NC0020389_Authorization to Construct_20230315

ot� STATf�,�
ROY COOPER
Governor
ELIZABETH S.BISER =1�A
Secretary
RICHARD E.ROGERS,JR. NORTH CAROLINA
Director Environmental Quality
March 15, 2023
Ms. Kimberly Pickett
Town Manager
Town of Benson
303 East Church Street
Benson,North Carolina 27504
SUBJECT: Authorization to Construct
A to C No. 020389A02
Town of Benson
Benson WWTP
NPDES Permit No. NCO020389
Dear Ms. Pickett:
A letter of request for an Authorization to Construct was received January 4, 2023, by the
Division of Water Resources(Division). With additional information received on March 15,2023,
final plans and specifications for the subject project have been reviewed and found to be
satisfactory. Authorization is hereby granted for the construction of modifications to the existing
1.9 MGD Benson WWTP, with discharge of treated wastewater into the Hannah Creek in the
Neuse River Basin.
This authorization results in no increase in design or permitted capacity and is awarded for
the construction of the following specific modifications:
Installation of one (1) 9.375 MGD mechanical bar screen with washer/compactor, one (1)
9.375 MGD manual bar screen, one (1) 9.375 MGD vortex type grit removal system, and
all necessary piping and controls; in conformity with the project plans, specifications, and
other supporting documentation comprising the ATC Permit Application package
submitted to the Department of Environmental Quality.
This ATC is issued in accordance with Part III, Paragraph A of NPDES Permit No.
NCO020389 issued effective May 1,2021,and shall be subject to revocation unless the wastewater
treatment facilities are constructed in accordance with the conditions and limitations specified in
Permit No. NCO020389.
It is the Owner's responsibility to ensure that the as-constructed project meets the
requirements of all applicable regulations and statutes, the ATC Permit Application package, and
North Carolina Department of Environmental Quality I Division of Water Resources
D E Q�� 512 North Salisbury Street 1 1611 Mail Service Center I Raleigh,North Carolina 27699-1611
rrOF"GARmw 919.707.9000

Ms. Kimberly Pickett, Town Manager
March 15,2023
Page 2 of 3
all of the requirements contained herein. Failure to comply may result in penalties in accordance
with North Carolina General Statute §143-215.6A through §143-215.6C.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the Division.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by the Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Raleigh Regional Office, telephone number 919-791-4200, shall be notified at least
forty-eight(48)hours in advance of operation of the installed facilities so that an on-site inspection
can be made. Such notification to the regional supervisor shall be made during the normal office
hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a Professional Engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit and the ATC Permit Application package.
Mail the Certification to: Division of Water Resources, WQ Permitting — NPDES, 1617 Mail
Service Center, Raleigh,NC 27699-1617.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the project plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the Permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance with
the North Carolina Sedimentation Pollution Control Act, and when applicable, the North Carolina

Ms. Kimberly Pickett, Town Manager
March 15,2023
Page 3 of 3
Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Prior to entering into any contract(s) for construction, the recipient must have obtained all
applicable permits from the State.
The issuance of this ATC does not preclude the Permittee from complying with any and
all statutes,rules,regulations, or ordinances which may be imposed by other government agencies
(local, state, and federal) which have jurisdiction.
If you have any questions or need additional information, please contact Min Xiao, PE at
telephone number(919) 707-3644 or by email at [e-mail].
Sincerely,
Signed by:
Em,0:0�"IOC9F62041`7
X��- ...
for Richard E. Rogers, Jr.
Director, Division of Water Resources
by Min Xiao, PE
NPDES Industrial Permitting Unit
With Engineer's Certificate attached:
cc: NPDES Files
ecopy: David Bennett, PE
The Wooten Company
Email: [e-mail]
DWR Raleigh Regional Office, Water Quality Programs
Without Engineer's Certificate attached:
cc: Wake County Health
ecopy: DWI/Eric Karis

Town of Benson
Benson WWTP
Authorization to Construct No. 020389A02
Issued March 15, 2023
NPDES Permit No. NCO020389
Engineer's Certification
I, , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Benson Wastewater Treatment
Plant, located in Wake County, hereby state that, to the best of my abilities, due care and
diligence was used in the observation of the following construction:
Installation of one (1) 9.375 MGD mechanical bar screen with washer/compactor,
one (1) 9.375 MGD manual bar screen, one (1) 9.375 MGD vortex type grit
removal system, and all necessary piping and controls; in conformity with the
project plans, specifications, and other supporting documentation comprising the
ATC Permit Application package submitted to the Department of Environmental
Quality.
I certify that the construction of the above referenced project was observed to be built within
substantial compliance, intent and in conformity with all applicable regulations and statutes and
the project plans, specifications, and other supporting documentation comprising the
Authorization to Construct Permit Application package.
Signature Registration No.
Date
Mail this Certification to: Attn: Min Xiao, PE SEAL
NPDES Industrial Permitting Unit
DEQ/DWR/Water Quality Programs
1617 Mail Service Center
Raleigh,NC 27699-1617 -- -