NCS000315_Email from CMSWS_20180817

Bennett, Bradley
From: Broadway, Chad <[e-mail]>
Sent: Friday, August 17, 2018 8:08 AM
To: Bennett, Bradley
Cc: Khan, Zahid; Moore, James
Subject: [External] RE: [External]Checking in on a few more Mecklenburg County sites
Attachments: IGM Resins - 9-22-15 - Final Report.pdf, Gerdau Ameristeel NOV 8-2-12.pdf, Geradu Ameristeel US
Inc. - Final - 5-14-13.pdf, Gerdau - Facility Cover Letter and Inspection_11.14.17.pdf, Gerdau
Monitoring - Cover Letter and Report (Color).pdf; Inspection Report - Charlotte Pipe and Foundry -
FINAL.pdf, Final - Nexeo Solutions - Stormwater Facility Inspection.pdf,
NexeoSolutions_report_v2.pdf
Hi Bradley,
Sorry for the very late response, we've had a number of issues come up over the last month and I'm just now getting
caught up. For the facilities you mentioned:
NCS000049 — IGM Resins USA, Inc. — 3300 Westinghouse Blvd
o Our most recent inspection of the facility was on 9/22/15 (attached), although it was by an inspector
who is no longer in our group and is not very thorough/descriptive.
o I conducted a complaint -based inspection at the facility in June of this year and found a compromised
pipe that conveys process water to their pretreatment system. While I did not view any discharge from
the pipe during two visits, the pipe appeared to have a high potential to discharge residual toluene (one
of the primary chemicals used on site) and other pollutants from their waste stream. I received
notification last week that the pipe has been replaced.
o From my visit, there was a fair amount of spilled material and a lot of outdoor ASTs, but most of the
exposed area near the plant appears to be collected in a system that discharges to the facility's
pretreatment system.
■ NCS000304 — Gerdau Ameristeel US, Inc. - 6601 Lakeview Road
o Our most recent facility inspections were on 10/23/17 and 5/14/13 (attached).
o We also conducted stormwater monitoring on 2/9/14. Results are attached — we found slight
exceedances of pH, Cu, and Zn.
■ Generally speaking, the facility has a significant amount of exposure and pollution sources, but
also reuses a lot of accumulated stormwater and has very large buffers between the plant and
the final outfalls.
o I responded to a spill of approximately 125 gallons of hydraulic oil on 1/3/18. 1 think this spill was
reported to MRO, and then Zahid notified us. The discharge was due to an operator error during facility
maintenance, and approximately half of the spilled amount reached the ground with no obvious impacts
to the storm drainage system. The affected area was excavated by a remediation contractor within a
week and results for remaining soils were below action levels.
o We conducted a complaint -based inspection in January 2015 based on reports of discharges from the
facility's closed-loop recycle process water (contact) system. During our inspection, no active discharge
was occurring, but high-water marks and stained soils around the system's return pond indicated
multiple previous discharges from the system. From my understanding, while this may not be relevant
to the NPDES permit, this situation also turned into a wrongful termination whistle blower lawsuit. We
have been contacted by legal representatives for the former employee on multiple occasions.

o We conducted an inspection on 8/2/12 for a spill of 460 gallons of diesel fuel to the ground and a
stormwater retention / process water pond. The NOV is attached, and I think James Moore may have
recently been contacted about this discharge.
NCS000040 — Charlotte Pipe & Foundry Co. - 1335 S. Clarkson Street
o Our most recent facility inspection was on 5/14/2015 (attached). From the report, it appears they were
in Tier II/III at the time, but there's not information about what parameter(s) were exceeded or how
great the exceedances were.
o We also responded to an "asphalt -water mixture spill" on 1-13-14. Our file did not have a lot of
information about the source and cause of this spill, but I would assume it was due to site
improvements as opposed to process -related.
NCS000315 — Nexeo Solutions LLC — 3930 Glenwood Drive
o I inspected the facility on 11/28/17 and a previous inspection was conducted on 3/31/14.
(attached) The facility is a repackaging and distribution center for haz-mats, flammables, caustics, etc.,
and is generally well -kept.
o During my inspection, I found they were not conducting qualitative monitoring at all outfalls, as
required. Based on the requirement for analytical to only be conducted at one outfall, I could see how
this may have been confusing.
Chad Broadway, Environmental Specialist
Charlotte -Mecklenburg Storm Water Services
Mecklenburg County Water Quality Program
2145 Suttle Avenue
Charlotte, NC 28208
704-280-1497 (mobile)
[e-mail]
http://charlottenc.gov/StormWater
Storm Water's WHY statement: We are passionate about making our environment safe and healthy by reducing
flood losses and improving water quality for all.
chxktf#-X ck;@n"
STORM
WATER
IF Services
From: Bennett, Bradley <bradley. ben [e-mail]>
Sent: Monday, July 30, 2018 3:55 PM
To: Broadway, Chad <[e-mail]>
Cc: Khan, Zahid <[e-mail]>; Moore, James <[e-mail]>
Subject: [External]Checking in on a few more Mecklenburg County sites
CAUTION: This email originated from outside of the organization. Do not click links or open attachments unless you
recognize the sender and know the content is safe.
Hey Chad,
Over the next few weeks I'll hopefully be getting to a few more facilities for individual permit renewals. I just wanted to
touch base with you and see if you had any information on these that might not be reflected in BIIMS inspections.
• NCS000049 — IGM Resins USA, Inc. — 3300 Westinghouse Blvd
• NCS000304 — Gerdau Ameristeel US, Inc. - 6601 Lakeview Road
• NCS000040 — Charlotte Pipe & Foundry Co. - 1335 S. Clarkson Street

• NCS000315 — Nexeo Solutions LLC — 3930 Glenwood Drive
I haven't started the review just yet so I don't have any drafts ready. Just wanted to see if you have anything to pass
along on these that we should consider as we work through it. I'll check through BIMS and see if there were any issues
from the most recent DEMLR or CMSWS inspections.
Zahid, James — heads of for you guys also. Let me know if you are aware of any issues.
f:�
Bradley Bennett
Stormwater Program
NC Division of Energy, Mineral & Land Resources
512 N. Salisbury Street
1612 Mail Service Center
Raleigh, NC 27699-1612
Note New Phone Number
Phone: [phone]
Fax: [phone]
Email: brad ley. [e-mail]
Email correspondence to and from this address may be subject to public records laws