HomeMy WebLinkAboutNC0072125_Permit Issuance_20050112t
Michael F. Easley, Governor
r
William G- Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Y
Alan W. Klimek, P. E. Director
Division of Water Quality
January 12, 2005
Mr. Stephen Raper
City Manager
City of Rocky Mount
P.O. Box 1180
Rocky Mount, North Carolina 27802-1180
Subject: Issuance of NPDES Permit NCO072125
Tar River WTP
Nash County
Dear Mr. Raper:
Division personnel have reviewed and approved your application for renewal of the subject pemvt.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
This final permit includes no major changes from the draft permit sent to you on November 10,
2004.
This permit includes a TRC limit that will take effect on August 1.2006. If you wish to install
dechlorination equipment, the Division has promulgated a simplified approval process for such projects.
Guidance for approval of dechlorination projects is attached.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30) days
following receipt of this letter. This request must be in the form of a written petition, conforming to Chapter
150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings (6714 Mail
Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision shall be final
and binding.
Please note that this pemvt is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or Local
governmental permit that may be required. If you have any questions concerning this permit, please contact
Karen Rust at telephone number (919) 733-5083, extension 361.
cc: Central Files
Raleigh Regional Office/Surface Water Protection Section
NPDES Files
Sincerely,
ORIGINAL SIGNED BY
Mark McIntire
Alan W. Klimek, P.E.
0" Carolina
Nr/y
N. C. Division of Water Quality 1617 Mail Service Center
Internet hftpJ1h2o.enr.state.nc.us 512 N. Salisbury St.
An Equal Opportunity/Affirmative Action Employer
Raleigh, North Carolina 27699-1617 Phone: (919) 733-7015 Customer Service
Raleigh, NC 27604 Fax: (919)733-0719 1-877-623-6748
Permit NCO072125
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended, the
City of Rocky Mount
is hereby authorized to discharge wastewater from a facility located at the
Tar River Reservoir WTP
4489 Leaston Road
East of Langley Crossroads
Nash County
to receiving waters designated as the Tar River in the Tar -Pamlico River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective February 1, 2005.
This permit and authorization to discharge shall expire at midnight on October 31, 2009.
Signed this day January 12, 2005.
ORIGINAL SIGNED BY
Mark McIntire
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit NC0072125
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked. As of this permit issuance, any previously issued
permit bearing this number is no longer effective. Therefore, the exclusive authority
to operate and discharge from this facility arises under the permit conditions,
requirements, terms, and provisions included herein.
The City of Rocky Mount is hereby authorized to:
1. Continue to operate a water treatment plant with a discharge of chlorinated
filter -backwash wastewater. This facility is located at the Tar River Reservoir
WTP, at 4489 Leaston Road in Nash County.
2. Discharge from said treatment works at the location specified on the attached
map into the Tar River, classified WS-IV NSW waters in the Tar -Pamlico River
Basin.
T,
A
it
m
C6 7
167
C
uem
own
-Langle' Cr�growds
V E R
to
OutfaH 001
f
1 it
r Ido 17 1 11 it
N P/ it
J It
Ch
Iatbjik: 35*54'02"
..I, � M05
NCO07212S Facility
Longtude: 77%3'W" Location
Qaad # D27NW
PWmvmg&�:UwRvar City of Rocky Mount --E -
Stm= Cla WS-IV NSW Tar River Reservoir VVTP
Subba :30302 North SCALEI:24000
Permit NCO072125
A. (l .) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS - FINAL
During the period beginning on the effective date of this permit and lasting until expiration, the Permittee is
authorized to discharge from outfall 001. Such discharges shall be limited and monitored by the Permittee as
specified below:
«� ?�? it,,_�,��T+:.'�„ Y..i£�X.�"r_
�•
'_U: s%x � " �.
�L»•_y_-,..`F'.`: J I�S���.7t�'��
'ar" ,�,.��:f.. •rrN,.f"�yy�.�- ._-_.-u.. -
= '#�_'.
s�,.;�:
f
. - �,
[� � 'J"' �y[-�'
a^ y', a.� ;rq w r.C. �t7.�r �.s f•
� �.. w • .a +'del. p � i Y , _ '.f . f-.
Flow
Weekly
Estimate
Effluent
Total Suspended Residue
30.0 mg/L
45.0 mg/L
2/Month
Grab
Effluent
Settleable Solids
0.1 ml/L
0.2 mVL
Weekly
Grab
Effluent
Turbidityl
Weekly
Grab
Upstream & Downstream
Iron
Weekly
Grab
Effluent
Aluminum
Weekly
Grab
Effluent
Total Nitrogen
2/Month
Grab
Effluent
NO2+NO3+TKN
Total Phosphorus
2/Month
Grab
Effluent
Total Residual Chlorine2
28 µg/L
Weekly
Grab
Effluent
Footnotes:
1. The discharge from this facility shall not cause turbidity in the receiving stream to exceed 50 NTU. If the
instream turbidity exceeds 50 NTU due to natural background conditions, the discharge cannot cause
turbidity to increase in the receiving stream.
2. The limit for total residual chlorine will take effect August 1, 2006.
All samples must be collected from a typical discharge event.
There shall be no discharge of floating solids or visible foam in other than trace amounts.
A. (2.) Nutrient Reduction Requirement
The Tar -Pamlico Nutrient Sensitive Waters (NSW) Implementation Strategy requires a total reduction
in nutrients (total phosphorus and total nitrogen) within the Tar -Pamlico River basin.
If requirements other than those listed in this permit are adopted as part of a future revision to the
NSW strategy, the Division reserves the right to reopen this permit and include those requirements.
If requirements other than those listed in this permit are adopted to prevent localized adverse
impacts to water quality, the Division reserves the right to reopen this permit and include those
requirements.
LEGAL ADVERTISING INVOICE
No.24314
THE ROCKY MOUNT TELEGRAM
PUBLISHED BY ROCKY MOUNT PUBLISHING COMPANY
ROCKY MOUNT, NORTH CAROLINA 278D4
November 15, 2004
NCDENR
Attn: Carolyn Bryant
1617 Mail Service Center
Raleigh, NC 27699-1617
DAVIT OF PUBLICATION
swear that from my personal
TOTAL INCHES AMOUNT DUE $
and from reference to the files of
:KY MOUNT TELEGRAM, a
DESCRIPTION: public Notice
printed and published at Rocky
he Of Nash, STATE of
li , the Adve 'sment referred to
,i was publish d on the date(s)
l6
-egal Advertising Clerk
end subscribed me this
-before
�—" a
— dayof
PUBLISHED:
—
November 15, 2004
otary Public
Sion Expireseb 4,an5
ewspaper at time of publication of
vas qualified under G.S. 1-597 to
I legal advertising!
PUBLIC NOTICE
STATE OF
NORTH CP^^s 1NA—..
ENVIRONMENTAL
MANAGEMENT
COMMISSION/NPOES
UNIT
1617 MAIL SERVICE
CENTER
RALEIGH, NC 27699-1617
NOTIFICATION OF
INTENT TO ISSUE A
NPDES WAST TWATER
PERM
On the basis of thoruugl
staff review and appltcatto
law 92-Soo and
standards and
1e North Caro-
mpmal Man-
mit to me parwuo,
ys
from effective thapublish 4 s dateof
this notice.
Written comments regard-
ing the proposed permit will
be accepted until 30 days
after the publish date of
this notice. All comments
recelvod prior to that date
�.e mn,idered in the final
to hold a
Copies of the aftpermit
and other supporting infor
motion on file used to tlefer-
mine conditions present In
the draft permit are avail-
able upon uest and pay
&Q Osts of repro
for inior-
ity at the
or call Ms.
at (119) 733-
,arsans may also visit the
division of Water Ouality at
Raleigh, Salisbury
ur27604 1148
between the hours of 8:00
a.m. and 5.00 p.m. to
review infor7tl ten on file.
City of Rocky Mount (P.O.
Box 118D, Rocky Mount, NC
for
renewal ofsN POEISo parrot
N 00072125 far the Tar River
WTP in Nash County. This
p or miftetl facilit dis-
charges treated wastewater
To h¢ Tar RivBaser in the Tar-
l t
I It,. River in. Cur-
re"It total resitlu al chlo-
rine is water quality
IimifM. This discharge may
affect future allocations in
this portion of the Tor -
Pamlico River Basin.
water to the Tar River in
the Tar -Pamlico River
Basin. Currently total resid-
limitetl This discharge .I chlorine is water quality
may
affect future allocatlons in
this portion of the Tar -
Pamlico River Basin.
11/15, 20"
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
November 10, 2004
MEMORANDUM
To: Michael Douglas
NC DENR / DEH / Regional Engineer
Raleigh Regional Office
From: Karen Rust
NPDES Eastern Unit
Subject Review of Draft NPDES Permit NCO072125
City of Rocky Mount / Tar River WTP
Nash County
1, •ai�
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT ANo NATURAL RESOURCES
N
O
O
Please indicate below your agency's position or viewpoint on the draft permit and return this form by December 15,
2004. If you have any questions on the draft permit, please contact me at the telephone number or e-mail address
listed at the bottom of this page.
TC
SE: (Check one)
oncur with the issuance of this permit provided the facility is operated and maintained properly, the stated effluent limits
e met prior to discharge, and the discharge does not contravene the designated water quality standards.
❑ Concurs with issuance of the above permit, provided the following conditions are met:
❑ Opposes the issuance of the above permit, based on reasons stated below, or attached:
Vl
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 919 733-5083, extension 361 (fax) 919 733-0719
VISIT US ON THE INTERNE @ h1tp://h2o.enr.s1ate.nc.us/NP0ES Karen.Rust@ ncmail.nel
NPDES REGIONAL WATER QUALITY
STAFF REPORT AND RECOMMENDATIONS
(This form is best filled out on computer, rather than hard copy)
Date: 06/04/2004 County: Nash
To: NPDES Discharge Permitting Unit Permitee: Tar River WTP
Attn. NPDES Reviewer: Charles Weaver Application/ Permit No.: NCO072125
Staff Report Prepared By: Wilson Mize
--5
SOC Priority Project? (Y/N) N If Yes, SOC No.
A. GENERAL INFORMATION WA cr �N
1. This application is (check an that apply): ❑ New ® Renewal
❑ Modification JUN 10 P004
2. Was a site visit conducted in order to prepare this report? ® Yes or ❑:No
a. Date of site visit: 06/03/2004 NON -DISCHARGE PERMITTING
1'
b. Person contacted and telephone number: Jay Van Hoose - (252) 97 -1°3'3'6-
c. Site visit conducted by: Wilson Mize Mom'
d. Inspection Report Attached: ® Yes or ❑ No.
3. Keeping BIMS Accurate: Is the following BRAS information (a. through e. below) correct?
® Yes or ❑ No. If No, please either indicate that it is correct on the current application or the
existing permit or provide the details. If none can be supplied, please explain:
Discharge Point: (Fill this section onlv if BIMS or ADDlication Info is incorrect or missin
a. Location OK on Application ®,
OK on Existing Permit ❑, or provide Location:
b. Driving Directions OK on Application ®,
OK on Existing Permit ❑, or provide Driving Directions (please be accurate):
c. USGS Quadrangle Map name and number OK on Application ❑,
OK on Existing Permit ®, or provide USGS Quadrangle Map name and number: See attached
map.
d. Latitude/Longitude OK on Application ❑, (check at htto://topozone.com These are often
inaccurate) OK on Existing Permit ®, or provide Latitude: Longitude:
e. Receiving Stream OK on Application ❑,
OK on Existing Permit ®, or provide Receiving Stream or affected waters:
a. Stream Classification: WS-IV, NSW
b. River Basin and Sub basin No.: Tar -Pamlico River Basin - 03-03-02
c. Describe receiving stream features and downstream uses: The Sunset Ave. Water Treatment
Plant is downstream.
' NPDES REGIONAL WATER QUALITY
STAFF REPORT AND RECOMMENDATIONS
For NEW FACILITIES Proceed to Section C. Evaluation and Recommendations
(For renewals or modifications continue to section B)
B. DESCRIPTION OF FACILITIES AND WASTE(S) (renewals and modifications only)
1. Describe the existing treatment facility: Drinking Water Plant: Alum sludge from settling basin and
back wash from filters are pumped to trav-vac basins, the sludge is pumped from these basins to sludge
press for dewatering, this water is sent back to trac-vac basins and the supernate is discharged.
2. Are there appropriately certified ORCs for the facilities? ® Yes or ❑ No.
Operator in Charge: Jay Van Hoose Certificate # PC-1 / 985816 (Available in BIMS or Certification
Website)
'Back- Operator in Charge: Gary Weeks Certificate # PC-1 / 985812
3. Does the facility have operational or compliance problems? Please comment: No.
Summarize your BIMS review of monitoring data (Notice(s) of violation within the last permit cycle;
Current enforcement action(s)): Data appears to be accurate at this time.
Are they currently under SOC, ❑ Currently under JOC, ❑ Currently under moratorium ❑? Have
all compliance dates/conditions in the existing permit, SOC, JOC, etc. been complied with? ❑ Yes
or ❑ No. If no, please explain:
4. Residuals Treatment: Pf ['(Process to Significantly Reduce Pathogens, Class B) or
PFRP JM (Process to Further Reduce Pathogens, Class A)?
Are they liquid or dewatered to a cake? dewatered
Land Applied? Yes ❑ No ® If so, list Non -Discharge Permit No. NA
Contractor Used:
Landfilled? Yes ® No❑ If yes, where? Hauled by Granville Farms to Nash County Landfill
Other? NA
Adequate Digester Capacity? Yes ❑ No ❑ Sludge Storage Capacity? Yes ❑ No ❑
Please comment on current operational practices: NA
5. Are there any issues related to compliance/enforcement that should be resolved before issuing this
permit? ❑ Yes or ® No. If yes, please explain:
C. E VAL UA TION AND RECOMMENDATIONS
1. Alternative Analysis Evaluation: has the facility evaluated the non -discharge options available? Give
regional perspective for each option evaluated:
Spray Irrigation: NA
Connect to Regional Sewer System: NA
FORM: NPDES-RRO 06/03 2
NPDES REGIONAL WATER QUALITY
STAFF REPORT AND RECOMMENDATIONS
Subsurface: NA
Other Disposal Options: NA
2. Provide any additional narrative regarding your review of the application:
3. List any items that you would like NPDES Unit to obtain through an additional information
request. Make sure that you provide a reason for each item:
Recommended Additional Information I Reason
4. List specific Permit requirements that you recommend to be removed from the permit when
issued. Make sure that you provide a reason for each condition:
Recommended Removal I Reason
5. List specific special requirements or compliance schedules that you recommend to be included in
the permit when issued. Make sure that you provide a reason for each special condition:
Recommended Addition I Reason
6. Recommendation: ❑ Hold, pending receipt and review of additional information by regional office;
❑ Hold, pending review and approval of required additional information by NPDES permitting
office; ® Issue; ❑ Deny. If deny, please state reasons:
Reminder: attach inspection report if Yes was checked for 2 d.
7. Signature of report preparer:
Signature of WQS regional su
FORM: NPDES-RRO 06/03 3
UMed slates Environrnental Protection Agency
Form Approved.
EPA Washington, D.C.20460
ONNo. 2040-0057
Water Compliance Inspection Report
Approval expires 831-98
Section A National Data System Coding (i.e., PCs)
Transaction Code NPDES yr/mo/day Inspection Type Inspector Fac Type
1 N 2 U 31 Norm-'__'j. 11 121 o4/06/03 17 18Lj 19Lj 20Lj
Remarks
211111111111111111111111111111III IIIIIIIIIIIII11166
Inspection Work Days Facility Self -Monitoring Evaluation Rating 61 QA Reserved
67 I 169 70 U 71 u 72 Lj 73 w 74 75I I I I I I I 180
Section B: Facility Data
Name and Location of Facility Inspected (For Industrial Users discharging to POTW, also include
Entry Time/Date
Permit Effective Date
POTW name and NPDES permit Number)
Ax-�4/05/-3
co/c2/ol
Tar River WTP
Exit Time/Date
Permit Expiration Date
4469 L=_ast r, Read
Rocky Mount NC 27802
11 30 AM 04%06/03
04/10/31
Name(s) of Onsite Representative(syTitles(s)/Phone and Fax Number(s)
Other Facility Data
Jay W. Van Foals/nRr,.-_=___r72-t335/
Name, Address of Responsible OfficialTtle/Phone and Fax Number
Paul B Blount,PO Box 1180 Rocky Mount NC 27802//252-972-1292/ Contacted
No
Section C: Areas Evaluated During Inspection (Check only those areas evaluated)
Permit E Operations & Maintenance Records/Reports N Self -Monitoring Program
Sludge Handling Disposal 0 Facility Site Review Effluent/Receiving Waters 0 Laboratory
Section D: Summary of Finding/Comments (Attach additional sheets of narrative and checklists as necessary)
(See attachment summary)
Name(s) and Signature(s) of Inspector(s) Agency/Office/Phone and Fax Numbers Date
Wilson [-0i �e RRG WQ//9195�: d%UOU_35/9_9-571-4'ti8
signature of Management Q A Review Agency/Office/Phone and Fax Numbers Date
11 [P %
EPA Form 35603 (Rev 9-94) Previous editions are obsolete.
NPDES yr/mo/day Inspection Type
31 rac^m2125 j11 12 04/06/U� 17 1B U
Section D: Summary of Finding/Comments (Attach additional sheets of narrative and checklists as necessary)
Permit: NC0072125 Owner - Facility: City of Rocky Mount - Tar River WiP
Inspection Date: 06/03/04 Inspection Type: Compliance Evaluation
Permit
(If the present permit expires in 6 months or less). Has the permittee submitted a new application?
Yec
■
No
❑
NA
❑
NF
❑
Is the facility as described in the permit?
■
❑
❑
❑
Are there any special conditions for the permit?
❑
■
❑
❑
Is access to the plant site restricted to the general public?
■
❑
❑
❑
Is the inspector granted access to all areas for inspection?
IN
❑
❑
❑
Comment:
Ooerationc&Maintenance
Does the plant have general safety structures in place such as rails around or covers over tanks, pits, or wells?
Yes
■
No
❑
NA
❑
NF
❑
Is the plant generally clean with acceptable housekeeping?
■
❑
❑
❑
Comment:
Laboratory
Are field parameters performed by certified personnel or laboratory?
Yes
■
No
❑
NA
❑
NF
❑
Are all other parameters(excluding field parameters) performed by a certified lab?
❑
❑
■
❑
Is the facility using a contract lab?
❑
❑
■
❑
Are analytical results consistent with data reported on DMRs?
■
❑
❑
❑
Is proper temperature set for sample storage (kept at t.0 to 4.4 degrees Celsius)?
■
❑
❑
❑
Incubator (Fecal Coliform) set to 44.5 degrees Celsius+/- 0.2 degrees?
❑
❑
■
❑
Incubator (BOD) set to 20.0 degrees Celsius +/- 1.0 degrees?
❑
❑
■
❑
Comment:
Yes
No
NA
NF
Record Keenino
Are records kept and maintained as required by the permit?
■
❑
❑
❑
Is all required information readily available, complete and curent?
■
❑
❑
❑
Are all records maintained for 3 years (lab. reg. required 5 years)?
■
❑
❑
❑
Are analytical results consistent with data reported on DMRs?
■
❑
❑
❑
Are sampling and analysis data adequate and include:
■
❑
❑
❑
Dates, times and location of sampling
❑
Name of individual performing the sampling
❑
Results of analysis and calibration
❑
Dates of analysis
❑
Name of person performing analyses
❑
Transported COCs
❑
Plant records are adequate, available and include
■
❑
❑
❑
O&M Manual
❑
As built Engineering drawings
❑
Schedules and dates of equipment maintenance and repairs
❑
Are DMRs complete: do they include all permit parameters?
■
❑
❑
❑
Has the facility submitted its annual compliance report to users?
❑
❑
❑
■
(If the facility is = or> 5 MGD permitted Bow) Do they operate 24/7 with a certified operator on each shift?
❑
❑
■
❑
Is the ORC visitation log available and current?
■
❑
❑
❑
Is the ORC certified at grade equal to or higher than the facility classification?
■
❑
❑
❑
Is the backup operator certified at one grade less or greater than the facility classification?
■
❑
❑
❑
Is a copy of the current NPDES permit available on site?
■
❑
❑
❑
Is the facility description verified as contained in the NPDES permit?
0
❑
0
❑
Permit: NC0072125 Owner - Facility: City of Rocky Mount - Tar River WiP
Inspection Date: 06/03/04 Inspection Type: Compliance Evaluation
Record Keeping
Does the facility analyze process control parameters, for example: MLSS, MCRT, Settleable Solids, DC, Sludge
Judge, pH, and others that are applicable?
Facility has copy of previous years Annual Report on file for review?
Comment:
Fflluent Pine
Is right of way to the outfall propedy maintained?
Are receiving water free of solids and floatable wastewater materials?
Are the receiving waters free of solids / debris?
Are the receiving waters free of foam other than a trace?
Are the receiving waters free of sludge worms?
If effluent (diffuser pipes are required) are they operating properly?
Comment:
H■ ■ ■
131313 ■
Vac No NA NF
M ❑ ❑ ❑
1313 ■ ❑
❑ ❑ ■ ❑
❑ ❑ ❑
■ ❑ ❑ ❑
❑ ❑ M ❑
CITY OF ROCKY MOUNT
April 7, 2004
Mrs. Valery Stephens
NC DENR / Water Quality / Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Dear Mrs. Stephens:
Subject- Renewal Notice NPEDS Permit NCO072125
DEPARTMENT OF
WATER RESOURCES
4-� 1
I APR 2 2 2004
I
This letter is to request for permit renewal for NPEDS permit NCO072125 for the Tar River Water
Treatment Plant located at the City of Rocky Mount.
Our process is that of a typical surface water treatment plant with the following treatment steps of
coagulation, flocculation, sedimentation and filtration. The sludge that has accumulated during the
sedimentation process will then be thickened and then dewatered in our plate and frame filter press.
The fitter cake is then disposed of in a landfill. Our backup plan is for the thickened sludge to be
hauled away and land applied on approved permitted land by Grandville Farms.
Attached please find our completed application and required copies. If you have any questions in
reference to this application for renewal, please feel free to contact me at (252)-972-1336.
Sincerely,
Jay W. Van Hoose
Superintendent of Water Treatment
City of Rocky Mount
Enclosure (1)
One Goverment Plaza • Post Office Box 1180 Rocky Mount, North Carolina 27802-1180
Telephone (919) 972-1111 Fax(919) 972-1232