HomeMy WebLinkAboutNCG030601_Zinc Tier III Response_20151204i 0
December 4, 2015
NC Department of Environmental Quality
Division of Water Quality
Mooresville Regional Office
610 East Center Avenue
Mooresville, North Carolina 28115
Re: Tier III Stormwater Response
Cataler North America Corporation
Lincolnton, Lincoln County, North Carolina
General Stormwater Permit No. NCG030000
Dear Sir/Madam:
This letter and supporting documents represent a notification of a Tier III response to a fourth consecutive
exceedance of the benchmark value for zinc at Outfall No. SD07 at our facility located at 2002 Cataler
Drive in Lincolnton, North Carolina.
Date of Sampling Benchmark Results
11/23/14 0.130 mg/L
7/8/15 0.067 mg/L 0.139 mg/L
9/9/15 0.273 mg/L
10/26/15 0.235 mg/L
Note: No flow conditions prohibited sampling during June and August 2015
Our analyses indicate that zinc is entering our stormwater discharge from condensate drains on the roof
of our facility from heating and air conditioning (HVAC) units. Deposition of zinc from HVAC condensate
onto roof surfaces through evaporation during periods of dryer weather may also lead to higher initial
zinc loading at our outfalls during the early periods of stormwater events, when stormwater sampling is
specified by our permit.
A second possible source of zinc in our stormwater discharges is the result from occasional deposition of
raw material powders (of which zinc is a trace component) from our powder processing oven exhausts.
We are currently evaluating methods of better preventing powder carryover from the processing ovens
to the exhausts and intend to install filtration equipment on the oven exhausts within the next several
months (pending approval of modification of our current air quality permit).
We have sampled multiple roof -mounted HVAC condensate drains and conducted an analysis of impacts
to the receiving waters, an unnamed tributary of Larkard Creek. The attached diagram details the
sampling points and test results, which are summarized by the diagram below:
Zinc Analysis Results (Received 11/18/15)
Outfall SD06 Outfall SD07
0.045 mg/L 0.235 mg/L
From
4 0.045 mg/L .a 1 0.031 mg/L Offsite
0.042 mg/L 4 Of
Larkard Creek, flow direction
4
The results of the HVAC condensate analyses demonstrate that HVAC condensate drains are the
predominant source of the zinc in our stormwater discharges and that the impacts of the zinc in our
stormwater discharges on the receiving waters are minimal. Based on the results of our analyses, we
request a waiver of continued monthly sampling for zinc at our facility outfalls.
Should you have any questions or require additional information, please contact me by telephone at
828.970.2102 or by email at reynolds@cataler•-na.com.
Sincerely, q
� ki&v — —
Chad Reynolds
Utilities Supervisor
Enclosures: Test results (10/23/15, 10/26/15, 10/27/15), Facility Diagram
Blase Ridge Lads
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drive
Lincolnton. NC 28092
Attention: Chad Rc%nolds
Date Received: 28 -Oct- I s
Report Date:
OU -Nov -15
Sample Date:
36 -Oct -15
BR N:
BRL-2015-0851
Lab Sample lD:
LSID ?015-03-157
Client Sample ID:
SD06
Parameter
Result MQL
Oil & Grease
8S 5
blueridgelabslenoir@gmail.com
Unit Method
nil,, i 1664-A O&:G
Analysis Analysis
Time Date
11 3Q01?
Reported Bx:
S. J. , hnson, D.R. Wessinger
" Concentrations are below Nlimmum Quantification Limit except where noted.
NC Laboratory Certificate No. 27
Pace I of 6
Analyst
N-n�Qth
Blue Ridge Labs
PO Box 2940
Letzoir, NC" 28645
828-728-0149
Client :
Cataler-North America
2002 Cataler Drive
Date
Lincolnton, NC 28092
Attention:
Chad Reynolds
Date Received:
28 -Oct -15
Report Date:
09 -Nott -15
Sample Date:
'_6 -Oct -15
13RL #:
SRL-2015-0851
Lab Sample M
LS1D ?015-03458
Client Sample W:
SD06
Parameter
Result MQL
ISS
h.� 6
blueridgelabslenoir@gmail.com
Unit Method
111�"1 =540D 1997
Analysis
Analysis
Tlnte
Date
.Analyst
16:77
10,`28,'--015
KC1
Reported By: .�+''✓'
S. J. kimson, O.R. 1rYessinger
* Concentrations are below Manimum Quantification Limit eycept where noted.
SNC Laboratory Certificate No -275
Pa,—,a 2 of 6
Blue Ridge Labs
PO Bax 2940
Leoroif, A -C 28645
828-728-0149
Client : Carder -North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention: Chad Reanolds
Date ReceiNed: 28 -Oct -I;
Report Date:
09 -Nuc -I5
Sample Datc:
26 -Oct -1 5
BRL k:
BRL-201 -0U 1
Lab Sample ID:
LSID-2015-0349
Client Sample ID:
SD06
Parameter Result
Cu 0.018
11b
/n 9.0;3
blueridgelabslenoir@gmail.com
Reported By:
S-3{Johnson, D.R. 1k essinger
Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratoti Certificate No. 27n
Paa of 6
Analyst
KCI
lU :I
KC.I
AnaIxsis
AnaIN, sis
YIQI,
Unit
Method
"Gime
Date
0.091
to=r 1
200.7 199-1
1 6:-18
1 1 i ^0I
0.OI
in�l
260.7 190.4
16:-48
113'015
9.001
mgi
260.7 1991
16.18
1 1 3 2015
Reported By:
S-3{Johnson, D.R. 1k essinger
Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratoti Certificate No. 27n
Paa of 6
Analyst
KCI
lU :I
KC.I
Blue Ridge Labs
PO Box 2940
Lenoir, .;VC 28645
828-728-0149
Client :
Cataler-North America
3002 Cataler Drive
Liricolnton,NC 38092
Attention:
Chad Reynolds
Date Received:
28 -OCL -t5
Report Date:
09-NOV-15
Sample Datc:
26 -Oct -15
BRLu:
BRL-3017-0851
Lab Sample ID:
LSID-3015-03060
Client Sample ID:
SD07
Parameter Result
0 1 R GI"case 11.7
blueridgelabsienoir@gmail.com
MQL unit Method
S m I 166.4-A OR:G
A nalvsis analcsis
'I`iIII e Date Aoalxst
1132015 bSIIQdy
r� y'
Repurted B}:
J. J. 6�FiJfnson, D.R. Wessinger
Concentrations are beiovV Minimum Quantification Limit except wlcere awed.
NC Laboratory Certificate No. "j
Page .1 oC 6
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client:
Catater-North America
2002 Cata let Drive
e
Lincolmon. NC 28091
Attention:
Chad Reynolds
Date Received:
28 -Oct -l5
Report Date:
09 -Nov -I5
Sample Date:
26 -Oct -15
IMM, 4:
13RL-20 1J-0851
Lab Sample ID:
1,S] D2015-03.461
Client Sample fD:
SD07
Parameter Restj It
ISS I
bIueridgelabslenoir@gmaiI.com
NIQL Unit Method
3.3 m,-, I -,40D I997
Anal Esis A na Iv s is
Filn, Date Analyst
16.38 1() ]8 20 1 i KCJ
Reported Byl
(Insan, D.R. Wk"siwger
Concentrations are beloH Minimaja Quantification Linut except wIlere noted.
.NC Laboratory Certificate No. 275
pave: of 6
Blase Ridge Labs
PO Bar 2940
Lenoir, NC 28645
828-728-0149
Client :
Cataler-;North America
4lethod
2002 Cataler Driye
Date
Lincolnton. NC 2509'
,Attention:
Chad Reynolds
Date Received:
'_8 -Oct -15
Report pate:
09 -Nos -I5
Sample Date:
26 -Oct -15
B R L a:
BRL_ ?015-0851
Lab Sample [D:
LSID-2015-03452
Client Sample [D:
SD07
Parameter Result
Cu (1.005
P 1? +
/n 0._3�
blueridgelabslenoir@gmail.com
\ nil hSis Analysis
NIQL
Lnit
4lethod
Time
Date
0.001
m_1
200.7 190.1
16:='_
11 5 201
0.01
mg'I
'_()0.7 199-1
16 s-1
I I S 701
0.001
mti l
'_OQ.? 1991
1652
1 1 5 201 �
Reported By:-
ir', ,
S. J, Jornisoo, D,R, Wessinger
Concentrations are below Minimum Qunntif¢ation Limit except where noted.
NC Laboratmv Certificate deo. 2'-5
Parr 6 of 6
AnahSt
KCJ
KC -1
hCJ
WATER QUALITY LAS & OPERATIONS, INC.
P.O.BOX 11S7
BANNER ELK, NC 28604
(828) 898-6277
CLIENT: BLUE RIDGE LABS LOGIN TIME:
ADDRESS: P.O.BOX 2Q4O SAMPLER:
CITY: LENO|R RECEIVED DATE:
STATE: NC ZIP 28645 REPORTED DATE: 0`Nuv~ 5
REPORTED BY: INC CERTIFIED LAB #544
PAUL |GENHOVR.SUPERVISOR
RESULTS,.
AT6.
OIL & GREASE
3453
11.0
5.00
MG/L
3 -Nov -15
PI
OIL & GREASE
3455
92
5.00
MG/L
3 -Nov -1 5
PI
OIL & GREASE
3457
8.5 5.00
MG/L
3 -Nov -15
PI
REPORTED BY: INC CERTIFIED LAB #544
PAUL |GENHOVR.SUPERVISOR
551
rA
U
m � N
N
N
v
r
�
rr•
A
2
a
v�
S
J
R
}
Q
�
c1 �d
L
Z
N
V
p
T
-b
t
e -
U
�
I
I
m � N
v
11
ii
3
2
a
v�
S
J
R
Q
�
c1 �d
L
Z
N
V
m � N
N
V
p
T
-b
t
e -
C
I
I
M
!
:
G
9 z
I
I
j
u —
-g:-
- a
I
O
o
k
E
M
k
I
I �
Q%
f
i cni d�
t I
—5--
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention: Chad Reynolds
Date Received: 28 -Oct -I5
Report Date:
16 -Nov- 15
Sample Date:
23 -Oct -15
BRL #:
BRL-2015-0852
Lab Sample ID:
LSID-2015-03463
Client Sample ID:
HVAC 068
Parameter
Result NIQL
Cu
0.033 0.001
Ln
0.153 0.001
blueridgelabslenoir@gmail.com
Reported By:
S. f/�'ohhuson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Paee I of 15
Analysis
Analysis
Unit Method
Time
Date Analvst
mg,'1 200.7 1994
12:33
11, 16'2015 ItiCJ
ing'1 200.7 1994
12:33
1I;16,2015 KG
Reported By:
S. f/�'ohhuson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Paee I of 15
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
blueridgelabslenoir@gmail.com
Client:
Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention:
Chari Revnolds
Date Received:
28 -Oct -I5
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -15
BRL 9:
BRL-2013-0852
Lab Sample ID:
LSID-2015-246.1
Client Sample ID:
RTU -105
Aaalvsis
Anaksis
Parameter
Result
MQL
Unit lNlethod
Time
Date Analvst
Co
0.096
0,001
in;'] 200,7 199.4
12:=6
I1 [6�20t5 I<CJ
Zn
0.169
0,001
=1 200.7 1994
12:36
1616;2015 KCI
Reported By: t..,s-=,.�,�....•x',._:s s:.•:;.,_..,��`
S. dohnson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 27j
Page 2 oC 15
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client :
Cataler-North America
2002 Cataler Drive
Llncolnton, NC 28092
Attention:
Chad Reynolds
Date Received:
28 -Oct -15
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -15
BRL 4:
13R1. 2015-0852
Lab Sample 11):
LSID-2015-0346.
Client Sample ID:
RTU -107
Parameter
Result NIQL
Cu
0.302 0,001
Ln
0.111 0.001
blueridgelabslenoir@gmail.corn
Analysis Analysis
Unit Method Time Date .4nalvst
Rig l 200.7 1994 12:39 11 16,22015 I<C7
rg1 200.7 1994 12:39 It'16'1-015 KC1
Reported By: /,✓ I I
tdo
S. It nson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
IVC Laboratory Certificate No. 275
page 3 Of 15
Blue Ridge Labs
PO Sox 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention: Chad Reynolds
Date Received: 28 -Oct -15
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -15
13RL 4:
BRL-2015-0852
Lab Sample ID:
LSID-2015-03466
Client Sample ID:
RTU -108
Parameter
Result NIQL
C'u
0 242 0.001
Ln
0.503 0.001
blueridgelabslenoir@gmail.com
Reported By':t:wr*
S. J.nson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
:NC Laboratory Certificate No. 275
Pa, -,e 4 of 15
Analysis
Analysis
Unit
Method
Tittle
Date Analvst
ing.'1
200.7 1994
12:52
1116 20t5 �C,1
im, 1
200,7 1994
12:52
11 16'2011 ltCl
Reported By':t:wr*
S. J.nson, D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
:NC Laboratory Certificate No. 275
Pa, -,e 4 of 15
Blue Ridge Labs
PO Bax 2940
Lenoir, NC 28645
828-728-0149
Client:
Cataler-North America
.Analysis
2002 Cataler Drive
Unit
Lincolnton, NC 28092
Attention:
Chad Reynolds
Date Received:
28 -Oct -15
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -15
BRL d:
BRI --2015-0852
Lab Sample ID:
LSID-2015-03467
Client Sample ID:
HVAC 123
Parameter
Result MQL
CU
0.001
Zn
0.415 0.001
blueridgelabslenoir@gmaiI.com
l f/
Reported 6N: yam,,.-s2
S. .I �tnson, D.R. Wessinger
Concentrations are below Minimum Quantification Limit except where noted.
SC Laboratory Certificate No. 27j
Pale 5 of 15
.Analysis
.Analvsis
Unit
Method
Time
Date Analyst
mgil
200.7 1994
12:55
11 16i20ti 1<CJ
mgll
200.7 1994
12:55
11'16.'-Ot5 KCJ
l f/
Reported 6N: yam,,.-s2
S. .I �tnson, D.R. Wessinger
Concentrations are below Minimum Quantification Limit except where noted.
SC Laboratory Certificate No. 27j
Pale 5 of 15
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drive
Lincolnton-NC 28092
Attention: Chad Reynolds
Date Received: 28 -Oct -15
blueridgelabslenoir@gmaii.com
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -15
BRI, 4:
BRL-2015-0852
Lab Sample ID:
LSID ?015-03-468
Client Sample 11):
HVAC 125
Analysis
Analysis
Parameter
Result
NIQL
Unit Method Time
Date Analyst
Ri
*
0.001
mg:1 300,7 1994 12:58
11 16 2015 KCj
Zn
0.076
0.001
mel 200.7 1994 12.58
It 162015 1{C)
Reported Br: s �« ,,a�.^�.u.`'-
S. ohnson D R Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Pace 6 or Is
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention: Chad Reynolds
Date Received: 28 -Oct -15
blueridgela bslenoir@gmail.com
Report Date:
I6 -Nov -15
Sample Date:
23 -Oct -15
BRI,4:
BRL-2015-0852
Lab Sample ID:
LSID-2015-03469
Client Sample ID:
I IVAC 126/4
Analysis
Analysis
Parameter
Result AIQL
Unit Method
Time
Date Analyst
Cu
* 0.001
mg'1 260.7 1994
13:01
1 1 "1612015 1<CJ
Zn
0.181 0.001
rn',J 200.7 1994
13:01
11 16,2015 KCd
Reported By
S. 'M ason, D.R. Wessinger
* Concentrations are below Minimum Quantification limit except where noted.
NC Laboratory Certificate No. 275
Page 7 or 15
Blue Ridge Labs
PO Box 2940
Lenoir, AV 28645
828-728-0149
Client
attention;
Date Received:
Report Date:
Sample Date:
13RL #:
Lab Sample ID:
Client Sample ID
Cataler-North America
2002 Cataler Drive
Lincolnton, NC 2809-1
Chad Reynolds
2S -Oct -15
16 -Nov -15
23 -Oct -l5
BRL-2015-0852
LSID-2015-03470
HVAC 126/6
blueridgelabslenoir@gmail.com
Reported BN
,4,,ry'"' z✓..e.-fYF�i'a-r✓'rul%:SY',:nE:s.'ae-.. �
S. Johnson, D.R. Wessinger
Concentrations are below Alinimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Pale 8 of 15
Analyst
KCJ
KCJ
Analvsi.s
Analysis
Parameter Result :MQL
Unit
Method
Time
Date
Cu 0.045 0.001
nw, 1
200.7 1994
13:04
1 1 163015
Zn 0.093 0.001
m_r'1
200.7 1994
13:04
1 116 '-015
Reported BN
,4,,ry'"' z✓..e.-fYF�i'a-r✓'rul%:SY',:nE:s.'ae-.. �
S. Johnson, D.R. Wessinger
Concentrations are below Alinimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Pale 8 of 15
Analyst
KCJ
KCJ
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client : Cataler-North America
2002 Cataler Drke
Lincolnton, NC 28092
Attention: Chad Remolds
Date Received: 28 -Oct -15
Report Date:
16 -Nov -15
Sample Date:
23 -Oct -IS
BRI,9:
BRL-2015-0852
Lab Sample ID:
LSID-2015-03471
Client Sample ID:
11VAC 132
Parameter
Result hIQL
Cu
0.212 0.001
Ln
1.43 0,001
blueridgelabslenoir@gmail.com
Reported By:
S.° -.f. J� lu som D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 375
Pa"e 9 of I i
Analysis
analysis
Unit Method
Time
Date
Analvst
m,'1 200.7 1994
13:07
11'16;2015
KC
marl _'00.7 1994
13:07
1116'2015
KCl
Reported By:
S.° -.f. J� lu som D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 375
Pa"e 9 of I i
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client
Attention
Date Received:
Report Date:
Sample Date:
BRI, 4:
Lab Sample Ill:
Client Sample ID
Parameter
Cu
Ln
Cataler-North America
2003 Cataler Drive
Lincolnton. NC 28092
Chad Rel'n01d5
38 -Oct -1 5
16 -Nov -1 d
23 -Oct -15
l3 R L-2 01 5-08 5 2
LS I D-301 5-034 72
HVAC 133
Result
k
0.150
blueridgelabslenoir@gmail.com
IVIQL Unit Method
0,001 1 '_00.7 1994
0.001 n��r.'1 '00.7 1994
Analysis
Analysis
Tine
Date
13:19
1I.I6,101?
I-, 19
I 116.'--015
� r
Reported Ry; //�
S. 4,; iasou, D.R. Wessinger
" Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Paue to of I
Analyst
KCJ
KCJ
Blue Ridge Labs
PO Box 2940
Lenoir, A'C 28645
828-728-0149
Client :
Attention:
Date Reeeixed:
Report Date:
Sample Date:
RRL #:
Lab Sample ID:
Client Sample ID
Parameter
Cu
/n
Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Chad Reynolds
28 -Oct -15
16 -Nov -I5
23 -Oct -15
BRI --2015-0851-
L S f D-2 0 1 -5 - 03 4 7
RI-?015-0852LSID-201-5-03-47
HVAC 134
Result
0.12;
0.403
blueridgelabslenoir@gmail.com
MQL Unit Method
0.001 rnO 200.7 1994
0.001 mg.1 '-00.7 1994
Analvsis
Analysis
Time
Date
13:22
1116.2015
13:2-
1116,2015
Reported Ry:>..,...yR�.�;,:;.:�c_.:;=-<;_,,,_Y..w
S., t ohnson. D.R. Wessinger
* Concentrations are below Minimum Quantification Limit except where noted.
NC LaboratorN Certificate No. 275
Pa_e 11 or I?
Anaisst
KCJ
KCJ
Blue Ridge Labs
PO Bov 2940
Lenoir, NC 28645
828-728-0149
Client:
Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28092
Attention:
Chad Reynolds
Date Received:
28 -Oct- 15
Report Date:
16 -Nov -15
Sample Date:
23 -Oct- 15
BRI, #:
BPL -2015-0852
Lab Sample ID:
LSID-2015-03474
Client Sample ID:
HVAC 138
Parameter
Result NIQL
Cu
0.413 0.001
7_11
0 094 0.001
blueridgelabslenoir@gmail.com
Analysis Anit INS is
Unit Method Time Date Atilt IVSt
ms�1 200.7 1994 13:2-1 1116:2015 ICJ
me l 200.7 1994 13:34 1 1 16 201 ICJ
Reported Bv:-
S,I;i/Johnson, D.R. Wessinger
Concentrations are below Ylinimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Page 12 of 15
Blore Ridge Labs
PO Box 2940
.Lenoir, NC 28645
828-728-0149
blueridgelabslenoir@gmail.com
Client :
Cataler-North America
2002 Cataler Drive
Lincolnton, NC 28093
Attention:
Chad Reynolds
Date Received:
28 -Oct -15
Report Date:
16 -Nov -15
Sample Date:
27 -Oct- t 5
13RL 4:
BRL-2015-08. 3
Lab Sample ID:
LSID-2015-OJ473
Client Sample ID:
Upstream of Outfalls
Analvsis
Analvsis
Parameter
Result
NIQL
Unit Nlethod
'rine
Date
Cu
+
0.001
ms.'I 300.7 1994
13:27
11 116/2015
Zn
0.043
0.001
ng'1 300.7 1994
13:37
11'163015
w
2 �
„z
Reported 8y:
b.
S.-Yjohnson, D.R. Wessinger
Concentrations are below Nlimmum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Page 13 of t5
Analyst
KCJ
KCJ
Blue Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client
Attention
Date Received:
Report Date:
Sample Date:
BRL #:
Lab Sample ID:
Client Sample ID
Parameter
Cu
Zn
Cataler-North America
2003 Cataler Drive
Lincolnton, NC 1_8092
Chad Reynolds
'_8 -Oct -15
I6 -Nov -l5
27 -Oct- 15
BRL-2015-0852
L.,SID-2015-03476
Creek Downstream SD06
Result
0.045
blueridgelabsienoir@gmail.com
MQL Unit Method
0,001 mg'1 2007 1994
0.001 ma'1 200,7 1994
Anacsis
Analvsis
Time
Date Analyst
13:30
t 116-2015 KCJ
13:30
11 16,'-015 KCJ
Reported BN:
��.''':;
S. J.iomon, D.R. Wessinger
" Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 375
Pale. 14 of 15
Bltce Ridge Labs
PO Box 2940
Lenoir, NC 28645
828-728-0149
Client:
Cataler-North .America
2002 Cataler Drive
Analysis
Lincolnton, NC 28092
Attention:
Chad Reynolds
Date Received:
28 -Oct -15
Report Date:
16 -Nov- I
Sample Date:
27 -Oct -15
BRI, 9:
BRL-2013-0832
Lab Sample [D:
LSID-2013-03477
Client Sample ID:
Creel: Downstream SD07
Parameter
cu
Zn
blueridgelabslenoir@gmail.com
Reported Bv:
,t✓nj'rrison, D.R. Wessinger
" Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Pal,e 15 of 15
Analysis
Analysis
Result IINIQL
Unit
Method
Time
Date
Analyst
* 0.001
m,'1
300.7 1994
13:33
11 16x1013
KCJ
0.031 0.001
ma.1
200.7 1994
13:31
11 16 201
KCJ
Reported Bv:
,t✓nj'rrison, D.R. Wessinger
" Concentrations are below Minimum Quantification Limit except where noted.
NC Laboratory Certificate No. 275
Pal,e 15 of 15
FA
Z
I
U
n
x
rA
J
�
d
S2 z x
7 _
I f
i
ll
p
u
FA
Z
I
U
1
J
7 _
I f
i
ll
j
I I
J
i
i
17
v
ti
a�
Y
C
_. __J .+�yf
f
J
J
z�
p of
r}
d
x
r,
p of
n
= r
v
_ _
c
d
v
-
Y2
�
_
i
M'..,
z
C
ir7.
All Analysis Results In mg/L
Zinc Benchmark at outfalls is
0.067 mg/L
HVAC 068 to SDO6
Sample Date 10/23/15
Zn. 0.153
JLf t ] {7lll
Tota! CUM* A,
says amps-raus
Creek Upstream of Outfalls
Sample Date 10/27/15
Zn. 0.042
SD07 Zinc
Sample Date Result
11723/14 0.130
June 2015 No Flow
7/8/15 O 139
August 2015 No Flow
979715 0.273
10726/15 0 235
Creek Downstream 51307
Sample Date 10/27/15
Zn. 0.031
Creek Downstream SD06
Sample Date 10/27/15
Zn. 0.045
Ou tfall
r,ta suer f Are.
6[U'lrnperk'w.rs
f
Flow
Dry Detention Bc7o/n #.
HVAC 108 to SDO2
Sample Date 10/23/15
Zn. 0.503
Larkard Creek Flow
Outfall #7
Tntal L tfdl Arcw 3.4 Acres
TO%lmpenbovs (24 aoreaj
Ou t fall #S _._....
r td ourrwi Arn al A ae
HVAC 123 to SD07
Sample Date 10/23/15
Zn. 0.415
1"o 1
Md. r}+.rYr
Se qWc Argo
,`_'de ttr l-)io Nc�ltYi
4sd
1,tf�
�r
HVAC 134 #15 to SD07 r L)I+TCOr,r.7 cpUry
1 { 52i =
Sample Date 10/23/15
Zn. 0.403
AV
P
HVAC 125#3 to SD07
Sample Date 10/23/15
Zn. 0.076
HVAC 126#4 to SD07
Sample Date 10/23/15
HVAC 132#14 to SD07
Sample Date 10/23/15
Zn. 1.43
HVAC 138#20 to SD07
Sample Date 10/23/15
HVAC 126#6 to SD07
Sample Date 10/23/15
HVAC 133 to SD07
Sample Date 10/23/15
Zn. 0.150
Outfall #1
a r r
Pato! Qutfo77 Area 9.6 Acres
29X lnWcrWour (2.4 acres)
-W lYuf.F,r I`�r n
_ lJ offal! #2
s xl+cw rralF�4+e(2.9 .a s�s
rDry
Detention Bosln #1
Outfall
To -tar 4 trdl Mao'S.7 Acre
cxresje
C7r Detention Basin #2
HVAC 107 to SDO2 HVAC10Sto SDO2 \
Sample Date 10/23/15 Sample Date 10/23/15
Zn. 0.111 Zn. 0.169