater treatment such as mechanical or
electrical failures of pumps, aerators, compressors, etc.
C.. Any failure of a pumping station, sewer line, or treatment facility resulting
in a by-pass directly to receiving waters without treatment of all or any
portion of the influent to such station or facility.
3

d. Any time that self-monitoring information indicates that the facility has gone
out of compliance with its permit limitations.
Persons reporting such occurrences by telephone shall also file a written report in
letter form within 15 days following first knowledge of the occurrence. This report
must outline the actions taken or proposed to be taken to ensure that the problem
does not recur.
i13NKW Mel ►I0'i': ► i xel 111 C 51 U ►
1. Any groundwater quality monitoring as deemed necessary by the Division of -
Environmental Management shall be provided.
1. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee
to insure proper operation of the subject facilities.
2. The Permittee or his designee shall inspect the wastewater treatment and disposal
facilities to prevent malfunctions and deterioration, operator errors and discharges
which may cause or lead to the release of wastes to the environment, a threat to
human health, or a nuisance. The Permittee shall keep an inspection log or
summary including at least the date and time of inspection, observations made, and
any maintenance, repairs, or corrective actions taken by the Permittee. This log of
inspections shall be maintained by the Permittee for a period of three years from the
date of the inspection and shall be made available upon request to the Division of
Environmental Management or other permitting authority.
3. Any duly authorized officer, employee, or representative of the Division of
Environmental Management may, upon presentation of credentials, enter and
inspect any property, premises or place on or related to the disposal site and facility
at any reasonable time for the purpose of determining compliance with this permit;
may inspect or copy any records that must be kept under the terms and conditions
of this permit; or may obtain samples of groundwater, surface water, or leachate.
► "All OR 1 ► _
1. This permit shall become voidable unless the facilities are constructed in accordance
with the conditions of this permit, the approved plans, specifications and other
supporting data.
2. This permit is effective only with respect to the nature and volume of wastes
described in the application and other supporting data.
3. This permit is not transferable. In the event there is desire for the facilities to
change ownership, or there is a name change of the Permittee, a formal permit
request must be submitted to the Division of Environmental Management
accompanied by an application fee, documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request will
be considered on its merits and may or may not be approved.
4

4. Prior to any transfer of this land, a notice shall be given to the new owner that gives
full details of the materials applied or incorporated at this site.
5. A set of approved plans and specifications for the subject project must be retained
by the applicant for the life of the project
6. The annual administering and compliance fee must be paid by the Permittee within
thirty (30) days after being billed by the Division. Failure to pay the fee
accordingly may cause the Division to initiate action to revoke this permit as
specified by 15 NCAC 2H.0205 (c)(4).
7. Failure to abide by the conditions and limitations contained in this permit may
subject the Permittee to an enforcement action by the Division of Environmental -
Management in accordance with North Carolina General Statute 143-215.6.
8. The wastewater treatment facility shall connect to a publicly owned areawide
sewage collection system within 180 days of its availability. All discharge of
wastewater to the system shall cease at the time of the connection to the sewerage
collection system.
9. The issuance of this permit does not preclude the Permittee from complying with
any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
10. The Permittee, at least six (6) months prior to the expiration of this permit, shall
request its extension. Upon receipt of the request, the Commission will review the
adequacy of the facilities described therein, and if warranted, will extend the permit
for such period of time and under such conditions and limitations as it may deem
appropriate.
Permit issued this the 13th day of November, 1990
CAROLINA
`9=— ge T. Ev
Division of E
By Authority
AL MANAGEMENT COMMISSION
Management Commission
5

Permit No. WQ0004058
November 13, 1990
Engineer's Certification
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of
the
project, for the
Project Name Location
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within
substantial compliance and intent of the approved plans and specifications.
Signature Registration No.
Date
C.1

N
zOCf7T!ON N19P
S CAC E ,• o � ? (�+�1/LE.S}
N1.- SC110 oL
E.�`/ST.
EL El/.9T�1J
yr�,9TE.Q TANS
E_ c'.
t15.V'--