#5007_03_2015_FINAL

*'W.AA
'V-IKV
NCDEHR
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
April 6, 2015
5007
Mr. Ryan Bower
Dare County Skyco Water Plant
P.O. Box 1000
Manteo, NC 27954
John E. Skvarla, III
Secretary
SUBJECT: North Carolina Wastewater/Groundwater Laboratory Certification (NC WW/GW LC)
Maintenance Inspection
Dear Mr. Bower:
Enclosed is a report for the inspection performed on March 26, 2015 by Nick Jones. Since the
finding(s) cited during the inspection were all corrected prior to the completion of the enclosed
report, a response is not required. The staff is commended for taking the initiative in correcting the
findings in such a timely manner. For certification maintenance, your laboratory must continue to
carry out the requirements set forth in 15A NCAC 2H .0800.
Copies of the checklists completed during the inspection may be requested from this office. Thank
you for your cooperation during the inspection. If you wish to obtain an electronic copy of this
report by electronic mail, or if you have questions or need additional information, please contact
me at [phone].
Attachment
cc: Master file
Nick Jones
Sincerely,
Gary Francies, Technical Assistance/Compliance Specialist
Division of Water Resources
Water Sciences Section
NC Wastewater/Groundwater Laboratory Certification Branch
1623 Mail Service Center, Raleigh, North Carolina 27699-1623
Location: 4405 Reedy Creek Road, Raleigh, North Carolina 27607
Phone: [phone] FAX: [phone]
Internet: www.dwglab.org
An Equal Opportunity `', Affirmative Action Employer

INSPECTION REPORT ROUTING SHEET
To be attached to all inspection reports in-house only.
Laboratory Cert. #:
Laboratory Name:
Inspection Type:
Inspector Name(s):
Inspection Date:
Date Report Completed:
Date Forwarded to Reviewer:
Reviewed by:
Date Review Completed:
Cover Letter to use:
Unit Supervisor/Chemist III:
Date Received:
Date Forwarded to Linda:
Date Mailed:
5007
Dare County Skvco Water Plant
Field Maintenance
Nick Jones
March 26, 2015
April 1, 2015
April 1, 2015
Todd Crawford
April 2, 2015
❑ Insp. Initial ❑ Insp. Reg.
❑ Insp. No Finding ❑ Insp. CP
® Corrected
Gary Francies
4/2/2015
4/6/2015
4-1-11►(�) "

On -Site Inspection Report
LABORATORY NAME:
NPDES PERMIT # :
ADDRESS:
CERTIFICATE #:
DATE OF INSPECTION:
TYPE OF INSPECTION:
AUDITOR(S):
LOCAL PERSON(S) CONTACTED:
I. INTRODUCTION:
Dare County Skyco Water Plant
NCO035670
P.O. Box 1000
Manteo, NC 27954
5007
March 26, 2015
Field Maintenance
Nick Jones
Ryan Bower
This laboratory was inspected by a representative of the North Carolina
Wastewater/Groundwater Laboratory Certification (NC WW/GW LC) program to verify its
compliance with the requirements of 15A NCAC 2H .0800 for the analysis of
environmental samples.
GENERAL COMMENTS:
The laboratory was clean and well organized. The facility has all the equipment necessary
to perform the analyses.
Proficiency Testing (PT) samples for the 2015 proficiency testing calendar year have not
yet been analyzed. The laboratory is reminded that these results must be submitted to this
office directly from the vendor by September 30, 2015.
Contracted analyses are performed by Environmental Chemists, Inc. (Envirochem)
(Certification #94).
Current quality assurance policies for Field Laboratories and approved procedures for
the analysis of the facility's currently certified parameters were provided at the time of
the inspection.
FINDINGS. REQUIREMENTS, COMMENTS AND RECOMMENDATIONS:
Documentation
Comment: The benchsheet for Dissolved Oxygen, pH and Temperature used by the
laboratory did not contain all of the necessary labeling information. No instrument

Page 2
#5007 Dare County Skyco Water Plant
identification is documented. The NC WW/GW LC Approved Procedure for the Analysis of
Dissolved Oxygen, NC WW/GW LC Approved Procedure for the Analysis of pH and NC
WW/GW LC Approved Procedure for the Analysis of Temperature state: Document
instrument identification. This requirement is a new policy that has been implemented by
our program since the last inspection. Notification of acceptable corrective action (i.e., a
statement that as of 4/1/2015 the lab has updated the benchsheet to include instrument
identification) was received by email on 4/1/2015 and 3/26/2015, No further response
is necessary for this finding.
Comment: The laboratory was not documenting Proficiency Testing (PT) sample
analyses in the same manner as environmental samples. The NC WW/GW LC
Proficiency Testing Requirements documents states: All PT sample analyses must be
recorded in the daily analysis records as for any environmental sample. This serves as
the permanent laboratory record. This requirement is a new policy that has been
implemented by our program since the last inspection. Notification of acceptable corrective
action (i.e., a statement that as of 4/1/2015 PT samples will be documented in the same
manner as environmental samples) was received by email on 4/1/2015. No further
response is necessary for this finding.
IV. PAPER TRAIL INVESTIGATION:
The paper trail consisted of comparing original records (e.g., laboratory benchsheets,
logbooks, etc.) and contract lab reports to Discharge Monitoring Reports (DMRs)
submitted to the North Carolina Division of Water Resources. Data were reviewed
for December, 2014 and January and February, 2015. No transcription errors were
detected. The facility appears to be doing a good job of accurately transcribing data.
V. CONCLUSIONS:
All findings noted during the inspection were adequately addressed prior to the
completion of this report. The inspector would like to thank the staff for its assistance
during the inspection and data review process. No response is required.
Report prepared by: Nick Jones Date: April 1, 2015
Report reviewed by: Todd Crawford Date: April 2, 2015