NCGNE0550_COMPLETE FILE - HISTORICAL_20090227

• AYE __ :L'
1 i•
STORNIWATER DIVISION CODING SHEET
NCG PERM ITS
PERMIT NO. NCGNE b
DOC TYPE HISTORICAL FILE
DOC DATE ❑ a
YYYYM M DD

NCDENR
North Carolina Department of Environment and
Division of. Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
February 27, 2009
Mr. Thomas Warlick
Sonoco CorrFlex
300 Forum Parkway
Rural Hall, NC 27045
Natural Resources
Dee Freeman
Secretary
Subject: No -Exposure Certification NCGNE0550
Sonoco CorrFlex
300 Forum Pkwy., Rural Hall, NC 27045
Forsyth County
Dear Mr. Warlick:
The Division has reviewed your submittal of the No -Exposure Certification for Exclusion from NPDES Stormwater
Permitting form. Based on your submittal and signed certification of no exposure at the above referenced facility, the
Division is granting your conditional exclusion from permitting as provided for under 40 CFR 126.22(g), which is
incorporated by reference in North Carolina regulations.
Please note that by our acceptance of your no -exposure certification, you are obligated to maintain no -exposure
conditions at your facility. If conditions change such that your facility can no longer qualify for a no -exposure
exclusion, you are obligated to immediately obtain NPDES permit coverage for your Stormwater discharge.
Otherwise, the discharge becomes subject to enforcement as an un-permitted discharge. Your.conditional no -
exposure exclusion expires in five years (February 26, 2014). At that time you must re -certify with the Division, or
obtain NPDES permit coverage for any stormwater discharges from your facility.
Your conditional exclusion from permitting does not affect your facility's legal requirements to -obtain environmental
permits that may be required under other federal, state, or local regulations or ordinances.
If you have any questions or need further information, please contact Robert Patterson at [phone], or at
[e-mail].
Sincerely,
ORIGINAL. SIGNED BY
KEN PICKLE
for Coleen H. Sullins
cc: Winston-Salem Regional Office -Rose Pruitt
Stormwater Permitting Unit No- Exposure Files
Wetlands and Stormwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Internet: wwwmcwaterquality.org
Nne
orthCarolina
Naturally
An Equal Opportunity L Affirmative Action Employer

WfO NC6-0_EoS'30
United States Environmental Protection Agency Form Approved
NPDES A Washington, DC 20460 OMB No. 2040 0211
FORM ®AW. E
PA NO EXPOSURE CERTIFICATION for Exclusion from
351D-11
NPDES Storm Water Permitting
Submission of this No Exposure Certification constitutes notice that the entity identified in Section A does not require permit authorization for its storm water
discharges associated with industrial activity in the State identified in Section B under EPA's Storm Water Multi -Sector General Permit due to the existence
of a condition of no exposure.
A condition of no exposure exists at an industrial facility when all industrial materials and activities are protected by a storm resistant shelter to prevent
exposure to rain, snow, snowmelt, and/or runoff. Industrial materials or activities include, but are not limited to, material handling equipment or activities,
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products. Material handling activities include the storage,
loading and unloading, transportation, or conveyance of any raw material, intermediate product, final product or waste product. A storm resistant shelter is
not required for the following industrial materials and activities:
— drums, barrels, tanks, and stmilar containers that are tightly sealed, provided those containers are not deteriorated and do not leak. "Sealed"
means banded or otherwise secured and without operational taps or valves;
— adequately maintained vehicles used in material handling; and
— final products, other than products that would be mobilized in storm water discharges (e.g., rock salt).
A No Exposure Certification must be provided for each facility qualifying for the no exposure exclusion. In addition, the exclusion from NPDES permitting is
available on a facility -wide basis only, not for individual outfalls. If any industrial activities or materials are or will be exposed to precipitation, the facility is
not eligible for the no exposure exclusion.
By signing and submitting this No Exposure Certification form, the entity in Section A is certifying that a condition of no exposure exists at its facility or site,
and is obligated to comply with the terms and conditions of 40 CFR 122.26(g).
ALL INFORMATION MUST BE PROVIDED ON THIS FORM.
Detailed instructions for completing this form and obtaining the no exposure exclusion are provided on pages 3 and 4.
A. Facility Operator Information
1. Name: [Sloll joiclol IC,o,r,rIF,1,e7.j I I I I Ikk1 1
3. Mailing Address: a. StreetHALL
:71310101 1Fplr-"9 ,'IP, r1J'iw1
b. C€ty; Fgr1a11�
1l1 AL _I I I_ I I I i I I I I
B. Facility/Site location Information
1. Facility Name: Ispriloc
2. a. Street Address: 10101rr
b. City: r a IF
d. State: kl`-'I e. Zip Code: 271014151 -1 1 1
3. Is the facility located on Indian Lands? Yes ❑ No ❑✓
4. Is this a Federal facility?
5. a. Latitude: 13 tJ " 12,11W "
2. Phone: 13131 Q 91619191519161
c. State: NIQ d. Zip Code: 12171014151 — 1 1 1 1
o "
6. a. Was the facility or site previously covered under an NPDES storm water permit? Yes ❑
b. If yes, enter NPDES permit number:
7. SIC/Activity Codes: Primary: Zf 16,513 Secondary (if applicable): I I I
8. Total size of site associated with industrial activity: 2 -4- acres
9. a. Have you paved or roofed over a formerly exposed, pervious area in order to qualify for the no exposure exclusion? Yes ❑ No ✓❑
b. If yes, please indicate approximately how much area was paved or roofed over. Completing this question does not disqualify you for the no exposure
exclusion. However, your permitting authority may use this information in considering whether storm water discharges from your site are likely to have
an adverse impact on water quality, in which case you could be required to obtain permit coverage.
Less than one acre ❑ One to five acres ❑ More than five acres ❑
EPA Form 3510-11 (10-99) Page 1 of 4

NPDES A ® Form Approved
FORMS �+.oE�� NO EXPOSURE CERTIFICATION for Exclusion from OMB No.2040-0211
3510-11 NPDES Storm Water Permitting
C. Exposure Checklist
Are any of the following materials or activities exposed to precipitation, now or in the foreseeable future?
(Please check either "Yes" or `No" in the appropriate box.) If you answer "Yes" to any of these questions
(1) through (11), you are not eligible for the no exposure exclusion.
Yes
No
1. Using, storing or cleaning industrial machinery or equipment, and areas where residuals from using, storing
D
7
or cleaning industrial machinery or equipment remain and are exposed to storm water
2. Materials or residuals on the ground or in storm water inlets from spills/leaks
El
7
3. Materials or products from past industrial activity
[�
4. Material handling equipment (except adequately maintained vehicles)
5. Materials or products during load inglunloading or transporting activities
6. Materials or products stored outdoors (except final products intended for outside use [e.g„ new cars] where
El
V
exposure to storm water does not result in the discharge of pollutants)
7. Materials contained in open, deteriorated or leaking storage drums, barrels, tanks, and similar containers
071
8. Materials or products handled/stored on roads or railways owned or maintained by the discharger
9. Waste material (except waste in covered, non -leaking containers [e.g., dumpsters])
121
10, Application or disposal of process wastewater (unless otherwise permitted)
17
11, Particulate matter or visible deposits of residuals from roof stacks andlor vents not otherwise regulated
El
Q
(i.e.. under an air quality control permit) and evident in the storm water outflow
D. Certification Statement
I certify under penalty of law that I have read and understand the eligibility requirements for claiming a condition of "no exposure" and obtaining an
exclusion from NPDES storm water permitting.
i certify under penalty of law that there are no discharges of storm water contaminated by exposure to industrial activities or materials from the industrial
facility or site identified in this document (except as allowed under 40 CFR 122.26(g)(2)).
I understand that I am obligated to submit a no exposure certification form once every five years to the NPDES permitting authority and, if requested, to
the operator of the local municipal separate storm sewer system (MS4) into which the facility discharges (where applicable). I understand that I must
allow the NPDES permitting authority, or MS4 operator where the discharge is into the local MS4, to perform inspections to confirm the condition of no
exposure and to make such inspection reports publicly available upon request. I understand that I must obtain coverage under an NPDES permit prior
to any point source discharge of storm water from the facility.
Additionally, I certify under penalty of law that this document and all attachments were prepared under my direction or supervision in accordance with a
system designed to assure that qualified personnel properly gathered and evaluated the information submitted. Based on my inquiry of the person or
persons who manage the system, or those persons directly responsible for gathering the information, the information submitted is to the best of my
knowledge and belief true, accurate and complete. I am aware that there are significant penalties for submitting false information, including the possibility
of fine and imprisonment for knowing violations.
Print Name:1TI111`'1M4sj ,W,alr,1,i,gX 1 1 1 1 1 1 1 1 1
PdntTibe:
Signature:
Date: 111110170,71
EPA Form 3510-11 (10-99) Page 2 of 4

Bryan Mosgrober
Sonoco CorrFlex Rural Hall
P.O. Box 1160
Rural Hall, North Carolina 27045
To whom it may concern,
My name is Bryan Mosgrober, and I am the Safety Manager from the Sonoco
CorrFlex Rural Hall facility. In November of last year, we had applied to the
United States EPA for a No Exposure Certification for Exclusion from NPDES
Storm Water Permitting. The US EPA stated that this was a state matter and to
send the application to the state. Either Alan Owens, Plant Manager or Thomas
Warlick, the Sonoco CorrFlex Environmental representative then mailed it to
your agency. Months later we found that because of the backlog of applications,
our application was lost or misplaced. Contained within is a copy of our
application for the No Exposure Certification. If I have forgotten to include any
information, please do not hesitate to call me.
Thank you,
Bryan Mosgrober
Safety Manager
Sonoco CorrFlex Rural Hall
336.969.0846 Office
336.908.6268 Cell

MEMO
Division of Water Quality
Winston-Salem Regional Office
November 20, 2008
Memorandum to: Bradley Bennett, Stormwater Permitting Unit (Sarah Young)
Through: Steve W. Tedder
WSRO Water Qu pervisor
4
From: Rose Pruitt
Environmental Specialist
Subject: Sonoco CorrFlex: NCGNE0550
No Exposure Certification
Forsyth County
OK to issue No Exposure Certification. Site inspection 11/19 & 26/2008.