NC0072664_Regional Office Historical File Pre 2018 (10)

State of North Carolina
Department of Environment,
Health and Natural Resources.,
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mark E. Hawes
Shurtape Technologies, Inc.
1620 Highland Avenue Ne
Hickory, NC 28603
Dear Permittee:
1••
� lk
T.
�. _,
July 24, f9W:U 'L
J U L 14 1998
Subject: Certificate of Coverage No: NCG500323
Renewal of General Permit
Stony Point Tape Plant
Alexander County
In accordance with your application for renewal of the subject Certificate of Coverage, the Division is forwarding
the enclosed General Permit. This renewal is valid until July 31, 2002. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated December 6, 1983. If.any parts, measurement
frequencies or sampling requirements contained in this permit are unacceptable to you, you have the right to request
an individual permit by submitting an individual permit application. Unless such demand is made, this certificate
of coverage shall be final and binding. .
The Certificate of Coverage for your facility is not transferable except after notice to the Division. Use the enclosed
Permit Name/Ownership Change form to notify the Division if -you sell or otherwise transfer ownership of the
subject facility. The Division may require modification or revocation and reissuance of the Certificate of Coverage.
If your facility ceases discharge of wastewater before the expiration date of this permit, contact the Regional
Office listed below at [phone]. Once discharge from your facility has ceased, this permit may be rescinded.
This permit does not affect the legal requirements to obtain other permits which may be required by the Division of
Water Quality, the Division of Land Resources, Coastal Area Management Act or any other Federal or Local
governmental permit that may be required.
If you have any questions concerning this permit, please contact the NPDES Group at the address below.
Sincerely,
A. Preston Howard, Jr., P.E.
cc: Central Files
IvIooresville-Regional-Office -. ,
NPDES -File-
Facility, Assessment Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 [phone] FAX [phone] p&[e-mail]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL -RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG500000
CERTIFICATE OF COVERAGE NO. NCG500323
TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER
BLOWDOWN, CONDENSATE, EXEMPT STORMWATER, COOLING WATERS ASSOCIATED WITH
HYDROELECTRIC OPERATIONS, AND SIMILIAR WASTEWATERS UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Shurtape Technologies, Inc.
is hereby authorized to discharge
non -contact cooling water, condensate, boiler blowdown and other similar wastewaters
from a facility located at
Stony Point Tape Plant
NC Highway 90
Stony Point
Alexander County
to receiving waters designated as subbasin 30706 in the Yadkin River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth
in Parts I, II, III and IV of General Permit No. NCG500000 as attached.
This certificate of coverage shall become effective August 1, 1997.
This certificate of coverage shall remain in effect for'the duration of the General Permit.
Signed this day July 24, 1997.
6;J&
1/ 1k. Preston Howard, Jr., P.E., Director
6f Division of Water Quality
By Authority of the Environmental
Management Commission

State of .North. Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Mark Hawes
Shurtape Technologies
P.O. Box 1530 -
Hickory, North Carolina 28603
Dear Mr. Hawes:
AITCO?
40&
[DEtE _
Au u�,St ,J 7o N.C. D P
t. of afr NFL
ENVIRONIAE NT, 11_XW Hi
& NAT.URP.T. PZG0L7RGE9
AUG 19 1997
AUG 14 J997
Winston-Sa1eWn
Regional OfficO
DIVISiRN �F EljVlRal AFdT4L LX1111 t'«1101,
RSjNhiocide Approval
5t Point Tape Plant
ermit: N 3
Alexander County r�
The Division received your request dated June 5,1997 for approval of four chemical additives to
the discharge at the subject, facility. Two of these additives (Drewsperse 738 and Biosperse 250) were
approved on June 5, 1997. The additives Valuguard 250 and Advantage Plus 6445 were previously
approved in December 1996, but the appropriate documentation was evidently not forwarded to you.
After a review of the biocide information you submitted by the Aquatic Survey & Toxicology
Unit, the Division has concluded that use of Valuguard 250 and Advantage Plus 6445 is acceptable at
the stated rates and dosage levels.
If you have any, questions regarding this matter, please contact Charles Weaver at (919) 733-
5083, extension 511.
Sincerely,
David Goodrich
Supervisor, NPDES Group
cc: Central Files
��i+��irTsto- n=�are'm_ Regional Office _
Permits & Engineering Unit
Aquatic Survey & Toxicology Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone]- FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

Page 1
Note for Charles Weaver
From: Melissa Rosebrock
Date: Thu, Jul 31, 1997 12:12 PM
Subject: RE: NCG500323;- additives
To: Charles Weaver
250 and 6445 were requested in dec. of '96 through susan r. and approved in may 1, 1997
memo from me to her. the region and central files were copied.
From: Charles Weaver on Thu, Jul 31, 1997 11:50 AM
Subject: NCG500323 - additives
To: Melissa Rosebrock
-- lit hehe facility iri question is Shurtape"Technoiogies -Stony mint i ape Plane: _ - --
2. Mark Hawes (of Shurtape) submitted a biocide approval request for 4 chemicals. We
approved use of Drewsperse 738 and Biosperse 250.
He wants to know about Valuguard 250 and Advantage Plus 6445.
3. He said he sent the 101 forms and MSDS data to you directly - I don't have any of that
material.
4. If you don't have the necessary data, let me know and I'll tell him to submit it.
5. If you prefer, contact him directly - his number is [phone], extension 4428. His
e-mail address is [e-mail] if you'd rather contact him electronically
Thanks, Melissa
CHW