NCGNE0648_COMPLETE FILE - HISTORICAL_20091102

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO. IV C& N C- K
DOC TYPE C�HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE ❑ Ua
YYYYMMDD

M®
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
November 2, 2009
Synergy Recycling, LLC
Attn: Ms. Arene Cooper-Baker, Compliance Director
320 South Gibson Drive
Madison, NC 27025
Subject: No-Exposure Certification NCGNE0648
Synergy Recycling, LLC
Rockingham County
Dear Ms. Cooper-Baker:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal of signed certification of no exposure at the above referenced facility and the
site visit conducted by Mr. Ron Boone of the Division's Winston-Salem Regional Office on 15 September 2009, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations. We are also hereby rescinding your current permit Certificate
of Cove?age, NCG200462.
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately 'obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (November 1, 2014). At that time you must re-certify with the Division or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
if you have any questions or need further information, please contact Ron Boone at (336) 771-5000 or
[e-mail].
Sincerely,
for Coleen H. Sullins
cc: Winston-Salem Regional Office] Stormwater Permitting File NCG200462
Stormwater Permitting Unit No- Exposure Files Fran McPherson-Budget Office
Wetlands and Stormwater Branch One L. t 1617 Mail Service Center,Raleigh,North Carolina 27699-1617 NorthCarOfrna
Location:512 N.Salisbury 5t,Raleigh,North Carolina 27er Naturally
Phase:919-89-807-63001 FAX:919�1)7-64941 Customer Service:1-877�23-6748
Internet:www.ncwaterquality.org
An Equal Opportunity 1 Affxrnat+ve ACtton Employer

NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Caleen H. Sullins Dee Freeman
Governor Director Secretary
November 2, 2009
Synergy Recycling, LLC
Attn: Ms. Arene Cooper-Baker, Compliance Director
320 South Gibson Drive �O�
Madison, NC 27025P,
Subject: No-Exposure Certification NCGNE0648
Synergy Recycling, LLC
Rockingham County
Dear Ms. Cooper-Baker: jt
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal of signed certification of no exposure at the above referenced facility and the
site visit conducted by Mr. Ron Boone of the Division's Winston-Salem Regional Office on 15 September 2009, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations. We are also hereby rescinding your current permit Certificate
of Coverage, NCG200462.
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (November 1, 2014). At that time you must re-certify with the.Division or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Ron Boone at (336) 771-5000 or
[e-mail].
Sincerely,
for Colleen H. Sullins
cc: Winston-Salem Regional Office __ Stormwater Permitting File NCG200462
Stormwater Permitting lDnit No- Ex po.sure_F.,iles] Fran McPherson-Budget Office
Wetlands and Stormwater Branch One
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 NorthCarotina
Location:512 N.Salisbury St.Raleigh,North Carolina 04
9� aturallr�
Phone:[phone] FAX:919�807-64941 Customer
Service:1 877-623-5748
Internet:www.ncwaterquaiity.org
An Equal Cpporiunily 4 Aftmative Action Employer

/5�
, v
�CDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
November 2, 2009
Synergy Recycling, LLC
Attn: Ms. Arene Cooper-Baker, Compliance Director
320 South Gibson Drive
Madison, NC 27025
Subject: No-Exposure Certification NCGNE0648
Synergy Recycling, LLC
Rockingham County
Dear Ms. Cooper-Baker:
The Division has reviewed your submittal of the No-Exposure Certification for Exclusion from NPDES Stormwater
Permitting form, Based on your submittal of signed certification of no exposure at the above referenced facility and the
site visit conducted by Mr. Ron Boone of the Division's Winston-Salem Regional Office on 15 September 2009, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations. We are also hereby rescinding your current permit Certificate
of Coverage, NCG200462.
Please note that by our acceptance of your no-exposure certification, you are obligated to maintain no-exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no-exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your conditional no-
exposure exclusion expires in five years (November 1, 2014). At that time you must re-certify with the Division or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Ron Boone at (336) 771-5000 or
[e-mail].
Sincerely,
^
for Coleen H. Sullins
O
C7
r'v1�4�-_ __�
cc: Winston-Salem Regional Office stormwater P_ermitting.Eile- 004B2_'
Stormwater Permitting Unit No- Exposure Files Fran McPherson-Budget O e
d
Wetlands and Stormwater Branch
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 North Carolina
Location:512 N.Salisbury St.Raleigh,North Carolina 27604
Phone:[phone] FAX:9IM07-64941 Customer Service:1-877-623-6748 NQtmral`i/
Internet:www.ncwaterquality.org J
An Equal ppponunity 1 Affirmative Actior Employer

on 1,
i I I 11Y)n l/1Jk14 L+ 15�-►.�e�r FOR AGENCY USE ONLY
pate Received
Division of Water Quality/Surface Water Protection Year Month Day v "
National Pollutant Discharge Elimination System CcrtiricatcofCoverage J�
NCDENR y
„tr�„. — NO EXPOSURE CERTIFICATION for Exclusion
rr'rcr+M . 'Hct L raao..x�s
NCGNE0000
NO EXPOSURE CERTIFICATION Please check here if this is a renewal: ❑RENEWAL
National Pollutant Discharge Elimination System application for exclusion from a Stormwater Permit based
on NO EXPOSURE:
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter(with some exceptions)to
prevent exposure to rain, snow, snowmelt,andlor runoff.
For permitted facilities in North Carolina, DWO must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the-terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks,and similar containers
that are tightly sealed,provided those containers are not deteriorated and do not leak. "Sealed"means
banded or otherwise secured and with locked or non-operational taps or valves;adequately maintained
vehicles used in material handling;and final products, other than products that would be mobilized in
stormwater discharges(e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility-wide basis only—not for individual
outfalls. if any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once every five (5) years.
For questions, please contact the DINO Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of owner/operator(address to which all certification correspondence will be mailed):
Name Synergy Recycling LLC
Contact Arene Cooper-Baker,Compliance Director
Street Address 320 5 Gihwn Drive
City Madison State NC ZIP Cade 21025
Telephone No. 336 548-7014 Fax: 336 548-7015
Page 1 of 7,
` G S E P 2 1 2009
N�.
SWU-NE-021309 Last r
LPN4R WA h
w 2/ 312009
ndi&&'prlThwew

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name NIA
Facility Contact
Street Address
City State ZIP Code
County
Telephone No. Fax:
3) Physical location information:
Please provide a narrative description of how to get to the facility(use street names, state road numbers, and
distance and direction from a roadway intersection). Facility located on S Gibson Dr.approximately 0.1 miles From US-311
Webster Hwylw Academy Street which is located 3.5 miles south of US-2201thomas A Burton Hwy
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands?❑Yes ONo
5) Is this a Federal facility? ❑Yes Q No
6) Latitude 36:22:48 Longitude 79:59:56 (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
❑ New or Proposed Facility Date operation is to begin
0 Existing Date operation began 03/23/2009
❑ Renewal of existing No Exposure Certification Certification No-: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit?❑Yes ❑✓ No
If yes,what is the NPDES Permit Number?
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 5 0 9 3
10) Provide a brief description of the types of industrial activities and products produced at this facility:
Recychng of obsolete and end of life electionic eqUipMent, asset recovery, and certified destsuction.
11) Does this facility have any Non-Discharge permits (ex: recycle permits)?
ED40
❑Yes
If yes, list the permit numbers for all current Non-Discharge permits for this facility:
Page 2 of 7
SWU-NE-021309 Last revised 2/13/2009
1

NCGNE0000 No Exposure Certification
Exposure Checklists(12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future?(Please check either"Yes" or"No.") if you answer"Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a_ Using, storing, or cleaning industrial machinery or equipment, and areas where ❑Yes❑✓ No ❑NIA
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑Yes ❑✓ No ❑N/A
c_ Materials or products from past industrial activity Dyes ❑No QN/A
d_ Material handling equipment (except adequately maintained vehicles) ❑Yes [�]No []N/A
e_ Materials or products during loading/unloading or transporting activities ❑Yes QNo ❑N/A
f. Materials or products stored outdoors (except final products intended for outside ❑Yes ❑No QN/A
use [e.g., new cars]where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, ❑Yes ❑No M N/A
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by ❑Yes ❑No QN/A
the discharger
i. Waste material (except waste in covered, non-leaking containers [e.g., dumpsters]) ❑Yes E]No ❑N/A
j. Application or disposal of process wastewater(unless otherwise permitted) ❑Yes []No ❑✓ N/A
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not ❑Yes ❑No ❑r N/A
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored ❑Yes ❑No ON/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers ❑Yes ❑No ON/A
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks(ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑Yes ❑No 0 N/A
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑Yes [—]No 0 NIA
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?
Page 3of7
SWU-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
14) Secondary Containment: If you answer"No"to any of the following items, you are not eligible for the
no exposure exclusion.
a. Is secondary containment provided for single above ground storage containers ❑Yes ❑No ❑� N/A
(including drums, barrels, etc.)with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored []Yes ❑No ❑✓ N/A
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund ❑Yes ❑No QNIA
Amendments and Reauthorization Act (SARA)water priority chemicals*?
d. is secondary containment provided for hazardous substances**designated in 40 ❑Yes ❑No QNIA
CFR §116?
e. Are release valves on all secondary containment structures locked? ❑Yes ❑No 0 NIA
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑Yes ❑No 0 NIA
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste ❑Yes [:]No ON/A
generated per month) of hazardous waste?
c. Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste El Yes No BN/A
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport/disposal vendor:
Vendor address:
Footnotes to Questions 14)c. & d.
*Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
**Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.
Page 4 of 7
5WU-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
16) Other information: If you answer"Yes" to any of the following items,you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? ❑Yes E1No ❑NIA
b. Does your facility have coal piles on site? ❑Yes E]No ❑NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑Yes CJNo [:]N/A
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity(e.g., []Yes EjNo ❑NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity:
e. If you answered yes to d., are those emissions permitted by an Air Quality Permit? ❑Yes ❑No EI NIA
Please specify:
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: Program:
Permit: Program:
Permit: P rog ra m:
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:
Page 5of7
SW U-NE-021309 Last revised 2/13/2009

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of"no
exposure"and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document(except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five(5)years to the North Carolina
Division of Water Quality and, if requested,to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges(where applicable). I understand that I must allow the North Carolina Division of Water
Quality,or MS4 operator where the discharge is into the local MS4,to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility.Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system,or those persons directly responsible for gathering the
information,the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true,complete,and accurate.
Printed Name of Person Signing: Arene Cooper-Baker
Title Compliance Director
09/17/2009
(Signature of Applicant) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement,representation,or certification in any application,record,report,plan,or other
document filed or required to be maintained under this Article or a rule implementing this Article;or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article;or who falsifies,tampers with,or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management]Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars($10,000).
There is currently no fee for a No Exposure Exclusion.
Page 6 of 7
SWU-NE-021309 last revised 2/13/2009

•
;�9t
r�
a. rJ�j?ra %J
aWT-
-c• V �.r^Yy fi ,';O '.li � °� �_? � Z '�V .•.`,fir ��`c.!'-�Sj ;� �' •i,�F
- ,ems yy'X�1,lz^,� C..90�81s `�. ,''r'�' '!� � � i lq�ry�,�+r� ,,1..� �,..•r'�
-�� t '�'�r��.t -�,,.,���� �. .,,�w� •� I,-- " Ci a.= 3. ,� �~� �rxT"-..��'k c-��� � �frr�ry�*'�f .�
L#_ � Y i� t� �4Ta��r r ���. ��- �� „Q", dp►,-,r^" ,y. r.- � �� tom. "jn_y i ���_ �l;'7.
-,r � I i;+'�� �i.�" �r ..,-� r ;' + '►,:., � S5 ��.,, S O'��� Uzi [��'
d l St f W
0. UAW
+'�► �"` ate`' ; •, t F •# � 1 + ^S °+. _ '; ri t ryr
,.S' a�d $ :b •.• ! fF Q'i 11.,, at -~i�r7'yu f. s. _ t .3.1�j �
��r i� �. �9 -."\ 'r : F•' p �� �"� 8� C� CY- 4 Ft � i �•iN.�,�- t -+,�,1.
..r1 � J. 2 'ttr^� •'�` # - ; ! ' •• - .4F L'l ►:�" "Jt� r f .t * a ;C°}�
• • - • . •• - • - • • • • 1 •li: 'ill: •' it • il'

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
❑✓ This completed application and all supporting documentation.
Q A map with the location of the facility clearly marked.
❑ If this is a renewal, indicated current NCGNE number in Question 7.
❑ if the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions,please contact the DWO Regional Office for your area.
DWQ Regional Office Contact Information:
Asheville Office ...... [phone] wl. tornsale
Fayetteville Office ... [phone] 1 al gh
Mooresville Office [phone]
Raleigh Office ........ [phone] 1 lie
oor le
Washington Office ...[phone]
Wilmington Office ... [phone]
Winston-Salem ...... [phone] lle =f
Central Office ......[phone]
Wil n9tan
Page 7 of 7
SWU-NE-021309 Last revised 2/13/2009

+�
NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
July 28, 2009
Mr. Brian Beinarauskas
Synergy Recycling LLC
320 Gibson Drive
Madison, North Carolina 27025
Subject: General Permit No. NCG200000 h�
Synergy Recycling LLC
COC No. NCG200462 1
Henderson County
Dear Mr. Beinarauskas: "
The Division of Water Quality's Stormwater Permitting Unit (SPU) acknowledges receipt of your notice
of intent (NOI) for coverage under NPDES General Permit Number NCG200000 on July 17, 2009. General
Permit NCG20000 is in the process of being renewed and significant changes in the permit are anticipated.
We expect the final permit to be issued sometime in November of this year. You can review the proposed
general permit changes here: ww.w.ncwaterquality.org/su/publicnotice.htm.
SPU has initiated review of your NOI application but will not issue a permit for this facility until
NCG200000 is finalized so as to limit potential non-compliance between the requirements of the current permit
and the new permit. No additional information is required at this time, but we may contact you in the future.
Please notify us if any significant changes have taken place at this facility since you submitted the renewal
package.
If you have any questions about this matter, please contact me at [phone] or at
cory.la [e-mail].
Sincerely,
Co r n
Environmental Engineer
Stormwater Permitting Unit
cc: Asheville Regional Office
Stormwater Permitting Unit Files
Central Files
Wetlands and Stormwater Branch One
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 NorthCarohna
Location:512 N.5artsbury St Raleigh,North Carolina 27604 �at�r�ll�
Phone:[phone] FAX:[phone] Customer Service:1-877-623-6748 f/
Internet:www.ncwaterquality.org
An Equal Opportunity 1 Affirmative Action Employer

U a farL 1VQ-Q Af S

WArFi4QG Michael F.Easley,Govemor
William G.Ross]r.,Secretary
North Carolina Department of Environment and Natural Resources
J �
Coleen H. Sullins,Director
Division of Water Quality
May 2, 2008
Mr. Brian Beinarauskas N.C.
E EI ED
Synergy Recycling, LLC. "R
104 E. Roosevelt St. p 6 2008
Mayodan, NC 27027
Subject: General Permit No. NCG200000
Synergy Recycling, LLC
C OC NC"'200-i-7I
Rockingham County
Dear Mr. Beinarauskas:
In accordance with your application for a discharge permit received on April 4, 2008, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state—NPDES
general permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-
215.1 and the Memorandum of Agreement between North Carolina and the US Environmental Protection
Agency dated October 15, 2007 (or as subsequently amended).
Please take notice that this certificate of coverage is not transferable except after notice to the
Division of Water Quality. The Division of Water Quality may require modification or revocation and
reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required
by the Division of Water Quality or permits required by the Division of Land Resources, Coastal Area
Management Act or any other federal or local governmental permit that may be required,
If you have any questions concerning this permit, please contact Robert Patterson at telephone
number [phone] ext. 360.
Sincerely,
ORIGINAL SIGNED BY
BRADLEY BENNETT
for Coleen H. Sullins
cc: Winston Salem Regional Office, David Russell
Central Files
Stormwater Permitting Unit Files
North Carolina
Nattrratty
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh,NC 27699-1617 Phone[phone] Customer Service
Internet: www.ncwaternuality.ora Location•, 512 N.Salisbury St, Raleigh,NC 27604 Fax [phone]
An Equal Opportunity/Affirmative Action Employer—50%Recyclad110 o Post Ccrsumer Paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG200000
CERTIFICATE OF COVERAGE No. NCG200457
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Synergy Recycling, LLC
is hereby authorized to discharge stormwater from a facility located at
Synergy Recycling, LLC
104 E. Roosevelt Street
Mayodan
Rockingham County
to receiving waters designated as the Mayo River, a class C water in the Roanoke River Basin, in
accordance with the effluent Iimitations, monitoring requirements, and other conditions set forth
in Parts I, 11, III, IV, V, and VI of General Permit No. NCG200000 as attached.
This certificate ofccverage shall become effective May 2; 2008.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this 2°d day of May 2008.
ORIGINAL SIGNED BY
BRADLEY BENNETT
for Coleen H. Sullins., Director
Division of Water Quality
By the Authority of the Environmental Management Commission

.. � � �L
.\
•V
J
f�'�;,�}
..r. ���+{�N .
_���:
�wt t`�i.
~�r,l`
. . i . �. � � r _ t ^--' - .. ..F ....., ...... r.�...� �. ...ems., - _.��.-- ..y.y...�.+,�a:-�...• .

r
1
. S 'nw Yi ;• J S �; n i f�•c.sF A�- -'' l- i i.-,K* pS •s '" J , '., tit. r
i' - "` '' ? s w:ra. •- s si t i �'J:
`�-.r -z, ,•,` r, -;.t�,,� . �r�� �f.'--_ -�D . u ter, I L�,� ,.-
Na
is
Synergy Recycling, LLC
' n an !ey
t_: ,� a 's•� -.p 1't•, , •..9 r• � � - .� ✓<Lw+;r,� yi:-'�—" .on p s.� '�'y�.Ji
,\ k c.4` r, .y�p r 'k.,�. .« • 3• �: i 5.�i`'ti3,t •1n5 �/ ,>R G 7 r^ y..
1 Y�... +- Y` � �__ _ k.r es%� r +-a,. � �'�1� e � j r' r �+� � � �•A � (��k a 'ey. r .
i ~ Y •�iu_ •�. �-.:�� is kY�i �c�e k''s i�• x :n•*�"�,�,t,`�,�.�';�;3� � � t�:•r,
s � 'a r4'� � �...�� p; 1 �.��� ',I�j, �i� �.s.�,.'a .i�✓>���f to r�r'f p .. Kl...". J r r�Ytt�-'�
} 'Y,,,• 'sin F �' •�-�-ems^ r 'r�_ p�aT t�.' �" '�d'�"Cf ��y .- �
-r� ti > +�� �t r.,.'.- Hfsh -- r r i i �k,tL[i �,.r�' _ ''`'"'� .�' .�J. r• .'1+k.�a
33'•-�' �ii ,r ���a.�,, Fy 7 �5a:, �e y-v� +.��-_,� .� �t� _ �,p ]/,.�/,1 x � -{���� � •.+- -�i:
-���
� _ — 4 �°$.z� � a��� �- •. � QA ;� �'��� � ��.-. � �J:. -M.Sf l IPJ+ t •• i '�N'�: hh� E�tJ! ••�2�
06--
a � j fi 4. �.';7wr• 4! ? 1 1 'F'aL•„d t �.r � a'� ��P€
NCG200457 Synergy Recycling, LLC
Synergy Recycling, LLC
N
Latitude: 360 24' 2811 N
W' E Longitude: 791 58' 0411 W
County: Rockingham
S ' Receiving Stream: Mayo River
Stream Class: C
Map Scale 1:24,000 Sub-basin: 03-02-02 (Roanoke River Basin) Facility Location

f
'f S
Eile,. jailis queries. JSdmmistraton lie1P .,_..''_•T �T-,z
x
Analytical Limit Qualitalke Llmd. Ve:rlcle Llmlt fommenls History Inspec-ns rincIdents IEngnements Violation
` Delait 1_ Details 2 Bi!hn9 5vents : Req.Aclrndes I ns nenewer9 j Related Permits - =311 �•
p@ Permit NCO200457•- - Varslon: '1.0,- Status EzPira�d
y Permit Type: VVholesaie Tra_de of Metal Wa st_e and Scrap Etermwatet Discharge COO
-
,ti-
• Permit Ctassficatron:FOC = ". Pnmary Related Permit�+ICG200000
Program Categery.NPDES SW A.dmm Region'Wlns.on-Salem
Faculty'rSynetgy Recycling,LLC L Qetails;;� County�ucldngham
Owner,F,i R.ReCytlingLLC ,.DetAils.•..r PrbleciType: NewPralect• _
Rnd Per
- -Dates- _ -
% 'Issued: 05fD212008 Ong Fssued',05m2=19
CI Ma;nrPew' wiracluny§u
Ercactive',05102l2008 Statuturf.04minon8 - - -
- i O New Farm rV Existing Farm Forms:
Expire:09131Y2008' In
❑.:mwapve Arad.Acrss:,
SOC= Ddviig-.' ❑Ra.nhraakeiDe�ics
_ []OIC.Present'
- Last Updated BY blr+lsprcd.cren - - Last Updated On:11 Wf2008 1:31 AM-- -
FlnisA
1 Ready -l. - I SID:PMD7:....._.. ;
r
Elle-,jask sued MESH—AT!"
Cummenls Permis Wellsr meldants I Inspections Violations BAlinq Entarcemen History l�^ pepiacer
~ �-061alIs-Tt Regulated AcMities. Affiliations Treatment Unr'.s -_Slcs f Tar Cemficatdn Numheis Classiflca'dens °���� le4•tr
'F acIlNName:synargy Recycling LLC "� Farm A-[i,,, -- Pretreat Plan Status-Nene
t rt-- -
r.^Del 'Owner Name, nsrgy Rerycllnq LLC Clear 'Facility SSatus:Atlhe„ all
R
Available _ 'Selected ... QRecems Pretreated Wastewale
usaoe "l. Usa a -❑Primary Pretreatment FaChty s f,
_ Contaminaucn Source - F3cioty `[J NoirExAosure Exemption -
Disposal5ra =3e•n�se' - .. ["�Registered for ADMRPert .j
Stan DI_. Oriq Registered:�- 'Closed Dtl J Inactn'e Dt F
P Ong CAWMP Ot: Latest CAWMP Integrator. Fln.L1 j
tf
Locaben Addl;lDA E Ro6evell St q,' - , ' ':F - Region RStar}Salgm
Add2: Cuuntf Rockingham
ksid?err - City- Woolen •• fix..
State:.NC .-.--, .� '.Zip:. 7027
Dlraetcns:.l 68 Norm ftdm Greensboro to Bus.220 N.Exit into SR 1 35 At end or ramp tum ferF ApArc.3 miles ofthe Ief;
I
1.1506.Map Num:1
ri
-Maps Decimal-, -D�D:MM�S�S�'�� { y Accurac ., ' "
Latitude:. ��"'�''��'_-,�_„1 Method-
Datum:
- Last Updated By.sarah,ydung - Last Updated On:41913D08 9:59 AM- n I
••.Help; �Far.R. �lea< FinrSh...- I irCtoSe•-� _ -
aW

1
File,casks Queries .tdministrandn delp
---—3��"� #h rre
oc 3aaab[coci AaBbGI AaHhCe't^� '�aeGl�rr
3
x iea•q�.
MaM1ca1 Llmd i.vtuahtahwe r_lmu vehicle tlrrut %Omments Hs.err i Snspecyons Incidents Ento+cements {{7olauons —
Deiail 1 Details? Hillmq C-vents Reg.ACIMISS ATifratmns Renewers _ Peia:ed Perrrds - Ounl1 _
.. ,Permit 1VC G20G457 Version_ •1.0 status: Eirplrer_-i d_.-
`rn4N 'ATlla�onT a Name Tide Phone Number
-F acdily COnlact Person 16emarauskae&non J3$ 5497013 -
ly
Jvmer IOwner leelnaraasi+as Brian (336 546-7014
lPemtd �Beinarauskas,Brian
-[ramOva bn.x
-i�g @ark ' hldd> finish, g'41ase -
e 3 Vlltalions bond-- - �Rr-ea[ly jrSI,:PMRF