NC0048151_Permit Issuance_20071217

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Colleen H. Sullins, Director
Division of Water Quality
December 17, 2007
Mr. Willie Etheridge, III
Etheridge Seafood Company, Inc.
PO Box 77
Wanchese, North Carolina 27981
Subject: Issuance of NPDES Permit NCO048151
Etheridge Seafood Company W WTP
Dare County
Dear Mr. Etheridge:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated October 15, 2007 (or as subsequently amended).
This final permit includes no major changes from the draft permit sent to you on October 24,
2007.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30) days
following receipt of this letter. This request must be in the form of a written petition, conforming to Chapter
150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings (6714 Mail
Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision shall be final
and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or pennits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or Local
governmental permit that may be required. If you have any questions concerning this permit, please contact
Karen Rust at telephone number [phone], extension 361.
Sincerely,
AVV��
Coleen H. Sulfibs
cc: Central Files
Washington Regional Office/Surface Water Protection Section
NPDES Files I
't��ltCaro ma
dva1mnz447Y
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, North Carolina 27699-1617 Phone: [phone] Customer Service
Internet httipl/h2o.erustatem.us 512 N. Salisbury St. Raleigh, NC 27604 Fax: [phone]
An Equal Opportunity/Affirmative Action Employer

Permit No. NCO048151
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER (QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Etheridge Seafood Company, Inc.
is hereby authorized to discharge wastewater from a facility located at
Etheridge Seafood Company.
4561 Mill Landing Road
Wanchese, North Carolina
Dare County
to receiving waters designated as Mill Landing Creek in the Pasquatank River Basin in
accordance with effluent limitations, monitoring requirements, and other conditions set forth
in Parts I, II, III, and IV hereof.
The permit shall become effective February 1, 2008.
This permit and the authorization to discharge shall expire at midnight on December 31,
2012.
Signed this day December 17, 2007.
-'000'V
Coleen H. Sullins, Dire or
Division of Water Quality
By Authority of the Environmental Management Commission

Permit No. NCO048151
SUPPLEMENT TO PERMIT COVER SHEET
The exclusive authority to operate this facility arises under this NPDES permit. The
conditions, requirements, terms and provisions of this NPDES permit governs surface water
discharges from this facility. All previous NPDES Permits issued to this facility bearing this
permit number, whether for operation or discharge, are hereby revoked.
Etheridge Seafood Company, Inc. is hereby authorized to:
1. Continue to operate facilities. that discharge wastewaters from ice machine melt water
(Outfall 002), fish processing (Outfall 003), and fish packing/rinsing (Outfall 004) at the
Etheridge Seafood Company, 4561 Mill Landing Road, Wanchese, Dare County, and;
2. Discharge from said facilities via Outfalls 002, 003, and 004 into Mill Landing Creek, a
Class SC water in the Pasquatank River Basin, at the location specified on the attached
map.

7
vt
Zd�
TMmy
M k
Creek(O,
0
CZ;,
C)
—0 3
IrA
Daybe n
chese
Discharge Location Q-9
I TAuding
0 "Daybe
\V
\%
z
L Dayboaco"
3
y.
0
Quad: Oregon lnle% N.V NCO048151 Facility
Subbasin. 30151 Location
Latitude:,;60r'%,' Etheridge Seafood Company
Longitude'55"5TI0' WWTP
Receiving Stream: Mill Landing Creek SCALE 1:24000
Stream Class: SC North I

Permit No. NCO048151
A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting until expiration, the Permittee is authorized to discharge
Ice machine melt water from Outfall 002. Such discharges shall be limited and monitored by the Permittee as
specified below:
EFFLUENT
CHARACTERISTICS
EFFLUENT LIMITATIONS
MONITORING REQUIREMENTS
Monthly Average
Daily Maximum
Measurement
Frequency
Sample
Type
Sample
Location'
Flow
Annual
Estimate
E
Settleable Solids
15.0 ml/1
15.0 ml/l
Annual
Grab
E
pHz
I
Annual
Grab
E
Notes:
1. Sample locations: E- Effluent.
2. The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit No. NCO048151
A. (2). EFFLUENT LINIITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting until expiration, the Permittee is, authorized to discharge
fish processing wastewater from Outfall 003. Such discharges shall be limited and monitored by the Permittee as
specified below:
m q ,{ d
0
.... ...�-A y,.
1 �-/ ;.f*"LA^
. �%Y e.
a L EEI L i1tT " TATIO ,-
.i ry
•�• '.5.o' L" T a ,t.. Ne, 3
011iI O THE
i
r
'-� ;-ti?rs. _ r...'... te. "..'�i-''3i•_'%¢`7'
S
n 'R.;tr �k..^t`�'w.. .L' -
EFuF�IUEI�LT
�1 S• i •tl°r•$::.'�`k"X'i`J'Li: .. .`�i
��RA►CTERISTTICS
FfM
Moathlys Average 1rYitifS��
y
Y
`.ca
r [ :i ^ `Ti
y-�
LSL Yency -•e r. onx
Y�.�T:'•���. • X:—�
r..'-��L3f �St[�+lw
Flow
Monthly
Estimate
E
Total Suspended Solids
4.0 lbs/day
14.4 lbs/day
Monthly
Grab
E
Oil and Grease
1.10 lbs/day
4.0 lbs/day
Monthly
Grab
E
pH2
Monthly
Grab
E
Dissolved Oxygen3
Monthly
Grab
E
Notes:
1. Sample locations: E- Effluent.
2. The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units.
3. The daily effluent dissolved oxygen concentration shall not be less than 5.0 mg/l. .
Effluent Temperature. The effluent temperature shall not increase receiving water temperature by more than 0.8
degrees C (June -August) nor more than 2.2 degrees C (September -May). In addition, effluent temperature shall not
cause receiving water temperature to exceed 32 degrees C.
Best Management Practice (BMP) Requirements for Seafood Processing.
• There shall be no discharge of fish parts, floating solids, or visible foam in other than trace amounts.
• The permittee shall direct employees and provide resources to follow, at a minimum, the following practices
such that wastewater volume and wastewater constituents are reduced:
a) All hoses used to provide on demand water delivery shall be equipped with automatic shut-off
nozzles.
b) Personnel shall be instructed to eliminate flows through idle equipment.
c) All process and washdown equipment shall be fitted with high pressure/low volume nozzles.
d) Dry cleanup shall be preformed prior to washdown of the facility
Biocide Condition. There shall be no chromium, zinc or copper added to the treatment system except as
pre -approved additives to biocidal compounds. The Permittee shall obtain approval from the Division of Water
Quality's Aquatic Toxicology Unit (ATU) prior to the addition of any biocidal compound to the water discharged from
Outfall 003. Approval for use of new compounds (not previously approved) must be submitted to the ATU at least
90 days in advance of any planned use of those compounds.

Permit No. NCO048151
A. (3). EFFLUENT LINIITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting until expiration, the Permittee is authorized to discharge
fish packing/rinsing wastewater from Outfall 004. Such discharges shall be limited and monitored by the
Permittee as specified below:
�-y� e:rksrac �j
L-I_il
_; :"-r! ti .,z-.t
^.F'-•�iLl�
ISTIC�S��,
�~`��cat%n
x�4.F µpi., 4�" ��.. _,_ .a.. At�siM;
=i�r r ry _;
�, FRLUEL`111IIT.FiTIONS
�L Ppr••'?1�.aC,.4'
ONiRI1G'gLtIREMENTSpP�-
..�� �..i-^�".--J..�
yr�r�st•"r- 2++a-
Iolnremat3
.~ t-,'�1tl. _�
_ ;. �.y ,1 �".....��.
-7k�irT.i• ,a%a ��`L.] T''oCC
�,/.,,� Mr 't�Kr
�iy.
�s-.^
i<T�:.'.
�i...F ,di
-
;'��-..
Flow
Annual
Estimate
E
Total Suspended Solids
30.0 mg/1
60.0 mg/1
Annual
Grab
E
Settleable Solids
5.0 ml/1
10.0 ml/1
Annual
Grab
E
pHz
Annual
Grab
E
Dissolved Oxygen3
Annual
Grab
E
Notes:
1. Sample locations: E- Effluent.
2. The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units.
3. The daily effluent dissolved oxygen concentration shall not be less than 5.0 mg/1.
Effiuent Temperature. The effluent temperature shall not increase receiving water temperature by more than 0.8
degrees C (June -August) nor more than 2.2 degrees C (September -May). In addition, effluent temperature shall not
cause receiving water temperature to exceed 32 degrees C.
Best Management Practice (BMP) Requirements for Seafood Processing.
• There shall be no discharge of fish parts, floating solids, or visible foam in other than trace amounts.
• The permittee shall direct employees and provide resources to follow, at a minimum, the following practices
such that wastewater volume and wastewater constituents are reduced:
a) All hoses used to provide on demand water delivery shall be equipped with automatic shut-off
nozzles.
b) Personnel shall be instructed to eliminate flows through idle equipment.
c) All process and washdown equipment shall be fitted with high pressure/low volume nozzles.
d) Dry cleanup shall be preformed prior to washdown of the facility
Biocide Condition. There shall be no chromium, zinc or copper added to the treatment system except as
pre -approved additives to biocidal compounds. The Permittee shall obtain approval from the Division of Water
Quality's Aquatic Toxicology Unit (ATU) prior to the addition of any biocidal compound to the water discharged from
Outfall 003. Approval for use of new compounds (not previously approved) must be submitted to the ATU at least
90 days in advance of any planned use of those compounds.

PUBLIC NOTICE
STATE OF NORTH CAROUNA
ENVIRONMENTAL MANAGEMENT::
COMM ISSION/NPDES ,UNIT
MAIL SERVICE CENTER .'' '
-RALEIGH, NC 27609-1617
NOTIFICATION OF INTENT TO ISSUE
A NPDES WASTEWATER PERMIT
On.the basis of thorough staff review and
applica dh of Nc,,General Statute 143.21,
Public )aw 92-506i eimd other lawful stan-
dards ;and ; Keggulationsi the North , Carolina
Envlro"' rimd' al Management Commission
proposes to Issue -a National Pollutant Dis-
charge Eltinlhatlon"Systeni (NPDES) waste-
water,.; discharge ..permit. to, 4hq pegpp(s).
listed�belaia"effective 45 days from the pub-
lish.' ate'of.this`noticeivt�''t, cy� `}
Written�comTeents:regarding the Tposed
permit will' be accepted until ,30 days after
the publish:date'of this notice: Alfcomrnents
recelved 'prior to that date are considered in
the. final determ1hations regarding the pro-
posed.perMq. The:�Dlrsctor of the'NC Dlvi-
sion'of Water QUallty may dedde to hold.4
public meetin for. the proposed �pennii
should the, DIvlsion receive 'a significant
'degreeofioUblidInteresi.
Copies of, the; draft permit and. other sup=
porting Irifommatiori on files used to determine
conditions; present;In.the,draft;Offn .' are
available' upon request and payment of the
cost'of,reproduction. Mafl.comments -and/or
requests for Information to the NC Division
of • Water. Quafity, at the above address or
call Dina.�•Spdnide`(919)i�733-5083, exten-
sion ; r363. d : ;the;: Point Souicw Branch.
Pleasa Include: the, NPDES, permit 'number
(attached j'Iii'any-communicatFon''IMerested
persong1may.:atso- visit the Divislon.of Water
Quality at 512: N.,_Sa€lsbury.Street;. Raleigh,
NC 27664-1148 between the hours bf 8:00
a.m. and 5:00 p ni: to review information' on
file..
Tyrrell.,County;-� TyReli County: Reverse
Osmosis' Witter Treatment Plant, :168 South.
water= �Street,',,Cotumb4,-! IS16dW1C16rolina-
27925i.,has:e appIW.for1'i jhewal; of its
NPDES (NC0086924)"permit discharging to
Bill-,Bayriri they Pasq66t6hW,'Al06r-: Basin.
Some,metaia are W" 6te'rquality,limiteo in this
permit. Tf its �ischarge. may,. ect future ais-
charges l6this oq of the baslii
.,Captain �N'ell's eafood, Inc: (508 North
$treat: i3oad, Cotumbla,rNC)'fias spplied.for
renewal of, NPDES ,pgrrpit,NC0088234', dis-
to an unnamed_trlbtitaiji'td th" -Albemarle
Sound In te,PasquotantRiver Basin. pH is
water ,qualityt 11inqg":o-
is; discharge• may
,this portion, of the
receiving stream, :, .` , r
Mr ! Willid Etheridge,' III, (P.O. Box. 77.
Wagchese; NGs;29g1)s�has_# applied for
renewal, of,NPD,E4- permit„NC004$151 for
the. Etheridge Seafood:. Company WWTP in
Darej.. Canty f?This! perrnitteci' ;facility dis-
chargeswastewate��toM€Q,Landing Creek
In. the, PaagriotRrik River' basin.. This dis-
charge'may affect fut�ie�atiocahons in this'
portion of the Pasquotank River Basin,
NORTH CAROLINA
DARE COUNTY.
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said County
and State, duly commissioned, qualified, and authorized
by law to administer oaths, personally appeared
Su.s.an..M... Simp.snn.,..trRa.s.ur..er.......
...............................................who being
first duly sworn, deposes and says: that he (she) is of The
Times Printing Co., Inc., engaged in the publication of a
newspaper known as THE COASTLAND TWS, pub-
lished, issued, and entered as second class mail in the Town
of Manteo, in said County and State; that he is authorized to
make this affidavit and sworn statement; that the notice or
other legal advertisement, a true copy of which is attached
hereto, was published in THE COASTLAND TIMES on the
following dates:
. 0 ct-o.bar...2B.,...2.0.07............................
........................................................:
and that the said newspaper in which said notice,, paper,
document, or legal advertisement was published was, at
the time of each and every such publication, a newspaper
meeting all of the requirements and qualifications of Sec-
tions 1-596 and 1-597 of the General Statutes of North Caro-
lina and was a qualified newspaper within the meaning of
Section 1-597 of the General Statutes of North Carolina.
This ...11�i�ay'of.. December%op... ....., x c x 2007
Sworn to and!kiibscribed to before rp s ... Id."t.h... .
day of .... k ... .. ... .......
eceL
,,..,.. ., Y2" 2007
.Mnn
Notary Public
My Commission expires: ..A.W 9 u Pt - ,12 , ,

NCDENR / DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
Etheridge Seafood Company, Inc.
NPDES No. NCO048151
Facility Information
1. Facility Name:
Etheridge
Seafood
6. Pretreatment Program:
No
2. Permitted F1ow,MGD:
NA
7. County:
Dare
3. Facility Class:
NA
S. Regional Office:
Washington
4. Facility Status:
Existing
9. USGS Topo Quad:
D36SE
5. Permit Status:
Renewal
10. USGS Site:
Stream Choacteristics
1. Receiving Stream: Mill Landing Creek
2. Subbasin: 030151 S. Drainage Area (mi2):
3. Stream Index No.: 30-21-8 9. Summer 7Q 10 (cfs) TIDAL
4. Stream Class: SC 10. Winter 7Q10 (cfs):
5. 303(d) Listed: NO 11. 3OQ2 (cfs):
6. 305(b) Status: NA 12. Average Flow (cfs):
7. Use Support: 13. IWC (0r6):
PROJECT NOTES
Summary
• This is a permit renewal for a Minor Industrial operation (fish processing and packing)
located in Dare County. This is a fish packing facility with a small processing room to fillet
fish. Per the renewal application, there have been no changes since the last permit was
issued. The discharge is small and intermittent due to production.
• The facility discharges through three outfalls to Mill Landing Creek located adjacent to
Roanoke Sound in the Pasquatank River Basin (subbasin 030151). The receiving stream is
not listed as impaired on the 303(d) list, and there are no special basinwide permitting
strategies presented in the Pasquatank River Basin Plan. The receiving waters are used as
a harbor for commercial fishing vessels.
Permit Development
• The facility's renewal application was received July 2, 2007.
• Outfall 002 (ice machine melt water)- Maintain same permit requirements.
• Outfall 003 (fish processing). Maintain same permit requirements. Limit and monitor in
accordance with Effluent Guidelines (40 CFR 408.212- for TSS, Oil and Grease, pl-I) as well
as NC NPDES Seafood Processing and Packing Policy Memo (dated 1/5/93). Effluent
Guidelines are based on production. According to the permit renewal application, 2,000
lbs/day is the average amount processed. Effluent Guideline limits for TSS and O&G are
based on 2,000 lbs/day to develop Monthly Average Limits, and 4,000 lbs/day to develop
Daily Max Limits. Fish processing is subject to monthly monitoring.
• Outfall 004 (fish packing/rinsing)- Maintain same permit requirements. Limits and
monitoring are based on General Permit conditions for fish packing/rinsing, as well as NC
NPDES Seafood Processing and Packing Policy Memo (dated 1/5/93). Fish packing/rinsing
is subject to annual monitoring.

NPDES PERMIT FACT SHEET
Page 2
Etheridge Seafood Company, Inc.
NPDES No. NCO048151
DMR Data.
• Effluent Chemical/Physical Data. These are small discharges. There are two pH and DO
violations in 2005, but no violations in 2006 or 2007 (to August 2007).
• Effluent Toxicity Data. Not applicable.
Proposed Schedule for Permit Issuance
Draft Permit to Public Notice: 10/24/2007
Permit Scheduled to Issue: 12/ 12/2007
State Contact
If you have any questions on any of the above information or on the attached permit,
please contact Karen Rust at [phone], extension 361.
Copies of the following are attached to provide further information on the permit development:
• Draft Permit
NPDES Recommendation by:
Signature Date
Regional Office Comments
Regional Recommendation by:
Signature Date
Reviewed and accepted by
Regional Supervisor:
Signature
Date
NPDES Unit Supervisor:
Signature
Date
Page 2
Version: October 18, 2007

§ 408.207
pollutant properties controlled by this
section which may be discharged to a
publicly owned treatment works by a
new source subject to the provisions of
this subpart:
Pollutant or pollutant property Pretreatment standard
GODS .............................................. No limitation.
TSS................................................. Do.
PH................................................... Do.
Oiland grease ................................ Do.
[40 FR 55787, Dec. 1, 1975, as amended at 60
FR 33945, June 29, 1995)
§ 408.207 Effluent limitations guide-
lines representing the degree of ef-
fluent reduction attainable by the
application of the best conventional
pollutant control technology.
(a) [Reserved]
(b) Except as provided in §§ 125.30
through 125.32, any Alaskan bottom
fish processing facility located in popu-
lation or processing centers including
but not limited to Anchorage, Cordova,
Juneau, Ketchikan, Kodiak, and Pe-
tersburg shall achieve the following ef-
fluent limitations representing the de-
gree of effluent reduction attainable by
the application of the best conven-
tional pollutant control technology
(BCT): The limitations shall be the
same as those specified for conven-
tional pollutants (which are defined in
§ 401.16) in § 408.202(b)(2) of this subpart
for the best practicable control tech-
nology currently available (BPT).
[51 FR 24998, July 9, 19861
Subpart U—Non-Alaskan Conven-
tional Bottom Fish Processing
Subcategory
SOURCE: 40 FR 55788. Dec. 1, 1975, unless
otherwise noted.
§ 408.210 Ap]plicability; description of
the non -Alaskan conventional bot-
tom fish processing subcategory.
The provisions of this subpart are ap-
plicable to discharges resulting from
the processing of bottom fish outside of
Alaska in which the unit operations
are carried out predominately through
manual methods. However, the use of
scaling machines and/or skinning ma-
chines are considered to be normal
practice within this subcategory. The
40 CFR Ch. 1 (7-1-06 Edition)
provisions of this subpart apply to the
processing of currently, commercially
processed species of bottom fish such
as flounder, ocean perch, haddock, cod,
sea catfish, sole, halibut, and rockfish.
These provisions apply to existing fa-
cilities processing more than 1816 kg
(4000 lbs) of raw material per day on
any day during a calendar year and all
new sources.
§ 408.211 Specialized definitions.
For the purpose of this subpart:
(a) Except as provided below, the gen-
eral definitions, abbreviations and
methods of analysis set forth in part
401 of this chapter shall apply to this
subpart.
(b) The term seafood shall mean the
raw material, including freshwater and
saltwater fish and shellfish, to be proc-
essed, in the form in which it is re-
ceived at the processing plant.
§ 408.212 Effluent limitations guide-
lines representing the degree of ef-
fluent reduction attainable by the
application of the best practicable
control technology currently avail-
able.
Except as provided in §§ 125.30
through 125.32, any existing point
source subject to this subpart shall
achieve the following effluent limita-
tions representing the degree of efflu-
ent reduction attainable by the appli-
cation of the best practicable control
technology currently available (BPT):
Effluent limitations
Average of daily
Effluent characteristic Maximum values for 30
for any 1 consecutive days
day shall not ex-
ceed—
Metrk units (Idlograms per
1,000 kg of seafood)
TSS...................................... 3.6 2.0
Oil and grease ..................... 1.0 0.55
PH........................................ (') (1)
English units (pounds per
1,000 lb of seafood)
TSS...................................... 3.6 2.0
Oil and grease ..................... 1.0 0.55
PH ...... , ,
I Within the range 6.0 to 9.0.
(40 FR 55788, Dec. 1, 1975, as amended at 41
FR 31822, July 30, 1976; 60 FR 33945, June 29,
1995)
144

Environmental Protection Agency
§ 408.213 [Reserved]
§ 408.214 Pretreatment standards for
existing sources.
Any existing source subject to this
subpart that introduces process waste-
water pollutants into a publicly owned
treatment works must comply with 40
CFR part 403. In addition, the following
pretreatment standard establishes the
quantity or quality of pollutants or
pollutant properties controlled by this
section which may be discharged to a
publicly owned treatment works by a
§408.220
§ 408.216 Pretreatment standards for
new sources.
Any new source subject to this sub-
part that introduces process waste-
water pollutants into a publicly owned
treatment works must comply with 40
CFR part 403. In addition, the following
pretreatment standard establishes the
quantity or quality of pollutants or
pollutant properties controlled by this
section which may be discharged to a
publicly owned treatment works by a
new source subject to the provisions of
this subpart:
point source subject to the provisions Pollutant or pollutant property Pretreatment standard
of this subpart.
BODS.............................................. I No limitation.
TSS................................................: I Do.
.............................................. No limitation. Pollutant or pollutant property Pretreatment standard PH ...................
BOD5Oil and grease ............................... Do.
TSS................................................. Do.
PH ................................................... Do. [40 FR 55788, Dec. 1, 1975, as amended at 60
Oil and grease ................................ Do. FR 33945, June 29, 1995]
[40 FR 55788, Dec. 1, 1975, as amended at 60
FR 33945, June 29, 1995]
§ 408.215 Standards of performance for
new sources.
The following standards of perform-
ance establish the quantity or quality
of pollutants or pollutant properties,
controlled by this section, which may
be discharged by a new source subject
to the provisions of this subpart:
Effluent limitations
Average of daily
Effluent characteristic Maximum values for 30
for any 1 consecutive days
day shall not ex-
ceed—
Metric units (kilograms per
1.000 kg of seafood)
GODS ................................... 1.2 0.71
TSS...................................... 1.5 0.73
Oil and grease ..................... 0.077 0.042
PH ........................................ (') (1)
English units (pounds per
1.000 tb of seafood)
BOD5............................ .......1.2 0.71
TSS...................................... 1.5 0.73
Oa and grease ..................... 0.077 0.042
PH........................................ (') (r)
I Within the range 6.0 to 9.0.
[40 FR 55788, Dec. 1, 1975, as amended at 41
FR 31823, July 30, 1976]
§ 408.217 Effluent limitations guide-
lines representing the degree of ef-
fluent reduction attainable by the
application of the best conventional
pollutant control technology (BCT).
Except as provided in §§ 125.30
through 125.32, any existing point
source subject to this subpart shall
achieve the following effluent limita-
tions representing the degree of efflu-
ent reduction attainable by the appli-
cation of the best conventional pollut-
ant control technology (BCT): The lim-
itations shall be the same as those
specified for conventional pollutants
(which are defined in § 401.16) in § 408.212
of this subpart for the best practicable
control technology currently available
(BPT).
[51 FR 24997, July 9, 19861
Subpart V—Non-Alaskan Mecha-
nized Bottom Fish Processing
Subcategory
SouRcE: 40 FR 55789, Dec. 1, 1975, unless
otherwise noted.
§ 408.220 Applicability; description of
the non -Alaskan mechanized bot-
tom fish processing subcategory.
The provisions of this subpart are ap-
plicable to discharges resulting from
the processing of bottom fish outside of
Alaska in which the unit operations
145

co,r
Willie R Etheridge Seafood Co., Inc
P. O. Box 77
4561 Mill Landing Rd
Wanchese, NC 27981
252-473-5272 fax [phone]
Mrs. Carolyn Bryant "
NC DENR / DWQ
Point Source Brach
1617 Mail Service Center
Raleigh, NC 27699-1917
Dear Mrs. Bryant,
We are requesting the renewal of the NPDES Permit NC0048151 we
have had no changes to our facility since the last permit was issued.
Thank you,
s

NPDES PERNIIT APPLICATION - SHORT FORM C-Seafood
For seafood processing facilities with a discharge <I MGD
I oment and Natural Resources
N. C. Department of Env rn
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
http://h2o.enr.state.nc.us/NPDES/
NPDES Permit Number NC§ S
1. Contact Information:
Facility Name
Owner Name
Street Address
City
State. / zip Code
Telephone Number
Fax Number
e-mail Address
Operator Name
Street Address
City
State / zip Code
County
Telephone Number
Please print or type
V. 27'MsI
( 252) q-73 - 5 2--7 2-
(25z) -r
2. Location of facility producing discharge:
Check here if same as above
Facility Name (if different from above)
Street Address or State Road
City
State / zip Code
County
3, ownership Status:
Federal ❑ State ❑
4. Standard Industrial Classification (SIC) code(s):
Private Public ❑
Canned/Cured Fish & Seafood (2091) ❑ /
Prepared Fresh or Frozen
5. Number of employees:
Fish & Seafood (2092)
6. Number of separate discharge points:
pack seafood? ((f you only pack seafood, you may be eligible for
7, co you process seafood and/or p
coverage under a general permit -please caul the NPDES Unit at 919-733-5083): Q
Process
❑ Pack Only Process and Pack
Version -02/04
Page 1 013

COPYNPDES PERMIT APPLICATION - SHORT FORM C-Seafood
For seafood processing facilities with a discharge <1 MGD
B. Facility Operations: (check all that apply)
Product a.. :' } !. ; f,.
Check
if applicable
l t,> i'e ii Outfall number
i(CY:i i
Breaded Shrimp
Non -Breaded Shrimp
Manually Processed Blue Crab
Mechanically Processed Blue Crab
Hand -Shucked Clam Processing
Mechanically -Shucked Clam Processing`
Scallop Processing
Fish Meal Processing
Manually Processed Bottom -Fish
Mechanically Processed Bottom -Fish
Hand -Shucked Oyster Processing
Mechanically -Shucked Oyster Processing
Other (Specify)
9. Production:
Outfall ..-.
.;... ,. Raw.Mato
�° v'n9 �pDH
�p3
(Report gross weight 4f $P
on' to:'processing-
Exception': rorV sfers and'scallo a=te
bwel tafter
processing.)
Average pounds per
Day Processed
Average pounds per
7X
Month Processed
Average pounds per
S4`
Day Packaged
Average pounds per
Month Packs ed
Check here if discharge occurs all year or list the month(s) in which discharge occurs:
Number off{days per week discharge occurs:
pill
1-P Niel r^�° , c „i- ga • d
�SR�� {�I
gross�iigIXta,�
i..•:.
tg ,roCessing.
.. .
as
?-
Each. or sfers and scallo :re o :
- ioduct.wei t slier
rocessln
Average pounds per
Day Processed
Average pounds per
Month Processed
Average pounds per
Day Packs ed
Average pounds per
Month Packaged
Check here if discharge occurs all year or list the month(s) in which discharge occurs:
Number of days per week discharge occurs:
For listing additional outfalls, duplicate this page and correct the outfall number.
NOTE: If the facility has separate discharge points (outfalls) or multiple industrial processes,
include a schematic diagram of wastewater flow at the facility.
Page 2 of 3 Version -02iO4

COPYPDES PERMIT APPLICATION - SHORT FORM C-Seafood
For seafood processing facilities with a discharge <1 MGD
8. -Facility Operations: (check all that apply)
Product i::: >,.. + :,
,.- .;7;
�het:k3',�id
if lica_ e
, _;t,��.,� �Otitfall number s`. 'i
e� ,tct+,
Breaded Shrimp
Non -Breaded Shrimp
Manually Processed Blue Crab
Mechanically Processed Blue Crab
Hand -Shucked Clam Processes
Mechanically -Shucked Clam Processing
Scallop Processes
Fish Meal Processes
Manually Processed Bottom -Fish
Mechanically Processed Bottom -Fish
Hand -Shucked Oyster Processes
Mechanically -Shucked Oyster Proc sin
Other (Specify)
9. Production:
j
M?q6
i2aw}13afetj
f
r e
*
gross"}vefgfit of cif
r to processing.
'
r In
is and 3a�lo`'
d cvei tit after rocessit'it
Average pounds per
Day Processed
Average pounds per
Month Processed
Average pounds per
Day Package
Average pounds per
!Ir
94�VV
Month Packaged
Check here if discharge occurs all year
or list the month(s) in which discharge occurs:
Number of days per week discharge occurs:
MM",n�q/
oM®rrteYs
,gr09,E
anft'o
> we r roc s'
e
Average pounds per
Day Processed
---.--..---
Average pounds per
Month Processed
Average pounds per
Dav Package
Average pounds per
Month Packaged
Check here ff discharge occurs all yearLl
or list the month(s) in which discharge occurs:
Number of days per week discharge occurs:
For listing additional outfalls, duplicate this page and correct the outfall number.
NOTE: If the facility has separate discharge points (outfalls) or multiple industrial processes,
include a schematic diagram of wastewater flow at the facility.
Page 2 of 3 Version -02104

COPY NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
For seafood processing facilities with a discharge <1 MGD
10. Types of wastewater discharged to surface waters only:
Type
Average Flow
(GALLONS PER OPERATING MONTH)
Sanitary - monthly average
Cooling water - monthly average
Process water - monthly average
f ©�
Packing Water - monthly average
Other - (Please Specify)
11. Name of receiving stream(s) (Provide a map showtng the exact location of each oug'aw
M;(( L6fndIhjC(-ec'4 -- UAR130K
12. List all permits, construction approvals and/or applications (check all that apply and provide permit
numbers or check none ( not applicable):
I ie
Permit Number
Woe Permit Number
0
None
O
Non -Attainment
L]
U1C
O
Ocean Dumping
O
NPDES (� L4 D is
I t]
Dredge/Fill Permits
PSD
RCRA
NESHAPS
Other
13.
Are any of the following substances
added as a result of your operations, activities, or processes?
(Check all that apply):
Blocides for Algal Control ❑
Chlorine/Bleach
❑ Other (please specify) ❑
14. Is this facility located on Native American lands? (check one)
YES ❑ NO Lr I
I certify that I am familiar with the information contained in the application and that to the best of my
knowledge and belief such information is true, complete, and iacte.
i n -Ii*i- 7 cCy'�8l
CT,.. -.�. i� Ye— ,,
Printed note of Persgn-5igning M /l Title
North Carolina General Statute 143.215.6 fb)(2) provides that: Any person who knowingly makes any false statement
representation, or certification in any application, record, report, plan, or other document files or required to be maintained
under Article 21 or regulations of the Environmental Management Commission implementing that Article, or who falsifies.
tampers with, or knowingly renders inaccurate any recording or monitoring device or method required to be operated or
maintained under Article 21 or regulations of the Environmental Management Commission Implementing that Article, shall be
guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by imprisonment not to exceed six months, or by both.
(18 U.S.C. Section 1001 provides a punishment by a nne of not more than $10,000 or imprisonment not more than 5 yearns, or
both, I -or a similar offense.)
Page 3 of 3 Version -WO4

C
' 3,4S
r -I
u
�00,
I
F

6 •
FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date
Val, //,
Permit Number
g4pr
Facility Name
Basin Name/Sub-basin numbers
? , 01. Si
Receiving Stream
,, %&Du vid-
SG
Stream Classification in Permit
Does permit need NH3 limits?
Does permit need TRC limits?
Does permit have toxicity testing?
1140
Does permit have Special Conditions?
Does permit have instream monitoring?
Is the stream impaired on 303 d list)?
Any obvious compliance concerns?
Any permit mods since lastpermit?
Existing expiration date
121.31) &
New ex iration date
New permit effective date
Miscellaneous Comments
YES This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
name/ownership changes). Include conventional WTPs in this group.
YES_ This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 303(d)
listed, toxicity testing, instream monitoring, compliance concerns, phased
limits). Basin Coordinator to make case -by -case decision.
NO This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS,
etc) ,
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)