The URL can be used to link to this page

Home My WebLink AboutNCG500307_Complete File - Historical_20161129�0"50 PAT MCCRORY Water Resources ENVIRONMENTAL QUALITY November 29, 2016 Mr. George Freeman Glenoit Fabrics 3001 N Main St Tarboro, NC 27886 DONALD R. VAN DER VAART \icI,k1I1 S. JAY ZIMMERMAN Subject:Rescission of Certificate of Coverage NCG500307 Glenoit Fabrics Edgecombe County Dear Mr. Freeman: Division staff has confirmed that the subject Certificate of Coverage (CoC) is no longer required. Therefore, in accordance with your request, NPDES CoC NCG500307 is rescinded, effective immediately. If in the future you wish to discharge wastewater to the State's surface waters, you must first apply for and receive a new NPDES permit. If you have any questions concerning this matter, please contact Charles H. Weaver at (919) 807-6391 or via e-mail [charles.weaver@ncdenr.gov]. Sincerely for S. Jay Zimmer m n, irector Division of Water Resources cc: Raleigh Regional Office / Mitch Hayes NPDES Unit Teresa Revis / Budget State of North Carolina I Environmental Quality I Water Resources 1617 Mail Service Center I Raleigh, NC 27699-1617 919 807 6300 919-807-6389 FAX https://deq. nc. gov/about/divisions/water-resources/water-resources-permits/wastewater-branch/npdes-wastewater-permits Charles Weaver Division of Water Resources WQ Permitting Section-NPDES 1617 Mail Service Center Raleigh, NC 27699-1617 11/23/16 Dear Mr. Weaver, I am writing you in reference to COC Permit NCG500307. On 6/6/16 Danny Smith the Regional Supervisor from the Water Quality Regional Operations Section visited our facility. He stated the following: General Permit NCG500000 specifically COC permit NCGS00307 allows discharge of non -contact cooling water, cooling water, boiler water and condensate from your facility. Since all cooling tower blow down and air compressor condensate is discharged to the City of Tarboro wastewater collection system, you may request to have COC permit NCG500307 rescinded. Please address your letter to Charles weaver, Division of Water Resources, WQ Permitting Section -• NPDES,1617 Mail Service Center, Raleigh, NC 27699-1617. 1 have attached a copy of the letter from Danny Smith. I would like to formally request that COC Permit # NCG500307 be rescinded. If you have any questions please contact me at 252.641.6034. Regards, I,Cvr (� �: Q � � George Freeman VP of Manufacturing Glenoit Fabrics 3001 N. Main Street Tarboro, NC 27886 (252) 641-6034 Office (828) 387-6642 Cell GLENOIT FABRICS A DIVISION OF MONTEREY MILLS Water Resources ENVIRONMENTAL OUALITY PAT MCCRORY DONALD R. VAN DER VAART S. JAY ZIMMERMAN June 6, 2016 George Freeman, VP of Manufacturing Glenoit Fabrics 3001 N. Main Street Tarboro, NC 27886 Subject: Compliance Evaluation Inspection Glenoit Fabrics Corporation —Tarboro COC Permit Number: NCG500307 Edgecombe County The subject inspection was conducted by Mitch Hayes of the Division of Water Resources on May 26, 2016. Your assistance and the assistance of Mr, BK Upchurch was appreciated. Below is a list of findings developed from the inspection. 1. Cooling tower blow down and air compressor condensate is pH adjusted inside the facility and then flows to a pit located outside the facility. The wastewater then flows to an aeration tank and is discharged to the City of Tarboro wastewater collection system. Boiler blow down is recycled and is not discharged. 2. General Permit NCG500000 specifically COC permit NCG500307 allows discharge of non -contact cooling water, cooling water, boiler blowdown and condensate from your facility. Since all cooling tower blow down and air compressor condensate is discharged to the City of Tarboro wastewater collection system, you may request to have COC permit NCG500307 rescinded. Please address your letter to Charles Weaver, Division of Water Resources, WQ Permitting Section — NPDES, 1617 Mail Service Center, Raleigh, NC 27699-1617. Cj ) r1 - 8C) -r - ('. 3 `i I if you have any questions about this letter or the inspection, please contact Mitch Hayes at 919.791.4261 or at mitch.haves@ncdenr.eov Danny Smith, Regional Supervisor Water Quality Regional Operations Section Raleigh Regional Office cc: Central files Permit files Division of Water Resources, Raleigh Regional Office. Water Quality Operations Section httpJ/pOrW.nedenr.org/web/wgfaps 1628 Mail Service Center, Raleigh, NC 27699-1628 Phone: (919) 791-4200 Location_ 3800 Barrett Drive, Raleigh, NC 27609 Fax: (919) 788-7159 Weaver, Charles From: Weaver, Charles Sent: Tuesday, December 22, 2015 10:02 AM To: 'jhoward@montereymills.com' Cc: 'bbirkhoff@montereymills.com'; 'tbreedlove@montereymills.com' Subject: renewal of NCG500307 / Glenoit Fabrics Attachments: Technical Bulletin - NCG500000 2015.doc; NCG50 Final 093015.pdf Importance: High Attached you will find the updated version of NPDES General Permit NCG500000, effective 10/1/2015. Discard any previous versions of the General Permit and use this version until further notice. You do not need a reprinted Certificate of Coverage, as the one issued to you in 2007 is still applicable. Thank you for your patience during the longer -than -expected renewal period. If you have any questions about this matter, simply reply to this message. Charles H. Weaver Environmental Specialist N.C. Division of Water Resources N.C. Department of Environmental Quality 919-807-6391 charles.weaver(a)ncdenr.gov (physical address) 512 North Salisbury Street, Raleigh, NC 27604 (mailing address) 1617 Mail Service Center, Raleigh, NC 27699-1617 fcl_ -' Nothing Compares Email correspondence to and from this address is subject to the North Carolina Public Records Law and may be disclosed to third parties. 1 Weaver, Charles From: Microsoft Outlook To: jhoward@montereymills.com; bbirkhoff@montereymills.com; tbreedlove@montereymills.com Sent: Tuesday, December 22, 2015 10:02 AM Subject: Relayed: renewal of NCG500307 / Glenoit Fabrics Delivery to these recipients or groups is complete, but no delivery notification was sent by the destination server: ihoward0montereymills.com (jhoward@montereymills.com) bbirkhoff@montereymills.com (bbirkhoff@montereymills.com) tbreedlove(-@montereymills.com (tbreedlove@montereymills.com) Subject: renewal of NCG500307 / Glenoit Fabrics I renewal of NCG500307 / GI... NCDENR North Carolina Department of Environment and Natural Resources Beverly Eaves Perdue Governor Mr. Jerry Howard, Plant Manager Glenoit Fabrics Corporation 3001 North Main Street Tarboro, North Carolina 27886 Dear Mr. Howard: Division of Water Quality Charles Wakild PE Director September 13, 2012 SEP 17 2012 Subject: Compliance Evaluation Inspections NPDES Wastewater General Permit NCG500307 Glenoit Fabrics Corporation Edgecombe County Dee Freeman Secretary On September 11, 2012, I, Dave Parnell of the Raleigh Regional Office of the Division of Water Quality, performed compliance evaluation inspections (CEI) at the referenced facility. Your assistance, as well as that of Mr. Jay Guff, (of the facility maintenance staff), was helpful and appreciated. This inspection was conducted to determine your compliance with the NPDES wastewater general permit referenced above. The following observations were noted during the Division of Water Quality inspection: SITE DESCRIPTION This facility is a textile production facility primarily involved in the manufacture of cloth liners for jackets and coats. The facility has reduced production in recent years and much of the site is not in use. The boiler blowdown water continues to be recycled and is not discharged to the environment. Two of the three cooling towers are in operation. The cooling water and condensate discharge is regulated by the NCG500000 permit. INSPECTION SUMMARY The NPDES Wastewater Permit was available during the inspection and was issued August 1, 2007. An application for a new permit has been received by DWQ, and the issuance is pending. North Carolina Division of Water Quality Internet: www.newaterquality.org Raleigh Regional office 1628 Mail Service Center one NhCarolina Surface Water Protection Phone (919) 191-4200 Customer Service Raleigh, NC 27699-1628 FAX (919) 788-7159 877-623-6748 An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper 2. The water within the cooling system is treated with SELtect 542, SELcide 651 and SELcide 921. The treatment agents are routinely administered to the system by Bill Keesee of Southeastern Laboratories, Inc. 3. The cooling system wastewater discharges to the ground after being treated inside the plant building. Samples are taken inside of the building, post -treatment. DMRs were available and reviewed. Please review your new (current) permit when it arrives by mail. Make sure that the required monitoring parameters that are set forth are in the new permit are being sampled as required. There may be new monitoring parameters assigned to your facility and it is important to make that change in a timely manner. If you have any questions regarding the attached report or any of the findings, please contact Dave Parnell at: (919) 791-4200 (or email: david.parnell@ncdenr.gov. Sincerely, CI - Dave Parnell Environmental Specialist Surface Water Protection Section Enclosure: September 11, 2012, Wastewater Compliance Evaluation Inspection Cc RRO/SWP files DWQ Central Office Files United States Environmental Protection Agency Washington, D.C. 20460 [Form Approved. EPA MB No. 2040-0057 MitAr lmmn(iAnrP Incnnrtinn Dinr,r�r+ pproval expires 8-31-98 Section A: National Data System Coding (i.e., PCS) Transaction Code NPDES yr/mo/day Inspection Type Inspector Fac Type ' IJ 2 I_j 3 I NCG500307 111 12I 12/09/11 117 18I 19I S I 20I � —J 21IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII Remarks IIIIIII6E Inspection Work Days Facility Self -Monitoring Evaluation Rating B1 CIA --------------------------- Reserved ---------------------- 671 69 701 __ 711 72 U�I 73 74 I I I80 I I I Section B: FacilityData Name and Location of Facility Inspected (For Industrial Users discharging to POTW, also include POTW name and NPDES permit Number) Entry Time/Date Permit Effective Date Glenoit Fabrics (HG) Corporation 01:15 PM 12/09/11 07/08/01 1 3001 N Main St Exit Time/Date Permit Expiration Date Tarboro NC 27886 02:15 PM 12/09/11 12/07/31 Name(s) of Onsite Representative(s)/Titles(s)/Phone and Fax Number(s) /// Other Facility Data Name, Address of Responsible OfficialMtle/Phone and Fax Number Tom Breedlove,PO Box 4011 Tarboro NC 27886/Enginee r/252-823-7798/ Contacted No Section C: Areas Evaluated During Inspection (Check only those areas evaluated) Permit 0 Records/Reports (See attachment summary) Name(s) and Signature(s) of Inspector(s) David R Parnell �a"Y � Signature & Manage701nt Q A EPA Form 35A-3 (Rev 9-94) Previous editions are obsolete. sheets of narrative and checklists as Agency/Office/Phone and Fax Numbers RRO WQ//919-791-4260/ and Fax Numbers Date 9 - 11, I-z-- Date Page # 1 Permit: NCG500307 Owner - Facility: Glenoit Fabrics (HG) Corporation Inspection Date: 09/11/2012 Inspection Type: Compliance Evaluation Permit Yes No NA NE (If the present permit expires in 6 months or less). Has the permittee submitted a new application? Q ■ Q ❑ Is the facility as described in the permit? ■ 0 ❑ Q # Are there any special conditions for the permit? Is access to the plant site restricted to the general public? Is the inspector granted access to all areas for inspection? Comment: Facility must submit renewal forms for permit. Record Keeping Are records kept and maintained as required by the permit? Is all required information readily available, complete and current? Are all records maintained for 3 years (lab. reg. required 5 years)? Are analytical results consistent with data reported on DMRs? Is the chain -of -custody complete? Dates, times and location of sampling Name of individual performing the sampling Results of analysis and calibration Dates of analysis Name of person performing analyses Transported COCs Are DMRs complete: do they include all permit parameters? Has the facility submitted its annual compliance report to users and DWQ? (If the facility is = or > 5 MGD permitted flow) Do they operate 24/7 with a certified operator on each shift? Is the ORC visitation log available and current? Is the ORC certified at grade equal to or higher than the facility classification? Is the backup operator certified at one grade less or greater than the facility classification? Is a copy of the current NPDES permit available on site? Facility has copy of previous year's Annual Report on file for review? Comment: Permit on hand at the facility. Yes No NA NE Page # 3 NCDENR North Carolina Department of Environment and Division of Water Quality Michael F. Easley, Governor July 23, 2007 Jerry Howard Glenoit Fabrics (HG) Corporation 3001 North Main Street Tarboro, NC 27886 Natural Resources William G. Ross, Jr., Secretary Coleen H. Sullins, Director Subject: Renewal of coverage / General Permit NCG500000 Glenoit Fabrics (HG) Corporation Certificate of Coverage NCG500307 Edgecombe County Dear Permittee: In accordance with your renewal application [received on January 23, 20071, the Division is renewing Certificate of Coverage (CoC) NCG500307 to discharge under NCG500000. This CoC is issued pursuant to the requirements of North Carolina General Statue 143-215.1 and the Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated May 9, 1994 [or as subsequently amended]. If any parts, measurement frequencies or sampling requirements contained in this General Permit are unacceptable to you, you have the right to request an individual permit by submitting an individual permit application. Unless such demand is made, the certificate of coverage shall be final and binding. Please take notice that this Certificate of Coverage is not transferable except after notice to the Division. The Division may require modification or revocation and reissuance of the certificate of coverage. Contact the Raleigh Regional Office prior to any sale or transfer of the permitted facility. Regional Office staff will assist you in documenting the transfer of this CoC. This permit does not affect the legal requirements to obtain other permits which may be required by the Division of Water Quality or permits required by the Division of Land Resources, Coastal Area Management Act or any other Federal or Local governmental permit that may be required. If you have any questions concerning the requirements of the General Permit, please contact Jim McKay [919 733-5083, extension 595 or james.mckav@ncmail.netl. Sincerely, Z'oc' -"e2 4�� for Coleen H. Sullins cc: Central Files Raleigh Regional Office / Surface Water Protection NPDES file 1617 Mail Service Center, Raleigh, North Carolina 27699-1617 One 512 North Salisbury Street, Raleigh, North Carolina 27W4 North Carof ina Phone: 919 733-5083 / FAX 919 733-0719 / Internet: www.ncwaterquality.org Naturally An Equal Opportunity/Affirmative Action Employer- 50% Recycled/10% Post Consumer Paper STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES DIVISION OF WATER QUALITY GENERAL PERMIT NCG500000 CERTIFICATE OF COVERAGE NCG500307 TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN, CONDENSATE AND SIMILAR WASTEWATERS UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, Glenoit Fabrics (HG) Corporation is hereby authorized to discharge from a facility located at Glenoit Fabrics (HG) Corporation 3001 N Main Street Tarboro Edgecombe County to receiving waters designated as an unnamed tributary to the Tar River in subbasin 30303 of the Tar -Pamlico River Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III and IV hereof. This certificate of coverage shall become effective August 1, 2007. This Certificate of Coverage shall remain in effect for the duration of the General Permit. Signed this day July 23, 2007. for Coleen H. Sullins, Director Division of Water Quality By Authority of the Environmental Management Commission JAN 2 S 2001 NCDENR North Carolina Department of Environment and Natural Resources Division of Water Quality Michael F. Easley, Governor William G. Ross, Jr., Secretary Alan W. Klimek, P.E., Director NOTICE OF RENEWAL INTENT Application for renewal of existing coverage under General Permit NCG500000 r . Existing Certificate of Coverage (CoC): NCG500 't (Please print or type) 1) Mailing address` of facility owner/operator: Company Name Owner Name Glenoit Fabrics (HG) Corporation Haixin Group Street Address 3001 N. Main Street City Tarboro State N. C. ZIP Code 27886 Telephone Number (252) 823-7798 Fax: (252) 641-5195 Email address jhoward@glenoitfabrics.com * Address to which all permit correspondence should be mailed 2) Location of facility producing discharge: Facility Name Same Facility Contact Street Address City Jerry Howard State ZIP Code County Edgecombe Telephone Number Same Fax: Same Email address Same 3) Description of Discharge: a) Is the discharge directly to the receiving stream? ❑ Yes V"No (If no, submit a site map with the pathway to the potential receiving waters clearly marked. This includes tracing the pathway of the storm sewer to the discharge point, if the storm sewer is the only viable means of discharge.) b) Number of discharge outfalls (ditches, pipes, channels, etc. that convey wastewater from the property): 3 c) What type of wastewater is discharged? Indicate which discharge points, if more than one. ❑ Non -contact cooling water Outfall(s) #: ❑ Boiler Blowdown Outfall (s) #: Page 1 of 3 NCG500000 renewal application ❑ Cooling Tower Blowdown ❑ Condensate ❑ Other Outfall (s) #: Outfall (s) #: Outfall (s) #: (Please describe "Other") d) Volume of discharge per each discharge point (in GPD): #001: #002: #003: #004 4) Please check the type of chemical [s] added to the wastewater for treatment, per each separate discharge point (if applicable, use separate sheet): ❑ Chlorine ❑ Biocides ❑ Corrosion inhibitors ❑ Algaecide ❑ Other ❑ None 5) If any box in item (4) above [other than None] was checked, a completed Biocide 101 Form and manufacturers' information on the additive must be submitted to the following address for approval: NC DENR / DWQ / Environmental Sciences Section Aquatic Toxicology Unit 1621 Mail Service Center Raleigh, NC 27699-1621 6) Is there any type of treatment being provided to the wastewater before discharge (i.e., retention ponds, settling ponds, etc.)? ❑ Yes ❑ No (If yes, please include design specifics (i.e., design volume, retention time, surface area, etc.) with submittal package. Existing treatment facilities should be described in detail. ) 7) Discharge Frequency: a) The discharge is: ❑ Continuous ❑ Intermittent ❑ Seasonal* i) If the discharge is intermittent, describe when the discharge will occur: ii) *Check the month(s) the discharge occurs: ❑ Jan ❑ Feb ❑ Mar. ❑ Apr ❑ May ❑ Jun ❑ Jul ❑ Aug. ❑ Sept. ❑ Oct. ❑ Nov. ❑ Dec. b) How many days per week is there a discharge? c) Please check the days discharge occurs: ❑ Sat. ❑ Sun. ❑ Mon. ❑ Tue. ❑ Wed. ❑ Thu. ❑ Fri. 8) Receiving stream[s]: a) To what body or bodies of water (creek, stream, river, lake, etc.) does the facility discharge wastewater? If the site discharges wastewater to a separate storm sewer system (4S), name the operator of the 4S (e.g. City of Raleigh). b) Stream Classification: Page 2 of 3 NCG500000 renewal application Additional Application Requirements: The following information must be included in triplicate [original + 2 copies] with this application or it will be returned as incomplete. Site map. If the discharge is not directly to a stream, the pathway to the receiving stream must be clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point. Authorization for representatives. If this application will be submitted by a consulting engineer (or engineering firm), include documentation from the Permittee showing that the consultant submitting the application has been designated an Authorized Representative of the applicant. Certification I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief such information is true, complete, and accurate. Printed Name of Person Signing: ✓�� Title: �7/✓% ✓ ` %�/ Applicant) North Carolina General Statute 143-215.6 b (i) provides that: (Date Signed) Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan or other document filed or required to be maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article, or who falsifies, tampers with or knowingly renders inaccurate any recording or monitoring device or method required to be operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both, for a similar offense.) This Notice of Renewal Intent does NOT require a separate fee. The permitted facility already pays an annual fee for coverage under NCG500000. Mail the original and two copies of the entire package to: Mr. Charles H. Weaver NC DENR / DWQ / NPDES 1617 Mail Service Center Raleigh, North Carolina 27699-1617 Page 3 of 3 24' STORM DRAN PFE STORMWATER OUTFALL T NOTES: N (Sol)HAY eKe /— _ \ D STORMWATER PPE POSITION AND CONFIGURATION IS APPROXIMATE SINCE NO UTILITY PLAN WAS AVAILABLE. 2) SITE PLAN BASED ON MARCH 1989 EDGECOMB COUNTY < 4 W ECS E ASM&r AERIAL PHOTOGRAPH AND EXISTNG GLENOIT MILLS SITE PLAN ^� D WA` \ w KEY PROPnIE sroanGE S ` \ / -APPROXIMATE STORMWATER FLOW DIRECTION4�% FARM LAND w / ® - DROP INLET TO STORMWATER PIPE 7 (C0V6+ED AREA) � 1` /Tam STORMWATER PPE 4 � 1 ' - „ ow FROM n FENCE N o+utE ma SEPARATE S PERMT �. , FACT '9 STORMWATER FALL 2 s�55 AREA n arir�+re T J J ' (SO2) ` LW PRNU CAD CAA Y BALES STORAGE M EFRl6lT HT ALLETS ASPFNLT C01 AM TI SPLL 'v COD EdT PLART ASPFNLT SMALL DRANAC£ i + RECH� DOCKSHppwd _ OL PROPOSED B6aCEIICY G96IATIX2 gAND�Y WH .2 ROL A LPE FROM DOWNSPOUT STD. AID SCRAP..,' • • SECONDARY CONTANIENT ,• .i • GASOLlE STORAGE STORMWATER OUTFALL 3 • OPPR x Lan (SO3) . PECEBM FLOW FTtOM Y RN -ES � OL `- 4 TWO DROP NETS MD •. +l 1`81 UST SOME RaM ROOF ATER STORMS TAW FR • _ 4 • \ PUM OL \ $ / FRSTORAGE i.`• STORAGE IN" SPLL DYE HOUSE � CONr C; , • WATER Nf 6 /f TREE L E SOCIAL SERVICES ffi,•,COA ASMALT swpwwr�PNrs • ,R PROPERTY �' �oRA1Ln� MAN STREET • ` ' ` • / . . LD®reweoam,2aaaNarm Engineering Consulting Services pre, M T-20 P.O. Box 9) 3 1735RTPFax ^7709 Mo. 2 (E00) 327-3E32 (919) 344-1733 Faz�(919) 544-0810 seer• I- -ISO' D GLENOIT MILLS STORMWATER POLLUTION PREVENTION PLAN Dr•oo BT Engineer TARBORO. NORTH CAROLNAing �•<et<d s, Consulting Appro.ed H, $8fY1CCS SITE PLAN d a, R State of North Carolina Department of Environment and Natural Resources Division of Water Quality Michael F. Easley, Governor William G. Ross Jr., Secretary Alan W. Klimek, P.E. Director June 27, 2003 TOM BRREDLOVE GLENOIT FABRICS (HG) CORPORATION PO BOX 4011 TARBORO, NC 27886 1�• NCDENR NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES Subject: NPDES Permit Modification -Name and/or Ownership Change Permit Number NCG500307 Glenoit Fabrics (HG) Corporation Glenoit Corporation Edgecombe County Dear Permittee: In accordance with your request received June 24, 2003, the Division is forwarding the subject permit modification. This modification documents the change in the ownership of the subject facility. All other terms and conditions in the original permit remain unchanged and in full effect. This permit modification is issued under the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the U. S. Environmental Protection Agency dated December 6, 1983. This permit modification does not affect the legal requirement to obtain other permits which may be required by the Division of Water Quality, the Division of Land Resources, Coastal Area Management Act, or any other Federal or Local government permit that may be required. If you have any questions concerning this permit, please contact Valery Stephens at the telephone number or address listed below. Sincerely, for an W. Klimek, P.E. cc: Central Files Raleigh Regional Office, Water Quality Section Stormwater and General Permits Unit Files 1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone 919-733-5083 FAX 919-733-9919 An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES DIVISION OF WATER QUALITY GENERAL PERMIT NO. NCG500000 CERTIFICATE OF COVERAGE No. NCG500307 TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN, CONDENSATE AND SIMMAR WASTEWATERS UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, GLENOIT FABRICS (HG) CORPORATION is hereby authorized to discharge non -contact cooling water from a facility located at GLENOIT FABRICS (HG) CORPORATION 3001 NORTH MAIN STREET TARBORO EDGECOMBE COUNTY to receiving waters designated as a ut to the Tar River, a class WS-IV NSW stream, in the Tar -Pamlico River Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, and W hereof. This certificate of coverage shall become effective June 27, 2003. This Certificate of Coverage shall remain in effect for the duration of the General Permit. Signed this day June 27, 2003. for Alan W. Klimek, P.E. Director Division of Water Quality By Authority of the Environmental Management Commission State of North Carolina Department of Environment and Natural Resources Division of Water Quality Michael F. Easley, Governor William G. Ross Jr., Secretary Alan W. Klimek, P.E. Director July 26, 2002 DAVID E GURLEY JR GLENOIT CORPORATION PO BOX 1157 TARBORO, NC 27886 Affl�_�WA NCDENR NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES Subject: Reissue - NPDES Wastewater Discharge Permit Glenoit Corporation COC Number NCG500307 Edgecombe County Dear Permittee: In response to your renewal application for continued coverage under general permit NCG500000, the Division of Water Quality (DWQ) is forwarding herewith the reissued wastewater general permit Certificate of Coverage (COC). This COC is reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between the state of North Carolina and the U.S. Environmental Protection Agency, dated May 9, 1994 (or as subsquently amended). The following information is included with your permit package: * A copy of the Certificate of Coverage for your treatment facility * A copy of General Wastewater Discharge Permit NCG500000 * A copy of a Technical Bulletin for General Wastewater Discharge Permit NCG500000 Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility for compliance with any other applicable federal, state, or local law rule, standard, ordinance, order, judgment, or decree. If you have any questions regarding this permit package please contact Aisha Lau of the Central Office Stormwater and General Permits Unit at (919) 733-5083, ext. 578 Sincerely, for Alan W. Klimek, P.E. cc: Central Files Stormwater & General Permits Unit Files Raleigh Regional Office 1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone 919-733-5083 FAX 919-733-0719 An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES DIVISION OF WATER QUALITY GENERAL PERMIT NO. NCG500000 CERTIFICATE OF COVERAGE No. NCG500307 TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN, CONDENSATE AND SIMILAR WASTEWATERS UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, GLENOIT CORPORATION is hereby authorized to discharge NON -CONTACT COOLING WATER / CONDENSATE water or similar wastewater from a facility located at GLENOIT CORPORATION 3001 NORTH MAIN ST TARBORO EDGECOMBE COUNTY to receiving waters designated as a ut to the Tar River, a class WS-IV NSW water, in the Tar - Pamlico River Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, and IV of General Permit No. NCG500000 as attached. This certificate of coverage shall become effective August 1, 2002. This Certificate of Coverage shall remain in effect for the duration of the General Permit. Signed this day July 26, 2002. for Alan W. Klimek, P.E., Director Division of Water Quality By Authority of the Environmental Management Commission State of North Carolina Department of Environment, Health and Natural Resources Division of Water Quality James B. Hunt, Jr., Governor Wayne McDevitt, Secretary A. Preston Howard, Jr., P.E., Director David E. Gurley, Jr. Glenoit Mills, Inc. P.O. Box 1157 Tarboro, NC 27886 Dear Permittee: Ar4jo AV"MN%% IDEHNF1 July 24, 1997 Subject: Certificate of Coverage No. NCG500307 Renewal of General Permit Glenoit Mills, Inc. Edgecombe County In accordance with your application for renewal of the subject Certificate of Coverage, the Division is forwarding the enclosed General Permit. This renewal is valid until July 31, 2002. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the Memorandum of Agreement between North Carolina and the U.S. Environmental Protection Agency dated December 6, 1983. If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you, you have the right to request an individual permit by submitting an individual permit application. Unless such demand is made, this certificate of coverage shall be final and binding. The Certificate of Coverage for your facility is not transferable except after notice to the Division. Use the enclosed Permit Name/Ownership Change form to notify the Division if you sell or otherwise transfer ownership of the subject facility. The Division may require modification or revocation and reissuance of the Certificate of Coverage. If your facility ceases discharge of wastewater before the expiration date of this permit, contact the Regional Office listed below at (919) 571-4700. Once discharge from your facility has ceased, this permit may be rescinded. This permit does not affect the legal requirements to obtain other permits which may be required by the Division of Water Quality, the Division of Land Resources, Coastal Area Management Act or any other Federal or Local governmental permit that may be required. If you have any questions concerning this permit, please contact the NPDES Group at the address below. Sincerely, v (1_41_� A. Preston Howard, cc: Central Files Raleigh Regional Office NPDES File Facility Assessment Unit P.O. Box 29535, Raleigh, North Carolina 27626-0535 (919) 733-5083 FAX (919) 733-0719 p&e@dem.ehnr.state.nc.us An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES DIVISION OF WATER QUALITY GENERAL PERMIT NO. NCG500000 CERTIFICATE OF COVERAGE NO. NCG500307 TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN, CONDENSATE, EXEMPT STORMWATER, COOLING WATERS ASSOCIATED WITH HYDROELECTRIC OPERATIONS, AND SIMILIAR WASTEWATERS UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, Glenoit Mills, Inc. is hereby authorized to discharge non -contact cooling water, condensate and other similar wastewaters from a facility located at Glenoit Mills, Inc. 3001 North Main Street Tarboro Edgecombe County to receiving waters designated as subbasin 30303 in the Tar River Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III and IV of General Permit No. NCG500000 as attached. This certificate of coverage shall become effective August 1, 1997. This certificate of coverage shall remain in effect for the duration of the General Permit. Signed this day July 24, 1997. t�A. Preston Howard, Jr., P.E., Director � Y Division of Water Quality By Authority of the Environmental Management Commission OLENOITMiLls, Inc Post Office Box 1157 Tarboro, North Carolina 27886 Telephone (919) 823-2124 Fax: (919) 823-7181 February 3, 1997 Mr. Charles H. Weaver, Jr. Division of Water Quality/WQ Section NPDES Group Post Office Box 29535 Raleigh, North Carolina 27626-0535 Dear Mr. Weaver: 2nd. mai 1- ng pia_. 2, 1997 Cert _4i.ed P 393 785 321 Return: Recei.nt Requested We are in receipt of your letter dated January 28 concerning renewal of NPDES Permit No. NCG500307. We hereby request renewal of this permit. We have removed from operation the previous non -water contact vacuum compressor. However, we operate one (1) cooling tower for Air Conditioning at present and plan to have another tower in operation by May, 1997. There are no plans to direct any of this water to storm drains but there is potential for possible overflow should a float or valve stick. Chemical additives made in cooling towers are as follows, all supplied by Southeastern Laboratories. a. Seltect 572 Scale and Corrosion Inhibitor b. Selcide 901 Mixed Isothiazolin - one Microbicide C. Selcide 332 Microbicide The invoice form, copy attached, has been completed. We have attached our check number 1906 in the amount of $400.00 to cover the renewal requirement. Executive and Sales Offices: 111 West 40th Street, New York 10018 I trust all of the above meets the requirements for Permit renewal, and feel free to call me if I can be of further assistance. Sincerely yours, GLENOIT MU-LS, INC. David E. Gurley, Jr. Corporate Vice President Engineering Services DEG: rwc cc: Central File OLE101imills, Inc Post Office Box 1157 Tarboro, North Carolina 27886 Telephone (919) 823-2124 Fax: (919) 323-7181 February 3, 1997 Mr. Charles H. Weaver, Jr. Division of Water Quality/WQ Section NPDES Group Post Office Box 29535; Raleigh, North Carolina 27626-0535 Dear Mr. Weaver: -► v We are in receipt of your letter dated January 28 concerning renewal of NPDES Permit .-n No. NCG500307. We hereby request renewal of this permit. We have removed from operation the previous non -water contact vacuum compressor. However, we operate one (1) cooling tower for Air Conditioning at present and plan to have another tower in operation by May, 1997. There are no plans to direct any of this water to storm drains but there is potential for possible overflow should a float or valve stick. Chemical additives made in cooling towers are as follows, all supplied by Southeastern Laboratories. a. Seltect 572 Scale and Corrosion Inhibitor b. Selcide 901 Mixed Isothiazolin - one Microbicide C. Selcide 332 Microbicide The invoice form, copy attached, has been completed. We have attached our check number 1906 in the amount of $400.00 to cover the renewal requirement. Executive and Sales Offices: 111 West 40th Street, New York 10018 I trust all of the above meets the requirements for Permit renewal, and feel free to call me if I can be of further assistance. Sincerely yours, GLENOIT MILLS, INC. "av"irl , Jr. Corporate Vice President rnering Services DEG: rwc cc: Central File Letter to David E. Gurley January 28, 1997 NCG 500307 INVOICE FOR RENEWAL OF NPDES PERMIT ❑ Check here if you do NOT wish to renew this permit. Please return this page along with a letter documenting your reasons for not requesting renewal to: Mr. Charles H. Weaver, Jr. Division of Water Quality/WQ Section NPDES Group Post Office Box 29535 Raleigh, North Carolina 27626-0535 El Check here if you wish to renew this permit. Please verify that the following information is documented accurately: Mailing Address Mr. David E. Gurley GLENOIT MILLS, INC. P. 0. Box 1157 3001 North Main Street Tarboro, North Carolina 27886 (919) 823-2124 Fax number: 919-823-7181 e-mail address: Facility Location Mr. David E. Gurley GLENOIT MILLS, INC. 3001 North Main Street Tarboro, North Carolina 27886 ® No revision required. Revision required. (Please specify below.) -r� in No revision required. Revision required. (Please specify below.) Please return this page with your letter requesting renewal, and $400 fee (payable to NCDEHNR) to: Mr. Charles H. Weaver, Jr. Division of Water Quality/WQ Section NPDES Group Post Office Box 29535 Raleigh, North Carolina 27626-0535 n Signature of applicant or authorized representative Date zzz; -16 -53 z State of North Carolina Department of Environment, Health and Natural Resources Division of Environmental Management James B. Hunt, Jr., Governor Jonathan B. Howes, Secretary A. Preston Howard, Jr., P.E., Director Mr. David Gurley Glenoit Mills, Inc. P. O. Box 1157 Tarboro, North Carolina 27886 Dear Mr. Gurley: A 5�'V K4J* �EHNFi December 8, 1995 Subject: Permit No. NCG500000 Glenoit Mills, Inc. COC NCG500307 Edgecombe County In accordance with your application for discharge permit received on June 23, 1995 we are forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated December 6, 1983. If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you, you have the right to request an individual permit by submitting an individual permit application. Unless such demand is made, this certificate of coverage shall be final and binding. Please take notice that this certificate of coverage is not transferable except after notice to the Division of Environmental Management. The Division of Environmental Management may require modification or revocation and reissuance of the certificate of coverage. This permit does not affect the legal requirements to obtain other permits which may be required by the Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area Management Act or any other Federal or Local governmental permit that may be required. If you have any questions concerning this permit, please contact Mr. Jay Lucas, P.E., at telephone number (919) 733-5083, extension 502. Sincerely, � A. Preston Howar PJr., E. cc: Central Files Raleigh Regional Office, Water Quality Mr. Roosevelt Childress, EPA Permits and Engineering Unit Facilities Assessment Unit P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone 919-733-7015 FAX 919-733-2496 An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES DIVISION OF ENVIRONMENTAL MANAGEMENT GENERAL PERMIT NO. NCG500000 CERTIFICATE OF COVERAGE No. NCG500307 TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN, CONDENSATE AND SIMILAR WASTEWATERS UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, Glenoit Mills, Inc. is hereby authorized to construct and operate or continue operation of a treatment system for the generation of non - contact cooling waters, boiler water blowdown or similar waste streams with the discharge of treated wastewater from a facility located at Glenoit Mills, Inc. U.S. Hwy 64 Business Tarboro Edgecombe County to receiving waters designated as an unnamed tributary to the Tar River in the Tar -Pamlico River Basin in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, H, III and IV of General Permit No. NCG500000 as attached. This certificate of coverage shall become effective December 8, 1995 This Certificate of Coverage shall remain in effect for the duration of the General Permit. Signed this day December 8, 1995 A. Preston Howard, Jr., P.E.,Director Division of Environmental Management By Authority of the Environmental Management Commission