HomeMy WebLinkAbout510013_Permit Renewal Application 2019_20190410State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee
1. Farm Number: 51-0013 Certificate Of Coverage Number: AWS510013
2. Facility Name: Mark & Pam Denning Farm 1-6
3. Landowner's Name (same as on the Waste Management Plan): Mark Denning
4. Landowner's Mailing Address: 2022 Benson Hardee Rd
City: Benson State: NC Zip: 27504-9658
Telephone Number: 919-291-7647 Ext. E-mail: skidmarkf677Qvahoo.com
5. Facility's Physical Address: 2395 Benson -Hardee Rd
City: Benson State: NC Zip: 27504
6. County where Facility is located: Johnston
7. Farm Manager's Name (if different from Landowner): Mark Denning
8. Farm Manager's telephone number (include area code): 919- 94 863.3 Ext.. qJ 9 _a q%'76,92
9. Integrator's Name (if there is not an Integrator, write "None"): Prestage Farms Inc
10. Operator Name (OIC): Hunter Mark Dennine Phone No.: 919-291-7647 OIC #: 985111
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Other 5,400
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poulin
Gilts Other Non Laying Pullet
Other Layers
13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
i 415.
C jay
871,134.00
117,612.00
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sinned b■ the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic YieldExpectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewal@ncdenr.gov
13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
I4'9.5-
fay
871,134.00
117,612.00
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP) sittned bt the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewal@ncdenr.gov
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: nli I-Zfe1r 4,/4 De i, : 04✓at ee-
Date: 3-„ze -/ F
Signature:
Name: Parr' 'Cie' j . lJev ✓l _i
Title: Cam-)
Signature- Date: 3 -
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: (919) 707-9100
E-mail: 2019PermitRenewal@ncdenr.gov
FORM: RENEWAL -STATE GENERAL 02/2019
ROY COOPER
Governor
MICHAEL S. REGAN
secretary
LINDA CULPEPPER
Director
NORTH CAROLINA
Environmental Quality
February 27, 2019
Mark Denning
Mark & Pam Denning Farm 1-6
2022 Benson Hardee Rd
Benson, NC 27504-9658
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Pennittee:
APR 01 2019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hens://deq,nc.gov/about/divisions/water-resources/water-aualit% -regional-o erations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: (919) 707-9100
In order to assure your continued coverage under the State Non -Discharge General Permits. vou must submit an application for
permit coverage to the Division. Enclosed ' ou will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned b4 April 3. 2019.
Please note that you must include one 1) cool of the Certified Animal Waste Management Plan (CAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Raleigh Regional Office, Water Quality Regional Operations Section
Johnston County Soil and Water Conservation District
AFOG Section Central Files - AWS510013
Prestage Farms Inc
�1 harth Car: -r a epartment of Environmental 1Zt ality I Division of Water Resources
512 N. Salsbury St. 11636 Mail Ser race Center I Raleigr, North Carolina 27699-1636
31.9.7079000
ROY COOPER
Governer
MICHAEL S. REGAN
Set -Mary
LINDA CULPEPPER
0lrector
NORTH CAROLINA
Environmental Quality
February 27, 2019
Mark Denning
Mark & Pam Denning Farm 1-6
2022 Benson Hardee Rd
Benson, NC 27504-9658
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
APR 0' 12019
,
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hrtps://deq.nc.gov/about/divisions/water-resources/water-t.tuality-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: (919) 707-9100
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application for
permit coverage to the Division. Enclosed you will fmd a "Request for Certificate of Coverage Facilio, Currentb, Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by Auril 3, 2019.
Please note that you must include one I1I copy of the Certified Animal Waste Management Plan ICAWMPY with the
completed and sinned application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Raleigh Regional Office, Water Quality Regional Operations Section
Johnston County Soil and Water Conservation District
AFOG Section Central Files - AWS510013
Prestage Farms Inc
� L A�rth Car Department of Environmental Quality I Division of Water Resources
r}' 512 N. Salisbury St. 11636 Mail Service Center I Raleigh, North Car is 27699-1636
— 919.70?.9000
Waste Utilization Plan
Producer:
Name of Farm:
Location:
Phone:
Type of Operation:
Number of Animal:
Storage Structure:
Method of Application:
Mark Denning
Mark & Pam Denning Farm
2022 Benson -Hardee Rd.
Benson NG 27504
919-894-83T6
Feed -Finish
4410
Anaerobic Lagoon
Irrigation
Amount of waste produced per year:
Amount of plant available N (PAN): produced/year:
County: Johnston
8379 ton/year
10143 lbs./year
APR 0 I
ii
0
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils , when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop, or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and -reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which
Mark & Pam Denning Farm
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Table 1
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
1388
11
VarinaA
CB -HAY
5.5
50
5.90
1623
MAR-SEP
_
275
1388
11
VarinaA
SG -OS
1
50
5.90
295
OCT-MAR
50
1388
12
VarinaA
CB -HAY
5.5
50
4.30
1183
MAR-SEP
275
1388
12
VarinaA
SG -OS
1
50
4.30
215
OCT-MAR
50
1388
13
VarinaA
CB -HAY
5.5
50
2.00
550
MAR-SEP
275
1388
13
VarinaA
SG -OS
1
50
2.00
100
OCT-MAR
50
1388
24
VarinaA
Millet(Hay)
5.1
49.4
4.00
1008
MAR15-AUG
252
1388
24
VarinaA
Oats
85
1.13
4.00
384
SEP-APR15
96
1388
25
VarinaA
Millet(Hay)
5.1
49.4
4.30
1084
MAR15-AUG
252
1388
25
VarinaA
Oats
85
1.13
4.30
413
SEP-APR15
96
1388
26
L, VarinaA
Millet(Hayt
5.1
49.4
1.70
MAR15-AUG
252
1388
26
VarinaA
Oats
85
1.13
1.70
_428
163
SEP-APR15
96
1388
35
VarinaB
Millet(Hay)
4.9
49.4
2.00
484
MAR15-AUG
_
242
1388
35
VarinaB
Oats
82
1.13
2.00
186
SEP-APR15
93
1388
36
VarinaB
Millet(Hay)
4.9
49.4
1.40
339
MAR15-AUG
242
1388
36
VarinaB
Oats
82
1.13
1.40
130
SEP-APR15
93
1388
37
VarinaB
Millet(Hay)
4.9
49.4
2.00
484
MAR15-AUG
242
1388
37
VarinaB
Oats
82
1.13
2.00
186
SEP-APR15
93
Total 27.60
Available Nitrogen
Surplus or deficit
Table 2 Honeywagon to be used on these folds
9255 lbs.
10143 lbs.
888 lbs.
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
12257
1
UcheeB
Millet(Hay)
4.4
53.9
1.20
284
MAR15-AUG
237
12257
1
UcheeB
Oats
59
1.27
1.20
90
SEP-APR15
75
12257
2
VarinaB _,
Millet(Hay)
4.9
49.4
1.92
465
MAR15-AUG
242
12257
2
VarinaB
Oats
82
1.13
1.92
179
SEP-APR15
93
Total
Table 1
Table 2
Total
Available Nitrogen
Surplus or deficit
3.12
27.60
3.12
30.72
1018 lbs.
9255 lbs.
1018 lbs.
10273 lbs.
10143 lbs.
-130 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner
Mark & Pam Denning Farm Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October . Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates. The
sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients or
other elements. Your production facility will produce approximately 1588 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 7938 lbs. of PAN to utilize. Assuming you
apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 26
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 64
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity
Mark & Pam Denning Farm Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is instdlled to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Table 1
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
1388
11
VarinaA
CB -HAY
0.5
0.96
1388
11
VarinaA
SG -OS
0.5
0.96
1388
12
VarinaA
CB -HAY
0.5
0.96
1388
12
VarinaA
SG -OS
0.5
0.96
1388
13
VarinaA
CB -HAY
0.5
0.96
1388
13
VarinaA
SG -OS
0.5
0.96
1388
24
VarinaA
Millet(Hay)
0.5
0.96
1388
24
VarinaA
Oats
0.5
0.96
1388
25
VarinaA
Millet(Hay)
0.5
0.96
1388
25
VarinaA
Oats
0.5
0.96
1388
26
VarinaA
Millet(Hay)
0.5
0.96
1388
26
VarinaA
Oats
_
0.5
0.96
1388
35
VarinaB
Millet(Hay)
0.5
0.96
1388 _
35 _
VarinaB
Oats
0.5
0.96
1388
36
VarinaB
Millet(Hay)
0.5
0.96
1388
36
VarinaB
Oats
0.5
0.96
1388
37
VarinaB
Millet(Hay)
0.5
0.96
1388
37
VarinaB
Oats
0.5
0.96
Table 2 Honeywagon to be used on these feld
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
12257
1
UcheeB
Millet(Hay)
0.5
0.96
12257
1
UcheeB
Oats
0.5
0.96
12257
2
VarinaB
Millet(Hay)
0.5
0.96
12257
2
VarinaB
Oats
0.5
0.96
p5
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
APR 012019
1.
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste , he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding Tess than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
PAb4-4
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
Mark & Pam Denning Farm Page 67
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION
Operator will use a honey wagon on Tract 12257, field(s) 1 & 2 when needed.
Page g
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Mark & Pam Denning Farm
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and maintenance procedures
established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality (NCDWQ)
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste from
this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour storm.
The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Mark Denning
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Phone: 910-596-5749
Date: S"
Date:
Signature: d.kLam..... C L4 LSL,. Date: fJV+fa•
Johnston County
Geographic Information Services
Pil 5 U73 Smishr11.1. Mu Omr/k. 77,117 0:1.4 d
PARNOM.-.....: CI Go703a
NCP1N. • 1 820-1 7—.3244
IdAPSFEET • 1 820
OWNERINAUE. • HARDIS01.1, LESLIE: S TEW AR 7
A.DDR1 •
ADDR2 ...... 2395 BENSON HARDEE RD
ADDR3 •
CITY 9ENSON
STATE • NC
ZIP.... ....... : 27504000n
BCC*" 466
PAGE • 542
CALC ACREAGE..: 1 23 82
DEED ACREAGE..: 104 480000
REVAL. IF • 4 4 0,57()
MARKET • 51 987n
LASTMOD • 1 4 .NCA'.- 9 7
information ia valid
state plane conrdinutes (NA027:
X—coordinate...: 21 21 344.25
Y—coordinate...: 60724 9.81
---
township • Bonner
e.t I N/A
city limits • N/A
soil type • VrA
zip coda • 27504
census tract...: 4.1 4
fire diatrict: Banner
rescue district: benson
power district.: CPL—Di It /
water district.: N/A
Sr.c.cle: 1 ir tc:11 rtst
Ootor April 1 ,908
Discla inter:
, 1, ,i t on Count1c II .; : • -
Operator:Stuart Hardison County: Johnston
Date: 05/31/94
Distance to nearest residence (other than owner): 0.0 feet
1. AVERAGE LIVE WEIGHT (ALW)
' 0 sows (farrow to finish) x 1417 lbs.
0 sows (farrow to feeder) x 522 lbs.
4410 head (finishing only) x 135 lbs.
0 sows (farrow to wean) x 433 lbs.
0 head (wean to feeder) x 30 lbs.
Describe other :
Total Average Live Weight =
0 lbs
0 lbs
595350 lbs
0 lbs
0 lbs
0
595350 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 595350 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/1b, ALW = 1 CF/lb. ALW
Volume = 595350 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION Sludge Accumulation Not Computed At
Owners Request Remove Sludge
Volume = 0,0 cubic feet As Needed
4. TOTAL DESIGNED VOLUME
Inside top length (feet)
Inside top width (feet)
Top of dike elevation (feet)
Bottom of lagoon elevation (feet)
Freeboard (feet)
Side slopes (inside lagoon)
500.0
210.0
93.0
81.0
1.0
3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 ' 494,0 204.0 11.0
AREA OF TOP
LENGTH * WIDTH
494.0 204.0
AREA OF BOTTOM
LENGTH * WIDTH =
428.0 138.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
461,0 171.0
100776 (AREA OF TOP)
59064 (AREA OF BOTTOM)
315324 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] DEPTH/6
100776.0 315324.0 59064.0 1.8
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
500.0 210.0 105000.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 105000.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 ib. ALW 1.37
Volume = 595350 lbs. AL'J/135 lbs,'ALW * 1.37 gal/day 180 days
Volume = 10875,06 gals, or 145388.5 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
'per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume = 7.0 in * DA / 12 inches per foot
Volume = 61250.0 cubic feet
7.0 inches
7. DESIGNED BY: Lanier & Houston
ND
SPE
PRACTICE MEETS STANDARD
C-RTIFIFATION MA
FI;.TIONS,
5D. Volume of 25 year - 24 hour storm
Volume =
7.0 inches / 12 inches per foot * DA
Volume = 61250.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 145389 cubic feet
5B. 0 cubic feet
5C. 61250 cubic feet
5D, 61250 cubic feet
TOTAL 267889 cubic feet
6. SUMMARY
Temporary storage period > 180 days
Rainfall in excess of evaporation > 7.0 inches
25 year - 24 hour rainfall > 7.0 inches
Freeboard > 1.0 feet
Side slopes > 3.0 : 1
Inside top length > 500.0 feet
Inside top width > 210.0 feet
Top of dike elevation > 93.0 feet
Bottom of lagoon elevation > 81,0 feet
Total required volume > 8632.39 cu. ft. � /
Actual design volume > 87.11.34 cu. ft, 1/ VQleuy
Seasonal high watertable elevation (SHWT)===>83.7 07.5 feet`.).,... A"f-4(
Stop pumping elev. > 89.1 feet *
Must be > or = to the SHWT elev. >83.7 87. ✓ feet anE"o.,—
Must be > or =.to min. req. treatment el.=> 87.0 feet
Required minimum treatment volume > 595350 cu. ft.
Volume at stop pumping elevation. > 596201 cu. ft.
Start pumping elev. - > 91.3 feet *
•Must.be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>. 809884 cu. ft.
Volume at start pumping elevation > 801613 cu. ft.f
Required volume to be pumped > 206639 cu. ft, *
Actual volume planned to•be.pumped__-'• > 205411 cu. ft. *
Min. thickness of soil liner when required==> 1.8 feet
ECI D BY: e a
DATE : 5�S f � DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:
fflfIii
ACOON SUI•LMARY 'IYi'iC,;L CROSS-SrCTIO:.
Settled top of darn: 93.00
�Slapc i
3
Top Width
lZ'
Natural ground e1 ev.
Depend_ or,
See. S{hee
-\
\\cut off tee;
eqt_<1 pn Sri t _(—
/ JCZ -- au' da-Tic:i ?repara.
Scarf land applicacion
elev. 9/3
Bent
support--
j146p<
3
bot tom e1 `v. 8100
Sedin,fE/
93, 2 0
Construct top of
Fill Yardage: See 7:70,3
Sh eef
l
3
--L-- Depth detc-r,nind (.y
SCS on si tc _ -
Scop land apo l ic:scion--}
elev. S9o0
Temporary Volume
Treatmenc Volume
Top of sludge_ elev. iv/y
Lagoon size: Length5'
Width 2/40
to �
3
Cu. Yds. excavated
AEI`'GH MARK DI="SCR I P ( I i)t1:
•- Ot0'� 7."d1)% /1�2, .�•i it i y 1 ft)r iQ��/.*le %i'LL� o
Cl (i'v<<t i an : ____Z±V,ie., iI
GENERAL I NFORriAT I CN
JOB CLASS:
HAZARD CLASS:
ANIMAL TYPE b NUh113EF - �ata�/IWO
KIND OF OPERATION: reel ou-t
NOTE: If construction is not
started within one year, this
elan is not valid until re -
:valuation of flood plain for
safety hazard is made.
k
LAGOON FOR ANIMAL WASTE
(SINGLE STAGE)
_511 ct a I
ri N4 ref / O ri
,fir Jiiis7j _'
,Ye 4-& C —
EARN
COUNTY
STATE
U. S. DEPARTl ENT OF AGRICULTUF
SOIL CONSERVATION SERVICE
DESIGNED) BY:.„,/,,a.n:er
TITLE: ��. l l
DATE: - g - F
tl
C7:7i'7T 1 /'1 r.' 7
OPERATION AND T T T TC PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for thP _'•armed
fluid level (permanent and temporary storage) to be reached m=_ :,_ —�
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists. of 180 days _..rage for.
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storsge
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and thisis usually the outlet invert of pipe(s) from
\.'uildiflg(s) , T_ the outlet .pipe i n t _ nstalled at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
__ stop pumping to maintain lagoon treatment depth.
rumping car. be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, cr i , -.leaching.
crop, and equipment in order to applywaste aste without
runoff 1 ea��hing.,
-ppl i cati cn of waste water is recognized as an acceptable
method of disposal_. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried _.
1. Tt is strongly recommended that the treatment lagoon be pre-
c11 a'i geL,' tv 1/2"� _ its capacity to Drevent e __:.ssive odors during
start-up. Pre -charging reduces the concentration of the initial
waste en-e_i-rig the lagoon thereby reducing odors. Solids should he
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling
_. The attached waste utilization plan shall be followed. This
plan recoimnends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 91.3 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 89.1 . temporary
1 !I - .------ - 206639 cubic feet or
l.45656Lgallorls.
SHEET OF
4. The recommended maximum amount to apply per C_ irrigation is
one (1) inch and the — ; commence ;a._imum = pi , cat _ r nate is 0:
inch per- hour. Refer to the waste utilization plan for further l-
5. Keep vegetation on the y-s�—ik-..e_tand are
as adjacent to the
lagoon mewed annually. vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded arias
-_ =as damaged by rodents and
7. �,
All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. :Waste shall be applied in a
manner not to reach other - •r ?nd public s
r'_:'-.
_ r. tS' right-of-ways.
9. The Clean an Water Act of _977 _ j.. _ 1�. _ the
�- � -�.._ �_ its discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural .l Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.
D ;yeti' 0O,Cg4. U.‘14,rev'1,4 1 .1 1 I
Nee'.cts .60 :f4x c4e'04! I •.,3-
- . ,
, . .
25',4 FS' I
Ir-f '3
74
1 I 1 --I 1- •1 . • 1 I • ; , •I ' : .
• 1
, ••, 1 • I•
I .!
t .
I P - • ' I I - .I-- - - ; , I •
II
• . i ' ' i
r)cff,.•-
--
-2-r-i. 'i --i--+-14:11i 11 , — --24- 11--- -------' ' ij---..—i---.-. .
.-P-1*-- ..r-.. --
i. . , ..
- ..--. -•
. : I i I • • t I I.' I • .- 1 l• I . 1-
,
.. ... t. ; ., . . .
iNacei '14.1/41; •
F-t
431
92.'14
3 400
Lit
9S .0
F SO
0 i- 71rf\i"
o0
• • •-• •
• !
/
I •
!
#1!
• ti I . !
• ! ! • •
Z.5.! 0 • ; fiottoIfti e ekk;
8212. : t i 4 i . ...I . . .-
.
I • , . . I : I i
.1._ ,__._ i i i ..• I
- I •
k91. D ctS -`1( 4
'17
Oikec114-, 5
4<-74
—
99 Z
< ioi .9 - • 0•02.1
E.
3
-Ng
At-C1
5 +3 DI
. „
—
343
P1.7
97 ,g
+lo
7 0
I.
t.D
1+,0
77.9, PI, /k./
Pin e Affnie /V /42
P sril A °too
let4
145,
95"
+op
4r in Ora
D L ;•
-7----
_,
. +0.0 . .. III -OD 5 3.0I0I1_., . .
• ,
oy,.,..+0 ..cii.v trt......i.tio.i-.c.t. ,....a_tilit,*•:__fril._,..i4a_ Ait.i...: — . ,_ . ! ..L_L__...,. .. 1 _1_1_1. !
• ! 1 . . ! , . . .
, uppfr
rE•18v 99.4I
' S'D
Flek- K.
Ear-ON.s.tk
: 1-3500',1— 199 2
Not — 293 ydi
T.4.01 —
90 Fi 11 : 00<e — 10V19
No( — 192.1 v6,13‹
To+,21 — 16511 yci3LY
'Cu4 : Fill —
•
•
r • • I .-
40.ve.r Pa) ' I
• • .
•: 1-6se .
,
K,
.: • !
• '
I 6
--;
6. 6. 6 • 6 I I 4
ej.n • 1.
gin 1 177----riPI. Elev, 1.5i•-• •
5.'4, es -Imp 16-IN.
! — \
p,..o 7e ti- lioe),- 404,4hi; kV I lit ), r . ' 1 , , ,1; . . I
lig/ CLIO,/ !Illi,er' !del, poc:11,241 in 9 ' 'I if-1-s
/ %/1))2., ,v7,-/ Oct•te ,I- !
4f$A r ,./0e-Y , ..
. : 1,,,s4..,111 c tc rld,,iied it'A‘sre; , wea ,S41
—4, —, '-',-- ---1—rvit•-R, et: 1 ;f4:-
1 ' • ; ! ,.S1,e s' '.1' -V; si .fi! ' riry,4i0.,
1 , ;
, f
i — : , ' -11), fi4er i',11:4-41L-1-.1‘0,, re'coi'ee,,,e435
- CAUTION - , • ;
&fore Starting Exccrvation .
. ------'-:iii--1
Check for Undergi&t:iiici Utilities ' .- , . 7-‘,. - .
•
; ke.: clev. 93,0'
;!! •
; !
I ,
ii*/[54
. . ,
.. ; • i -I - -• i - •I••• • • '. !- I • I •I •!•• -•!-••
, I, --- •t .- --1 1 - • • i , 1 1 1.-. 1•• •i i• 1--.1
t!-
j : 6
, •
. 1.1
. 1 !
i
• !!
JOHNSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMENT SERVICES (EMS)
SOIL & WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
COOPERATIVE EXTENSION SERVICE (CES)
"l
ire¢
919-571-4706-
919-989-5050
919-934-7156
919-934-7156
919-989-5380
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office, at 919-571-4700, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME , FACILITY
NUMBER, TELEPHONE NUMBER, THE DETAILS OF TE INCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 919-989-5050.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 919-989-5381 and Cooperative Extension
Service at 919-989-5380 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of the problem to minimize off -
site damage.
a. Contractors Name: Robezf t .)/a5or1 MASS
b. Contractors Address:
c. Contractors Phone: 9/ b -$z_-f 75o (—
Page 2
6. Contact the technical specialist who certified the lagoon.
a. Name: C. Q.ENN Ct. t F j
b. Phone: 9.so-592- `fTU. x 2,49
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3
Insect Control Checklist for. Animal Operations
Source Cause IiMI's to Control Insects` - Site Specific Practices
Flush Gutters • Accumulation of solids
Lagoons and Pits • Crusted Solids
Liquid Systems
fq•lush system is designed and operated
sufficiently to remove accumulated solids from 7 / -p
Antlers as designed.
Li Remove bridging of accumulated solids at
Sl• charge,
AA7
Excessive Vegetative • Decaying vegetation
l iruwth
Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids' lei a depth of no more than 6 -
8 inches over more than 30% of,stirface. •
Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
m0cu I h v-6a et
Fccdcc • Feed Spillage
Dry Systems: •
Feed Storage • Accumulations of feed residues
El l)esign ,operate and maintain feed systems (e.g.,
'bunkers and troughs) to minimize the
accumulation of decaying wastage.
•111 Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
)tiring winter).
1_ Iteduce-moisture accumulation within and
around iinine liate perimeter of Iced storage t'ih.AA✓ 115 /Yee
nrcas,by:insuruig drainage away Boni site
and/or:providiiigadequate containment (c.g.,
covered bin for brewer's grain and siiuilar high
moisture grain products).
CI inspect for tuid remove or break up accumulated
Solids in filter strips•arouncl Iccd•storage as
needed; '
Ahll(: - November 1 I, 1996, Page
:'�Illlll I.
Animal I10.1y Idolfact::,
Him'
Swine farm Waste Management Odor Control Checklist
Ca115e
• Saville hrtulurtian
IMPS In 1%11111wizc Odor
vegetative or wooded buffers; G o o��
f ccoinmended best management practices; 6--0 0 V
fond judgment and common sense
• Ditty manure -covered animals
Icy floors
• Wet ntaIrlre-covered floors
Ntaimit: colLL&.Iitln pits • Urine;
• Pallid microbial decomposition
Vcmul.tlttnl tans • Volatile gases;
1)11si
In,luul • I —
I-lu:.lt
ftY.lued floors;
(Il�aterers located over slotted floors;
eders at high end ill -solid floors;
Scrape manure buildup from floors;
fl tlndt:rllnor ventilation for drying /101
iKrequent manure removal by (lush, pit recharge,
or scrape;
Cl 11ndcrllonr ventilation �/A
1f1I rcti maintenance;
14' I:ftlLlent air movement
, 1ThWasbdown between groups of animals;
fl reed additives;
11 Feeder covers;
fIY1ecd delivery Ilotvnspnllt extenders to feeder
cnvcrs
• Agitation (if recycled lagoon
litluid %vhilt: tanks are filling
f1
Ind' ,tll, • Agitation during wastewater
conveyance
It. tidal.,. It,tltll•, • Agitation nfrccycled Iagimn
liquid white Mils are filling
Flush lank covers; Nr/1
Extend 1111 lines to near bottom of tanks with j1,.//4
Site Specific Practices
A v e
's
anti -siphon vents
f�l llnderflnnr flush with underfloor ventilation
,V/4
/aS47-4ice 4'eeX
fl I:xlcm, recharge Iiuta In near bottom ulpits
%villa iinll siphon vents
I.III I ttlun:, • Agitation dllrillg Slllllh tank
tilling; and tlrilw(own
t�lll�kt&: tllalll t uIICt Ilttll • Agitation dining wasletvitt:r
111 Illllt fluff
conveyance
n Sump tank covers
11 Box covers
A//4
Pi- Re ehil,
"/4
At.tt I(' I I.t' i ulbta I I, I't'nn, I'.Igt: 1
cc Cause
Fllil 111 illill1111111C!. 11 • Aguainni during %viisie‘vater
1.q;01111 conveyance
I arum' !do
Isigaimo 51'11111.1c'
1111111C:i
Lill'. Ail
.14
• Volatile gas emissions;
• Biological mix in;
• Agitation
• High pressure agitation;
• \Vim! drift
IIMPS illIvTh suiizc Odor
fl Extend dischargei point of pipes underneath
lagoon liquid level
14-1Croper lagoon liquid capacity;
1.1"-6-orrect lagoon starinp procedures;
14---cliniminn surface area -to -volume rail();
fq<finiminn agitation when pinnping;
fl Mechanical aeration; A//14
n Proven biological additives 11/1)1
Site Specific Practices
A/R e 5 De yi7
ffKlirigate on dry days milli' little or no wind;
recomnientled operating pressure;
ftl---1-1:4 intake near lagoonliquid surface;
fl Pump frail second-siage lagoon
• Nina' microbial decomposiiion; ri liounin or midlevel loading;
• Mixing while
• Agitation ‘vhen emptying
!AL:111111i; Ilir...111 • Pill Oil' inianbial decomposiiitin;
• 1 i iii1 whilelilting;
• Agitation vlien emptying
khoole, 1,111dge • A giudion when spreading;
oloich
fl Tani: covers;
fl Basin surface mats of solids;
Cl proven biological inli Or oxidants
11 Extend drainpipe aide's underneath
level;
n Iteniove settled solids regularly
n Sal injection of slurry/sludges;
n WaSli residual manure r111111 spreader alter use.;
fl Proven biological additives or oxidants
Inca:L:1.1d manioc, • Volatile gas emissions while
dint 5. tit 1.111,1r.4: ,)n I (hying
SIII lilt
• Volatile gas emissions
soil injection or sitirty/sintigcs
n Soil incorporatinn.‘vithin 418 hrs.;
n •. .
Spread in thin. iinifain layers for rapid drying;
11 Pri)ven biological addiiives oroxidanis
• Calcass decomposition PrOper disposition of carcasses .... ,
De A el 30)('
. Cart...ass tIccin4iiin4iiion 1114()unpick: covering iils cnicies in burial piis;
•.. n Proper lbetilion/construelion of disposal pits A.pit
/v/i
:\ t. 1411• min:i I. 1'ml'. Paitc
pi (4
Suut t'c
`i1a11:1ing 1Y �t1.a Jl Ulln:l
I.,: tlu1. ,
Itl:uuut: U it:1, until
1111111it: It,:ul:, iit ii1 1,11111
tl Ll:eS]
i dull Itll lit I I11ltil I lti1111111 :
Cause
• Improper drainage;
Alit:iuhial dt:t:unlpnsitiuit ill
ttigilit lc matter
HMI's in Minimize Odor
R-ade and landscape such that wafer drains
atwiiy from lilcilities
• fool ly nlailtlainetl access roads
1111- 1'i nt access road maintenance
66 61
Site Specific Practices
Swim hlanutt: hlanagt:nlcnl ; 0211f Rule/EMI'. Packet
Available From :
Swine 111u(lut:dun Daunt I1ttenlial Odor Sources and Remedies ; Iil1Al: Fact Sheet
S‘v nue Facility Manure Management: Pit Recharge. - Lagoon Treatment ; IiIIAIs 128-88
Swint: I'Iutluction Facility Miuuure Management: Underfloor Flush - Lagoon Treatment ; 113A1: 129-88
I aguun 1 4:sign anti management for Livestock tvtanure •Trcalnt:nt and Storage Ia1AIi 103-83
(',1111,1 .uiuu ul ALuuuc and Wastewater Application Equipment ; I:IIA F. Fact Sheet
1'uuuullu,g (I,InI:. Ilunl Swine !Mailings ; f111-33
I:uvinnuncnlal :1s5nl:ulce I'tngrtntt ; NI'I'C Manual
( Iluluus I„1 Pl,ul,lging I )tlur ; a rellutl front the Swine C)ttor "Task Force
I luu:ult.e t'unt.t:l,r in Animal Manure lvIanagenlcrIt: ()finis and Flies ; I'Rl107, 1095 Conference Proceedings
At11(11 I I. . nil:: t 1 1 l)'tn, hint:
NCSI1, County Iixlension Ct:nlcr
NCSl1 - I1AIi
NCSI1-'IlAli
NCSIJ - I1A1:
NCSHI - liAli
NCSI1- unl:
NCS11 - Swine Extension
NC fork Producers Assoc
NCStJ Agri Communications
Florida Cooperative I:xlcnsinn
Primary Secondary
Version —November 26, 2018
Mortality Management V ethods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Routine Mortality
:,.. Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
! n Rendering at a rendering plant licensed under G.S. 106-168.7.
ElComplete incineration according to 02 NCAC 52C .0102.
❑ A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
I I ❑ In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
C Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
Date
Signature of Techhical Specialist Date