NCGNE1499_No Exposure Certification_20211108

DocuSign Envelope 10: 1DBC4656-A054-46DC-853B-4E32AF6E2858
ROY COOPER
Governor
ELIZABETH S. BISER
Secretary
BRIAN WRENN
Director
AlloyWorks, LLC
Attn: Carl Adams
814 West Innes St.
Salisbury, NC 28144
Dear Carl Adams:
NORTH CAROLINA
Envlronmenrol Quollty
11/8/2021
Subject: No Exposure Certification NCGNE1499
AlloyWorks
Rowan County
The Division of Energy, Mineral and Land Resources (DEMLR) has reviewed your submittal of the
No Exposure Certification for Exclusion from NPDES Stormwater Permitting form. Based on your
submittal and signed certification of no exposure at the above referenced facility as well as
observations made during a site visit conducted by inspector with the Mooresville Regional Office
on date of site visit, the Division is granting your conditional exclusion from permitting as provided
for under 40 CFR 122.26(g), which is incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your No Exposure Certification, you are obligated to maintain
no exposure conditions at your facility. If conditions change such that your facility can no longer
qualify for the No Exposure Certification, you are obligated to immediately obtain NPDES permit
coverage for your stormwater discharge. Otherwise, the discharge becomes subject to enforcement
as an un-permitted discharge. You must self -re -certify annually that the No Exposure conditions are
being met by completing the Annual Self Re -Certification Form, which can be found at
https://deq.nc.gov/about/divisions/energy-mineral-land-resources/npdes-no-exposure. The
completed form does not need to be submitted but shall be kept onsite and made available upon
request.
Your conditional exclusion from permitting does not affect your facility's legal requirements to
obtain environmental permits that may be required under other federal, state, or local regulations
or ordinances.
If you have any questions or need further information, please contact Brittany Carson at (919) 707-
3648.
Sincerely,
DocuSigned C6y: � GteVi�bU�iaS
3D05]7a331 D407...
for Brian Wrenn, Director
Division of Energy, Mineral and Land Resources
cc: Mooresville Regional Office / Z. Kahn
D _E North Carolina Department of Environmental Quality i Division of Energy. Mineral and Land Resources
512 North Salisbury Street ' 1612 Mail Service Center I Raleigh, North Carolina 27699-1612
a<ax�� 919.707.9200

FOR AGENCY USE ONLY
NCGNE1,Y_l.Cl
Assigned to: "kv 04'y'�
ARO FRO MRO RRO WARd WIRO WSRO '°°es°oc�r°crc,:
Division of Energy, Mineral, and Land Resources r Ect—=I ED
National Pollutant Discharge Elimination System OCT 04 2021 "7&ims ✓
No Exposure Certification for Exclusion DENR-LAND L� ✓
NCGNE0000 STORMWATERPERMITTIN w�
Submission of this No Exposure Certification constitutes notification that your facility does not require a permit for
stormwater discharges associated with industrial activity in the State of North Carolina because it qualifies for a no
exposure exclusion. A condition of no exposure at an industrial facility means all industrial materials and activities
are protected by a storm resistant shelter (with some exceptions) to prevent exposure to rain, snow, snowmelt,
and/or runoff. Industrial materials or activities include, but are not limited to:
• material handling equipment or activities, • by-products,
• industrial machinery, • final products, or
• raw materials, • waste products.
• intermediate products,
Material handling activities include the storage, loading and unloading, transportation, or conveyance of any raw
material, intermediate product, final product, or waste product.
A storm resistant shelter is not required for industrial materials stored in the following container types, provided
the containers are not deteriorated and do not leak:
• drums, • tanks, and
• barrels, • similar containers.
For permitted facilities in North Carolina, DEMLR must approve your application for No Exposure Certification
before this exclusion is effective. Until you are issued a No Exposure Certification and your NPDES permit is
rescinded, your facility must continue to abide by the terms and conditions of the current permit.
A No Exposure Certification must be provided for each facility qualifying forthe no exposure exclusion. Additionally,
the exclusion from NPDES permitting is available on a facility -wide basis only — not for individual outfalls. If any
industrial activities or materials are, orwill be, exposed to precipitation, the facility is not eligible forthe no exposure
exclusion. By signing and submitting this No Exposure Certification form, you certify that a condition of no exposure
exists at this facility or site and are obligated to comply with the terms and conditions of 40 CFR 122.26(g).
If approved, your conditional No Exposure Certification has no expiration date but must be self -recertified at least
annually. Please look for information about recertification under the No Exposure section on this page:
https•//deg nc gov/about/divisions/energy-mineral-land-resources/npdes-no-exposure.
Directions: Print or type all entries on this application form. Send the original, signed application to: NCDEMLR
Stormwater Program, 1612 MSC, Raleigh, INC 27699-1612. The submission of this form does not guarantee
exclusion from NPDES stormwater permitting. Prior to exclusion from NPDES stormwater permitting a site
inspection will be conducted.
Page 1 of 5

1. Owner/Operator (to whom all permit correspondence will be mailed):
Name of legal organizational entity:
Legally responsible person (as signed in Item 7 below):
AIIoyWorks, LLC
Carl Adams
Street address:
City:
State
Zip Code
814 West Innes St.
Salisbury
NC
28144
Telephone number:
Email address:
[phone] Ext 105
[e-mail]
Type of Ownership:
Government
E3 County E3 Federal 0 Municipal 0 State
Non -government
0 Business (If ownership is business, a copy of NCSOS report must be included with this application)
E3 Individual
2. Industrial Facility (facility requesting exclusion):
Facility name:
Facility environmental contact:
AIIoyWorks
Jerry Money
Street address:
Telephone number:
814 West Innes St.
[phone] Ext 105
Email address:
[e-mail]
City
County
State
Zip Code
Salisbury
I Rowand
NC
28144
Latitude of entrance: 35.673730
Longitude of entrance:-80.477481
Parcel Identification Number (PIN):
020 054
Date operation began:
Standard Industrial Classification (SIC) Code:
2001
3341
Brief description of the types of industrial activities and products produced at this facility:
Produce Titanium Ingots for the Areospace Industry
3. Consultant (if applicable):
Name of consultant: Consulting firm:
Street address: City: State and zip code:
Telephone number: Email address:
4. Exposure Checklists
Are any of the following materials or activities exposed to precipitation, now or in the foreseeable future? If you
answer "Yes" to any of these items, you are not eligible for the no exposure exclusion.
Using, storing, or cleaning industrial machinery or equipment, and areas where residuals from
using, storing, or cleaning industrial machinery or equipment remain and are exposed to
stormwater
❑ Yes I] No ❑ N/A
Materials or residuals on the ground or in stormwater inlets from spills/leaks
❑Yes ❑ No ❑N/A
Materials or products from past industrial activity
0 Yes 0 No ❑ N/A
Material handling equipment (except adequately maintained vehicles)
E3 Yes El No ❑ N/A
Page 2 of 5

Materials or products during loading/unloading or transporting activities
❑Yes M No
❑ N/A
Materials or products stored outdoors (except final products intended for outside use [e.g., new
cars] where exposure to stormwater does not result in the discharge of pollutants)
❑ Yes 0 No
❑ N/A
Materials contained in open, deteriorated, non -sealed', or leaking storage drums barrels, tanks,
and similar containers
❑ Yes ElNo ❑ N/A
Materials or products handled/stored on roads or railways owned or maintained by the discharger
❑Yes 0 No
❑ N/A
Final products that would be mobilized in stormwater discharges (e.g., rock salt)
❑Yes El No
❑ N/A
Waste material (except waste in covered, non -leaking containers [e.g., dumpsters])
❑Yes 0 No
❑ N/A
Application or disposal of process wastewater (unless otherwise permitted)
❑Yes 0 No ❑ N/A
Particulate matter or visible deposits of residuals from roof stacks and/or vents not otherwise
regulated (i.e. under an air quality control permit) and evident in the stormwater outflow
❑Yes 0 No
❑ N/A
Empty containers that previously contained materials that are not properly stored (i.e., not closed
and stored upside down to prevent precipitation accumulation)
❑Yes El No
❑ N/A
For any exterior ASTs, as well as drums, barrels, tanks and similar containers stored outside, has
the facility had any releases in the past three (3) years?
❑Yes El No
❑ N/A
'Sealed means banded or otherwise secured and with locked or non -operational taps or valves.
Above Ground Storage Tanks (ASTs) and Secondary Containment
if you answer "No" to any of the following items, you are not eligible for the no exposure exclusion.
Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or deterioration, or
❑Yes ❑No 0 N/A
evidence of leaks?
Is secondary containment provided for all exterior ASTs? If so, is it free of any cracks, holes, or
❑Yes ❑No El N/A
evidence of leaks, and are drain valves maintained locked shut?
Is secondary containment provided for single above ground storage containers (including drums,
❑Yes ❑No El N/A
barrels, etc.) with a capacity of more than 660-gallons?
Is secondary containment provided for above ground storage containers stored in close proximity
❑Yes ❑No El N/A
to each other with a combined capacity of more than 1,320 gallons?
Is secondary containment provided for Title III Section 313 Superfund Amendments and
Oyes ❑No El N/A
Reauthorization Act (SARA) water priority chemicals?
Is secondary containment provided for hazardous substances designated in 40 CFR §116?
❑Yes ❑No EMN/A
Are release valves on all secondary containment structures locked?
❑Yes ❑No 0 N/A
Other information
If you answer "Yes" to any of the following items, you might not be eligible for the no exposure exclusion. A more
in-depth evaluation of the site circumstances may be required.
Are vehicles used in material handling in disrepair and/or leaking fluid?
❑ Yes 0 No ❑ N/A
Does this facility store used, recycled, or otherwise reclaimed pallets outside?
Dyes 0 No ❑ N/A
Does this facility have coal piles on site?
❑ Yes 0 No ❑ N/A
Does this facility store other fuel sources outside in piles, such as wood chips, sawdust, etc.?
❑Yes El No ❑ N/A
Page 3 of 5

Does this facility have air emissions associated with industrial activity (e.g., degreasing operations, 0 Yes El No I❑ N/A
plating, painting, or metal finishing)?
If yes:
Describe the industrial activity:
Are those emissions permitted by an Air Quality Permit? ❑ Yes E3No
Please specify:
S. Other Facility Conditions (check all that apply and explain accordingly):
❑ This facility has other NPDES permits.
If checked, list the permit numbers for all current NPDES permits:
❑ This facility has Non -Discharge permits (e.g. recycle permit).
If checked, list the permit numbers for all current Non -Discharge permits:
❑ This facility stores hazardous waste in the 100-year floodplain.
If checked, describe how the area is protected from flooding:
❑ This facility is a (mark all that apply)
❑ Hazardous Waste Generation Facility
❑ Hazardous Waste Treatment Facility
❑ Hazardous Waste Storage Facility
❑ Hazardous Waste Disposal Facility
If checked, indicate:
• Kilograms of waste generated each month:
• Type(s) of waste:
• How material is stored:
• Where material is stored:
• Number of waste shipments per year:
• Name of transport/disposal vendor:
• Transport/disposal vendor EPA ID:
• Vendor address:
❑ This facility is located on a Brownfield or SUPERFUND site.
If checked, briefly describe the site conditions:
❑ This facility is located on Native American Lands.
6. Required Items (Application will be returned unless all of the following items have been included):
❑ Copy of most recent Annual Report to the NC Secretary of State (if applicable)
El This completed application and any supporting documentation
El Copy of county map or USGS quad sheet with the location of the facility clearly marked
Page 4 of 5

7. Applicant Certification
North Carolina General Statute 143-215.68 (i) provides that: Any person who knowingly makes any false statement,
representation, or certification in any application, record, report, plan, or other document filed or required to be maintained
under this Article or a rule implementing this Article ... shall be guilty of a Class 2 misdemeanor which may include a fine not
to exceed ten thousand dollars ($10,000). 1 hereby request exclusion from NPDES stormwater permitting.
Under penalty of law, I certify that:
El I am the person responsible for the industrial activity, for satisfying the requirements of this exclusion, and for any civil
or criminal penalties incurred due to violations of this exclusion.
O I have read and understand the eligibility requirements for claiming a condition of "no exposure' and obtaining an
exclusion from NPDES stormwater permitting.
El There are no discharges of stormwater contaminated by exposure to industrial activities or materials from the industrial
facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
0 I understand that I am obligated to maintain no exposure conditions and complete a Self -Recertification form at least
once each year and, if requested, provide this certification to the operator of the local municipal separate storm sewer
system (MS4) into which the facility discharges (where applicable). I understand that I must allow the North Carolina
Division of Energy, Mineral, and Land Resources, or MS4 operator where applicable, to perform inspections to confirm
the condition of no exposure and to make such inspection reports publicly available upon request. I understand I must
keep a copy of annual recertifications on file at the facility.
❑ I understand that in the event that the site no longer qualifies for a No Exposure Exclusion that I must obtain coverage
under an NPDES permit prior to any point source discharge of stormwater from the facility.
❑ The information submitted in this NOI is, to the best of my knowledge and belief, true, accurate, and complete based on
my inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information.
Printed Name of Person Signing: Carl Adams
Title: Operational Manager
o 9/22/21
Signature of Applicant Date Signed
Mail the entire package to: DEMLR— Stormwater Program
Department of Environmental Quality
1612 Mail Service Center
Raleigh, NC 27699-1612
Page 5 of 5

_ LEGEND
o EdXWV St —
Now Cana. Man.
O Edetl^g Man
• Ns Man
p Paint
■ Ed"4 Na
0 water Matw
® Yerd/Osb Inlet
• Pam Pda
• Manhole
♦ Crain
• Light Pala
• man Cal
O Sprkaer Cantrd Vldve
w water Vat"
cmtwmm
Rw Right -of -war
4e\
`1\
CITY Of SALISBURY
PARCEL 1D 020 031 NO7�1� S
e SE OF PL /
.` 44 /
VICINITY MAP —MOT To SCALE
PROPERTY SURVEY FOR:
NOTE: THIS MAP IS NOT PREPARED FOR RECORDATION.
Lk+e Beerkq OHlawe
(SAS OETERMIaD TO BE OUTSIDE THE Q2% ANNUAL
"°'E' THIS 11TM `W O °�CT"ID° THE O Z0"E "
A l l o ywo rk s LLC &
CHANCE ILOOD PLAIN) (SEE FIRM 3710576000J}
f
L1 It EWE 43."'
L2 N 20' 3V 4:Y E 43.26
Surveyor C6ftiBCGtO
Alloy Holdings, Inc.
L3 N 20' 34' S4' E 101.57
L4 N 34. 10' IV E 24.00'
'40m3wry",
SM CARq '
•1 awUly awl Uds map ■as arosnd e uer my sloe from an acted
w■vey made under my «pwNw sla, (Creed a.lPiton r.«In Book 1176.
F.'Z=0ot Mn e be derINes not eurveye0 are Wkded as traem ham
612 W. peas sT.. CITY OF SALISBURY
TRACT I OF PROPERTY SURVEY FOIL
L RICHARD L SHULDHBIlROfR. PROfE551ONAL LAND SURVEYOR. L-2567 N.C., CERTIY
r
In In Book of MWe 9996 Pogo 4273; ghat the raUc of predsim ar
poMUawl ouurocy Is 1.,10,900+; and that this map meats tho reWbimenls of
FUC HS SYSTEMS. INC.
THAT THIS SURVEY IS OF AN EXISTING PARCEL OR PARCELS OF LAND AND DOES NOT
CREATE A NEW STREET OR CHANCE AN EXISTING STREET.
= sw
L-:m
■�
the StoWads of Prwtko for Land Surveying In North CodYw (21 NCAC 30.160D)'
This 20th day of Aprt 201&
SALISBURY TOWNSHIP. ROWAN COUNTY. NORTN CAROLINA
REFIERENCES: Pa ED 0 034 Deed Soak 21L
Book of Maps 9995 Page 4273.
SCALE 1' - 40' OATF- 4-20-2016
T Nro
A1p
��¢•L� dB
R�9MDiIlRCER. PLS
E
psmn
RNfivd L S1%Aw6Avw, P.L.S.
SURVEY AND MAP BY SHUID■URO R SURVEYWO COMPANY. P.A. (I = f C-16S9)
614 N. MAN ST- S 31E A. SALISBURY. N.C. PHONE., 704-037-9021

- File an Annual Report/Amend an Annual Report - Upload a PDF Filing - Order a Document Online - Add Entity to My Email Notification List -View Filings -
Print a Pre -Populated Annual Report form - Print an Amended a Annual Report form
Limited Liability Company
Legal Name
AIIoyWorks, LLC
Information
Sosid: 0577656
Status: Current -Active O
Date Formed: 1 /17/2001
Citizenship: Domestic
Annual Report Due Date: April 15th
CurrentAnnual Report Status:
Registered Agent: National Registered Agents, Inc.
Addresses
Reg Office Reg Mailing Mailing Principal Office
160 Mine Lake Ct Ste 200 160 Mine Lake Ct Ste 200 4650 S MACADAM AVENUE, SUITE 300 814 W. Innes Street
Raleigh, NC 27615-6417 Raleigh, NC 27615-6417 PORTLAND, OR 97239-4262 Salisbury, NC 28144
Company Officials
All LLCs are managed by their managers pursuant to N.C.G.S. 57D-3-20.
Vice President General Counsel Executive Officer
Roger P BECKER RUTH A BEYER SHAWN R HAGEL
4650 S MACADAM AVE STE 300 4650 S MACADAM AVENUE, SUITE 400 4650 S MACADAM AVENUE, SUITE 400
PORTLAND OR 97239 PORTLAND OR 97239 PORTLAND OR 97239
Chief Executive Officer
MICHAEL J MOSLEY
4650 S MACADAM AVENUE SUITE 400
PORTLAND OR 97239