990031_Compliance Evaluation Inspection_20191216

Division of Water Resources
❑ Division of Soil and Water Conservation
❑ Other Agency
Facility Number: 990031 Facility Status: Active Permit: AWS990031 ❑ Denied Access
Inspection Type: Compliance Inspection Inactive Or Closed Date:
Reason for Visit: Routine County: Yadkin Region: Winston-Salem
Date of Visit: 12/16/2019 Entry Time: 10:00 am Exit Time: 11:20 am Incident#:
Farm Name: Loyd Ray Farms, Inc. Owner Email:
Owner: Loyd Bud Bryant Phone: [phone]
Mailing Address: 2049 Center Rd Boonville NC 27011
Physical Address: Casstevens Rd Yadkinville NC 27055
Facility Status: 0 Compliant ❑ Not Compliant Integrator: L&H
Location of Farm: Latitude: 36' 10'00" Longitude: 80'42'30"
From Yadkinville,take Hway 601 North,left on Haire Road,right on Center Road(SR1331), right on Cass Stevens Road
(SR1375),farm approx.4000 ft on right
Question Areas:
Dischrge&Stream Impacts Waste Col,Stor,&Treat Waste Application
Records and Documents Other Issues
Certified Operator: William L Bryant Operator Certification Number: 21378
Secondary OIC(s):
On-Site Representative(s): Name Title Phone
24 hour contact name Loyd Bryant 336-468-1729
On-site representative Andrew Combs
Primary Inspector: Rebecca D Chandler Phone: [phone]
Inspector Signature: Date:
Secondary Inspector(s):
Inspection Summary:
25.Sludge survey due by end of the year.Consultant has been hired,DWR staff met consultant during inspection and discussed
the process and neccesary information to collect for the survey.
24. Irrigation calibration due in 2020.
21.Soils completed 11/8/2018,due again 2021.
Loyd wishes to have digester and aeration basins closed out with pulling the innovative system out,does not want additional
storage.
Andrew Combs(Loyds nephew)seeking to get operator certification, DWR to send information on class.
Gun nozzles both measured at 1.29 during inspection.
Page 1 of 5

Permit: AWS990031 Owner: Loyd Bud Bryant Facility Number: 990031
Inspection Date: 12/16/19 Inspection Type: Compliance Inspection Reason for Visit: Routine
Regulated Operations Design Capacity Current promotions
Swine
Swine-Feeder to Finish 8,640 I 6,638
Total Design Capacity: 8,640
Total SSLW: 1,166,400
Waste Structures
Effective Built Closed Designated Observed
Type Identifier Date Date Date Freeboard Freeboard
Lagoon LAGOON 05/26/2005 36.00
Page 2 of 5

Permit: AWS990031 Owner: Loyd Bud Bryant Facility Number: 990031
Inspection Date: 12/16/19 Inspection Type: Compliance Inspection Reason for Visit: Routine
Discharges&Stream Impacts Yes No NA NE
1. Is any discharge observed from any part of the operation? ❑ ❑ ❑
Discharge originated at:
Structure ❑
Application Field ❑
Other ❑
a.Was conveyance man-made? ❑ 0 ❑ ❑
b. Did discharge reach Waters of the State? (if yes, notify DWQ) ❑ 0 ❑ ❑
c.What is the estimated volume that reached waters of the State(gallons)?
d. Does discharge bypass the waste management system? (if yes, notify DWQ) ❑ 0 ❑ ❑
2. Is there evidence of a past discharge from any part of the operation? ❑ 0 ❑ ❑
3.Were there any observable adverse impacts or potential adverse impacts to Waters of the ❑ 0 ❑ ❑
State other than from a discharge?
Waste Collection, Storage&Treatment Yes No NA NE
4. Is storage capacity less than adequate? ❑ 0 ❑ ❑
If yes, is waste level into structural freeboard? ❑
5.Are there any immediate threats to the integrity of any of the structures observed (Le./large ❑ M ❑ ❑
trees, severe erosion, seepage, etc.)?
6.Are there structures on-site that are not properly addressed and/or managed through a ❑ MEI ❑
waste management or closure plan?
7. Do any of the structures need maintenance or improvement? ❑ MEI ❑
8. Do any of the structures lack adequate markers as required by the permit? (Not applicable ❑ 0 ❑ ❑
to roofed pits,dry stacks and/or wet stacks)
9. Does any part of the waste management system other than the waste structures require ❑ 0 ❑ ❑
maintenance or improvement?
Waste Application Yes No NA NE
10.Are there any required buffers, setbacks, or compliance alternatives that need ❑ 0 ❑ ❑
maintenance or improvement?
11. Is there evidence of incorrect application? ❑ 0 ❑ ❑
If yes, check the appropriate box below.
Excessive Ponding? ❑
Hydraulic Overload? ❑
Frozen Ground? ❑
Heavy metals(Cu, Zn, etc)? ❑
PAN? ❑
Is PAN > 10%/10 lbs.? ❑
Total Phosphorus? ❑
Failure to incorporate manure/sludge into bare soil? ❑
Outside of acceptable crop window? ❑
Evidence of wind drift? ❑
Application outside of application area? ❑
Crop Type 1 Millet
Page 3 of 5

Permit: AWS990031 Owner: Loyd Bud Bryant Facility Number: 990031
Inspection Date: 12/16/19 Inspection Type: Compliance Inspection Reason for Visit: Routine
Waste Application Yes No NA NE
Crop Type 2 Fescue(Hay)
Crop Type 3
Crop Type 4
Crop Type 5
Crop Type 6
Soil Type 1
Soil Type 2
Soil Type 3
Soil Type 4
Soil Type 5
Soil Type 6
14. Do the receiving crops differ from those designated in the Certified Animal Waste ❑ 0 ❑ ❑
Management Plan(CAWMP)?
15. Does the receiving crop and/or land application site need improvement? ❑ 0 ❑ ❑
16. Did the facility fail to secure and/or operate per the irrigation design or wettable acre ❑ 0 ❑ ❑
determination?
17. Does the facility lack adequate acreage for land application? ❑ 0 ❑ ❑
18. Is there a lack of properly operating waste application equipment? ❑ 0 ❑ ❑
Records and Documents Yes No NA NE
19. Did the facility fail to have Certificate of Coverage and Permit readily available? ❑ 0 ❑ ❑
20. Does the facility fail to have all components of the CAWMP readily available? ❑ 0 ❑ ❑
If yes, check the appropriate box below.
WUP? ❑
Checklists? ❑
Design? ❑
Maps? ❑
Lease Agreements? ❑
Other? ❑
If Other, please specify
21. Does record keeping need improvement? ❑ ❑ ❑
If yes, check the appropriate box below.
Waste Application? ❑
Weekly Freeboard? ❑
Waste Analysis? ❑
Soil analysis? ❑
Waste Transfers? ❑
Weather code? ❑
Rainfall? ❑
Stocking? ❑
Crop yields? ❑
Page 4 of 5

Permit: AWS990031 Owner: Loyd Bud Bryant Facility Number: 990031
Inspection Date: 12/16/19 Inspection Type: Compliance Inspection Reason for Visit: Routine
Records and Documents Yes No NA NE
120 Minute inspections? ❑
Monthly and 1" Rainfall Inspections ❑
Sludge Survey ❑
22. Did the facility fail to install and maintain a rain gauge? ❑ 0 ❑ ❑
23. If selected, did the facility fail to install and maintain a rainbreaker on irrigation equipment ❑ ❑ 0 ❑
(NPDES only)?
24. Did the facility fail to calibrate waste application equipment as required by the permit? ❑ 0 ❑ ❑
25. Is the facility out of compliance with permit conditions related to sludge? If yes, check the ❑ ❑ ❑
appropriate box(es)below:
Failure to complete annual sludge survey ❑
Failure to develop a POA for sludge levels ❑
Non-compliant sludge levels in any lagoon ❑
List structure(s)and date of first survey indicating non-compliance:
26. Did the facility fail to provide documentation of an actively certified operator in charge? ❑ ❑ ❑
27. Did the facility fail to secure a phosphorous loss assessment(PLAT)certification? ❑ ❑ ❑
Other Issues Yes No NA NE
28. Did the facility fail to properly dispose of dead animals within 24 hours and/or document ❑ 0 ❑ ❑
and report mortality rates that exceed normal rates?
29.At the time of the inspection did the facility pose an odor or air quality concern? If yes, ❑ 0 ❑ ❑
contact a regional Air Quality representative immediately.
30. Did the facility fail to notify regional DWQ of emergency situations as required by Permit? ❑ 0 ❑ ❑
(i.e., discharge,freeboard problems, over-application)
31. Do subsurface tile drains exist at the facility? ❑ 0 ❑ ❑
If yes, check the appropriate box below.
Application Field ❑
Lagoon/Storage Pond ❑
Other ❑
If Other, please specify
32. Were any additional problems noted which cause non-compliance of the Permit or ❑ 0 ❑ ❑
CAW M P?
33. Did the Reviewer/Inspector fail to discuss review/inspection with on-site representative? ❑ 0 ❑ ❑
34. Does the facility require a follow-up visit by same agency? ❑ 0 ❑ ❑
Page 5 of 5