WQ0032601_Regional Office Historical File Pre 2018

Michael F, Easley, Governor
William Cr Ross 4r,„ Secretary
North C.2arolina Department Envirortrnem and Natural Resources
Coleen I+ Sullins, Director
Division of VYater Quality
January 10, 2008
Mr, Bob Greback, Town Manager
Town of Stanley
114 S. Main Street
Stanley, NC 28164
Subject: Permit No, WQ0032601
Stanley Commons
Town of Stanley
Wastewater Collection System Extension
Gaston County, North Carolina
Dear Mr, Greback,
In accordance with your application received on January 4, 2008, we are forwarding herewith
Permit No. WQ0032601, dated January 10, 2008, to the City of Stanley for the construction and
operation of the subject wastewater collection system extension, This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein, This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T ,0403 or any
individual system -wide collection system permit issued to the Permittee,
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T, 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable, 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215,6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board,
Mooresville Regional Office 61C1 East Center Ave., Suite 301 Mooresville, NC .28115
Internet. www,ncrowaterqua1ity.org Customer Service 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer —50% Recycled/10% Post Consumer Paper
Phone,. (704) (53-4699 Fav (704) 653-664(1
One
NorthCarotima
,Naturally

Mr, Greback
Page 2
January 10, 2008
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to the City of Mount Holly for the construction and operation of approximately 468 linear feet of
8-inch gravity sewer and the discharge of 8,000 gallons per day of collected domestic wastewater into
the Town of Stanley and the City of Mount Holly existing sewerage systems, pursuant to the application
received January 4, 2008, and in conformity with 15A NCAC 2T; the Division's Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable; and
other supporting data subsequently filed and approved by the Department of Environment and Natural
Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the City of Mount Holly
WWTP (NPDES No. NC0021156) prior to being discharged into the receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatonj hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
Jr Coleen H. Sullins
cc: Mooresville Regional Office, Gravity Sewer Permit File
Riley Burgess, Environmental Design, PA
Surface Water Protection Central Files
Tom Asenzo, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2T
.0403:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L. .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (Le.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215 1C.

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6, Per 15A NCAC 2T .0116, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2T, the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9, In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch, 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B ,0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number (800) -0 or
(19) 733-3300. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form S-SS (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part ll of Form S-SSr (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 10th day of January, 2008.
ORTH ,R LINA ENVIRONMENTAL MANAGEMENT COMCOMMISSION
for Coleen H. Sullins; Director
Division of Water Quality
By Authority of the EnvironmentalManagement Commission
Permit iumh Q003 O

Fr Fast Track Engine
Permit No, WQ0032601
January 10, 2008
Owner/ WQCS
Bob Greback, Town Manager
Town of Stanley
114 S. Main Street'
Stanley, NC 28164
Monroe, NC 28110
ring Certification
\AANTPIWQCS
Eric Davis, City Manager
City of Mount Holly
PO Box 406
Mount Holly, NC 28120
PE
Riley Burgess
Environmental Design, PA
20816 N. Main St, Suite 204
Cornelius, NC 28031
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form, Permit
modifications are required for n chan es esultin non-com a e with this ermit e ulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
L
ENGINEER'S CERTIFICATION
Partial
Final
, as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observe (El periodically, E weekly, full time) the construction of Stanley Commons, a Gaston
County project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial compliance of
this permit; 15A NCAC the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials,
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received, Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions,

ACK APPLICATION for CRAV1T' SEWERS. PUMP STATIONS, AND FORCE MAINS PAGE
USE THE TAB KEY TO MOVE FROM FIELD TO HELD i Application Number: 1:-) 3t,c)
„_ (17, be comp4eted by DVVO
1, Owner:
1 Town icif Stanley
Full Legal Name (company, muncipahty, HOA. utility. etc )
0 1b. 6 re- 6 4,4,k_ To 6...$ei tvl
Signing Official Name and Title (Please review 15,A NCA 2H .0206(b) fofor authorized signing officials!)
l4:(
2 c. The legal entity who will own this system is:
CZ 0 individual 0 Federal El Municipality 0 State/County 0 Private Partnership Corporation 0 Other (specify):
0
z
o.
z
0
z
1—
th
id. 114 S. Main Street
Mailing Address
if NC
State
1h [phone]
Telephone Facsimile
2. Project (Facility) Information:
2a, Stanley Commons
Brief Project Name (permit will refer to this name)
le. Stanley
City
lg, 28164
Zip Code
E-mai
2b. Gaston
County Where Project is Located
3, Contact Person,
3a. Peyton Woody (Civil Designer) Environmental Design, PA,
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b. [phone] 3c, pw9dpanet
Phone Number E-mail
1 Project is Ii New 0 Modification (of an existing permit) If Modification, Permit No.:
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
2. Owner is I4 Public (skip to Item B(3)) 0 Private (go to !tem 2(a))
2a if private, applicant will be. 2b. If sold, facilities owned by a (must choose one)
O Retaining Ownership (i.e. store, church, single office, etc.) or
0 Leasing units (lots, townhomes. etc, - skip to Item ,8(3))
O Selling units (lots, tovvnhomes, etc. - go to Item B(2b))
Town of Stanley
0 Public Utility (Instruction III)
O Homeowner Assoc./Developer (Instruction IV)
Owner of Wastewater Treatment Facility (WWTF) Treating Wastewater From This Project
4a. Mt., ii,Hrti 14L.i9'_rPat-ment Facility
Name of WWTF
5a, Town of Stanley l5b. 8-inch ! Gravity
Owner of Downstream Sewer !Receiving Sewer Size 0 Force Main
6, The origin of this wastewater is (check all that apply):
o Residential Subdivision 0 Car Wash
o Apartments/Condominiums 0 Institution
O Mobile Home Park 0 Hospital
o School 0 Church
Restaurant El Nursing Home
Ej Office El Other (specify):
4b, Oc?Jf5,
VVVVIF Permit No
50. Vo.eqo C 0 Cto gcs
Permit Number of Downstream Sewer (if known)
100 % Domestic/Commercial
% Industrial
% Other (specify):
7 Volume of wastewater to be allocated for this particular project 16.050 gaitons per day
1.7
*Do not include previously permitted allocations
8. If the permitted flow is zero, indicate why:
0 Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
o Flow has already been allocated in Permit No,
o Rehabilitation or replacement of existing sewer with no new flow expected
FLA - Re,. $04'05

ST-TRACT{ APPLICATION fur CRAVTl'Y S i?F'):R , PUMP S'TA"I If}NS, At I FORCE NIINS
PACE 4
Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(I) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below, Values other than
that in 15A NCAC 2H .0219(IX1-2) must be supported with actual water or wastewater use data in accordance with 15A
NCAC 2H .0219(0(3),
((125 seats'40gpd)+(14 employees'25gpd)j+1[(5 employees"25gpd)]+[45 ernpto ees`2 gpd)r ,000 gpd
0. Summary of Sewer Linea to be Perini
Size (Inches)
8-inch
ed (attach additional sheets if necessary)
Length (feet)
R TOTAL LINE LENGTH IN MILES 0.0886
Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Location ID t Power Reliability Option
osen - as shown on ; Design Flow h Operational Point (1- dual line feed; 2- permanent generator w/ATS; 3-
cross•reference) (MGD) GPM 6 TDH ._. portable generatorwttelemetry; 4-wet well storage)
Gravity or Force
use the pull down me
Gravity
2. Does the
Mains (fa
Yes
er system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .0200 as applicable?
No If no, pleas* reference the pertinent minimum design criteria or regulation and indicate why a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? [1 Yes ''itt No © NIA
Yes ©No El N/A
© No O NIA
Sedimentation and Erosion Control Plan?
Stormwater?
Does this project involve aerial lines or siphons? Check if yes:
willbe_ considered teeth arimr41x.enr moat bit checked once every sixmonths.
this project have gravity sewer' lines designed at minimum slo
Be aware that the Division will not accept Installed Ilnes more than 10% flatter than the minlrttu
corrected prior to submitting the final engineering certiflcaton,.
Y
s installed outside this tolerance should be

K APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS PACE 5
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
0 0 A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
0 A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
Location ID on Map
(self chosen - as shown on Name of Waterbody Stream Waterbody
map for cross-reference) Waterbody County River Basin Index Classification
Stream #1 South Stanley Creek Gaston Catawba 11-119-4 WS-IV
LU
0
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1: Applicant's Certification:
1,, attest that this application for Stanley Commons has been reviewed by me and is
accurate and complete to the best of my knowledge. 1 understand that if all required parts of this application are not
completed and that if all required supporting documentation and attachments are not included, this application package
is subject to ,being returned as incomplete, Note: In accordance with North Carolina General Statutes 143-215.6A and
143-215.68, any person w knowingly makes any false statement, representation, or certification in any application
shall be guilty of a ClCpa rn,sderneanor which may include a fine not to exceed $10,000 as well as civil penalties up to
$25,000 perykir
la
Signing Official Signature
2. Professional Engineer's Certificationz
to
e
I attest that this application for Stan/ay Commons has been reviewed by me and is accurate, complete and consistent with
the information in the engineering plans, calculations, and all other supporting documentation to the best of my knowledge.
I further attest that to the best of my knowledge the proposed design has been prepared in accordance with the applicable
regulations. Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February 12, 1996, and the Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 and the watershed
classification in accordance with Division guidance. Although certain portions of this submittal package may have been
developed by other professionals, inclusion of these materials under my signature and seal signifies that! have reviewed
this material and have judged it to be consistent with the proposed design. Note: In accordance with NC General Statutes
143-215.6A and 143-215,6B, any person who knowingly makes any false statement, representation, or certification in any
application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed S/0,000 as well as civil
ci penalties up to $25,000 per violation,
2a. Riley Burgess
Professional Engineer Name
2b, Environmental Design, PA
Engineering Firm
2c. 20816 N. Main St, Suite 204
Mailing Address
2d. Cornelius
City
2e, NC 2f 28031
State Zip
2g. 704-896-8020 2h, 704-892-5479 2i. r,burges ,net
Telephone Facsimile
E-mail Seal, &gnature & Date
ETA 02/03 - Rev, 30405
1

9 I :M"S 'W NZ!

CITY of ou HOLLB'
PostOffice Box 406 n 'taunt Honv. North Car ma 2
December 1200'7
Mr. Bob Greback, 'own to ana er
"fown Of Stanley
PO Box
Stanley, 28164
Dear Mr. eback:
2
7 4- 2`7
7-
d rt4 it#,,M1Eatnr:
David Moore, yor r'resTem
rry Bishop,
yore, Council
, Councilman
McLean,k unc lm
Toomey, Councilman
iry Manager
22-23
ram
ere es as the city of Mount Hollys approval to accept 8,000 gallons per day of
the "Stanley Commons" commercial subdivision in Stanley to our
tefater treatment facility in Mount Holly. Our wastewater treatment facility permit
number is NC0021156. Our Downstream Discharge Permit Number r is OO1 11 6-
1 0.
Sincere
Eric Davis
Mount Holly Ci
y'
onager
"c: James Friday, Mount
y
s Director

it of t uilep
114 Souih Main Street
Stanley, NC 28164
704-263-4779
Friday, December 21,2007
s. Dee Browder, Environmental En ;.
NCDENR DWQ Muor>esQHeRegional Ot,|ce
610 East Center Avenue, Suite 301
Mooresville, NC 28115
BobGreb k
Town Manager
RE: Flow Acceptance Late 'or Stanley Co monsl
Ms Browd :
This letter serves as an approval toaccept: 8 000 gpd wastewater now from the 'Stanley Commons" commercial
subdivision in Stanley mmudhour coll § llllsystem.
)u Coll••et System mE Number is W QCSOQlk¢

Permit Nun her 0032 01
Central r#lea APS WP
1 10108
Pennit Tracking Slip
Program category
Non -discharge
Permit Type
Gravity Sewer Extension, Pump Stations, Pressure Sewer
Extensions
Primary Reviewer
de.browder
Permitted Flow
000
Faciti y
Facility Nam
Stanley Commons
on Address
Owner
Owner Name
Town caf Stanley
Date Events
Gang Issue App Received Draft Initiated
1 / 10/0 12/2 7 a"ti7
Scheduled
Issuance
PO Box 279
Stanley
Public N
Status Project Type
Active New Project
Version
1.00
Permit Classification
Individual
Perm t Contact Affili ti n
ajorll inor Region
linor Mooresville
County
Gaston
Facilitycontact Affiliation
Owner Type
Government - Municipal
Owner Affiliation
Michael IVicl .auxin
NC 2164
Issue Effective Expired
01 /1 t1t 01/10/08
.etutated Abtivttles rasr!lt?ceivl vents
Restaurant
,Afastewater crl#ecnon
trtf ll t l
body Name
dditInnal Infoi
Ad l tlnnal nfcrrnat cry rec ve d
m index Number Current±lass Subbasth