820284_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 82-0284 Certificate Of Coverage Number:
2. Facility Name: G&R Farms
3. Landowner's Name (same as on the Waste Management Plan): Gene S West
4_ Landowner's Mailing Address: 688 S Eldridge Rd
City: Newton Grove
Telephone Number: 910-567-5319 Ext.
State: NC
E-mail:
5. Facility's Physical Address: 668 S Eldridge Rd : C A 3 n+ 11, fl i lA i IK S . b I L
City: Newton Grove State:
6. County where Facility is located: Sampson
7. Farm Manager's Name (if different from Landowner):
g. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"):
10. Operator Name (OIC): Gene S. West Jr.
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Tvoe
Swine - Feeder to Finish
Operation Types:
Swine
Cattle
Wean to Finish
Dairy Calf
Wean to Feeder
Dairy Heifer
Farrow to Finish
Milk Cow
FeedeT to Eiiusli-
Dry Cow
Farrow to Wean
Beef Stocker Calf
Farrow to Feeder
Beef Feeder
Boar/Stud
Beef Braad Cow
Gilts
Other
Other
NC
Prestage Farms Inc
Phone No.: 910-385-8701
Allowable Count
6,890
AWS820284
Zip: 28366
Zip: 28366
OTC 4: 18456
Dry Poultry
Other Types
Non Laying Chickens
Horses - Horses
baying Chickens
Horses - Other
Pullets
Sheep- Sheep
Turkeys
Sheep- Other
Turkey Pullet
Wet Poultry
Non Laying Pullet
Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
i
-TiAi.4 i[CiRil
C-1 a%/
7 f i 3
i4 95�-e8'
19.00
2
SCpr. e$q4
C i ao
I I"
s eee
19.00
3
@IiG l4��i
4r1 i
' (�� (,�
28.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
L The most recent Waste Utilization Plan (WUP), signed by the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2_ A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility_
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewal(&ncdenr.gov

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should he by a prinncipal executive officer of the corporation):
Name: Sly _�2 Title: OW/1 45i-
Signature: dw _'?, ^—' a yC Date: Lfi 1 ej
Name:
Signature:
N ame:
Signature:
Title:
Date:
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636 .
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
5e�r�trry
LINDA CULPEPPER
0ireztor
NC RTH CAROLINA
EnWrvnmental QuaUf)r
February 27, 2019
Gene S West
G&R Farms
688 S Eldridge Rd
Newton Grove, NC 28366
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deci.ne.gov/about/divisions/water-resources/water-quality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non-Dischar4e General Permit." The application form must be completed, signed and returned by April 3, 2019.
Please note that you must include one (1)__cop_y__of_ the _CertifiedAnimal Waste Management Plan (CAWMP) with the
completed and signed _application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.Land could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc (w/o enclosures): Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Soil and Water Conservation District
AFOG Section Central Files - AWS820284
Prestaize Farms Inc
�-, Nert�ae:ara rsa©ar�art^�eat•�Envs a-rnerta r1 ast_• � �usbn�;#%4'aterRe17ur�s �12 N. Sa shun St. 1 1cSo N1a � rvt� entefr I Rae gh, Perth Care �e =Se 1WE,
..._.,, Baia 707 HM 0

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISI❑N OF WATER QUALITY (DWQ) 910-406-1541
EMERGENCY MANAGEMENT SERVICES (EMS) 910-592-B996
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-592-7963
NATURAL RES❑URCES C❑NSERVATION SERVICE (NRCS) 910-592-7963
C❑❑PERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be passible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flaw to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side
walls and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish kills, or
Property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off of
the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of
Water Quality) regional office, at 910-486-1541, after
hours, emergency number:919-733-3942. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE SEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-592-8496.
c. Instruct EMS to contact local Health Department.
d. Contact local SAMPSON Soil and Water Conservation
District (SWCD), Natural Resources Conservation Service
(NRCS) office at 910-592-7963 and Cooperative Extension
Service (CES) at 910-592-7161 for advice/technical
assistance_
4. If none of the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies jor yoLl.

c Contact the con-tr-actQr of Y-or chnice to begin r epajr- of the
problem to minimize off -site damage.
a• Contractors Name:
h. Contractors Address: 057
3�
c. Contractors Phone: Ito -5cC0410c,
6. Contact the technical specialist who certified the lagoon (NRCS,
Consulting Engineer, etc.)
a. Name: GLIM �3_ FTUli
b . Phone: 5`ij.- 1-11
7. Implement procedures as advised by DWO and technical assistance
agencies to rectify the damage, repair the system,, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
a. If you are a contract swine grower associated with a swine
company integrator, contact the company representative at
1--910--592--5771

EMERGENCY ACTION PLAN
SITE INFORMATION
Unit Location:GENE WEST
Premise ID Number: OOCAE64
Owner/Operator Name: GENE WEST
39S- $7vt '710- 50- 5314
Cell: 910- Alternate:
911 Address:
50 "TH
66eELDRIDGE ROAD
NEWTON GROVE, NC 28366
Rescue/Ambulance: Phone 911
Hospital or Clinic: Name SAM4 &J"Otial MrLlifdl CCi,4LiL Phone
Veterinarian: Name Dr. Matthew Turner Phone [phone]
Fire Department: Phone 911
Police/Sheriff: Name 911
Other: Name out of feed — weekend Phone [phone]
Name Power Com an %"+ a Phone_ q 10- S9P- 9071
Name
Phone
Name Phone

Swine Farm Waste Management Odor Control Checklist
Source Cause BKPs to Minimize Odor Site Specific Practices
Pttmtttettd Swine production is Vegetative or wooded buffers;
JZf Recommended best management practices;
E' Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals Dry' floors
Floor surfaces 0 Wet manure -covered floors 6 Slotted floors;
121 Waterers located over slotted floors;
d Feeders at high end of solid floors;
❑ Scrape manure buildup from floors;
❑ Underfloor ventilation for drying
Manure collection pits
+ Urine;
2f
Frequent manure removal by flush, pit recharge,
6 Partial microbial decomposition
or scrape;
❑
Underfloor ventilation
Ventilation exhaust fans
• Volatile gases;
Fan maintenance;
Dust
QJ
Efficient air movement
Indoor surfaces
Dust
Wasltdown between groups of animals;
❑
Feed additives;
❑
Feeder covers;
41
Feed delivery downspout extenders to feeder
Flush tanks
• Agitation of recycled lagoon
❑
covers
Flush tank covers;
liquid while tanks are filling
❑
Extend fill lines to near bottom of tanks with IF
anti -siphon vents
Flush alleys
• Agitation during wastewater
❑
Underfloor flush with underfloor ventilation
conveyance
4.
Pit recharge points
• Agitation of recycled lagoon
❑
Extend recharge lines to near bottom of pits
liquid while pits are filling
with anti -siphon vents
Lift stations
• Agitation during sump lank
❑
Sump tank covers
filling and drawdown
Outside drain collection
• Agitation during wastewater
Box covers
orjunction boxes
conveyance
AMOC -November 11, 1996, Pages

Source Cause BMPs to Minimize Odor Site Specific Practices
Standing water around + Improper drainage; Grade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto + Poorly maintained access roads )21 Farm access road maintenance
public roads from farm
access
Additional Information : Available From:
Swine Manure Management; 0200 RuleBMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Shcet NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88 NCSU - BAG
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Shed NCSU - RAC
Controlling Odors from Swine Buildings ; PIU-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor; a rcport from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC • November 11, 1996, Page 5

Source Cause DMZ's to Minimize Oddr Site Specific Practices
End of drainpipes at + Agitation during wastewater ❑ Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions;
Proper lagoon liquid capacity;
Biological mixing; e Correct lagoon startup procedures;
Agitation 0 Minimum surface area -to -volume ratio;
if Minimum agitation when.pumping;
❑ Mechanical aeration;
❑ Proven biological additives
Irrigation sprinkler • High pressure agitation; Zr Irrigate on dry days with little or no wind;
nozzles + Wind drill
U' Minimum recommended operating pressure;
❑ - Pump intake near lagoon liquld surface;
CI Pump from second -stage lagoon
Storage tank or basin • Partiai microbial decomposition; 13 Bottom or midlevel loading;
surface • Mixing while filling; ❑ Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑
Proven biological additives or oxidants
Settling basin surface
Partial microbial decomposition;
©
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
•
Agitation when emptying
❑
Remove settled solids regularly
Manure, slurry or sludge +
Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader outlets •
Volatile gas emissions
Cl
Wash residual manure from spreader after use;
❑
Proven biological additives or oxidants
Uncovered manure, •
Volatile gas emissions while
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
surfaces
❑
Soil incorporation within 48 firs.;
❑ Spread in thin uniform layers for rapid drying;
❑ Proven biological additives or oxidants
Dead animals Carcass decomposition IY Proper disposition of careaxscs
Dead animal disposal • Carcass decomposition ❑ Complete coverittg of carcasses in burial pits;
pits
17 Proper location/construction of disposal pits
Incinerators 0 Incomplete combustion ❑ Secondary stack burners
AMOC -November 11, 1996, Page 4

Insect Control Checklist for Animal Operations
Source
Cause
BMPs to Control Insects Site Speciite Practices
Liquid Systems
Flush Gutters
+ Accumulation of solids
El Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
0 Remove bridging of accumulated solids at
discharge
Lagoons and Pits
• Crusted Solids
Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative
• Decaying vegetation
U Maintain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed Spillage ff Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
1f Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage Accumulations of feed residues Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page I

Mortality Management Methods
(check which method(s) are being implemented)
C1 Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
L3 Rendering at a rendering plant licensed under G.S. 106-169.7
V Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

Vetsi m—November 26, 2019
Mortality Management Methods
indicate which method(s) will be implemented.
When selecting muthple methods indicate a primary versus secondary option.
Methods Other than those listed must be approved by the State Veternarian,
Primary
Secondary
Routine MortMity
❑
❑
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from .any flowing stream or public body of watiar
(G:S.1015-403).. The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location chap and plan.
❑
❑
Landfill at municipal solid waste facility .permitted by NC DEQ under GS 15A. NCAC
13B .62€30..
Rendering at a rendering plant licensed under G.S..1fl6-168..7..
D❑ Complete incineration according to 02 NCAC 52C .0102_
❑ ® A composting system approved and permitted by. the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm, .
additional requiriamente.. must bd Met and a permit is required from NC DEQ.
❑ ❑ In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G_S. 106-549-70).
❑ ❑ Any method which, in the professional opinion of the State'Veterinarian, would make. possible.
the salvage of park of a dead animal's value without endangering human or animal heatth.
(Written approval by the State Veterinarian must be attached).
❑ Mass Mortality Plan
Mass mortality plans are required for farms covered by an .NPDES permit These plans are
also recommended for all animal operations_ This plan oWines farm -specific mortality man-
agement methiods to be used for mass mortality: The.NCDA&C.S• Veterinary Division sup-
ports a variety of emergency mortality disposal ophow cocrtact the Division for guidance..
• A catastrophic mortality disposai plan is part of -the facility's GAWMP and is activated
when numbers of dead animals exceed. normal mortality rates as specified by ;the: State
Veterinarian.
Burial mustbe done in accordance with NG General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• M&S.S burial sites are Subject to additional perrrfit conditions (refer to facility's animal
waste management system permit)_
• -,In the event of imminent threat of a disease emergency, the state Veterinarian may enact
additional temporary procedures or measures for disposal according to G S. 1106, 3g9.4.
Al
r+V
Signature Farm owner/Manager
f
Signature Trechvnical Specialist
7`j!
Date
4-1 r I 19
Date

HOG FARM
TO DO
check for dead
check waterers
check feeders
report temp. & dead
dispose of dead
replace disenfectant
wash clothes
take feed inventory
check feed lines
clean under bins
pull plugs
put plugs in/pump on
check curtains
check curtain rope
clean shower room
cut grass
check rat bait
spray round up
checkfans
other maintenance
Phone Numbers
OPERATION & MAINTENANCE - TO DO LIST
Weeklv Monthly Mondav Therdav Wednesdav Thursdav Frirfav Ctaturrlav Crrnrlav
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
x
Gene West
910-385-8701
Rhonda West
910-385-8702
Matthew West
910-385-8703
Scott Strickland
910-237-3132
Hog Slat, Inc.
910-594-0219
Alan Honeycutt - Electrician
910-385-8397
Prestage;
Service Person - Tyler
Equipment Service - Derrick
Office
Feed Mill - Moltonville
910-214-6166
910-596-8828
910-592-5771
910-592-3531 ext. 1

Waste Utilization Plan
Producer.
Name of Farm:
Location:
Phone:
Type of Operation:
Number of Animal:
Storage Structure:
Method of Application
Gene West
G & R Farms
668 S Eldridge Rd.
Newton Grove NC 28366
910-385-8701
Feed -Finish
6890
Anaerobic Lagoon
Irrigation
Amount of waste produced per year:
Amount of plant available N (PAN) produced/year:
Amount of plant available phosphorus produced/year:
County: Sampson
13091 ton/year
15847 lbs./year
8957 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
Z_ Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
S. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

G & R Farms Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Cotton and Winter Annual
Tract No.
Pul] No.
Soil Type
Crop
Yield/Ac
Lbs. N Acres
Lbs N Month to
Lbs. N
Code
unit
Used Apply
Per Ac.
9040-9038
Pivot 1
GoA
Cotton
925
0.12
34.97
3982 MAR15-AUGi
111
9040-9038
Pivot 1
GoA
WA
1
100
34.97
3497 SEP-MAR
100
3488
Pivot 2
NoA
Cotton
875
0.12
25.00
2625 MAR15-AUG1
105
3488
Pivot 2
NoA
WA
1
100
25.00
2500 SEP-MAR
100
3488
Pivot 3
Ra
Cotton
800
0.12
11.00
1056 MAR15-AUG1
96
3488
Pivot 3
Ra
WA
1
100
11.00
1100 SEP-MAR
100
3487
Pivot 4
NoA
Cotton
875
0.12
15.00
1575 MAR15-AUGi
105
3487
Pivot 4
NoA
WA
1
100
15.00
1500 SEP-MAR
100
9041
23
NoA
Cotton
875
0.12
1.84
193 MAR15-AUGi
105
9041
23
NoA
WA
1
100
1.84
184 SEP-MAR
100
9041
24A
NoA
Cotton
875
0.12
3.64
382 MAR75-AUG1
105
9041
24A
NoA
WA
1
100
3.64
364 SEP-MAR
100
9041
246
NoA
Cotton
875
0.12
3.89
408 MARTS AUGi
105
9041
24B
NoA
WA
1
100
3.89
389 SEP-MAR
100
Total
95.34
19655 lbs.
Available Nitrogen
15847 lbs.
Surplus or Deficit
-3808 lbs.
Corn and Winter Annual
Tract No.
Pull No.
Soil Type
Crop
Yield/Ac
Lbs. N Acres
Lbs N Month to
Lbs. N
Code
unit
Used Apply
Per Ac.
9040-9038
Pivot 1
GoA
Corn
125
1.25
34.97
5455 FEB-I5-JUN
156
9040-9038
Pivot 1
GoA
WA
1
100
34.97
3497 SEP-MAR
100
3488
Pivot 2
NoA
Corn
110
1.25
2S.00
3438 FEB-IS-JUN
137.5
3488
Pivot 2
NoA
WA
1
100
25.00
2500 SEP-MAR
100
3488
Pivot 3
Ra
Corn
110
1.25
11.00
1513 FEB-15-JUN
137.5
3488
Pivot 3
Ra
WA
1
100
11.00
1100 SEP-MAR
100
3487
Pivot 4
NoA
Corn
110
1.25
1S.00
2063 Fee-is-JUN
137.5
3487
Pivot 4
NoA
WA
1
100
15.00
1500 SEP-MAR
100
9041
23
NoA
Corn
110
1.25
1.84
253 FEB-15-JUN
1375
9041
23
NoA
WA
1
100
1.84
184 SEP-MAR
1.00
9041
24A
NoA
Corn
110
1.25
3.64
50"-SEP-MAR
137.5
9041
24A
NoA
WA
1
100
3.64
36
100
9041
24B
NoA
Corn
110
1.25
3.89
53
137.5
9041
24B
NoA
WA
1
100
3.1
38
10D
Total
95.34
23292lbs.
Available Nitrogen
15847 lbs.
Surplus or Deficit
-7445 lbs.
Applying the above amount of waste is a bigjob. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

G & R Farms
Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (Le_ small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 2480 lbs. of plant available
nitrogen per year in the sludge_
If you remove sludge every 5 years you will have approximately 12402 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 41
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need gg
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods_
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

G & R Farms
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Cotton and Winter Annual
Tract No.
Pull No,
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
9040-9038
1
GoA
Cotton
0.4
1.0
904D-9038
1
GoA
WA
0.4
1.0
3488
2
NoA
Cotton
0.4
1.0
3488
2
NoA
WA
0.4
1.0
3488
3
Ra
Cotton
0.35
1.0
3488
3
Ra
WA
0.35
1.0
3487
4
NoA
Cotton
0.4
1.0
3487
4
NoA
WA
0-4
1.0
9041
23
NoA
Cotton
0.4
1.0
9041
23
NoA
WA
0.4
1.0
9041
24A
NOA
Cotton
0.4
1.0
9041
24A
NoA
WA
0.4
1.0
9041
24B
NoA
Cotton
0.4
1.0
9041
24B
NoA
WA
Corn and Winter Annual
Tract No.
i Pull No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
9040-9038
1
GoA
Corn
0.4
1.0
9040-9038
1
GoA
WA
0.4
1.0
3488
2
NoA
Corn
0.4
1.0
3488
2
NoA
WA
0.4
1.0
3488
3
Ra
Corn
0.35
1.0
3488
3
Ra
WA
0.35
1.0
3487
4
NoA
Corn
0.4
1.0
3487
4
NoA
WA
0.4
1.0
9041
23
NoA
Corn
0.4
1.0
9041
23
NoA
WA
0.4
1.0
9041
24A
NoA
Corn
0.4
1.0
9041
24A
NoA
WA
0.4
1.0
9041
24B
NoA
Corn
0.4
1.0
9041
24B
NoA
WA
0.4
1.0

G & R Farms
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

G & R Farms
Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1_ Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip),
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may he broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9_ Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10_ Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients_ Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal_ Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

G & R Farms
Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells_
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: G & R Farms
Owner/Manager Agreement Gene West
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Gene West
Signature:
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc. Phone: [phone]
Address: P.O. Box 438
Clinton, NC 28329
Signature:
Date:
Date:
Date: 3 t ?— t 4-

r
9
5
to
Pivot # 1 ;
34.97 acres

Soil Ma"ampson County, North Carolina
35. 13 30"
35' 12' 34"
Mep Scale: 112,500 if printed cn A size (8,6" x 11 ") sheel,
N N Meters
0 150 300 Goo 800
Feet
0 S00 1,000 2,000 3,000
USA Natural Resources
;ilk Conservation Service
Web Soil Survey
National Cooperative Sol€ Survey
11/30/2011
Page 1 of 3
35° 13' 28"
35.12' 31"

amp�on County FAA Vsfetfanrl petarmination lclentifiers plsdafiner: Weiland t<lenliflers (ID notrepresent the size. shape,
® Resirletecl Use or speclfia cielennhlatlon of the area. Ref010 your orlgihal
Farm 9 IJlnitad Resirlchons determfnallon ICPA-026 and Oita maps) fbt exact Weiland
4300 Tract 9035 l3ouirdarles and delerminatfons. or contact NRCS.
Exem 1 ftom GonserVetivh Goni Ilanc6 Provisions
I �Y
a,
Acres Crop
HEL
CRP
1 3.16
2
1.IS
3
3.71.
4
25.83
Total Cropland Acres
33.8

6ampson County FSA
Farm 14300 Tract 9039
4 Q
IV
�I
;P
-�"�r pis
n r� rw''9w
!oe,
.IM:
`l"otatl Cropland Acres
s 9.8

Sampson County FSA
Farms 16761 Tract 3487
Wetland Determination identifiers Ofsclalmer: Welland Idenflflers do not represent the size, shape,
Restricted Use or specfllc determ#naflon of1he area. Rarerto yourorlglnal
Untiled Restrlclfons determination (CPA-026 and attached maps) for exact weltand
boundaries and delerminatfons, or contact MRCS.
-M Exempt rrom Conservation Comcllanrn or—iei..,.e
Crog)
"1 12.6
3 20.1
4 9.2.
9 7.2
Total Cropland Acres
49.2

m
Wetland Determination Identifiers Disclaimer: Wetland Identifiers do not repro sent the size, shops
Restricted Use or specific determination o€the Area. Refertoyour original
determination 4CPA-026 and alfacharl maps)for exact wetland �Acres�r.o
Limited Reshlctlons boundaries and determtnatfons. or contact MRCS, --'-
Exempt from Conservation Cana (lance Provisions
2 13.72
1 `tip
Map for FSA purpos95 OMY Total Cropland Acres
35.4

-. W-Est plans to construct a 2480 topping operation on a 20 acre tract of
it1d. The operation wilfl consist of 4 topping houses and a waste treatment
�gaan. Mr, blast does n t have adequate land for waste disposal,`.and has
Gtered into agreement ti th 4 adjacent lanowners to dispose of some waste on
jeir land as needed.
TE CONDITIONS:
Fe lagoon will be constructed in two soil types, one being Rains (830) sandy
jam and having a seasonal high water table at or near the surface, and the
:her being Goldsboro (410) loamy sand which has a seasonal high water table
gat remains 2 to 3 feet below the surface.
'PE AND SIZE
OPERATION
.ASS
:SIGNED BY
JE
Finishing
2480
G. Glenn Clifton
5/30/89
'PROVED BY ,� • e�-d-�—
JE crl tl� Bg.
RMANENT STORAGE
2480 Hogs x 135 Ibs per hog 1 Cu Ft per lb.
MPORARY STORAGE
334800 lbs of animal x 1.35 cu. ft. of waste per day
per 1000 Ibs of animal wt. x 180 days
INFALL LESS EVAPORATION
X 68016 sq. ft. surface area per 12"per ft
INFALL — 25 YR. 1 DAY STORM
X 68016 sq. ft. of surfaoe area per 12" per ft.
TOTAL STORAGE NEEDED
TOTAL STORAGE AVAILABLE
NURE AND URINE PRODUCTION
2480 hogs x 2.1 tons per year
334800 Cu Ft
81356 Cu Ft
39676 Cu Ft
39676 Cu Ft
455832 Cu Ft
16883 Cu Yds
457173 Cu Ft
16932 Cu Yds
5208 T./yr.

DEPTH EAREA OF TOP + AREA OF BOTTTOM + 4 X AREA OF MIDSECTION]
-.�r�E _----------------------------------- -----------------------------
6.0 27
DEPTH C L X W + L X W+ 4 X L X W I
VOLUME=-------------------------- ---------------------
6 27
10.0 C 612 X
VOLUME _-------------------
6
10.0 E 2743041
VOLUME =-----------------
6 27
457173 CU. FT.
VOLUME _---------
27
VOLUME = 16932 CU.YDS.
97 X 572 X 57 + 4 X 592 X 771
---------------------------------------
27
68016 sq.ft.
455832 cu. ft. needed
SIDE SLOPES 2:1
INSIDE TOP MEASUEMENTS 620 FT. X 105 FT.

PHONE [phone] _
�f------------------------------------------------------_------ ----
OPERATOR:
Please review the attached plan and specifications carefully.
Retain this plan for your use and records. It is strongly
recommended that you, your contractor and Soil Conservation
Service personnel are in agreement as to how the waste lagoon
is to be constructed. SCS personnel will meet with all
concerned parties and walk over the site to explain all flags
and markings. It is important that everyone understand what is
expected so that final construction meets plans and
specification and the ,job can be certified for payment Cif ACP
cost sharing is involved).
The pad dimensions and grades are the best estimate. The
builder or contractor is responsible for final layout and
design of the pads. SCS personnel will assist in a limited
capacity, as its major concern is the proper design and
construction of the waste treatment lagoon.
The actual amount of material required for pads and dam may
vary from the estimates. The design will attempt to balance
cuts and fills as close as possible. If additional material is
required after construction is complete on the lagoon, the
contractor and owner will negotiate on the price and location
of borrow area.
It should be noted that certification of the lagoon will depend
upon all specifications being met. Important items include
length, width, depth, slopes, topsoil placement, correct
elevations (top, bottom, discharge pipes), and seeding.
NOTE:
Design Requirement: 4-Sl1113 cu.ft. ,537- -- cu.yds.
Estimate of Excavation q-otgc?cu.ft. _ 1,5,0- 1 cu•yds.
Estimate of Pad & Dike 3323i(P cu.ft. 1230 0u.yds.
Estimate of Topsoil Required = -- 4-0 — cu-yds.
1. 7 4 Rat i o
Job Class
Designed By
Design Approval
Date
f
rr
-�J jj_q_
Date
MIN

,A TO BE SEEDED
'PLY THE FOLLOWING
1 AC.
SE THE SEED MIXTURE
NDICATED
t )
f )
500 LBS. 8-8-8 FERTILIZER
2 TONS DOLOMITIC LIMESTONE
0 BALES SMALL GRAIN STRAW
0 LBS. FESCUE GRASS
0 LBS. OATS
50 LBS. BAHIA GRASS
0 LBS. KEEPING LOVE GRASS
12 LBS. HULLED BERMUDA GRASS
0 LBS. UNHULLED BERMUDA GRASS
0 LBS. RYE (GRAIN)
DIVERT ALL WATER TO A STABLE OUTLET
-HE NEAREST RESIDENCE IS 800 FT.
.B.M. ELEVATION 50.00
)ESCRIPTION Nail in base of 10" fence post (corner) located
approx. 75` west of station 0+00

/
'
'
OpeT County: SAMPSON
Date:
D1stance to nearest residence (other than owner):
�000.0 feet
1. AVERAGE LIVE WE�GHT
0 so�s (farrnw to finish> x
1417 lbs.
=
0 1bs
�0 sows (farrow to feeder)
2940 head (finishing only) x
135 lbs. =
396900 lbs
0 s�ws (farrow �o wea�> x
4�53 l�s.
=
0 Ibs
0 hea� (wean to feeder) x
30 lbs.
Describe
=
0 Ib�
:
0
e 4gnt =
396900 lbs
(Z. MINIMUM REQUIRED TREATMENT ;OLUME OF LAGOON
Volume 0O lbs' ALW x Treatment
Volume(�F)/Jb. AL�;
Treatuent- Volume(CP�/lb. ALW =
1 CF/ib. ALW
Volume = 396900 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
SLUDGE ACCUMULAT1ON
NOT COMPUTED
VoIume = 0.0 cubic feet
fZT OWNERS REQUEST� REMOVE
3LUDGE
AS Nv7EDED.
4' T[>T��L DESIGNED VOLUME
de top Iength (feet)---------------------
345.0
Inside top width (feet)----------------------
�o� of dik� eIevation (feet)-----------------
25O.0
5O.0
Bottom of la�oon eleva�ion (f�et)------------
40.0
Freeboard (feet)-------------------------____
1.0
Side slopes (inside l�g000>------------------
3.0 :
1
TotaI design volume using �rismoidal
formula
SS/FND1 SS/END2 SS/SIDE1 BS/SIDE2
DEPTH
3.0 3.0 3.0 3.0
339.0 244.0
ARE*
�ENGTH * WIDTH =
339.0 244.0 B2716
(AREA OF TOP)
AR�A OF BOTTOM
LENGTH * WIDTH ~
285'0 190.0 54l50
(AREA OF E0TTOM)
AREA OF MIDSECTIO;
LENGTH * �VIDTH * 4
312.0 217.0 27O816
(A�EA OF MIDSECTION
� 4)
CU. FT. = [AREA TOP + (4*AR��A MIDS"HCT~ ARE4 BOTTOM3
* -DEPTH/6
82716.0 270816'0
54150.0
1.5
Tot�al 'Des igneg Vozumva--"labie U. FT.

5' TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
345,0 250.0 36250.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
'
TOTAL DA 86250.0 square feet
Design temporary storage period to be 180 days.
5A. volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 396900 Ibs. ALW/135 !be. ALW * 1.37 gal/day 180 days
Volume = 725004 gals. or 96925.7 cubic feet
5B. Volume of wash water
Th1s is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/nay * 180 days s±orage/7.48 gallons
per CF
Volume = 0.0 cubic feat
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 50312.5 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 50312.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 96926 cubic feet
58. 0 cubic feet
50. 50313 cubic feet
5D. 50313 cubic feet
.
TOTAL 197551 cubic feet
6. SUMMARY
Temporary storage 180 days
Rainfall in excess of evaporation===========> 7.0 inches
25 year - 24 hour rainfall==================> 7.0 inches
Freeboard==============================1.0 feet
Side slopes=====3.0 : 1
Inside top length===========================> 345.0 feet
Inside top width============================> 250.0 feet
Top of dike 50.0'feet
Bottom of lagoon 40.0 feet
Total required volume=======================> 594451 cu. ft.
Actual design volume========================> 611523 cu. ft. *~~
Seasonal high watertable elevation (SHWT)===> 46.0 feet
Stop pumping 46.3 feet *
Must be > or = to the SHWT elev.=======­> 46.0 feet
Must be > or = to min. req. treatment el.=> 46.0 feet
Required minimum treatment volume====> 96900 cu. ft ^
Volume at stop pumping elevetion============> 400704 cm. ft,
Start pumping elev.=========================> 4Q.3 feet *
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume loss 25 yr.- 24 hr. reinfall==> 561211 cu. ft.
Volume at start pumping elevation===========> 554475 cu. ft.
Required volume to be pumped================> 147238 cu. ft. �
Actual volume planned to be pumped==========> 153771 cu. ft. *
Min. thickness of soil liner when required==> 1.5 feet
DESISNED BY:.�.��6�^�� �- APPROVED BY: Ontr A kit
DATE: �//� �� �
`'/ ^ / / /
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTSo

.
SEEDIMG SPECIFICATIONS
AREA TO 8E SEEDED,2.5
USE T�E SEE� MIXTURE INDICATB} AS FOLLOWS:
0.0 LBS. FESCUE GRASS AT 6O LBS./ACRE
(BEST SUIT£D ON CLAYEY OR WET SOIL C3NDITIONS)
�EEDIF -jG DATES: SEPTEMBER 1 TO NOVEy1BER 30
FEGRUARY 1 TO MARCH 30
0.0 LBS. RYE GRAIN AT 30 LBS./ACR2 (MURSERY FOR FESCUE)
0.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./PS. CRE
(SEE FOOTMOTE NO. 1)
SEE�ING DATES: MARCH.15 TO �UNE 15
2().0 LGS. HULLE� COHM3N �ERMUDA GRASS AT 8 LBS./ACRE
(SUITE� FQR MOST SOIL CONDITI[)NG)
SEEDING DATES: A'�IL 1 TO JU-Y 31
0.0 LBS. UNHU�-LED COMMON BER�1UDA GRASS AT 10 L�S./ACRE
GEEDING DATES: �ANUARY 1 TO MARCH 30
0.0 LBS. RYE GRA3S AT 40 LDS./ACRE (TEMPORARY VEGETATION)
SEEDING DATE3: DECEMBER 1 TO MARCH 30
APPLY THE FOLLOk�ING:
250�.0 LB�. OP 10-�0-10 FERTILTZER (1000 LBS./AC�E)
5.0 TQNS OF DOLOMITIC LIME (2 TON --/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO �EEDING. SHAPE
ALL DISTURB�D A�EA 7MwFnr�T,�v u�rPn �u�rW wnorm� rC rnM�/crr"
"'IF -PLY LIME AND FER�ILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTTPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACQL� BAHIAGRASS I3 SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRAS5. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF ��MMON BERMUDA BE INCLUDE� TO PROVIDE CUVER
UNTIL BAHIAGRASS IS ESTABLISHED.

DESTGN SUMMARY
DAME: G & R Farms
COUNTY: Sampaon
TYPE OPERATION: Feed -Finish
TOTAL
REQUIRED VOLUME
445420
CU
FT
TOTAL
DESIGN VOLUME AVAILABLE
460960
CU
FT
E=_T.T.MATED:
OF LA{ OON1 L` i_:VAT ONk CU `s r)::f
VOLUME OF LAGOON EXCAVATION 0 CU YDS
FOR LINER -_-_----
TOTAL EXCAVATION 12176 CU YDS
VOLUME
OF
PAD FILL
7604
CU
YDS
VOLUME
OF
DAM
2648
CU
YDS
TOTAL FILL 10252 CU YDS
CUT -FILL RATIO
WHERE SM MATERIAL IS ENCOUNTERED OVEREXCAVATE 1.5 FEET
AND BACKFILL WITH COMPACTED SC MATERIAL
TOP OF DAM
ELEVATION
53.0
START PUMPING
ELEVATION
50_7
STOP PUMPING
ELEVATION
48.3
BOTTOM
ELEVATION
42.0
BEGIN PAD
ELEVATION
53.0
END PAD
ELEVATION
53.4

LAGOON DESIGN
atr.=rt:G & R Farrrt County: `aarorlsor
Date
Oaf` 11197
Gene West
the site evaluation been r~6mpleted
& approved:
YES
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
r 1417
lbs. =
0
lbs
Fe) sows (farrows to feeder)
522
lbs.
0
lbs
1470 read (finishing only)
r 1.35
1_bs.
1984,50
1[-s
J r.tUws F'.•:r-r,rlwr to wear))
{. 4.3�,
lbs. _=
V
I
€4�t fIr•Er1 !-i°1Ean r:p f'-eJr.r")
lbs.
-
-...
__-.,... .__0�_.
...._......---_
i"i li'•J T i is 11*i 1=C1i.�:i_ 11;�L� TREnTi1ENT V01--Ulf- 01F
L_HGODN
Volume
= 198450 cubic ft (includes
0 cu. ft.
add. treat. vol. )
ISTORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 49980, 13 cubic feet
TOTAL DESIGNED VOLUME
Inside tap length (feet) ---------------------
Inside top width (feet) ----------------------
TOP of dike elevation (feet) -------------------------
Bottom of lagoon elevation (feet)--
Freeboard ( feet) -----------------------------
Emergency spillway depth of flow(feet)-------
Side slopes (inside lagoon) ----------------..._.....
Total design volume rasing pr,ismoidal formula
SS/END1 SS/ENDS SS/SIDE1 SS/SIDES LENGTH
3.0 3.0 3.0 321. 0 244.0
AREA OF
TOR
LENGTH
* WIDTH =
244.0
244.0
AREA OF
BOTTOM
LENGTH
* WIDTH =
184.0
184.0
AREA OF MIDSECTION
LENGTH
* WIDTH * 4
214.0
214.0
250.0
230.0
53.00
42.00
1.00
0.00
3.0 . 1
WIDTH DEPTH
244. 0 1 rZI. 00
59536 (AREA OF TOP)
.33856 (AREA OF BOTTOM)
183184 (AREA OF MIDSECTION * 4)
CU. FT. = CAREA TOP -+- (4*AREA MIDSECTION) + AREA BOTTOM] DEPTH/6
59536 183184 33856 1.67
Total Designed Volume Available = 460960 CU. FT.
0

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon {top of dike)
( Length Widtf'i i + Gur-f<<ce area of conner"t ing waste facility
Pik
TOTAL DA Cam2'500. 173 square feet
Design temporary storage period to be 180 days.
Volume of waste produced
Feces & urine production in gal. /day per 135 lb. ALW 1.37
Volume = 198450 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 362502 gals. or 46462.8 oubic feet
Volume of excess water
Volume = 1330.5 gallons./day 180 days storage/7.48 gallons
per CF
Volume = 32016.6 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days evaporation - 13.3 inches
180 days rainfall — 21.7 inches
Volume = 21.7 in * DA 1 12 in. per ft. = 113021 cubic feet runoff
Volume = 13.3 in * lagoon DR/12 in./ft = 69427 cubic feet evap.
Volume = 43594 cubic feet

Voli_ime of 2; year E4 hour, seer m
VolUme of "Heavy Rain" 7.0 in.
Volume = 14.0 inches 1 12
Volume = 72917 cubic feet
Additional volume as follows.
7.0 its.
inches per foes * DA
-7 01-4�1_ RECsU I RED TI-111='i�l?FIR CITORA7E
Lj
r i
1- C_ I- f' (' t
51E,. ci_!bi feet
TOTAL 1'9 '990 cubic feet
SUMMARY
Temporary storage
Rainfall during wettest period of stor~age===}
Evaporation during stor--age period===========y
2S year - 24 hour
Heavy
Side
Inside top
Inside top
Top of dike elevation=;===,===================>
Bottom of lagoon elevation==================>
Tap of sludge
Total required
Actual design volume========= =============)
Seasonal high watertable elevation (SHWT)===>
Stop pumping
Must be } or = to the SHWT
Must be ) or = to min. req. treatment e l . =)
Min. Required treatment
Volume at step pumping elevation============)
Start pumping
Must be at bottom of F. B. & 25 yr. rainfall
Act, vol. less 25 yr. and heavy rainfall====)
Volume at start pumping elevation===========)
Required volume to be pumped=====--===== ==)
Actual volume planned to be pumped==========)
Min. thickness of soil liner when required==>
DESIGNED BY: Jd. iu.-
P,t,,rn{,r.�c. e�zu•,.
DATE: g1l r) g7
180 days
1-1.7 inches
13.3 inches
7.0 inches
7.0 inches
1.00 feet
3.0 . 1
250.0 feet
250.0 feet
53. 00 feet
42.00 feet
43.45 feet
445420 cu. ft-.
460960 cLt. ft.
46.70 feet
48.30 feet a�
46.70 feet
48.00 feet
196450 cu. ft.
208662 cu. ft.
50.70 feet
& heavy rain
388043 cu. f t .
.386011 cu. ft.
124073 cu. ft.
125900 cu. ft. �
1.5 feet
APPROVED BY: Itl —V'
DATE: 41zal98
n

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian,
Primary Secondary Routine Mortality
❑ ❑ Burial three feet beneath the surface of the ground. within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
LEM
;■ ■
u
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under.G.S.106-168.7.
Complete incineration according to 02 NCAC 52C .0102_
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State"Veterinarian, would make possible.
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The N.CDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
JJW.4. 4)140
Signature I Farm Owner/Manager
Date
Signature of Technical Specialist Date