NC0086690_Issuance of Permit_20080603

A
O�O�WAT�9QG
r
o��
June 3, 2008
Aqua North Carolina, Inc.
Thomas J. Roberts
202 MacKenan Court
Cary, NC 27511
Dear Mr. Roberts:
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins , Director
Division of Water Quality
Subject: Issuance of Renewal NPDES Permit
Permit NCO086690
Stansted Subdivision Well #2 WTP
Wake County
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to
the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between North Carolina and the U.S. Environmental Protection Agency dated October 15, 2007 (or as
subsequently amended).
�1 :
This final permit includes two major changes from the draft permit send to you on April 9,
1) A Total Monthly Flow (TMF) calculation and A. (2) Section are no longer necessary. The
TMF value and A. (2) Section were needed to calculate the TN Load which is no longer required.
2) A TN Load calculation, Monthly and Annually, has been removed from this permit. The
Division has determined that the TN Load impact from this facility does not warrant further
evaluation at this time. As nutrient conditions or other factors change in the Neuse River Basin
the Division will re-evaluate this permit requirements.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition, conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings
(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this
decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division
may require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or
Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Ron Berry at telephone number
[phone], extension 531.
Sincerely,
rr Coleen H. Sullins
-try
Attachments
Cc: Raleigh Regional Office/Surface Water Protection Section
Central Files
NPDES Unit
Division of Water Quality, Point Source Branch Telephone [phone]
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 FAX [phone] laht,,aro
};na512 N. Salisbury Street, Raleigh, North Carolina 27604 On the Internet at http://hlo.enrsbte.nc us,� haI
An Equal OpponwilylAffirmative Ac ion Employer

Permit NCO086690
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Aqua North Carolina, Inc.
is hereby authorized to discharge wastewater from a facility located at the
Stansted Subdivision Well #2
Stansted Drive north of Fuquay-Varina
Wake County
to receiving waters designated as an unnamed tributary to Basal Creek in the Neuse
River Basin in accordance with effluent limitations, monitoring requirements, and
other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective July 1, 2008.
This permit and authorization to discharge shall expire at midnight on April 30, 2013.
Signed this day June 3, 2008.
r ' Coleen 6.Su—llin-
s, Dir for
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0086690
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked As of this
permit issuance, any previously issued permit bearing this number is no longer effective. Therefore, the exclusive
authority to operate and discharge from this facility arises under the permit conditions, requirements, terms, and
provisions included herein.
Aqua North Carolina, Inc. is hereby authorized to:
1. Continue to operate a well -water treatment system that discharges wastewater
from sand filters that is chemically dechlorinated and filtered through a final sand
bed filter prior to discharge to the permitted outfall. This facility is located at the
Stansted Subdivision Well #2 on Stansted Drive north of Fuquay-Varina in Wake
County.
2. Discharge at the location specified on the attached map into an unnamed
tributary to Basal Creek, classified B, NSW waters in the Neuse River Basin.

jy) 13D
1 1,0
Z
Sunset
01;
Lake
.306
.4 Discharge Point
AJ
r
"•j 14
-_ -� �-� �' -' t �"-� ram- �� •.• •
6
V
A.
Aj
c
USGS Quad: E23NE Apex, NC
%
•
ght(C) .001, Maptr2ch,.4ny;z 11 'k-,
Latitude: 35' 38'31" N Stream Class: B, NSW
Longitude: 78' 47'20" W Subbasin: 030403
Receiving Stream: UT to Basal Creek
Facility
Location
NCO086690 — Stansted WeU#2 WTP
Wake County

Permit NCO086690
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to discharge from outfall 001. Such discharges shall be limited and monitored
by the Permittee as specified below for each outfall:
Effluent
Characteristics
LIMITS
MO : ITORIRG`REQ
IR TS
Monthly
Average
Daily
Maximum
Measurement
Fre uenc
Sample Type
Sample Location
Flow
0.0025 MGD
Monthly
Estimate
Effluent
Total Suspended Solids (TSS)
30.0 mg/L
45.0 mg/L
2/Month
Grab
Effluent
Total Iron
Monthly
Grab
Effluent
Total Residual Chlorine (TRC) 2
17 Ng/L
2/Month
Grab
Effluent
pH 3
21Month
Grab
Effluent
Nitrite/Nitrate Nitrogen
(NO2-N + NO3-N) 4
Monitor & Report (mg/L)
Semi-annually
Grab
Effluent
Total ICeldahl Nitrogen (TKN) 4
Monitor & Report (mg/L)
Semi-annually
Grab
Effluent
Total Nitrogen (TN) 4
TN = (NO2 A +NO3 -I) +TKN
Monitor & Report (mgA -)
Semi-annually
Calculated
Effluent
Total Phosphorus (TP)
Monitor & Report (mg/L)
Semi-annually
Grab
Effluent
Footnotes:
1. Daily flow estimates are determined by the number and duration of backwash/rinse events.
2. Total Residual Chlorine compliance is required for chlorine or chlorine derivative used for disinfection. The
facility shall report all effluent TRC values reported by a NC certified laboratory including field certified.
However, effluent values below 50 µg/L will be treated as zero for compliance purposes.
3. The pH shall not be less than 6.0 s.u. or greater than 9.0 s.u..
4. For a given wastewater sample, TN - (NO2-N + NO3-N) + TKN, where TN is Total Nitrogen, (NO2-N + NO3-N) is
Nitrite/Nitrate Nitrogen, and TKN is Total Kjeldahl Nitrogen.
All samples collected should be from a representative discharge event.
There shall be no discharge'of floating solids or visible foam in other than trace amounts.

AFFIDAVIT OF PUBLICATION
NORTH CAROLINA.
Wake County.) Ss.
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT•.("-''
COMMISSIOWNPOES UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617 -`
NOTIFICATION OF INTENT TO ISSUE
A NPDES WASTEWATER PERMIT
On the basis of thorough staff review and application of NC
General Statute 143,215.1 and 15A NCAC 02H.0109 and
other lawful standards and regulations, the North Caroli-
na Environmental Management Commission proposes to
issue a National Pollutant Discharge Elimination System
(NPDES) wastewater discharge permit to the person(s)
listed below effective 45 days from the publish date of this
notice.
,hritten comments regarding the proposed permit will be
accepted until 30 days after the publish date of this notice.
All comments received prior to that date are considered in
the final determinations regarding the proposed permit.
The Director of the NC Division of Water Quality may
decide to hold a public meeting forthe proposed permit,
should the Division receive a significant degree of public
interest.
Copies of the draft permit and other supporting informa-
tion on file used to determine conditions present in the
draft permit are available upon request and payment of
the costs of reproduction. Mail comments and/or requests
for information to the NC Division of Water Quality at the
above address or call Dina Sprinkle (919) 733-50113, exten-
sion 363 at the Point Source Branch. Please include The
NPDES permit number (below) in any communication.
Interested persons may also visit the Division of Water
Quality at 512 N. Salisbury Street, Raleigh, NC 27604-1148
between the hours of 8:00 a.m. and 5:00 p.m. to review
information on file.
Town of Hookerton, NC0025712, has applied to renew its
NPDES permit discharging to Contentnea Creek in the
Neuse River Basin. Total Residual chlorine (TRC) and
fecal coliform ore water -quality limited. This discharge
may affect future wasteload allocations to the receiving..
BP Products North America (7401 Old Mt. Holly Road,
Charlotte, North Carolina 28214) has applied for renewal of
NPDES permit NCO036145 for the Selma Terminal at 3707
Buffalo Road in Selma, North Carolina. This permitted
facility discharges wastewater to on unnamedtributgryto
Mill Creek in the tJeuse River Basin. Currently, total
suspended solids and phenol are water quality limited.
Thisdischarge may affect future allocations in this portion
of,Mill Creek.
Jerry G. Williams & Sons, Inc. (P.O. Box 2430, Smithfield,
NC 27577) has applied for renewal of permit NCO085936 for
the company's Wet Deck Log Storage site In Johnston
County. This permitted facility discharges stormwater
and wet -decking 'runoff to an unnamed tributary to the
Neuse River in the Neuse River Basin. Currently, no
parameters are water -quality limited. This discharge
may affect future allocations in this portion of the Neuse
River.
Before the undersigned, a Notary Public of Chatham
County North Carolina, duly commissioned and authorized to
administer oaths, affirmations, etc., personally appeared Debra
Peebles, who, being duly sworn or affirmed, according to law,
doth depose and say that she is Billing Manager -Legal
Advertising of The News and Observer a corporation
organized and doing business under the Laws of the State of
North Carolina, and publishing a newspaper known as The
News and Observer, in the City of Raleigh , Wake
County and State aforesaid, the said newspaper in which such
notice, paper, document, or legal advertisement was published
was, at the time of each and every such publication, a
newspaper meeting all of the requirements and qualifications
of Section 1-597 of the General Statutes of North Carolina and
was a qualified newspaper within the meaning of Section 1-
597 of the General Statutes of North Carolina, and that as such
she makes this affidavit; that she is familiar with the books,
files and business of said corporation and by reference to the
files of said publication the attached advertisement for NC
DIVISION OF WATER QUALITY was inserted in the
aforesaid newspaper on dates as follows: 04/11/08
Account Number: 73350833
The above is correctly copied from the books and files of the aforesaid Corporation and publication.
C414L)U�
`\�.• e� Scrcg9s:i
� �OC••�ptOr�•' r'
Puo`�
l77Ji11111W
NIN
Debra Peebles, Billing Manager -Legal Advertising
Wake County, North Carolina
Sworn or affirmed to, and subscribed before me, this
14 day of APRIL , 2008 AD ,by Debra Peebles.
In Testimony Whereof, I have hereunto set my hand
and affixed my official seal, the day and year aforesaid.
k/ Janet Scroggs, Notary Public
My commission expires 14`b of March 2009.

The Town of Smithfield has applied for renewal of NPDES
permit numberNC0083348 for its WTP. This permitted
facility discharges filter -backwash wastewater to Buffalo
Creek in the Neuse River Basin. Currently total residual
chlorine Is water quality limited. This discharge may
affect future allocations in this portion of Buffalo Creek.
The City of Raleigh hasapplied for renewal'of the NPDES
discharge permit (NCOD29033) for its Neuse River Waste-'
water Treatment.Plant located on NCSR 2552 southeast of
Ralpiah. This facility discharges to the Neuse River. a
), pH, alssolvea oxygen, ammonia, Ta701 nitrogen, ana
1 phosphorus'are water quality limited.
on
Aqua North Carolina,' Inc. has applied for renewal of
NPDES permit number, NCO073679, Oak Hollow, WTP
located off NC 42 near Mount Pleasant in Wake County.
This permitted facility discharges filter wastewaters to an
unnamed tributary to Middle Creek ln.the Neuse River
Basin: Currently total residual chlorine and PH are water
quality limited. This discharge may affect future alloca-
tions in this portion of Middle Creek.
The City of Raleigh(P.O. Box 590, Raleigh, NC27602) has
applied for renewal of NPDES permit number NCO082376
a
nese are water quality iimnea. inisaiscnargemayaTTeCT
future allocations in this portion of the Neuse River Basin.
Aqua North Carolina, tht has applied for renewal of
NPp S Permit NCO082996 for the HollybrooR WTP located
on KI dare Form Road southeast of Cary in Wake County.
This permitted facility discharges sand filter wastewater
to an unnamed tributary to Middle Creek in the Neuse
River Basin. Currently total residual chlorine and pH are
water quality limited. This discharge may affect future
allocations In this Portion of Middle Creek.,}
Aqua North Caroling% Inc. has applied for renewal Iof
NPDES Permit NC0086690 for the Stansted Well M2 WTP
located on Stansted Drive north of FuquayVarina in Wake
County. This permitted facility discharges sand filter
wastewater to an unnamed tributary to Basal Creek in the
Neuse River Basin. Currently total residual chlorine and
futture H areallocatiater ons In this limited. portion Thisdischarge
Creeks.
ultn, April Z 7MN", i

FACT SHEET - RENEWAL NCO086690 Stansted Well #2 WTP
*REVISED: 5/29108
*Per revised guidelines this permit is no longer required to calculate or report TNLoads.
Therefore, the final permit has been revised to remove TN Load requirements including TMF.
Will keep semi-annual frequency TN & TP.
Current Date: March 18, 2008 Prepared by: Ron Berry
Previous Renewal Permit Effective Issue Date: November 1, 2003
Existing Permit Expiration Date: April 30, 2008
Renewal Permit Expiration Date: April 30, 2013
Discharge: UT to Basil Creek
Basin: Neuse
Classification: B, NSW
General:
The renewal application was returned to the consultant, return #2270, on December 27, 2007. There
were several missing items. A follow up letter was also send to Aqua North Carolina, Inc. stating the
application could not be process until a correct application was provide.
The correct application was received January 15, 2008. A fast track dechlorination AtC was issued in
March 2005. Aqua North Carolina, Inc. became the new owner in 2007. The application stated the
permitted flow monthly average would be 0.00171 MGD.
Effluent Limited criteria are:
- Flow, monthly average max, monitor to determine TN Load
- TSS, daily max, monthly average max
- TN, calculate allocated N lbs
- (NO2-N + NO3-N), monitor to determine TN
- TKN, monitor to determine TN
- TP, monitor only
- Total Iron, monitor
Water Quality Limited criteria is:
- pH, daily range limit
- TRC, daily max.
The 2008 renewal application included a copy of the Sludge Management Plan.
Process:
Three parallel sand filter provide water treatment for the well water. Chlorination is done upstream
of the filters. The sand filters backwash and other waste water are discharged through a tablet
dechlorinator and then to a sand filter bed were the effleunt continues to the outfall. The accumulated
sludge in the sand filter is removed by a contractor as needed. March 2005 AtC given for tablet
dechlorination treatment which is added to the waste water stream prior to entering the final sand
filter. Discharge is to UT to Basal Creek.
Numerous paperwork violations.
Concerns:
Flow effluent monitoring/reporting, per last permit it is estimated based on backwash events. DMR
data review indicates monthly average flow would exceed the 0.00171 MGD monthly average so the
permitted value was increased to 0.0025(BPJ).
Page 1 of 1

TSS monitoring with Effluent Daily and Monthly Average Limits. Sample is grab. Will increase
frequency to 2/month with previous and limits. DMR data review indicates no violations, daily value
typically less than 5 mg/L.
Settleable Solids with Effluent Daily and Monthly Average Limits. Sample is grab. One value at
Daily Max. Will not continue per latest guidelines.
Turbidity monitoring with Effluent Daily Limit. Sample is grab. No violations. Turbidity typically
less than 10 ntu. Will not continue per latest guidelines.
Iron monitoring, currently monitoring only. Sample is grab. Typically less than 5 mg/L. Will
increase frequency to monthly.
TRC monitoring with Water Quality Daily Limit. Sample is grab. Will need to modify footnote
to state definition of chlorine additives, compliance date already enforced. Prior to compliance date
had values above limit but installed dechlorination. Will increase frequency to 2/month.
.pH monitoring with Water Quality Daily Limits. Requires grab sample. New requirement per
latest guidelines. Frequency is 2/month.
Total Nitrogen (TN) monitoring, currently monitoring only with measurements of TKN and (NO2-
N + NO3-N). TN Load calculations and reports submitted monthly and annually. Sample is grab.
Will maintain current frequency. Per DMR data TN Load annually is less than 3 lbs/yr.
Total Phosphorus (TP) monitoring, currently monitoring only. Sample is grab. Will maintain
current frequency. Based on DMR data TP less than 1 mg/L.
Changes to renewal permit:
1. Continue all monitoring parameters and limits for TN, TN Load, TP as in existing modified
permit.
2. Edit permit, owner name to reflect Aqua, updated component list.
3. Remove Settleable Solids and Turbidity.
4. Edit TRC existing footnote to show only definition for chlorine additive, increase frequency.
5. Edit Iron monitoring to increase frequency.
6. Edit TSS to increase frequency.
7. Add pH with limits.
Rational For Changes:
This WTP facility is a small discharger. The historical data indicates very small TN Load and TP.
Does not have allocation or limit therefore will continue frequencies.
Per guidelines need to add pH with limits and Total Manganese monitoring. All limited parameters
need to be measured 2/month while monitored parameters of significance should be measured
monthy.
TRC footnotes need to clearly define the additives. The limit is enforced and no longer requires
compliance time line.
REVISIONS NOTES. 411108: Fluoride, Zinc, and Manganese are NOT required since no
chemical additions are part of the treatment
Page 2 of 2

mg/L
O O O O
O N A O
O O O O
Mar-04
I I I
May-04
I I
Jul-04
I I I
Sep-04
I I I
I I
I I 1
Nov-04
I I I
I I
Jan-05
I I
I 1
Mar-05
May-05
Jul-05
Sep-05
I
Nov-05
1
Jan-06
Mar-06
May-06
Jul-06
I I I
Sep-06
I I I
I 1 I
Nov-06
I I I
I I 1
Jan-07
I 1 I
i I I
Mar-07
I I i
I I
May-07
I I
I I 1
Jul-07
I I
� I I
Sep-07
Nov-07
N
O
J
II
I
I
II
1
1
I
1
I
I
TN = (NOM + NO3-N) + TJK
N mg/L
O O C) O
N
pO
O
O O O O O O O O
O O
Jan-05
y 0.0
No
Feb 05
0116
0�
0
v,
Mar-05
•0.13 I I I
I
IV
Apr-05
I
• U.1b
May-05
' I. 110.11• h ' 1 1
I I I I I
1
I
Z
Jun-05
m
Jul-05
0.14 1 1 1
I
Aug-05
i 0.�3
m
Sep-05
I
rn
Oct-05
0.1 9
I l I I� I I
I I'
Nov-05
* 0.17 I
I
oN)
Dec-05
z
Jan-06
H
Feb-06
400.16
Mar-06
0.37
to.36,
Apr-06
May-06
00,36
0
Jun-06
0- 5
CID
Jul-06
00.17
z_
Aug-06
:0 A.16 i
i 1
9
Sep-06
0 0.15
Oct-06
0 0.15
I
Nov-06
0.081
Dec-06
0.07
Jan-07
;0.06
Feb-07
I I
0.0¢
Mar-07
0.09 1 I I
1
Apr-07
May-07
O A 2
Jun-07
I* 0.16
Z
Jul-07
0j041
Aug-07
0.631
Sep-07
04.04
Oct-07
0 0.05 i i
--1
Z
Nov-07
0.63 I I I 1 I
I 1
r
Dec-07
0. 3
0
0 0 0 0 0 0 0 0
0 0
0
O
A OD N O O A OND N
W O
TN Load =TN x TMF x 8.34
N Ibs/month
O
Mar-04
May-04
Jul-04
Sep-04
Nov-04
Jan-05
Mar-05
May-05
Jul-05
Sep-05
Nov-05
Jan-06
Mar-06
May-06
Jul-06
Sep-06
Nov-06
Jan-07
Mar-07
May-07
Jul-07
Sep-07
Nov-07
mg/L
N N W
(T O UI O rs O
O
R
m
N
_0 N
O
0- O
0- OD

, 1 1
DMR Data NCO086690 Date: 2/20/2008
Stansted Well#2 WTP pb:rdb
--*--Turbidity —Daily Max Limit
so----------------------
- --- - --- - - - ----
- -
-
-
50
40
---------------------
- - --- - - - -- --
-
--
- --- -
----
c 30
20
-----------
------
-- -------------- -----
------------------
10
- -
------
---------------- ---
--
-- -
-
-
0
0 o
0
0
0
0 0 0 0 0 0 0 0 0 0
0
0
0 0 0
0
0
cd
g
m
co
o
z
id
m id 5 m 'o m
g co z g co
o
z
coo
io m
g
m
co
'o
z
--*—TRC —Daily Max Limit
eo-------------------
--------------------------
--
-
70
----------
-------------------------------
--
-----
60
---
-- -----------------------------------
50
-
-
- -- -- ---------------
------------------
40
—
- -- - - - ------
-----------------
a
30
-
--- ---- ---------------------
-----------
--
20-t;2�7
v v v
0 0 0
v
0
v
0
Ln
0
u') Ln Ln Ln Ln co co co co co
0 0 0 0 0 0 0 0 0 0
co
0
►,
0
p- n n
0 0 0
n
0
n
0
m 75
g
m
co
o
z
co
--
cd m 'o is m � m
2 N z -> 2 (D
o
z
m
-1)
W
2
co
z

• / 4
DMR Data NCO086690 Date: 2/20/2008
Stansted Well#2 WTP pb:rdb
x Estmated Daily Flow • Monthly Average —Permitted Flow
0.0090 - - -
0.0080 X - - -
0.0070 - X
0.0060 - - - - - -
p 0.0050 X W X
XK
0.0040
)OC =
0.0030 x
•N � -
0.0020
0.0010WO•�-
0.0000 1
v a v a a a a v v v cn to cn cn 0 cn cn u, LO to 0 W co 0 M co 0 (D (D 0 (D cD r` r_ n r` rI_ r` r` r` r• r`
00000000000000000000000000000000000000000000
�Q���<00z 0 0 j 5LL2<��Q(nOZO�LLQ2 <U)OZ0Ii2Q2 <0 Z0
L--*---TSS —Monthly Max limit —Daily Max Limit
50 -
45
40
35
30
zd 25
20
15
10
5 ----
0
v v a v It u, cn LO LO LO cn 0 0 (D CD o o r- r- n r- r- �
0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
m o C o-)a'm o _3m c'a'
C13 ai o co ca
22 OZ g AZ g (AZ g ao
U) Z J
Settleable Solids —Monthly Max limit —Daily Max Limit
0.25
0.20
0.15
_J
0.10
0.05
0.00 �- --- — -,-- , -- I
,
'r 'IT v cn LO Ln Lr) LO LO (D (D cD (D (D cD r, f` n r` r` r
0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0
cca 5 m o coma ca -) ara o ca cc 1 aai o M co75 as o
g)cn Z g cn z � m 2 cn z � 2 2 cn Z

NPDES PERMIT APPLICATION - SHORT FORM C - WTP
For discharges associated with water treatment plants
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit Number INCO086690
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next To check the boxes, click your mouse on top of the box Otherwise, please print or type.
1. Contact Information:
Owner Name
Aqua North Carolina, Inc.
Facility Name
Stansted Well #2 Vn?
Mailing Address
202 MacKenan Court
City
Cary
State / Zip Code
NC/27511
Telephone Number
(919 )467-8712
Fax Number
[phone]
e-mail Address
msharwood®aquaamerica.com
2. Location of facility producing discharge:
Check here if same as above ❑
Street Address or State Road Stansted Drive
City
north of Fuquay-Varina
State / Zip Code
NC
County
Wake
3. Operator Information:
Name of the ftrnt, consultant or other entity that operates the facility. (Note that this is not referring to the
Operator in Responsible Charge or ORC)
Name Aqua North Carolina, Inc.
Mailing Address 202 MacKenan Court
City Cary
State / Zip Code NC/27511
Telephone Number [phone]
Fax Number [phone]
4. Ownership Status:
Federal ❑
State ❑
Private
Public ❑
Page 1 of 4 C-WTP 03/05

NPDES PERMIT APPLICATION - SHORT FORM C - WTP
For discharges associated with water treatment plants
b. Type of treatment plant:
❑ Conventional (Includes coagulation, flocculation, and sedimentation, usually followed by
filtration and disinfection)
❑ Ion Exchange (Sodium Cycle Cationic ion exchange)
® Green Sand Filter (No sodium recharge)
❑ Membrane Technology (RO, nanofiltration)
Check here if the treatment process also uses a water softener ❑
6. Description of source water(s) (Le. grounduxater, surface water)
Groundwater from well
7. Describe the treatment process(es) for the raw water:
• 3 filters 42" X 60" (they each backwash twice a week)
• Backwash rate 100 gpm for 15 min.
• Rinse rate 35 gpm for 6 min. j j 1,Y ;
• Chemical feeds before filtration: ►`'�+
Sodium e(Chlorine)
Sodium Hydroxide(Caustic)
Polymer Coagulate(Filter Aide)
• Chemical feeds after filtration:
Sodium Phosphate(Sequestering)
• Chemical feeds after Backwash:
Calcium Thiosufate(Dechlorination)
Polymer Coagulate(Dewatering Polymer)
S. Describe the wastewater and the treatment process(es) for wastewater generated by the
facility:
Filter backwash from drinking -water well.
The backwash wastewater is passed through a 400 sf sandbed to remove residuals (sludge).
The effluent is dechlorinated and discharged to stream.
Residual solids are scraped from the sandbed and hauled to a landfill.
9. Number of separate discharge points: 1
Outfall Identification number(s) 001
10. Frequency of discharge: Continuous ❑ Intermittent El
If intermittent:
Days per week discharge occurs: 6 Duration: 21 min.
11. Plant design potable flowrate 0.050 MGD
Backwash or reject flow 0.00171 MGD
Page 2 of 4 C-WTP 03/05

NPDES PERMIT APPLICATION - SHORT FORM C - WTP
For discharges associated with water treatment plants
12. Name of receiving stream(s) (Provide a map shouring the exact location of each oulfall, including
latitude and longitude):
unnamed tributary to Basal Creek in the Neuse River Basin
13. Please list all water treatment additives, including cleaning chemicals or disinfection
treatments, that have the potential to be discharged.
Sodium Chloride
Sodium Hydroxide
Polymer Coagulate
Sodium Phosphate
Calcium Thiosufate
14. Is this facility located on Indian country? (check one)
Yes ❑ No
15. Additional Information:
Provide a schematic of flow through the facility, include flow volumes at all points in
the treatment process, and point of addition of chemicals.
Solids Handling Plan
16. NEW Applicants
Information needed in addition to items 1-15:
New applicants must contact a permit coordinator with the NCDENR Customer
Service Center.
Was the Customer Service Center contacted? ❑ Yes ❑ No
Analyses of source water collected
Engineering Alternative Analysis
Discharges from Ion Exchange and Reverse Osmosis plants shall be evaluated using a
water quality model.
17. Applicant Certification
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
!l
Signature
Page 3 of 4 C-WTP 03/05

Om~aL FOD
CHO= FEED
I somw CRAMI
WELL
88 GPM
FILTER #1
FILTER 12
FILTER #3
BACKWASH
100 GPY
SANDBED
013MM FEED
TO WATER DISTRIBUTION
0.050 MGD
0.00171 MGD
i TO STREAM DISCHARGE
QM= 7HOMM REMOVE SLUDGE
PMYM MUM DISPOSE IN LANDFILL

SLUDGE MANAGEMENT PLAN
Facility Name: Stansted Well #2 WTP
The sludge removal consists of passing filter backwash water through sand filter bed which in
turn goes to effluent stream discharge. Sludge management for this facility consists of the
raking of sludge from the 400 sf sand filter and hauled to a landfill by Aqua North Carolina, Inc.
The removal service occurs regularly on an as needed basis as determined by Aqua North
Carolina, Inc. operating personnel.
Sludge Collection and Disposal shall conform to 40 CFR 503 of the Clean Water Act.
Every shipment of sludge will be recorded in a log book. This log book will provide a record of:
1. date of shipment
2. volume removed off site
3. destination of sludge
Sludge Collection and Disposal Tracking:
Authorized Representatives shall document each shipment.

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information M determine otential for ex edited ermit renewal
Reviewer/Date
L KQ(3
Permit Number
N C - G to 0
Facility Name
-
r =�
Basin Name/Sub-basin number
t- : s = 03- ()`/'
Receiving Stream
LA
A-o 6A C"_'(-
Stream Classification in Permit
6, WS
W
Does permit need NH3 limits?
N
Does permit need TRC limits?
l)
L.Vzr--A,'J-1
Does permit need Enteroccoci limit?
v
Does permit have toxicity testing?
Does permit have Special Conditions?
Does permit have instream monitoring.?
ND
Is the stream impaired (on 303(d) list)?
�1
Any obvious compliance concerns?
N
Any permit mods since lastpermit?
tJ
Existing expiration date
A Piz) L-
3 2,),) b'
New expiration date
3
New permit effective date
1►diannlhnnro�c %'nmmantc
C
YES_ This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
/ name/ownership changes).
YES t/ This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan),
Conventional )VTP, 303(d) listed, toxicity testing, instream monitoring,
compliance concerns, phased limits). Basin Coordinator to make case -by -
case decision.
YES_ This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS, etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TR Version 9/7/2007