HomeMy WebLinkAboutAQ_F_1900083_20191022_CMPL_InspRpt �IJW
NORTH CAROLINA DIVISION OF Raleigh Regional Office
AIR QUALITY Daniels Brothers Logging,Incorporated
NC Facility ID: 1900083
Inspection Report County/FIPS:Chatham/037
Date: 10/25/2019
Facility Data Permit Data
Daniels Brothers Logging,Incorporated Permit: 07692/R05
94 Bonlee-Bennett Road Issued:2/5/2018
Bonlee,NC 27213 Expires: 1/31/2026
Lat: 35d 38.8350m Long: 79d 25.0240m Classification: Small
SIC: 2421 /Sawmills&Planing Mills General Permit Status:Active
NAILS: 321912/Cut Stock,Resawing Lumber,and Planing Current Permit Application(s):None
Contact Data Program Applicability
Facility Contact Authorized Contact Technical Contact SIP
Debbie Daniels Cliff Daniels Debbie Daniels
Bookkeeper Secretary and Co-owner Bookkeeper
(919)837-2879 (919)837-2879 (919)837-2879
Compliance Data
Comments: Appeared to b ' ompliance.
Inspection Date: 10/22/2019
Inspector's Name: Elisabeth Nystrom
Inspector's Signature: Operating Status: Operating
Compliance Code: Compliance-inspection
Action Code:FCE
Date of Signature: ] / On-Site Inspection Result: Compliance
Total Actual emissions in T/ NS/YEAR.
TSP S02 NOX VOC CO PM10 *HAP
2016 11.41 --- --- ---
2012 13.83 --- --- --- ---
*Hi hest HAP Emitted(in pounds)
Five Year Violation History:None
Date Letter Type Rule Violated Violation Resolution Date
Performed Stack Tests since last FCE:None
Date Test Results Test Method(s) Source(s)Tested
(1) DIRECTIONS TO FACILITY: From the Raleigh Regional Office(RRO)take the Outer Beltline(I-440 South),which
becomes US-1 South,to Sanford. After going approximately 41.6 miles,take the Horner Boulevard(US-421 /NC-87 EXIT
69A). At the signal light,turn left onto Homer Boulevard and head north. Take the US-421 /NC-87 S exit,EXIT 69A. Turn
left onto US-421 North. Go 14.1 miles and turn left onto NC-902. Go 1.4 miles and turn right onto Old US 421. Go 2.6 miles
and turn left onto Bonlee Bennett Road. The facility is 0.1 miles on the right. The office is located in the center of the yard.
A.7 CYCLONE REQUIREMENTS—As required by 15A NCAC 2D .0611,particulate matter emissions shall be controlled as
described in the permitted equipment list.
a.Inspection and Maintenance Requirements—the Permittee shall perform and annual inspection of each cyclone system.
b.Recordkeeping Requirements—Records of all maintenance activities shall be recorded in the logbook.
Appeared to be in Compliance—Mr.Daniels has retained records of all inspection and maintenance requirements for this facility dating
back to 2008.The most recent inspections were noted on August 29 and September 26 of 2019.
A.8.CONTROL AND PROHIBITION OF ODOROUS EMISSIONS—As required by 15A NCAC 2D .1806"Control and Prohibition of
Odorous Emissions"the Permittee shall not operate the facility without implementing management practices or installing and operating
odor control equipment sufficient to prevent odorous emissions from the facility from causing or contributing to objectionable odors
beyond the facility's boundary.
Appeared to be in Compliance—No odors were detected at or leaving the facility property.There are no complaints on file against this
facility at the RRO.
(VH) INSIGNIFICANT/EXEMPT ACTIVITIES: No exempt(insignificant)emission activities or sources are indicated
on the permit and no new emissions sources or activities were discovered that should be added to the permit.
(VHI) 112(r)APPLICABILITY: No RMP Required—Daniels Brothers Logging,Incorporated is subject to the 112(r)
program general duty clause,but does not maintain sufficient quantities of regulated chemicals onsite to require a risk
management plan.
(IX) SOURCE TESTING: There are no stack tests pending for Daniels Brothers Logging,Incorporated.
(X) COMPLIANCE HISTORY: A review of DAQ files shows a Notice of Violation(NOV)letter was sent to facility on
June 6,2008 for failure to submit a permit renewal application and emissions inventory 90 days prior to the expiration
of the permit.
(XI) EMISSIONS INVENTORY: The facility has experienced an approximate-17.49%change in PM(TSP)emissions.
This is mainly due to the decrease of throughput that has run through the facility in recent years.
(XII) CONCLUSIONS RECOMMENDATIONS: At the time of this inspection,Daniels Brothers Logging,Incorporated
appeared to be in compliance with all permitting requirements. Another inspection is recommended within two(2)
years.