NC0085189_authorization to construct_19951119

r
, State of North Carolina
Department of Environment,
Health and Natural Resources
°' ,� Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
November 13, 1995
Mr. Joseph Doyle
163 Grassey Spring Farm Road
Stoneville, North Carolina 27048
Subject: Authorization to Construct
Permit No. NC0085189 � / `� �'
Jose's Restaurant V'iTWTP
Rockingham County
Dear Mr. Doyle
A letter of request for an Authorization to Construct was received October 12, 1995 by the Division
and final plans and specifications for the subject project have been reviewed and found to be satisfactory.
Authorization is hereby granted for the construction of a wastewater treatment system consisting of: an
existing grease trap and septic tank; conversion of an existing pump tank to a septic tank; a 2,500 SF
recirculating sand filter (single -pass treatment during power. outages); a 3,500 gallon wet well pump
station with dual 325 GPM submersible pumps; a 700 gallon chlorine contact chamber with tablet
chlorination and dechlorination units; 1500 linear feet of 4-inch diameter gravity outfall piping with
cleanouts' and all associated piping, valves, controls, and appurtenances with discharge of treated
wastewater into an unnamed tributary to Buffalo Creek in the Roanoke River Basin.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of NPDES
Permit No. NC0085189 issued November 13, 1995, and shall be subject to revocation unless the
wastewater treatment facilities are constructed in accordance with the conditions and limitations specified in
Permit No. NC0085189 .
The sludge generated from these treatment facilities must be disposed of in accordance with G.S.
143-215.1 and in a manner approved by the North Carolina Division of Environmental Management.
In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those as may be required by this
Division, such as the construction of additional or replacement wastewater treatment or disposal facilities.
The Winston-Salem Regional Office, telephone number 910-771-4600 shall be notified at least
forty-eight (48) hours in advance of operation of the installed facilities so that an in -place inspection can be
made.. Such notification to the regional supervisor shall` be made during the normal office hours from 8:00
a.m. until S:OO p.m. on Monday through Friday, excluding State Holidays.
Upon completion of construction and prior to operation of this permitted facility, a certification
must be`'received from a professional engineer certifying that the'permitted facility has been installed in
accordance with the NPDES Permit, this Authorization to Construct and the approved plans and
specifications: ° Mail the Certification to the Permits and` Engineering Unit, P.O. Box 29535, Raleigh, NC
27626-0535
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
Art Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

v
Permit No. NC0085189
Authorization to Construct
Jose's Restaurant
November 13, 1995
Page 2
Upon classification of the facility by the Certification Commission, the Permittee shall employ a
certified wastewater treatment plant operator to be in responsible charge (ORC) of the wastewater treatment
facilities. The operator must hold a certificate of the type and grade at least equivalent to or greater than the
classification assigned to the wastewater treatment facilities by the Certification Commission. The
Permittee must also employ a certified back-up operator of the appropriate type and grade to comply with
the conditions of Title 15A, Chapter 8A, .0202. The ORC of the facility must visit each Class I facility at
least weekly and each Class II, III, and IV facility at least daily, excluding weekends and holidays, and
must properly manage and document daily operation and maintenance of the facility and must comply with
all other conditions of Title 15A, Chapter 8A, .0202. Once the facility is classified, the Permittee must
submit a letter to the Certification Commission which designates the operator in responsible charge within
thirty days after the wastewater treatment facilities are 50% complete.
A copy of the approved plans and specifications shall be maintained on file by the Permittee for the
life of the facility.
The sand media of the recirculating sand filter must comply with the Division's sand specifications.
The engineer's certification will be evidence that this certification has been met.
A leakage test shall be performed on the septic tank and dosing tank to insure that any exfiltration
occurs at a rate which does not exceed twenty (20) gallons per twenty-four (24) hour per 1,000 gallons of
tank capacity. The engineer's certification will serve as proof of compliance with this condition.
Failure to abide by the requirements contained in this Authorization to Construct may subject the
Permittee to an enforcement action by the Division of Environmental Management in accordance with
North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from complying
with any and all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have any
questions or need additional information, please contact Mr. Greg Nizich at telephone number 919/733-
5083, ext. 541.
Sincerely,
G��
. Preston
cc: Rockingham County Health Department (Mr. Glenn L. Martin)
Winston-Salem Regional Office, Water Quality
Technical Assistance and Certification Group
Facility Assessment Unit
ATC File
Howard, Jr., P.E.
Mr. Mike Hanna, Dewberry &Davis, 551 Piney Forest Road, Danville, VA 24540
b

1!e"�,•: Y i 6•`9J fir( i:'„ �='�
•wmts and En Jgeenng
Technical III Branc
County m Departm
Central
R •
�C+P14a�'ee 'ii4. a:�VA i ��IwJi V '3u
SOC PRIORITY PROJECT: YES _ NO
IF Yes, SOC No.®
1 11 1 1 I J 1 ETie
1 i
i /
• 1 1 1 1,MAJ
AUTHORIZATION TO CONSTRUCT
Date: 1 4
1. Facility Name and Current Address: Jose's Restaurant
Joses Road off Hwy 125
Stoneville, N.C. 27048
2. Date of most recent NPDES Staff Report: (attach copy) Sept. 6, 1995
3. Changes since previous action on NPDES Permit: None
i
4. Verify Discharge Points) on plans with can ent NPDES Permit. List for all discharge
points. Proposed:
Attach a USGS map extract and indicate treatment facility site and discharge point on
�P•
U.S.G.S. Quad No. 819NE U.S.G.S. Name Southwest Eden
5. Treatment plant classification: (attach completed rating sheet)
No existing system -system is proposed. Upon approval of A to C proposed system
should be rated.

1 1 1' 1 1 1 DQV OL
��• ��-�i�i r
b. Date(s) and construction activities allowed by previous Authorizations to
Construct issued in the previous two (2) years: NA
c: What is the actual treatment capacity of the current facility (design volume)? NA
d. Please provide a description of existing or substantially constructed wastewater
treatment facilities. NA
recirculating sandfilter, chlorination, flow measurement,
3. Residuals handling and utilization/disposal scheme:
a. If residuals are being land applied, please specify DEM permit no. NA
Telephone No.
c. Landfill:
Submission of Plans and Specifications
Begin Construction
Complete Construction

I MM
-r• ( 1 �'i I 1 I(unitsJ �+ 1 1 septic ► •/ 1• 1 1 1
lecked to insure 11," units are structuraUyadequate • provide treatment fbr the proposed
IYACM,
c
_� _�_ 1 I �� Imo• I l� I_
Water Quality Supervisor