WQ0002857_Monitoring - 08-2020_20201001

Monitoring Report Submittal
............................................................................................................................................
Permit Number #* WQ0002857
Name of Facility:*
Month:* August
Report Information
Piedmont Custom Meats WWTF
Type *
NDMR, NDAR-1, NDAR-2, NDMLR
Confirmation Email Address:*
Name of Submitter:*
Signature:
Date of submittal:
Initial Review
Year:* 2020
Upload Document*
Piedmont Custom August.pdf 1.47MB
FDF Only
Please upload one PDF containing all applicable monitoring reports
(i.e., NDMR, NDAR-t, NDAR-2, NDMLR, GW-59).
[e-mail]
Jessica Mize
jus l oil
Reviewer: Williams, Kendall
9/30/2020
This will be filled in automatically

Is the project number correct? * WQ0002857
Is the monitoring report r Yes r No
accepted?*
Regional Office * Winston-Salem
Accepted Date: 10/1/2020

Page 1 of 3
NON -DISCHARGE WASTE WATER MONITORING REPORT
PERMIT NUMBER: W 0002857
MONTH: August _YEAR: 2020
FACILITY NAME: Piedmont Custom Meats WWTF
COUNTY: Caswell
Flaw Monitoring Point: Effluent Influent: Lyj
Effluent: © Influent: ❑
Surface Water (SW}: ❑ SW CodelName:
Parameter Monitoring Point:
Was There Effluent Flow for this Month Generated At This Facility: Yes: LJNo:
50050 00400 50M 00310 00610
00530 31976 70300 00620 00625 00940 00600 00665
Operator
Feral
D Arrival Daily Rate
A Time Operator ORC (Flow) into
Colif rnr
Total Toni11.
2400 Time on on Treatment Residual BOD-5
20°C NH-3-N
{ tttctric
(ic°'
TSS Nhan•) DS N(r-3-N TKN Chloride Nitrogen Phosphoms
E Clnck Sire Site? sntcrn PHChlorine
UNITS L'(i:'I. M1IG/L MGiI.
NS611. :UIUML N1GR. MULL MG/l, M11GiL NIQrL hiG1L
I IttS YIN G11.S,()N5
t
1,150
3 I,lsn
4 1,lSU
5 1,150
6 (1938 0.25 1' 1,150 6.4 <lU
7 1 150
s 1,150
q 1 150
10 1,150
11 1,150
12 1236 0.25 13 1,15U 6.5 <10
13 1,150
14 1,15U
is 1,150
16 1,15o
17 1 150
Ix 1,15(I
1v
n845
0.50:
Y
1'
1,15()
1,150
1,i50
1,150
1,150
1, 1"
1,150
1,150
6.4.
6A
<10
<10
__
211
z1
22
23
2.25
24
tuou
25
z6
z7
1,150
1,150
1,150
1,150
z1
yq
36
31 1,150
Average 1,150
Daily Maximum 1,150 6.50
Daih' %linimurn 1.150 6.40
Ntunthly Llndts (Av;;) 5000
Composite G 1 Grah (G)
Operator in Responsible Charge (ORC): Glenn Price Grade: SI
Phone: [phone]
Check Box if ORC Has Changed: 7
ORC Certification Number: 9879.
Certified Laboratories (1): It & A Laboratories Inc.
(2):
Person(s) Collecting Samples: Glenn Price
Mail ORIGINAL and'rrvo COPIES to:
ATTN: Non -Discharge Compliance Unit N r
DENR (SIGNATURE OF OPERATOR IN RNSPONS113LE CIIA
I)ivision of Water Quality By this signature, 1 certify that this report is accurate and
1617 Mail Service Center complete to the best of my knowledge.
RALEIGH, NC 27699-1617
DENR Form NDAR-1 (5/2003)

NON DISCHARGE WASTEWATER MONITORING REPORT
FACILITY STATUS:
Please answer the following question: Compliant ,N)
I. Does all monitoring data and sampling frequencies meet permit requirements?
If the facility is non -compliant, please explain in the space below the reason(s) the facility was not in compliance with its
permit. Provide in your explanation the date(s) of the non-compliance and describe the corrective action(s) taken. Attach
additional sheets if necessary.
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance
with a system designed to assure that a qualified personnel properly gather and evaluate the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the information, the
information submitted is, to the best of my knowledge and belief true, accurate, and complete. I am aware that there are significant
penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
Y - Baron Neal McDuffie
(Signature of Pennitee)* Z7
Date (Name of Signing Official -Please print or type)
Baron Neal MCDuffie (Authorized Agent)
(Permittee-Please print or type)
9683 Keres Chapel Road
Gibsonville NC
(Permittee Address)
01002 Arsenic
01022 Boron
00310 BOD5
01027 Cadmium
00916 Calcium
00940 Chloride
50060 Chlorine, Total
Residual
01034 Chromium
00340 COD
31504
Coliform, Total
00094
-Conductivity01042
Copper
00300
Dissolved Oxygen
31616
Fecal Coliform
01051
Lead
00927
Magnesium
71900
Mercury
00610
NH3 as N
01067
Nickel
Field Services Director ( R & A Laboratories, Inc)
(Position or Title)
336-582-8247
(Phone Number)
PARAMETER CODES
00600 Nitrogen, Total
00630 NO2 & NO3
00620 NO3
00556 Oil & Grease
W 09 PAN Plant Available
00400 pH
32730 Phenols
00665 Phosphorus, Total
00937 Potassium
00545 Settleable Matter
03/31/21
(Permit Exp. Date)
00929
Sodium
00931
SAR
00745
Sulfide
00515
TDS
00010
Temperature
00625
TKN
00680
TOC
00530
TSS/TSR
00076
Turbidity
01092
Zinc
Parameter Code assistance may be obtained by calling the Water Quality Compliance/Enforcement Unit at [phone], extension 529.
The monthly average for Fecal Coliform is to be reported as a GEOMETRIC mean. Use only units designated in the reporting
facility's permit for reporting data.
* If signed by other than the Permince, delegation of signatory authority must be on file with the state per 15A NCAC 28.0506 (b) (2) (D).

Page 2 of 3
NON -DISCHARGE APPLICATION REPORT
SPRAY IRRIGATION SITES)
THERE ARE TWO APPLICATION FIELDS PER PAGE. USE ADDIDTIONAL PAGES AS NEEDED
PERMIT NUMBER.• W 0002857 MONTH: Au ust YEAR: 2020
FACILITY NAME: Piedmont Custom Meats WWTF COUNTY: Caswell
Formulas:
Daily Loading (inches) = [Volume Applied {gallons) x 0.1336 (cubic feeVgallon) x 12 (inchesHDot)) l [Area Sprayed (acres) x 43.560 (square teetiacre) or
= [Volume Applied (gallons) I [Area Sprayed (acres) x 27,152 (gallonslacre-inch).
Maximum Hourly (.Dading (inches) = Daily Loading (inches) / [rime irrigated (minutesl 160 (minuteslhour)[ Monthly Loading {inches) =Sum of Daily Loading (inches)
12 Month Floating Total (inches) = Sum of this monih's Monthly Loading (inches) and previous 11 month's Monthly Loadings (inches)
Average Weekly Loading (inches) = [Monthly Loading (incha57month) / Number of days in the month (dayslmonth )l x 7 (daysfweek)
Did Irrigation Occur At This Facility: Did Irrigation Occur On This Field:
Did Irrigation Occur On This Field:
Q No, ❑
Yes: No: ❑ Yes: ® No: ❑
Yes:
Field Number: 1
Field Number.
Area Sprayed (acres): t
Area Sprayed (acres):
LFe
Cover Crop: Fescue
Cover Crop:scue
Permitted Hourly Rate (Inches):
0.2 Permuted Hourly Rate (inches): 0.2
WEATHER CONDITIONS Permitted Yearly Rate (inches):
52 Permitted Yearly Rate (inches): 62
D
M.,iau,m
A
Weather Temperame Storage
hlatimum
Timr L
Iloudy
God.- al Precipitate Lagoon Ynlvnu: Time P..1y
Applied in 9-d laudinx
[lovely v.duma
1¢d ns Arlid ImgunJ Ia+di. ding
E
applir,lun hon Frra-hued
u:d4a n.h�
u.hn
I'll inches f.. N+11'". novas n.hr+
aches
1
1
a
5
6
R
76
0.8
3.0
7
N
9
1a
tl
12
PC
78
0
2.8
13
la
15
16
17
IN
19
PC
72
0
2.5
8820
24S
1 0.32
0.08 '
6820
245
0.32
0.08
20
21
22
PC
76
0
2.8
9000
251)
0.33
0.08
91
250
0.33
(bits
[2,51
30
3t
0.65
f , ``,= '*' . n ' 0.65
.1'nwl Gallond},nnlLly L,,>.dinn� (lnchro)
9.07
9.07
9
1=51�nth lno.lins Thal liisc6nl - _�'�
0.16
0,16
AIM9. R'.W 1.w04iy tlaean)
•Wnthrr Codes: C-clear. PC -peril! cloudy, CI -cloudy, R-raln, Sn-snow, St-slcer
Spray Irrigation Operator in Responsible Charge (ORC): Glenn Price
Phone: [phone]
ORC Certification Number: 987931/20771
Check Box if ORC H;s Changed:
Mail ORIGINAL and Two COPIES to:
ATTN: Nun -Discharge Compliance Unit
DENR
Division of Water Quality
1617 Mail Service Center
RALEIGH, NC 27699-1617
(SIGNATURE OF OPERATOR IN RESPONSIBLE CHARGE)
By this signature, I certify that this report is accurate and
complete to the best of my knowledge.
DENR Form NDAR-1 (5/2003)

FACILITY STATUS:
Please indicate( by inserting Y(es) or N (o) in the appropriate box) whether the facility has been compliant
with the following permit requirements: (Note: If a requirement does not apply to your facility put (NA) in the
compliant box.)
Compliant (Y,N)
1. The application rate(s) did not exceed the limit(s) specified in the permit. QD
2. Adequate measures were taken to prevent wastewater runoff from the site(s).
3. A suitable vegetative cover was maintained on the site(s) in accordance with the permit. 4
d. All buffer zones as specified in the permit were maintained during each application. 4
S. The freeboard in the treatment and/or storage lagoon(s) was not less than the 4
limit(s) specified in the permit.
If the facility is non -compliant, please explain in the space below the reason(s) the facility was not in compliance with its
permit. Provide in your explanation the date(s) of the non-compliance and describe the corrective action(s) taken. Attach
additional sheets if necessary.
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance
with a system designed to assure that a qualified personnel properly gather and evaluate the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the information, the
information submitted is, to the best of my knowledge and belief true, accurate, and complete. I am aware that there are significant
penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
" 0 d- (/ Baron Neal McDuffie
(Signature of Permitee)* Date (Name of Signing Official -Please print or type)
Baron Neal McDuffie (Authorized Agent)
(Permittee-Please print or type)
9683 Kerr's Chapel Road
Gibsonville NC
(Permittee Address)
Field Services Director (R & A Laboratories Inc)
(Position or Title)
336-582-8247
(Phone Number)
03/31/21
(Permit Exp. Date)
* If signed by other than the Permittee, delegation of signatory authority must be on file with the state per 15A NCAC 2B.0506 (b) (2) (D).
DENR Form NDAR-1 (5/2003)

Page 3 of 3
NON -DISCHARGE APPLICATION REPORT
SPRAY IRRIGATION SITE(S)
THERE ARE TWO APPLICATION FIELDS PER PAGE. USE ADDIDTIONAL PAGES AS NEEDED
PERMIT NUMBER: W 0002857 MONTH: AugustYEAR: 2020
FACILITY NAME: Piedmont Custom Meats WWTF COUNTY: Caswell
Formulas:
Daily Loading (Inches) = [Volume Applied (gallons) x 0.1336 (cubic featfgallon) x 12 (inchesftoot)) I [Area Sprayed (acres) x 43,560 (square feetlacre) or
= [Volume Applied (gallons) I (Area Sprayed (acres) x 27,152 (gallonslacre-Inch).
Maximum Hourly Loading {inches) = Daily Loading (inches) f (rime irrigated (minutes)160 (minutesmour)i Monthly Loading (inches) =Sum of Daily Loading (inches)
12 Month Floating Total (inches) = Sum of this month's Monthly Loading (inches) and previous 11 month's Monthly Loadings (inches)
Averaoe Weekly Loadinq (inches) = [Monthly Loading (inches/manttl) I Number of days In the month (daysfmonth )I x 7 (dayw*eek)
Did Irrigaitiori
omaur an This Field:
Did inigation occur On This Field:
No� i*
Yes:R
■
yes,
Area Sprayed (acras)�
...
®
E�
r
�i
-Wcnlher Codes: CaIe•r. FC-partly cloudy. ClKloudy, R-rala, So -maw, sett
Spray Irrigation Operator in Responsible Charge (ORC): Glenn Price Phone: [phone]
ORC Certification Number: 987931/20771 Check Box if ORC Ha�Changed: ❑
Mail ORIGINAL and Two COPIES to:
ATTN. Non -Discharge Compliance Unit
DENR
Division of Water Quality
1617 Mail Service Center
RALEIGH, NC 27699-1617
(SIGNATURE OF OPERATOR IN RESPONSIBLE CHARGE)
By this signature, I certify that this report is accurate and
complete to the best of my knowledge.
DENR Form NDAR-1 (5/2003)

FACILITY STATUS:
Please indicate( by inserting Y(es) or N (o) in the appropriate box) whether the facility has been compliant
with the following permit requirements: (Note: If a requirement does not apply to your facility put (NA) in the
compliant box.)
Compliant (Y,N)
L The application rate(s) did not exceed the limit(s) specified in the permit. 4
2. Adequate measures were taken to prevent wastewater runoff from the site(s). 4
5. A suitable vegetative cover was maintained on the site(s) in accordance with the permit. [�
4. All buffer zones as specified in the permit were maintained during each application. DTO
5. The freeboard in the treatment and/or storage lagoon(s) was not less than the
limit(s) specified in the permit.
If the facility is non -compliant , please explain in the space below the reason(s) the facility was not in compliance with its
permit. Provide in your explanation the date(s) of the non-compliance and describe the corrective action(s) taken. Attach
additional sheets if necessary.
"I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance
with a system designed to assure that a qualified personnel properly gather and evaluate the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the information, the
information submitted is, to the best of my knowledge and belief true, accurate, and complete. I am aware that there are significant
penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations."
(Signature of Permitee)* v Date
Baron Neal McDuffie (Authorized Agent)_
(Permittee-Please print or type)
9683 Keres Chanel Road
Gibsonville NC
(Permittee Address)
Baron Neal McDuffie
(Name of Signing Official -Please print or type)
Field Services Director ( R & A Laboratories. Inc)
(Position or Title)
336-582-8247
(Phone Number)
03/31/21
(Permit Exp. Date)
* If signed by other than the Permittee, delegation of signatory authority must be on file with the state per 15A NCAC 2B.0506 (b) (2) (D).
DENR Form NDAR-1 (5/2003)