WQ0030839_Regional Office Historical File Pre 2018

Michael. F, Easley, Governor
William G. Ross Jr,, Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, PE, Director
Division of Water Quality
October 4, 2006
Mr. Wilmer Melton, HI, Director Public Yorks
City of Kannapolis
1401 Bethpage Road
Karmapolis, North Carolina 28081
Subject: Permit No. WQ0030839
Proposed Fire Station No.5 Site
Wastewater Collection System Extension
Cabarrus County, North Carolina
Dear Mr,
In accordance with your application received on September 22, 2006, we are forwarding
herewith Permit No. WQ0030839, dated October 4, 2006, for the construction and operation of the
subject wastewater collection system extension. This .permit shall be effective from the date of issuance
until rescinded and shall be subject to the conditions and limitations as specified therein. This cover
letter shall be considered a part of this permit and is therefore incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division.) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000„ as
applicable, unless specifically mentioned herein, Division approval is based on acceptance of the
certification provided by a North Carolina -licensed Professional Engineer in the application. It shall be
the Permittee's responsibility to ensure that the as -constructed project meets the appropriate design.
criteria and rules. Failure to comply may result in penalties in accordance with North Carolina General
Statute §1.43-21.5.6A through §143-215.6C, construction of additional or replacement wastewater
collection facilities, and/or referral of the North Carolina -licensed. Professional. Engineer to the licensing
board.
Mooresville Regional Office 610 East Center Ave,, Suite 301 Mooresville, NC 28115
Internet: immcwaterquality.org, Customer Service: 1-877-6,23-6748
An Equal OpportunitylAffirrnative Action Employer - Recycled00% Post Consumer Paper
Phone: [phone] Fax: [phone]
NOic
o h
„Naturally

Mr Wilmer Melton
Page 2
October 4, 2006
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby granted
to the City of Kannapolis for the construction and operation of approximately 2,170 linear feet of 8-inch
gravity sewer as part of the Proposed Fire Station No. 5 Site sewer extension, and the discharge of
1,500 gallons per day of collected domestic wastewater into the City of Kannapolis existing sewerage
system, pursuant to the application received September 22, 2006, and in conformity with 15A. NCAC
2T; the Division's Gravity Sewer Minimum Design Criteria adopted February 12,1996, as .applicable;
the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting data subsequently filed and approved
by the Department of Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Rocky River
Regional WWII' (NPDES No. NC0036269) prior to being discharged into the receiving stream.
If any parts, requirements, or limitations contained in this perrnit are unacceptable, you have the
right to request an adjudicator), hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 1.50B of North.
Carolina. General Statutes, and tiled with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and binding.
If you need additional information concerning this matter, please contact Sarnar Bou-Ghazale at
[phone].
Sincere
'? for Alan W. Klimek, PE.'
cc: Mooresville Regional Office, Surface Water Protection (WWTP Permit No. 'NC0036269)
Jeffery Moody, Alley, Williams, Carmen & King, Inc.
Surface Water Protection Central Files
Tom Ascenzo, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and. limitations:
L This permit shall become voidable unless the wastewater collection .facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
This permit shall be effective only with respect to the nature and volume of wastes described in the
application. and other supporting data.
The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system .permit for the
operation and maintenance of these facilities as required by 1.5A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met. as provided. in 15A NCAC 2T
.0403:
a, The sewer system s.hali be effectively maintained and operated at all times to prevent discharge
to land or surface waters, and any contravention of the groundwater standards in 15A NCAC
21-0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained,
c. An operation and maintenance plan shall be developed and implemented,
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e..
36.5 days per year). Pump stations that are connected to a telemetry system shall be inspected at
least once per week.
e. High -priority sewer lines shall be inspected at leastonce per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.

4. This permit shall not be transferable. In the event there is a desire fir the wastewater collection facilities
to change ownership, or there is a name change of the Permittee, a formal permit request shall be submitted
to the .Division accompanied by documentation from the parties involved, and other supporting materials as
may be appropriate. The approval of this request shall be considered on its .merits and may or may not be
approved.
Construction of the gravity sewers, pump stations, and 'force mains shall be scheduled so as not to interrupt
service by the existing utilities nor result in an overflow or bypass discharge of wastewater to the surface
i,vaters of the State.
6. Per 1.5A NCAC 2T .0116, upon completion of construction and prior to operation of these permitted
facilities, the completed. Engineering Certification form attached to this permit shall be submitted with the
required supporting documents to the address provided on the form. ,A complete certification is one where
the form is fully executedand the supporting documents are provided as applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life of the
wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 211 .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's 'Minimum
Design Criteria for the Fa.st-Trac,k Permitting of Pump Station and Force Mains adopted June 1, 2000 as
applicable; and other supporting materials may subject the -Permittee to an enforcement action by the
Division, in accordance with North Carolina General Statutes §I43-215.6A through §143-21.5,6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may be required
by this Division, such as the construction of additional or replacement facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all statutes, rules,
regulations, or ordinances that may be imposed by other governm,ent agencies (local, state and federal) which
have jurisdiction, including but not limited to applicable river buffer rules in 15A NCAC 2B .0200, erosion
and sedimentation control requirements in 15A NCAC Ch. 4 and under the Division's General Permit
NCG010000, and any requirements pertaining to wetlands under 15A NCAC 2,B ,0200 and 15A NCAC 2H.
.0500,
11 Noneonipliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the -Mooresville, Regional
Office, telephone number (704). 66.3-1699, as soon as possible, but in no case more than 24 hours or on the
next working day, following the occurrence or first knowledge of the occurrence of either of the following:
a. Any process unit failure, due to known or .unknown reasons, that renders the facility incapable of
adequate wastewater transport, such as mechanical or electrical failures of pumps, line blockage or
-breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters Without
treatment of all or any portion .of the influent to such station or .facility.
Voice mail messages or faxed information is permissible, but shall not be considered as the initial verbal
report. Overflows and spills occurring outside normal business hours .may also be reported to the Division
of Emergency Management at telephone number [phone] or (919) 7.33-3.300. Persons reporting
any of .the above occurrences shall file a spill report by completing Part 1 of Form CS-SSO (or the most
2

current Division approved form), within five days following first knowledge of the occurrence. This
report shall outline the actions taken or proposed to ensure that the problem does not recur. Part II of
Form CS-SSO (or the most current Division approved fOrm) can also be completed to show that the SS()
was beyond control.
Permit issued this the 4th day of October, 2006.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Enviromuenta I Management Commission
Permit Nuitiber WQ0030839

Fast Track Engineering Ce
Permit No, WQ0030839
October 4, 2006
on
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection system
extension
Supporting design calculations (selected pumps, system curve, operating point, available storage if portable generator(s)
or storage greater than longest past three year outage reliability option selected) for any pump stations permitted as part
of this project
Changes to the: project should be clearly identified on the record drawings or in written summary: form. Permit
modifications are required for an chan ,es resulting -in non-compliance with this permit, regulations or minimum design
criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all required
supporting documentation have been received by the Division, Therefore, it is highly recommended that this certification
be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
Partial LI Final
1. , as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observeperiodically, LI weekly, FTJ fill time) the construction of proposed Fire Station No,5 Site project,
Cabarrus County, for the permittee , hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to he built within substantial compliance of this
permit; 15A NCAC 2T :0200; the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12,1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting ofPump Stations and
Force. Mains adopted June I, 2000 as applicable; and other supporting materials,
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION'
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Pennittee is responsible for tracking all partial certifications up until a final certification is received. Any wastewater
flow made tributary to the wastewater collection system extension prior to completion of this Engineer's Certification shall be
considered a violation of the permit and shall subject the Permittee to appropriate enforcement actions,

CCU. APPLICATION for GRAV '"Y SE'ti'4'ERS PZT1i P STATIONS, ANI) FORCE MAINS PAGE
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD
Owners
la. City of Kannapolis_ m m _ _
Full Legal Name (company, municipality, HOA, utility, etc,)
Z lb. Wilmer Melton, Director Public Works
0
Qlc, The legal entity who will own this system is:
{'] Individual 0 Federal Z Municipality E State/County D Private Partnership Corporation © Other {specify):
Application Number:
(to be completed by DVQ)
2
0
2
0
LL
z
Signing Official Name and Title (Please review 1SA NCAC 2H .0206(b) for authorized signing officials!)
d. 1401 Beth a e Road
Street Address
if. NC
State
1 h. 704.920-4200 1 i. 704920-4244
Telephone Facsimile
2. Project (Facility) Information:
2a, Proposed Fire Station No. 5 Site
Brief Project. Name (permit will refer to this name
3 Contact Person:
Jeffery-D. Moody, RE, Alley, Williams„ Carmen & King, Inc,
Kannapolis
City
1 g. 28081
Zip Code
wmelto ci.kenna olis,no,us
E-mail
2b. Cabarrus
County Where Project
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b. 704-938-1515
Phone Number
3c, mood awck.com
E-mail
1 Project is Z New Modification (of an existing permit) tf' Modification, Permit No,:
For modifications, attach a separate sheet clearly explaining the reason for the modification (Le. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
2 Owner is Public (skip to Item 8(3)) © Private (go to Item 2(a))
2a if private, applicant will be: 2b. If sold, facilities owned by a (must choose one,
El] Retaining Ownership (i.e. store, church, single office. etc,) or
© Leasing units (lots, townhomes, etc. - skip to Item B(3))
0 Selling units (lots, townhomes, etc. - go to item B(2b))
3. Water and Sewer Authority of Cabarrus County
Owner of Wastewater Treatment Facility (WWTF) Treating
4a, Rocky River Regional Waste Water Treatment Plant
Name of WWTF
5a City of Kannaapolis
Owner of Downstream Sewer
The origin of this wastewater is (check all that apply).
Residential Subdivision
0 Apartments/Condominiums
Mobile Home Park
School
0 Restaurant
LJ Office
5b. 8 in
7 Volume of wastewater to be permitte
Receiving Sewer Size
Q Public Utility (Instruction III)
0 Homeowner Assoc./Developer (Instruction IV)
ewater From This Project
4b NC0036269
WWTF Permit No,
c WQ0019829
Permit Number of Downstream Sewe
Q Car Wash
Institution
0 Hospital
[ Church
Nursing Home
El Other (specify): Fire Station
if known
100 % Domestic/Commercial
% Industrial
% Other (specify):
8. If the permitted flow is zero, indicate why:
Interceptor Line - Flow will be permitted is subsequent permits that connect to this line
❑ Flow has already been allocated in Permit No.
[] Rehabilitation or replacement of existing sewer with no new flow expected
F°'I"A 02.03 - Rev. 1 06r"03

z
z
0
z
ACK APPLICATION for GRAVIT
SEW
RS, PUMP STATION S, AND FORCE MAINS PAGE 4
Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
0219(t) for Item B(7) or the design flow for dine or pump station sizing if zero flow in the space below. Values other than
that in 15A NCAC 2H .0219(I)(1-2) must be approved prior to submittal of this application. Submit a separate request to
the Division of Water Quality, Non -Discharge Permitting Unit, 1617 Mail Service Center, Raleigh, NC 27699-1617 in
accordance with 15A NCAC 2H ,0219(I)(3).
Proposed Fire Station No. 5 will have 20 full time employees x 75 gpd per person = 1500 gallons per day,
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
8 DIP
8 PVC
ENTER TOTAL LINE LENGTH IN MILES
Length (feet)
1580'
590'
0 41 miles
11. Summary of Pump Stations to be Permitted (attach additional sheets as nece
Gravity or Force Main
(use the pulp down menu)
Gravity
Gravity
Location ID Power Reliability Option
(self chosen - as shown on Design Flow Operational Point (1- dual fine feed; 2- permanent generator w/ATS; 3-
plans for cross-reference) (MGD) GPM @ TDH portable generator w/telemetry; 4-wet well storage)
N/A
12. Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H ,9200 as applicable?
Yes ❑ No If no, please reference the pertinent minimum design criteria or regulation and indicate why a
variance is requested: See Attachment
SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
13. Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? NI Yes ❑ No ❑ N/A
Sedimentation and Erosion Control Plan? NI Yes ❑ No ❑ NIA
Stormwater? ❑ Yes ❑ No NI N/A
F I°.A 02103 - Rev, 1 06/0..3

/^1
00
CK AP CATION for GRAVITY SEWERS, PUMP STATIONS, AN]) FORCE MAINS
PAGE 5
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary), This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
0
0 A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
El A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody,
w
0
0
0
Ce.
w
0
Location ID on Map
(self chosen - as shown on Name of Waterbody Stream Waterbody
map for cross-reference) Waterbody County River Basin Index Classification
Sewer Crossin
UT of Afton Run Cabarrus Yadkin
13-17-6-6
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1 Applicant's Certification:
1, Wilmer Melton, ill, Dir. Public Works, attest that this application for Proposed Fire Station No. 5 Site
has been reviewed by me and is accurate and complete to the best of my knowledge 1 understand that if all required
parts of this application are not completed and that if all required supporting documentation and attachments are not
included, this application package is subject to being returned as incomplete. Note: In accordance with North Carolina
General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement, representation, or
certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10,000
as well as civil penalties up to $25, 000 per violation,
la
Signing Official Signature
2, Professional Engineer's Cerbflcation:
7.,11.66
Date
I attest that this application for Proposed Fire Station No. 5 Site has been reviewed by me and is accurate, complete
and consistent with the information in the engineering plans, calculatbns, and all other supporting documentation to the
best of my knowledge, I further attest that to the best of my knowledge the proposed design has been prepared in
accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February
12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June
1, 2000 and the watershed classification in accordance with Division guidance. Although certain portions of this submittal
package may have been developed by other professionals, inclusion of these materials under my signature and seal
signifies that I have reviewed this material and have judged it to be consistent with the proposed design, Note: In
accordance with NC General Statutes 143-215,6A and 143-215,68, any person who knowingly makes any false statement,
representation, or certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed $10,000 as well as civil penalties up to $25,000 per violation,
2a, Jeffery D. Moody, P.E.
Professional Engineer Name
2b Alley, Williams, Carmen & King, Inc
Engineering Firm
2c 120 South Main Street
Address
2d, Kannapolis 2e. NC 2f. 28082
City State Zip
: 704-938-1515 2h. 704-938-6810 2ijimoody@awck,com
Telephone Facsimile E-mail Seal, Signature & Date
PIA 02/03 - Rev„ 1 0603

er Crossing4
Kannap©lis Quadrangle

(2)
September 20, 2006
7
NC Div of Environmental Management
Department of Environment and 'Natural Resources — Division of Water Qua
61.0 East Center Drive, Suite 301
Mooresville, North Carolina 28115
Re: City of Kannapolis
Kannapolis Fire Station No. 5 Site
Dear Sir or Madam:
y
06502A
Please find attached for review and approval the original and one copy of the permit application,
and the processing fee of $400.00. The 'Water & Sewer Authority of Cabarrus County Standard
Specifications for Wastewater Collections Systems were approved by your office on August 11,
1993 and are being maintained by the Division of Environmental Management. New Water &
Sewer Authority of Cabarrus County Standard Specifications were submitted December 1995,
for review and approval. This project will be installed in accordance with the Water & Sewer
Authority of Cabarrus County Standard Specifications.
This project consists of the installation of approximately 2,170 LF of 8-inch Gravity Flow Sewer
Pipe. A sewer flow of 1,500 gallons per day will be added to the system with this extension.
The system will be operated and maintained by the City of Kannapolis. Please call me at
704-938-1515 if you have any questions.
Sincerely,
ALLEY, WILLIAMS, CARMEN & KING, INC.I
fery D. Moody, PE
06502A Sewer Permit Lettm doe
DURCES
OFFME
SEP 2 2 201L
120 1248: 22,-.112
_ 938-6810 awck: cf„.1,rn

CC
vVS
I
PavA'ER ALTHORlTY
QF CABARRUS COUNTY
Mr. Michael Legg
City Manager
City of Kannapolis
PO Box 1199
Kannapolis, NC 28082-1199
Fax:[phone]
September 20, 2006
Subject: Flow Acceptance
Kannapolis Fire Station No. 5 Site
Dear Mr. Legg:
Sep 20 2006 15 :13 P. 04
232 03..,10,6+1 Hwy,
Cun4.,;,,rci, NC 28e,:i
Ma.,1 tc- Pr) droK 42e,
Concord., NC 2/4026.042d
Phone [phone]J
i Fax ',704 7951 Sto
This is in response to the City's request for flow acceptance received 8/29/06, The Water
and Sewer Authority of Cabarrus County (WSACC) has or currently expects to be able to make
available capacity at the Rocky River Regional Wastewater Treatment Plant and appropriate sewer
interceptors to transport and treat the wastewater from the proposed project_ WSACC agrees to
accept wastewater from the proposed Kannapolis Fire Station No. 5 site located along Macedonia
Church Road. This is based on the information provided by Alley, Williams, Carmen & King, Inc,
(Engineer for the Project) using North Carolina Department of Environment and Natural Resources
(NCDENR) wastewater flow guidelines. The projected flow is 1,500 gpd; however WSACC
expects the actual wastewater flow to more closely approximate 1,200 gpd based upon Master Plan
engineering data
By requesting flow acceptance, the City of Kannapolis acknowledges that WSACC may
need to upgrade, expand, or construct new facilities to accommodate the increased flow volume
granted by this and previous flow acceptance. Appropriate design and construction will be initiated
when actual flows dictate but may be subject to situations that WSACC does not expect or control.
Based upon flow of 1,500 gpd and cost of S8A26/gpd to provide treatment and transportation
capacity, this flow acceptance represents an estimated capital expenditure in excess of S12,189,
For your information and based upon NCDENR wastewater flow guidelines, WSACC has
approved 2,759,744 gallons of flow acceptance for the City of Kannapolis from 1992 to present and
336,274 gallons of flow acceptance year-to-date including this request. Based upon the approved
flow acceptances, WSACC has committed capacity valued in excess of 522,425,679 for the City of
Kannapolis since 1992 including S2,732,562 for this calendar year
Projects on the CIP are subject to approval by WSACC's Board of Directors, support from
local governing bodies, regulatory approval, and funding availability, At this time there are no
scheduled upgrades to WSACC facilities Jn the current six year CapItal Improvement Prosrarn
(CIP) (ha r are located downsErearn of 7hi s proposed project It should be noted that tic list and

of Kinhapolis
Kannapolis Fire Stab)
September 20, 2006
Page 2 of
Fax :74 64
ite
20 2006 l :1 P. 05
schedule of OF proects are ter r tr e and are revised periodically 'to ref
arid needs
h n in conditions
Please note that if cans ctiun of this project is not started ithin two years f the date
of this approval, 1, the approval is rescinded and a second request and approval will be required.
1 ease notify WSACC, CC, in writing, when construction of this project is initiated.
If you havey quest]. s, please call me at10,f:786-1781
'rho ;» A. Bach, P.
Util t ° Systems Engineer
WSACC Engineering Staff
ff Moody, P,EIK apnlss City Enginee `
per Melto npnlis

Central Files: APS SWP
09128/06
Permit Number " tiQ0030839 Permit Tracking Slip
Program Category Status Project Type
Non -discharge In review New Project
Permit Type Fast Track Version Permit Classi
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A Individual
Extensions
Primary Reviewer
samar.bou-ghazale
Permitted Flow
1500
Facility
Permit Contact Affiliation
Facility Name Major/Minor Region
proposed ire station No.5 site Minor Mooresville
Location Address
Owner
County
Cabarrus
Facility Contact Affiliation
Owner Name Owner Type
City of Kannapolis Government - Municipal
t atesIEyents
©rig Issue
App Received
09/22/06
Draft Initiated
Scheduled
Issuance
Pub
Owner Affiliation
Melvin Rape, PE
n
P©Box 119'9
Kannapolis NC 280811199
Notice issue
Effective Expiration
Requlated Activities R,eauestedifteceivecj veri
[Domestic, other
Additional information requested
Wastewater collectlan Additional information received
Outfall NULL
Waterbody Name
Stream Index Number Current Class Subbasln

2 ©Vlt5 : 4 '' 01 50.' tHEf©'8t©.14

A; Michael F Easley, Governor
Wilrsarm G, Ross Jr., Secretary
North Carokina Department of Environment and Natural Resources
Coleen Sullins, Director
Division of Water Quality
November 17, 2008
City of Kannapolis
P.O. Box 1 197
Kannapolis, North C
Attn: Wilmer Melton
rolina 28081
SUBJECT: Fire Station No. 5
Permit No. WQ0030839
Wastewater Collection System Extension
Final Engineering Certification
Dear Perm`lttee.
The Division received a final engineering certification for the subject project on October 30, >2008,,
A full review of the certification materials may or may not be conducted. It is assumed that receipt
of this certification indicates compliance with all regulations, design criteria and the permit. Please
be reminded that the Permittee is responsible for keeping a copy of the final record drawings for
the life of the project. If you have not received a copy, please contact your consultant
immediately to obtain a copy.
You are receiving this letter because 'thee Division has you listed as the responsible party. If this
permitted system is no longer owned by you, please complete Form PNOCF-S as this permit is not
automatically transferable. Form PNOCF-S can be downloaded from
http//h2o.enr.state.nc.us/�ndpcbindpuapps.html #Sewer.
If you have any questions concerning this document or the completion of Form PNOCF-S
necessary), please contact Ms. Dee Browder at the (letterhead address or via E-mail at
[e-mail].
Robert Krebs
Surface Water Protection 'Regional Supervisor
Enclosur
ery Moody, May, Corrnen & King
Surface Water Protection Section Central Files lcertitic tin g only)
Un.e
'orthCarotin a
Pretreatment, Emergency Response and Collection Systems Unit
1617 Mail Service Center, Raleigh NC 27699-1617
Telephone [phone] Fax t919f 733-0059
Internet http:/lh2o.enr no state.us/ndpu
An Equal Opportunity Action Employer
50'` 5 recycled!'10°% post -consumer paper

' Fast Track Engineering Certification
"Ncj wQ0030s39
October 4, 20'06
Complete and submit this form to the permit issuingi ioiul OffiCC With the, followin2:
)
One copy of the project record drawings (plan & profile views or sewer lines) of the wastewater collection systein
extension
• Supporting design calculations (selected pumps, system curve: operating point, available storage if portable generator(s)
or storage greater than longest past three year outage reliability option selected) for any pump stations permitted as pan
of this project
• Changes to the project should he clearly identified on the record drawings or in r it ten summary for rit Permit
modifications are required for any chartgo resultingin non-compliance with thispermit, regulations or minimum design
criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all required
supporting documentation have been received by the Division. Therefore,. it is highly recommended that this certification
be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CER MICA I ION
Partial Final
1, , as a duly: registered Professional Engineer in the State of -North Carolina, having been
authorized to observe xeekly„ • full time) the construction of proposed Fire Station No.5 Site project,
Cabarrus County, for the permittee , hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within ,substantial compliance of this
permit, 5A NCAC 2T :0200: the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria lot the Fast -Track Permitting of Pump Stations and
Force Mains adopted June 1, 2000 as applicable; and other supporting materials,
North Carolina Professional Engineer's
seal, signature„ and date:
4,004
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
'Ihe Perminee is responsible for tracking all partial certifications up until a final unification is received. Any wastewater
flow made tributary to the wastewater collection system extension prior to completion olthis Engineer's Certification shall be
considered a violation of the permit and shall subject the Pertniuee to appropriate enforcement actions,

cv wilhiam s carmen & kint inc.
TO:
NCDENR DIV OE ENVIRONMENTAL HEALTH
MOOIRESVILLE REGIONAL OFFICE
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE, NC 28115
Gentlemen:
Enclosed find the following data:
Engineering
DATE
Job No. 06534
October 29, 2008
PROJECT SEWER CERTIFICATION FOR
'<ANNAPOLIS FIRE STA. No. 5
COPIES DESCRIPTION
1 CERTIFICATION LETTER FOR THE ABOVE MENTIONED PRO, IECT
Remarks:
LOCATED IN THE CITY OF }<ANNAPOLIS, CABARRUS CO.,,PERMIT No. WQ0030839
.ET OF RECORD DRAWINGS
n
Yours very truly,
alley, Williams, carmen & king, inc.
By JEFF'ERY D. MOODY, PE
120 South Main Street RO, Box 1248 Kannapolis, North Carolina 28082
Tel, — [phone] Fax — [phone] awcicoorn
ESTABLISHED 1960