WQ0030282_Regional Office Historical File Pre 2018

o4 WA1
—O
1
May 23, 2006
Ms. Christie Putnam, Interim Director
Union County Public Works
400 North Church Street
Monroe, North Carolina 28112
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
Subject: Permit No. WQ0030282
Old Hickory Industrial Park, Phase
-17
Union County Public Works
Wastewater Collection System Extension
Union County, North Carolina
Dear Ms Putnam:
In accordance with your application received on May 18, 2006, we are forwarding herewith
Permit No. WQ0030282, dated May 23, 2006, to Union County Public Works for the construction and
operation of the subject wastewater collection system extension. This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .0227 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2H .0200; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as
applicable, unless specifically mentioned herein. Division approval is based on acceptance of the
certification provided by a North Carolina -licensed Professional Engineer in the application. It shall be
the Permittee's responsibility to ensure that the as -constructed project meets the appropriate design
criteria and rules. Failure to comply may result in penalties in accordance with North Carolina General
Statute §143-215.6A through §143-215.6C, construction of additional or replacement wastewater
collection facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing
board.
Mooresville Regional Office 610 East Center Ave., Suite 301 Mooresville; NC 28115 Phone: [phone] Fax: [phone]
Internet: www.ncwaterquality.org Customer Service: 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer— 50% Recycledll0% Post Consumer Paper
No `Carolina
�117atura!lj

r. Christy Putnam
Page 2
May 23, 2006
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina
as amended, and other applicab4e Laws, Rules, and Regulations, permission is hereby granted to
Union County Public Works for the construction and operation of approximately 540 linear feet of 8-inch
gravity sewer as part of the Old Hickory Industrial Park, Phase'aoject; and the discharge of 1,440
gallons per day of collected domestic wastewater into Union County's existing sewerage system,
pursuant to the application received May 18, 2006, and in conformity with 15A NCAC 2H .0200; the
Division's Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains
adopted June 1, 2000, as applicable; and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Union County -
Crooked Creek WWTP (NPDES No. NC0069841) prior to being discharged into the receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
for Alan W. Klimek, P.E.
cc: Mooresville Regional Office, Surface Water Protection (WWTP Permit No. NC0069841)
Kevin Vogel, LandDesign, Inc.
Surface Water Protection Central Files
Marie Doklovic, PERCS

pr
NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at all times to. prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at feast three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
'accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1 C.
1

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2H .0220, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are. provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part II of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 23rd day of May, 2006.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0030282
3

Fast Track Engineering Certification
• Permit No. WQ0030282
May 23, 2006
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
El Partial ❑ Final
, as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe (❑ periodically, ❑ weekly, ❑ full time) the construction of the Old Hickory Industrial
Park, Phase 7, Union County for the Permittee hereby state that, to the best of my abilities, due care and
diligence was used in the observation of the construction such that the construction was observed to be built
within substantial compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division)
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and
other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

ACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 3
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD! 1 Application Number: •/v�y��.7
(to be completed by DM) Y 1 l-'
1. Owner:
la. Union County Public Works Department
Full Legal Name (company, municipality, HOA, utility, etc.)
Z
0
1b. Christie L. Putnam, P.E. Interim Director Union County Department of Public Works
F„
Signing Official Name and Title (Please review 15A NCAC 2H .0206(b) for authorized signing officials!)
mplc.
C
The legal entity who will own this system is:
❑ individual ❑ Federal ❑ Municipality El State/County ❑ Private Partnership 0 Corporation
•
Other (specify):
0
1 d. 400 North Church street 11 e. Monroe
LL
Mailing Address I City
Z
1 f. NC ilg. 28112-4804
Z
. State Zip Code
0
1h. 704 296-4210 11 i. 704 296-4232 Ili. •
Q
Telephone Facsimile.' E-mail
V
2. Project (Facility) Information: .
J
2a. Old Hickory Industrial Park, Phase 7 • 2b. Union County
O.
CI.
Brief Project Name (permit will refer to this name) 1 County Where Project is Located
Q
3. Contact Person:
Q3a.
Charles P. O'Cain, P:E. Deputy Director Union County Department of Public Works
Name and•Aft liation of Someone Who Can Answer Questions About this Application • • • •
3b. 704 296-4214 . - 3c. O'cain©co.union.nc.us ' •
Phone Number E-mail
•
1. - Project'is
0
New
• Modification (of an existing permit) If Modification, Permit NO.:
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
F. Owner is El Public (skip to Item B(3)) •❑ Private (go to Item 2(a))
Z
0
2a.
i
If
0
•
•
private, applicant will be: 2b.
Retaining Ownership (i.e. store, church, single office, etc.) or'
Leasing units (lots, townhomes, etc. - skip to Item B(3))
Selling units (lots, .townhomes, etc. - go to Item B(2b))
If
■
❑
sold, facilities owned by a (must choose one)
Public Utility (Instruction III)
Homeowner Assoc./Developer (Instruction IV)
.
]—
3. Union County Public Works Dept.
Q
Owner of Wastewater Treatment Facility (WWTF) Treating Wastewater From This Project
w14a.
Crooked Creek WWTP
4b. NC0069841
0
I Name of WWTF
WWTF Permit No.
LL
5a. Union County
5b. 8"
r Gravity
5c. WQ0020132
Z
Owner of Downstream Sewer
Receiving Sewer Size
•
Force Main
Permit Number of Downstream Sewer (if known)
I—
6. The origin of this wastewater is (check all that apply):
2
lY
■ Residential Subdivision
❑ Apartments/Condominiums
• Car Wash
• Institution % Domestic/Commercial
illI
Lt.
0
■
❑
Mobile Home Park
School oV
estaurant r s` b
Office
• Hospital
III■ Church °o Industrial
Nursing Home % Other (specify):
'
9
Other (specify): i e
7. Volume of wastewater to be allocated for this particular project: 1,440 gallons per day
*Do not include previously permitted allocations
8. If the permitted flow is zero, indicate why:
❑ Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
❑ Flow has already been allocated in Permit No.
i ❑ Rehabilitation or replacement of existing sewer with no new flow expected

ACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS PAGE 4
W
Z_
l—
.Z
0
Z
0
2
ce
0
u.
z
B. PERMIT
9. Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(1) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below. Values other than
that in 15A NCAC 2H .0219(I)(1-2) must be supported with actual water or wastewater use data in accordance with 1SA
NCAC 2H .0219(I)(3).
(360 GPD) x (4 LOTS) = 1,440 GPD
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
8
• ENTER TOTAL LINE LENGTH IN MILES
Length (feet)
54'0
• 0.102
11. Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Location ID
(self chosen - as shown on
plans for cross-reference)
Gravity or Force Main
(use the pull down menu)
Gravity
Power Reliability Option
Design Flow , Operational Point ; (1- dual line feed; 2- permanent generator w/ATS; 3-
(MGD) GPM @ TDH portable generator w/telemetry; 4-wet well storage)
12. Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .0200 as applicable?
® Yes 0 No If no, please reference the pertinent minimum design criteria or regulation and indicate why a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
13. Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? 0 Yes 0 No ® N/A
Sedimentation and Erosion Control Plan? ❑ Yes 0 No ® NIA
Stormwater? 0 Yes 0 No ® NIA
14. Does this project involve aerial lines or siphons? Check if yes: 0
These. lines will be. considered high priority and must be checked once every six months_ __ W _ -
115. Does this project have gravity sewer lines designed at minimum slopes? 0
Be aware that the Division will not accept installed lines more than 10% flatter than the minimum slope. Lines instated outside this tolerance should be
corrected prior to submitting the final engineering certification..
FTA 02/03 - Rev. 3 04/05

HACK APPLICATION for GRAVITY SEWERS, PI P STATIONS, AND FORCE MAINS PAGE 5
1. Use the Division's guidance document entitled,"DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
E' A. Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody,
Location iD on Map
(self chosen - as shown on Name of
map for cross-reference) Waterbody
Waterbody Stream Waterbody
County River Basin Index Classification
Submit the 8.5" x 11"' COLOR topographic map as required in Instruction VI
regardless of whether a classification Is provided!
Applicant Certification:
1, Christie L. Putnam, attest that this application for OLD HICKORY INDUSTRIAL PARK, PHASE 7 has been reviewed
by me and is accurate and complete to the best of my knowledge. 1 understand that if all required parts of this application'
are not completed and that if all required supporting documentation and attachments are not included, this application
package is subject to being returned as incomplete, Note,' In accordance with North Carolina General Statutes 143-
215.6A and 143-215,68, any person who knowingly makes any false statement, representation, or certification in any
p. ' at a n shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10, 00t0 as well as civil
up to $25, 000 per vielafkrn.)
ning Official Signi� e
Professional Engineers Certification:
I attest that this application for OLD HICKORY INDUSTRIAL PARK, PHASE 7 has been reviewed by me and is accurate,
complete and consistent with the information in the engineering plans, calculations, and all other supporting documentation
to the best of my knowledge. I further attest that to the best of my knowledge the proposed design has been prepared in
accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February
12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June
1, 2000 and the watershed classification in accordance with Division guidance, Although certain portions of this submittal
package may have been developed by other professionals, inclusion of these materials under my signature and seal
signifies that I have reviewed this material and have judged it to be consistent with the proposed design. Note: In
accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly make any false statement,.
representation, or certification in any application shall be guilty of a Class 2 mttsdemeanwhich ma i elude a fine not to
exceed $10,000 as well as civil penalties up to $25,000 per violation,
2a. Kevin W. Vogel
Professional Engineer Name
2b. LandDesign, Inc,
Engineering Firm
2c. 223 North Graha
Mailing Address
2d, Charlotte
City
2g. 704 376-7777
Telephone
2h, 704 376-8235
Facsimile
E-mail
2f. 28202
Zip
landdesign,com
Sigr
FTA 02/03 - Rev. 3 04/05

Central Files: APS SWP
05/22/06
Permit Number WQ0030282 Permit Tracking Slip
Program Category Status Project Type
Non -discharge In review New Project
Permit Type Fast Track Version Permit Classification
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A Individual
Extensions
Primary Reviewer Permit Contact Affiliation
dee.browder
Permitted Flow
1440
Facility
Facility Name Major/Minor Region
Old Hickory Industrial Park, Phase 7 Minor Mooresville
Location Address
Owner
County
Union
Facility Contact Affiliation
Owner Name
Union County
Dates/Events
Owner Type
Government - County
Owner Affiliation
Christine Putnam, Director Interim
400 N Church St
Monroe
NC 281124804
Orig issue
App Received
05/18/06
Draft Initiated
Scheduled
Issuance
Public Notice Issue
Effective Expiration
Regulated Activities Requested/Received Events
Condominium
Wastewater collection
Outfall NULL
Additional information requested
Additional information received
Waterbody Name Stream Index Number Current Class Subbasin

UNION COUNTY PUBLIC WORKS
400 N. Church Street
Monroe, NC 28112-4804
704/296-4210
Fax [phone]
To: NC Department of Environment and Natural Resources
Mooresville Regional Office
610 East Center Avenue
Suite 301
Mooresville, N.C. 28115
Attention:
TRANSMITTAL
Regarding: Sanitary Sewer to serve Old Hickory Industrial Park, Phase 7
Date: 4/21/06
We are sending you: Ej Copy of letter Q Plans © Prints El Shop Drawings
�I Other
Copies Date No. Description
4/"7/66
417/06
10/18/0
Original Non -Discharge Permit Application
Copy of Non -Discharge Permit Application*,;
Check for $400.00 (Application Fee)
These are transmitted as checked below:
For approval P For your use Q As requested 0 For review and comments
Remarks:
Signed:
Received by: Date:

11:Q
QG
William G. Ross Jr., Secretary
r North Carolina Department of Environment and Natural Resources
--I
CI ,c
Michael F. Easley, Governor
Alan W. Klimek, P.E., Director
Division of Water Quality
October 5, 2006
Union County Public Works
400 North Church Street
Monroe, North Carolina 28112-4804
SUBJECT: Old Hickory Industrial Park Phase 7
Permit No. WQ0030282
Wastewater Collection System Extension
Final Engineering Certification
Dear Permittee:
The Division received a final engineering certification for the subject project on October 2, 2006. A
full review of the certification materials may or may not be conducted. It is assumed that receipt of
this certification indicates compliance with all regulations, design criteria and the permit. Please be
reminded that the Permittee is responsible for keeping a copy of the final record drawings for the
life of the project. If you have not received a copy, please contact your consultant immediately to
obtain a copy.
You are receiving this letter because the Division has.you listed as the responsible party. If this
permitted system is no longer owned by you, please complete Form PNOCF-S as this permit is not
automatically transferable. Form PNOCF-S can be downloaded from
httQ://h2o.enr.state.nc.us/ndpu/ndpuabos.html#Sewer.
If you have any questions concerning this document or the completion of Form PNOCF-S (if
necessary), please contact Ms. Dee Browder at the letterhead address or via E-mail at
[e-mail].
Sincerely,
�-� 1-TU
b. Rex Gleason, P.E.
Surface Water Protection Regional Supervisor
Enclosure
Cc: Kevin W. Vogel
Surface Water Protection Section Central Files (certification page only)
Please forward copy to Engineer
One
NorthCarolina
Naturally
Pretreatment, Emergency Response and Collection Systems Unit Internet httpifi2o.enr.nc.state.uslndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 An Equal Opportunity Action Employer
Telephone [phone] Fax [phone]% recycled/10% post -consumer paper

st Track En • ineerin • Certification
Permit No. WQ0030282
May 23, 2006
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
❑ Partial $1 Final
I, 1t..1 4. COLt el.. , as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe ([bperiodically, ❑ weekly, ❑ full time) the construction of the Old Hickory Industrial
Park, Phase 7, Union County for the Permittee hereby state that, to the best of my abilities, due care and
diligence was used in the observation of the construction such that the construction was observed to be built
within substantial compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division)
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and
other supporting materials.
North Carolina Professional Engineer's
seal, sign tore, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

UNION COUNTY PUBLIC WORKS
400 N. Church Street
Monroe„ NC 28112-4804
704/296-4210
Fax [phone]
To: Mooresville Regional Office �.
Water Quality
610 East Center Ave. Suite 301
Mooresville NC 28115
Attention: Dee Browder
TTAL
Date: 9/28/06
Regarding: Record Drawings and Engineer"s Certification for Sewer to serve Old Hickory Industrial
Park Phase 7 (Final Certification)
We are sending you: D Copy of letter Plans LJ Prints ❑ Shop Drawings
Other
Description
Record Drawings
Engineers Certification for Sewer (WQ0030282)
These are transmitted as checked below:
D For approval For your use 0 As requested El For review and comments
Remarks:
Received by: Date:

Dater 01/07/06
Scale I " 1000'
Project iCX)5276
Sheet. n;
OLD HICKORY INDUSTRIAL PARK
8" SANITARY SEWER EXTENSION USGS TOPO MAP
MERRIFIELD PARTNERS; CHARLEY' I E, NC
MATTHEWS QUADRANGLE 3580-A6-TF-024
LandDesivct
333 tq Strew kas. NC ffi2b1
7043330 33.43

Michael F. Easley, Governor
1rwiSiam G, Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. K➢k, P.E„ Director
ision of Water Quaff`
October 3, 2006
Christie Putnam, Di ector tt° tterirn,,
Union Countyfubfic Works Department
400 Nlh Church Street
y Aroe, NC 28112
SUBJECT: Old HlckoIndustrial Park
Permit No. WQ0030282
Wastewater Collection System Extension
Final Engineering Certification Acknowledgement
Dear Permittee:
Per 15A NCAC 2H .0220, the Division received a final engineering certification for the subject project on
9/29/2006. Enclosed is a copy of the certification page for your records. A full review of the certification
materials may or may not be conducted. It is assumed that receipt of this certification indicates compliance
with all regulations, design criteria and the permit. However, if a full technical review is conducted, you will be
notified of any items of non-compliance. Note that the Division does not acknowledge partial certifications
by letter. It is the Permittee's responsibility to track all submissions and receipt of partial certifications to the
Division.
Please be reminded that the Permittee is responsible for keeping a copy of the final record drawir
life of the project. If you have not received such copy from your consultant, please contact them
immediately to obtain a copy.
s for the
Lastly, you are receiving this letter because the Division has you listed as the responsible party. if this permitted
system is no longer owned by you or your company, please complete Form PNOCF-S as this permit is not
automatically transferable. Form PNOCF-S can be downloaded from http://n2o,enestate.nc.us/percs from
the Collection Systems Applications page.
If you have any questions concerning this document or the completion of Form PNOCF-S (if necessary),
please contact me at the letterhead address or via E-mail at [e-mail],
Thomas Ascenzo
Environmental Technician
Enclosure
Cc:
Kevin Vogel, PE, Land Design Inc (no enc
223 North GrahamStreet , Charlotte, HOC 2322
Surface Water Protection Section Central Des (certification page only)
TOne Pretreatment, Emergency Response and Collection Systems Unit Internet httptTh2n.enr.nc,state.us/ndpu
NorthCcar©llna 1617 Mail Service Center, Raleigh, NC 27699-1617 An Equal opportunity AcOpportunity Action Em«gayer
Natural/Et Telephone [phone] Fax [phone]%, recycled/1 O% post -consumer paper

Fast Track Engineering Certification
Permit No. WQ0030282
May 23, 2006
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension - -
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
. ❑ Partial Final
I, kra• \I,Ot..L.. , as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe (I .periodically, ❑ weekly, ❑ full time) the construction of the Old Hickory Industrial
Park, Phase 7, Union County for the Permittee hereby state that, to the best of my abilities, due care and
diligence was used in the observation of the construction such that the construction was observed to be built
within substantial compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division)
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and
other supporting materials.
North Carolina Professional Engineer's
seal, sign •ture, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

LandDesign.
urban design planning civil engineering landscape architecture
-
September 25, 2006
Mr. Kim Colson
Supervisor, Fast Track Permitting Review System
NC Division of Water Quality
Water Quality Operations
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: Wastewater Collection System Extension
Union County
Permit No. WQ0030282
Old Hickory Industrial Park
Union County
LandDesign PN #1005276
Dear Mr. Colson:
DENR - WATER RUALfTY
POINT SOURCE BRANCH
Please find attached our final certification for the following 2 projects; WQ0030282 and WQ0020132. Please do
not hesitate to call me should you have any questions or comments.
est re
in . Vogel, P.E.
artner
LandDesign 1 Charlotte
704.333.0325
KWVIrc
Enclosures
Cc: Charles 0' Cain, Union Co. Public Works Director
Ken Chapman, Merrifield Partners
223 North Graham Street
Charlotte, NC 28202
L-T1005276130csicwriFicRT1ONs 0.25.08.DOCARTC
V:704.333,0325
F:704.332.3246
www.LandDesign.com
Washington DC
Charlotte NC
Pinehurst NC
Asheville NC
Tampa FL
Nashville TN
Beijing PRC

LandDesign, urban design planning civil engineering landscape architecture
WATER AND SEWER TESTING CHECKLIST
Project Name: Old Hickory Industrial Park Ph. 7
Project Number: 1005276
Date: 9 08 06
Tested By: J and T Utilities
Weather: Warm and Sunny
Observed By: Scott Tarlton Union County
SEWER TESTING LOCATION/ROAD NAME:STINSON-HARDIS ROAD
CC: Ken Chapman Merrifield Partners
Kevin Vogel LandDesign
Location of Line
Size of Line:8 -inch
MH TO MH
MH TO MH
MH TO MH
MH TO MH
MH TO MH
EX34
1
2
Low Pressure Air Test
Length of Time Pressure held per line:
4M1N.4PD.
4M1N.4PD.
N/A
N/A
N/A
Mandrel Pull Test
Passed: Yes/No
Yes
Yes
IN ).]e
N 1 '\
1iN
Location of Line
Size of Line: -inch
MH TO MH
MH TO MH
MH TO MH
MH TO MH
MH TO MH
Low Pressure Air Test
Length of Time Pressure held per
line:
N/A
N/A
NIA
N/A
N/A
Mandrel Pull Test
Passed: YeslNo
�.l N
141+X
N1
NI -IN
N N\
Location of Line
Size of Line:
MH TO MH
MH TO MH
MH TO MH
MH TO MH
MH TO MH
Low Pressure Air Test
Length of Time Pressure held per
fine:
NIA
N/A
N/A
N/A
N/A
Mandrel Pull Test
Passed: Yes/No
07'*C•
il 1-t\
'1\0-Pt's
tl
h\
NW
WATER PRESSURE TESTLOCATIONIROAD NAME: No note sewer only
Size of Line
Did pressure hold for at 200psi for 2 hours: Yes/No?
1-inch
1-inch
1-inch
1-inch
1-inch
No
No
No
No
No
FINAL WALK THROUGH: ® YES ❑ NO
Comments:
All items have been completed.
Signed:
PO Box 36959 Charlotte, NC 28236-6959 223 North Graham Street Charlotte, NC 28202 V: 704.333.0325 F:704.376.8235
FILE PATH: C°,Documents and Setlmostpcubison'ARy DorumentsMater and Seiner Testing Cneckiisi Old H[cknry Industrial park ph.1 lasing rp. k0052769 08 05.dcc