NCGNE0627_COMPLETE FILE - HISTORICAL_20091215

�f�
�}1�;
�
k,,
i.

NC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sit€lins Dee Freeman
Governor Director Secretary
Mr. Scott Carr
Bonded Pac Inc.
5100 West W.T. Harris Blvd.
Charlotte, NC 28269
Dear Mr. Carr:
December 15, 2009
Subject: No -Exposure Certification NCGNE0627
Bonded Pac Inc.
5100 West W.T. Harris Blvd.
Charlotte, NC 28269
The Division has reviewed your submittal of the No -Exposure Certification form for Exclusion
from NPDES Stormwater Permitting. Based on your submittal and signed certification of no exposure
at the above referenced facility, and the site visit on 12/08/2009, the Division is granting your
conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is incorporated by
reference in North Carolina regulations.
Please note that by our acceptance of your no -exposure certification, you are obligated to
maintain no -exposure conditions at your facility. If conditions change such that your facility can no
longer qualify for no -exposure exclusion, you are obligated to immediately obtain NPDES permit
coverage for your stormwater discharge. Otherwise, the discharge becomes subject to enforcement as an
un-permitted discharge. Your conditional no -exposure exclusion expires in five years (December 15,
2014). At that time you must re -certify with the Division, or obtain NPDES permit coverage for any
stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to
obtain environmental permits that may be required under other federal, state, or local regulations or
ordinances.
If you have any questions or need further information, please contact Mr. Samar Bou-Ghazale at
[phone].
Sincerely,
Robert B. Krebs Fn
Surface Water Protection Regional SupervisoCc:Storm,,vater Permitting Unit No -Exposure Files Fran McPherson -Budget Office
Mooresville Regional Office
Location: 610 East Center Ave., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: [phone] Customer Service: 1-877-623-6748 S) e
( } ( } N��o,��hCaroJina
Internet: www.ncwaterguality.org Alatimallry.
An Eoual ODoorlunity l Affirmative Action Emotover — 50% Recvcled110% Post Consumer paper

�� ' • Division of Water Quality / Surface Water
NCDENR National Pollutant Discharge Elimination
Noam C , - o� or NO 1\ EXPOSURE
7�CV 1 �ECERTIFICATION for E
4V+•L
—o NReaa�wccs OOOO
NO EXPOSURE CERTIFICATION f
RENEWAL
National Pollutant Discharge Elimination System application for excl
on NO EXPOSURE:
FOR AGENCY USE ONLY
Daic Received
oY'esr
Month
Day
Lifl�'�fieateofCo'Jeiaga, /
N (, O;(o
I y
2 J U L 29 200q .
.check,here,ifthis rs a renewal 0
in from_a.Stoater Permit -based
L� O
Submission of this No Exposure Certification constitutes notification that your facility does not require a
permit for stormwater discharges associated with industrial activity in the State of North Carolina because
it qualifies for a no exposure exclusion. A condition of no exposure at an industrial facility means all
industrial materials and activities are protected by a storm resistant shelter (with some exceptions) to
prevent exposure to rain, snow, snowmelt, andlor runoff.
For permitted facilities in North Carolina, DWQ must approve your application for No
Exposure Certification before this exclusion is effective. Until you are issued a No
Exposure Certification and your NPDES permit is rescinded, your facility must continue
to abide by the terms and conditions of the current permit.
Industrial materials or activities include, but are not limited to: material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
Material handling activities include the storage, loading and unloading, transportation, or conveyance of
any raw material, intermediate product, final product or waste product. A storm resistant shelter is not
required for the following industrial materials and activities: drums, barrels, tanks, and similar containers
that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed" means
banded or otherwise secured and with locked or non -operational taps or valves; adequately maintained
vehicles used in material handling; and final products, other than products that would be mobilized in
stormwater discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In
addition, the exclusion from NPDES permitting is available on a facility -wide basis only ---not for individual
outfalls, if any industrial activities or materials are, or will be, exposed to precipitation, the facility is not
eligible for the no exposure exclusion. By signing and submitting this No Exposure Certification form, you
certify that a condition of no exposure exists at this facility or site and are obligated to comply with the
terms and conditions of 40 CFR 122.26(g).
You are required to reapply for the No Exposure Exclusion once every five (5) Years.
For questions, please contact the DWQ Regional Office for your area. (See page 6)
(Please print or type)
1) Mailing address of ownerloperato-r-/(address to which all certification correspondence will be mailed):
Name Rohd,Pl &C- �yj,4 -
- - -
FT L
Contact Q alp 7►4R.le
Street Address D
City G B L
Telephone No. ?d y 765`—D 76.91
State /1 4f - ZIP Cade Z 7•2- 6 !r
Fax: - O
Page 1 of 7

NCGNE0000 No Exposure Certification
2) Location of facility producing discharge:
Facility Name
Facility Contact
Street Address 2
City State ZIPCode
County
Telephone No.� 5 =0 Fax: 20 1i 6 y
3) Physical location information:
Please provide a narrative description of how to get to the facility (use street names, state road numbers, and
distance and direction from a roadway intersection). jEL_2e7K JI&P4 44ke_ fia pu' kl-
an - T PAS ffled. ,o vL/ on I
(A copy of a map with the facility clearly located on it should be included with the certification application.)
4) Is the facility located on Native American Lands? ❑ Yes AEMo
S) Is this a Federal facility? ❑ Yes RNo
6) Latitude 36• 3/ %� �. Longitude -40-,276;2L9 (deg., min., seconds)
7) This NPDES No Exposure Exclusion application applies to which of the following:
2--New or Proposed Facility Date operation is to begin -ez--3-09
❑ Existing
Date operation began
❑ Renewal of existing No Exposure Certification Certification No.: NCGNE
8) Was this facility or site ever covered under an NPDES Stormwater Permit? ❑ Yes ffNo
If yes, what is the NPDES Permit Number?.
9) Standard Industrial Classification:
Provide the 4 digit Standard Industrial Classification Code (SIC Code) that describes the primary industrial
activity at this facility
SIC Code: 2z
10) Provide a brief description of the types of industrial activities and products produced at this facility:
11) Does this facility have any Non -Discharge permits (ex: recycle permits)?
R'No
❑ Yes
If yes, list the permit numbers for all current Non -Discharge permits for this facility!

NCGNE0000 No Exposure Certification
EX"sure Checklists (12. - 14.)
12) Are any of the following materials or activities exposed to precipitation, now or in the foreseeable
future? (Please check either "Yes" or "No.") If you answer "Yes" to any of these items, you are not
eligible for the no exposure exclusion.
a. using, storing, or cleaning industrial machinery or equipment, and areas where ❑ Yes ErNo ❑ NIA
residuals from using, storing or cleaning industrial machinery or equipment remain
and are exposed to stormwater
b. Materials or residuals on the ground or in stormwater inlets from spills/leaks ❑ Yes "o ❑ NIA
c. Materials or products from past industrial activity
❑ Yes
Wl' o
❑ NIA
d. Material handling equipment (except adequately maintained vehicles)
❑ Yes
"o
❑ NIA
e. Materials or products during loadingfunloading or transporting activities
❑ Yes
"o
❑ NIA
f. Materials or products stored outdoors (except final products intended for outside
❑ Yes
9'N o
❑ NIA
use [e.g., new cars] where exposure to stormwater does not result in the discharge
of pollutants)
g. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks,
❑ Yes
&KNo
❑ NIA
and similar containers
h. Materials or products handled/stored on roads or railways owned or maintained by ❑ Yes "o ❑ NIA
the discharger
i. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters]) ❑ Yes "o ❑ NIA
j. Application or disposal of process wastewater (unless otherwise permitted) ❑ Yes K No ❑ NIA
k. Particulate matter or visible deposits of residuals from roof stacks and/or vents not
❑ Yes C+J'No ❑ NIA
otherwise regulated (i.e., under an air quality control permit) and evident in the
stormwater outflow
I. Empty containers that previously contained materials that are not properly stored
❑ Yes E6o ❑ N/A
(i.e., not closed and stored upside down to prevent precipitation accumulation)
m. For any exterior ASTs, as well as drums, barrels, tanks, and similar containers
❑ Yes W<o ❑ NIA
stored outside, has the facility had any releases in the past three (3) years?
13) Above Ground Storage Tanks (ASTs): If you answer "No" to any of the following items, you are not
eligible for the no exposure exclusion.
a. Are exterior ASTs or piping free of rust, damaged or weathered coating, pits, or ❑ Yes "lo 0 NIA
deterioration, or evidence of leaks?
b. Is secondary containment provided for all exterior ASTs? If so, is it free of any ❑ Yes IH'No ❑ NIA
cracks, holes, or evidence of leaks, and are drain valves maintained locked shut?

NCGNE0000 No Exposure Certification
14) Secondary Containment: If you answer "No" to any of the following items, you are not eligible for the
no exposure exclusion.
a_ Is secondary containment provided for single above ground storage containers ❑ Yes ❑ No P-61A
(including drums, barrels, etc.) with a capacity of more than 660-gallons?
b. Is secondary containment provided for above ground storage containers stored ❑ Yes ❑ No P4A
in close proximity to each other with a combined capacity of more than 1,320-
gallons?
c. Is secondary containment provided for Title III Section 313 Superfund ❑ Yes ❑ No "/A
Amendments and Reauthorization Act (SARA) water priority chemicals*?
d. Is secondary containment provided for hazardous substances** designated in 40 ❑ Yes ❑ No 014/A
CFR §116?
e. Are release valves on all secondary containment structures locked? ❑ Yes ❑ No `d /A
15) Hazardous Waste:
a. Is this facility a Hazardous Waste Treatment, Storage, or Disposal Facility? ❑ Yes VNo ❑ NIA
b. Is this facility a Small Quantity Generator (less than 1000 kg. of hazardous waste ❑ Yes "o ❑ NIA
generated per month) of hazardous waste?
c_ Is this facility a Large Quantity Generator (1000 kg. or more of hazardous waste ❑ Yes "o ❑ NIA
generated per month) of hazardous waste?
If you answered yes to questions b. or c., please provide the following information:
Type(s) of waste:
How is material stored:
Where is material stored:
How many disposal shipments per year:
Name of transport 1 disposal vendor: _
Vendor address:
Footnotes to Questions 14) c. & d.
*Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for de minimis amounts of certain substances,
and/or other qualifiers, as described in the exemptions from reporting requirements of Title III SARA 313 in 40 CFR
§372.38.
*"Note that amounts below the 660-gallon (single) and 1,320-gallon (combined) bulk storage minimums require
secondary containment. However, some exceptions may be made for amounts less than the Reportable Quantities
of the hazardous substances listed in 40 CFR §117.3.

NCGNE0000 No Exposure Certification
16) Other information: If you answer "Yes" to any of the following items, you might not be eligible for the
no exposure exclusion. A more in-depth evaluation of the site circumstances may be required.
a. Does your facility store used, recycled, or otherwise reclaimed pallets outside? ❑ Yes "o ❑ NIA
b. Does your facility have coal piles on site? ❑ Yes li; o ❑ NIA
c. Does your facility store other fuel sources outside in piles, such as wood chips, ❑ Yes "Vo ❑ NIA
sawdust, etc.?
d. Does your facility have air emissions associated with its industrial activity (e.g., ❑ Yes of No ❑ NIA
degreasing operations, plating, painting and metal finishing)? If so, describe the
industrial activity:
e. If you answered yes to d., are those emissions permitted by an Air Quality Permit? ❑ Yes ❑ No W<A
Please specify:
f. Please list any other environmental program permits (federal, state, etc.) not
specified earlier in this application (such as Hazardous Waste Permits, etc.):
Permit: Program:
Permit: Program:
Permit: Program. -
Permit: Program:
Permit: Program:
Permit: Program:
Permit: Program:

NCGNE0000 No Exposure Certification
17) Certification:
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no
exposure" and obtaining an exclusion from NPDES stormwater permitting.
I certify under penalty of law that there are no discharges of stormwater contaminated by exposure to industrial activities
or materials from the industrial facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five (5) years to the North Carolina
Division of Water Quality and, if requested, to the operator of the local municipal separate storm sewer system (MS4) into
which the facility discharges (where applicable). I understand that I must allow the North Carolina Division of Water
Quality, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request.
In the event that the site no longer qualifies for a No Exposure Exclusion, I understand that I must obtain coverage under
an NPDES permit prior to any point source discharge of stormwater from the facility. Additionally, I certify under penalty of
law that this document and all attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my
inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is to the best of my knowledge and belief true, accurate and complete. I am aware
that there are significant penalties for submitting false information, including the possibility of fine and imprisonment for
knowing violations.
I certify that I am familiar with the information contained in this application and that to the best of my knowledge and belief
such information is true, complete, and accurate.
Printed Name of Person Signing: AwRYe't/h
Title:
(Signafu Applicant) (Date Signed)
Please note: This application for the No Exposure Exclusion is subject to approval by the
NCDENR Regional Office prior to issuance. The Regional Office may inspect your facility for
compliance with no exposure conditions prior to that approval. The Regional Office may also
inspect your facility at any time in the future for compliance with the No Exposure Exclusion.
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan, or other
document filed or required to be maintained under this Article or a rule implementing this Article; or who knowingly makes a false
statement of a material fact in a rulemaking proceeding or contested case under this Article; or who falsifies, tampers with, or knowingly
renders inaccurate any recording or monitoring device or method required to be operated or maintained under this Article or rules of the
[Environmental Management) Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine
not to exceed ten thousand dollars ($10,000).
There is currently no fee for a No Exposure Exclusion.

NCGNE0000 No Exposure Certification
Final Checklist
This application should include the following items:
❑ This completed application and all supporting documentation.
❑ A map with the location of the facility clearly marked.
❑ If this is a renewal, indicated current NCGNE number in Question 7_
❑ If the site currently has an NPDES Stormwater Permit, be sure to indicate the permit number in Question 8.
Mail the entire package to:
Stormwater Permitting Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Note
The submission of this document does not guarantee the issuance of a No Exposure Exclusion.
For questions, please contact the DWQ Regional Office for your area.
DWQ Regional Office Contact Information:
Asheville Office ......
[phone]
Fayetteville Office ...
[phone]
Mooresville Office ...
[phone]
Raleigh Office ........
[phone]
Washington Office ...
[phone]
Wilmington Office ...
[phone]
Winston-Salem ......
[phone]
Central Office .........
[phone]

West WT Hams Blvd.
Logrstrts
SITE PLAN
Bonded Logistics - 5100 Hams Boulevard
Total Square Footage = 97,200
O
LIJ
O®
®
0 ®
®
IE
m
®
®
®
®
® E
m
®
i
4
®
®
®
® ®
®
a
®
E3
0 El
Neighboring
®
®
0
customers
w
Warehouse
Office
(7) Truck Doors (3) Rail Doors

,Map of 5100 W Wt Harris Blvd Charlotte, NC by MapQuest
Page 2 of 2
MAPOWES-f
Ii
i
L�ka_y1e}y Rd
' �r�w�Wr"Harris.
200 m
VOW"irl
U� 1z �Is, nre�aor�
-o
-��a•'ni�r M45Y Of
V �I
3 4
IN
S ate.
�f
—J
I i
11 .�
Lakes
2009 MapQues1 Inc.
a ��f
t L
60
�1 _,.5�
x ! IIY7 �N
�JJ
C�S P,� f
k�k'M Deerton Rd_
t,—f',tapData 0200'NAVTEO of TeleAtlas 6v
All rights reserved. Use subject to License/Copyright Map Legend
Directions and maps are informational only. We make no warranties on the accuracy of their content, road conditions or
route usability or expeditiousness. You assume all risk of use. MapQuest and its suppliers shall not be liable to you for
any loss or delay resulting from your use of MapQuest. Your use of MapQuest means you agree to our Terms -of Use
http://www.mapquest.com/maps?city=Charlotte&state=NC&address=5100+West+Wt-+-Harris+Blvd&zipc... 7/ 15/2009