WQ0022105_Regional Office Historical File Pre 2018 (5)

North Carolina Department of
Michael F. Easley, Governor
IdCPrIANCJIWcretary
' td ounces
U u�
SUiLLE REGI4A& 0R
'trW. Klimel E., Director
Division . ater Quality
Jon C. Dyer, Director of Public Works
Union County
400 North Church Street
Monroe, NC 28112
Dear Mr. Dyer:
January 23, 2003
JAW 2 8 2003 1
WATER QUALITY SECTION
Subject: Permit No. WQ0022105
Union County
Rea Road Development
Wastewater Collection System Extension
Union County
In accordance with your application received December 3, 2002, we are forwarding herewith
Permit No. WQ0022105, dated January 23, 2003, to Union County for the construction and operation of
the subject wastewater collection system extension. This permit shall be effective from the date of
issuance until rescinded and shall be subject to the conditions and limitations as specified therein. This
cover letter shall be considered a part of this permit and is therefore incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .0227 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996 as applicable; and the Division's Minimum Design Criteria
for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina Generai Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to Union County for the construction and operation of approximately 892 linear feet of 8-inch
gravity sewer to serve a grocery store, drug store, retail store, gas station, church and restaurant as
part of the Rea Road Development project, and the discharge of 17,838 gallons per day of collected
domestic wastewater into the Charlotte -Mecklenburg Utilities' existing sewerage system, pursuant to
the application received December 3, 2002 and in conformity with 15A NCAC 2H .0200; the Division's
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
DENR Customer Service Center
An Equal Opportunity Action Employer
Internet http://h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

June 1. 2000 as applicable; and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Charlotte -
Mecklenburg Utilities Wastewater Treatment Facility (Permit No. NC0024970) prior to being discharged
into the receiving stream.
This permit shall become voidable unless the agreement between Union County and Charlotte -
Mecklenburg Utilities for the collection and final treatment of wastewater is in full force and effect.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Kristin E. Miguez at
[phone] extension 524.
Sincerely,
k:: 66,1(it
for Alan W. Klimek, P.E.
cc: Union County Health Department
Mecklenbur. Coun De artment of Environment Protection
Section (WWTF Permit No. NC0024970)
Carter & Burgess, Inc.
Charlotte -Mecklenburg Utilities
Central Files
NPDU Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000 as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed prior to January 1, 2004 and shall be actively
maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.
1

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Upon completion of construction and prior to operation of these permitted facilities, a certification, a
copy of the construction record drawings, as well as supporting design calculations for any pump
stations permitted as part of this project shall be received from a North Carolina -licensed
Professional Engineer certifying that the facilities have been installed in accordance with this
permit; 15A NCAC 2H .0200; the Division's Gravity Sewer Design Criteria adopted February 12,
1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Station and Force Main adopted June 1, 2000 as applicable; and other supporting materials. If this
project is to be completed in phases and partially certified, you shall retain the responsibility to
track further construction approved under the same permit, and shall provide a final certificate of
completion once the entire project has been completed. A copy of the construction record
drawings, indicating the facilities constructed in the phase being certified, shall be submitted with
each partial certification. Mail the Engineer's Certification, one copy of the "Construction Record
Drawings", and one copy of the supporting design calculations to the Non -Discharge Permitting
Unit, 1617 Mail Service Center, Raleigh, NC 27699-1617.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall report by telephone to the Mooresville Regional Office, telephone number
[phone], as soon as possible, but in no case more than 24 hours or on the next working
day, following the occurrence or first knowledge of the occurrence of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
2

rb. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
Persons reporting such occurrences by telephone shall also file a written report in letter form within
five days following first knowledge of the occurrence. This report must outline the actions taken or
proposed to be taken to ensure that the problem does not recur.
Permit issued this the twenty-third day of January, 2003
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
for Alan W. Kljnek,J.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0022105
3

Permit No. WQ0022105
January 23, 2003
ENGINEER'S CERTIFICATION
Partial Final
I, , as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project, _ for the
Project Name Location and County
Permittee hereby state that, to the best of my abilities, due care arid diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer
Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as
applicable; and other supporting materials.
North Carolina Professional Engineer's seal, signature, and date:
The above Engineer's Certification shall be completed and submitted to the address below with one
copy of the "Construction Record Drawings" of the wastewater collection system extension as well as
supporting design calculations for any pump stations permitted as part of this project. This project shall
not be considered complete nor allowed to operate until this Engineer's Certification and all required
supporting documentation have been received by the Division. Any wastewater flow made tributary to
the wastewater collection system extension prior to completion of this Engineer's Certification shall be
considered a violation of the permit and shall subject the Permittee to appropriate enforcement actions.
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
4

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen Sullins, Director
Division of Water Quality
July 19, 2007
Union County Public Works
400 N. Church Street
Monroe, North Carolina 28112-4804
SUBJECT: Rea Road Development
Permit No. WQ0022105
Wastewater Collection System Extension
Final Engineering Certification
Dear Permittee:
The Division received a final engineering certification for the subject project on June 21, 2007. A full
review of the certification materials may or may not be conducted. It is assumed that receipt of
this certification indicates compliance with all regulations, design criteria and the permit. Please be
reminded that the Permittee is responsible for keeping a copy of the final record drawings for the
life of the project. If you have not received a copy, please contact your consultant immediately to
obtain a copy.
You are receiving_this letter because the Division has you listed as the responsible party. If this
permitted system is no longer owned by you, please complete Form PNOCF-S as this permit is not
automatically transferable. Form PNOCF-S can be downloaded from
http://h2o.enr.state.nc.us/ndpu/ndpuapps.html#Sewer.
If you have any questions concerning this document or the completion of Form PNOCF-S (if
necessary}, please contact Ms. Dee Browder at the letterhead address or via E-mail at
[e-mail].
Sincerely,
obert Krebs
urface Water Protection Regional Supervisor
Enclosure
Cc: Timothy Campbell, PE
Surface Water Protection Section Central Files (certification page only)
Please forward copy to Engineer
NorthCarohina
Naturally
Pretreatment, Emergency Response and Collection Systems Unit Internet httpJlh2o.enr.nc.state.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 An Equal Opportunity Action Employer
Telephone [phone] Fax [phone]% recycledll0% post -consumer paper

Fast Track Engineering Certification
Union County
PO Box 400 North Church Street
Monroe, NC 28112.
Permit No, WQ0022105
January 23, 2003
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria,
i, Timothy W. Campbell, PE
having been authorized to observe
ENGINEERS CERTIFICATION
L Partial Final
a duly registered Professional Engineer in the State of North Carolina,
periodically, 0 weekly, 0 full time) the construction of Rea Road
Development, a Union County project for the Permittee, hereby state that, to the best of my ,abilities, due care and
diligence was used in the observation of the construction such that the construction was observed to be built
within substantial compliance of this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity
Sewer Minimum Design Criteria adopted February 12, 1g9Et as applicable; the Division's Minimum Design Criteria
for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and other
supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received, Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions,

UNION COUNTY PUBLIC WORKS
400 N. Church Street
Monroe, NC 28112-4804
704/296-4210
Fax [phone]
To: Mooresville Regional Office
Water Quality
610 East Center Ave. Suite 301
Mooresville, N.C. 28115
Attention: Dee Browder
NTTA�L,
TR- #�4 CE
IOORESV(LLE REGIONAL S
� � OFFICE
Err- •- rtr
JUJN 2 1 2007
WATER W LITYSECTION
Regarding: Record Drawings and Engineer's Certification for Sewer to serve Rea Road Development
(Final Certification)
We are sending you:
Copies
1
1
Date
4/4/07
6/11/07
['Copy of letter
® Other
No.
Description
['Plans ❑ Prints
Record Drawings
❑ Shop Drawings
Engineers Certification for Sewer (W00022105)
These are transmitted as checked below:
❑ For approval ® For your use ❑ As requested
Remarks:
Signed:
Received by: v
❑ For review and comments
Date: