NC0030848_Permit (Issuance)_20160706

NI
:cA
Water Resources
ENVIRONMENTAL QUALITY
Mr. Tim Church
J. R. Vannoy & Sons Construction Co.
1608 US Highway 221
Jefferson, NC 28604
PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Secretary
S. JAY ZIMMERMAN
I)irecior
July 6, 2016
Subject: Issuance of NPDES Permit NC0030848
Jefferson Apparel WWTP
Class WW-2
Ashe County
Dear Mr. Church:
The Division of Water Resources (the Division) hereby issues the attached NPDES permit for the
subject facility. This permit is issued pursuant to the requirements of North Carolina General
Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency dated October 15, 2007, or as subsequently amended.
We have made the following updates to your previous permit:
➢ Section A. (2) has been added to require electronic submission of effluent data. Federal
regulations require electronic submittal of all discharge monitoring reports (DMRs), effective
December 21, 2016.
➢ Regulatory citations have been added to the permit.
➢ An updated outfall map has been included.
➢ Coordinates for the outfall location have been updated.
We have made the following updates since the draft permit:
➢ The total residual chlorine limit has been changed to 17 mg/L since the facility discharges
into trout waters.
➢ Owner and facility name has been updated on the outfall map and permit to reflect the
information included on the NPDES renewal application.
Starting on December 21, 2016, federal regulations require electronic submittal of all discharge
monitoring reports (DMRs) and specify that, if a state does not establish a system to receive such
submittals, then permittees must submit DMRs electronically to the Environmental Protection
Agency (EPA). The final NPDES Electronic Reporting Rule was adopted and became effective on
December 21, 2015.
The requirement to begin reporting discharge monitoring data electronically using the NC DWR's
Electronic Discharge Monitoring Report (eDMR) internet application has been added to your final
NPDES permit. [See A. (2)] For information on eDMR, registering for eDMR and obtaining an
eDMR user account, please visit the following web page:
http://deq_.nc.gov/about/divisions/water-resources/edmr.
For more information on EPA's final NPDES Electronic Reporting Rule, please visit the following
web site:
State of North Carolina I Environmental Quality I Water Resources
1617 Mail service Center I Raleigh, North Carolina 27699-1617
919 807 6300

http://www2.epa.gov/compliance/final-national-pollutant-discharge-elimination-system-npdes-
electronic-reporting-rule.
If any parts, measurement frequencies, or sampling requirements contained in this permit are
unacceptable, you have the right to an adjudicatory hearing, upon written request submitted within
thirty (30) days after receiving this letter. Your request must take the form of a written petition
conforming to Chapter 150B of North Carolina General Statutes, and you must file it with the Office
of Administrative Hearings, 6714 Mail Service Center, Raleigh, North Carolina 27699-6714. Unless
such a demand is made, this permit shall remain final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Resources or
any other Federal, State, or Local governmental permits that may be required.
If you have questions, or if we can be of further service, please contact Jennifer Busam at
[[e-mail]] or call [phone].
S. Zimmerman, P.G., car
Division of Water Resources, NCDEQ
Enclosure: NPDES Permit NC0030848 (Issuance Final)
hc: Central Files
NPDES Program Files
WSRO Files
ec: Mr. Tim Church [[e-mail]]

Permit NC0030848
STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other
lawful standards and regulations promulgated and adopted by the North Carolina
g
Environmental
Management Commission, and the Federal Water Pollution Control
Act, as amended,
J.R. Vannoy & Sons Construction Co.
is hereby
authorized to discharge wastewater from a facility located at the
Jefferson Apparel WWTP
Jefferson Apparel Road
Jefferson
Ashe County
g
as
to receiving waters
designated as Dog Creek in subbasin 05-07-01 of the New River B t forth
in in
acco
rdance with effluent limitations, monitoring requirements, and other conditions
in Parts I, II, III and IV hereof.
This permit shall become effective August 1, 2016.
This permit and
d authorization to discharge shall expire at midnight on March 31, 2021.
Signed this day July 6, 2016.
S. y Zimmerman, P.G. , Dire r
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 6

Permit NC0030848
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are
hereby revoked, and as of this issuance, any previously issued permit bearing this number
is no longer effective. Therefore, the exclusive authority to operate and discharge from this
facility arises under the permit conditions, requirements, terms, and provisions included
herein.
J.R. Vannoy 86 Sons Construction Co.
is hereby authorized to:
1. Continue to operate an existing 0.008 MGD wastewater treatment system with
the following components:
• Influent gravity flow
• Manual bar screen
• Aeration basin
• Secondary clarifier with RAS
• Effluent sand filter
• Tablet chlorine disinfection
• Tablet dechlorination
This facility is located in Jefferson at the Jefferson Apparel WWTP, (Jefferson
Apparel Road) in Ashe County.
2. Discharge from said treatment works via Outfall 001, at the location specified
on the attached map into Dog Creek [10-1-33] currently classified C-Trout +
waters in subbasin 05-07-01 [HUC: 0505000102] of the New River Basin.
Page 2 of 6

Permit NC0030848
Part I
A. (1)EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B.0400 et seq.,
15A NCAC 02B.0500 et seq.]
Beginning with the permit effective date and lasting until expiration,fthe Permittee is
all 001. Such
authorized to discharge treated domestic wastewater from Outfall
dischar es shall be limited and monitored' by the Permittee as specifie
d below:
g
EFFLUENT CHARACTERISTICS
Parameter Code
Flow
BOD, 5-day, (20°C)
Total Suspended Solids
NH3 as N - *Summer
50050
C0310
C0530
C0610
NH3 as N - *Winter C0610
Fecal Coliform
(geometric mean)
31616
Total Residual Chlorine 2 50060
Temperature (°C) 3 00010
pH 00400
*Summer: April 1 - October 31
*Winter: November 1 - March 31
Footnotes:
1. No later than December 21, 2016, the permittee shall begin submitting disct rg[see A.
monitoring reports electronically using the NC DWR's eDMR applicationY
(2)].L to be in
2... The Division shall consider all effluent TRC values reported below
50to record and submit
compliance with the permit. However,
the Permittee shall con
all
values reported by a North Carolina certified laboratory (including field certified), even
if these values fall below 50 jig/L.
p era
3.
The tem erature of the effluent shall be such not to cause an increase in the to cause t re
e
of the [trout water] receiving stream of more than 0.5° C and in no
ambient water temperature to exceed 20° C.
THERE SHALL BE NO DISCHARGE OF FLOATING SOLIDS OR VISIBLE FOAM IN OTHER
THAN TRACE AMOUNTS.
EFFLUENT LIMITATIONS
Monthly
Average
0.008 MGD
30.0 mg/L
30.0 mg/L
10.0 mg/L
200/100 ml
Daily
Maximum
45.0 mg/L
45.0 mg/L
35.0 mg/L
400/100 ml
17 pg/L
> 6.0 and < 9.0 standard
units
MONITORING REQUIREMENTS
Measurement
Frequency
Weekly
Weekly
Weekly
Weekly
Weekly
Weekly
Weekly
Daily
Weekly
Sample
Type
Instantaneous
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Sample
Location
Influent or
Effluent
Effluent
Effluent
Effluent
Effluent
Effluent
Effluent
Effluent
Effluent
Page 3 of 6

Permit NC0030848
A. (2) ELECTRONIC REPORTING OF MONITORING REPORTS
[NCGS 143-215.1 (b)]
Federal regulations require electronic submittal of all discharge monitoring reports
(DMRs) and program reports and specify that, if a state does not establish a system
to receive such submittals, then permittees must submit monitoring data and reports
electronically to the Environmental Protection Agency (EPA) . The final NPDES
Electronic Reporting Rule was adopted and became effective on December 21, 2015.
NOTE: This special condition supplements or supersedes the following sections
within Part II of this permit (Standard Conditions for NPDES Permits):
• Section B. (11.)
• Section D. (2.)
• Section D. (6.)
• Section E. (5.)
Signatory Requirements
Reporting
Records Retention
Monitoring Reports
1. Reporting Requirements [Supersedes Section D. (2.) and Section E. (5.) (a)]
Effective December 21, 2016, the permittee shall report discharge monitoring data
electronically using the NC DWR's Electronic Discharge Monitoring Report (eDMR)
internet application.
Monitoring results obtained during the previous month(s) shall be summarized for
each month and submitted electronically using eDMR. The eDMR system allows
permitted facilities to enter monitoring data and submit DMRs electronically using
the internet. Until such time that the state's eDMR application is compliant with
EPA's Cross -Media Electronic Reporting Regulation (CROMERR), permittees will be
required to submit all discharge monitoring data to the state electronically using
eDMR and will be required to complete the eDMR submission by printing, signing,
and submitting one signed original and a copy of the computer printed eDMR to the
following address:
NC DEQ / Division of Water Resources / Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or
due to the facility being physically located in an area where less than 10 percent of
the households have broadband access, then a temporary waiver from the NPDES
electronic reporting requirements may be granted and discharge monitoring data may
be submitted on paper DMR forms (MR 1, 1.1, 2, 3) or alternative forms approved by
the Director. Duplicate signed copies shall be submitted to the mailing address
above. See "How to Request a Waiver from Electronic Reporting" section below.
Page 4 of 6

Permit NC0030848
Regardless of the submission method, the first DMR is due on the last day of the month following the issuance of the permit or in the case of a new facility, on the last
day of the month following the commencement of discharge.
Starting on December
21,2020, the permittee must electronically report the
p
followin compliance monitoring data and reports, when applicable:
licable:
g
• Sewer Overflow/ Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act (CWA) Section 316(b) Annual Reports.
The permittee may seek
an electronic reporting waiver from the Division (see "How to
Request a Waiver from Electronic Reporting" section below) .
2. Electronic Submissions
In accordance with 40
CFR 122.41(1) (9), the permittee must identify the initial he
we
recipient at the time of each electronic submission. The permittee should usethesubmission.
InitialEPA's
recipient of electronic NPDES information from NPDES-regulatelemthe NPDES
means the entity (EPA or the state authorized by EP � NPDES data [see 40
program) that is the designated entity for receiving electronic
EPA
CFR 127.2(b)]. appropriate plans to establish a website that will also link to the state. Instructions electronic
reporting tool for each type of electronic submission and
on how to access andusethe appropriate electronic reporting tool will be available as
.
well. Information
on EPA's
NPDES Electronic Reporting Rule is found at:
ination-
htt ' wwuT 2 . e • a.:ov com • liance final -national- • ollutant-dischar e e
•
s stem-n • des -electronic -re • ortin:-rule. Electronic submissions must start by the dates listed in the "Reporting
Requirements" section above.
• uest a Waiver from Electronic Re . ortin
T: the Division. To
3. How t Re
The permittee may seek a temporary electronic reporting waiver from
reporting waiver, a permittee must first submit an electronic tin
obtain an electronic rep gelectronic reporting
reporting waiver request to the Division. Requests for temporary approval at least
P g
waivers must be submitted in writing to the Division
be required under this permit to
sixty (60) days prior to the date the facility wouldwaiver
submitting monitoring data and reports. The duration of a temporary monitoring data
begin sub g
shall not exceed 5 years and shall thereupon expire. At such time,
the permitteegda
and reports shall be submitted electronically to the Division unless waiver by the
e-
electronreporting
applies for and is granted a new temporary
mpr w fivers are not transferrable. Only
Division. Approved electronic reporting
permittees with an approvedporting waiver re request may submit monitoring data
e orts on paper to the Division for the period that the approved reporting orting w
andrp
request is effective.
Page 5 of 6

Permit NC0030848
Information on eDMR and the application for a temporary electronic reporting waiver
are found on the following web page:
http: / /deq.nc.gov/about/divisions/water-resources/edmr
4. Signatory Requirements [Supplements Section B. (11.) (b) and Supersedes
Section B. (11.) (d)]
All eDMRs submitted to the permit issuing authority shall be signed by a person
described in Part II, Section B. (11.)(a) or by a duly authorized representative of that
person as described in Part II, Section B. (11.)(b). A person, and not a position, must
be delegated signatory authority for eDMR reporting purposes.
For eDMR submissions, the person signing and submitting the DMR must obtain an
eDMR user account and login credentials to access the eDMR system. For more
information on North Carolina's eDMR system, registering for eDMR and obtaining an
eDMR user account, please visit the following web page:
http: / /deq.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR
system shall make the following certification [40 CFR 122.22]. NO OTHER
STATEMENTS OF CERTIFICATION WILL BE ACCEPTED:
"I certify, under penalty of law, that this document and all attachments were prepared
under my direction or supervision in accordance with a system designed to assure that
qualified personnel properly gather and evaluate the information submitted. Based on
my inquiry of the person or persons who manage the system, or those persons directly
responsible for gathering the information, the information submitted is, to the best of my
knowledge and belief, true, accurate, and complete. I am aware that there are
significant penalties for submitting false information, including the possibility of fines
and imprisonment for knowing violations."
5. Records Retention [Supplements Section D. (6.)]
The permittee shall retain records of all Discharge Monitoring Reports, including
eDMR submissions. These records or copies shall be maintained for a period of at
least 3 years from the date of the report. This period may be extended by request of
the Director at any time [40 CFR 122.41].
Page 6 of 6

J.R. Vannoy & Sons Construction Co.
Jefferson Apparel WWTP
NPDES Permit NC0030848
Receiving Stream: Dog Creek
Stream Segment: 10-1-33
River Basin: New
County: Ashe
Stream Class: C-Trout +
Sub -Basin #: 05-07-01
HUC: 0505000102
SCALE
1:24,000
Facility Location
scale not shown
36.449444° ,-81.411389°
USGS Quad: Jefferson

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
This form must be completed by Permit Writers for all expedited permits which do not require
full Fact Sheets. Expedited permits are generally simple 100% domestics (e.g., schools, mobile
home parks, etc) that can be administratively renewed with minor changes, but can include
facilities with more complex issues (Special Conditions, 303(d) listed water, toxicity testing,
instream monitoring, compliance concerns).
Basic Information for Expedited Permit Renewals
Permit Writer/Date
Jennifer D. Busam — 5/6/2016
Permit Number
NC0030848
Facility Name
Jefferson Apparel Company WWTP
Basin Name/Sub-basin number
New / 05-07-01
Receiving Stream
Dog Creek
Stream Classification in Permit
C-Trout + Stream Index: 10-1-33
Does permit need Daily Max NH3 limits?
No — already present
Does permit need TRC limits/language?
No — already present
Does permit have toxicity testing?
No
Does permit have Special Conditions?
No
Does permit have instream monitoring?
No
Is the stream impaired (on 303(d) list)?
No
Any obvious compliance concerns?
No. No enforcements during the current
permit cycle. Not currently discharging.
Any permit mods since last permit?
No
New expiration date
03/31/2021
Changes to 2011 Permit?
Added eDMR requirements
Added regulatory citations
Latitude and longitude coordinates updated
for outfall location
Created a new outfall map
Changes to Draft Permit?
0tJrae' .-c 1i I i mil l 1m4 IL
Most Commonly Used Expedited Language: Vitt Wien
aIi.fW Not iMS
• 303(d) language for Draft/Final Cover Letters: "Please note that the receiving stream
is listed as an impaired waterbody on the North Carolina 303(d) Impaired Waters List.
Addressing impaired waters is a high priority with the Division, and instream data will
continue to be evaluated. If there is noncompliance with permitted effluent limits and
stream impairment can be attributed to your facility, then mitigative measures may be
required".
• TRC language for Compliance Level for Cover Letters/Effluent Sheet Footnote:
"The facility shall report all effluent TRC values reported by a NC certified laboratory
including field certified. However, effluent values below 50 µg/L will be treated as zero
for compliance purposes."

Winston-Salem Journal
Advertising Affidavit
P.O Box 3159
Winston-Salem, NC 27102
NCDENR/DWQ/POINT SOURCE BRANCH
ATTN: WREN THEDFORD
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
Account Number
3376309
Date
May 20, 2016
Date
Category
Description
Ad Size
Total Cost
05/20/2016
Legal Notices
PUBLIC NOTICE North Carolina Environmental Management ( 1 x 44 L
274.52
PUBLIC NOTICE
North Carolina Environmental
Management Commission/
NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Notice of Intent to Issue a
NPDES Wastewater Permit
The North Carolina Environmental
Management Commission proposes
to issue a NPDES wastewater dis-
charge permit to the person(s) listed
below. Written comments regarding
the proposed permit will be accept-
ed until 30 days after the publish
date of this notice. The Director of
the NC Division of Water Resources
(DWR) may hold a public hearing
should there be a significant degree
of public interest. Please mail com-
ments and/or information requests
to DWR at the above address. Inter-
ested persons may visit the DWR at
512 N. Salisbury Street, Raleigh, NC
to review information on file. Addi-
tional information on NPDES permits
and this notice may be found on our
website: http://deq.nc.gov/about/di
visions/water-resources/wate r-
resources-permits/wastewater-
branch/npdes-wastewater/pubiic-
notices, or by calling [phone].
James Vannoy & Sons Construction
Co. has requested renewal of permit
NC0030848 for the Jefferson Apparel
Company WWTP/ Ashe County. This
facility discharges to Dog Creek/
New River Basin. Three parameters
are water quality limited.
WSJ: May 20, 2016
KIMALEY JOHNSON
NOTARY PUBLIC
0 FORSYTH COUNTY
1 STATE OF NORTH CARQLI
MY COMMISSION EXPIRE
A
Publisher of the
Winston-Salem Journal
Forsyth County
Before the undersigned, a Notary Public of Forsyth County, North Carolina, duly
commissioned, qualified, and authorized by law to administer oaths, personally appeared D.
H. Stanfield, who by being duly sworn deposes and says: that he is the Controller of the
Winston-Salem Journal, engaged in the publishing of a newspaper known as
Winston-Salem Journal, published, issued and entered as second class mail in the City of
Winston-Salem, in said County and State: that he is authorized to make this affidavit and
sworn statement: that the notice or other legal advertisement, a true copy of which is
attached hereto, was published in the Winston-Salem Journal on the following dates:
05/20/2016
and that the said newspaper in which such notice, paper document, or legal advertisement
was published was, at the time of each and every such publication, a newspaper meeting all
the requirements and qualifications of Section 1-597 of the General Statutes of North
Carolina and was a qualified newspaper within the meaning of Section 1-597 of the General
Statutes of North Carolina.
This 20th day of May, 2016
Sworn to and subscribed before me, this 20th day of May, 2016
My Commission expires S
1010
THIS IS NOT A BILL. PLEASE PAY FROM INVOICE. THANK YOU

Tim Church
209 Martin Way
Jefferson, NC 28640
March 8, 2016
NC DEQ
ATTN: NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
SUBJECT: Renewal Application for NPDES NC0030848
Jefferson Apparel c/o JR Vannoy & Sons Construction
Jefferson, North Carolina Ashe County
Dear Staff:
RECEIVED/NCDEQ/DWR
MAR 142016
Water Quality
Permitting Section
Please find enclosed the renewal application for NPDES Permit NC0030848 held by JR
Vannoy & Sons Construction Company for the Jefferson Apparel facility. The facility in
question no longer produces a discharge but the permit holder wishes to retain possession
of this permit.
If you have questions or require additional information please call me at [phone]
or contact me by email at jeffwns@century link.net.
Respectfully,
vw.i
equmitL
Tim Church
Operator
cc: Mr. Carlton Yearick, Vannoy & Sons

U.S.DEPARTIENT OF THE INTERIOR
-"USGS
tars changing world U.S. GEOLOGICAL SURVEY
JEFFERSON QUADRANGLE
NORTH CAROLINA-ASHE CO.
7.5-MINUTE SERIES (TOPOG.RAPHI(