NC0085936_Draft Permit_20180613

ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
Water Resources LINDA CULPEPPER
Environmental Quality Interim Director
June 13,2018
Mr.J.Mark Williams
Jerry G.Williams& Sons, Inc.
PO Box 2430
Smithfield,NC 27577-2430
Subject: Draft NPDES Permit NC0085936
Wet Log Deck Storage site
Johnston County
Dear Mr.Williams:
In response to your request to renew the subject NPDES permit,the Division of Water Resources(DWR or
the Division)hereby transmits this draft for your review and comment.Please review this document to assure
your understanding of the permit limits and monitoring conditions,and to correct errors,if any.
The Division understands that you have made no significant changes to your facility since the last permit
renewal.We have made the following updates to your previous permit:
1. The facility map has been updated.
2. Regulatory citations have been added.
3. Parameter codes have been added to Section A. (1.).
Concurrent with this notification,the Division will solicit public comment on this draft by publishing a notice
in newspapers having circulation in the general Johnston County area,as required by the NPDES Program.
Please provide your comments,if any,to me via email [[e-mail]] or write to my attention
care of DEQ/DWR/NPDES Program no later than July 13,2018.Your written comments are welcome but
not mandatory.
Following the mandatory 30-day public comment period,the Division will review all pertinent comments on
your permit draft, and take appropriate action prior to issuing your NPDES permit final. If you have questions
concerning this draft,please e-mail me or call my direct line(919) 807-6307.
Sincerely,
itriArAfir15:114.4
Derek Denard,Environmental Specialist
Compliance&Expedited Permitting Unit
Division of Water Resources,NCDEQ
Enclosure:NPDES Permit NC0085936(renewal DRAFT)
hc: NPDES Program Files
ec: DWR/RRO,Danny Smith[[e-mail]];Vanessa Manuel[[e-mail]]
DWR/PWS/RRO,Allen Hardy[[e-mail]]
Wastewater Operator Certification Group/Maureen Kinney[[e-mail]]
[e-mail]
State of North Carolina I Environmental Quality
1617 Mail Service Center I Raleigh,North Carolina 27699-1617
919-707-9000

NPDES Permit NC0085936
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATERTHE
NATIONAL POLLUTANT DISCHARGE ' ATION SYSTEM
(NPDES)
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Jerry G. Williams & Sons, Inc.
is hereby authorized to discharge wastewater from a facility located at the
Wet Deck Log Storage site
524 Brogden Road, Smithfield 27577
Johnston County
to receiving waters designated as an unnamed tributary to the Neuse River in the Neuse River Basin in
accordance with effluent limitations, monitoring requirements, and other conditions set forth in Parts I,
II, and III hereof.
This permit shall become effective , 2018.
This permit and authorization to discharge shall expire at midnight on , 2023.
Signed this day , 2018.
Linda Culpepper, Interim Director
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 6

NPDES Permit NC0085936
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked. As of this permit issuance, any previously issued permit bearing this number is no longer
effective. Therefore, the exclusive authority to operate and discharge from this facility arises under the
permit conditions,requirements, terms, and provisions included herein.
ifok
Jerry G. Williams & S 4 : nc.
is hereby authorized to:
1. continue to discharge wet-decking water(and stormwater runoff) from the Wet Log Deck Storage
site;
located at in Smithfield,NC at 524 Brogden Road in Johnston County; and
1/214-
2. discharge via Outfall 001 at the location specified on the attached mapinto an unnamed tributaryto
g p
the Neuse River [stream index 27-(41.7)], currently classified as WS-V;NSW waters within
Subbasin 03-04-02 [HUC 030202011105] of the Neuse River Basin.
Page 2 of 6

NPDES Permit NC0085936
Facility Classification: PCNC
PART I
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B .0400 et seq., 02B .0500 et seq.]
a. During the period beginning on the effective date of this permit and lasting until expiration, the
Permittee is authorized to discharge wet-decking wastewater from Outfall 001. Such discharges
shall be limited, monitored and reported' by the Permittee as specified below:
EFFLUENT CHARACTERISTICS LIMITATIONS MONITORING REQUIREMENTS'
[Parameter Codes] Monthly Daily Measurement Sample Sample
Average Maximum Frequency Type Location_
Flow(MGD)2 50050 Monitor&Report Weekly Instantaneous Effluent
Total Suspended Solids(mg/L)3 C0530 30.0 mg/L 45.0 mg/L Weekly Grab Effluent
pH(su) 00400 Not less than 6.0 S.U.nor Weekly Grab Effluent
greater than 9.0 S.U.
Oil and Grease(mg/L)3 00556 Monitor&Report Weekly Grab Effluent
Total Nitrogen(TN)(mg/L)3'4 C0600 Monitor&Report Quarterly Grab Effluent
Total Phosphorus(TP)(mg/L)3 C0665 Monitor&Report Quarterly Grab Effluent
Footnotes:
1. The Permittee shall submit Discharge Monitoring Reports electronically using NC DWR's eDMR
application system. See Condition A. (3.).
2. Flow shall be monitored at least once each week, either during a discharge caused by rainfall
[stormwater runoff] or during a discharge from wet-decking operations. Monitoring during rain
events is preferred,but flow readings from wet-decking runoff are acceptable during weeks when no
rainfall occurs.
3. Samples for these parameters will be collected on the same day as flow monitoring is reported. TN
and TP shall be monitored once each quarter on the same day as other samples are collected.
4. For a given wastewater sample, TN = TKN + (NO3-N+NO2-N),where TN is Total Nitrogen, TKN
is Total Kjeldahl Nitrogen, and (NO3-N +NO2-N) are Nitrate and Nitrite Nitrogen, respectively.
Conditions:
b. There shall be no debris discharged from the facility.
c. There shall be no discharge of floating solids or visible foam in other than trace amounts.
d. There shall be no discharge of process wastewater pollutants associated with sawmill operations.
Page 3 of 6

NPDES Permit NC0085936
A. (2.) BIOCIDE CONDITION [G.S. 143-215, 143-215.1]
a. There shall be no chromium,zinc or copper added to the treatment system except as pre-approved additives to
biocidal compounds.
b. The Permittee shall obtain approval from the Division's Aquatic Toxicology Unit prior to the use of any
biocide(not previously approved by the Division)in the effluent discharged under this permit. Approval for
use of any biocide not previously approved should be requested at least 90 days in advance of any planned
usage.
c. Contact the Aquatic Toxicology Unit for detailed instructions on requesting approval of biocides:
NC DEQ/DWR/Aquatic Toxicology Branch
1621 Mail Service Center
Raleigh,North Carolina 27699-1621
A. (3.) ELECTRONIC REPORTING OF DI CHARGE MONITORING REPORTS
[G.S. 143-215.1(b)] ***
Federal regulations require electronic submittal of all discharge monitoring reports(DMRs)and program reports.
The final NPDES Electronic Reporting Rule was adopted and became effective on December 21, 2015.
NOTE: This special condition supplements or supersedes the following sections within Part II of this permit
(Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D.(2.) Reporting
• Section D.(6.) Records Retention
• Section E. (5.) Monitoring Reports
1. Reporting Requirements [Supersedes Section D. (2.) and Section E. (5.)(a)1
The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic
Discharge Monitoring Report (eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and submitted
electronically using eDMR. The eDMR system allows permitted facilities to enter monitoring data and
submit DMRs electronically using the internet. Until such time that the state's eDMR application is
compliant with EPA's Cross-Media Electronic Reporting Regulation(CROMERR),permittees will be
required to submit all discharge monitoring data to the state electronically using eDMR and will be required
to complete the eDMR submission by printing, signing,and submitting one signed original and a copy of the
computer printed eDMR to the following address:
NC DEQ/Division of Water Resources/Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility being
physically located in an area where less than 10 percent of the households have broadband access,then a
temporary waiver from the NPDES electronic reporting requirements may be granted and discharge
monitoring data may be submitted on paper DMR forms(MR 1, 1.1,2,3)or alternative forms approved by
Page 4 of 6

NPDES Permit NC0085936
the Director. Duplicate signed copies shall be submitted to the mailing address above. See"How to Request
a Waiver from Electronic Reporting"section below.
Regardless of the submission method,the first DMR is due on the last day of the month following the
issuance of the permit or in the case of a new facility,on the last day of the month following the
commencement of discharge.
Starting on December 21,2020,the permittee must electronically report the following compliance
monitoring data and reports,when applicable:
• Sewer Overflow/Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act(CWA) Section 316(b)Annual Reports. uvrt
The permittee may seek an electronic reporting waiver froth tfl s ivi ..g , ee"How to Request a Waiver
from Electronic Reporting"section below). •
2. Electronic Submissions
In accordance with 40 CFR 122.41(1)(9),the permittee must identify the initial recipient at the time of each
electronic submission. The permittee should use the EPA's website resources to identify the initial recipient
for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity(EPA or
the state authorized by EPA to implement the NPDES program) that is the designated entity for receiving
electronic NPDES data[see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting tool for each type of
electronic submission and for each state. Instructions on how to access and use the appropriate electronic
reporting tool will be available as well. Information on EPA's NPDES Electronic Reporting Rule is found at:
http://www2.epa.gov/compliance/final-national-pollutant-discharge-elimination-system-npdes-electronic-
reporting-rule.
Electronic submissions must start by the dates listed in the"Reporting Requirements"section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an electronic
reporting waiver,a permittee must first submit an electronic reporting waiver request to the Division.
Requests for temporary electronic reporting waivers must be submitted in writing to the Division for written
approval at least sixty(60)days prior to the date the facility would be required under this permit to begin
submitting monitoring data and reports. The duration of a temporary waiver shall not exceed 5 years and
shall thereupon expire. At such time,monitoring data and reports shall be submitted electronically to the
Division unless the permittee re-applies for and is granted a new temporary electronic reporting waiver by the
Division. Approved electronic reporting waivers are not transferrable. Only permittees with an approved
reporting waiver request may submit monitoring data and reports on paper to the Division for the period that
the approved reporting waiver request is effective.
Information on eDMR and the application for a temporary electronic reporting waiver are found on the
following web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Page 5 of 6

NPDES Permit NC0085936
4. Signatory Requirements [Supplements Section B.(11.)(b)and Supersedes Section B.(11.)(d)1
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II, Section
B. (11.)(a)or by a duly authorized representative of that person as described in Part II, Section B.(11.)(b). A
person,and not a position,must be delegated signatory authority for eDMR reporting purposes.
For eDMR submissions,the person signing and submitting the DMR must obtain an eDMR user account and
login credentials to access the eDMR system. For more information on North Carolina's eDMR system,
registering for eDMR and obtaining an eDMR user account,please visit the following web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make the
following certification[40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION WILL BE
ACCEPTED:
• Ari.
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief true, accurate, and complete.I am aware that there are signtfieant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
5. Records Retention [Supplements Section D. (6.)1
The permittee shall retain records of all Discharge Monitoring Reports,including eDMR submissions. These
records or copies shall be maintained for a period of at least 3 years from the date of the report. This period
may be extended by request of the Director at any time [40 CFR 122.41].
nrne
Page 6 of 6

- _ o
1
-Q 1 '\,..,
_ G Vii i ..
;-. 43 in 44t1711400—
L..__A___------- - -
, .....- _ •
. ____ _ .
::.„,
,._ ,
\ ‘) r
.,. . „.,_, ; ., .,,itr. ,., ,. A A
r- ��`
= '
iii:<- - , , .,1 , , :
. _._ ,,, riv,, , ,.
...,:,_, ,,, .4
itir- -.-.
—, �, L. , . ,..-.„. ..._,-.....:_,- , . . . „ ,,,,, .....,„,. . : ii,
. ... .,„, .., : . .. . :.,._ Ay-, *. . V '',11%. '
• D
r- _ �g Swage .f -' ` �' / tir' t' ..
/ ��s.. 1 i �.,� . _f .•• ! �"
• NEUSE I i' 't". r . -`i . ,
*7.-) .V.4". 4 111 II
,,S i 1 1= • N, ,,,,IiiriNIPIIII:b.,:: 44111k ,
, ---- . : ,,, , , ,k I -N.- ... . . 4! AP -T . wir ' 4
.40441p, ,, i..4fr „,
.r___,
IIIIII
wi
p-•,•"•••i-• .r_-,./q...--
o...--.
i)i,16 , - V.7401-P.4..1...ri„4 . -, •Afdil
{ Approximate •\� ,
tiFacility Boundary ,%
-7, ---)11P0,y'....,104iihke— —A'
'2- I • s ' -or—zAitti, ,,,,..„ .....„,..2 IA .1117171r. •,t\
.....„, \ , , . ., , --_-_-__*: .. , _ .;.„- >.....„,--..•-,,-,--
br�.� r,= i -'1 j/ ' Outfall 001 Arid
© l' _ .i, � "� :�95 ,i �K - (i [flows southwest]
/ til �` /` J 11� �, \ �,
1
,...iviji
i.
. -:•
47
, 1: s\J 2;
.. . : _
c� ♦ ��- Mem Gatdens2,` ' 9ak, ,
$'�' 1i:-
Brogden Rd =
ilhilh*Crik." ....::-:_,:e,'„i'i'l,;;:_-_(':_---'_ , -'-, , Ili -,klikviiffrik..,,,,2s,— viwallIIIITIVAIlipki
.A,F0,„_1,.-.:.,,,..-.-t...,s.-.!rs.
,/0 ;• ' 5".
Neuse River iL .4.....t_. iiff,:,,.4w.
` - _ [flows southeast] / )711
9d / J,lw,aG , �r ; Copyright 02013 National Geographic Societyi-cubed
Jerry G Williams & Sons, Inc. N arm. �,
NPDES Permit NC0085936 -;410414 /Rial ' r
524 Brogden Road, Smithfield 27577 ��- �'15000,000 #���' n `'r
Receiving Stream: UT to Neuse River
Stream Segment:27-(41.7) Stream Class: WS-V;NSW 35.4931°N, -78.3528°W
River Basin:Neuse Sub-Basin#: 03-04-02 SCALE NC Grid: E25SE
County:Johnston HUC: 030101040602 1:24,000 USGS Quad: Selma,NC
j

_? ('i q .. 13 ! •-' - !
f qv,
j Y '
LA. J\ '''' 11
_ 4.r
•r
,-' co, ... 4,_ po „ _ 4
i
.t J�
it r
iipl
1 ; -i _ is- , . ,,1 r _ ..lir ik J
i:\ ,
- Nt-e*.s:',..:, :. i : .. . ,,:
iii ... ,_ ,
S
;t, S M I t K - F I _E.* •• ' • p'-"F-
�"
�. ., �- Se«age s Kr �. + �r
r
NEUSE '' - ` ,?
•IVER \ , ._..._. " ) •�4 � �
41f7.
01
�':/atilt-1;, , � � ! � =staff% .- -�i ~' ,
riiiii, *
iii.
re. - 4.* '/‘ '-- ..
Al \\AL -1411144. NIZIP:.,,,, ' -' -... '4.1.,,
r---c.---- - 'PI ) 7-741.1.0.2.. ---:",..- - -„L-/--:-.-\-,___ .--- ,, g _,
, .
. / (;;; f ,,,
't� , Approximate - 1 ji g
� „,„J---- iiprr..-7.4
^ \ . Facility Boundarkaley • ; /�
r-1 - l \ Q ® � ti ..
d�
b ;oC�` Ou.5.71-rakttfa11001 al
�r '1 \"'+'I 7 —•'�tf�5!� h -14 [flows[flows southwest]
1 - . iii �..----.,�
l'W -—)„. tvisi,;70,-, – -, i i
-. .....catt.20 , - -!itripmitanderks , --/- r '.!: ,'—–.E...--'-•,..g3=1)‘7.) -:4',I:-is,„.,,„ .
lio ri
----kVi::K,:--.-,4-.,:..c.\p;,..*t.o,,)i4,4s,- „.4,4-y0,e00r,*(-/.i;•z/"s 1i/,1.,11.4 0j.
A.N....‘
01, Brog,iden Rd IN\-
rn
s.
4k,
6
If / -,i1 ,rNeuse River s,ti:i„.
4IrN
'11,
`►.: - . [flows southeast] , rr /A
__,. -,r . / n.
.4.
*; , \ W/:-..., 1
C� 'I,
��- . \ Co n x©2093 National'Geo ra hie Society,i-cubed
Jerry G Williams & Sons, Inc. N - - -
NPDES Permit NC0085936 ���,M�;� {p _erire(
524 Brogden Road, Smithfield 27577 iffirV '�O
t
Receiving Stream: UT to Neuse River
Stream Segment: 27-(41.7) Stream Class: WS-V;NSW 35.4931°N, -78.3528°W
River Basin:Neuse Sub-Basin#: 03-04-02 SCALE NC Grid: E25SE
County: Johnston HUC: 030101040602 1:24,000 USGS Quad: Selma,NC