HomeMy WebLinkAboutNC0005762_NPDES Permit Mod_20070621vv=�FR
7-1
17
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources •
Coleen H. Sullins, Director
Division of Water Quality
Mr. Eddie Lanier, Director
Environmental Department
WestPoint Home, Inc.
3300 23ra Drive
Valley, Alabama 36854
Dear Mr. Lanier:
June 1, 2007
DENIR-F 0
JUN 0 6 2007
DW '
Subject: NPDES Permit Modification
Permit Number NC0005762
Wagram Facility WWTP
Scotland County
The Division issued NPDES permit NC0005762 to WestPoint Home, Inc. on October 24, 2005. The
Division has received your March 9, 2007 proposal for permit modification at the subject facility. In your letter, you
stated you would like to make some process modifications at the facility, including converting the equalizationbasin
to an aerated lagoon and taking the aeration basin out of the treatment process.
In accordance with your permit modification request and our review, the Division is forwarding herewith a
modification to the subject permit. Enclosed please find the modified permit page. This page should be inserted into
your permit and the old one discarded. This permit modification is issued pursuant to the requirements of North
Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
Please take notice that this permit is not transferable. This permit does not affect the legal requirement to
obtain other permits which may be required by the Division of Water Quality or permits required by the Division of
Land Resources, Coastal Area Management Act or any other Federal or Local government permit that may be
required.
If you have any questions concerning this permit, please contact Karen Rust at telephone number (919) 733-
5083, extension 361.
Sincerely,
Coleen H. Sullins
cc: Fayetteville Regional"6ffice,_S_urface_W_ater_P.rotection Section
Central Files
NPDES Files
N. C. Division of Water Quality, 1617 Mail Service Center Raleigh, North Carolina 27699-1617 Phone: (919) 733-7015
Internet: http!/h2o.enr.state.nc.us 512 N. Salisbury St. Raleigh, NC 27604
Fax: (919) 733-0719
An Equal Opportunity/Affirmative Action Employer
No�rthCarolina
Naturally
Customer Service
1-877-623-6748
Permit NC0005762
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked. As of this
permit issuance, any previously issued permit bearing this number is no longer effective. Therefore, the exclusive
authority to operate and discharge from this facility arises under the permit conditions, requirements, terms, and
provisions included herein.
WestPoint Home, Inc.
is hereby authorized to:
1. Continue to discharge process effluent, through outfall 001, from a wastewater
treatment facility consisting of the following:
• Mechanical bar screen
• 10 MG aerated lagoon (former equalization basin)
• Clarifiers
• Aerobic digester
• Chemical feed system
• Gravity belt sludge thickener
• Sludge holding tank
• Post aeration
• Effluent flow measurement
Facility is located off NCSR 1407, south of Wagram, Scotland County.
2. Continue to discharge cooling water discharge generated by facilities located at the
Wagram Plant through outfalls 002 & 004, and
3. Discharge wastewater from said treatment works from Outfall 001 at the location
specified on the attached map into the Lumber River which is classified WS-IV, .B
HQW Sw in the Lumber River Basin and discharge cooling water from Outfalls 002
and 004 at the locations specified on the attached map into Big Shoe Heel Creek,
which is classified C-Swamp, in the Lumber River Basin.