WQ0024825_Regional Office Historical File Pre 2018

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Rmourtes
Alan W. Klimek, P.E. Director
Division of Water Quality
February 1, 2005
Mr. Wilmer Melton, Public Works Director
City of Kannapolis
Post Office Box 1199
Kannapolis, North Carolina 28081
Subject: Permit No. WQ0024825
City of Kannapolis
Winecoff Commons Sewer Extension
Wastewater Collection System Extension
Cabarrus County, North Carolina
Dear Mr, Melton:
In accordance with your application received on January 27, 2005, we are forwarding herewith
Permit No, WQ0024825 dated February 1, 2005, to the City of Kannapolis for the construction and
operation of the subject wastewater collection system extension. This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .0227 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2H .0200; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design
Criteria for the Fast -Track Perrnitting of Pump Stations and Force Mains adopted June 1, 2000, as
applicable, unless specifically mentioned herein. Division approval is based on acceptance of the
certification provided by a North Carolina -licensed Professional Engineer in the application. It shall be
the Permittee's responsibility to ensure that the as -constructed project meets the appropriate design
criteria and rules. Failure to comply may result in penalties in accordance with North Carolina General
Statute §143-215.6A through §143-215.6C, construction of additional or replacement wastewater
collection facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing
board.
Mooresville Regional Office 610 East Center Ave_, Suite 301 Mooresville,
Internet: h2o.enr.stale.nc.us Customer Service; 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer - 50% Recycled/10% Post Consumer Paper
NC28115
Phone: [phone] Fax;
7

Mr. Wilmer Melton
Page 2
February 1, 2005
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to the City of Kannapolis for the construction and operation of approximately 370 linear feet of
8-inch gravity sewer to serve as an interceptor line as part of the Winecoff Commons Sewer Extension
project, with no additional discharge of collected domestic wastewater (flow will be permitted in
subsequent permits that connect to this line) into the City of Kannapolis' existing sewerage system,
pursuant to the application received January 27, 2005, and in conformity with 15A NCAC 2H .0200; the
Division's Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Perrnitting of Pump Stations and Force Mains
adopted June 1, 2000, as applicable; and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources and considered a part of this permit,
The sewage and wastewater collected by this system shall be treated in the Water and Sewer
Authority of Cabarrus County (WSACC) Rocky River WWTP (NPDES No. NC0036269) prior to being
discharged into the receiving stream.
This permit shall become voidable unless the agreement between the City of Kannapolis and
WSACC for collection and final treatment of wastewater is in full force and effect.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Sonja Basinger at
[phone].
Sincerely,
/2-6-
f•oi• Alan W. Klimek, P.E.
cc: Cabarrus County Health Department
Mooresville Regional Office, Water Quality Section (WVVTF Perrnit No. NC0036269)
Stephen Bissinger, Alley, Williams, Carmen & King, Inc.
Water Quality Central Files
Marie Doklovic, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein,
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times, The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
general observation af the entire sewer system shall be conducted at least once per year.
g.
Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State:
6. Per 15A NCAC 2H .0220, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for he life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification;
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Forrn CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
contra
Permit issued this the 1st day of February, 2005.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
cc--)
for Alan W. Klimek,,P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0024825

Fast Track Engineering Certification
Permit No. WQ0024525
February 1, 2005
Complete and submit this form to the permit issuing regional office with the following:
One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division, Therefore, it is highly recommended
that this certification be sent in a mariner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
Partial Final
, as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe (D periodically, El weekly, full time) the construction of the Winecoff Commons
Sewer Extension, Cabarrus County project for the Permittee hereby state that, to the best of my abilities, due care
and diligence was used in the observation of the construction such that the construction was observed to be built
within substantial compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division)
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and
other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
„.'
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
ATTN: DEE BROWDER
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

Central Files:
SWP
01 /31 /05
PPS it Number Wt 0024825 Permit Tracking Slip
Program Category
Non -discharge
Permit Type Fast Track
Gravity Sewer Extension, Pump Stations, & Pressure Sewer
Extensions
Primary Reviewer
sonja.basinger
Permitted Flow
0
Facility
Status Project Type
in review New Project
Version Permit Classification
Individual
Permit Contact Affiliation
Facility Name
Winecoff Commons Sewer Extension
Location Address
Owner
Owner Name
City of Kannapolis
dates/Events
Scheduled
Orig Issue App Received Draft Initiated Issuance
01/27/05
Regulated Activities
Commercial or industrial, other
Wastewater collection
Outfail NULL
Major/Minor Region
Minor Mooresville
County
Cabarrus
Facility Contact Affiliation
Owner Type
Government - Municipal
Owner Affiliation
Melvin Rape, PE
NC 280811199
PO Box 1199
Kannapolis
Public Notice Issue
2J /03
Requested/Received Events
Effective
Additional inforrnation received
Additional information requested
Expiration
Waterbody Name Stream Index. Number
Current Class Subbasin

alley, williams, carmen ,$ i1► , Inc.
ENGINEERS „,& ARCHITECTS
p.c. box 1179 / 740 chapel hill rod
Merlin®tans north caroling 27216
telephone [phone]
;fly Four hundred and xx /100 Dollars
PAY
TO THE
ORDER
OF
II'O1?369»
I:053101i2LI: 51&LEA2'129
I'

aims,
January 25, 2005
NC Div of Environmental Management
Department of Environment and Natural Resources Division of Water Quality
610 East Center Drive, Suite 301
Mooresville, North Carolina 28115
Re: City of K.annapolis
Winecoff Commons Sewer Extension
Dear Sir or Madam:
05503
Please find attached for review and approval the original and one copy of the permit application,
and the processing fee of $400.00. The Water & Sewer Authority of Cabarrus County Standard
Specifications for Wastewater Collections Systems were approved by your office on August 11,
1993 and are being maintained by the Division of Environmental Management New Water &
Sewer Authority of Cabarrus County Standard Specifications were submitted December 1995,
for review and approval. This project will be installed in accordance with the Water & Sewer
Authority of Cabarrus County Standard Specifications.
This project consists of the installation of approximately 370 LF of 8-inch Gravity 'Flow Sewer
Pipe. No additional sewer flow: will be added to the system with this extension; new flow will be
permitted with a future extension.
The system will be operated and maintained by the City. of Kannapolis. Please call me at
704-938-1515 if you have any questions.
Sincerely,
ALLEY, WILLIAMS, CARMEN & KING, INC.
Stephen J. Bissinger, PE
(5.503 sewer perr . eitcr,doc
120 South Mnin k P.O. Box eht)e; Kh.h ht)uttyhh. North Ctarchotti 28082
"Th,tt. (704.) 938- I 51h Fa„Y t 104) 938-68 • aohitk„).)tttitn
i):11hglit 1.4 1960

CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
.1.1•11•11.•000.1111,
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD! Application Number:
(to be completed by DWQ) VV5,002 40
1. Owner:
la. Jyof Kannapolis
FullFu Legal Name (company, municipality, HOA, utility, etc.)
PAGE 3
lb, Wilmer Melton, Director Public Works
Q Signing Official Name and Title (Please review 15A NCAC 2H . 206(b) for authorized signing officials!)
0.
0 z
1—
Telephone Facsimile
2. Project (Facility) Information:
2a. WINECOFF COMMONS SEWER EXTENSION
Brief Project Name (permit will refer to this name)
3. Contact Person:
lc. The legal entity who will own this system is:
Individual Ej Federal E Municipality 0 State/County 0 Pr vate Partnership Ej Corporation 0 Other (sp
ld. 1401 Bethpage Road
Street Address
if, NC
State
1 e. Kannapolis
City
28081
Zip Code
1h, 704-920-4200 1 i. 704-920-4244 1j, wmelton ',kann . LJ S
E-mail
2b.
ROS
•ounty Where Project is Located •
3a
Stephen J. Bissinger, Project Engineer
Name and Affiiiation of Someone Who Can Answer Questions About this Application •
3b. 704-938-1515 3c. [e-mail] , !
Phone Number E-mail
1. Project is N New E Modification (of an existing permit) If Modification, Permit No..
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
2. Owner is tEl Public (skip to item B(3)) 0 Private (go to Item 2(a))
2a, if private, applicant will be: 2b. If sold, facilities owned by a (must choose one)
Ej Retaining Ownership (Le. store, church, single office, etc.) or
Leasing units (lots, townhomes, etc, - skip to Item B(3))
0 Selling units (lots, townhomes, etc. - go to Item 8(2b))
0 Public Utility (Instruction ID)
0 Homeowner Assoc./Developer (Instruction IV)
3. Water and Sewer Authority of Cabarrus County
Owner of Wastewater Treatment Facility (WWTF) Treating Wastewater From This Project
4a, Rocky River Regional Waste Water Treatment Plant 4b. NC0036269
Name of WWTF WWTF Permit No.
5a, City of Kannapolis
5b, 8" `5c.
Owner of Downstream Sewer Receiving Sewer Size Permit Number of Downstream Sewer (if known)
6, The origin of this wastewater is (check all that apply).
0 Residential Subdivision
0 Apartments/Condominiums
11 Mobile Home Park
Ej School
E:1 Restaurant
0 Office
0 Car Wash
El Institution
El Hospital
0 Church
0 Nursing Home
Other (specify): Commercial
7. Volume of wastewater to be permitted in this project 0 gallons per day
^ y N
100 °A Domestic/Commercial
If the permitted flow is zero, indicate why:
- Flow will be permitted is subsequent permits that connect to this line
0 Flow has already been allocated in Permit No.
0 Rehabilitation or replacement of existing sewer with no new flow expected
% Industrial
% Other (specify):
FTA 02/03 - Rev! 1 06103

CK APPLICATION for GRAVITY SEWERS,'Pl : P STATIONS, I) FORCE MANS
9, Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCA;
.0219(I) for Item E(7) or the design flow for line or pump station sizing if zero flow in the space below. Values
that in 15A NCAC 2H .0219(I)(1-2) must be approved prior to submittal of this application. Submit a separate
the Division of Water Quality, Non -Discharge Permitting Unit, 1617 Mail Service Center, Raleigh, NC 27699-
accordance with 15A NCAC 2H ,0219(l)(3).
No new flow.
10, Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches) Length (feet)
8"
ENTER TOTAL LINE LENGTH IN
ES
370
0,07 miles
Gravity or Force
use the pull down rn
Gravity
Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Location ID Power Reliability Option
(self chosen - as shown on Design Flow Operational Point (1- dual line feed; 2- permanent generator wf#
0 plans for cross-reference) (MGD) _ GPM © TDH portable generator wltellemetry; 4-wet well st
LL
z
NIA.
12, Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations ar
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H ,0200 as app
® Yes ❑ No If no, please reference the pertinent minimum design criteria or regulation and indicate w)
variance is requested: See Attachment
SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS PERTINENT TO THE VARIANCE WITH YOUR APPLt
t3. Have the following permitscertifications
been suubmitttee.
d for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? ❑ Yes ❑ No NIA
Sedimentation and Erosion Control Plan? ❑ Yes ❑ No N/A
Stormwater? ❑ Yes ❑ No NIA
FTA 02/03 - e

Location ID on Map
(self chosen - as shown on
map for cross-reference)
0
CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS PAGE ,5
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03 I
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary), This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
E A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
E A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability ;
option for any pump station near a Class C down slope waterbody.
Name of Waterbody Stream Waterbody
Waterbody County River Basin Index Classification
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1, Applicants Certification:
la,
1, Wilmer Melton, 111, Dir. Public Works, attest that this application for Winecoff Commons Sewer Extension has
been reviewed by me and is accurate and complete to the best of my knowledge 1 understand that if all required parts
of this application are not completed and that if all required supporting documentation and attachments are not included,
this application package is subject to being returned as incomplete. Note: In accordance with North Carolina General
Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement, representation, or
certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10,000
as well as civil penalties up to $25,000 per violation.
Signi g Official Signature
Professional Engineer's Certification;
Date
1 attest that this application for Winecoff Commons Sewer Extension has been reviewed by me and is accurate,
complete and consistent with the information in the engineering plans, calculations, and all other supporting documentation
to the best of my knowledge. I further attest that to the best of my knowledge the proposed design has been prepared in
accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February
12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June
1, 2000 and the watershed classification in accordance with Division guidance, Although certain portions of this submittal
package may have been developed by other professionals, inclusion of these materials under my signature and seal
signifies that 1 have reviewed this material and have judged it to be consistent with the proposed design, Note: In
accordance with NC General Statutes 143-215,6A and 143-215,6B, any person who knowingly makes any false statement,
representation, or certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed $10,000 as well as civil penalties up to $25,000 per violation.
2a, Stephen J. Bissinger
Professional Engineer Name
2t) Alley, Williams, Carmen & King, Inc,
Engineering Firm
2c, 120 S. Main Street, PO Box 1248
Address
2d, Kannapolis _2e. NC 2f, 28082
City State Zip
2g. 704-938-1515 2h. 704-938-6810 21. sbissinger@awck,com
Telephone Facsimile
E-mail
z,„„3, -
frk a
„ „:
aa(
Sea( Signature & pate_
FTA 02/03 - Rer 1 06/03

gtM,