NC0000744_Permit (Issuance)_20100323

NPDES DOCUWENT SCANNIMO COVER SHEET
NPDES Permit: NC0000744
Captain Charlie's Seafood
Document Type:'?' Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Monitoring Report
i
lnstream Assessment (67B)
Environmental Assessment (EA)
Permit
History
Document Date: March 23, 2010
Thies doccaunr��at is pri�t�d o��u.,a��paper-tg�nor��y
coat WMt oMX the X-e WeW 5ft 014a

A;FA
. NCDENR
' North Carolina Department of Environment and Natural Resources .
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
----------------------------------------------------------------------------------------------------------------------------------
March 23, 2010
Mr. Phillip Carawan
Captain Charlie's Seafood,Inc.
P.O. BOCK 164
Columbia,North Carolina 27925
Subject: Issuance of NPDES Permit NCO000744
Captain Charlie's Seafood,Inc.
Hyde County
Dear Mr.Carawan:
The Division of Water Quality(the Division)hereby issues the attached NPDES permit for the subject
facility.This permit is issued pursuant to the requirements of North Carolina General Statute 143-215.1 and
the Memorandum of Agreement between North Carolina and the U.S. Environmental Protection Agency
dated October 15, 2007, or as subsequently amended.
The Division understands that you have not discharged since 2005,but that you intend'to rebuild your
facility destroyed by hurricane. Please be advised that you must contact the Washington Regional Office
(WaRO)prior to startup so that the Division may inspect your new facility prior to any discharge.
If any parts, measurement frequencies, or sampling requirements contained in this permit are unacceptable,
you have the right to an adjudicatory hearing,upon written request submitted within thirty(30) days after
receiving this letter.Your request must take the form of a written petition conforming to Chapter 150B of
the North Carolina General Statutes, and you must file it with the office of Administrative Hearings, 6714
Mail Service Center,Raleigh,North Carolina 27699-6714.Unless such a demand is made,this permit shall
be final and binding.
This permit is not transferable except after notifying the Division of Water Quality. The Division may
require modification, or revocation and re-issuance of this permit. Please note that this permit does not
affect your legal obligation to obtain other permits required by the Division of Water Quality, the Division
of Land Resources,the Coastal Area Management Act,or other federal or local governments.
If you have questions, or if we can be of further service,please contact Joe Corporon at
[ioe.corporon0,ncdenr.goy] or call [phone].
Respectfully,
oleen H. Sullins C s
�iJ( oa E wnrF,�Qc
Enclosure: NPDES Permit NCO000744 FINAL y r
cc: Central Files [hard copy permit final] n
NPDES Program Files [hard copy permit final]
WaRO/SWPS,Attn: Al Hodge [e-copy permit final]
1617 Mail Ser kce Center,Raleigh,North Carolina 27699-1617
Location:512 N.Salisbury$t.Raleigh,North Carolina 27604 One �-+
Phone:[phone] FAX:[phone] Customer Service:1-877-623•6748 NmthCaro1 ha
Internet:www.ncwaterquality.org An Equal Opportunity 1 Affirmative Action Employer ,Naturally
y

Permit NC0000744
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
Captain Charlie's Seafood, Inc.
is hereby authorized to discharge wastewater from a facility located at
Captain Charlie's Seafood, Inc.
261 Hightop Road
Englehard, NC
Hyde County
to receiving waters designated as Far Creek in the Tar-Pamlico River Basin in accordance with effluent
limitations,monitoring requirements, and other conditions set forth in Parts 1, II, and III and IV hereof
The permit shall become effective May 1, 2010.
This permit and the authorization to discharge shall expire at midnight on November 30, 2014.
Signed this day March 23, 2010
olleen H. Sullins, Director
"I 0 r Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0000744
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility,whether for operation or discharge are hereby revoked.As of this permit
issuance,any previously issued permit bearing this number is no longer effective.Therefore,the exclusive authority to operate
and discharge from this facility arises under the permit conditions,requirements, terms,and provisions included herein.
Captain Charlie's Seafood, Inc. is hereby authorized to:
1. Continue to generate untreated/monitored wastewater from a seafood processing and packing
operation including wastewater from crab processing (Outfall 001) and oyster shucking (Outfall
002) at a facility located at 261 Hightop Road Englehard,NC in Hyde County.
2. Discharge from said processing and packing works(see attached map) into Far Creek, a stream
currently classified as SC-HQW waters within the Tar-Pamlico River Basin.

-A
T, '.-t
'3�
4%
tip4a4
4
4 w
01­0
R L k4.* I
n
v
X 3
jrr7F
-
A,
k w.
2
,1,
2
4
R.—
R
dr.
i:
;..Q
1,5
a,
gg 4
'71
42, ej
AY.
All" . srt 4
V. J�
L AF",
4
x
r:1
77 tZ �:l
N
Qp,.�;, A v,7,t.C4.,
A
5 x?`
J,
MOM44 110e�ffsL 4P
it-I
4315fl. MOO
&i
F)
Engel FAR
4V wPlh--7 F
'. a yes,�_• � j.¢ _ ._ , ,. . � �. I �>,M, - ` I
Coo,
Gibt)4
Fko4nt
(0 Q
Captain Charlie's Seafood, Inc. Facility
Location
Slate Grid/Quad: E 35 SW 1 Engelhard East
Latitude: 35*30'27" not to scale
konaitudk' 76'59'26" Permitted Flo.w;; Not Limited it NCO000744
Receivinil Stream: Far Creek Drainage Baste: Tar--Pamlico North
NPDES Perm
&Mngaass: SC-HQW Sub-Basin: 03-03-08 1 HYLC County

Permit NC0000744
A. (1} EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS 10011
During the period beginning on the effective date of the permit and lasting until expiration,the Permittee is authorized to
discharge crab cooking wastewater from outfall 001, Such discharges shall be limited and monitored by the Permittee as
specified below:
Parameter ... Limits,- Monitarin Re uirements
OUTFALL#001 Monthly Daily': Measurement Sample Type Sampld
Average Maximum Frequency Location
Flow Annually Instantaneous Effluent
Total Suspended Solids' 1.75 5.72 Annually Grab Effluent
pounds/day pounds/day
Oil and Grease' 0.50 1.56 annually Grab Effluent
pounds/day pounds/day
PH > 6.8 and< 8.5 standard units Annually Grab Effluent
Temperature Annually Grab Effluent
Footnotes:
I. The limit is for the combined mass loading from both outfalls 001 and 002(See Special Condition A.(3.)
2. See Special Condition A. (6.)
See Special Condition A.(4.) Best Management Practices
See Special Condition A. (5.) Dry Cleanup Procedures
A. (2) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS [0021
During the period beginning on the effective date of the permit and lasting.until expiration,the Permittee is authorized to
discharge oyster shucking wastewater from outfall 002. Such discharges shall be limited and monitored by the Perrnittee as
specified below:
Parameter Limits .xLF �` 1 .. , ` ' :Monitor�nQ'Reguirements
r '� ry r! �' "�yx!.� e Sn. - _, _ ? '� -2 l :+^ S �; - Y �Y•,3`., t- .'��.� .+. . i�tr s .n".,
'OUTFALL,#„002 i ;-Monthly'; s•" Dailr,4 Measurement Sazriple Type Sample =
no' i•oduction rovided '. ,; Avera a Maximum . Fre uenc s' 'it' ' ' t tl.. r:, ' -..: Location
Flow Annually Instantaneous Effluent
Total Suspended Solids' Annually Grab Effluent
Oil and Grease' Annually Grab Effluent
PH > 6.8 and < 8.5 standard units Annually Grab Effluent
Temperature Annually Grab Effluent
Footnotes:
1. Report this value on the Discharge Monitoring Report for Outfall 002.
2. See Special Condition A.(6.)and A.(7.)
See Special Condition A. (4.) Best Management Practices
See Special Condition A. (5.) Dry Cleanup Procedures

Permit NC0000744
A. (3) Total Suspended Solids and Oil & Grease Reporting Requirement
Outfalls 001 and 002 shall both be independently sampled and monitored annually for oil &grease and
Total Suspended Solids (TSS).
The value reported on the discharge monitoring report for Outfall 001 shall be the sum of mass loading from
both Outfalls 001 and 002.
1. i.e. Value reported on Discharge Monitoring Report for Outfall 001.
2. ,Oil &Grease = pounds/day for Outfall 001 + pounds/days for Outfall 002
3. TSS = pounds/day for Outfall 001.+ pounds/day for Outfall 002
A. (4) Best Management Practices (BMPs)
BMPs must be employed to ensure that excessive pollutants are not discharged to the surface water of the
state. These practices should include as a minimum the following:
1. No discharge of fish or crab parts, floating solids, foam visible in other than trace amount,
2. The permittee shall direct employees and provide resources to follow, at a minimum, the following
practices such that wastewater volume and wastewater constituents are reduced:
a. All hoses used to provide on-demand water shall be equipped with automatic shut-off nozzles.
b. Personnel shall be instructed to eliminate flows through idle equipment.
c. All process and washdown equipment shall be fitted with high pressure/low volume nozzles.
d. Dry cleanup shall be preformed prior to washdown of the facility
A. (5) Dry Cleanup Requirements,
Dry Cleanup shall emphasize the following techniques where practical;
Batter drippings shall be collected in pans under the breading tables.
a. Spilled batters shall be squeegeed off the floor prior to wet cleanup.
b. Leftover batter shall be collected in a container and disposed of properly. Discharge to surface
waters of batter residuals shall not be allowed.
c. Trays shall be placed under machines and conveyor belts to catch particles of breading or other
food products.
d. Employees shall be instructed to remove, by hand or other method, leftover breading from sifters
and other machines prior to these solids entering the drainage system.
e. Flooring shall be brushed with a stiff broom prior to wet cleanup.
A. (6) Temperature Condition
The temperature of the effluent shall not cause the temperature of the receiving stream to increase by more
than 0.8 °C above the natural water temperature during the months of June,July, and August nor more
than 2.2°C during any other month and in no case to exceed a maximum of 32°C.
A (7) Biocide Condition
There shall be no chromium, zinc or copper added to the treatment system except as pre-approved
additives to biocidai compounds.
The Permittee shall obtain approval from the Division of Water Quality's Aquatic Toxicology Unit (ATU) prior
to the addition of any biocidal compound to the water discharged from outfall(s) 001. Approval for use of
new compounds (not previously approved) must be submitted to the ATU at least 90 days in advance of any
planned use of those compounds.

BEAUFORT COUNTY
NORTH CAROLINA
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said County
and State, duly commissioned, qualified and authorized
by f law to administer oaths, personally appeared
) ' a ho being first duly ', Piit3uc nto ice;-w
North`Carollria-7 nvironliiental w:6-
sworn as a representative of the Washington Daily agement commissionlNPDES,,unii Y
News, a newspaper, published, issued and entered as 1617 Mail Service Center
p Raleigh,NC 27fi99 1677
second class mail in Washington, NC in said county and Notice.of Intent to issue'a,NPDES
Wastewater Permit
state and is authorized to make this affidavit and sworn
-The,.North Carolina. Environmental 1
statement; that the notice or other legal advertisement, a fufanagenientrcommission proposes
true co of which is attached hereto was published in '�o,issu"a a NPDES wastewater dis
copy 1} charge permit to the person(s)listed.,`
below;.
the Washington Daily News on the following dates: .
Writteri�comments'regarding the prate
j ppsed�permd will be accepted i ntrj'
30.days after the publish date ofithis,
'notice,The Director of the NC DKA1
stop of Water;Quality (DWo) may
'bold tia`,public'hearing should therej:
be'a significant degree'of"putilicSln -
and that the said newspaper in which such notice, paper, teresE Please mall:commems,and/or
document, or legal advertisement was published was, at above addtion ess, I ts_to DWQ`'at7ttie�
p above address, Interested perso'ss
the time of each and eve publication, a newspaper may visit the DWQ at512 N"$ells
every Ptiuiy street. Raleigh, NG to revlew 1
meeting all of the requirements and qualifications of information on fife. Add it!onal i`Hfor,
matipn on NPDES
permits andRttils>:,
Section I-597 of the General Statutes of North Carolina notice may be found on our wetisue,;
www,ncwaterquality.org, or by cell. .
and was a qualified newspaper within the meaning of Ing(919)607-6304::
Section I-597 of the General Statutes of North Carolina. Captain Charlie's Seafood, Inc: has
/` applied to renew its active NPDES
This da y Fa of - _ 20 v permit (NC0000744).dischtirging to
r Creek in the Tar•Pamlicb'.River
satin ,
(Signature of person making affidavit)
Sworn to and subscribed before me, a Notary Public, r
this day of �,✓ , 20�, r I
(Notary Public)
My commis 4on ire0D0
Publication cost $ paid.

CAPT. CHARLIE'S SEAFOOD, INC.
508 NORTH ROAD STREET
COLUMBIA, NC 27925
252-796-0795
252-796-1348
September 7, 2009
Dear Sirs:
We would like to renew our permit for Capt. Charlie's Inc. for the existing limits we have
on our previous permit. The application is filled out to the best of my knowledge because
all of our records were destroyed during hurricane Isabel. We have still yet to open our
plant back up in Engelhard but we would still like to renew the permit in case we decide
to reopen in the future. Thank you very much and please do not hesitate to call with any
questions please call 252-796-0795.
Thanks Again,
Tara Foreman
Capt. Charlie's Seafood, Inc.
P O Box 164
Columbia,NC 27925
252-796-0795 ext 23

Weaver Charles
From: Bullock, Robert
Sent: Tuesday, July 21, 200911:25 AM
To: Weaver, Charles; Rust, Karen
Cc: Jarman, Kristin
Subject: FW: NC0000744-Captain Charlie's Seafood
Karen,
I called (252-796-0795) a phone number listed on the l7MR and talked with a secretary arid she gave me this address.
Hope this will help.
PO Box 164
Columbia NC 27925
Thanks,
Robbie
Robbie Bullock
WWTP Consultant
252-948-3924 Phone
"E-mail correspondence to and from this address may be subject to the North Carolina Public
Records Law and may be disclosed to third parties. "
From: Rust, Karen
Sent:Tuesday, July 21, 2009 10:43 AM
To: Bullock, Robert
Subject: FW: NC0000744-Captain Charlie`s Seafood
From: Weaver, Charles
Sent: Monday, July 20, 2009 1:20 PM
To: Hodge, Al
Cc: Jarman, Kristin; Rust, Karen
Subject: NC0000744-Captain Charlie's Seafood
FYI-I sent an NOV to the permittee for failure to submit a renewal application. The NOV was returned by t1SPS stamped
"No Mail Receptacle".
Their most recent annual fee (due 6/27/2009] is unpaid.
Has this one gone out of business?
If anyone knows more, please enlighten me.
Thanks,
CHW
Messages to and from this address are subject to the N.C. Public Records law.
1