NC0062278_Permit Issuance_20150710

4
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory Donald van der Vaart
Governor Secretary
July 10, 2015
Mr. Sam Misuraca
Manager, Berkley Oaks, LLC
821 W. Eleven Mile Road
Royal Oak, Michigan 48067
Subject: NPDES PERMIT ISSUANCE
Permit Number NCO062278
Berkley Oaks MHP WWTP - Class H
Gaston County
Dear Mr. Misuraca:
Division personnel have reviewed and approved your application for renewal of the subject
permit. Accordingly, we are forwarding the attached final NPDES discharge permit. This permit is
issued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum
of Agreement between North Carolina and the U.S. Environmental Protection Agency dated October 15,
2007 (or as subsequently amended).
Please also note that proposed federal regulations require electronic submittal of all discharge
monitoring reports (DMRs) and specify that, if a state does not establish a system to receive such
submittals, then permittees must submit DMRs electronically, to the Environmental Protection Agency
(EPA). Therefore, a requirement to begin reporting discharge monitoring data electronically using the
NC DWR's Electronic Discharge Monitoring Report (eDMR internet application has been added to this
final permit. [See Special Condition A. (3.)] For information on eDMR, registering for eDMR and
obtaining an eDMR user account, please visit the following web page:
htW://portal.nedenr.org/web/Wq/admin/boWipLi/ed
For information on EPA's proposed NPDES Electronic Reporting Rule, please visit the following
web site: hUp://www2.epa. ov/compliance/pro op sed-npdes-electronic-reportin rule.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty
(30) days following receipt of this letter. This request must be in the form of a written petition,
conforming to Chapter 150B of the North Carolina General Statutes, and filed with the Office of
Administrative Hearings (6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such
demand is made, this permit shall be final and binding.
Please note that this permit is not transferable except after notice to the Division.. The
Division may require modification or revocation and reissuance of the permit. This permit does
not affect the legal requirements to obtain other permits which may be required by the Division
of Water Resources or any other Federal, State, or Local governmental permits that may be
required.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Phone: [phone] Internet: www.ncwaterquality.org .
An Equal Opportunity1 Affirmative Action Employer— Made in part by recycled paper

Berkley Oaks MHP WWTP
NCO062278
July 10, 2015
Page 2
If you have any questions or need additional information, please do not hesitate to contact
Maureen Kinney of my staff at [phone].
ncerel ,
G
S. Jay Zimmerman, Director
Division of Water Resources, NCDENR
cc: Central Files
NPDES Unit Files
DWR Mooresville Regional Office, Water Quality Regional Operations Section

Permit NCO062278
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER RESOURCES
PERMIT
� • • Y�/:�Cif%�li.+/�.`�Il�iii/:11�1 �Zi��l•7�:�111.1.1
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Berkley Oaks, LLC
is hereby authorized to discharge wastewater from a facility located at
Berkley Oaks MHP
NCSR 1112
southwest of Gastonia
Gaston County
to receiving waters designated as an unnamed tributary to McGill Branch in the Catawba River
Basin in accordance with effluent limitations, monitoring requirements, and other conditions set
forth in Parts I, II, III and IV hereof.
This permit shall become effective September 1, 2015.
This permit and authorization to discharge shall expire at midnight on August 31, 2020.
Signed this day July 10, 2015.
S. rsion
mmerman, P.G., Director
Di-+ of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 7

Permit NCO062278
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are
hereby revoked. As of this permit issuance, any previously issued permit bearing this number is
no longer effective. Therefore, the exclusive authority to operate and discharge from this facility
arises under the permit conditions, requirements, terms, and provisions included herein.
Berkley Oaks, LLC is hereby authorized to:
Continue to operate an existing 0.036 MGD wastewater treatment facility with the following
components:
• Influent bar screen
• Diffused aeration system
• Clarifier
• Tablet chlorination
• Effluent flow meter
• Tablet de -chlorinator
• Effluent composite sampler
• Aerated sludge holding tank
This facility is located at the Berkley Oaks MHP on NSCR 1112 southwest of Gastonia in
Gaston County.
2. Discharge from said treatment works at the location specified on the attached map into an
unnamed tributary to McGill Branch, currently classified C waters in sub -basin 03-08-37 of
the Catawba River Basin.
Page 2 of 7

Permit NCO062278
PART I
A. (L) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B .0400 et seq., 02B .0500 et seq.]
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to discharge treated wastewater from Outfall 001. Such discharges shall be
limited and monitored' by the Permittee as specified below:
EFFLUENT
LIMITS
MONITORING REQUIREMENTS
CHARACTERISTICS
Monthly
Daily
Measurement
Sample
Sample
Parameter Code
Average
Maximum
Frequency,
Type
Location 2
Flow
Fl ow
0.036 MGD
Continuous
Recording
E
BOD, 5-day, 20°C—Summer*
C0310
9.0 mg/1
14.0 mg/1
Weekly
Composite
E
BOD, 5-day, 200C — Winter*
18.0 mg/l
27.0 mg/l
Weekly
Composite
E
C0310
Total Suspended Solids
30.0 mg/1
45.0 mg/1
Weekly
Composite
E
C0530
3-N NH —Summer*
3-N
2.0 mg/1
10.0 mg/1
Weekly
Composite
E
3-N NH —Winter*
3-N
4.0 mg/l
20.0 mg/1
Weekly
Composite
E
Fecal Coliform (geometric mean)
200/100m1
400/100ml
Weekly
Grab
E
31616 .
pH
Not < 6.0 nor > 9.0
Weekly
Grab
E
00400
Standard Units
Dissolved Oxygen (DO)
00300
Daily Average > 6.0 mg/1
Weekly
Grab
E
Temperature (°C)
00010
Weekly
Grab
E
Total Residual Chlorine
50060
17 µg/1
2/Week
Grab
E
Temperature (°C)
00010
Weekly
Grab
U,D
Dissolved Oxygen (DO)
00300
Weekly
Grab
U,D
*Winter: November I - March 31
*Summer: April I - October 31
Footnotes:
1. No later than 270 days from the effective date of this permit, begin submitting discharge monitoring reports
electronically using NC DWR's eDMR application system. See Special Condition A.(3.).
2. Sample Location: E = Effluent, U = Upstream 100 feet from outfall, D = Downstream 300 feet from outfall.
3. Total Residual Chlorine compliance is required for chlorine or chlorine derivative used for disinfection. The Division
shall consider all effluent TRC values reported below 50 µg/l to be in compliance with the permit. However, the
Permittee shall continue to record and submit all values reported by a North Carolina certified laboratory (including
field certified), even if these values fall below 50 µg/l.
THERE SHALL BE NO DISCHARGE OF FLOATING SOLIDS OR VISIBLE FOAM IN OTHER THAN TRACE AMOUNTS.
Page 3 of 7

Permit NCO062278
A. (2.) REGIONAL SEWER CONNECTION INVESTIGATION
[15A NCAC 02B .0400 et seq., 02B .0500 et seq.]
The Permittee shall complete an initial investigation and submit a report to the Mooresville
Regional Office by March 31, 2016 on the feasibility of connecting to the Gastonia Regional
System. This does not require a final ' design or engineer cost estimate but is a preliminary
investigation. This report should include:
- Permittee name and contact person for the report,
- persons/Gastonia Utility representative contacted,
- highlights of the investigation,
- list of any identified issues and known cost,
- a rough cost estimate, if possible.
Mail the report to:
NCDENR
Mooresville Regional Office/Water Quality Regional Operations Section
610 East Center Avenue, Suite 301
Mooresville, NC 28115
The Mooresville Regional Office/Water Quality Regional Operations Section is the contact for
any questions or concerns in regards to this investigation and report. The Mooresville Regional
Office/Water Quality Regional Operations can be reached during normal business hours Monday
— Friday at phone [phone].
A. (3.) ELECTRONIC REPORTING OF DISCHARGE MONITORING REPORTS
[G. S. 143-215.1(b)]
Proposed federal regulations require electronic submittal of all discharge monitoring reports (DMRs)
and specify that, if a state does not establish a system to receive such submittals, then permittees must
submit DMRs electronically to the Environmental Protection Agency (EPA).
NOTE: This special condition supplements or supersedes the following sections within Part II of this
permit (Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.) Reporting
• Section D. (6.) Records Retention
• Section E. (5.) Monitoring Reports
I. Reporting [Supersedes Section D. (2.) and Section E. (5.) (a)]
Be6inning no later than 270 days from the effective date of this permit, the permittee shall begin
reporting discharge monitoring data electronically using the NC DWR's Electronic Discharge Monitoring
Report (eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and
submitted electronically using eDMR. The eDMR system allows permitted facilities to enter monitoring
Page 4 of 7

Permit NCO062278
data and submit DMRs electronically using the internet. Until such time that the state's eDMR
application is compliant with EPA's Cross -Media Electronic Reporting Regulation (CROMERR),
permittees will be required to submit all discharge monitoring data to the state electronically using eDMR
and will be required to complete the eDMR submission by printing, signing, and submitting one signed
original and a copy of the computer printed eDMR to the following address:
NC DENR / DWR / Information Processing Unit
ATTENTION: Central Files / eDMR
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility
being physically located in an area where less than 10 percent of the households have broadband access,
then a temporary waiver from the NPDES electronic reporting requirements may be granted and
discharge monitoring data may be submitted on paper DMR forms (MR 1, 1.1, 2, 3) or alternative forms
approved by the Director. Duplicate signed copies shall be submitted to the mailing address above.
Requests for temporary waivers from the NPDES electronic reporting requirements must be
submitted in writing to the Division for written approval at least sixty (60) days prior to the date the
facility would be required under this permit to begin using eDMR. Temporary waivers shall be valid for
twelve (12) months and shall thereupon expire. At such time, DMRs shall be submitted electronically to
the Division wiless the permittee re -applies for and is granted a new temporary waiver by the Division.
Information on eDMR and application for a temporary waiver from the NPDES electronic reporting
requirements is found on the following web page:
http://portal.ncdenr.or web/wq/admin/bog/ipu/edmr
Regardless of the submission method, the first DMR is due on the last day of the month following
the issuance of the permit or in the case of a new facility, on the last day of the month following the
commencement of discharge.
2. Signatory Requirements (Supplements Section B. (11.) (b) and supersedes Section B. (11.) (d)]
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II,
Section B. (I 1.)(a) or by a duly authorized representative of that person as described in Part H, Section B.
(I 1.)(b). A person, and not a position, must be delegated signatory authority for eDMR reporting
purposes.
For eDMR submissions, the person signing and submitting the DMR must obtain an eDMR user
account and login credentials to access the eDMR system. For more information on North Carolina's
eDMR system, registering for eDMR and obtaining an eDMR user account, please visit the following
web page:
hLtp://portal.nedenr.org/web/Wq/admin/bog/ipu/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make
the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION WILL
BE ACCEPTED:
U certify, under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or
persons who manage the system, or those persons directly responsible for gathering the information,
Page 5 of 7

Permit NCO062278
the information submitted is, to the best of nzy knowledge and belief, true, accurate, and complete. I
am aware that there are significant penalties for submitting false information, including the
possibility of fines and imprisonment for knowing violations. "
Records Retention [Supplements Section D. (6.)]
The permittee shall retail records of all Discharge Monitoring Reports, including eDMR
submissions. These records or copies shall be maintained for a period of at least 3 years from the date of
the report. This period may be extended by request of the Director at any tune [40 CFR 122.41].
Page 6 of 7

Page 7 of 7

PUBLIC NOTICE
North Carolina
AFFIDAVIT OF INSERTION OF ADVERTISMENT
Environmental
Management
The Gaston Gazette
Commission/
NPDES Unit
1617 Mail Service
Center
Raleigh, NC
Gastonia, N.C.
27699-1617
Gaston County
Notice of Intent to
Issue a NPDES
Wastewater Permit
The North Carolina Envi-
The Gaston Gazette does certify that the advertisement for:
ronmental Management
Commission proposes to
issue a NPDES waste-
water discharge permit to
Wastewater Permit: NC0062278 BerkleyOaks LLC
� �
the person(s) listed below
Written comments regard-
ing the proposed permit
will beaccepted until 30
Measuring 8.15 inches appeared in The Gaston Gazette, a newspaper published in
to
days after the publish date
of this notice. The Director
Gaston County, Gastonia, N.C., in issue(s):
of the NC Division of Water
Resources (DWR) may
hold a public hearing
should there be a signifi-
cant degree of public inter-
�5/22/2015.
est. Please mail comments
and/or information re-
quests to DWR at the
above address. Interested
persons may visit the DWR
at 512 N. Salisbury Street,
Raleigh, NC to review in-
formation on file. Additional
information on NPDES
permits and this notice
may be found on our
website: htt /
portal ncdenr ora/web/wN
swp/ps/npdes/calendar, or
by calling [phone].
Berkley Oaks, LLC : re-
quested renewal of permit
NCO062278 for Berkley
C As MHP WWTP, Gaston
C(,,inty; this permitted;dis-
ch nes i� treated domes- Name of Account: NCDENR/DWQ/NPDES
tic istewater to an un-
named tributary to My Gill Order Number: 54563494
Branch, Catawba River
Basin. Ad Number: 54663104
Mr. Randy Ferrill requested
renewal of permit
NCO080195 for the Forest
Hills Mobile Home Estates
Water Treatment Plant in Sworn to, and subscribed before me this 22 nd day of May, 2015.
Gaston County; this per-
mitted discharge is treated
filter backwash wastewater
to an unnamed tributary to
Hoyle Creek in the Ca-
tawba
ver
1C-May 2'015.. \\\\\\\\Pt�Ptn
� ZY
Text GS563494 to 56054
' - NOTARY
PUBIC 2 Lis . Zyble, Notary Public
�`' .44�N1) 0„0,�a`����`My Commission Expires April 25, 2017

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
This form must be completed by Permit Writers for all expedited permits which do not require full
Fact Sheets. Expedited permits are generally simple 100% domestics (e.g., schools, mobile home
parks, etc) that can be administratively renewed with minor changes, but can include facilities with
more complex issues (Special Conditions, 303(d) listed water, toxicity testing, instream monitoring,
compliance concerns).
Basic Information for Expedited Permit Renewals
Permit Writer/Date
Maureen Kinney 2/20/2015
Permit Number
NC0062278
Facility Name
Berkley Oaks MHP WWTP
Basin Name/Sub-basin number
Catawba 03-08-37
HUC #
03050101
Receiving Stream
UT to McGill Branch
Stream Classification in Permit
C
Does permit need Daily Max NH3 limits?
No
Does permit need TRC limits/language?
Yes No
Does pen -nit have toxicity testing?
Yes No
Does permit have Special Conditions?
Yes No — E-Re orting
Does permit have instream monitoring?
Yes No
Is the stream impaired (on 303(d) list)? For
what parameter?
Yes No
Any obvious compliance concerns?
See Attached
Any permit mods since last permit?
No
Current expiration date
8/31/2015
New expiration date
8/31/2020
Comments received on Draft Permit?
Please note the following modifications to this draft:
• Parameter codes have been added to Section A.(L) Effluent Limitations and
Monitoring Requirements.
• A requirement to begin reporting discharge monitoring data electronically using the
NC DWR's Electronic Discharge Monitoring Report (eDMR) internet application has
been added to this draft, see Special Condition A. (3.). For information on eDMR,
registering for eDMR and obtaining an eDMR user account, please visit the following
web page: http://portal.ncdenr.org/web/wq/admin/bog/ipu/edmr.

KACE ENVIRONMENTAL, INC.
2905 Wood Rd Phone [phone]
Mooresboro, NC 28114 Fax [phone]
February 18, 2015
NC DENR
Attn: NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject: NPDES Permit # NCO062278 Renewal
Berkley Oaks WWTP
With this letter you will find a completed copy of the NPDES Permit Renewal Form for
Berkley Oaks WWTP NPDES Permit # NCO062278 for your review and approval. There have
been no changes to the facility since the last permit period.
Should you need further information, or if you have any questions, please call or email us
and we will be happy to help.
Thank you,
c el G. Kramer
omplian ager
KACE Enviro ental, Inc.
[phone]
[e-mail]

February 11, 2015
Wastewater Branch
Water Quality Permitting Section
Division of Water Resources
1617 Mail Service Center
Raleigh, NC 27699-1617
Subject: Delegation of Signature Authority
BERKLEY OAKS WWTP
NPDES Permit Number NCO062278
To Whom It May Concern:
By notice of this letter, I hereby delegate signatory authority to each of the following individuals for all
permit applications, discharge monitoring reports, and other information relating to the operations at
the subject facility as required by all applicable federal, state, and local environmental agencies
specifically with the requirements for signatory authority as specified in 15A NCAC 2B.0506.
Name:
Title:
Individual #1
Ken Deaver
President, Kace Environmental, Inc.
Mailing Address: I
2905 Wood Road I
Mooresboro, Nc 28114
Physical Address:
(if different)
Email Address. [e-mail]
Office Phone: 828 - 657 - 1810
Mobile Phone: -
Individual #? /iinnn/i.•..{./.�
Rachael Kramer
Complaince Manager,
Kace Environmental, Inc.
2905 Wood Road
Mooresboro, Nc 28114
[e-mail]
828-657- 1810
If you have any questions regarding this letter, please feel free to contact me at 248.399.7755 or
sam(c?oakridgemgt.com.
Sincerely
Sam Misuraca
Manager
821 W. 1 1 Mile Rd.. Royal Oak, MI 48067
Sam@i)Oakridgemgt.Com
248.399.7755
cc: Mooresville Regional Office, Water Quality Permitting Section

. NPDES APPLICATION - FORM D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
Mail the complete application to:
N. C. DENR / Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit CO062278
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next. To check the boxes, click your mouse on top of the box. Otherwise, please print or type.
1. Contact Information: RECEIVED/DENR/DWR
Owner Name Berkley Oaks, LLC. FEB 2 3 2015
Facility Name Berkley Oaks WWTP Water Quality
PeFFAifting Be_ —
Mailing Address 821 W. Eleven Mile Rd. ZI
City Royal Oak
State / Zip Code Michigan, 48067
Telephone Number [phone]
Fax Number (248) 399 - 9975
e-mail Address sam(woakridgemgt.com, lela(woakridgemgt.com,
[e-mail]
bellsouth.net
2. Location of facility producing discharge:
Check here if same address as above ❑
Street Address or State Road 602 Ramsey Circle
City Gastonia
State / Zip Code NC / 28052
County Gaston
3. Operator Information:
Name of the firm, public organization or other entity that operates the facility. (Note that this is not
referring to the Operator in Responsible Charge or ORC)
Name Oak Ridge Properties, LLC
Mailing Address 821 W. Eleven Mile Rd.
City Royal Oak
State / Zip Code Michigan, 48067
Telephone Number [phone]
Fax Number [phone]
e-mail Address sam(@,oakrid eg_m t.com, lelakoakridgemet.com,
choffice392Cbellsouth. net
1 of 3 Form-D 11 /12

NPDES APPLICATION - FORM D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
4. Description of wastewater:
Facility Generating Wastewater(check all that apply):
Industrial
❑
Number of Employees
Commercial
❑
Number of Employees
Residential
®
Number of Homes 93
School
❑
Number of Students/Staff
Other
❑
Explain:
Describe the source(s) of wastewater (example: subdivision, mobile home park, shopping centers,
restaurants, etc.):
Mobile home community
Number of persons served: 236
S. Type of collection system
❑ Separate (sanitary sewer only)
6. Outfall Information:
❑ Combined (storm sewer and sanitary sewer)
Number of separate discharge points 1
Outfall Identification number(s) 001
Is the outfall equipped with a diffuser? ❑ Yes No
7. Name of receiving stream(s) (NEW applicants: Provide a map showing the exact location of each
outfall):
McGill Branch
8. Frequency of Discharge: Continuous ❑ Intermittent
If intermittent:
Days per week discharge occurs: Duration:
9. Describe the treatment system
List all installed components, including capacities, provide design removal for BOD, TSS, nitrogen and
phosphorus. If the space provided is not sufficient, attach the description of the treatment system in a
separate sheet of paper.
Plant components are:
36,000 gallon aeration tank, 9,000 gallon clarifier, 2,000 gallon contact chamber, 2,500
gallon digester, tablet chlorination, tablet de -chlorination.
2of3
Form-D 11/12