NCG551223_Lab Data_20210624

DAVID BRANTLEY & SONS
WASTEWATER TREATMENT INSPECTION REPORT
SYSTEM OWNER:
OPERATOR:
Admin,Admin
Eagle Express -No Permit
!CERTIFICATION:
ADDRESS
PIN#
6132 Hwy 64 E
TAX REC:
Knightdale,NC 27545
SYSTEM OPERATOR:
DAVID BRANTLEY & SONS
DATE OF THIS INSPECTION:
9/8/2021
DATE OF LAST INSPECTION:
6/14/2021
Y N
REMARKS
FACILITY:
Type, size and sewage flow in accordance with permit
TANKAGE:
Risers accessible, surface water diverted?
X
Risers structurally sound, watertight?
X
Sanitary tee in good condition? Effluent filters cleaned?
X
Sludge depth/appearance , level acceptable?
12
Grease Trap:
2
1 st pump tank
EFFLUENT DOSING SYSTEM:
Sludge depth/appearance , effluent appears clear?
0
Required pumps present, operating, and cycling properly?
X
High-water alarm present and operating properly?
X
Vent/floats/pipe/valves/disconnects in good working condition?
X
Control panel/electrical components in good condition?
X
X
Water meter not working
GROUND ABSORPTION FIELDS:
No evidence of effluent surfacing/reaching surface waters?
X
See notes
Minimal ponding in subsurface trenches?
Surface water diverted around fields, no depressions?
X
Pondin9 at discharge
Line cover/vegetation adequate/maintained as needed?
X
Protected from traffic, destructive uses?
Distribution devices accessible?
Distribution devices in good condition, working properly?
Repair areaproperly reserved, maintained?
Turn-ups/cleanouts/valves intact and accessible?
No effluent standing in lower laterals?
Laterals free of excess solids, flushed as needed?
Diversion Ditch/Berm in good condition?
COMMENTS:
Meter reading 1575795. Effluent running
onto parking lot from discharge point
MALFUNCTIONING
X
NEEDS MAINTENANCE
STRUCTURELY NON COMPLIANT
COMPLIANT

II
.
•�
.
.
.
I�
.
ti
.
.
•
_•
.
• •
r ,
..% •
•
.•
�•4;
•F_
it •
.
.. ._ .
• L' •L".uJ
1
.
.
.
.
x
. .
.
•
•
• •.
•
o .
.
_.
.:- ilt•I •J ., "II
..J
-.
■•
ti•
•
I
•
.-u I
•
•
•
•
•
•
r
; •
•
•
•.
•
•
•
•
ti
•
•
•

Yace
Analytical
www.pacelabs.com
6701 Conference Drive
Raleigh, NC 27607
[phone]
June 24, 2021
Dave Welch
DAVID BRANTLEY & SONS
37 PINE RIDGE RD,
Zebulon, NC 27597
RE; Project: Eagle Express
Pace Project No,: 92544172
Dear Dave Welch:
Enclosed are the analytical results for sample(s)
samples included in this report.
Analyses were performed at the Pace Analytical
otherwise footnoted.
The test results provided in this final report were
• Pace Analytical Services - Asheville
• Pace Analytical Services - Eden
received by the laboratory on June 15, 2021. The results relate only to the
Services location indicated on the sample analyte page for analysis unless
generated by each of the following laboratories within the Pace Network:
if you have any questions concerning this report, please feel free to contact me.
Sincerely,
Tyriek Hooks
[e-mail]
[phone]
Project Manager
Enclosures
cc: Cory Brantley, DAVID BRANTLEY & SONS
REPORT OF LABORATORY ANALYSIS
This report shall not be reproduced. except in full
without the written consent of Pace Analytical Services LLC. Page 1 of 11

f..raceAnalyircal
www.pacalatia.com
6701 Conference Drive
Raleigh, NC 27607
[phone]
CERTIFICATIONS
Project: Eagle Express
Pace Project No.: 92544172
Pace Analytical Services Asheville
2225 Riverside Drive, Asheville, NC 28804
FloridafNELAP Certification #: E87648
North Carolina Drinking Water Certification #: 37712
Pace Analytical Services Eden
205 East Meadow Road Suite A, Eden, NC 27288
North Carolina Drinking Water Certification #: 37738
North Carolina Wastewater Certification #: 40
South Carolina Certification #: 99030001
VirginiaNELAP Certification #: 460222
North Carolina Wastewater Certification # 633
VirginiaNELAP Certification #: 460025
REPORT OF LABORATORY ANALYSIS
This report shall not be reproduced, except in full
without the written consent of Pace Analytical Services, LLC
Page 2 of 11

.1,1alce Analytical
www.pacelabs.com
6701 Conference Drive
Raleigh, NC 27607
[phone]
SAMPLE ANALYTE COUNT
Project: Eagle Express
Pace Project No.: 92544172
Lab ID Sample ID
Method
Analytes
Analysts Reported Laboratory
92544172001 Effluent
PAST -A = Pace Analytical Services - Asheville
PASI-E = Pace Analytical Services - Eden
SM 2540D-2011 DAW 1 PASI-E
SM 5210B-2011 DAW 1 PASI-E
EPA 351.2 Rev 2.0 1993 MFO 1 PASI-A
REPORT OF LABORATORY ANALYSIS
This report shall not be reproduced, except in full
without the written consent of Pace Analytical Services LLC. Page 3 of 11

face Analytical
www.pacslabs.com
6701 Conference Drive
Raleigh, NC 27607
[phone]
ANALYTICAL RESULTS
Project: Eagle Express
Pace Project No.. 92544172
Sample: Effluent
Parameters
Lab ID: 92544172001 Collected: 06/15/21 07 45 Received 06/15/21 08:56 Matrix Water
Results
Units Report Limit DF Prepared Analyzed CAS No. Qual
2540D Total Suspended Solids
Total Suspended Solids
5210B BOD, 5 day EDN
BOD, 5 day
351.2 Total Kjeldahl Nitrogen
Nitrogen, Kje:dahl, Total
Analytical Method SM 2540D-2011
Pace Analytical Services - Eden
13.5 mglL 4.6 1
06/17/21 12:14
Analytical Method: SM 5210B-2011 Preparation Method. SM 5210B-2011
Pace Analytical Services - Eden
26.9 mg+L
2.0 1 06/16/2i 17:32 06/21 +21 15:38
Analytical Method: EPA 351.2 Rev 2.0 1993 Preparat on Method • EPA 351.2 Rev 2.0 1993
Pace Analytical Services - Asheville
180 mg1L
5.0 10 06/23/21 21:34 06/24/21 05:40 7727-37-9
REPORT OF LABORATORY ANALYSIS
L2
Date' 06/24/2021 02:28 PM
This report shall not be reproduced, except in full,
without the written consent of Pace Analytical Services, LLC. Page 4 of 11

�raceAnalytical
www.pacelebs.coln
6701 Conference Drive
Raleigh, NC 27607
[phone]
QUALITY CONTROL DATA
Project: Eagle Express
Pace Project No.: 92544172
QC Batch: 627780 Analysis Method: SM 2540D-2011
QC Batch Method. SM 2540D-2011 Analysis Descnption: 2540D Total Suspended Solids
Laboratory: Pace Analytical Services - Eden
Associated Lab Samples: 92544172001
METHOD BLANK: 3300101 Matrix: Water
Associated Lab Samples: 92544172001
Blank Reporting
Parameter Units Result Limit Analyzed Qualifiers
Total Suspended Solids mg/L ND 2.5 06/17/21 12:11
LABORATORY CONTROL SAMPLE: 3300102
Spike LCS LCS % Rec
Parameter Units Conc. Result % Rec Limits Qualifiers
Total Suspended Solids mglL 250 228 91 90-110
SAMPLE DUPLICATE: 3300103
92544536001 Dup
Parameter Units Result Result RPD Qualifiers
Total Suspended Solids
mg/L 1370 2670 64 D6
SAMPLE DUPLICATE: 3300104
92544637001 Dup
Parameter Units Result Result RPD Qualifiers
Total Suspended Solids
mg/L 22.5 28.5 24
Results presented on this page are in the units indicated by the "Units" column except where an alternate unit is presented to the right of the result.
REPORT OF LABORATORY ANALYSIS
Date: 06/24/2021 02:28 PM
This report shall not be reproduced, except n full
without the written consent of Pace Analytical Services LLC. Page 5 of 11

,/• aceAnalytical
www.pacelabs.com
6701 Conference Drive
Raleigh. NC 27607
[phone]
QUALITY CONTROL DATA
Project. Eagle Express
Pace Project No.: 92544172
QC Batch: 627613 Analysis Method: SM 5210B-2011
QC Batch Method: SM 5210B-2011 Analysis Descript on. 5210B BOD, 5 day Final EDN
Laboratory: Pace Analytical Services - Eden
Associated Lab Samples: 92544172001
METHOD BLANK: 3299509 Matrix: Water
Associated Lab Samples: 92544172001
Blank Reporting
Parameter Units Result Limit Analyzed Qualifiers
BOO, 5 day mglL ND 2.0 06/21/21 15:17
LABORATORY CONTROL SAMPLE: 3299510
Sp ke LCS LCS % Rec
Parameter Units Conc. Result % Rec Limits Qualifiers
BOD, 5 day mg/L 198 149 75 84.6-115.4 L2
SAMPLE DUPLICATE: 3299512
92544541001 Dup
Parameter Units Result Result RPD Qualifiers
BOO, 5 day
mg/L 1130 888 24
Results presented on this page are in the units Indicated by the "Units" column except where an alternate unit Is presented to the right of the result.
REPORT OF LABORATORY ANALYSIS
Date: 06/24/2021 02:28 PM
This report shall not be reproduced. except in full.
without the written consent of Pace Analytical Services LLC. Page 6 of 11

/1744ceAnalytical
www.pacalabt.com
ten«.fu.1.. .10,4•�w
6701 Conference Drive
Raleigh, NC 27607
[phone]
QUALITY CONTROL DATA
Project: Eagle Express
Pace Project No • 92544172
QC Batch: 629100 Ana ysis Method: EPA 351.2 Rev 2.0 1993
QC Batch Method- EPA 351.2 Rev 2.0 1993 Ana ysis Description: 351.2 TKN
Laboratory: Pace Analytical Services - Asheville
Associated Lab Samples. 92544172001
METHOD BLANK 3306522 Matrix: Water
Associated Lab Samples: 92544172001
Blank Reporting
Parameter Units Result Limit Analyzed Qualifiers
Nitrogen, Kjeldahl, Total mgfL ND 0.50 06/24/21 04:33
LABORATORY CONTROL SAMPLE: 3306523
Spike LCS LCS % Rec
Parameter Units Conc, Result % Rec Limits Qualifiers
Nitrogen, Kjeldahl, Total mg1L 10 11.0 110 90-110
MATRIX SPIKE & MATRIX SPIKE DUPLICATE: 3306524 3306525
MS MSD
92544712001 Spike Spike MS MSD MS MSD % Rec
Parameter Units Result Conc. Conc. Result Result % Rec % Rec Limits RPD Quai
Nitrogen, Kjeldahl, Total mglL 5.7 10 10 6.1 36.0 5 303 90-110 142 M1,R1
MATRIX SPIKE & MATRIX SPIKE DUPLICATE: 3306526 3306527
MS MSD
92544166002 Spike Spike MS MSD MS MSD % Rec
Parameter Units Result Conc. Conc. Result Result % Rec % Rec Limits RPD Qual
Nitrogen, Kjeldahl. Total mglL 13.0 10 10 29.1 30.1 161 171 90-110 3 M1
Results presented on this page are in the units indicated by the "Units" column except where an alternate unit is presented to the right of the result.
REPORT OF LABORATORY ANALYSIS
Date. 06)24.+2021 02:28 PM
This report she.. not be reproduced, except In full,
without the written consent of Pace Analytical Services, LLC. Page 7 of 11

/w,aceAnalyiical
www.pacelatis.com
I
6701 Conference Drive
Raleigh, NC 27607
[phone]
QUALIFIERS
Project: Eagle Express
Pace Project No.: 92544172
DEFINITIONS
DF - Dilution Factor, if reported, represents the factor applied to the reported data due to dilution of the sample aliquot.
ND - Not Detected at or above adjusted reporting limit.
TNTC -Too Numerous To Count
J - Estimated concentration above the adjusted method detection limit and below the adjusted reporting limit.
MDL - Adjusted Method Detection Limit.
PQL - Practical Quantitation Limit.
RL - Reporting Limit - The lowest concentration value that meets project requirements for quantitative data with known precision and
bias for a specific analyte in a specific matrix.
S - Surrogate
1,2-Diphenylhydrazine decomposes to and cannot be separated from Azobenzene using Method 8270. The result for each analyte is
a combined concentration.
Consistent with EPA guidelines. unrounded data are displayed and have been used to calculate % recovery and RPD values.
LCS(D) - Laboratory Control Sample (Duplicate)
MS(D) - Matrix Spike (Duplicate)
DUP - Sample Duplicate
RPD - Relative Percent Difference
NC - Not Calculable.
SG - Silica Gel - Clean -Up
U - Indicates the compound was analyzed for, but not detected.
Acid preservation may not be appropriate for 2 Chloroethylvinyl ether.
A separate vial preserved to a pH of 4-5 is recommended in SW846 Chapter 4 for the analysis of Acrolein and Acrylonitrile by EPA
Method 8260
N-Nitrosodphenylamine decomposes and cannot be separated from Diphenylamine using Method 8270. The result reported for
each analyte is a combined concentration.
ANALYTE QUALIFIERS
D6
L2
Ml
R1
The precision between the sample and sample duplicate exceeded laboratory control limits.
Analyte recovery in the laboratory control sample (LCS) was below QC limits. Results for this analyte in associated
samples may be based low.
Matrx spike recovery exceeded QC limits. Batch accepted based on laboratory control sample (LCS) recovery.
RPD value was outside control limits.
REPORT OF LABORATORY ANALYSIS
Date: 06/24/2021 02:28 PM
This rep.Nt shall not be reproduced, except in full.
w.thout the wntten consent of Pace Analytical Services, LLC. Page 8 of 11

.PaceAnalytical
www.pacelabs.com
6701 Conference Drive
Raleigh, NC 27607
[phone]
QUALITY CONTROL DATA CROSS REFERENCE TABLE
Project: Eagle Express
Pace Project No.: 92544172
Lab ID
Sample ID QC Batch Method
Analytical
QC Batch Analytical Method Batch
92544172001 Effluent SM 2540D-2011 627780
92544172001 Effluent SM 5210B-2011 627613 SM 5210B-2011 627654
92544172001 Effluent EPA 351.2 Rev 2.0 1993 629100 EPA 351.2 Rev 2.0 1993 629200
REPORT OF LABORATORY ANALYSIS
Date: 06/2412021 02:28 PM
This report shall not be reproduced, except in full
without the written consent of Pace Analytical Services LLC, Page 9 of 11

E
i{
I
I
I
I
I
ti
a
E
n
2
II
0.
.41
W'
4
5
LA
r!
8
IV
do
a.
Le
a
•
4411110144
.7C
5
a
r
E
It
Page 10 of 11

f-2eArktiffoal
Document Name:
Sample Condition Upon Rece pt(SCUR)
Document No.:
]-CAR-CS-033-Rev.07
Document Revised: October 28, 20W
Pate 2 of 2
issuing Authority:
Pace Carolinas Quality Office
s
7
8
9
SO
11
12
*Check mark top half of box if pH and/or dechlorination Is
verified and within the acceptance range for preservation
samples.
Exceptions: VOA, Colfform, TOC, Oil and Grease, ORO/8015 (water) OOC, Wig
"Bottom half of box Is to list number of bottles
7
BPiU-i liter Plastk Unpreserved (N/A)
a
N
V
O
a.
E
a.
a.
Y
•
I
A
Q
T
A
2
S
a
N
V
x
t
N
V
d
A
6
Project WO# :92544172
rya
a
Y
}
•
PM: TIH Due Date: 08/29/21
CLIENT: 91-BRANTLEY
VOAX 16 vials per idt--5035 kit (N/A)
V/GK 13 vials per ktrj-VPH/Gas kit (N/A)
0
2
I
BP3A-250 mu_ Plank (Nii2)2504 (4.3.4.7)
J
Semple ID
Type of Preservative
PH t stmefat t na fnr Preserved Sanmies
pH upon receipt
Oats preservation adjusted Time preservation
adjusted
Amount of Preservative
added
tot V
Nate: Wheneve there 1s a discrepancy affecting North Carolina compliance samp es, a copy of this form will be sentto the North Carolina DEHNR Certification Office (I.e
Out of hold, incorrect preservative, out a temp, ncorrect containers.
Page 11 of 11

■
■ ■ 1.1
II ■
■
I I
■
■
1
■ ■
■
■
■
■
■
1
■
1
1
■
•
r
i
■
■
I
'i