010028_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non-Discharge General Permit
On September 30, 2019, the North Carolina State Non-Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non-Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3,2019.
Please do not leave any question unanswered Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permitter
1. Farm Number: 01-0028 Certificate Of Coverage Number: AWC010028
2. Facility Name: A.D.and Carlton Williard
3. Landowner's Name(same as on the Waste Management Plan): Albert C Williard
4. Landowner's Mailing Address: 8152 Lindle;Mill Rd
City: Graham State: NC Zip: 27253-8329
Telephone Number: 336-675-3453 Ext. E-mail:
5. Facility's Physical Address: 8152 Lindlev Mill Rd
City: Graham State: NC Zip: 27253
6. County where Facility is located: Alamance
7. Farm Manager's Name(if different from Landowner): Albert C Williard
8. Farm Manager's telephone number(include area code): 336-675-3453 Ext.
9. Integrator's Name(if there is not an Integrator,write"None"):
10. Operator Name(OIC): Albert C.Williard Phone No.: 336-675-3453 OIC#: 21331
11. Lessee's Name(if there is not a Lessee,write"None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Cattle-Milk Cow 150
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses-Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses-Other
Farrow to Finish Milk Cow Pullets Sheep-Sheep
Feeder to Finish Dry Cow Turkeys Sheep-Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Design
Estimated Liner Type Estimated Freeboard
Structure Date (Clay,Synthetic, Capacity Surface Area 'Redline"
Name Built Unknown) (Cubic Feet) (Square Feet) (Inches)
ROOFED WET STACK
WSP 26.40
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d)to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan(WUP),sinned b%-the owner and a certified technical specialist containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
It. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g.composting,digesters,waste transfers,etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]
RECEtVED/NCDEQlDWR
MAR 19 Z919
Prater Quality
Regional Operations Section

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation,signature should be by a principal executive officer of the corporation):
Name: Title:
Signature: G� M-, Dater
Name: _ Title:
Signature: Date:
Name: Title:
Signature: _ Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
E-mail:2019Permit][e-mail]
FORM: RENEWAL-STATE GENERAL 02/2019

ti►�t a
ROY COOPER �
Govcmor
MIICHAl;4 S.PECAN �•�
LINDA CULPEPPER WORTH CAROLINA
Director r nYft anmen1dQudity
February 26,2019
Albert C Williard
A.D.and Carlton Williard
8152 Lindley Mill Rd
Graham,NC 27253-8329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non-Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non-Discharge General Permits are available
at hMs:Hdgg.nc.gov/about/divisions/water-resources/water-quality-revional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
In order to assure your continued coverage under the State Non-Discharge General Permits, you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non-Discharge General Permit." The application form must be completed signed and returned by April 3. 2019,
Please note that you must include one (1) coos of the Certified Animal Waste Management Plan (CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on pUe 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to$25,000 per day.
If you have any questions about the State Non-Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Sincerely,
Jon Risgaard,Section Chief
Animal Feeding Operations and Groundwater Section
Enclosures
cc(w/o enclosures): Winston-Salem Regional Office,Water Quality Regional Operations Section
Alamance County Soil and Water Conservation District
AFOG Section Central Files-AWC010028
North Carolina Depannient of Environments!Quality I Ditision of Water Resources
5:12 N.Sardsuty 5t.1 1636 Mail Service Center I Raleigh,North CaroBaa 276SO-1636
— '�- 918.70729WO

far >} vh wi•!G`"ot AWe- 01 002 $
R
6 tq hA f''>t f w4. Z 7 2 y? Version—November 26,2018
Mortality Management Method
ECENEDMODEQlD11VR
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian. MAR 19 2019
Primary Secondary Routine Mortality daie�QualityRegional Operations Section
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should beat least one foot above the seasonal
high water table.Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
R!--nderiro at a rendering plant license- i!"e��r t�.-...�... -111, -45 7
U I_3
Complete incineration according to 02 NCAC 52C .0102.
aA composting system approved and permitted by the NC Department of Agriculture &Con-
El Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
D NC Department of Agriculture&Consumer Services(G.S. 106-549.70).
a Q Any method which, in the professional opinionaof the State Veterinarian,would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be>.done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions(refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency,the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
ff,Ai?�o
Signature of Farm Owner/Manager Date
Signature of Technical Specialist Date

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Design
Estimated Liner Type Estimated Freeboard
Structure Date (Clay,Synthetic, Capacity Surface Area 'Redline"
Name Built Unknown) (Cubic Feet) (Square Feet) (Inches)
ROOFED WET STACK
WSP 26.40
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d)to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan(WUP),sinned b,� the owner and a certified technical specialist.containing:
a. The method by which waste is applied to the disposal fields(e.g.irrigation,injection,etc.)
b. A map of every field used for land application(for example:irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation(RYE)for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted-Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g.composting,digesters,waste transfers,etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]
RECEIVED/NCDEOJDWR
MAR 19 2019
Water Quality
Regional Operations Section

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included,this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25.000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation,signature should be by a principal executive officer of the corporation):
Name: Title: �J
Signature: C �M ", `� � Date: �— t�7`��
Name: Title:
Signature: _ Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh,North Carolina 27699-1636
Telephone number:[phone]
E-mail:2019Pe rm [e-mail]
FORM: RENEWAL-STATE GENERAL 02/2019

0/ .9 rAt, 02
LrNAl !Lll+'rf�2
Z 7 2 l Version—November 26,2018
Mortality Management Method
ECENED/NCDEC..-.,,.,;
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian. MAR 19 2019
w awi Quality
Primary Secondary Routine Mortality .Uglonal Operations Section
Q a Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table.Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEG under GS 15A NCAC
1�y 13B .0200.
at a rer dp!ing p!sne iicense-i under G.S. c�Z-i e--p_7
Complete incineration according to 02 NCAC 52C .0102.
Q A composting system approved and permitted 6Y the NC Department of Agriculture&Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off-farm,
additional requirements must be met and a permit is required from NC DEG.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture&Consumer Services(G.S. 106-549.70).
Q Any method which, in the professional opinionjof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm-specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be-done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions(refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency,the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
&W-e kayt,7 3- /,/-/f
Signature of Farm Owner/Manager Date
Signature of Technical Specialist Date

ANIMAL WASTE UTILIZATION PLAN
RECMVEDMI-;'-'x'7'WR
Producer: A.D.WILLIARD
Location: 8152 LINDLEY MILL RD. APR 2 3 2019
GRAHAM NC 27253 water Quality
Telephone: [phone] RegkmW 0p9Mons Sacban
Type Operation: Existing Dairy Milk Cows (Broadcast)
Number of Animals: 150 . 00 head
(Design Capacity)
STORAGE STRUCTURE: Waste Storage Structure
APPLICATION METHOD: Broadcast
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient .
Waste should be analyzed before each application cycle . Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1 . Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste . Do not apply
more nitrogen than the crop can utilize.
2 . Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3 . Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4 . Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations .

ANIMAL WASTE UTILIZATION PLAN
5 . Wind conditions should also be considered to avoid drift and
downwind odor problems .
6 . To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems. .
This plan is based on the waste application method shown above . If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste_ is based on
-typical nutrient content for this-type- of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H . 0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc. )
150 head x 32 . 1 tons waste/head/year = 4815 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
150 head x 76 lbs PAN/head/year = 11400 lbs . PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.

WASTE UTILIZATION PLAN
Producer ; � � LJ�� ��-�5��
-Type Operation :
L Number of Animals-.
J Capacity )VORGIon
? The waste from Your
animal facility
a . a 7Ti must
us ' be
1 a applied
. ! l � t a
SPe^iftd _at . to Prevent Pollution
of wuAfC .t water
and/or
oC n watcr . The plant nutrients in he animal J< ; r~ should
be
us0d to Te:l : J the amount of commercial fertilizer : l "F f � " the in the fields where Ie waste is to be appljed ;
This Waste utiliZation
Plan Uses nitrogen ». limiting
N,�r.^1:.,: should �i r analyzed � ,x�� the F,? rl t..!i.-.`( :1..,ca r'I k:
to determine'rminr
nutrient( content before
ap[ l1 :% ; l " T cycle . Annual- �r �_ tests are a " ZpCIy encouraged canbe 4'S>:i, 4 . all Plant nutrientsbalanced
1 ! realistic y % olsm of crop - , be grown , !Several factors :l.I I I a"I'� important 'rT 'P...Ae ITl CP,ri t.1,i"i<>
Your
r 7 1 r W i " ;Wutili:a ion Plan in order to maximize , he fertilizer Ji '
:� ( i 'd� �tv i i that
' 1)i1�en'r1;�T' _ � l.i-st;) in an �.n'„'i.'r<i]+Ilrr: '1`I'L.C::1 :b' ...�4' w
s
1 - Always aP,al r{ wasta based c�,�:a<,d on 'h.fr w needs of 'i;.{"i e crop to be
grown and the I
n�...l,.T .,. ;:r`i t content ,;�,-�= the
i:i��;%.1..;f more .. n than ! t!i. waste . n o �n�:��.
d
the e crop t::a r? utilize ,
2. E.rO.i types are JJJ rates ,im`atant Ts they have -different Li " iiira :irn leaching
capacities , and d %W;'.;1 'i l a b.l holding potentialss 1'T }:r:r! f'f!:�
` - C'- water'�;^.j^ capacities
3. Normally waste
� shall not f „ J C i 1 o 4 to land a i o: 1 With a '.g greater than 5 tons P acreperyear , special
�.:. .:J t.t;j n::...Precautions ,r?e i.. acre p t3 T"
apply4. Do not
waste on saturated soils , when it
raining , or
hen the
is conditions
r,J .. ' ,� frozen . Either C:A'T^ 1.,-i"I<w�.0 i
r^d i i o i I,`^..' I, a y result in runoff .}. �
.i.� 1`l t,^,t.. allowed under i North
..t.' surface waters which
l,.ilder North t^t:?T,•o1.1.3"`i•:•a i"'):i,.,, .C:;;.1on 0
Environmental Management f i'�.1C'D •. 00 Y i
5 Wind
and downwind
Li `,_ .7t_.ilC.I Aso be .1t:i1'Iv:..I.C�..:'rf'%-! toc'�'.,Ir ; d -t_
ot,ti-,,- problem,,,-.
I

HASTE UTILIZATION PLAN
6 . To maximize the value of nutrients for crop productio-11
and to reduce the potential for Pollution, the waste
should be applied to a growing crop or applied to bare
ground not more than 30 days prior to planting .,
injecting the waste or disking will WnscrVe nutrionha:
and reduce odor problems .,
The astimaLed acres needed to apply the animal waste is based an
typical nutrient content for this typo of
rcquirements should be based on the waste analysis report from youl
waste monagement facility . Attached you will find information an
proper sampling techniques , Preparation , and transfer of waste
samples to the lab for analysisr
This waste utilization plan , if carried out , meets the requifementz�;
for compliance with 15A NCAC 2H .0217 adopted by the Environmental.
Management Commission .
2

WAS77"- UTILLIAI DN PLAN
HOLDING POND FOR RUNOFF & PARLOR WATER ONLY
Amount of Water & Waste Produced Per Year(gallons, ft3 tons etc.
animals X 5 (GAL/DAY/COW) parlor wash water/animal/year X (number of
days) _ "' r'-�' (gals) of waste/year.
Runoff from Feedlot: AVG ANN Rainfall = i in X V o (Runoff X sig.ft. of
n
Area X 1ft/12in X 7.48gals/cu.ft. Jgallons/year
Excess Rainfall on Structure: )ir',; sq.ft. in/day of excess rainfall X
days X lft./12in. X_7.48gals/cu.ft. =11, r" '.? gallons/year
TOTAL GALLONS = .- . ' gallons of Waste Water/Year
Amount of Plant Available Nitrogen (PAN) Produced Per Year
,a -
lbs. PAN/1000 gals X - ` ' ^: >" ""=-' gals/year lbs. PAN/year. (PAN
from N. C. Tech. Guide Std. .633 or NCDA Waste Analysis Report)
MJ / ~ i =744 lbs.PAN/Year.lbs. PAN ac-in X��, . -: Total Ac-in
(PAN from N. C. Tech. Guide Std. 633 or NCDA Waste Analysis Report)
Applying the above amount of waste is a big job. . You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be
grown and surface application:
Table 1 : ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs . N Acres Lbs . N Month of
# No. Type Per Ac . Utilized Application
i is r .' 1WR
APR 2 3 2019
c�uatity
section
Total = 7 �,5 06910484
" This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. _N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern counties of North
Carolina to have a nutrient management plan that addresses all nutrients. This plan only addresses
Nitrogen.
2

ViASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landbwnev must bo attached )
CRequired only if opprator does not own
adequate land [see Required Specification 21 )
Tyact, Field Sail Crop Lbs . N Acres Lbs . N Month of
Typc Per Ac .* Utilized Applicatiori
-------------------
- -----------
I-----------------
Total
See footnote for Table 1 .
Totals from above Tables
Acres Lbs . N
Utilized
Table i
Table 2
Tota.l
,Df N Produced
NOTE-I—The 1,Jaste Utilization Plan must contain provisions for
Periodic land application of sludge it agronomic rates . The sludge
will ba nutrient rich and will require precautionary measures to
Prevent over application of nutrients or other Moments ,
4

WASTE UTILIZATION PLAP4
y
0 f f I c,e, Q v r v
t. t e,m! f a'Ge 'a-ve r z ig
MONTH O
S . In ri`;Y shc?utr! �A-,��. Voluaj,- of 11"Jas! e h�,-j" rij
v a t.T) C,u s.t I-u I r e
C;all the lccal Corls-.-Z.+I-vat i c,-lei
S 0 C o n s a t.J r Il S 0 T' ',E-,011, ai-)(] W lei r C`o n s e,r v t. n I s,
aft or You r-z,!:--o-t
in cletarrfiirda� th,� amouri'l- Per to appl,,, a�rid t.'rie propcv
, ppl.-11,.(-,t,�l,-,..i-,,-.,.-.,-II r�ate P-rior �,-,Pplying thle
tLi� F�t'jL:LVE OF OPERATION
Vv AST" UT, x-I z A-T i ci N PL-A T-c 14 A JVP LE -5 Tc>',Z!Et)
�IN WASTE S To IR-A 6-E POND ro R I-OT
_0 jv c, TIA
0, 59;�n
lbu /Cj
A
b�, d
hD 6m.
7 ncbew qs-oo, a)n Vn
40, 7
tl TO

WASTE STORAGE POND
OPERATION AND MAINTENANCE FLAN
r(,P, • A. _D- Pf OC(rL7�/V �i+/r!lfrcC�
The stora3e pond is cc-mposed of two vo I urnes .
The I ewer- '�. _ feet of deptr,
in the pond is the waste storage volume . The r-ernai n i r,3 depth C-f the pond
to the emergency sp i 1 l way I eve I is storage for a '�F year , 2:4 hour ra i nfa I 'I
that enters the pond . The elevation to start pump i r,3 is -!LI — and will be
marked with a permanent rnark:er . In order- to maintain _�__ months stC.ra,:
the pond will need to be pumped aut comipleteIy.
The waste ut i I i -at i can p I an sha I I be fc, I 1 owed as shown i n At-Lac hment A.
This requires sarnp I es and testing .:.f waste ( see Attachment L=,) before I arld
app I i cat i can . 'Wa9te sha I I be app I i ed on f i e I ds as shown on attached sc. i I s
maps .
A fence wi l I be co,`i�_;tr'ucted tr. ' reVerlt I I Ve5to
Ck: r rON wa i 1:: i n3 on the diarn,
therefc1re , preventing a hazard fc.r the I ivest,ck: and darn ,.;je -to t-he darn.
The rout I ne ma i nter,anCe Of th I s waste stora3e porid I nvo 1 Ves the fo I I .-w , n3:
1 . Maintenance of a vegetative cover on the ernbank:rnent and in the emer--
ger,cy sp i i lway: Fescue is being estab I i shed on these areas . E:eg i r,-
n i ng the year after construct i can and each year thereafter , the
ernbank::ment and emergency sp i I I way shou I d be f ert i I i es w i th 1 ,i;i;Cl
pounds o'F 1i1-1 1-Ic) per acre tcl rnalntaln a vI3]orous sitand .
�. Cor,tro I of weeds , brush , and trees on the e.rnbankment arid i n the
erner-gency sp i I I way: this sha I I be clone by me w i r, spraying , cIr-
c Kopp i n3 , or a combination of al I three . This w i I I need to be
done at least once each year and p1:1s5 I b l y twice in years favorab I e
tO heavy growth of vegetat i c.ns . Y�Iu may cr,ecE.: w i th the I oc a I
Extens i on Agency or- SCS off i ce fc r the I atest i nfor If,at i car, c,r, spray
material and the best time to apply them.
Maintenance Inspections .---If this waste stclraoe pond should be made during
the i n i t i a l f i I I i n3 , at least annual I y, and after- every rna.jor Storm. T l erns
t be checE:-ed shou I d i r,c I ude , as a rn i n i I'll UM, tr,e f c, I I cw i 1­13
1 . Emergency Sp i I I way
a. erasion
b . sed irnentat i cin
c . weeds , small trees , Iogs , fences , or ether obstruction that
reduce channe I capac i ty or may b i cick f I caw.
�. Er,ibankrnent
a. sett I ernent , crack i ng or- "iu3" ho I es
b . side s lope stab i I i ty-s I umps or bulges
c . e r'c i s i o r, NEC,
d . rodent damage
e , seepage or ether I eak:age APR 2 3 2019
f C0['1d I t I on and tYF,e !If ve,Ietat i or, cover
WaterQuafity
Regional®peUOM Sect ko

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ q rD- 7V- 6.ar
EyIERGENCY MANAGEyIENT SYSTEM 77S�_
S`VCD 3 3 cP - Z 29 _ 1-75,3 es-k-3
MRCS b .zZ. - I-753 ex4. 3
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until was rstes reach surface wate or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow-possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field-actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to elirrunate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems. houses, solid separators-action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems. or solid separators.

e. Repair all leaks prior to restarting;pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks-possible action:
a. Dig a small sump or ditch awav from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
''. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Anv damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property'?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal.business hours,call your DWQ (Division of Water Quality)
regional office; Phone - - . After hours, emergency number: 919-733-39a2.
Your phone call should include: your name. facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local ENIS Phone number -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local MRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off-site
damage.
a. Contractors Name:
b. Contractors address:
e. Contractors Phone:
DecL��b�r I S. I<?Uh

6: Contact the technical specialist who certified the lagoon (MRCS. Consulting
Engineer. etc.) /
a. Name: 0 CPS
b. Phone: . 3 3 6 229 -0.5.3 eX4. 3
is Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage. repair the system. and reassess the waste manavement plan.to
keep problems with release of wastes from happening again.
Decem�er 18. 1906

Dairy Farm Waste Management Odor Control Checklist
tZ 2 A.D G/�cGrii�x�
Source Cause 13MI's to&linftnize Odor'' Site Specific Practices
Farmstead Dairy produclion FT VVgetadve or wooded buffers
;-,-zCf"c011llllcllded best management practices `
Good judgment and common sense
Paived lots or barn alley We[manure-covered surfaces ' Scrape or(lush daily _
sui laces 111---Promotc drying with proper vcrtlilalion
ff,�Ruulinc checks and maintcn;mce on %vatcrcrs,
hydrants,pipes,stock tanks
Bedded-areas 0 Urine Promote drying with proper ventilation -----
• Partial microbial decomposition Replace wet or manure-covered bedding
-Manure dry slacks 0 Partial microbial decompositiun Provide liquid drainage lbr scored manure
Storage tank or basin 8 Partial microbial decomposition ; 1)oltum or mid-level loading ---
surface 0 Mixing while tilling; ❑ 'yank covers I-11A-
0 Agitation when emptying ❑ pasin surface mats of solids;
Minimize lot runoff and liquid additions
Agitate only prior to manure removal
❑ Proven biological additives or oxidants Nl
Settling basin surG�ces Partial microbial decomposition ❑ Liquid drainage from settled solids
• Mixing while filling f91Rcmove solids regularly
Agitation when emptying
-Manure,slurry or sludge • Agitation when spreading O Soil injectivu of slurry/sludges
spreader outlets 0 Volatile gas emissions ❑ Wash residual manure from spreader after use
❑ Proven biological additives or oxidants
Klucgvered manure, 0 Volatile gas emissions while CI Soil injection of slurry/sludges
slurry or sludge on field drying ❑ Soil incorporation within 48 hrs
surfaces I"Spread in thin uniform layers for rapid drying
❑ Proven biological additives or oxidants
17luslr tanks Agitation of recycled lagoon ❑ Flush lank covers; Y/
liquid while tanks are filling p Extend fill lines to near bottom of tanks with /U l
anti-siphon vents
Outside drain colleclivn Agitation during wastewater - ❑ Box covers -- /
orjunclion boxes conveyance
AMOC-November 11, 1996, Page I

1
Source Cause BINIPs to Minimize Odoi- Site Specific Practices
Lift stations Agitation during sun►p tank O Sump tank covers
filling and drawdown 1"
^I'nd ordminpipes at • Agitation during wastewater 0 L--xicnd discharge point orpipes ut%derrrcath /
lagoon conveyance lagoon liquid level
La I surraces a Volatile gas emission; Proper lagoon liquid capacity;
�P57 • Biological mixing; 9--'Correct lagoon startup procedures;
Agitation Cl Miniuurtn surface area-to-volume ratio;
C4-"M'inini un agitation when pumping;
O Mechanical aeration;
O Provcn biological additives
Irrigation sprinkler I ligh pressure agitation; Irrigate on dry days with little or no wind;
nozzles Wind drill C5--Mininrturt recommended operating procedure;
W Pump intake near lagoon liquid surface;
O Pump from second-stage lagoon;
g3,�F1ush residual manure from pipes at end or
slurry/sludge pumpings
Dead animals Carcass decomposition Proper disposition of carcasses
Standing water around 0 Improper drainage; EJ- Gradc and landscape such that water chains
facilities 0 Microbial decomposition of away front facilities
organic matter
Mud tracked onto public • Poorly maintained access roads Tartu access road maintenance
roads from farm access
Additional Inrormation : Available from
Cattle Manure Management ; 0200 Rule/BMP Packet NCSU, County Extension Center
Dairy Educational Unit Manure Management System -lake Wheeler[load field Laboratory; EBAE 209-95 NCSU-BAE
Lagoon Design and Management for Livestock Manure 7-reatntent and Storage ; EBAE 103-83 NCSU-BAE
Management of Dairy-Wastewater; EBAE 106-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE fact Sheet NCSU - BAE
Nuisance Concerns in Animal Manure Management: Odors and flies ; 11R0107, 1995 Conference Proceedings Florida Cooperative Extension
AN40C-November 11, 1996, Page 2

Insect Control Checklist for Animal Operations
Source = Cause 13AIPs to Control Insects - - - -- -_-
___ Site Specific 1 t acliccs
__ Liquid 5ystcuts ---
Flush(;uticrs Accun 1 atio❑of solids O Flush system is dcsigned and operated
sufficiently to remove accumulated solids from
guticrs as designed.
Cl Remove bridging oraccumulalcd solids at
_ dischafgc
La ons and Pils Crustal Solids Maintain lagoons,settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than G-
g in es over more than 30%of surface.
Lnessive Vegetative Decaying vegetation Maintain vegetative conlrol along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along Water's edge on impoundment's perimeter.
Dry Systems
Feeders Iced Spillage Ucsign,operate and maintain feed systems(e.g., �—
bunkers and troughs)to minimize the
Ic emulation of decaying wastage.
Clean up spillage on a routine basis(e.g., 7 - 10
day interval during summer; 15-30 day interval
king Avinter).
Iced Stot'age Accumulations of Iccd residues Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away front site
and/or providing adequate containment(e.g.,
covered bin for brewer's grain and similar high
n islurc grain products).
0
Inspect for and remove or break up accumulated N
solids in tiller strips around feed storage as co
needed. aq� �
u Q
v
au
AM IC-November 11, 1996, Page I

Source Cause — — 1'Ml's to Control Insects' --- — ----
Animal I loldin g Areas Site Specific Practices
b Accumulations of animal wastes 0 Eliminate low areas that trap inoist'ure along
aid toed wastage fences and other locations where waste
accumulates and disturbance by animals is
�
i •inimcd._
®' Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes(i.e., inspect for and
remove or break up acCiuiiulated solids as
needed).
SysManure !landling Accumulations of anunal wastes C3�temove spillage on a routine basis e. 7- 10 — -- —
5yslcros ( g•,
day interval during sununor; 15-30 day interval
during winter)where manure is loaded For land
application or disposal.
0 Provide for adequate drainage around manure
stockpiles.
O Inspect for and remove or break up accumulated
wastes in-filler strips around stockpiles and
—__-- - _ manure handling areas as needed.
For more information contact (lie Cooperative Extension Service, UeparUnent of l-,ntomology, Box 7613, North Carolina State University,
Raleigh,NC,27695-7613.
AM IC-November 11, 1996, Page 2

Mortality Management Methods
(check which method(s) are being* implemented)
Burial three feet beneath the surface of the around within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
cream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
Q Complete incineration
'_J In the case of dead poultry only, placing in a disposal.pit of a size and design
approved by the Department of Agriculture
til Any method which in the professional opinion of the State Veterinarian would
make possible the salva(,e of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December IS. 1996

ANIMAL WASTE UTILIZATION PLAN
TABLE l: ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE & CLASS- CROP YIELD LBS COMM N ** * LBS
DETERMINING PHASE CODE AW N PER ACRES AW N
PER AC AC USED
----- or -------
APPLY RESID. APPLIC
METH N TIME
Rom E FRi2
2856 2 GaB2 CS 17 204 0 28 5712
B MAR-JUL
2856 �2 WA 1 100 0 28 12800
B SEPT-MAR
T2856 �2 SA 1 1100 0 28 2800
B JUNE-
SEPT
2856 �2 GaB2 SB 30 120 0 128 13360
B APR-AUG
r 1929 1 TaB2 CS 18 . 0 1216 0 10 12160-
B MAR-JUL
1929 " 1 WA 1 100 0 F1O 1000
B SEPT-MAR
1929 �1 ISA ll 1100 0 10 1000
B IJUNE-
SEPT
1929 " 1 jTaB2 SB 30 . 0 1120 0 110 11200
IB I APR-AUG
2857 1 GaB2 CS 17 204 0 6 . 5 1326
IB I MAR-JUL
2857 �l WA 1 1100
T
6 . 5 650
B SEPT-MAR
2857 1 GaB2 CSGH 13 . 6 1180 0 6 . 5 1170
IB FEB-
MAY, S-N
2857 2 jEaC2 CS 117 204 0 2 1408
IB MAR-JUL
2857 _2 WA 1 1100 0 2 200
17 IB I SEPT-MAR

ANIMAL WASTE UTILIZATION PLAN
2857 2 lEaC2 CSGH 3 . 0 1150 0 2 1300
IB FEB-
MAY, S-N
2857 3 lGaB2 CS F17_T204 FO _Tl 3 . 5 2754
B MAR-JUL
2857 1 -3 IWA 1 1100 0 T3 . 5 1350
B SEPT-MAR
2857 3 lGaB2 CSGH 13 . 6 1180 0 113 . 5 12430
IB FEB-
MAY, S-N
2857 �4 GaC2 CS 17 204 0_ 3 612
B MAR-JUL
2857 �4 GaC2 CSGH 3 . 3 1165 0 3 495
B FEB
-
MAY, S-N
2857 � -4 IWA 1 1100 0 3 300
` B SEPT-MAR
3599 3B GaB2
CS 17 204 0 20 4080
IB MAR-JUL
3599 �3B WA 1 100 0 20 2000
B SEPT-MAR
3599 3A �TbC3 CSGH F2 _ 225 5 0 5 . 1 FFEB-
MAY, S-N7 . 5
B
3599 14 TbD3 CSGH 12 . 5 1125 0 2 . 8 350
� B FEB-
MAY, S-N
1.oV� �Pt 1ZM
1928 3 TaB2 PG 4 . 8 1135 0 7 . 1 � 958 . 5
B FEB-
JUN, S-N
1928 4 jGbC3 PG 4 . 8 135 0__T_8 .7 1174 . 5
B FEB-
JUN, S-N
1928 5 GbC3 PG 4 . 8 135 10 9 . 7 1309 . 5
B FEB-
JUN, S-N
D�rec. d

ANIMAL WASTE UTILIZATION PLAN
TVP-Y FARM
2885 1A GbC3 CSGH 0
IB 12 . 7
1135
I 11 . 8
1243
FEB-
MAY, S-N
2885 � 1B GbC3 CSGH 12 . 7 1135 0 112 IFEB-
MAY, S-N270
2885 5 GbC3 CSGH 12 . 7 1135 0 11 . 5 1202 . 5
B FEB-
MAY, S-N
2885 1C GbC3 CS 16 192 0 16 . 5 � 1248
B MAR-JUL
2885 I _1C I IWA 1 1 100 0 16 . 5 � 650
B SEPT-MAR
2885 �1C I SA 1 100 0 � 6 . 5 T650
Pet 3M� B UKE-5RP7
2 ss5 ! G CS&A 3.�O 1.160 _ rl`'
2885 11D GbC3 CS 16 192 0 5 . 5 1056 V
B MAR-JUL
2885 1D WA 1 100 0 15 . 5 1550
�N ' B SEPT-MAR
2885 �1D SA1 100 0 5 . 5 1550
g JUNE-$01
3 q Gs�� F�
��a�s ! � �.�_ Igo ® _�.�T
�IA
B a �
5-&
TOTALI47956 . 5
- Indicates that -this field is being overseeded (i . e . interplanted)
or winter annuals follow summer annuals .
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements . In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients . This plan
only addresses nitrogen.

WASTE UTILIZATION PLAN A MEVI)ME T
For A , r).
Date 8 Z9 j o t
The Environmental Management Commissions regulations for animal waste
management provides the following information in their Seventh Guidance Memo dated
January 9, 2001:
Animal waste application on fescue grass may begin on August 1 and end on July 31.
This means animal waste may be applied to fescue throughout the year
There are two exceptions.
Exceptions:
1 Limit nitrogen application during June and July. It is recommended that
you apply no more than 301bs. of N per 30 day period during June and July
providing there is adequate soil moisture. *
2 No_nitrogen in December.and January during severe winters such as when
ground is frozen or when ground is too wet for equipment.
Important: Include this Amendment with your Waste Utilization Plan.
Technical Representative Date
*This information on application rate provided by Carroll Pierce with the Division
of Soil and Water Conservation on August 28,2001.

ANIMAL WASTE UTILIZATION PLAN
TABLE 2s ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached. )
(Required only if operator does not own adequate land.
See required specification 2 . )
TRACT FIELD SOIL TYPE & CLASS- CROP YIELD LBS COMM N ** * LBS
DETERMINING PHASE CODE AW N PER ACRES AW N
PER AC AC USED
----- or -------
APPLY RESID. APPLIC
METH N TIME
END
TOTAL 0
Indicates that this field is being overseeded (i . e. interplanted) or
winter annuals follow summer annuals .
Caution must be exercised in grazing or haying summer
annuals under stressed conditions . Nitrate poisoning
may occur in livestock. Sampling forage or hay for
nitrate levels is recommended.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above :
CROP CODE CROP UNITS PER UNIT
CS CORN SILAGE TONS 12
CSGH COOL SEASON GRASS - HAY TONS 50
PG PASTURE - GRAZED 28 . 125
SA SUMMER ANNUALS - VW-iEzS SuPkm E"TG AC 100
SB SOYBEANS b AT5 EYG. 4
WA WINTER ANNUALS -- W Vk A� R`( ) AC 100

ANIMAL WASTE UTILIZATION PLAN
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 155 . 7 47956 . 5
TABLE 2 0 0
TOTAL 155 . 7 47956. 5
*** BALANCE -36556 . 5
-------------------
f
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to .be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations . Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables .
See attached map showing the fields to be used for the utilization of
animal waste.
Your facility is designed for 79 . 00 days of temporary storage and the
temporary storage must be removed on the average of once every
2 . 63333333333 months . In no instance should the volume of the waste
be stored in your structure be within the 25 year 24 hour storm
storage or one foot of freeboard except in the event of the 25 year 24
hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2 . Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste .
NARRATIVE OF OPERATION
f&CElVE iNCDEQ1D H
APR 2 3 200
i

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1 . Animal waste shall reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct
discharge during operation or land application. Any. discharge
of waste which reaches surface water is prohibited.
2 . There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3 . Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients .
4 . Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5 . Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6 . When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance . )
7 . Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies .
8 . Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9 . Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

WASTE UTILIZATION PLAN
REOUIRED SPECIFICATIONS
10 . Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients . Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11 . Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal . Animal waste other than
swine waste from facilities sited on or after October 1, 1995) ,
shall not be applied closer than 25 feet to perennial waters .
(See Standard 393 - Filter Strips) .
12 . Animal waste shall not be applied closer than 100 feet to
wells .
13 . Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14 . Waste shall be appl'ied in a manner not to reach other property
and public right-of-ways .
15 . Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over-spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist" . Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site .
16 . Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc. , shall not be discharged into the
animal waste management system.
17 . A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc . ) . Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc . , are limited to areas where considered
appropriate . Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18 . If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 . Waste handling structures, piping, pumps, reels, etc . , should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills . A regular maintenance checklist should be kept on
site .
20 . Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21 . Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons . Pumping shall be managed to
maintain the liquid level between the markers . A marker will
be required to mark the maximum storage volume for waste
storage ponds .
22 . Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element . Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels . pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years . Poultry dry
waste application records shall be maintained for three (3)
years . Waste application records for all other waste shall be
maintained for five (5) years .
23 . Dead animals will be disposed of in a manner that meets North
Carolina regulations .
Page: 11

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:A.D.WILLIARD
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above . I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on-site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request .
Name of Facility Owner: A.D.WILLIARD
(Please print)
Signature: Date:
Name of Manager(If different from owner) :
Signature:
uG'Z , Date:
Name of Person Preparing Plan: (Please print:)Phil M. Ross
Affiliation:Alamance SWCD Phone No. 910-226-0477
Address (Agency) : 201 West Elm St.
Graham\ NC 27253
Signature: Date: 3 2
Page: 12

�- AR° k, x pPPt (fQ l�•\• 9� _..�`R�'5:... j-J�P HNgQQ,.., 'I,
H AGGZ 1950
_ AJ r E884�.• NAll .. ••HURCH S S •~ ��� II,dX le �. 70
_ Mebane
r f- Mebanb R1.4 00
m�H `_ I -. Rt. �.
1 _` BURLINGTON _ - _ T - i- ..-. _ 1976
-I J � f
CC C C{t 81 c - 70'.... 81L r a 1936 RpTp'R.- o./ti.
.OE !.` � c.j{i;: 100 l��`lt ...x •� ..18ALL?:, O }t- D 3•`y. 1962 r T
hI.;A��/�.� RD. ,36 4 �, MebanelRt.l.,;t /936 r./940 '�.)
ZVER'• OLsI. 192e I yo,pt S! g {��
z 70 „ ".4,-•,�, C1rr "E' -�I ° :U / '�" ��O F).ELVII.LS: M 119
!r CHURCH •. ;T. �_ oB I '} A 49 GER /9
HWY. 9 �.-7 -, 54 �(F`e l °R i G RA/ 1 OL�'N 'AO• 1 1940 j/ t[96ppRK I979 a0•
//46 �i v� ' fa 6t 4piEC l0 -3 / WN IBR4A GY' 1977
4 sl Jg� 8 4 e\ t Hid ,_., ?e ,- 1945 f River Rt.I
O S - "'L1VG'r.,4 NE' //5 a4..'.•,U 54 vr'i C'\ z/00%
CITL SC RDOLS fir:-4? .2 I f P SWEPv96R LE FIRE GIST.
e t�
_ sham Ri io' / 2113 90
r 3Mo TN F 4r F 2101 928 f� TURNER RO 2126 0
�153 �J T. SCI100 DIST.- Ci > f NE x
,`•3J s v \ 115 'A-BurNngtnn r' H4Nrr t l r If ERRY F,BA o 'xr,
',-` `r• v 1 00 R Rt.6 H 2124 Haw River 2130
t^� //46 ?. i 1154 r„�' /!56 49 \ B,p --'�2/ {f,54 iI' -P!`ro 2/25 Rta" `o Mebane
r^ �1 BOA INGTON r - i 87 I J o 1007
c, 0 r g'�' 1 / �o fi. ft0 3 2 R1.2
//5/�.,l/64 & •ti\ \� YO- - O `River ---� RIMREy 119
GLEN MIL LE NV� AIRPOflT lCt. i e '� 7" GYP 4�,. - 2135 iL� ? r ✓
R0. F 08. t� .-M..-B�. --f/57._.� .�.__0114�_ 23_ _.._211.3- __ R D•,A�=gRisyrl'
F t.1 i /rr
•�� �\..... - ER yy �Hr G I �Q 2I34 far 213.7 2131
MOS t7 rFSI yr�,� /2-• ^CHE£X CN. �s r t ..
I ��-r3,�;3 eurHn oo Res �� •/ s�� ,si�:;g 1928 y .fir
ii �' COOR
air r.: fi'� i3E"0 9 2100 �0 2137t'ivb Z/35
A40MUee Me6one;f
45 pD. �� `�-r••-� 23/7`rr o� ICl c° 'rF R �4 2159 C 3 Rt.l
.'
Burlington ,v } 41 ` �.--� 1//7 2157 �✓'".�4.- 2/3/
Rt.1 +WY5t !!.u{Y3 y:: 1 1 215 2139
1159 1160 Belle onl R^�/Graham f�--•' , 2140' 2� _
RD- N36 "'^�--.1 236 Rt.l t.^ " :� •FIRE STA ti1�,,:/ =, -
GRDUNO - Burlington Rt.6 °'.'` I- -90``GS` Swepsonville Grp�g W •2l35
SSE mil. `-.Y� RA.IcH"•.._RD. (` - o -
3P v //30 �� FIRE STA / s0 ?` 2319 NO .\ 2158 C1P a 214/
r xl�THF-p v4, SOUTHERN 2118� 00y OS 1:., ,. y S -r�4' Han
y pr~, ^.� m N�O,HIGH SCH 00 2/5B 0 '4pEL,/ Ricer
a t s y ry 2321 Graham /, m F - 2/53
MANCE z 0 "j (INS 32387 GR RL3 f p 90. Rt.l
TLEGROUND Q C4 1152 µF •RD f, 2320 sr qqC \ A 8�
///3 ?iC f /S�fr:po. i` �` 2322 H HER 2//6 v 4. ,Og f2165 2152 .': 54 214
^ 2325..ti; Graham
Q• • 00. rrrrrr""""""!!!!!!
1136 \�Y �J�� "O 2120 O \/ l 11ia Y�°a0• NS,�NG 2I4
//30 }} = 1309�1 h fQ. 232 ��� :\� Haw River yl�' 6gGt,Fc.
'a 2121 Qsr it `n '.\� RL p4"Z/66 O 2151 2144 `A;
�/ x 232 2326 \ •oUDG Fs"
4 SAr`�`�ey1cF x
'///7 'PO s MT .E(ft r-2379 ,P t Graham Rt.2 C
I//3 3.-• p O r�?M Aif L m\ 2122 2/67 P 2142
//27 21/6FtRE 1 ORD 0. ry
7147 H
_ o y�R• MT o,•. 00 n' 2/45
s`si f s1 CH RpE4 NT 232/•� .O -.1 CFO,gR C �.\ 2/50 3 How Q-
H 2150 _
1122 0� //l8 `� /a 9 .� Am 2330 1 2391 2116 N_ _
-®--, n Y. qos 131r7 131E '�, y - RD. WMf7NEY Rt.l;
.. 0. Rurlinn� _gg-. ){ •Or_ _ v 87 2/76 V�2/7T\�'�'Y G9�"{"
i a 1 K I (_1
Up p , F• 9 ''Z 3 4
F' \ �2190 m 2189 21 NOPRO O 2/41 0
/i A:F 0 2331 ' o ?/j \ Z/Ol' SCh PD sj• Z/45
1(/1 %'0 /004 \9� 2176 NC Fy 2/7B�.. s
tE / 2147 ,,URCH R o
i 8LE//ZO RD.
�y1tj30E{ RO -IH195E62 j N RD,I-- Qy 2332 STONE. - Graham_ J -.•:. £.TEN' 1/46 .�
GO YS��..s SAXA PNAW ELEM\..fir aE1 H�: 0✓gRrF 4pST,. 2/45
.//1,9 /1/B J /6Or r 1 N(70 Posse °eo 100 2/7B ,131r���•\ SaxapahaW� RpS
4� TOM ✓EPEE. l Oa OS �� Z172 sue` SCHHAµ Graham Rt.2
"•Y F1RE ES / 2,327: ZF Af•PPP 1004 t12� 2174 - 2/48
4 4- ///7 S R 2171 2174
v 232/ 2328 -
1/!O ''rl T I 2334 , 2/71 2n5 -'
0
j'.. 0//09 2331,"I _"i•, I N RD-
r 1171 0 2563 Graham Rt.l HCGA z \ Cornor.rton
Snow Camp RD. '• "'
0 PJ Rt.2 m
�4 //08 2365 236 PYd / -
a 2335;
R D
RD A n
6c Rrl ER 2321 m CARL NO=N �oI Granam. 2336 9
1005 I PM4 Sr..Camp RL2� DI]ON 60 338 ELI \�
� ^'`LD�gT RD 23 7 G Rt.( - o WH ITHEY
1104 2363 OPg wH1Tf RD.
_ 23 V I i - 2/74 ELEM SCN
1.;N 1005 Po i1004 2356 2351 Graham Rt.l
1105 r 1005
RD. cy ay 2366 I CHAPEL 1005
�� 4'OF SCCF Z•363�� •''.` r _ L R0.
HILL
snow camp FIRE STA
9 re 1005 q0.1368 2327 I Z005 Fs 'TJ' . ,o RtI
oR0 s yF f o
r HILL1...- ?O GREENg9 �"•.. 7`,10 �}� D /003 Q 2139=o Mr84N
m 2365 -_ /005 z 13vf 1. 9 0 2338 ��e F2179 R0.
s Snow-666 RD a a Sutphin - q 23T9 2180-
o Snow Camp R1.2 237C ) ,,,„GRIFFIN ,- Snar Camv Rt.l FOyK
:t ;� 2373 SYLVAN N r 2359 µORKMAN 2356 Graham-
III ROGERS
or„ RO •SCH. RD. (FIRE STA RDRD 235 F
RD 2358 3S7 MA dOR '2348 HILL .2 r . �`'-d
( - o A 2348 tm rON Grancm
.• r-'I cs: GRIFFIN i R0. W10pW LDJ E,. y'T_ 2340 Rt.2
RT✓ - 2375 2371 D�OMEURD,369 ! rro RD i •� 1349 RD��m J003 _ 2132
2377 RO. 2386 SYL AN 3 pG4 91s 1 + PERRY
RD
t +� qRY
c Y
06 2378 = Q0. ESxH I-, k�NeUSH54 2354 - .� T3 .T�'- OMFS ft0. PE,
RD j /PRIG 2370 �• a,C RE) _ YYN,RD. 2345 "'0 2341 2104
� HT RO yr 4R .X1
2377 0 0
2370 I 23i/ 'Yb"' m aE 2347
. 237/ 4 M a 2352 3� 2356 Po - - o
C - 346 w Graham Rt.2
2372
2307 z a 2-569 e0 snow camp 2343 RU55
n R E i r"1 I R t.I J� 1003 2345

bZ f
1 �Af ip--' ' r• V
16
, yi$s-�
R ! a�.lam r .�a-. �� ��,` 1 � yc. ,� i5-I �� •' �F"�-' � :
n' .
f ♦y ^=L l+ 1"- 3s�zq s (J .:
`Y
If (j "T.6'. _
t ; - '� � ' '` � -�^�J - �iy •.��- � Vie. ,fr p4,��f�}- { ��. r 'ram} �z _ a � L„a
Ws.
''� _� 7�.K��1 -`F$� 2 .. •� '� ,, /�tj t r�• r {' ���+.)rri.�: -4� is v
,Ral,
1 i' a T t7 J ■ {I i _ •itj' �. ' 4
1�r {" E���a.•#H � { L �� � " j �� +tt ��w A x t,�.. 'r � n R I_ 4 j
:044 At
J tf #_SI. S 3�3s �r � RR'' �S� /� __r `. " �� �„ gam,' `•.
' ��•��SP - 1- � �.' � ate, r . 'IA 1-P
or
3 _-�� • fit�_ � --�;� r � �'�# �
�3M � c�)�{_.•R , F 4 F' atl i � Q ,f - r 1 r,-.".� � I d _ . ,+
v .�-A. � :'i ter.:• 1. � � f
WA-ST E A PPLICATIC3N FIELDB r;{ � �f_ ' t .<J IT ��• �� =A y
OV
TRACT # kcIZA
F I ELL r ACRE$. c
CA iF
bROPDGAST Tf1TAl C7
ACRES FOR.
'`;:'

-4,
K.
44
lsE, •_ ' ✓Fri- 1 ..1 i, �'
iA
am
ite
��^- _ .a w�xl..�_�• ,rk•'.ram ► � L''�`� 'a" �Y
yr7
rr'� �-
t`•;fan f s r
4 7 •". sr 1 a�, ; �f _ ,l,,� i •lam.
TRACT{ f p r L�] "
�+tab ' <: Z��j �a
a 3 � ` L D #
E
TOTAL ACRES
FOR TPf;CT
fJul I s •. _: s *�
I V 6J y ry uu
�� 6• �..� yp({� '�yrT,y z • %Y}. � `.},•Y'•�l �',lu• _ L' .II��;�, •
1S 777��� � y_T 7•�y
17 Mx y.
7
11 ye,
t v
yr• nOi - -. ���.-.- I f
`� �,-:n1rl ,jig } '.-k _ ra• a +r-•<�.:•i 3Y3*i .Y�it, P 1:2 s
.. �- '_5."!f� �yy"" .� _- �.Y�.7��. �'.��tv�l. �w.. -- �...4`.A� `�0 .- .. - .�_ .:.4`-•�-if..:,-.f {3'-: _. ... - _ �'r�'- c�__��.:.._ ..Fs�

y .f tea" ,y e¢.. -�' ! - `}_.�,.':�{i�•�.Y-q ti-' ~�i
=i• ^�•is�;;:r.•
R.
•� 4 `';T � ti` ^ �, Y• 4:��.•• ". _ ,1' 'wtaa"„'+ss'999 `+r - _
;y�� •�i=yr�i N�.:. ;�""•:',r.'-•.:_ sir ":� '��•!- -•.
�,,j�.f+ rf �G .r�:�. . .�'�i_..:_.r• _ ,��....- is � „rc�: •+ -
•: .f _r-may.. �:."'• :+i rF � "�
�� t•-. f _ �•:i_. Cam• ftFtl a '7 x •• .
CX�. .♦.i'�' _ .. 'r i� .:�.;��.a.•�";.�'f��li M.
Illy
MIT,E
t, o pryQws
1f �� � ham•• �f { ^'
r� e
�„• .� 'r'- :��.. _ � -.r.r• '-'� is-�: r �!f�'..
F,ma
2, 11
1 5i -. .
f� a tr - ?<:`.Y• •ti y � -: °_'�s. �:^
�y L' fib•;. .e���^,ai'ti�: •.r• ."3'::� ���� _ -
.may� .4=•,
*� '"`` + r: ti•��.�'..•.: cps
r� r � ����� if �; 1•�
►,.. �.� ;,�ij�r ��_���Y,�'y"'� '`i r•=r +�'r. .��.�• � �`` ''°•'� .���p• Cpry,•
--, ;S x• `cif• .';�'.�;
' 3
1. J

S+� �' E •ti'•�e•r- -
� ...; may; `':Ft .' - _ `��•'-},�It_ '�-
- �•� i�Ct Sly -�� �' .=7fF _ � ,���• --
•� f����,�'!•.7 ' .ss � .. l ..••'_' •`^c. ,. .,.fj,"t+,:.'�• - �_ •;1 r.y:},`-,�r•� Ys -,� •Y
f°-i±.� t+�^z'fv... — yg_.'ti- �, �� y#`.�i gas-�j��. ,~•' •�y�.;� .,�.
. r �' "�� .�f`(1 .+ram♦{}
ys►�,'iSq' . •, m --*�•..
01
ter, +, ' •�: t' Y� +s y� f. ,s -. � sO1 �3 . q y,`
ST
L � e•,,. - � �r-+sore. �� c.� ,f'��� t'.r�'q�+r+�s�T rT f 1� � ��+'!4 � t
a..•rt-, _ ... "� rr �r'A. ti'+Fslu.,, �'.;u a°S F -' A�$s�� -� t��,2 fj��[� a. +:
i� �r Y � Si � pT.;='�+. �t -} ;l�.•m `�t-y.•,�. A� w } h �� � � 'y J .�1� yi.
t R- � 9�..ti. 3R-�,�•A��� +�i.-YVk s�y„1jk� YYy -0. F 6�4, .LY - J t�Tj`e�'q'f'� .e `�ty '� �`Y-- i
,� ®0.i J'- 5 x$ � •apt �^`+•e K �j:••,.'�. ; p�`'�� �
r7�r�y Aw � rl°,a G S � � >'y� �k� �}� �"�,c t ,� .��'•�Ti �°�'g�
met � ' _ � ���- ." +' ;3 •�; � � '` 'q.'�� �t?A� �£ �.�+ �' 1 -1 t
�a may .•': W A 9 T E A Y F L_I i=fa T I f.7['! F-• I e,17
Ell
2- 7
J.
y- Y
- _ __ -
OP
A. --�� 4�2tY � J�-°� �-.�.'�..�y�•i�'�•a ; xrtk�+ .:'� � ri �_•._ �'�tdSye`E ._�
_#''rZ►E � - .r �. -.fir+ v ? 6=' �.

'�f r• _err � "I. - r+g :. +F t -�f—�lJ
k 1 4;;'��r� •_°� q+1 ;,� ?'il ���� _ 7 _`P T p � \-: x }i.- "Y'I
r L'� �s.' r-� •f'7�F `� ,:; � 'r u� r f 1 �f r'-- ��f'RK*,
IVt - y �.Ar f'�-•'its ,.: �'. - _ 4 f:..
�" 1Rr';r�`�ti' ��3.�� ci� '�'�+e+,'P�4f '�_ -� � � � 1:t. _.`-':�- -+:�.�•.
r
, l.,, a' Y-�' . 7'rFrr sc'(h+f" 4 /y n p }
•s .sr^ - i'1!6'' !� 'r...: .1 >� f �,:.��yr i,, gym.:�.. _ ;.ice• � �yl; � /! '
7
"I A. %
'r 't '� �• �t�� r ,� y-'�� { J'',SSf.�� �. ry �� tl.s: a "�i,lf!' �",3 -
IT
J V J h 4• "f';'��`1 `� .` R •,i V - •� ,�"� }Ter i. 4Y Y l x r
4c
Y 4•; _
VA
Ir
"t f in Os'
10%
WY
AF
i
LO AA
=J/�4 AK- �'� r� Y9• I�r� k .l. � i r 1-i �T -1
19
71.�r
p 3
.:.w:
9 —7 y
rt` �• 'a ys 1 '(LTA L TRPtC-r Actf,Z.5

United States Natural Resources 111 Jackson St.
Department of Conservation Yadkinville, NC
Agriculture Service 27055
July 17, 1997
Subject: ENG - A.D. Williard Dairy
Waste Irrigation System
Design Review
Alamance County, NC
Angela G. Jessup, PE
Civil Engineer
Natural Resources Conservation Service
530 West Innes Street
Salisbury, North Carolina 28144
Attached is a solid set irrigation system design for the A.D. Williard Dairy in
Alamance County. The system was designed by David Graham with Gra-Mac
Distributing Company, Advance, NC, to apply waste water from an existing waste
storage pond. The original design was completed in August, 1996 and submitted by
the Alamance Field Office for review in February, 1997. We requested Gra-Mac make
minor modifications which have been completed and are included in the enclosed
package.
We have reviewed the irrigation system design which appears to meet our
requirements for the NC ACSP. Please review the enclosed design package and review
notes to determine if this design package is acceptable for cost share approval.
Enclosed is a copy of our friction loss calculations for your convenience. If you have
any questions or if we can provide any further information, please let us know.
J. Tomm3 urchette Daphne M. Cartner, EIT
Civil Engineering Technician Division of Soil and Water Conservation
cc: T.H. Wetmore, Jr.
Concurred by: 4.0
Title: C.('.
Date: 9�z 5-'/4 7
Transmitted to Field Office: 7 If/26 1/ 977

IRRIGATION SYSTEM DESIGN PARAMETERS
Landownerloperator Name: A. D. Williard
County: Alamance
Address: 8152 Lindley Mill Rd
Graham NC 27253 Date: 8-16-96
Telephone: [phone]
TABLE - Field Specifications
Approximate Maximum
... Maximum Maximum Application
Useable Size Application per irrigation
Field of Field Slope Rate+ cycle4
Number z (acres) Soil Type (%) Crop(s) (rnthr) (inches) l comments_
1 I 7.9 I Orange ( 3 (Pasture/Fescue I .2 I .75
4 I Z.65 I Orange 3 IPas-ture/Fescue I .2 I .75
1 I I I
I I I I
•I• I I I -
!
I I I I
I I
'Table to be completed in its entirety by Field Office personnel and forwarded to the irrigation system designer.
ZSee attached map provided by the Field Office for field location(s).
'Total field acreage minus required buffer areas.
'Refer to N. C. Irrigation Guide, Field Office Technical Guide, Section II G. Annual application must not exceed the agronomic rates for the soil and crop used.
Irrigation Parameters USDA-NRCS
October 1995 page-1 North Carolina

TABLE 2 - Traveling Irrigation Gun Settings
Make,Model and Type of Equipment:
IT EQUIPMENT SETTINGS
Field No' Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate Effective Effective Diameter Diameter Pressure Pressure Are
Hydrant No (ftfmin) (inlhr) Width(ft) Length(ft) ` (feet) (inches) @ Gun tpsi} @ Reel(psi) Patters Comments
I
f
I I I I I
i
I I I I I
1
I
i
1
'See attached map provided by the Field Office for field location(s).
2Show separate entries for each hydrant location in each field.
'Use the following abbreviations for various arc patterns: F(full circle),TQ(three quarters),TT(two thirds), H (half circle),T(one third), Q (one quarter).
May also use degree of arc in degrees.
I
Irrigation Parameters USDA-MRCS
October 1995 page-2 North Carolina

TABLE 3 - Solid Set Irrigation Gun Settings
11qAe,
Model and Type of Equipment: Nelson F100 Guns with a .5 taper bore nozzle
OPERATING PARAMETERS
Field Nol Wetted Hydrant Spacing(ft) Application Nozzle Operating Operating
and Number of Diameter Along Between Rate Diameter Pressure Time
Line Noe Hydrants (feet) Pipeline Pipelines (inlhr) (inches) @ Gun(psi) @ Hydrant(hr) Comments
1,1 I 7 I 215 I 170 I 170 .18 .5 60 3
4,1 2 I 215 I 170 ( 170 .18 ( .5 I 60 3
4,2 2 215 I 170 I 170 I .18 I .5 60 I 3
I I I I I I
I
i I I i I I I I I •
i I I I I I
i
1
I I l I I I I
1 I I I
I I t
'See attached map provided by the Field Office for field location(s).
'Show separate entries for each pipeline with hydrants in each field.
Irrigation Parameters USDA-MRCS
October 1995 page- North Carolina

TABLE�4 - Irrigation System Specifications
Traveling Solid Set
Irrigation Gun 1 Irrigation
Flow Rate of Sprinkler(gpm) 55
Operating Pressure at Pump(psi) I 74
Design Precipitation Rate(inlhr) I , .18
Hose Length(feet) I XXXXXXXX
Type of Speed Compensation I I XXXXXXXX
Pump Type(PTO,Engine,Electric) I I Electric,
Pump Power Requirement(hp) I + 10
TABLE 5 - Thrust Block Specifications'
Designer may provide thrust block details on separate sheet.
t. THRUST BLOCK
LOCATION I AREA (sq.ft.)
90°Bend
" •y Dead End I 6
Tee I 6
Hydrants ( 6
Drains . 6
Ground Entry Pipes 6
See USDA-?ARCS Field Office Technical Guide,Section IV,Practice Ccde 430-DD.
Irrigation Parameters USDA-NRCS
October 1995 page-4 North Carolina

IRRIGATION SYSTEM DESIGNER
Name: David Graham
Company: Gra—Mac Distrihutin�- Companv
Address: 2310 NC A Y 801 N Mocksville NC 27028 171
Phone:
910-998-3232
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
Iocations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system..
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's spdcitcations for the irrigation pipe and/or USDA-I\'RCS standard for Irrigation Water Conveyance,
N.C. Field Office Technical Guide, Section IV, Practice Code 430-DD.
g, The information required by this form are the minimum requirements. it is the responsibility of the
designer to consider all relevant factors at a particular site and address them as appropriate.
g. Irrigation pipes should not be installed in lagoon or storage pond embankments without the'approval
of the designer.
DOTE: A buffer strip 25 feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per DEHNR-DEM Code Section 15A NCAC 2S .0200 -Waste Not Discharged to Surface
Waters.
USDA-MRCS
Irrigation Parameters North Carolina
October 1995 page-

a
Narrative of Irrigation System Operation
Describe the operation of the system in the space provided below or on a similar sheet most convinient to the designer/supplier.
Include procedures such as start-up, shut-down, winterization and regular maintenance of all equipment.
1 f
See attached sheets for additional specifications and oiperations informat'
Irrigation Parameters USDA•NRCS
October 1995 Page-6 North Carolina

Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE:ADVANCE EXCHANGE 2310 NC HWY. 801 N
1910) 996.3232
[phone] MOCKSVILLE, N. C. 27023
NC TOLL FREE 1-800-422-3560
Specifications Sheet
A. D. Williard
1. Acres under gun coverage is ± 6 acres.
2. System uses 2 Nelson F100 guns with a .5 taper bore nozzle.
3. Gun performance with a .5 taper bore nozzle is 55 GPM, .215' diameter @ 60 PSI.
4: Friction loss in 4" SDR21 PR200 gasketed PVC pipe is .28/1001 .
5. Liquid velocity in 4" SDR21 PR200 gasketed PVC pipe is 2.7 Ft/Sec.
6. Pressure .requirements are as follows:
Gun 60 PSI
1360' of 4" SDR21 PR200 PVC pipe 4 PSI
Elevation ± 10' 5 PSI
Miscellaneous 5 PSI
74 PSI
171 Head Feet
7. Application Rate is as follows:
96.3 x GPM _ 96.3 x 55 _ 5297 .18 In/Hr
Spacing x .8 (Dia. ) 170 x .8(215) 29240
8. Pump is a Berkeley B1-1/2TP(SL) 10HP, 3 Phase, Slurry Pump & Motor
9. Pump maximums are 175 GPM and 190 Head Feet.
10. Pump performance at 110 GPM is ± 175 Head Feet.

Design — Sales — Service
COMPLETE IRRIGATION SYSTEMS
TELEPHONE:ADVANCE EXCHANGE 2310 NC HWY.801 N
[phone] MOCKSVILLE, N. C. 27028
[phone]
NC TOLL FREE 1-800-422-3560
System Operation
A. D. Williard
System Start-Up
1. Attach gun cart to hydrant and open the hydrant valve.
2. Close ground entry gate valve.
3. Prime pump.
4. Start pump motor.
5. Open ground entry gate valve slowly.
6. After air has been purged from the system, open the ground entry gate
valve fully.
8. Make sure than no buffer zones are being violated.
System Shut-Down
1. Close ground entry gate valve to a slightly open position.
2. Turn of pump motor.
3. Move gun cart to next location and repeat system start-up.
4. If last pumping location, move gun cart to storage.
Winterization
1. Open all drains in the system. (pump, pipeline, etc. )
2. After all water is drained, close the pipeline drains.
3. Leave pump drain open to prevent freezing.
Maintenance
1. Follow all maintenance manuals supplied with the system.
2. Grease hydrant steiis at least annually.
3. Replace any damaged or worn parts as soon as possible.
3 2019
�� aterQuaiitid-wy
QmatlO'ft Section

S32401(l.' U) Nlaximum Working Pressure: 150 I'SI
1.........:.. ....._...... ..J:::::.:.. . ......
�'��[ I
N SkIR .....
...........
J?.__.._.I._._. . ::: 1: : :�... __ _.IMPC�I LGR,fMACk17.T. :
I ...............:.. :.......I.......... I...........:...:.:,..�._..:_.:.:.....:..,. 20 �
....... {..........I.......... ...I IR.. ...::'7/A)rU,.. 1 ...ry w
r......... .............I........ . . .
(::::.:::::.::.:.:: . ..........:........................ 1............ ,..:"a...,U!.:.::.':� LL
225," _..__•.•_...._�_.._..._ __ ............._... ..___..__ ._.4_.._MU7L37...... ,——
........ :..........f>0'I, ... .. ::.:......: 7. :: . M07G38'::'. S34238.... ':'.:.10
Li-9/Ir,..tln.•rtr).. .�65'%� �70%.• ...... .........:.��:� �.j .. .. .. ."'-i..:...:.. L..':':.'. �•�,10 .. .M07298 -• 1S32�IO
3 fS...... ..... I �... 1
zoo, r--•-•-•----..__ ._ ; T4 r-err r"r�r�r.. 1- ..._.- --.._..:.... .. .. ._I o �
. _
I':.. .. :.75i 674 j ..... :..... I" ..
r y,'...... `i ..:.I
w f ...... 73"/u.:: ..'.'I ........... ... . ::.....':....:
W 17� ._..._...a........... ..... . _._. _.... ..
,5 "1..._. __..__....... ........I...
........
I
,
a H f
_'W 150....._...... . .....:::
I
I
I:.
125 .........1::: ... . f
z
,.... . ; ... .. ..... 1. ...... ......•:. ski:.._.__..;+.:.... --I�... • ...1... i..
.. .:.I
J ._..-_...I........... ........_. .........�. ....... 1...... _.::..... . . , . . : i ..I
fj 100 , 1.......... :..L.. .. ::._:._::,
i'.`'...•'.... .....:.: ..... -. ) :_i.. ..
......:......a. :.I
.75 I .. :_....._x......_. : .._...a.._....._.i._......: e
` ....�..... .. I 9..... I .. f .... ..�j ..I ... ..�.. ... ...... ...... .........j...........q ... .......I...
SO ........... �_ ........I.. .......................... .......... '....__
1111 7 . , .......7 . .. . 1J.._.._. .1
: I
r.......... ...........,.. ......, ........
......
':......I ...................!._............._....._.!._......... _..........i... .:... .........i ,..._.......) _...._.._i _:......_..........
0 50 100 150 200 256 C N
CAPACITY IN U.S.GALLONS PER M
C•-RAAA oasaaon T-3957, -1, -2 s�oarxaaa: C-8888 nabs 12-7-83 o„a 7-30-85 MODEL B I i2T PM
i..
1

BIG GUN° PERFORMANCE TABLES U.S. UNITS
100 SERIES BIG GUNS - 240 TRAJECTORY"
100 T TAPER BORE NOZZLES
NozzIs Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle
'S" '.55" .6" .65" .7" .75" .8" .85" .9" 1.0"
P.S.I. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA.
xt $� h r1.5 ( .+t :: •" ni '� ; "sTc. z,,.. r
4F];,c:.:.,4.� 1.9d- �c� 202 13 -13},.(;;SiG?6�-...,rw22tr. ,9.1mw.,a:2aQ':�,w103.,k.Sa'Iiu240,af'r�-1,16,�;,�.��`2b0�,i3r.1.3:9<,;e,�;�258.5<ttis152.a-y�'..•„262,,,a����•;�,,.,,;.,.,,:v's�,;;,'
50 50 205' 64 215' 74 225' 87 235' 100 245' 115 256' 130 265' 150 273' 165 260' 204 300'
-- (fop
,A2
LT "3..:7 .44,,�r "�'S--;=nx- "O c- .rr.-„-r e• ate- + ^-^
b`0 2. B 2 ]1 a,+ ,.F iff9 6 ' S z 1,f060. :s«7627D:.�. 43.i t"28D �,Y(id,MNZb.B!>`sa1[32 ;.:y�A ,_ 31,6.ti„
70 60 225' 75 238 88 250 103 263' 120 275 136 283 155 295 177 302 197 310 243 338
2�B�.?-94�-�'a t28Q( a? ,awes 2r73,:, N1.28�_;s.,.a2B5. 1d8„, ,.r 2�5.;..;6165.,,. 3,0,5.,7; a 189? „ 37 lr,
90 66 245' 83 25B' 100 270' 117 283' 135 _ 295' 155 306' 175 315' 201 326' 223 335' 274 362'
1bD-ntLe72a�xfar &9`F '"w4208` ilkh'280n3.;12§.�1.; 272,,,+,T,338�.�. 235
170 76 265' 92 278' 111 290' 129 303' 150 315' 771 324' 195 335' 222 344' 247 355' 304 380'
'Available only with F100&SR-100.
100 R RING NOZZLES 100 DN DIFFUSER NOZZLES
PSI ,71 RING .77 RING .81 RING .86 RING .89 RING .93 RING .96 RING 0.5 ON 0.6 ON 0.7 ON 0.8 ON
GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA GPM DIA
$. �•. .�a. i ( �t•- 1• :t , �:.. a ,# :r - n ; - rt�. ! -
�a:'>30.�#"1+'�`.. .�VS::Y7s .5'�is�S�L 'Ca":��a+.+l'. ,ci,r,c:.-. ,]t 5.,..*�,ee-..k.,:-rr+nuV z..�.1r.:.rr.,v�:,.C�•+'.aix• ;"'�.�...:<tr.:r1,^<.,,ti:.57 s.16Q v:,w i..,c»u 78.ir.17,4t.�Y.SiaLL7,QQw'c1.88 u'2
40 66 208 78 212 91 215 103 224 •�118 235 134 235 152 242 45 154 66 168 91 182 118 196
M�I� �.s r_ .-0-A 30-z,,4f 7 - •m•..r,--.--'; ^r z - roc,
�Tr4�✓':$`2.2G"�}.}.88:�.225 ��3�'�:00�"230.aa,,s.�as:'1;.1,�2d7[..s.:r n,l.:129�250.J:�...,..150..255+� :..i"i.167..�260.1,a ,�+....6Q.a165.,.� .,.irn7_4. 1JG;rr,:x�:7Db,a�]90.�..., .",w:L13Qex�0.6.:
60 81 235 96 240 110 245 125 260 141 270 164 275 183 280 110 200 143 215
+�,r70,4�.r�ti82�: 1f14�U�S2S0�:�'1;1.. '260L'., ielr.1,327.5,.,i,d�c,152i,.290 i .v.�tJ7�L295�s_ .198.,:8t)O,.m: ;m,..0.,.�„ s_....,, ., . � "�,,.»a..,.. •� r�
_ 80 94 255 111 265 127 275 145 285 163 300 189 305 211 315y _ - _-
90as_..env 9,8w285- �1'1� 76 :tuj34 2 a .r�154,w295_s �M173310"i. ;kr.201'�315.> i,z224,E'325.k.% - T:_., T�:.,.,s.,s
100 105 270 124 280 142 295 162 305 182 320 212 325 236 335
tat r• .:tr•2?2 r335'�T �, :248T34 ';� p-
::1.lOw021410't 30 ' 1 83a�rk?, ]0 (315'�::b !191325
"The diameter of throw is approximately 3%loss for the 21"trajectory angle,6%loss for 16".
150 SERIES BIG GUNS - 240 TRAJECTORY"
150 T TAPER BORE NOZZLES
Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle Nozzle
.7" .8" .9" 1.0 1.1" 1.2" 1.3"
P.S.I. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA.
60e3 AO Oh�aiaS�i v s1�0' 7� f ?sa chl_85 �$.Q: i'1°ib1 v.2Q t 311 1ill'.;u°1,w�255�etia"f 330zw �i �.'i300%r t 34511 ':/la.3ap '"ww 60�xa'j:
60 110 265' 143 285' 182 305 225 325 275 345' 330 365 385 380
i"x'isL IT .ram-0 $ x11 - '6• � �.�x 97''x�-1�:T320.. 4 r_�..MdT. 4s?aA.. .3d0'r u.w�. .+..1;.29,St y 3GUsGu?,1:., .:w'.ri5 ;,x,380`«.x,hx a.x�,...;31.$ 39t�iw,..•.'si
80 126 290' 165 310, 210 335' _ 260 355 315 375 380 395 445 410
r90: M1 - 17 365r:..,,:..� .k 335.a Y390n,.Y. _4Q@ �� 70.: �aa.. 47p
µ 1 0'D`�,i ia�G 5 iZTD,74 lr
10D 143 310 185 330 235 355 290 375 355 400 425 420 500 440
^" 24`7r.,.ir_:.5- ,.,305.n.-.:w385�rr".YA a..v.._3�D.K r,.410�',ti ru.r n .�d4 ,; -43Q 6'.C<.•f: .5�25:. v,i �rua.'�`.:
J1 `r`s4" 1SQ,,.1 .1i 20♦a? »`.5"19 }�8 *R
120 157 330' 204 350' 258 375' 320 395' 385 420' 465 440' 545 460'
150 R RING NOZZLES
Ring Ring Ring Ring Ring Ring Ring
86" .97" 1.OB" 1.lB 1.26" 1.34" 1.41"
P.S.I. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA.
ti 4.1 00;"- '1:4245W' A. • 'f ..t s� rr 53°195 21 t 28$4r ti +J, 2Q$ h i 300,` I,::�r 255 Y. 32 '',' { µc 3Q0 Nr•,w3 �s�1 a'�,:Y+,s�;35. L:`�:$•� Gw
.,�s,1k �.44v� :fir;�f4 wi>o o: �:w'�%::�i. Q.�.r3• '��° is'''''
60 110 260' 143 280' t 182 300 225 315 275 335 330 350 385 365'
= rt�''l t �t�SaT"ZMn.rZ1 G4ki as s3A 99 �f37� u.. t 245:.Ya��330.a.j:sm <'St Z95"w e,35Dn, W c �5 & iv3'SSt-t_ .7 .1-• r'.�$0^a.
80 128 280' 165 300' 210 320' 260 340 315 360 380 380' 445 395
� 'fR'°"'vT�30�"'•`-�.., w�y2,7,5,'-`--;�3.5tl�?'_c��.:-„ti'3'ST�zC�.Y,O`?,,�x�.'r�`,,�• 40r',^,{-'.Ta�39d;;'rm '�v��7 s'x3,-.^7^w'4a?a"�'T-
a.;,�Ow;�.1`3�.��u�ak�^.4.��1Tc'�"�ass'` ",����ca� ,n.�a:t: u�r 3e:� ;,:..x,;"a"....;vr..3. t,a";. s.rv'3'.,- �•rr# vx'S1;.tea 4�..,:e. �..r..u;
100 143 300 185 320' 235 340 290 360 355 380' 425 400 500 415
1;10i �Is a 6YrL30� Gi� S j1. ia"�T24i1� Yc 35d r i+u.-:'30G Yiw�370?a kG 370 "390 a sr u4�G• .i14,1b .0 S1 4�$ r r
120 157 315' 204 335' 258 360' 320 380' 385 400' a65 420'L 545 435'
"The diameter of throw is approximately 3%less for the 21"trajectory angle.
200 SERIES BIG GUNS - 270 TRAJECTORY"
200 T TAPER BORE NOZZLES
Nozzle Nozzle Nozzle Nozzle Nozzle 46254845' 715
Nozzle Nozzle Nozzle
1.05" 1.1" 1.2" 1.3" 1.4" 1.6" 1.75" 1.9"
P.S.I. GPM DIA. GPM DIA. GPM DIA. GPM DIA. GPM DIA. IA. i GPM DIA. GPM DIA. GPM DIA.
` 1=80 'a'" i;1330` 73'+5A'"k�Elflr365rblyY3BR tA45 410r$ 3 . 'w.270 0'70 270 360' 310 380' 355 395' 415 410 4II0 430 50 630 465 755 a95 890 515'�T.C' '''_"A:� T ''4 ,t,.,r{9�!x •r?, +r77 . �" � i r "c"'rr'ram cam �,�,80 .529b37>K �330�r,39�' a5'38.Oz[�'�d'10,1wa-s-:4'� t 430 ;r, c 510 ._,450,xxirc 70 �i „�675,�,,,,!{8� 005 515;-a s,,.950,90 310 390' 350 410' 405 425 475 445 545 465' 85 715 505 �c•+855�z535 1005 555
Y1007a 7 2� 40 37 42(?i l , M 4 IRIU5 500a� 4601 I' 67,5 ';df37' G60 .r;500 755 .t,S20 900 550 106,0 ka751-
110 340 410' 390 430' 445 450 525 470 605 495' 695 515 791 535 945 5155, 1110 59,
Rc- 4 '-40T''1'4'40x:`i :465. 460.1v�,;y ;,5q5;4:„1180;:'r1�';y630r;'SD,ri``..r'< 5'�:725;�:,;i, 530,,;.,..k;,::825_�� :550, '„tt;985,;,<�58,0, �._,11¢O:;n�605_f�=
MA 485 due 2 ._ '1_74-
130 370 425' 425 445' 485 465' T. 565 4II5' 655 515' 75.5 540' 860 560' 1025 590' 1210 620' ..
200 R RING NOZZLES -
1 '/a"Ring 1 3/s"Ring 1 yz" Ring 1 %, Ring 1 a/a Ring 1 r�"Ring 2"Ring
(1.29"actual) 0.46"actual) (1,56"actual) (1.66"actual) (1.74"actual) (1.83"actual) (1.93"actual)
PS.I. GPM DIA. GPM DIA. GPM 01 GPM DIA. GPM DIA. GPM DIA. GPM DIA.
(i4�s 2.iDY. $5' 3Q • r`5 '350 f�i"37.b;�.:`2i:},5:rs_".dJO,.:.,.:1'390.."a'.":��:.Gsa:��iTA7.0�Is.,�.c'�._=.a05.i�s..%Y.z",:7;.Wt�53S:..,,:..''�.'•".i920`a=i;�f�S i.:T,��t,640 .::"'t,,d35'„'sy'ta
60 250 340' 330 370, 385 390 445 410 615 425' 585 440 695 455
in7U G'x�z 2Y�11kF35b b lw 1t Jl: J 'btY�r7ik6ti :•4A5[n.r.. vdBD 4253 :'x 555' ::A40``TW r.a 630at s ^irb455 1'u 755:,.. .�475��s:
80 290 370' 380 400' 445 420' 515 440' .590 455' 675. 470' .< 805 490'
.....tom._ 7•,•-..T- r..1
t M.- �..Z .�q�. "i'.t."'�':i:^`.:7-T'."'•f r i.,.-'.,..:,T• •i•;.i;iT y tii::;? i YY._''c'_
t.:..r;.•.,455u.:....nib.�.ti7,15.:,.<.r..485,L..x'• :t..:v..055,v4i::,..:5051....r..r
100 325 390, 425 425' Soo 44,, 575 465' 660 480, _ 755 500' 900 520'
..
120 355 410 465 445' 545 465 630 485' 725 500' 825 520' 985 545
13D: '� .3`lbs�na A 115 s 485?1� 4S)'.� . ;565 ?'-;470 K, 855:"i490."T� 755 505'T yr B60''. $25. '. 1025. -
"The diameter of throw is approximately 2%less for the 241 trajectory angle,5%less for the 21"trajectory angle.
The BIG GUN'"porlorm3nco data has been obtained under ideal lest conditions and may be adversely affected by wind,poor hydraulic entrance conditions or other factors.
Nelson Irrigation Corporation makes no representation regarding droplet condition,uniformity,or application rate.

IMPORTANT
WATER HAMMER —Spears Manufacturing Company, recommends that all PVC and CPVC plastic piping
�. systems be designed and constructed to AVOID EXCESSIVE WATER HAMMER. Water hammer can cause damage,
and failure to pipe, valves, and fittings within the piping system.
CAUTION—Spears Manufacturing Company DOES NOT RECOMMEND the use of thermoplastic piping products
for systems to transport or store compressed air or gases,or the testing of thermoplastic piping systems with compressed
air or gases in above and below ground locations. The use of Spears products in compressed air or gas systems
i automatically voids Spears warranty for such products, and their use against our recommendation is entirely the
responsibility and liability of the installer. Spears Manufacturing Company will not accept responsibility for damage or
impairment of its products, or other consequential or incidental damages caused by misapplication, incorrect assembly,
and/or exposure to harmful substances or conditions.
4
PLEASE NOTE—When temperatures rise above 73°F,the tensile strength of thermoplastics decreases,thereby
derating the pipe or fitting Maximum Internal Pressure. When temperatures fall below 73°F, the tensile strength of
thermoplastics increases, however,'the impact strength decreases. Maximum operating temperatures for PVC i in
systems should not exceed 140OF(110OF threaded systems). Maximum operating temperatures for CPVC i systems
in
should not exceed 200*F (150°F threaded systems). piping g y
THRUST BLOCKING —Water under pressure exerts thrust forces in piping systems. Thrust blocking should
be provided, as necessary, to prevent movement of pipe or appurtenances in response to thrust.
TYPE OF THRUST BLOCKINGowl
...+. _.•�. ;;
If thrusts, due to high pressure, are expected,
I. anchor valves as below. At vertical bends i r�
anchor to resist outward thrusts. "
1. Thru line connection, tee
2. Thru line connection, cross used as tee
3. Direction change, elbow
l �4. Change line size, reducer
5. Direction change, tee used as elbow
6. Direction change, cross used as elbow
7. Direction change 4 Q
8. Thru line connection, wye
9. Valve anchor '—
10. Direction change vertical, bend anchorYffl _ :';.�'•r;
11. End Caps (above or below ground)
Thrust blocking is required wherever the pipeline: Size and type of thrust blocking depends on:
* Changes direction (e.g., tees, bends, elbows and * Maximum system pressure
crosses) * Pipe size
* Changes size at its reducers * Appurtenance size
* Stops as it dead ends * Type of fittings o'r appurtenance
* Valves and hydrants, at which thrust develops * Line profile (horizontal or vertical bends)
when closed. * Soil type
MADE IN! THE 1 I..q.A.

�o
ENGINEERING, INC.
BOX 98, YOUNG AMERICA, MN 55397 (612) 467-3100
' Tltl-ACTI® THE IRRIGATION INDUSTRY'S ONLY
LOW COST COMBINATION ACTION
IRRIGATION VALVE WITH THESE FEATURES
VALVE ® PRESSURE RELIEF
U.S. Patent a VACUUM RELIEF
No. 3766941 a AIR RELIEF.'
FIELD PROVEN -.THOUSANDS IN USE
UNIQUE DESIGN allows installer to set
Pressure Relief feature in the field to
match PSI rating of PVC or Asbestos Cement
Line - Eliminates inventory problems.
INSTALLED ON ONE THREE-INCH NIPPLE-
IN ANY POSITION - Saves installation costs. 4a `
� xi
i• �f"=-'S' ii1'' '-
BODY IS AIRCRAFT-TYPE HIGH TENSILE :s y
aW. . .
ALUMINUM AND STEEL PARTS ARE PLATED
Provides long, trouble-free service.
lets"i,* �, � '' •.:f.tiY
tnry. yG 11jpEl t lJY
ZZ
CENTERLESS GROUND STEEL SPRING
allows instant free flow when PSI setting is
� r
exceeded - To protect against costly pipeline
repairs.
:,as,.u,
STOCK.NO. DESCRIPTION
TAV 100 HI-PRESSURE TRI-ACTION VALVE - calibrated from
50 to 130 PSI (can be used for pressures to 160 PSI).
Shipping Wt. 24 lbs.
TAV 101 LO-PRESSURE TRI-ACTION VALVE - calibrated from
0 ;- 50 PSI. Shipping Wt. 24 Ibs.