NCGNE0664_COMPLETE FILE - HISTORICAL_20100226

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. /V `l
i
j
DOC TYPE [ HISTORICAL FILE
D MONITORING REPORTS
DOC DATE ❑ ,of 0 a a
YYYYMMDD

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Se tary
26 February 2010
t,
Mr. Mark Dwyer
Ametek—Technical & Industrial Products
1210 NC Highway 61
Whitsett, NC 27377 f �'
0
Subject: No-Exposure Certification NCGNE06NA �..
Ametek—Technical & Industrial Produc,
1210 NC Hwy 61, Whitsett, NC 27377
Guilford County
Dear Mr. Dwyer:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal and signed certification of no exposure at the above referenced facility, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (March 1, 2015), At that time you must re-certify with the Division, or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmenta4
permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Corey Basinger at [phone], or at
[e-mail].
Sincerely,
or Coleen H. Sullins
cc: Bob Allen, Ametek -TIP
Winston-Salem Regional Office
Stormwater Permitting Unit-No=Exposure Files
Wetlands and Stormwater Branch one
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 NorthCarohna
Location:512 N.Salisbury St Raleigh,North Carolina 27604
i Phone:[phone] FAX:[phone] Customer Service:1-877-623-6748 �atul"allr�
Internet:www.ncwaterquality.org
An Equal Opportunity 1 Affirmative Action Employer

1
NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
26 February 2010
Mr. Mark Dwyer
Ametek—Technical & Industrial Products
1210 NC Highway 61
Whitsett, NC 27377
Subject: No-Exposure Certification NCGNE0664
Ametek—Technical & Industrial Products
1210 NC Hwy 61, Whitsett, NC 27377
Guilford County
Dear Mr. Dwyer:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal and signed certification of no exposure at the above referenced facility, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (March 1, 2015). At that time you must re-certify with the Division, or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances,
if you have any questions or need further information, please contact Corey Basinger at [phone], or at
[e-mail].
Sincerely,
rorColeen H. Sullins
cc: Bob Allen, Ametek -TIP
Winston-Salem Regional Office
Stormwater Permitting Unit, No-Exposure Files
Wetlands and Stormwater Branch One
1617 Mall Service Center,Raleigh,North Carolina 27699-1617 NorthCarolina
Location:512 N.Salisbury St.Raleigh,North Carolina 27604
Phone:[phone] FAX:919�07-64941 Customer Service:1-877-623-5746 Naturally
Internet:www.ncwaterquality.org
An Equal Opportunity 4 Affirmative Action Employer

V "
FOR AGENCY USE ONLY
J�
AKI wlp Date Received
Division of Water Quality/Surface Water Protection Year Momh Da
���E � National Pollutant Discharge Elimination System crifricatcoPC°°` —
NO EXPOSURE CERTIFICATION for Exclusion y "'�
rr..,�y�r;.wntlavay.2rw:t ra NCGNE0000 JAN 0 5 2010
Winston-Salem
NO EXPOSURE CERTIFICATION Please check here f this`siayrenewa! If?fiNWA
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Permit based
on-NO-EXPOSURE.-
Sub iission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
-- - it qualifies-fora no exposure.exclusion.-A condition-of no-exposure at.an-industrial..facility means all_
industrial materials and activities are protected by a storm resistant shelter(with some exceptions)to
prevent exposure to rain, snow, snowmelt, and/or runoff.
For permitted facilities in North Carolina, DWQ must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and.conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not '
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed"means
banded or otherwise secured and with locked or non-operational taps or valves;adequately maintained
vehicles used in material handling;and final products, other than products that would be mobilized in
stormwater discharges(e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility-wide basis only—not for individual
outfalls. If any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form,you
certify that a condition of no exposure exists at this facility oPsite and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once every five (5) years.
For questions, please contact the DWQ Regional Office for your area. (See page 6)
(Please print or type)
Z) Mailing address of owner/operator(address to which all certification correspondence will be mailed):
Name
Contact ,AOP,& 224*4y,50_
Street Address Z-2/0 .VC Hi6[.✓AV 6/
City byW r,ff = State yC__ ZIP Code 27, 77
Telephone No. 3301 .q7-3y00 Fax:
Page 1 of 7 QEG 3D�u
DIENR
5WU-NE-021309 i �!I'312z0
'tlrBnCh

r _
NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Flame
Facility Contact
Street Address
City erl1 7J477r State Ne ZIP Code 27377
County
Telephone No. 33C W—?-341�9 Fax: ?fie 4/91 -2i oo
3) Physical location information:
Please provide a narrative description of how to get to the facility(use street names, state road numbers, and
distance and direction from a roadway intersection). WFsr�n.:..Y.aI//O-�'�y %,�r_ ��ro.;v,��p &x1r
7,1 Ve 6/ ��a.�rndaa.y� To d�a.Uire ���,�o�- _. �_y 62, a,r ta.P.��,e aF Ale-6/ kaIwcf
(A copy of a map with the facility clearly located on it should be includ d with the certification application.)
4) Is the facility located on Native American LandO Yes No.
5) Is this a Federal facility? ❑ Yes I�No 1,1r
6) Latitude 3S° 59//.S~ Longitude o740' jS`LS" (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
Ni Existing Date operation began _- /2l3
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes o
If yes, what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: �5
10) Provide a brief description of the types of industrial activities and products produced at this facility:
11) Does this facility have any Non-Discharge permits (ex: recycle permits)?
11 No
❑ Yes
It yes, list the permit numbers for all current Non-Discharge permits for this facility:
ai-
Page 2 of 7
SWU-NE 021309_ Last revised 2/13/2009

NCGNEQ000 No Exposure Certification
Exposure Checklists(12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items,you are not
eligible for the no exposure exclusion. ,/
a. Using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes LDS No ❑ NIA
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks © Yes /No ❑ NIA
c. Materials or products from past industrial activity ❑ Yes I2(No ❑ NIA
d. Material handling equipment (except adequately maintained vehicles) ❑ Yes M No ❑ NIA
e. Materials or products during loading/unloading or transporting activities ❑ Yes hJ No ❑ NIA
f. Materials or products stored outdoors (except final products intended for outside ❑ Yes R(No ❑ NIA
use[e.g., new cars]where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, i❑ Yes YNo ❑ NIA
and similar containers
f
h. Materials or products handled/stored on roads or railways owned or maintained by ❑ Yes �(No ❑ NIA
the discharger
i. Waste material (except waste in covered, non-leaking containers [e.g., dumpsters]) ❑ Yes R�No ❑ NIA
j. Application or disposal of process wastewater (unless otherwise permitted) ❑ Yes I�(No 0 NIA
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not ❑ Yes VNo ❑ NIA
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
1. Empty containers that previously contained materials that are not properly stored ❑ Yes elNo ❑ NIA
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels,tanks, and similar containers ❑ Yes Oe'No ❑ NIA
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No"to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or IM/Yes ❑ No ❑ NIA
deterioration, or evidence of leaks? /
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ® Yes ❑ No ❑ NIA
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
Page 3 of 7
SWU-NE-021309 Last revised 2/13/2009

r "
NCGNE0000 No Exposure Certification
14) Secondary Containment: If you.answer"No" to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers /ye's ❑ No ❑ NIA
(including drums, barrels, etc.) with a capacity of more than 660-gallons? /
b. Is secondary containment provided for above ground storage containers stored ❑ Yes El No L NIA
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund ❑ Yes [:] No 113 N/A
Amendments and Reauthorization Act (SARA) water priority chemicals`? /
d. Is secondary containment provided for hazardous substances— designated in 40 ❑ Yes ❑ No C N/A
CFR §116?
e. Are release valves on all secondary containment structures locked? VYes ❑ No ❑ NIA
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑ Yes &(No ❑ NIA
b. Is this facility a Small Quantity Generator(less than 1000 kg. of hazardous waste ❑ Yes /No ❑ N/A
generated per month) of hazardous waste? . 7nr is A C'r_X9C
c. Is this facility a Large Quantity Generator(1000 kg.or more of hazardous waste ❑ Yes i+o(No ❑ NIA
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport/disposal vendor:
Vendor address:
Footnotes to Questions 14) c. & d.
'Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
*"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
Page 4 of 7
SWU-NE-021309 Last revised 2/13/2009

NCGNEOOOO No Exposure Certification
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? ::] Yes /No ❑ NIA
b. Does your facility have coal piles on site? ❑ Yes /No ❑ NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑ Yes 14o ❑ NIA
sawdust, etc.?
d-Does-your-facility-have-air-emissions-associated-with-its-industrial-activity-(e.-g -----©--Yes—IY(No—❑-NtA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity: ``��
--- .e. it-you-answered-yes-to-d.;are-those-emissions-permitted.by-an-Air Quality-Permit?❑-Yes--❑--No--It-N/A-- -
Please specify:
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Page 5 of 7
5WU-NE-021309 fast revised 2/13/2009

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of"no
exposure"and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities.
or materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 12226(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five (5)years to the North Carolina
Division of Water Quality and, if requested,to the operator of the local municipal separate storm sewer system(MS4) into
which the facility discharges(where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4,to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request-
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility.Additionally, I certify under penalty of
law that this document and 0 attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true,complete,and accurate.
Printed Name of Person Signing: ,p�- ytyj
Title: i
(Signature of Applicant) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at anytime in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 13(i) provides that:
Any person who knowingly makes any false statement,representation,or certification in any application,record,report,plan,or other
document filed or required to be maintained under this Article or a rule implementing this Article;or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article;or who falsifies,tampers with,or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management]Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
5WU-NE-021309 Last revised 2/13/2009

NCGNEOOOO No Exposure Certification
Final Checklist
This'application should include the following items:
This completed application and all supporting documentation.
A map with the location of the facility clearly marked.
❑ If this is a renewal, indicated current NCGNE number in Question 7.
❑ If the site currently has an NPI]ES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
Stormwater Permitting Unit
0i_Visiau oof Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DWO Regional Office for your area.
DWQ Regional Office Contact Information:
_..... 73�•4jyn ton Safe
Asheville Office ...... [phone]
Fayetteville Office ... [phone]
Mooresville Office ... [phone]
j
Raleigh Office ........ [phone] r s, lie y" aary le ti lia '
Washington Office ...[phone] 4 x .a tF� ?
Wilmington Office ... [phone] _
Winston-Salem ...... [phone]
Central Office ........ 919 807-6300 w '
s 131it' n 51t
on
Page 7 of 7
SWU-NE-021309 Last revised 2/13/2009

Notes
MAPOUE'ST
Map of AMETEK Rcbmm- r--clocrz.
1210 Nc Highway 61, Whitsett, NC 27377 -
[phone]
... -
A10ADQUST. 1 aoa m
J w:
ronfi Fld YUhit�e3t T
W�hlts?!t Pz Fcl
c f
Am 47FIe
2009 ma Qil£5f tno- t � n � t
p r s;,, ( Map Data C•2009'NAVTC-O OraTeleA't
All rig is reserved.Use Nut�ject to Llcerlse/Cgpyrlght I Map Legend

+ . . �
Print Preview Page l of Z
Guilford County, NC
r
a
GREESO :.R6
4
1W
s 11 Al
OE
Nti40E �
3 A� �- ON RAMP 1851V'40E
�r
210`s M1ici61 Hwy
c�
'4
�i
JyI
i
Disclaimer. While every effort is made to keep information provided over the internet
accurate and up-to-date, Guilford County does not certify the authenticity or accuracy of Map Scale
such information. No warranties, express or implied, are provided for the records and/or 1 inch = 467 feet
mapping data herein, or for their use or interpretation by the User.
http://gcgis.co.guilford.nc.us/guilford—new/printPreview.aspx?PrintOptData--Guilford County, NC10101tr... 12/18/2009