NC0002071_PERMIT ISSUANCE_20080514

NPDES DOCUWENT SCANNING COVER SNEET
•
0
•
NPDES Permit:
NC0002071
Pamlico packing
Document Type:
Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Monitoring Report
Instream Assessment (67B)
Environmental Assessment (EA)
Permit
History
Document Date:
May 14, 2008
W'"M dooum0at is priatea oa rBsme paper - ignore aI,y
Cauteat oxM the r+everee side

�oF WArFRp �..
`p 61.
� r
D "C
May 14, 2008
Don Cross, Secretary
Pamlico Packing Company, Inc.
P. O. Box 308
Vandemere, North Carolina 28587
Michael F. Easley, Governor
State of North Carolina
William G. Ross, Jr., Secretary
Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
Subject: Issuance of NPDES Permit NCO002071
Pamlico Packing Company, Inc.
_ - - Pamlico County
Dear Mr. Cross:
The Division of Water Quality (the Division) hereby issues this final permit for the subject facility. This permit
is issued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between North Carolina and the U.S. Environmental Protection Agency dated October 15, 2007, or
as subsequently amended.
Changes to Your Previous Permit. In accord with federal guidelines for seafood processing (40CFR 408),
the Division has revised effluent parameter limits for Outfalls 002, 003 and 004 to reflect production data
submitted with your permit renewal application. The Division also acknowledges -your comments on the
draft permit received May 2, 2008. We offer the following:
Total Residual Chlorine (TRC). The Division understands that the subject facility may use dilute chlorine
to wipe down processing tables and to disinfect food -contact rooms or equipment. We therefore have
removed TRC monitoring from boiler-blowdown Outfall 005. Because of difficulties quantifying TRC in a
wastewater matrix, the Division will consider all TRC values reported below 50 ug/L to be "in compliance"
with this permit. However, please continue to monitor TRC regularly according to your permit using
instrumentation appropriate to this level, as required for similar permits statewide. To date, the Division has
no data on your discharge of chlorine. After you have established a database proving that your discharges do
not impact the receiving stream, you may petition the Division to relax or discontinue monitoring. Failure to
monitor will prompt a Notice of Violation and possible assessment of fines.
Please note that your facility discharges to waters within the Neuse River Basin. All streams within this
basin have been designated nutrient sensitive waters (NSW) as a result of environmental problems including
algal -blooms in the estuary. The North Carolina Environmental Management Commission adopted rules
establishing the Neuse River Basin Nutrient -Sensitive Waters Management Strategy to reduce phosphorus
and nitrogen inputs.
If any parts, measurement frequencies, or sampling requirements contained in this permit are unacceptable,
you have the right to an adjudicatory hearing upon written request within thirty (30) days after receiving this
letter. Your request must be in the form of a written petition conforming to Chapter 150B of the North
Carolina General Statutes, and must be filed with the office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, North Carolina 27699-6714. Unless such a demand is made, this permit shall be final and
binding.
A�{►W
NCDENR
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1 800 623-7748

Pamlico Packing Company a '
Issuance of NPDES Permit NC0002071
Page 2 _
This permit is not transferable except after notifying the Division of Water Quality. The Division may require
modification, or revocation and re -issuance of this permit. Please notice that this does not affect your legal
obligation to obtain other permits required by the Division of Water Quality, the Division of Land Resources,
the Coastal Area Management Act, or other federal or local governments.
if you have questions, or if we can be of further service, }Tease contact Joe Corporon at [Joe. C9r_poron&1cmail.ne l
or call [phone], extension 597.
Respectfully,
X ,r ; Coleen H. SulIins
Enclosure: Final NPDES Permit NC0002071
cc: Washington Regional Office, Water Quality Section
Central Files
:. NPDES Program
s.

Permit NCO002071
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
. TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
(hTDES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental -Management
Commission, and the Federal Water Pollution Control Act, as amended,
Pamlico Packing Company, Inc.
is hereby authorized to discharge wastewater from a facility located at
Pamlico Packing Company, Inc,
28 North First Street, Vandemere, NC
Pamlico County
to receiving waters designated as the Bay River within the Neuse River Basin in accordance with
effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III and W
hereof.
This permit shall become effective June 1, 2008
This permit and authorization to discharge shall expire at midnight on May 31, 2013.
Signed this day May 14, 2008
4r : Coleen H. Sullins, Direct
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NCO00207I
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked, and as of this issuance, any previously issued permit bearing this number is no longer effective.
Therefore, the exclusive authority to operate and discharge from this facility arises under the permit
conditions, requirements, terms, and provisions described herein.
Pamlico Packing Company, Inc.
is hereby authorized: -
1. to continue producing fish packing wash -down wastewater (Outfall 001); fish -processing
wastewater (Outfall 002); shrimp -processing wastewater (Outfall 003); crab -processing wastewater
(Outfall 004), and boiler blowdown (Outfall'005),
from facilities located at the Pamlico Packing Company, Inc., 28 North First Street, Vandemere,
Pamlico County; and,
2. to discharge from said packing and processing works at a specified location (see attached map), into
the Bay River, a Class SC, Sw; NSW waterbody located within the Neuse River Basin.

��Q
�x I�q�Str S 2T ... _ r �-.� r✓ �vi � ��
'y4�'.l��ys�ra�s ,�: cf,.pi,. _ 3 x y, �„�r�>ru•V •� ��,,i b_ r _
',�' r � � ?, �.d r_ � k-• � � s � rT ' � _ r •. a _ 7 1 • d� s�•�.�}1Fy.Jr ..
.." t'; •%Rr.i ;{i C ,.,;'17, . g r ��1
`� • : SFs y,.ra4 !tw*- . i e..� {r j_r;,,3rk <itn!'f `�.-,E3F . _�Ssj�,.y: S
_ ,v � 7,��r+'rrr �+z � i�i ,•.Lc�3L�a x. � � � _ 'f:CS•�n'�r� ,�'d
_ ^ --:� � xr•:� y,�ti� �` S� �� � rs'.�' fis�„� ���yZ � f�`�I+ rYf'��t�+' ;,5��"`S �3rP � `tj 6.4 . ra �:'��`
^*sxr
r} x , IF ar� ��s +�M"ej, Y � xt�� � �.��,(( " ��� � �' r t' i I ''r 5 ' ,v.�..�. I ;P , y'-`�•
� (- '41,at �,�"ti � i ./LiYi yg fir, iL.• r 1
9rt;a F tt �:. t: y5 rM ; k•' xrar,•,z, ah i, '`''y^a,'f'.-
"J{
,� u "+� Y �� „�> t'J�++Fr'� '� M ai��j _ fE�i �t+,s�4µyy •F�''i Z x r�, r. +�'fi
fi� a • P iy t r ��`.'3 i'7 wy�s 2 Fi�ti r !� �.'r r` �s'1 •�s f Fit ,s
t, drV
;Eg}: t if..•' n dri�✓i)t>` :Id np rith��
�� I j r 7r. '�.�." ,� r *u � r�� � i9 t�< � r 7 i ag1F � •w l � :4 vy � � 9i 1r�. r.
�r [ ['f7jrwyy�4�i't,M1 y1r F r�Tf F c sir t r his
a rY "R x i' r A31�9 C F..a +sir e c y`S 01
Y
1 r r Ps
§.r'+ '� „ t rkrar} i J `�r� f kr'✓'.�fit't vim t - xff �E� fir..
r
t°ru kh tN� .+ vGxi d }tF'� r ) cr kmHai�q Mn
• - 2'rl "1�{�, +r vi �L'4 Vr�4a �' TC ':'�, ruTf rfi! �. t rhf l�l 1 4
`L'.3"". i1sk x rFA•w '1 f) f 4r�N� �- of :b § ':k3k +'+ r w $� rM�
r _ _ _ _ o r R.a'. �..� s ': 1: •'c �PT'$�d# € r �� f "t ' tiF i�' -'N.
gl
• ry @ .n v � • S �`} w C ti � L afi '' 7 ti ;y �.15 � I ;" 4 �Ip{ >u 1 h
a r�r\� � i� ., �� �� ''Pi+{i'� 5f �" "�` r .��•�+ �R 3�' t".�„x ��rl��N
7+w :.jtir his � 11�.�Jvr �r ''"i'x�'til'7r tk. r'¢ r�rh� +43 a •v.>'� rr�JN x ��rt "t�tr�.� t:� 31! "�a�' >� �1 r�
x ssROyvd ��y.,,'k'S'- zr �// 4 w,'' " '� �r �f`' .�1,{ icy.: t Kra r Y• t�� 1:
)+ aQ� • °5 � ii"YM]�fw'✓4Y` �;�.F< c "7r r'"4,R, Z r� i 3 :v i ( '4i 7Y' t. t §mr a Y q
�-: �iqx' 'Pn {i ^� •k ,>}i '� +h i! fr'. Yr'" t tri�Hr t
!'rY•t``�r'�'i Ilf '� "e't 'r 1 6
!S °s ! J.s _! �„41 7`k �TMI4r xt:y nt' ran, kp$ri
�• 4 Ys 7� 'tiF��, � Ski e s 'y tit o l t YrS�gC s Yj" �
M. • {: ■ s7 it ?fi - ! �L� fi E fiM Jr S 1 f w y lrsl i
+r` a fH 8%� r r �zG t vaa f at , �t eta rV {,
Gl:^ tl •�'. 't�' sz +F? Ies i�.W I`r r r�tt+' rYF -."Y •s� ��'Cj"iis,,,'.
+, .• �p� � e$ DIn ��. ? � ''�t� dd �4ll � ' �r��v, �'�k^�,� rt � .z
w}fE,. A ? ',".'lVb,rt.[ �4•r'.;�K:ar�v,; +,s�i w�•vta1 >f,ii.! ',{
� +r'•�;",• e Y r`y Ou
i
3{3 r 1 � ` � s, � tiPr't$*�>.F�Ff n �4�aff� a.,3,•w,�' �� r� :t.�.,=..?y�r r � n t a
ay r +Y .•., ��� a� Mf rw' pyYh, Ir'wi 4 i '-It J Nc E r
Ca` `. x �k7 Tr fir, 1"�+„i�r :,z�,k,, , 411, - ;5
Y -r'♦ r !J; . r +v �riG r .. E,•.�'O tfwls 00]L 002, `;
r.- r .. -•l � mr "%.rw 4'• {� , 44 {'r' _ L s• Rr v 4$$i,,, .+ Er+,• i
..;I= • r;Y � „? .] �7 r'+Z 5 �
demere i ,, �:r = 443,�004; and 005s r;
f2�(discnargeund
' . �z >,• 7 �,' ~ ' r,' SY �� r ' iFer„tidal
I-�' r (t£.; / •-7y^q�rl(as]tih u,l�x r •`1,y; 7tif a`+iar µ• p('i r-ls i.t✓ij • •b{,t'.cFyr` to
3 y
r t f'< s • ..` A''`.- ` r.;sT �.; `' / r. -� ti+ u i `��, ti,l colldltlOnS) r 'rt+ �
7 �'r` QL ,` � � Ic- • +�� -. .��1jiC•r'-C`�'•�. r1 f� i� :''� ':ti-i hrr^ � .
{ r^ •�-e.tl: pt + ,s )'. V,:� • !rrr~R' fr.'k'4'' r+s.'lyE`1< vi. `7''x �y? >'S 4 rr`rs•t, Z rx ,l �y,F r� �w
y rSr � � Au r > it 1 - •.. ° ('a'4,. � �' v 4r+. e r ,:- t 4j it" ; h vy ! 2 Y i�( s f�{ s s
yr. l r f^ i � 7� r� 4a �} � �,. frl ti Y3 x. �,• : �- �f !i. c'r IIa.T r�r,,
'� '� � i' !t M 1 J... °• 4 � E ^'"d'.+ '-O� '1i ., t SS \ +. 3-, t: rrr rWr{:�y(y s�/�1�� �Y s7� r ! ;, 1a.;
�,r, �r 7 ';`� •tea 14+ ..h lif G P�•y x�'ri- -,yw �'.•c-E .'lh' �C .5�"%6 • r ,rr { �a..>', t°�`t, cY �r � �ry�4<;�.�w�+�rr•5i��+ �� ��,1 �r4r,f `�-5
1,4W
�•:1` a � 3, 4 errt� ' r'jl �. !�so-F,F,-, 'r"_ti. 1�''��i ti'?, /•M wr r? C r ;�l Ir �^: s.,'r S2. y� f-la� .r • s 'd
7a .� c / x 1� rr r� -.� .f13'� ► kk'C �� � r `S t frr�r 1 {r yr` ° c : �n Rti �ti f +,�C• 1 ` F rC x} ' P 1r ✓ tF. �
{�,:5:,t -y,ry y r•,� fir,_„ �4� � ���.. Gas y.�y ry S" �' rrd 'Y-'�,. e r ''. ~`''.I r rfi `'Dhr f��P, ,,n +,J : r r - i. �'a - '�+,,•'�,«�:� C
[, :,� wrY. +3::I. .2+tirk;.-: y- r h' �'a r�''• ,�., n.,, f, M r ;3/ r
-i,•r :y�kt' f�'% .�, lrtrlvj: s 1n.'�'rYlt.
N r r�JyrsJ,af f.} r`• -,.t si - l.e t ff�ll•r:t4 ilfr ''r 'r r at fi �, ?.^�Lr}',f�„^Cc
.. ^[ji ' �.rTk bh +�� Yy,., •. r "s ,.r y r-^i' S rr M Y l-r >ti J r r - ,� _ r•
!�a 'yya ,i' ✓re.{r rt ;,t� '.'`z ,+y r�"t
�t4�' �,y,s.yy .r s'F'��r�r1 ��t,�1r�''�a�, F•.�, .f Y.yr �p� �eY �r �rf"Cf t, r Ytrr`,nrrt r� i s- i r y� ,� rr1
,cr t:.. k✓`" .,;•"., A �y4�,r:ti•'au t".�`�s�1{{��.�tiN �na}N tkr �ri .s<ar� 'rt, r^^5M1.1r. ;��r af'.;tFxir�?f rt�rty A' ar�fi IYr r� i' :E.K��t rr r..,..s" :?>i;
{�� � 1+ of f 4 ymM ' wm * w� f�•Sr' -.s r. � a,� - •w s ,.. y 4.•...�y r dr•
4' r ➢ iElr_7 i' �'rr� ��r tS �Ma.F a }r�r2 �� � .A' xr r ••r. A a t � _ x. f r_ %-i w; p r J r -r S c � a r a ,: ? s ✓ r:qy f' fir.::
•sir ry )h - It,� -,>, i,� w '��',rY}��C a: !: r/a, ✓. � a s`':. 5' J yMc'„� t� jn,. s. ru r r v r:,S r�• �, ) s��, a �,r r- r f rry.z F. b a '. ,+ st't lrt +. fir.
g7gF ��.,',- rar;� �i}+f4 Wr rN •., SFil'+'_ yrrY��1 a� r'?�.w' '� '�, d+rn.,�_ v� ,rc,. s•. r t
4$'�"r. �'�:, r1y
yt
r r<; f t s� ix }34 tir''!v ,• k 'f' A.-,i' C. d M i i , +ti „r IC? r 5 n� '� �h t Y4, F rt'
Jj i{�: nb � }vrv;.�r� � >' e`1r r � 1 .r � ,r e�f ry 5..,,. 7 +t, k '^' � cy h r .,,•'ky� r : Y,., T• x t t � }f
.•.a `� � __� �;1�'�ls,r yv,_� '�4.! tir a� }xs`S i.' 7 �ti ° S �y� r>'- f`1a'r7atiy� t4 1: _ *ram �r r a ' f - %3
r�;S �'-- Y✓;,.0 �:r '� ,fir, _�+.�' � Frr r'.w.�4y �'�M1 rJr`•r r,�, r� i;°FAN r j'r(r �"i �" `'s:
r //al 1, a• ��vr {H\'� .N V .L*::r t ` •'^. r of 9{tier !. '� r i . .:f it s }•. F'-- rx a� r r -i:�,
1. -. Y i ,F. � ''1. �� CMr N n, "i'S. yr ✓(y. 5 r.l'' y - `. i' 1 t y i 4 3,� L w1 .f
vJ.iV, �-,i iFrt+� ��`�`C.. Cy� r ;A irti `� r`x-�� Z ti .•'r'r t � � 'ri r.- 4 r aEf �+�`,� rq�
� ri` �a..'. W�-. q ��. bif •T' "f•U.'�,,�n{yrf���'�,r'F' �``.,{ j�, rY'�,�}r fr..rri� _, � r. �Sy ir, *-wr, i�rr<k "> tri r�'"tiy� r -{ ��'qr tEf��r'` � �rh�3�er�A;
`r i ,� .-. 7�` y �y2•fs"C c`-r't<^�. {-� � r lye r � ftp sw�1is �ii�r } rrr -,.�� fy rr e � -' d'r+ m,,. ,f�i
.�'r, ..CZ ..e'�'�•.e�.r',-7�r �+r�h�rrr
K�r•.,:N 'F.K4`".- r,v.iw *yhr,�,�,Y1. r;zGy
' rp �l - Ly s 1 Pff_ l�ti!' '�. > :.r {fr.,'rfi r g _� > `:j;,„ r i .x. v,?�'�i, .:5i •yr.r -r .r: ,T n K', 'K '�''�:
f:Y �tiy
t i! ti 'rr T ) ✓:. r } - .• `:SZ r :r T +rx r / s i - >r r r r - rift
�`.�. t.r'� �
-y:i'S':' nt? "✓r '�,ti� 3, �`} �•c' w�• : ri �}''�'{" `T E La; fry. T�t'n,,,-�'iri�y: ,.nr�: sd^ !%� 'i„ �' S• t'"ti r .. {r?r 1 i3''h y, ns }vY h..:'^'y,T _;'.:..
1•Cr,;yM ,r; 1 4 •.ry r i` rx N7•"'i�Yl . �• C :! •' 1`.A ,s,"ar,;' "�i' j j. ; 5:, +� d 'S. '2 y :-~ a'x r ..t } -•'
.-yP r t , .{•,/9 �`,t44. fFF '�•• r �s a , L4 �i'ti'�. - ^.T•;v.,' - t '` w. - ''.sr'- g'.I .:.� 7,� - ';ti. r?r a �„{. J wKc'irr v - �, it r... r y,.ti c �5'�{,
r-%'•- r � x `' ✓ i`f� C S+ r, ti � � s:�'•rf� �'r
'r.t, t,e�,. h y i rA r, � y,•7 •. .�:A„� ;i' iT '� LN;$i rr,;�., l A' r y r f < s/'.. ';C Y. E; �:l }1,2r�5
' � .'-�'. a,i4vx� ;,rr ,�'.�..r 3'r r � o .- �T �' t $ P � r• � � y. �,'' �'�', � r'�? .r{�<- ,irF 7�r• r- t' JY?¢'!: w7.•ri.:'". !, bf r b`a-?f.y"�" ar`tiiP`k r, "' A i Mff- 'S4 -.`' t} y
.� r � r ?• ry..-`r5.rs +S t,� Y• ,r 4 1+ '!{ -t ti ^' � N. �tw rf ! : � :f.'S ti � a �:�: � '7 r � d .: . 4,,^/ I+" YS u7.J -[ 7'�T%' �:r'. J}r �`?' # v TtOn . Ci r � z •?� �" .f '� [� - n if rf +�.
C u- r } tiA`k` <,AF, ""' {�1 1' xx ��fr ti G � i �,- H,n "1yrs t;r' yr f . 3 � n�,., c''� ��.s �1 r. �t�G,..�.:a•.+�.� 1
.Y�Kr' xF /i rti �y.- .{ ' �R. rrr�� •.-� t ij �•Fp - i l a 7� i i. � 4�r .{ r - t, . �2 -,5 � i -ti ~ '
fT•r 'y .N� C -fi '�',''r7�4 ¢( 1 �n� y. -., �r,� _ : s � r s ri.. �a .. rC., f t - ( 's.r�1 T"a �i.�r:, 1�1�4..
.{�{N 'F �"f -` J_ r �f.:rdr kti. � -4 .FZ- 1 rE \ rr N 4 t a _S ! ry•
. ,15.1 r�r ,{ frlr � � s.;: T -�F:r sis' �.}� #aA ,ST,s ti t , w wl.r`.� Y�.F: i �, -{ y4 _- raS•"��`
�'s'rr r•. r , . � �, �,� •� , as ,Y ,,rr .. ,; ,^, f >'^ ; 7 v7! i�N .�
,�a':T �1;. Tina .r^r .,.)"':�>�,r:rRv�N�r' J�rrr ,,. • x.. � ;r.C„.HJ �: rrl r��r°* �',� .Y.^ S. -,r.
Pamlico Packing Company
State Grid/Ouad: D 32 NW / Vandemere, NC Sub -Basin: 03-04-13
Latitude: 350 11' 00" N Drainage Basin: Neuse River Basin
Longitude: 760 39' 40" W Permitted Flow: Not Limited
Receiving Stream: Bay River Stream Class: SC -SW -NSW
Facility
Location
not to scale
North NPDES Permit NCOo 2071
Pamlico Count
I

Permit NCO002071
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting through the expiration date,
the Permittee is authorized to discharge fish packaging wastewater from Outfall 001. Such discharges
shall be limited and monitored by the Permittee as specified below: _
<Tr Gri i94�....3f:��i��;.$�,'':�g.:-'Si
EFFLUENT LIMI�TATIUNS
,�dsYh,:�i��t9y??.�'�StlPa
�MoNI•TQRINGFIZEQUIREMENTS �
y. yl� fyS 1,: ,.�✓ e d c F, ¢ � ' `
PARAMETER;1111i'
_^s,cMonthlyY
..�r:" �xrS rf�..r.;uq n ,. , ` i.rTa � Pke;tr7 r r "F', "5'F' k.F" ',a�
a. ,z , . k , � 4,,, z ,
1:, ,erh,,. s :Y � ., .,K:: „
s WSeeklyDaily �,
F�N SIi 1;�ti'V,4:�If SS�j;�'P f
�� ,Measurements{ „Sample;jSamlalperq:d'p
y
5"�RY9::31 _ -t° +r.l;7w k -Ilq Z-`i'
Yh4t F,
I
�` z.�M1�,./1.,—.0
haveraa i. ,Avers e.j gMaximum.�
,.,i:�:A3
F
,�r Fre uenc ..;Locatton_:�
Flow
1/Month
Estimate 1
Effluent
Total Suspended Solids
30.0 mg/L
60.0 mgfL-
1/Month
Grab
Effluent
Settable Solids
5.0 mL/L
10.0 mL/L
1/Month
Grab
Effluent
Dissolved Oxygenl
1/Month
Grab
Effluent
Temperature
1/Month
Grab
Effluent
Footnotes:
1. Dissolved oxygen daily average shall not fall below 5.0 mg/L.
Units: mg/L = milligrams per liter
mL/L = milliliters per liter. .
Effluent shall contain no floating solids or foam visible in other than trace amounts.
See Special Conditions A.(7.) and A.(8.)'for clean-up procedures and Best Management Practice
(BMP) requirements.

Permit NCO002071
A. (2.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting through the expiration date, the Permittee is.
authorized to discharge fish -processing wastewater from Outfall 002. Such discharges. shall be limited
and monitored by the Permittee as specified below:
� r
tiw4PM,*,', si�d' ix�i.ri ti1'S„'�-A1d':.k..i - 5e1!
�I
i. . ' ''.^.*is�_•2:.+'a i'v�'ai c;a; 1'�ksh:vi . ,.+4i•` ., '�i:i�:? i h{... ``. �1.:$ M- -
1. EFFLUENT I'IMITATIONS
�,[
}'MONaITOgRIyNG REQUIREMENTS
R"
'
1 PARAMETER
-.. e 4 a.. . �4,�
.7�1. •e.klRs^FS
7 tK x 5 n "ho ,r
._. .IAhI'i96tl7 iF�.
1-Inry!!l`1 r d b -0'R yq R
,
a a 7 kl i%
�k;
{Monthly ,Weekly. Daily �+-
�
OE
Measurementt Sample a�Sample
i --
� fi; -i e� 7�M1i'� x 3' rk {�,
P � t. �..�-[ t
e,, Avers a
�. �'.T i:.P,:'�is`sYY '' ��r dusky '. �''
uenc„ i�,Locattons
,�f,7:;, }_&, �._ .r.
;'Ayers ;Maximum
„� �,Fre ;„�T e
Flow
1/Month
Estimate
Effluent
Total Suspended Solids
20.2
82•8
1/Month
Grab
Effluent
(TSS)
lbs/day
lbs/day
Settable Solids
1/Month
Grab
Effluent
Oil and Grease
23 lbs/day
1/Month
Grab
Effluent
lb5.6
Total Residual
13 µg/L '
1/Month
Grab
Effluent
Chlorine
Temperature
1/Month
Grab
Effluent
pH 3
1/Month
Grab
Effluent
Dissolved Oxygen 4
A /Month
Grab
Effluent
Monitor and Report (mg/L)
i/Month
Grab
1/Month
Total Nitrogen
S
Monitor and Report (lbs/month)
1/Month .
Calculated
1/Month
(NOz-N + NO3-N + TKN)
Monitor and Report (lbs/year)
l/Year
Calculated
Effluent
Total Phosphorus
Monitor and Report
1/Month
Grab
Effluent
Footnotes:
1. Total Residual Chlorine (TRC) - the Permittee shall comply with limit and monitoring only if chlorine is
used to disinfect the effluent. Because of difficulties quantifying TRC in a wastewater matrix, the Division
will consider all TRC values reported below 50 ug/L to be "in compliance" with this permit.
2. Effluent temperature shall not increase receiving stream temperature more than 0.8°C (1.44°F) during June
though August, and not more than 2.2°C (3.96°F) during September through May. In no case shall effluent
temperature cause receiving stream temperature to exceed 32°C (89.6°F).
3. pH shall not fail below 6.8 nor exceed 8.5 standard units.
4. Dissolved Oxygen daily average effluent concentration shall not fall below 5.0 mg/L
5. See Special Condition A.(6..), Total Nitrogen Monitoring.
Units:
lbs/day = pounds per day µg/L = micrograms per liter
mL/L = milliliters per liter mg/L = milligrams per liter.
Effluent shall contain no floating solids or foam visible in other than trace amounts.
See Special Conditions A.(7.) and A:(8.) for clean-up procedures and Best Management Practice
(BMP) requirements.

Permit NCO002071
A. (3.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting through the expiration date, the Permittee is
authorized to discharge shrimp -processing wastewater from Outfall 003. Such discharges shall be
limited and monitored by the Permittee as specified below:
rF+i:.'nrn:LiG.H,, wS,a.f,la ;¢2a1:, t�ciy,l IUD
�
d �4�1;
Ea 'ItMY��M�4cF
Q,rr ^7.° y„ '?•y! S is ?va r tiN,1 # ry>i Y ilahB" E d?-1nx h
?nfl� : y s.wp�q,W ar l 5ldtldr� 1L' 1s� a-rs ti ,� S^ a n 1 r6i; ,
"MONITORING;RENTQUIREMES�
1€,� J
}ati4 akCw�] k�:,e �f� re,'... Irykd, .;s'L�
P in7e .
�1r.i• ai,-'u�iY'�,�IS�I7°1G,":�i°i.^•it'4�',6.A1"llc�:�1io��Y.i.
$iCn"'ji'�' yi�'ak"eYi�3is'�;I�s{1°at1 kgP- Bi�'i�i ll�u9� JB:SSr1 'SM .-
. . -
��ManthlV '
y,:F 4'..tsr�i •Si,il,'r
_
MWeekl `�,'w:Dail{J
�.`• ! 1
I k�ifik T`+
''� _ .,. a 14M�2�
S T. 4. A4@� ✓ w
.F .• lL,L�. MIN,�F +eC*1
�� rv"nztc; tzvu
easurement'
tR i .:..vA i
•'! gi!,e�d:i : z :7 iL
�sr ;.. .,
am le °ISample
"sN' p . 7�
1 + 'w .� f
i {
i k 1 .1�.
s _k '.'•` Y°F5�•
��ARAMETERk
rY'� �� Iw71 " y
), r'
fy r
��.! l�(I
_.
x � u d'i. k�t'� �fY
. x ° SS a
Av
a
Maximum
uenc
T a P,,.;.
'.'Locatibn:
,�Fre �.;
,x
Flow
1/Month
Estimate
Effluent
Total Suspended Solids
91.2
1,540
I/Month
Grab
Effluent
(TSS)
lbs/day
lbs/day
Settable Solids
i/Month
Grab
Effluent
28.8
Oil and Grease
504 lbs/day
1/Month
Grab
Effluent
lbs/day
Total Residual Chlorine
13 µg/L 1
1/Month
Grab
Effluent
Temperature 2
l/Month
Grab
Effluent
pH 3
1/Month
Grab
Effluent
Dissolved Oxygen
1/Month
Grab
Effluent.
Monitor and Report (mg/L)
1/Month
Grab
1/Month
n Total Nitrogen
s
Monitor and Report (lbs/month)
1/Month
Calculated
1/Month
tr N+TIC
(NO2Monitor
and Report (lbs/year)
1/Year
Calculated
Effluent
Total Phosphorus —T--Monitor
and Report
1/Month
Grab
Effluent
Footnotes:
1. Total Residual Chlorine (TRC) - the Permittee shall comply with limit and monitoring only if chlorine is
used to disinfect the effluent. Because of difficulties quantifying TRC in a wastewater matrix, the Division
will consider all TRC values reported below 50 ug/L to be "in compliance" with this permit.
2. Effluent temperature shall not increase receiving stream temperature more than 0.8°C (1.44°F) during June
though August, and not more than 2.2°C (3.96°F) during September through May. In no case shall effluent
temperature cause receiving stream temperature to exceed 32°C (89017).
3. pH shall not fall below 6.8 nor exceed 8.5 standard units.
4. Dissolved Oxygen daily average effluent concentration shall not fall below 5.0 mg/L
5. See Special Condition A.(b.), Total Nitrogen Monitoring.
Units:
lbs/day = pounds per day µg/L = micrograms per liter
mL/L = milliliters per liter mg/L = milligrams per liter.
Effluent shall contain no floating solids or foam visible in other than trace amounts.
See Special Conditions A.(7.) and A.(8.) for clean-up procedures and Best Management Practice
(BMP) requirements. `

Permit NCO002071
A. (4.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting through the expiration date, the Permittee is
authorized to discharge crab -processing wastewater from Outfall 004. Such discharges shall be
limited and monitored by the Permittee as specified below:
+ ?'0st,: p r'.,,' Fts p; ,r rr
xt� it fi.ri ,1M. _. `'4 i� �y ,14 ., r fi ,Fall n t'$4xrr
:EFyF�L'DENT'LyiIMIT,yA)TIONJSCR°-MONITORINGREQUlIRwv`EM}EC�NTSn
�
�L
y ` ?m efa�r� 3 iH F ° iw'e ''f F,_ its u. rE � ; rf,,,;?sq+tl9.t�
01,
�i'-MF � k� 15.E 3! YliFR43d.: R', �151A F�.F3�fi!'t eF � 1F`i7n�
' �,.F
Y�Weekleasurement
,
.Vd
ASF;�°#��>,Y
y�
n,V"
�
1lSam le
p
Sam le
p�._rk4'
,
e:
e
;.Maximum.
��eFre uenc
i�I:ET- e
�Lacahon
4g.,,
•;Avers
rAvera .
... ;
�}�f
Flow
1/Month
Estimate
Effluent
Total Suspended Solids
8.5
40.7
1/Month
Grab
Effluent
(TSS)
lbs/day
lbs/day
Settable Solids
l/Month
Grab
Effluent
Oil and Grease
1/Month
Grab
Effluent
lb2 day
lbs/day
Total Residual Chlorine r
13 µg/L '
1/Month
Grab
Effluent
Temperature z
1/Month
Grab
Effluent
pH 3
1/Month
Grab
Effluent
Dissolved Oxygen 4
1/Month
Grab
Effluent
Monitor and Report (mg/L)
1/Month
Grab
1/Month
Total Nitrogen
3
Monitor and Report (lbs/month)
1/Month
Calculated
1/Month
(NO2-N + NO,-N + TKN)
Monitor and Report (lbs/year)
1/Year
Calculated
Effluent
Total Phosphorus
Monitor and Report
1/Month
Grab
Effluent
Footnotes:
1. Total Residual Chlorine (TRC) - the Permittee shall comply with limit and monitoring only if chlorine
is used to disinfect the effluent. Because of difficulties quantifying TRC in a wastewater matrix, the
Division will consider all TRC values reported below 50 ug/L to be "in compliance" with this permit.
2.. Effluent temperature shall not increase receiving stream temperature more than 0.8°C (1.44°F) during
June though August, and not more than 2.2°C (3.96°F) during September through May. In no case shall
effluent temperature cause receiving stream temperature to exceed 32°C (89.6°F).
3. pH shall not fall below 6.8 nor exceed 8.5 standard units.
4. Dissolved Oxygen daily average effluent concentration shall not fall below 5.0 mg/L
5. See Special Condition A.(6.), Total Nitrogen Monitoring.
Units:
lbs/day W pounds per day mg/L = milligrams per liter
mL/L = milliliters per liter µg/L = micrograms per liter.
Effluent shall contain no floating solids or foam visible in other than trace amounts.
See Special Condition A.(7.) and A.(8.) for clean-up procedures and Best Management Practice (BMP)
requirements.

Permit NCO002071
A. (5.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting through the expiration date,
the Permittee is authorized to discharge boiler blowdown wastewater from Outfall 005. Such
discharges shall be limited and monitored by the Permittee as specified below: .
�!•i `p '}�� F 9ye r," i°Srrfmf !
Y"3aff�°diS..•.:4
�, _r ir,� yl` :�Ml I e ,Y eq: lif t [.- —. i73 e Y :'. `9
-'3I�- t���4s11: �t h •i�ISI lv '.., 13`I Tr :.fu.,. ,x
EFFL'UENT,LIMITATIONS
'q
1..
:M'fONITORING'.REQUIREMENTSr
�:
}%III ,IPARAMETER
�.:_ •.N hw , = :;: v,
r�P c IT,
!
E!!f°f �s 66" :I Ir : , t , 4t�a
MontltilyT M Weekly ; :;�-Daly _
',.` ui.t.�.�� rkr�Y Fru.L i Ea.�f;a:'K
6
am I'
V,IleasurMih .Sample ;S ,Sample,
?su.rYsex,�Im:�F��'et'
r
t't_
r
e. Avera e<
akFre uencK�lk `^Location
kAvera <Max�mum
Flow
I/Month
Estimate
E
Oil and Grease
15 mg/L
20 mgfL
1/Month
Grab
E
PH 3
l /Month
Grab
E
Temperature 4
1/Month
Grab
E, U, D
Footnotes:
1. E = Effluent; U = approximately 50 feet upstream (north); D = approximately 50 feet
downstream (south)
2. pH — Effluent pH shall not fall below 6.8 nor exceed 8.5 standard units.'.
3. Temperature -- Effluent temperature shall not increase receiving stream
temperature more than 0.8°C (1.44°F) during the period June though August, and
not more than 2.2°C (3.96"F) during the period September through May. In no
case shall effluent temperature cause receiving stream temperature to�exceed 32°C
(89.6°F).
Units: mg/L = milligrams per liter.
µg/L = micrograms per liter.
Effluent shall contain no floating solids or foam visible in other than trace amounts.

Permit NC0002071
SUPPLIMENT TO EFFLUENT LIMITATIONS
AND MONITORING REQUIREMENTS
A. (6.) TOTAL NITROGEN MONITORING
The Permittee shall calculate the annual mass loading of total nitrogen as the sum of monthly loadings, according
to the following equations:
(a) Monthly Mass Loading Obs/month) = TN x Q x 8.34
where:
TN = the average total nitrogen concentration (mg/L) of
the grab samples collected during the month
Q = the total wastewater flow discharged during the
month (MG/month)
8.34 = Conversion factor, from (mg/L x MG) to pounds
(b) Annual Mass Loading (lbs/year) = ❑ (Monthly Mass Loadings) for the calendar year
The Permittee shall report the total nitrogen concentration for each sample and the monthly mass
loading in the appropriate self -monitoring report and the annual mass loading of total nitrogen in the
December self -monitoring report for the year.
A. (7.) SPECIAL OPERATING CONDITIONS
(a) Best Management Practice (BMP) Requirements:
(1) The Permittee shall discharge no fish parts or floating solids. Discharge shall contain no
foam visible in other than trace amounts.
(2) Permittee shall direct employees and provide resources to implement, at a minimum, such
practices that wastewater volume and wastewater constituents are reduced, as follows:
• Dry cleanup to be performed prior to washdown of the facility;
• Personnel shall be instructed to stop water flow through idle
equipment;
• All process and.washdown equipment shall be fitted with high
pressure/low volume nozzles;
• All on-demand'water delivery hoses shall be fitted with automatic
shut-off nozzles.
(b) Dry Clean-up Requirements:
(1) All batter drippings shall be collected in pans under the breading tables;
(2) Spilled batter shall be squeegeed off the floor prior to wet cleanup;

Permit NCO00207 t
(3) Perinittec shall not allow batter residuals to be discharged to surface waters; all left over
batter and solids shall be collected in a container and disposed properly;
(4) Where practical, trays shall be placed under machines and conveyor belts to collect
.particles of breading or other food products;
(5) . Employees shall be instructed to remove, by hand or other method, leftover breading
from sifters and other machines prior to these solids entering the drainage system;
(6) Flooring shall be brushed with a stiff broom prior to wet cleanup.
A. (8)USE OF BIOCIDE
The Permittee shall use no biocide(s) other than those approved by the Division for this specific
discharge. Should the Permittee intend to use a new biocide not previously approved, a request for
approval must be submitted to the Division no later than 90 days prior to its intended first use. This
approval request shall include both an accurately completed Biocide Form 101 and a Material Safety
Data Sheet (MSDS) for each proposed biocide.
Send biocide approval requests and to:
Aquatic Toxicology Unit
NC DENR — DWQ — ESB
4401 Reedy Creek Road
Raleigh, NC 27607

NPDES PERMIT
DRAFT &FINAL
CHECK LIST
FILE CONTENTS:
ride:
BIMS Tracking Slip
Facility_
Permit No.
NPDES Permit Writer:
Right side:
/ ,
❑ Streamline Package Sheet
(to region, only if streaml' ed)
Draft Permit Cover Letter.
(add new policy text; s marine mayor c nges to permit)
Draft Permit
(order: cover, suppl ent, map, efflue sheets, special conditions)
1� Facility Map
(E-Map: include cility Outfalls; U d D sample locations)
Fact Sheet.
(docu nts pe it writer's issues d re -issue logic)
❑ Permit Writer's Notes
(if no rn F s Sheet -- chronolo , strategy, DMR Review, RPA, etc.)
—❑ Staff Report from Region
(as ap priate -- not needed if treamlined)
[� Old Permit
(Text, Effluent Sheets and Sp cial Conditions)
Permit Application.
(New Permit or Renewal; an additional permittee correspondence)
E9' Acknowledgement Letter
(NPDES Unit written response to Renewal Application)
❑ Permittee Responses
(to acknowledgement letter, if any)
❑ Waste Load Allocation
(reference date; notes if recalculated for current action)
Note: Italics indicate special
conditions not always required or applicable.
d Submitted to 6 for Peer Review: Date a Admin cutoff date
❑ Peer Review completed by Date
W/Updated Public Notice System [date] �. Updated BIMS Events: [date]
Submitted for Public Notice on �. Newspaper Notice Received Actual Notice date(s)
C�' Draft Permit ai / J& to (Regional Staff)
❑ Regional Office Review /Approval completed by
❑ Additional Review by [TOXIDEH] WA initiated by
❑ Additional Review/Approval completed by
❑ EPA Review Draft sent to A initiated by
by 14 i DateU 1�
Received on [Date]
Date
Date
Date
❑ 'EPA Review /Approval [mail / E-mail] completed by Date Received
et'jFINAL to Mike / Susan / Tom / El!)o r signature on Letter Dated
❑ Additional Review [other]
❑ Final Files transferred to Server (Permits Folder) C t�l B1MS Final Updates: Events Limits
Version 11/29/2007

STATE OF NORTH CAROLINA
COUNTY OF PAMLICO
AFFIDA VIT OF PUBLICA TION
Before the undersigned, a person duly commissioned,
qualified and authorized by law to administer oaths, personally
appeared to Kathy Enzerink, who after being first sworn,
deposes and says she is the Business Manager for THE
PAMLICO NEWS, a newspaper published, issued and
entered as second class mail in the Town of Oriental in
said county and state, and that notice or other legal
advertisement, a true copy of which is attached hereto,
was published in THE PAMLICO NEWS on the following dates
And that said newspaper in which such notice, paper,
document or legal advertisement was published was at the
time of each and every publication, a newspaper meeting
all of the requirements and qualifications of Chapter 1,
Section 597 of the General Statutes of North Carolina and
was a qualified newspaper within the meaning of Chapter
1, Section 597 of the General Statutes of North Carolina.
This _ day of ('t 2008
BUSINESS MANA ER
Sworn to and subscribed before me this
day of, 2008
N TARP PUBLIC
My commission expires March 19, 2 I1
Sea]
_PUBLIC NOTICE
i STATE OF NORTH CAROLINA
ENVIRONMENTAL
MANAGEMENT COMMISSION/
NPDES UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617 .r.
NOTIFICATION OF INTENT TO
ISSUE A NPDES WASTEWATER
PERMIT
On the basis of thorough .staff
review and application of NC
General Statute 143.215.1 'and
+ 15A NCAC • 020.0109 and other
1 lawful standards and regulations,
the North Carolina Environmental
Management Commission propos-
es to issue a. National Pollutant
'Discharge Elimination . System
I (NPDES) wastewater discharge per-
mit to the person(s) listed below
'effective 45 days from the publish
date of this notice.
Written comments regarding the
proposed permit will be accepted
until 30 days after the publish date of
this notice. All comments received
prior to that date are considered in
the final determinations regarding
the proposed permit. The Director
of the NC Division of Water Quality
may decide to hold a public meeting
for the proposed permit, should the
Division receive a significant degree i
of public interest.
Copies of the draff permit and
other supporting information on file
used to determine conditions pres-
ent in the.draft permit are available
upon request and payment of the j
costs of reproduction. Mail com-
ments and/or requests for informa-
1 ticn io the NC Division of Water i
Quality at the above address or ?
call Dina Sprinkle [phone], i
extension 363 at the Point Source
Branch. Please include the NPDES
permit number (below) in any com
munication. Interested persons f may also visit the Division. of Water
Quality at 512 N. Salisbury Street,
Raleigh, NC 27,604-1148 between
the hours of 8:06 a.m. and 5:00 p.m.
to review information on file.
Pamlico Packing, Inc (NC0002071)
has applied to renew its permit dis-
charging to the Bay River within the
Neuse River Basin. No parameters
are water quallty limited. This dis-
charge may affect future allocations
to the receiving stream. (1X, 4/2)

DENR/DWQ
FACT SHEET
FOR NPDES PERMIT DEVELOPMENT
Pamlico Packing Company, Inc. - NPDES Permit NC0002071
Table 1 Facility Information
A ]icant/FaciIit Name:
Pamlico Packing Company, Inc.
'Applicant Address:
P.O. Box 308 Vandemere, North Carolina 28587
Facility Address:
28 North First, Vandemere, North Carolina 28537
Permitted Flow
Not limited
Type of Waste:
Untreated/monitored discharge from seafood packing and processing
(WW Code Prim. 25, Second.30, Treatment Unit Code 0000)
Facility/Permit Status:
Class I Minor/Renewal
County:
Pamlico Count
Miscellaneous
Receiving Stream:
Bay River
Regional Officer
Washington
Stream Classification:
SC-Sw-NSW
State Grid /
USGS To o Quad:
G32NW /
Vandemere, NC
303(d) Listed?
No
Permit Writer:
Joe R. Corporon
Subbasin:
03-04-13
Date:
12Mar08
Drainage Area (mi2):
<5 s . mi.
-
Summer 7Q10 (cfs)
Tidal
Winter 7Q10 (cfs):
Tidal
30Q2 (cfs)
Tidal
Average Flow (cfs):
Tidal
IWC (%):
N/A
Prii-nary SIC Code:
1 2092
FACILITY DESCRIPTION
Pamlico Packing sits on the north western shore of the Bay River where local topography is flat
and low-lying, about 0.5 feet above MSL. The Permittee operates a five- to six -day -per -week
seafood packing and processing facility that utilizes both year-round and seasonal processes.
Considering all waste streams, total discharge flow averages between 3,000 and 4,000 gallons per
day (gpd) through 5 outfalls. The report noted that there are now five discharge pipes (Outfalls
001 through 005) located within a 10-meter distance.
Outfall 001 -- fish packing (without processing) operates under General Perm it'conditions
Outfall 002 -- fish processing (bottom fish) per 40CFR 408.212(b), Subpart U.
Outfall 003 -- shrimp processing per 40CFR 408.122(b), Subpart L,
Outfall 004 -- crab processing per 40CFR 408.22(b), Subpart B.
Outfall 005 -- boiler blowdown associated with crab cooking (not process -contact wastewater)
Peak production (daily) has reached 6,000 lbs/day (shrimp), 6,000 Ibs/day (fish), and 800 lbs/day
(crab), during summer months. Pamlico removes solids by physical screening through containers
called "drain buckets" (a minor, Class 1 treatment facility). This facility discharges to the Neuse
River estuary and is not a member of the Lower Neuse River Basin Association.
Fact Shoe[
NI'D S INC00207E Renew;d 2009
Page I

Previous Permit. This facility was first permitted in 1980. The previous permit was issued on
December 29, 2005 and expires on May 31, 2008 and the Division has received the appropriate
documentation to renew.
Waste Load Allocation (WLA). The Division prepared the last Waste Load Allocation in
1991. Effluent limits were based on Guidelines (pH on saltwater guidelines). The Division views
this allocation appropriate for renewal except as noted herein.
Verification of Receiving Stream Conditions. The Division verified discharge to the Bay
River, located within sub -basin 03-04-13 [stream segment 27-150-(1)]. This waterbody has been
classified SC, Sw; NSW and ocean and wind tides influence stream flow. This waterbody is not
listed as an "impaired" on the Division's 303 (d) list. This facility discharges upstream in
proximity, but not within, a waterbody classified High Quality Waters (Sa, HQW; NSW), see
revised map.
PERMITTING APPROACH
Seafood Production. The Permittee's application estimated gross weights for processing fish (Table
2), shrimp (Table 3), and crab (Table 4), as required under federal regulations §40CFR 408, Subparts
U, L and B, respectively. Production data provided by the Permittee on December 4, 2007 is identical
to the previous renewal application. Therefore for this renewal, the Division has not revised
production -based permit limits. Applicable regulations and resulting production calculations are
summarized in the Tables 2, 3, and 4:
Table 2. Fish Processing Subpart U - Parameter Limit Calculations
Qutfa11�0- 2
40 CFR.408.212 (b)
Renewal Production
Previous Limits
Renewal Limits
_ �__ ��
BPT (lbs.11000 lbs.)
(gross weight)
(g g )
(lbs./day)
( Y)
(lbs./day)
( Y)
For
For
Maximum
Average of Daily
Daily
Monthly
Daily
Monthly
Parameter
Daily
Monthly
Production
Values for 30
Max
Average
Max
Average
Max
Average
Da
Da s
TSS
3.6
2.0
23,000 tbs.
10,121 tbs./ day
82.8
20.2
82.8
20.2
Oil & Grease
1.0
0.55
23,000 ibs.
10,121 lbs./ day
23
5.6
23
5.6
PH
6.0-9.0
6.0-9.0
-
1 6.0-9.0
6.0-9.0
6.0-9.0
6.0-9.0
Table 3. Shrimp Processing Subpart L - Parameter Limit Calculations
Oatfall 003
40 CFR.408.122 (b)
Renewal Production
Previous Limits
Renewal Limits
MR
BPT (1bs f10001bs.)
(gross wei ht
(g weight)
(tbs./day)
( y)
(lbs./day)
For
For
Maximum
Average of
Daily
Monthly
Daily
Monthly
Parameter
Daily
Monthly
Production
Daily Values
Max
Average
Max
Average
Max
Average
Day
for 30 Days
TSS
110
38
14,000 lbs.
2,400 lbs./ da
1540
91.2
1540
91.2
Oil & Grease
36
12
1 14,000 lbs.
2,400lbs./ day
504
28.8
504
28.9
PH
6.0-9.0
6.0-9.0
1 -
-
6.0-9.0
6.0-9.0
6.0-9.0
6.0-9.0
Table 4, Crab Processing Subpart B - Parameter Limit Calculations
'
Otrtfall 004
40 CFR.408.22 (b)
Renewal Production
Previous Limits
Renewal Limits
BPT (16sJ10001bs.)
(gross weight)
(tbs./day)
(lbs./day)
For
For
Maximum
Average of Daily
Daily
Monthly
Daily
Monthly
Parameter
Daily
Monthly
Production
Values for 30
Max
Average
Max
Average
Max
Average
Day
Days
TSS
2.2
0.7
18,500 lbs.
11,200 lbs./ day
40.7
8.5
40.7
9.5
Oil & Grease
0.6
0.2
18,500 lbs.
11,200 lbs./ day
11.1
2.4
11.1
2.4
H
6.0-9.0
6.0-9.0
-
1 6.0-9.0
6.0-9.0
6.0-9.0
6.0-9.0
Fact ShCTl
N1'l; FS N 000•_'0" I Rcnew�il 2009
Page 2

Outfall 002 Fish Processing -- Review of DMRs. For a 3-year period (January 2005 through
December 2007), the Permittee reported analytical results in 5 to 7 months per year — all other
months were reported.as "No flow" months, in accord with the permit. Monthly levels of Total
Suspended Solids (TSS) ranged from 0.009 lbs/day to 57 lbslday (6,814 mg/L) in compliance
with permit limits. Wide-ranging levels were reported for Oil & Grease at 0.0003 to 4.0 Ibs/day
again within limits of the permit. On January 29, 2007 the Permittee reported its lowest levels of
Total Nitrogen (0.3 mg/L TN) and Total Phosphorus (0.04 mg/L TP), while on March 21, 2007
the Permittee reported its highest TN at 799 mg/L and TP at 51.6 mg/L. Currently TN and TP are
not permit limited.
Outfall 003 Shrimp Processing -- Review of DMRs. Similar to Outfall 002, the Permittee
reported analytical results for 5 to 7 months per year — all other months reported as "No flow"
months. From January 2005 through December 2007, flow at this outfall appears relatively low,
with reported on -time rates between 2 gallons (0.00002 MGD) to 265 gallons (0.000265 MGD)
total. Monthly values for TSS range from 0.004 lbslday to 9.8 lbslday (521 mg/L). DO levels
appear consistent averaging 7.36 mg/L over 3 years. Oil & Grease levels appear relatively low
with a maximum of 4.0 Ibs/day (S.1 mg/L). TN levels vary widely from a minimum of 0.22 mg/L
(November 30, 2006) to a maximum of 566 mg/L (March 21, 2006) at 0.002809 MGD. The
Permittee reported relatively high single -day levels of TP at 38.4 mg/L and TN at 566 mg/L on
March 21, 2006,
Outfall 004 Crab Processing -- Review of DMRs. For a 3-year period (January 2005 through
December 2007), the Permittee collected samples 4 to 5 months per year — all other months were
reported as "No flow Month." Several parameters appear generally compliant such as
Temperature (seasonally within range), Dissolved Oxygen (6.7 to 8.2 mg/L), and pH (7.0 to 7.6
su). Monthly levels for TSS however range widely from a maximum of 11.1 lbslday (474 mg/L)
at < 0.003 MGD to a minimum of 0.05 lbslday (2.13 mg/L) at an estimated flow of 1000 gallons
(0.001 MGD). TN levels also varied widely from a maximum of 155 mg/L to a minimum of 1.03
mg/L reported at a flow of 0,002809 MGD for this 3-year period. Similarly TN and TP spiked on
a particular sampling day (September 9, 2006) when the Permittee report levels of TP at 33.24
mg/L and TN at 155 mg/L.
COMPLINACE SUMMARY
• The Division notes that production data provided by the Permittee has not changed since
the previous renewal. Therefore, effluent limits have not changed.
Pamlico Packing has stated on its application that it uses chlorine for cleanup, as required
by the Department of Health. The Division has therefore added TRC monitoring and a
permit limit of 28 ug/L to federally regulated Outfalls 002, 003, and 004 in compliance
with the new statewide limit standard for chlorine. However, a footnote has been added
noting that the limit and monitoring apply only if chlorine is used to disinfect effluent.
Fact shCCL
NPDES !+
1agc 3

PROPOSED SCHEDULE FOR PERMIT ISSUANCE
Draft Permit to Public Notice:
Permit Scheduled to Issue:
NPDES DIVISION CONTA
If you have questions
Joe Corporon,at (919)
L
NAME: ,
March 26, 2008
May 5, 2008
above information or on the attached permit, please contact
AL OFFICE COMMENTS
DATE: a? s7/qj� g
NAME: DATE:
SUPERVISOR: DATE:
NPDES SUPERVISOR: DATE:
Fact. Sheet '
NPDES NCO002071 Renewal 2008
Paw 4

Pamlico Packing Co., Inc.
Quality Fresh & Frozen Seafood
Since 1941
P.O. Box 308 * Vandemere, North Carolina 28587
Telephone [phone] * Fax [phone]
www.bestseafood.com
To Whom It May Concern:
My company is requesting renewal of our NP,DES Permit NC0002071. There
have been no changes at our facility since issuance of the last permit. I have enclosed all
requested documents to the best of my knowledge. If you have any questions please
feel free to call.
Sincer y,
Don Cross QEC - 4 2001
Secretary / Treasurer f
L

NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
This form should be completed by seafood processing facilities and mailed to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Website: lhttp://h2o.enr.state.nc.us/NPDESn
NPDES Permit Number NC00 DaO
1. Contact Information:
Facility Name
Owner Name
Street Address
City
State / Zip Code
Telephone Number
Fax Number
e-mail Address
Operator Name
Street Address
City
State / Zip Code
Please print or type
A /l i . 4 WA FA
FOY
r
County 6M7-A M7-
Telephone Number _ (2 51)j?= . GGJ _ „[2 ) 7,&3'O1P/ CELL
2. Location of facility producing discharge:
Check here if same as above
Facility Name (If different'from above)
Street Address or State Road
City
State / Zip Code
County
3. Ownership Statue:
Federal ❑ State ❑ Private 12 Public ❑
4. Standard Industrial Classification (SIC) code(s):
Canned/Cured Fish & Seafood (2091) [y��
Prepared Fresh or Frozen Fish & Seafood (2092)
5. Do you process seafood and/or pack seafood? f(f you only pack seafood, you may be eligible for
coverage under a general permit —please call the NPDES Unit at 9I9-733-SO83J:
Process ❑ Pack Only ❑ Process and Pack
Page 1 of 4 C-Seafood -04/05

NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
6. Facility Operations and Associated Federal Regulations: (check all that apply)
�s Product• {
%'�c.._-.Subpart
§4ICFR�!1n08'
� ff Check �
if Applicably.r"`:..::..@�rs'*:
�
Breaded Shrimp Processing
M
Non -Breaded Shrimp Processing
L
003
Manually Processed Blue Crab
B
Mechanically Processed Blue Crab
C
Hand Shucked Clam Processing
W
Mechanically Shucked Clam Processing
X
Scallop Processing
AD
Fish Meal Processing
O
Manual!Processed Bottom -Fish
U
Mechanica
jy Processed Bottom -Fish
V
Z
Hand -Shucked Oyster Processing'
Z
Mechanically Shucked Oyster Processing
AA
Other (Specify)
Other (Specify)
-
S
7. Production Information:
�..�
Qutfall i CQoD
�0 �
PCoduc#ion¢Re ort �Fir
'twr+wP�� #� a ssn, 3
B ,�' ((2eport gross weight ofaproductk��nor' Rprocesstng
$
e;of Seafood i1
, {.
�"'° i,
�Esce4 tion:�for o`-sters andscallo s re moo'j�roduct"tit,after rocessin
Processed: Maximum Pounds
0 (pounds)
in a Single Da
Processed: Average of Daily
(pounds per day)
Values in 30 Consecutive Days
O
If discharge occurs
all year, check here Eir or list the month(s) in which discharge occurs:
Number of days per
Comments:
wyeeky discharge occurs: S %
LxTn.E r0 NG FUw CF..D -C�A?Ji�TL00lIy4ff+i✓�I.7�Q O&E iC
02
Roductia ttF
rFM:r' eY,p'o,r,
(RAP h„J
wofp°c°r°process
Tlmees
,°
g
e%
iou:od nn;
."
Processed. Maximum Pounds
I (pounds)
d
in a Single Day
g3 {0
Processed: Average of Daily
I (pounds per day)
Values in 30 Consecutive Da s
/� �2
If discharge occurs X*W. FE-8 �AX4W ►OXAVWLL� SEaPr� QG,T j JVJ*Y. r%�
all year, check here ❑ or list the month(s) in which discharge occurs:
Number of days per 5 r�
Comments:
week dischar a occurs;
,.� 1;�4.YM.+I i'dY��i'- {15g4},..'', T k t
.. # ..,
Qutfall,rf
1 Ali:.- i. '�
Production Re ortr +
t &� Wxr r sit aka o
(Rep W pr�ocessing'm .
e>of,!Seatoo d HpFOOCESSIN6
:��.� _
y A., % r, W,;apr�oduct,nnor`to
*� zc ,.-ssi s,
�Exce tion:ft r;:o .stersTand{Lscailo p sire :o roduct wet ht of#e;"ri racesstn
Processed: Maximum Pounds
(pounds)
in a Single Day
00
Processed: Average of Daily
�Qb (pounds per day)
Values in 30 Consecutive Days
If discharge occurs 14hr Ti�/PFJNGf+i pra-EA7J8E
all year, check here ❑ or list the month(s) in which discharge occurs:
Number of days per
5- iD
Comments:
week discharge occurs:
To list' additional outfalls, duplicate this page and correct outfall number(s).
NOTE: if the facility has separate discharge points (outfalls) or multiple industrial processes,
Include a schematic diagram of wastewater flow at the facility.
Page 2 of 4 C-Seafood -04105

NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
6. Facility Operations and Associated Federal Regulations: (check all that apply)
;.�.'`y�ir, �:'�P�roduct`a+h��s`a'�'�t�." �Y.���;����,�`�,�a �:�: �i�w��CFR�408'`
•.+� (!', � t; r a; ��,+y7k`
fir`, i3 ' 47rk' "t tri7yrk{v r ;�sii o; tk: w ,
a: z�li � ,�tln<__ -+� R'7,.�`,'�, � .�i I
� rs.-
'kyllbD..a_�;f
.��4.G"" �. ,�* r � �
�°x';�Cleek��'���,�•:;.if��{n
� .^..r ,. a , x.,,
�2'aN�zr �..ti.,s� v�'rn,rzMP.c,ry.
�'Outfall' �r �;, � �� ,.
�j �'7d`.s .-g .. . � �.x �'' �'i'Y,a
l f �,•t
rY>_.^r a-�r"�y�+;ru•_ ,nets"��x.l,.r�
Breaded Shrimp Processing
M
Non -Breaded Shrim2 Processing
L
Manuall Processed Blue Crab
B
Mechanically Processed Blue Crab
C
Hand Shucked Clam Processing
W
Mechanically Shucked Clam Processing
X
Scallop Processing
AD
Fish Meal Processing
O
Manually Processed Bottom -Fish
U
Mechanically Processed Bottom -Fish
V
L
Hand -Shucked Oyster Processing
Z
Mechanical!Shucked Oyster Processing
AA
Other (Specify)rjV
Other (Specify)
-
5
7. Production Information:
+`Outfall��`00'. ;�:�,.;�` �•:,�
F,•.
r�, r,:; �;.' �a3��:� .rr�.�,��.Production Report���:
t �s�y Re 5 ht�ofa ducts to
, CIRI}8�7 ,rr�
os art wei r rior rocesin� e�ti�
'' f i> p p3 p{ w 4
h's�'re
;-� a^oftiSeafood • ,.'"ix,NG
;�•Exee tion.�f"r.o sters,arzd,aca7lo rt; roduct�wei ht.after,� rocessin .
Processed: Maximum Pounds
18 50v (pounds)
in a Sin le Da
Processed: Average of Daily
a�0 (pounds per day)
Values in 30 Consecutive Da s
If discharge occursPj�L 7%i<e+�Oj�Gi} fjECE/lI,B�R
all year, check here ❑ or list the month(s) in which discharge occurs:
Number of days per
5r
Comments:
week discharge occurs:
,s :.'. __ f+ t j,�-;;�""y v.. x'• y!^'t.
Qutfall ERxu
`7§ " 7� '"`s= E 'AI
R��i'iQduOtion,Re
k: ar ,: srcG,
�QD„?,'9d1
" e:oP:Beafood " AQW/Ex�e
,k {Report groswerght bfLproducti' z�iorto,pracesing
,fionfor3;pA�sters'',an.:salio sr� art roduct}wei htFafter; "rocessiii
Processed: Maximum Pounds
(pounds)
in a Single Da
Processed: Average of Daily
(pounds per day)
Values in 30 Consecutive Days
If discharge occurs
all year, check here ❑ or list the months) in which discharge occurs:
Number of days per /
5' 6
Comments:
week discharge occurs:
mD vzw W A Uly gx�zo
n
i4;?nh,-y, I .I"'¢'.� iYS s=;•:i$x; ., "'.,��iy .+ax., .• �i,k-
Outfall £T00 Inc '4 1 Y"a, N *+7i
'Ss
VA, rev
Nki:f. rDn,�N Max-
J�' " k:'i��k i YnfNd 1 1 Y P: - A. A3 .iY i*'6 .,
" (17Pok�pssw igl}t,oflrproduat'rito
i�
procesautg
+ - ' 9::R,�-.� r'4,_. rn'`'Fki-•, �.•+irw"iW, ASK #m-. •5• T: - �`�
e.,of;Seafood -5•• �•- ?. „x
_,I. ,r F
c$ `tioa fob: x r andv'aeallo sire ort, roduct�ve� Y <aftem ro, esain
Processed: Maximum Pounds
(pounds)
in a Single Da
Processed: Average of Daily
(pounds per day)
Values in 30 Consecutive Days
If discharge occurs
all year, check here ❑ or list the month(s) in which discharge occurs:
Number of days per
Comments:
week discharge occurs:
To list* additional outfalls, duplicate this page and correct outfall number(s).
ROTE: If the facility has separate discharge points (outfalls) or multiple industrial processes,
Include a schematic diagram of wastewater flow at the facility.
Page 2 of 4 C-Seafood -04l05

NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
S. Types of wastewater discharged to surface waters only:
Type
Average Flow
GALLONS PER OPERATING MONTH
Sanitary Sewer - monthly average
O
Cooling Water - monthly average
Process Water - monthly average
Packing Water - monthly average
Other - (Please Specify)
9. Number of employees: L
10. Number of separate discharge points: S
11. Name of receiving stream(s) (Provide a map showing the exact location of each outfall)
B4r RzvE:P
12. List all permits, construction approvals and/or applications (check all that apply and provide permit
numbers or check none if not gpplicableJ:
Tyne Permit Number
Tape
❑ None
❑
Non -Attainment
❑ UIC
❑
Ocean Dumping
[R-NPDES Me
❑
Dredge/Fill Permits
❑ PSD
❑
RCRA
❑ NESHAPS
❑
Other
Permit Number
13. Are any of the following substances added as a result of your operations, activities, or processes?
(Check all that opplyr
Biocides for Algal Control ❑ Chlorine/Bleach 521*� Other (please specify below) ❑ ,
etkyMpK X5 vS.D go ih & o E TS.
Page 3 of 4 CSeatood —04/05

NPDES PERMIT APPLICATION - SHORT FORM C-Seafood
14. Application Supplement - Conventional Pollutant Analyses [under §40CFR 122.211. Show this list to
your North Carolina -certified laboratory.
Provide data for the parameters listed. Temperature and pH shall be grab samples, for all other parameters 24-hour composite sampling shall be
used. If more than one analysis is reported, report daily maximum and monthly average. If only one analysis is reported, report as daily maximum.
Parameter
Daily
Maximum
Monthly
Average
Units of
Measurement
Biochemical Oxygen Demand (BOD5)
Chemical Oxygen Demand (COD)
Total Organic Carbon
Total Suspended Solids
<
Al L.. L.
Ammonia as N
Temperature (Summer)
C2 1
CF 2V5
Temperature (Winter)
PH
7.
15. Is this facility located on Native American lands? (check one)
YES ❑ NO 2
11,
16. Treatment Components - Provide a narrative description of installed wastewater treatment
components at the facility. Include sizes & capacities for each component.
17. Certification
I certify that I am familiar with the information contained in the application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
55
name of Person Signing
Signature of Applicant or Authorized Agent
L-A =
Title
I,
North Carolina General Statute 143-215.6 (b)(2) provides that: Any person who knowingly makes any false
statement representation, or certification in any application, record, report, plan, or other document files or
required to be maintained under Article 21 or regulations of the Environmental Management Commission
implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or
monitoring device or method required to be operated or maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable
by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section
1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both,
for a similar offense.)
Page 4 of 4 C-Seafood -04105

]utfali 001 I IOutfall 002
Cooler/Fish II Fish
Pamlico Packing Co., Inc.
Vandemere, NC
Outfall003 I jOuttall004 1 jOutfail 005
Shrimp Crab Boiler
mcessino or�ocessina blowdown
Bay River

Pamlico Packing Co., Inc.
Quality Fresh & Frozen Seafood
Since 1941
P.O. Box 308 * Vandemere, North Carolina 28587
Telephone [phone] * Fax [phone]
www.bestseafood.com
To Whom It May Concern:
My company does not have a written sludge management plan. We have catch basket
screens at all floor drain locations which are emptied throughout each production day. Any solids
collected are disposed of in our facility waste dumpster.
Regards,
Alyl�
Don Cross
Secretary / Treasurer

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date
lvcZill Z V17 �-z
Permit Number
oa a zo
Facility Name
Afm //c'
Basin Name/Sub-basin number
a aw-7
Receiving Stream
r&/E%
Stream Classification in Permit
SC S A%S kJ
Does permit need NH3 limits?
No
Does permit need TRC limits?
Q-t +/I ops
Does permit need Enteroccoci limit?.
Does permit have toxicity testing?
/ O
Does permit have Special Conditions?
AKS
Does permit have instream monitoring?
ES ou ,a/ por
Is the stream impaired (on 303(d) list)?
p
An obvious compliance concerns?
Any permit mods since lastpermit?
Av o
Existing expiration date
3i L009
New expiration date
3a 7-0 3
New permit effective date
Miscellaneous Comments
LL
YES, This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
name/ownership changes).
YES_ , This is a MORE COMPLEX EXPEDITED pen -nit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan),
Conventional WTP, 303(d) listed, toxicity testing, instream monitoring,
compliance concerns, phased limits). Basin Coordinator to make case -by -
case decision.
YES— This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipallindustrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS, etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TR Version 9/7/2007