AQ_F_0400058_20220328_PRMT_PmtApp_.22A

5504 Shadowbrook Drive
Raleigh,NC 27612
919-602-4662
March 22, 2022
Heather Carter, Acting Regional Supervisor
North Carolina Division of Air Quality, NCDEQ
Fayetteville Regional Office
Systel Building RECEIVED
225 Green Street, Suite 714
Fayetteville, North Carolina 28301-5094 MAR 2 8 2022
Subject: Air Permit Modification
Edwards Wood Products, Inc.
160 Pulpwood Yard Road DEQ-FAYETTEVILLERE6'ONALOFFICE
Peachland, NC Plant
Permit No. 10146R03
Facility ID No. 0400058
Dear Ms. Carter:
On behalf of Edwards Wood Products, Inc. (EWPI), this submittal includes an air permit
application to address changes in equipment at EWPI's Peachland, North Carolina plant located
in Anson County. EWPI currently holds air permit No. 10146R03 which covers boiler, lumber
drying kilns, and insignificant sawing operations.
As part of this permit modification, EWPI is requesting that NCDAQ make updates and
corrections to the air permit as outlined below. EWPI has added a new natural gas-fired boiler
for the purpose of providing process steam to the lumber drying kilns on site. The wood-fired
boiler is no longer used for producing process steam for the kilns, but instead will remain as a
backup boiler. Expectations of future use for the wood-fired boiler are minimal. No other
modifications are proposed.
Description of Permit Changes
EWPI hereby requests modifications to their existing air permit given the following additions,
corrections, and modifications to the existing permit:
• Add one natural gas-fired boiler (rated at 16.739 million Btu per hour maximum heat
input; package boiler, model# CB 700-400; serial# L-90141). Boiler only burns NG fuel
and is exempt under 15A NCAC 02Q.0102. Source ID ES-5.
• Corrections to existing permit for source ES-2 based on changes at the plant not
reflected in the permit: The description for ES-2 should indicate only "Two (2)" instead of
the current "Four (4)" listed in the permit. For ES-2, lumber drying kilns are rated at
62,000 board feet capacity each.
• Delete emission source ES-4 from the permit. ES-4 reflects two steam-heated lumber
drying kilns, rated at 62,000 board feet capacity each. These kilns have been relocated
to EWPI's Laurinburg plant. EWPI would like to remove this source from the permit.
EWP-Peachland Air Permit Modification Page 2 of 2 March 22, 2022
Project EWP-P01

5504 Shadowbrook Drive
Raleigh,NC 27612
919-602-4662
Potential emissions will not increase since the existing wood-fired boiler potentials are higher
than emissions associated with the new gas-fired boiler. During operations EWPI will only
operate either the gas-fired boiler or wood-fired boiler, not both simultaneously. Because of
EWPI's plan for minimal use of the wood-fired boiler, EWPI expects actual NC toxic air pollutant
emission levels to drop at the Peachland plant. Since the new boiler will burn only natural gas,
NCTAP emissions of ammonia and hexane, which are by-products of natural gas combustion,
will be added to the facilities pollutant emission totals. Based on normal operations, expected
actual ammonia and hexane emission levels for the gas-fired boiler will remain below the
designated NCDAQ emission threshold limits (TPER levels are defined under 15A NCAC 02Q
.0711 for ammonia and hexane).
The permit application was prepared using NCDEQ's Application forms, which are included in
Appendix A of this report. Estimated potential and actual emission calculations are included in
Appendix B of this report. Appendix C contains a copy of the Request for Zoning Consistency
Determination sent to the town of Concord authority, and boiler specification sheets and
literature are included in Appendix D.
Attached are two (2) copies of EWPI's air permit application along with a check for the $50
processing fee.
Closing
EWPI would appreciate that the Fayetteville Region keep EWPI abreast of any issues that might
have a bearing on the timeframe of your review schedule. If you have any questions or require
further information, please contact Mr. Daryl Grassick ([e-mail]) at 919.602.4662 or
Mr. Chris Harrington, Director Environmental Health and Safety ([e-mail]) of
Edwards Wood Products, Inc. (EWPI) at 704.624.3611.
Sincerely,
L
Daryl H. Grassick
Senior Air Consultant
919.602.4662
[e-mail]
cc: Jeffrey D. Cole, Engineer
Mike Thomas, Environmental Specialist
Appendices
Appendix A— NCDENR Air Permit Application Forms
Appendix B—Supporting Documentation of Emission Calculations
Appendix C—Zoning Consistency Determination Request
Appendix D— Equipment Specification
EWP-Peachland Air Permit Modification Page 2 of 2 March 22, 2022
Project EWP-P01

I
RECEIVED
MAR 2 8 2022
DEQ-FAYETTEVILLE RMONAL OFFICE
APPENDIX A
NCDENR AIR PERMIT APPLICATION FORMS

RECEIVED
FORM A MAR 2 8 2022
GENERAL FACILITY INFORMATION
REVISED 09/22/16 NCDEQ/Division of Air Quality Application for Air Permit to ConstrucVoperat- PP e A
NOTE-APPLICATION WILL NOT BE PROCESSED WITHOUT THE FOLL
O Local Zoning Consistency Determination - -
(new or modification only) ❑ Appropriate Number of Copies of Application Application Fee(please check one option below)
Responsible Official/Authorized Contact Signature ❑ P.E.Seal(if required)
❑ Not Required ❑ePayment ❑Check Enclosed
GENERAL INFORMATION
Legal Corporete/OwnerName: E,,w,r.,,fi Site Name: Edwards Wood Products-Peachland Plant
Site Address(911 Address)Line 1: 160 Pulpwood Yard Road
Site Address Line 2:
City: Peachland
Zip Code: 28133 State: North Carolina
County: Anson
CONTACT INFORMATION
Responsible Official/Authorized Contact:
Invoke Contact:
NameTtle: Chris Harrington/Director Environmental Health and Safety Name/Title: Chris Harrington/Director Environmental Health and Safety
Mailing Address Line 1: P.O.Box 219
Mailing Address Line 1: P.O.Box 219
Mailing Address Line 2: 2215 Old Lawyers Road
City: Marshville Mailing Address Line 2: 2215 Old Lawyers Road
State: NC Zip Code: 28103 City: Marshville State: NC Zip Code: 28103
Primary Phone No.: 704-624-3611 Fax No.: 704-624-5611
Primary Phone No.: 704-624-3611 Fax No.: 704-624-5611
Secondary Phone No.: 704-291-6851
Secondary Phone No.: 704-291-6851
Email Address: [e-mail]
Email Address: [e-mail]
Facility/Inspection Contact:
PermiUTechnical Contact:
Namemtle: Chris Harrington/Director Environmental Health and Safety Name/Title:
Chris Harrington/Director Environmental Health and Safety
Mailing Address Line 1: P.O.Box 219
Mailing Address Line 2: 2215 Old Lawyers Road Mailing Address Line 1: P.O.Box 219
City: Marshville State: NC Zip Code: 28103 Mailing Address Line 2: 2215 Old Lawyers Road
City: Marshville State: NC Zip Code: 28103
Primary Phone No.: 704-624-3611 Fax No.: 704-624-5611 Primary Phone No.: 704-624-3611 Fax No.: 704-624-5611
Secondary Phone No.: 704-291-6851
Secondary Phone No.: 704-291-6851
Email Address: [e-mail]
=mail Address: [e-mail]
APPLICATION IS BEING MADE FOR
New Non-permitted Facility/Greenfield Modification of Facility(permitted) Renewal Title V
❑ ❑ Renewal Non-Title V
❑Name Change ❑ Ownership Change ❑Administrative Amendment ❑Renewal with Modification
FACILITY CLASSIFICATION AFTER APPLICATION(Check Only One)
General Small Prohibitory Small
Synthetic Minor L Title V
FACILITY(Plant Site)INFORMATION
Describe nature of(plant site)operation(s):
Manufacture of wcod products,and savring,edging,chipping.
Facility ID No. 400058
Primary SIC/NAILS Code: 2421 Current/Previous Air Permit Nc 10146R03 Expiration Date: 5/31/2024
Facility Coordinates: Latitude: 34,59,25 Longitude: 80,17,56
Does this application contain II--•tt ***If yes,please contact the DAQ Regional Office prior to submitting this
confidential data-, tJ YES 0 NO application.*"*
(See Instructions)
PERSON OR FIRM THAT PREPARED APPLICATION
Person Name: Daryl H.Grassick
Firm Name:
Mailing Address Line 1: 5504 Shadowbrook Drive
Mailing Address Line 2:
City: Raleigh State: North Carolina Zip Code: 27612
Phone No.: 919-602-4662 County: Wake
Fax No.: 919-602-4662 Email Address:
SIGNATURE OF RESPONSIBLE OFFICIAUAUTHORIZED CONTACT
Name(typed): C ri Harrington X Signature(Blue Ink): Title: Director Environmental Health and Safety
Date:
Attach Additional Sheets AS Necessary Page 1 of 2

FORM A (continued, page 2 of 2)
GENERAL FACILITY INFORMATION
REVISED 09/22/1 o NCDEQ/Division of Air Quality Application for Air Permit to Construct/Operate- PP A
SECTION AA9-APPLICATION FOR NON-TITLE V PERMIT RENEWAL
(Company Name)hereby formally requests renewal of Air Permit No.
There have been no modifications to the originally permitted facility or the operations therein that would require an air permit since the last permit was issued.
Is your facility subject to 40 CFR Part 68"Prevnetion of Accidental Releases"-Section 112(r)of the Clean Air Act? ❑
If yes,have you already submitted a Risk Manage Plan(RMP)to EPA? ❑ YES NO
Did you attach a current emissions inventory? ❑ YES ❑ YES ❑ NO Date Submitted:
`, NO
If no,did you submit the inventory via AERO or by mail? ❑ V_AL RO ❑ Mailed Date Mailed:
SECTION AA2-APPUC ATiON F.0 TITLE V PERMIT RENEWAL
In accordance with the provisions of Title 15A 2Q.0513,the responsible official ofY
hereby formally requests renewal of Air Permit No. (Company Narra)
(Air Permit No.)and further certifies that:
(1) The current air quality permit identifies and describes all emissions units at the above subject facility,except where such units are exempted under the
North Carolina Title V regulations at 15A NCAC 2Q.0500;
(2) The current air quality permit cits all applicable requirements and provides the method or methods for determing compliance with the applicable
requirements;
(3) The facility is currently in compliance,and shall continue to comply,with all applicable requiremetns. (Note: As provided under 15A NCAC 20.0512
compliance with the conditions of the permit shall be deemed compliance with the li app cable requirements specifically identified in the permit);
(4) For applicable requirements that bec
ome ome effective during the term of the renewed permit that th
e he facility shall comply on a timely basis;
(5) The facility shall fulfill applicable enhanced monitoring requirements and submit a compliance certification as required by 40 CFR Part 64.
The responsible official(signature on page 1)certifies under the penalty of law that all information and statements provided above,based on information and belief
formed after reasonable inquiry,are true,accurate,and complete.
SECTIOI'J
AA3-APPLICATION FOR OR NAME CHANGE
New Facility Name:
Former Facility Name:
An official facility name change is requested as described above for the air permit mentioned on page 1 of this form. Complete the other sections if there have been
modifications to the originally premitted facility that would requie an air quality permit since the last permit was issued and if ther has been an ownership change
associated with this name change.
SECTION AA4-APPLICATION FOR AN OWNERSHIP CHANGE
By this application we hereby request transfer of Air Quality Permit No. from the former owner to the new owner as described below.
The transfer of permit responsibility,coverage and liability shall be effective
(immediately or insert date.) The legal ownership of the
facility described on page 1 of this form has been or will be transferred on (date). There have been no modifications to the originally
permitted facility that would require an air quality permit since the last permit was issued.
Signature of New'Buyer)Responsible Official/Authorized.Contact(as typed on page 1)
X Signature(Blue Ink):
Date:
New Facility Name:
Former Facility Name:
Signature of Former'Seller)Responsible Official/Authorized Contact:
Name(typed or print):
Title:
X Signature(Blue ink):
Date:
Former Legal Cc-: -ate/Owner Name:
in lieu of the seller's signature on this form,a letter may be submitted with the seller's signature indicating the ownership change
SECTION AA5-APPLICATION FOR ADMINISTRATIVE AMENDMENT
Describe the requested administrative amendment here(attach additional documents as necessary):
Attach Additional Sheets As Necessary Page 2 of 2

FORMs A2, A3
EMISSION SOURCE LISTING FOR THIS APPLICATION -A2
112r APPLICABILITY INFORMATION -A3
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate A2
EMISSION SOURCE LISTING: New,Modified,Previously Unpermitted,Replaced,Deleted
EMISSION SOURCE EMISSION SOURCE CONTROL DEVICE CONTROL DEVICE
ID NO. DESCRIPTION ID NO. DESCRIPTION
E uipment To Be ADDED By This Application New,Previously Unpermitted,or Replacement)
ES-5 16.739 mmBtu/hr NG-Fired Boiler NA NA
(Only burns NG fuel;exempt under 15A NCAC 02C.0102)
Existing Permitted Equipment To Ee MODIFIED By This Application
ES-2 Corrections to existing permit for source ES-2 based on NA NA
changes at the plant not reflected in the permit:
The description for ES-2 should indicate only"Two(2)" t
instead of the current"Four(4)"listed in the permit. For ES-
2,lumber drying kilns are rated at 62,000 board feet capacih
each.
h
i
Equipment To Be DELETED By This Application
ES-4 Two steam-heated lumber drying kilns,rated at 62,000 board NA NA
feet capacity each have been relocated to EWPI's
Laurinburg plant.
112(r)APPLICABILITY INFORMATION A3
Is your facility subject to 40 C F R Part 68"Prevention of Accidental Releases"-Section 112(r)of the Federal Clean Air Act? Yes No
If No,please specify in detail how your facility avoided applicability: No regulated materials stored in quantities exceeding thresholds.
If your facility is Subject to 112(r),please complete the following:
A. Have you already submitted a Risk Management Plan(RMP)to EPA Pursuant,.o 40 CFR Part 68.10 or Part 68.150?
7 Yes No Specify required RV!?si,brnktal date: If submitted,RMP submittal date:
B. Are you using administrative controls to subject your facility to a lesser 112(r)program standard?
Yes No If yes,please specify:
C. List the processes subject to 112(r)at your facility:
PROCESS LEVEL MAXIMUM INTENDED
PROCESS DESCRIPTION (1,2:or 3) HAZARDOUS CHEMICAL INVENTORY(LBS)
Attach Additional Sheets As Necessary

FORM B1
EMISSION SOURCE (WOOD, COAL, OIL, GAS, OTHER FUEL-FIRED BURNER)
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate B1
EMISSION SOURCE DESCRIPTION: NG-fired boiler rated at 16.739 million BTU/hr.
EMISSION SOURCE ID NO: ES-5
CB 700-400 package boiler(model#CB 700-400). Fuel is natural gas only.
Y CONTROL DEVICE ID NO(S): NA
OPERATING SCENARIO: OF EMISSION POINT(STACK)ID NO(S): NA
DESCRIBE USE: ❑PROCESS HEAT ❑SPACE HEAT ❑ ELECTRICAL GENERATION
❑CONTINUOUS USE ❑STAND BY/EMERGENCY ❑ OTHER(DESCRIBE):_ Process Steam
HEATING MECHANISM: ❑ INDIRECT ❑ DIRECT
MAX.FIRING RATE(MMBTU/HOUR):
WOOD-FIRED BURNER
WOOD TYPE: ❑ BARK ❑ WOOD/BARK ❑ WET WOOD ❑ DRY WOOD ❑ OTHER(DESCRIBE):
PERCENT MOISTURE OF FUEL: _
❑ UNCONTROLLED ❑CONTROLLED WITH FLYASH REINJECTION ❑ CONTROLLED W/O REINJECTION
FUEL FEED METHOD: °
HEAT TRANSFER.JlirCiA: ❑ STEAM ❑AIR ,OTHER(DESCRIBE)
COAL-FIRED BURNER
TYPE OF BOILER IF OTHER DESCRIBE:
PULVERIZED OVERFEED STOKER UNDERFEED STOKER SPREADER STOKER FLUIDIZED BED
❑WET BED ❑ UNCONTROLLED ❑ UNCONTROLLED ❑ UNCONTROLLED ❑ CIRCULATING
[]DRY BED i ❑ CONTROLLED ` ❑ CONTROLLED L] FLYASH REINJECTION ❑ RECIRCULATING
I 1 ❑ NO FLYASH REINJECTION
OIL/GAS-FIRED BURNER
TYPE OF BOILER: ❑UTILITY ❑ INDUSTRIAL [�] COMMERCIAL ❑ INSTITUTIONAL
TYPE OF FIRING: ❑✓ NORMAL ❑TANGENTIAL ❑ LOW NOX BURNERS ❑ NO LOW NOX BURNER
OTHER FUEL-FSRED BURNER
TYPE(S)OF FJEL: PE
TYPE OF BC.LEn: ❑UTILITY ❑ iND S 1 RIAL ❑ CVMiMERCIAL ❑ INSTITUTIONAL
TYPE OF FIRING: TYPE(S)OF CONTROL(S)(IF ANY):
FUEL.USAGE(INCLUDE STARTUPIBACKUP FUELS)
.1AXIMUM DESIGN REQUESTED CAPACITY
FUEL TYPE UNITS CAPACITY(UNIT/HR) LIMITATION(UNIT/HR)
Natural gas CF 16,410.8 NA
I �
FUEL CHARACTERISTICS(COMPLETE ALL THAT ARE APPLICABLE)
SPEC!F!C SULFUR CONTENT ASH CONTENT
FUEL TYPE BTU CONTENT (%BY WEIGHT) (%BY WEIGHT)
Natural gas 1020 B T U CF NA NA
COMMENTS:
AttacA Additional Sheets As Necessary

FORM B
SPECIFIC EMISSION SOURCE INFORMATION (REQUIRED FOR ALL SOURCES)
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate B
EMISSION SOURCE DESCRIPTION: EMISSION SOURCE ID NO: ES-5
Natural gas-fired boiler(page 1 of 2) CONTROL DEVICE ID NO(S): NA
OPERATING SCENARIO OF EMISSION POINT(STACK)ID NO(S): NA
DESCRIBE IN DETAILTHE EMISSiC?: 30URCE PROCI S3-(A-TAC'-i FLO'A D!AGRAM):
NG-fired boiler rated at 16.739 million BTU/hr,CB 700-400 package boiler(model#CB 700-400;serial#L-90141). Fuel is natural gas only.
TYPE OF EMISSION SOURCE(CHECK AND COMPLETE APPROPRIATE FORM 61-139 ON THE FOLLOWING PAGES):
❑, Coal,wood,oil,gas,other burner(Form 131) ❑ Wcodworking(Form 134) ❑ Manuf.of chemicals/coatings/inks(Form 67)
❑ Int.combustion engine/generator(Form 132) LJ Coating/finishing/printing(Form 65) ❑ Incineration(Form 68)
Liquid storage tanks(Form 133) ❑ Storage silos/bins(Form 66) Other(Form 69)
START CONSTRUCTION DATE: December 1,2021 DATE MANUFACTURED: 10/16/1991
MANUFACTURER/MODEL NO.: CB 700-400 1EXPECTED OP.SCHEDULE:_24_HR/DAY 7 DAY/WK 52 WK/YR
IS THIS SOURCE SUBJECT TO? NSPS(SUBPARTS?)- NA U NESHAP(SUBPARTS?): NA
PERCENTAGE ANNUAL THROUGHPUT(%): DEC-FEB 25 MAR-MAY 25 JUN-AUG 25 SEP-NOV 25
CRITERIA AIR POLLUTANT EMISSIONS INFORMATION FOR THIS SOURCE
SOURCE OF EXPECTED ACTUAL POTENTIAL EMISSIONS
EMISSION (AFTER CONTROLS/LIMITS) (BEFORE CONTROLS/LIMITS) (AFTER CONTROLS/LIMITS)
AIR POLLUTANT EMITTED FACTOR ib/hr tons/yr Ib/hr tons/yr Ib/hr tons/yr
PARTICULATE MATTER(PM) AP-42 0.00853 0.02990 0.00853 0.03738 0.00853 0.03738
PARTICULATE MATTER<10 MICRONS(Pvl,o) AP-42 0.00853 0.02990 0.00853 0.03738 0.00853 0.03738
PARTICULATE rL1,TTER<2.5,VlCR0jS(Prvt2.5) AP-42 60.00706 0.02473 0.00706 0.03091 0.00706 0.03091
SULFUR DIOXIDE(S02) AP-42 0.0C985 0.03450 0.00985 0.04313 0.00985 0.04313
NITROGEN OXIDES(NOx) AP-42 1.641 5.750 1.641 7.188 1.341 7.188
CARBON MONOXIDE(CO) AP-42 1.379 4.830 1.379 6.038 1.379 6.038
VOLATILE ORGANIC COMPOUNDS(VOC) AP-42 j 0.09026 0.31627 0.09026 0.39534 0A9026 0.39534
LEAD AP-42 8.21E-06 2.88E-05 8.21 E-06 3.59E-05 8.21 E-06 3.59E-05
OTHER
HAZARDOUS AIR POLLLUTANT EMISSIONS INFORMATION FOR THIS SOURCE
SOURCE OF EXPECTED ACTUAL ' POTENTIAL EMISSIONS
EMISSION (AFTER CONTROLS/LIMITS) (BEFORE CONTROLS/LIMITS) (AFTER CONTROLS/LIMITS)
HAZARDOUS AiR POLLUTANT CAS NO. FACTOR ib/hr tons/yr Ib/hr tons/yr ib/hr tons/yr
Acetaldehyde Ti-i} 75070 AP-42 2.49E-07 8.74E-07 2.49E-07 1.09E-06 2.49E-07 1.09E-06
Acrolein(TH) 107028 AP-42 2.95E-07 1.04E-06 2.95E-07 1.29E-06 2.95E-07 1.29E-06
Ammonia(T) 7664=,i 7 AP-42 u.05251 0.18401 0.05251 ' 0.23001 0.05251 0.23001
Benzene(TH) ! 71432 AP-42 3.=15E-05 1.21 E-04 I 3.45E-05 1.51E-04 3.45E-05 1.51 E-04
Benzo(a)pyrere (TH) 50328 AP-42 1.97E-08 6.90E-08 1.97E-08 8.63E-08 1.97E-08 8.63E-08
Cobalt unlisted compounds(H) COC-other AP-42 ,.33E-06 4.83E-06 1.38E-06 6.04E-06 1.38E-06 6.04E-06
Formaldehyde(TH) 50000 AP-42 0.00123 0.00431 0.00123 0.00539 0.00-123 0.00539
Hexane,n-(TH) C.02954 a 0.10351 0.02954 0.12938 0.02954 0.12938
A.R POLL U; :9T EMISSICIVS n,VF-0RMATION FOR THIS SOURCE
SOURCE OF EXPECTED ACTUAL EMISSIONS AFTER CONTROLS LIMITATIONS
ENiiSSiON
TOXIC AIR P TAN CAS I". FACTOR Iblhr Ib/day Ib,/yr
Acetaldehyde("-.; 75C70 %, 2 _ 2.49E-07 5.99E-06 i 0.00175
Acrolein(TH) 107098 AP-4 2 2.95E-07 7.09E-06 0.00207
Ammonia(T; 76644,7 -A.P-1.21 C.05251 1.260 ' 368.02
Benzene(TH) 71432 AP-42 3.45E-05 8.27E-04 0.24151
Benzo(a)pyrene (TH) 50325 AP-42 1.97E-08 4.73E-07
1.38E-04
Formaldehyde(-:-:; 5 IV,00 AP-42 0.00123 0.02954 8.626
Hexane,n-(TH) 1 ,
1,,0,,5:3 AP-42 0.02954 0.70895 207.01
Attachments:(1;emissions calculations and s.:pporting documen,ad;;n;(2)indicaie all requested state and federal enforceable permit limits(e.g.hours of operation,emission rates)and
describe how these are monitored and k0th v:,het frequency:ano(3,describe any monito+inn.devices.gauges,or test ports for this source.
COMPL:r TE THIS FORM AND COMPLETE AND A TTACh APPROPRIATE B1 THROUGH B9 FORM FOR EACH SOURCE
Att�cn Additiona Sheets As Necessary l

FORM B
SPECIFIC EMISSION SOURCE INFORMATION (REQUIRED FOR ALL SOURCES)
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate B
EMISSION SOURCE DESCRIPTION: EMISSION SOURCE ID NO: ES-5
Natural gas-fired boiler(page 2 of 2) CONTROL DEVICE ID NO(S): NA
OPERATING SCENARIO OF EMISSION POINT(STACK)ID NO(S): NA
DESCRIBE IN DETAILTHE MISS C': _b�;F',CE PRCCE"�jS(-TACS FLvA Y,-:GRAM):
NG-fired boiler rated at 16.739 million BTU/hr,CB 7CC-400 package boiler(model#CB 700-400;serial#L-90141). Fuel is natural gas only.
TYPE OF EMISSION SOURCE(CHEC;�AND COMPLETE AP?ROPRIATE FORM B1-B9 ON THE FOLLOWING PAGES):
0 Coal,wood,oil,gas,other burner(Form,B1) ❑ Woodworking(Form 134) ❑ Manuf.of chemicals/coatings/inks(Form B7)
❑ Int.combustion engine/generator(Form 62) ❑ Coating/finishing/printing(Form 85) ❑ Incineration(Form B8)
Liquid storage tanks(Form 133) ❑ Storage silos/bins(Form 66) Other(Form 139)
START CONSTRUCTION DATE: December 1,2021 DATE MANUFACTURED: 10/16/1991
MANUFACTURER/MODEL NO.: C5 700-400 _ ,EXPECTED OP.SCHEDULE: 24_HR/DAY 7 DAY/WK _52_WK/YR
IS THIS SOURCE SUBJECT TO? LJ NSPS(SUBPARTS?): NA L NESHAP(SUBPARTS?): NA
PERCENTAGE ANNUAL THROUGHPUT(%): DEC-FES 25 MAR-MAY 25 JUN-AUG 25 SEP-NOV 25
CRITERIA AIR POLLUTANT EMISSIONS INFORMATION FOR THIS SOURCE
SOURCE OF EXPECTED ACTUAL POTENTIAL EMISSIONS
EMISSION (AFTER CONTROLS/LIMITS) (BEFORE CONTROLS/LIMITS) (AFTER CONTROLS/LIMITS)
AIR POLLUTwh,"�EMITTED FACTOR Ib/hr tons/yr Ib/hr tons/yr Ibihr tons/yr
PARTICULATE MATTER(PM) AP42 0.00853 0.02990 0.00853 0.03738 0.00853 0.03738
PARTICULATE�,ATTER<10 micpcNs;F v:,,) l AP-42 0.00853 0.02990 0.00853 0.03738 0.00853 0.03738
PARTICULATE w i^�TTER<2.5 iUli'RONS;r iv12.5; AP-42 0.00706 0.02473 0.00706 0.03091 0A0706 0.03091
SULFUR DIOXIDE(S02) ; AP-42 0.00985 0.03450 0.00985 0.04313 0.00985 0.04313
NITROGEN OXIDES(NOx) AP-42 1.641 5.750 1.641 7.188 1.641 7.188
CARBON MONOX;DE(CO) AP-42 1.379 4.830 1.379 6.038 1.379 6A38
VOLATILE CRO _�iC COMPOUNCS(`vOC) AP-42 0.C5026 0.31627 0.09026 06.038 01.379 06.038
LEAD A?-42 8.21E-06 .39534
2.88E-05 8.21E-06 ! 3.59E-05 8.21E-06 3.59E-05
OTHER
HAZARDOUS AIR POLLUTANT'EMISSICUS INFORMATION FOR THIS SOURCE
SOURCE OF EAi:lECTED ACTUAL POTENTIAL EMISSIONS
EMiSS10N t (AFTER CONTROLS/LIMITS) (BEFORE CONTROLS/LIMITS) I (AFTER CONTROLS/LIMITS)
HAZARDOUS Asir e'OLLUTART CAS NO. FACTOR ib/nr tons/yr Ib/hr tons/yr Ibihr I tons/yr
Napthalene (H) 91203 AP-42 1.00E-05 3.51E-05 1.00E-05 I 4.38E-05 1.00E-05 4.38E-05
Selenium compcu:ids(H) SEC AP-42 3.94E-07 1.38E-06 3.94E-07 1.73E-06 3.94E-07 1.73E-06
Toluene{TH) 108833 AP- 2 5.58c-35 1.96E-04 5.58E-05 2.44E-04 5.58E-05 2.44E-04
,
,
i
'"0.�.C AI."@ POLE.:; "��'aT E 99;>SdC 9:► ORf��A TION FOR THIS SOURCE
SOURCE OF EXPECTED ACTUAL EMISSIONS AFTER CONTROLS i LIMITATIONS
EMISSION
TOXIC AIR P^LLjTANT CAS FACTCR Ibihr lb/day Ibtyr
Toluene(TH) -TO cSu3 AP-42 5.58=-05 ' O.00134 ".3S102
i
- i
Attachments:(1)emissions calculations anc;S,:pp0.7ing documen GG ;;;;2)indicate all requesi:z-d state and federal enforceable permit limits(e.g.hours of operation,emission rates)and
describe how these are monitored and with what frequency;and( ?describe any monitoring clevices gauges,or test ports for this source.
COMPLETE THIS FOR,",";I �C ,�I��PLETE A,',L A77 ;Cli „T1,0,n,OPRIATE B1 THROUGH B9 FORM FOR EA^H IS0URCE
Attach Additiona. Sheets As Necessary

FORM D1
FAC.9LITY-WIDE EMISSIONS SUMMARY
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to ConstrucVOperate D�
CRITERIA AIR POLLUTANT EMISSIONS INFORMATION-FACILITY-WIDE
EXPECTED ACTUAL
E.JI:SSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LiMiTA-i IONS) LIMITATIONS) LIMITATIONS)
AIR POLLU-TNT EMITTED tons/yr tons/yr tons/yr
PARTICULATE MATTER(PM) I 4 0.653 2,440 13.38
PARTICULATE MATTER<10 MICRONS(PMio) C.348 43.12 10.18
PARTICULATE MATTER<2.5 MICRONS(PM2.5) 3.224 23.04 6.45
SULFUR DIOXIDE(S02) 0.037 i 1.16 1.16
NITROGEN OXIDES(NOx) 6.92 14.85 14.85
CARBCN d ONOXIDE(CO) 5.51 30.40
30.40
VOLA'7.L=:;.2�GANIC CO;JIPGU;`DS,VCC) 0.41 1.15 ' 1.15
LEAD 6.92E-05 2.22E-03 2.22E-03
GREENF:CUSE GASES(GHG)(SHORT TONS) 7,298 13,066 13,066
OTHER
HAZARDOUS A!R POLLUTANT EMMS!ONS INFORMATION-FACILITY-WIDE
EXPECTEI:ACTUAL
EMISSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CCNTROLS/
LIMITATIONS) LIMITATIONS) LIMITATIONS)
HAZARDOUS AIR POLLUTANT EMITTED CAS NO. i tons/yr tons/yr tons/yr
Acetalde^yde;TH) 75070 '!.20=-03 3.83E-02 3.83E-02
Acetophenone(H) 98862 4.E2E-09 1.48E-07 1.48E-07
Acrolein(TH) 107028 0.77E-03 I 1.85E-01 1.85E-01
Ammonia(T) 7664417 1.84E-01 2.30E-01 2.30E-01
Antimony ;misted Compounds(component of SBC)(H SBC-other 1.14E-05 3.65E-04 l 3.65E-04
Arsenic-n!istad compe:nds (TH) ASC-other 3.17E-05 1.02E-03 1.02E-03
Benzene J.; 71432 6.06E-03 1.94E-01
1.94E-01
Benzo(a)Nyre;e (TH) 5C328 3.75E-06 1.20E-04 1.20E-04
Beryllium natal(unreacted)(TH) 7440417 1.59E-06 5.08E-05 5.0oE-05
Cadmiun;,-natal(elemental unreactec; (TH) 7440439 5.51E-06 1.89E-04 1.89E-04
Carbon tetrachloride(TH) 5^c235 S.^9c-05
2.08E-03 2.00c-03
Chlorine(T:-1; 7732505 4E-C3 ; 3.65E-02 3.65E-02
Chlorcbarzane(TH) 108907 4.76E-05 1.52E-03 1.52E-03
Chloroform(TH) 67863 4.04E-115 1.29E-03 1.29E-03
TOXIC AIR PO?L,IT ANT EMISSIONS► "ORMATION-FACILITY-WIDE
INDICATE REQUESTED ACTUAL EMISSIONS AFTER CO'`lTRCLS/LIMITATIONS. EIMISSIONS ABOVE THE TOXIC PERMIT EMISSION RATE(TPER)IN 15A
NCAC 2C ?,i 1 MAY REQUIRE AIR DISPERSION MCDELii�C. USE NETTING FORD.C2 IF NECESSARY.
Modeling Required? I
TOXIC JLLUTANT EMITTED I CA,id0. Ib/hr lb/day lb/year Yes No l
Acetaidanyde(TH) 7567G 8.75E-03 0.2100 76.63 x
Acrolein T H'; 97028 0.0422 1.01 i 369.32 x I
Ammonia(T) 7664417 0.0525 j 1.26 368.02 x
Arsenic unlisted Compounds(component of ASC)(TH) ASC-other 2.32E-04 5.57E-03 2.03 x
Benzene;7-.; .'432 0.044Z' 1.06 ! 387.79 x
Benzc(s) ;r�.;a (T) 50328 2.74E-0 6.58E-04 0.2401 x
Berylivar::. �,ai(unreacted)(component of BEC)(T/H) ;OK17 1.1 -C- 2.78E-04 0.1016 '
x
Cadmic::,11-�tal(unreacted)(compor .,of CDC)(T/H) ".�J439 4.32E-0: 1.04E-03 0.3786
x
Carbon:,�tr::.:;"loride(TH) c8235 4.74E-0- 0.0114 4.15 x
Chlorine;T", ;782505 8.33E-0-Z 0.1998 72.94 x
ChlOrOb:.::_e..a(TH) 106907 3.48E-04 8.35E-03 3.05 x
Chlorofo:_..: ` ) C7663 2.95E-0`: 7.08E-03 2.59 ! x
COMMEX-r_
Actuals c,aseu on 2015 AEi data. Potentials based on maxima::design operations for wood boiler,new NG boiler,kilns,and sawing equipment. Since the NG boiler will
not oper-c.:e ^ile the wood boiler is running the facility tota!s considered the maximum emissions between the gas boiler and wood boiler.
A tac i Additionw Siyeets As Necessary

FORM D1
FACILITY-WIDE EMISSIONS SUMMARY
REVISEC 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate D1
CRITERIA AIR POLLUTANT EMISSIONS INFORMATION-FACILITY-WIDE
EXPECTED ACTUAL
Eflr?`SSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LiiviiTATIONS) LIMITATIONS) LIMITAT!ONS)
AIR POL-i-FANT EMITTED _ tons/yr tons/yr tons/yr
PARTICL,-A�-E MATTER(PM) I
PARTICULATE MATTER<10 MICRONS(PM10)
PARTICULATE MATTER<2.5 MICRONS(PM2.5) i
SULFUR DIOXIDE(S02)
NITROGEN OXIDES(NOx)
CARBO;�tv,3n1OXIDE(CO) _
V0LAT1Lc Oo�wAN11C C01 V,POUNGS k'01
LEAD
GREENriOuSE GASES(GHG)(SHORT TONS) i
OTHER
HAZARDOUS AIR j°OLLUTAIJT EVISS:O0.S!NFORMATION-FACILITY-WIDE
EX:C01 ED ACTUAL
EMISSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ ; (BEFORE CONTROLS! (AFTER CONTROLS!
LIMITATIONS) LIMITATIONS) LIMITATIONS)
HAZARDOUS AIR POLLUTANT EMITTED CAS NO. -tons/yr tons/yr ! tons/yr
Chromic:!:^Ur:seed Cmods(H)(add.ti c ioni acid to ge C-omer 8.08E-04
Chromic acic!IA)(TH) 7738945 :.C":E_06 1.62E-04 1.62E-04
Cobalt uniistea compounds(H) COC-other 9.38E-06 3.00E-04 3.00E-04
Dinitrophenor,2,4-(H) 512852.60E-07 8.31 E-06 8.31 E-06
D'I(2-ethyihexyl)phthalate(DEH P)(Ti-i) i 178 i 7 u.7 uE-08 2.17E-06 2.17E-06
Ethyl benze--.e;H) 100414 ',7E-05 1.43E-03 1.43E-03
Ethylene�ici-:;oo;de(1,2-dicnlo;oeihar+e)(TH) :37062 4.;6E-05 1.34E-03 1.34E-03
Formalde,-4y ie(T H) 50000 �35_-C3 I 2.03E-01 2.33E-v1
Hexachlorod;benzo-p-dioxin 1,2,3,6,7,8(T) 57653857 Y.59E-11 1.47E-09 1.47E-09
Hexane,r"-(TH) 110543 1.04E-01 1.29E-01 1.29E-01
Hydrogen ch;orde(hydrochioric acid)(TH) 7647010 2.74E-02 8.77E-01 8.77E-01
Lead ur,;;s a3 co pounds(H) Po"'-other 6.92E-05 2.22E-03 2.22E-03
Manganesa ,-,!istea compounds(TH) iMiNC-other 2,31 E-0 3 7.39E-02 7.39E-02
Mercury vapN;, (TH) r_ 7430976 5.C5i=-06 1.62E-04 1.62E-04
TOXIC AIR POLl_'JTANT EMISSION"''NFORMATION-FACILITY40DE
INDICATE RECAUESTED ACTUAL cfv"iSS1ONS AFTEF:CON: ROLS/1-IflI1TATIONS. E%IISSIONS ABOVE THE TOXIC PERMIT EMISSION RATE(T.PER)IN 15A
NCAC 2Q.07-i%MAY REQUIRE AIR DISPERSION MODEUNG. USE NETTING FORM 02 IF NECESSARY.
Modeling Required?
TOXIC Ain POLLUTANT EMITTED CAS NO. Ib/hr I lb/day lb/year Yes No
Di(2-ethyrie>.vI)phthalate(DEHP)(TH) 117817 4.95E-07 r 1.19E-05 4.34E-03 x
Ethylene!Ic-l.ride(1,2-dich!oropthBn?)/TH) 07062 3.OeE.0:. I 7.34E-03 2.68 x r
Soluble Chromaie Cmpos,as Chrome(Vi)(TH) SOLCR6 3.69E-05 8.85E-04 0.3232 x I
Formaldehyde(TH) S0000 0.0464 1.11 406.25 x P
Hexachlorocibenzo-p-dioxin 1,2,3,6,7,8(T) 5;053857 3.35E-10 8.04E-09 2.94E-06 x
Hexane,""-J H) 110543 0.0295 0.7089 207.01 x
-- o
Hydroge,-.c,:; i;de(hydrochloric ac;c. =? 'G 0.2000 4.81 1,754 x
Manganesa,::-,;fisted Compounds(cc..Nonent of MNC) 0.0169 0.4047 147.73 I x
Mercury; (component 3.39E-% 8.85E-04 i x.
Methyl ci,ic;o cnr(TH)(1,1,1 trichioroeihane) 71556 3.2 c-0 4 7.84E-03 2.86 I x
r
Methyl ei.-.y..,etone(T) 73933 5.6 E-01; 1.37E-03 0.4986 x
Methylene c"!;;,,ide(TH)Idich!=^rnet.ane) 75C92 3.0 C3 0.0734 26.78
C0MV,ENTS: _
Actuals oasea on 2015 AEi data. roce :iais based on rnaxir.-:wr^.design operations, wood boiler,new NG boiler,kilns,and sawing equipment. Since tyre NG boiler
will not o^Praie while the wood Loi,er!s�,nning the fac!ity totals considered the ^„i Min,emissions bet.men the gas boiler and wood boiler.
�, �:� Addi"lien?i: '4rr��+Q As Nece3sary

FORM D1
FACILITY-WIDE EMISSIONS SUMMARY
REVISED D922/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate D1
CRITERIA AIR POLLUTANT EMISSIO!VS INFORMATION-FACILITY-WIDE
EXPECTED ACTUAL
E.LS:-IOVS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LiivilTh i IONS) LIMITATIONS) LIMITATIONS)
AIR POLLu I-ANT EMITTED - tons/yr tons/yr tons/yr
PART IC'_'.-L--=_MATTER(PM) ! !
PARTICULATE MATTER<10 MICRONS(PM10) ;
PARTICULATE MATTER<2.5 MICRONS(PM2.5)
SULFUR DIOXIDE(S02) �~
NITROGEN OXIDES(NOx)
CARBC:,_z:vCXIDE(CC)
VOLATiL__G.:�GANiC COiviFGvivuc;�v'GCj
LEAD
GREENHOUSE GASES(GHG)(SHORT TONS)
OTHER
HAZARDOUS fi".!=:'O_Ll!TAI!T ER�,oc::�r,,S INFORMATION-FACILITY-WIDE
EXPECT,ED ACTUAL
EMISSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LIMITATIONS) LIMITATIONS) LIMITATIONS)
HAZARDOUS AIR POLLUTANT EMITTED CAS NO. tons/yr tons/yr tons/yr
Methyl ::a(H)(brornomethane� ;-;�3y ri--05 6.92E-04 6.92 04
Methyl chioriae(H)(chloromethane) .4873 1.06E-03 1.06E-03
Methyl chioroferm(TH)(1,1,1 trichloroethane) ! 71556 4.47E-05 1.43E-03 1.43E-03
Methyl ethvi ketone(T) 78933 7.79E-06 2.49E-04 2.49E-04
Methyle;c .urde(TH)(d1*cnlo(vrte'L0ane) 7 5,,92 ;.'i bE-04 1.34E-02 1.34E-02
Napthajc. i)' _C3 -04 4.48E-03
4.46 c-03
NlCkai --46u2G _- _70_05 1.52E-03 i.52E-03
Nitrophe,.:;;. 130027 i
--- _ 5.08E-06 5.08E-06
Pentaciiiv, ienol(TH) 67865 :roc-08 2.35E-06 Z.35C-06
Perchlorc..c:v;ana(tetrachlorcethyiecie)(TH) 127184 _+oc-05 1.75E-03 I -i.75C-0J
Phenol(?H, I 108952 7.36E-05 ( 2.35E-03 cr_
2.3.,E 03
7723140 E.OE-D5 1.25E-03
Polychlcr::':_c:,:;biphenyls :,30363 c-02 3.76E-07 3.7 JE-07
i
Polycycl:c 0:lanic Matter (H) POW 5.77E-03 5.77E-03
TOXIC AIR POLL:.TpNT EMISSlONS ii`�FORMATION-FACILITY-WIDE
INDICATE 2SQUES7ED AC?U^L S.'.'.!SSIONS AFTER CO°;;ROLS/1_1111:ITATIONS. EMISSIONS ABOVE THE TOXIC PERMIT EMISSION RATE(TPER)IN 15A
NCAC 2Q.0711 MAY REQUIRE AIR DISPERSION MCDEUNG. JSE NETTING FORNII D2 iF NECESSARY.
Modeling Required?
TOXIC A,R; �LLJ e Air T EMITTED C-+S NO. ib/hr lb/day lb/year Yes No
Nickel meta, omponent of 373024./MC1(T/H) 74-,-)020 3.48E-0z!! 0.0083 3.05 i x
Pentach. _nog!TH` ;g 5 .oC_n. 1 29E-05 4.71 E-03
Perchloroethy,ene(tetrachforoethylene)(i h) I 2/184 4.01 E-04 0.0096 I 3.51 x
Phenol(TH; 108952 5.38E-04 0.0129 4.71 x
Polychlor:;ia eu biphenyls (TH,' 3v3o3 8.59E-06 2.06E-06 7.52E-04 x
Styrene;TH, 0;425 0.0200 0.4806 ' 175.43 j x
Tetrachic:cc: enzo-p-dioxin,Z,S,;",c- ;:r) E 2.18E-09 7.94E-07 ! x
7oluena -- 0";83 9.'JC-DJ 0.2327 84.94
x
Trichlor-c;_�t;;yiane(TH) io 3.'i6E-C4 7.59E-03 2.77 x
Trichlorc�;av:,Dmethane(C=C 111)(T) 75694 4.32E-0-;_ 0.0104 3.79 x
Vinyl c is ::e Tr) ;L314 4.5 -
I
SE 03 1.66 x
Xyle-e _ nv 20 7 2.E4�-
C- 2.31 x. E
COMM.,E`
Actuais bases on 2C55:�Ei data. Po,.=�tvais eased on maxim.,.oesign cperations t;,,wcod boiler,new NG boiler,kilns,and sawing equipment. Since:r.e NG boiler
will not c ^._t!hile the,.vood hoi!er running the fac,'%,tet=_!_considered tr.e r:axinium emissicns between the gas boiler and wood boiler.
5�.eets As Necessary

FORAW 01
FACILITY-WIDE EMJSSIONS SUMMARY
REVISED 09/22/16 NCDEQ/Division of Air Quality-Application for Air Permit to Construct/Operate a D1
i;
CRITERIA AIR POLLUTANT EMISSIONS INFORMATION-FACILITY-WIDE
EXPECTED ACTUAL
E'J.SSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LiwuTti i IONS) LIMITATIONS) LIMITATIONS)
AIR POL,_,j-f tAT EMITTED Lons/yr I tons/yr tons/yr
PARTICL E MATTER(PM)
PARTICULATE MATTER<10 MICRONS(PM10)
PARTICULATE MATTER<2.5 MICRONS(PM2.5) _
SULFUR DIOXIDE(S02)
NITROGEN 3X1DES(NOx)
CARBO1,,i CieOX{DE(CC)
VOLAT.Li=JiwAMC COiJiPviJiVDS Lvv�.)
LEAD i
GREENHOUSE GASES(GHG)(SHORT TONS)
OTHER
HAZARDOUS AIR POL LUTAHT c"T:Gch0p1S!NFORMAT10N-FACILITY-WIDE
E::PECT`D,ACTUAL
EMISSIONS POTENTIAL EMISSIONS POTENTIAL EMISSIONS
(AFTER CONTROLS/ (BEFORE CONTROLS/ (AFTER CONTROLS/
LIMITATIONS) LIMITATIONS) LIMITATIONS)
HAZARDOUS AIR POLLUTANT EMITTED CAS NO. tons/yr tons/yr tons/yr
Prop ion2i�er,.de(H) <3386 =-J5 2.82E-03 2?=. 03
Propylene dichicride(H)(1.2 dichlorcnropane) 8875 ;.i8 05 1.52E-03 1.52E-03
Selenium H compounds P (H) SEC 4.04E-U6 1.29E-04 1.29E-04
Styrene(T H) -_ 100425 6.74E-03 8.77E-02 8.77E-02
Tetrach,�;o�iu_ilzo-P-diOxiil,2,3,7,0_(Tnj 1746016 ,_24E-11 3.97E-10 3.97E-10
Toluei,c -a883 =
_ - _03 4.25E-02 4.25E_02
Trich!oi��_-a a(Tn) �u10 --05 1.38E-03 -
-03
Trich (CFC 1: -5694 _.05 1.89E-03 'i.3;E-03
Trichior�u �,: ,2,4,6-(H) 88062 -08 1.02E-06 ':.i,2E-06
Viny;c 11,_.-c T H) 75014 _.33c-05 8.31 E-04 8.3 c-04
Xylem 3.31E-05 1.15E-03
TOX!C AIR EMISS O!E,;.+!E.=0°RI!AT".ON L FACILITY-WIDE �-
INDICATE REQUESTED ACT..:AL EL":SS!ONS AFTER;CONMIOILS/LIMITAT:ONS. L`.',!SSIONS ABOVE THE TOXIC PERMIT EMISSION RATE( E 15A
NCAC 20.0711 MAY REQUIRE AIR DISPERSION MODELING. USE NETTING FORM D2 IF NECESSARY.
Modeling Required? `
TOXIC At2 POLLUTANT EMITTED CA.S 1\0. •h/hr Ib/day Ib/year Yes No
I '
i
d f
I
7
l
COMMENTS:
Actuals eased on 2015 AEi data. Potentials based on maximum design cperations for wcod boiler,new NG boiler,kilns,and sawing equipment.uiP ment. Since tr.e NG boiler
will not cperwte while the wood hci!er is ru-ning the fac'!�;,tctals considered the raviMiwm emissions bet teen the gas boiler and wood boiler.
Aff�r",4ddilJor=0 Shsgi-a As Nece3sary

APPENDIX B
SUPPOR-`.NG DOCU a MENTATION OF EMISSIONS CALCULATIONS

NATURAL GAS COMBUSTION EMISSIONS CALCULATOR REVISION N 01/05/2017-INPUT SCREEN
Instructions: Enter emission source/facility data on the"INPUT"tab/screen. The air emission results and summary of input data are
viewed/printed on the"OUTPUT"tablscreen. The different tabs are on the bottom of this screen.
This spreadsheet is for your use only and should be used with caution.NCDEQ does not guarantee the accuracy of the information
contained. This spreadsheet is subject to continual revision and updating. It is your responsibility to be aware of the most current
Air Quality information available. NCDEQ is not responsible for errors or omissions that may be contained herein.
ENVIRONMENTA:0�,A:ITY
Directions:Enter and select information in the boxes in the column on the right:
Fl.' LDS SELECTIONS
mPANY NAME: EWPI-Peachland
FACILITY ID NUMBER: 400058
PERMIT NUMBER 10146R03
FACILITY CITY: Peachland
7r,"CILITY COUNTY: Anson
SPREADSHEET PREPARED BY: D.Grassick
=:_..SSION SOURCE ID NO.: ES-5
mi! XIMUM HEAT INPUT(MILLION BTU PER HOUR): 16.74 mmBTU/HR
TYPE OF BOILER: SMALL BOILER(<100 mmBTU/HR) 1W
DOES THE SOURCE ALSC BURN COAL OR FUEL OIL? No 1W
OF CONSTRUCTION: 12/1/2021
(mm/dd/yyyy)
Q01TIONAL INFORMATION FOR GREENHOUSE GAS(GHGI EMISSIONS
ENTER Calculation Tier from EPA Mandatory Reporting Rule(MRR)*Subpart C TIER 1: DEFAULT HHV AND DEFAULT EF MW
Sae http://vAvvv.epa.gO�l.C!imatechange!emissions/ghgrulemaking.htmi
S:',�CE TIER 31IS NOT BE`NG USED,DO NOT ENTER FUEL CARBON CONTENT 0.7500 —�
".'sCE TIER 3 IS NOT SE KG USED,DO NC; ENTER MOLECULAR WEIGHT 19.00 kg/kg-mole
HEATING VALUE
:.., JAL AVG iVIE+S CC F,�Ei_(;EATING'J;;�JE(BTU!SC ,02 F): 10 BTU/SCF
-FAULT FUEL HEATnNG VALUE(BTU/SCF) --will be used for GHG calculations under TIER 1 approach
I—?,028 BTU/SCF default value is from EPA's mandatory reporting rule,Table C-1,"Natural Gas Pipeline(Weighted U.S.Average)"
OSAGE ARID OTHER SOURCE-SPECIFIC DATA
ACTUAL YEARLY FUEL USAGE(MILLION SCF): 115.01 MILLION SCF
C.ALCULATED POTENTIAL YEARLY USAGE(MILLION SCF) 1zi•3.76 MILLION SCF
REQUESTED ANNUAL'•_IMITATION(MILLION SCF) 143.76 MILLION SCF (TYPEOVER IF NECESSARY-DEFAULT IS POTENTIAL)
C."Y_Y HOURS OF CPE RAT 10N: 24 HOURS
71.1PE OF EMISSION COIF.ROL: NO CONTROL
SNCR APPLIED TC TNT=BOILER? NO

NATURAL GAS COMBUSTION EMISSIONS CALCULATOR REVISION N 01/05/2017-OUTPUT SCREEN
Instructions: Enter emission source/facility data on the"INPUT'tablscreen,The air emission results and summary of input data are viewed I
printed on the"OUTPUT'tablscreen.The different tabs are on the bottom of this screen.
This spreadsheet is for your use only and should be used with caution.NCDEQ does not guarantee the accuracy of the information contained.This
spreadsheet is subject to continual revision and updating.It is your responsibility to be aware of the most current information available. NCDEQ is
AirQaaliry not responsible for errors or omissions that may be contained herein.
EMVIRONMENTAL OUALITY
SOURCE/FACILITY/USER INPUT SUMMARY LFROM INPUT SCREEN
COMPANY: EWPI-Peachland FACILITY ID NO.: 400058
PERMIT NUMBER: 101461103
EMISSION SOL.RCE DESCRIPTION: 16.739 MMBTU/HR NATURAL GAS-FIRED BOILER FACILITY CITY: Peachland
EMISSION SCURC= D NO.: ES-5 FACILITY COUNTY: Anson
CONTROL REV.---_ NO CONTROL POLLUTANT CONTROL EFF.
SPREADSHEET PREPARED BY: D.Grassick NOX CALC'D AS 0%
ACTUAL FUEL THROUGHPUT: 115.01 10 SCF/YR FUEL HEAT VALUE: 1,020 BTU/SCF
POTENTIAL FUEL THROUGHPUT: 143.76 105 SCF/YR BOILER TYPE SMALL BOILER(c100 mmBTU/HR) INO SNCR APPLIED
REQUESTED MAX c' F-'HRPT' 143.76 0°SCF/YR HOI R3 OF OPERA7:)':S 24
r9fr RIA A/R POLLUTANT EMISSIONS INFORMATION
I ACT JAL EMISSIONS POTENTIAL EMSSIONS EMISSION FACTOR
.:.r RJLa:;Irn s; r6;:r vftk c(NJtR ;u•.II1:1 (AFTER CCNJTRUL6 r.EAIT S; Ibirn Btu
AIR POLLUTANT E..-:TTED 1"hr tons/r Ib/hr tons/r Ib/hr tons r uncontrolled controlled
PARTICULATE MATTER(Total) 0.01 0.03 0.01 0.04 0.01 0.04 0.001 0.001
PARTICULATE VA 7ER(Filterable) 0.00 0.01 0.00 0.01 0.00 0.01 0.000 0.000
PARTICULATE N1,-TER;Condensable) 0.01 0.02 0.01 0.02 0.01 0.02 0.000 0.000
PM 2.5 Tota! _ 0.01 0.02 0.01 0.03 0.01 0.03 0.000 0.000
PM 2.5 Fikerable) _ _ 0.00 7.G1 0.00 0.01 0.00 0.01 0.000 0.000
SULFUR DIOXIDE,SCU; 0.01 J.02 0.01 0.041 0.01 0.04 0.0011 0.001
NITROGEN OXtur_3,.NUx 1.64 5.15 1.64 7.191 1.64 7.19 0.098 0.098
CARBON MONOXIDE(00) 1.381 4.83 1.38 6.04 1.38 6.04 0.0821 0.082
VOLATILE ORGANIC COMPOUNDS VOC 0.091 0.32 0.09 0.40' 0.09 0.40• 0.0051 0.005
TOXIC/HAZARDOUS AIR POLLUTANT EMISSIONS INFORMATION
_ ACTUAL EMISSIONS POTENTIAL EMSSIONS EMISSION FACTOR
CAS 'racr:r.*ZOLSrLIMITS) (REFOREMNTROLSI,wrs' WTLR(;'jNT,40,.s,LPAITS) Ib/rnmBtu
TOXIC/HAZARDOUS AIR POLLUTANT I NUMBER Ins/yr Ib/hr Ibs/r Ib/hr Ibs/yr uncontrolled controlled
Acetaldehyde H} 175070 -46E-G! 1.75E-03 2.49E-07 2.19E-03 2.49E-07 2.19E-03 1.49E-08 1.49E-08
Acrolein H 107028 2.05E-07 2.07E-03 2.95E-07 2.59E-03 2.95E-07 2.59E-03 1.76E-08 1.76E-081
Ammonia T) _ 7664417 5.25E-02 I 3.68E+02 5.25E-02 4.60E+02 5.25E-02 4.60E+02 3.14E-03 3.14E-03
Arsenic unlisted cc--: - iss (TH) ASC-other 0.00E+00 O.00E-OG 0.00E+03 0.00E+00 0.00E+00 O.00E+00 0.00E+00 0.00E+00:
Benzene TH 71432 3.45E-05 2.42E-01 3.45E-05 3.02E-01 3.45E-05 3.02E-01 2.06E-06 2.06E-06
Benzo a p rane i _ c-032E fr;=-38 1.38E-0�7 1.S7c-33 1.73E-04 1.97E-08 1.73E-04 1.18E-09 1.18E-09
Beryllium metal unreameo TH /440417 c-00 0.00E+00 O.00E+UO 0.00E+00 0.00E+00 0.00E+00 o.o0E+00 O.00E+Oo
Cadmium metal elemental unreacted' (TH) 7440439 u.uuc-0G 0.00E+00 0.00E+00 0.00E+00 0.00E+00 0.00E+00 0.00E+00 0.00E+00
Chromic acid(VI)(TH) 7738945 C.uDE-CO 0.00E+00 O.COE+00 0.00E+00 O.00E+00 O,DOE+00 0.00E+00 O.00E+001
Cobalt unlisted cm-n ownos H COC-other -06 9.86E-03 1..38E-06 1.21 E-02 1.38E-06 1.21 E-02 8.24E-08, 8.24E-081,
Formaldehyde Jr,; 5C000 03 8.63E+00 .23E-03 1.08E+01 1.23E-03 1.08E+01 7.35E-05 735E-05._
Hexane,n- ,H 110543 0_ 1 2.07E+02 2.95E-02 2.59E+02 2.95E-02 2.59E+02 1.76E.03 1.76E-03.
Lead unlisted comoa u 9 H) 1PBC-other 75E-02 d.2'! -GE 7.19E-02 ' 8.21E-06 7.19E-02,. 4.90E-07 4.9oE-mq
Manganese unlisted compounds TH MNC-other C..CE+00 0.00E+00 C.LGi:T•J0 C.00E+00 0.00E+00 0.00E+00, O.00E+00 0.00E+00i
Mercury vapor I" 7439976 +02 0.00E-+03 G.:`i:+ 0.00E+00 0.00E+00 0.00E+00 0.00E+oo 0.00E+0o'
Napthalene _ 0?203 Oc 7.u2E-02 L .-uu 8.77E-02 1.00E-05 8.77E-02 5.98E-07 5.98E-07
Nickel metal 17r ,7440020 0 J^E+CC 0.00E+G'J 0.00=:+GO 0.00E+00 0.00E+00 0.00E+00, O.00E+oO O.o0E+00(
Selenium com ou-, ISEC 3.4E-07 2.76E-03 3.94E-07 3.45E-03 3.94E-07 I 3.45E-03 I 2.35E-08 2.35E-08
Toluene H) 108883 79E-06 3.91E-01. 5.58E-05 4.89E-01 5.58E-05 I 4.89E-01 3.33E-06 3.33E-06.
i
Total HAPs ,.-9E-02 2.16E+02 3.09E-02 ; 2.71E+02 3.09E-02 2.71E+02 1.84E-03 1.84E-03
Highest HAP Hexane ..95E-02 2.07E+02 _1.95E-02 I 2.59E+02 2.95E-02 2.59E+02 1.76E-03 J 1.76E-os
T^.Y.;::!n?CLLL'TANT EII1/SS.CNS}Nf i fA T10;J'FOR P.ERh"T77NG PURPOSES
EXPECTED ACTUAL EMISSIONs:.FTER CONTROLS i LIMITATIONS EMISSION FACTOR i
IblmmBtu
TOXIC AIR POL'--TAN;T CAS Num. Ib/hr ! lb/day Ib/yr uncontrolled controlled '
Acetaldehyde(T 175070 2.49E-07 5.99E-06 1.75E-03 1.49E-08 1.49E-08t
Acrolein TH i 107028 2.95E-07 719E-06 2.07E-03 1..76E-08 1.76E-Da
Ammonia M 17 664417, 5.25E-02 1.28E+00 1 3.68E+02 1
;;
Arsenic unlisted ce:n Funds (TH ASC-othe 3.14E-03 3.14E-03r C.CDE+OC __U.00E+OC_ _ _, 0.00E+00 0.00E+00 0.00E+00
Benzene(TH) 171432 5.45E-35 _ _i.27E-04 2.-2E-01 2.06E-06 2.06E-06
Benzo a rene;--; _ 50328 ;.97E-08 73E-07 1.38E-04 1.18E-09� 1.18E-09-
Beryllium metal .7440417 _ 0.00E+00 u.%jUE+0U O.OJE+Ou 0.00E+001 O.00F+uu
Cadmium metal atecla:;:a:L:nreacted TH ?44G439 U.i;0E+00 r O.J0E+00 0.00E+00 O.00E+00 0.00E+00
Soluble chromate _;;cs,as chromium(Vi)equivatent ,SoICR6 u..;0E+00 J.00E-0u 0.00E+00 0.00E+00 O.00E+00
Formaldehyee,--__ _ E0000 ::3E-03 _1.95E-02 8.63E+00 7.35E-05 7.36r_-05
Hexane,n.-;- :110543 5E-02 09E-01 2.07E+02 1.78E-03 1.76E-03'
Manganese :::a. _..:: -.pounds TH t.NZ-other +JO C,.DOE+00 O.00E+00 O.DOE+DO 0.00E+00
Mercuryvapc 39576 __ ;.JOE+00 0.00E+00 0.00E+00 O.CCE+I,�
Nickel meta: 440C20 _ TJ, -30E+00 OA0E+00 0.00E+00 0--'-
Toluene(Tr. 34E-03 3.51E 01 3.33E-06 3.�1 t
GREEN:; 'i� CO'VSJST=i•!T lrfTH EPA MANDATORY REPORTING RULE GHG-POTENTIAL TO EMIT
(B IRi7l P.c'.T -'D NOT BASED GN EPA MRR METHOD
GREENHOUSE,:,- ---_UTANT AC'IUNi_EMISSIONS P TEAIAL EMISSIONS
EPA MIRR CALCUI+TION METHOD:'i IER 1
met:.c tons/yr metric tons�,,.CO2e short tons/yr short tons/yr short tons/yr,CO2e
CARBON DiOX.0 ;3::68.36 d 268.39 6,909.71 8,569.93 8569.93
METHANE(CH,,, :.>:0E+00 1.30E-01 1.62E-01 4.04E+00
NITROUS OXIDE �- +_��_ -_,,;- _- _;,• ,__�_ 1,30E-02 1.62E-02 4.82E+00
;_274.87 I TCTALCO2e 8,578.78
(rrv,I (short tons
NOTE: CO2e 32 equivalent -- -'
NOTE: The DAQ.air Emissions Reporting Online(;ERO)system requires s.1c,t tors be reporcea. he& I!!'.;:•euu:res metric tons be reported.
NOTE: Do not use greenhouse gas emission estimates frorn this spreadsheet;or PSD(Prevention of 5G :.i Deterioration)purposes.

APPENDIX C
REQUEST FOR ZONING CONSISTENCY DETERMINATION

5504 Shadowbrook Drive
Raleigh, NC 27612
919-602-4662
March 22 2022
Ms. Bonnie Huntley
Clerk to The Board of Commissioners
101 S. Green Street
Wadesboro, North Carolina 28170
Subject: Request for Consistency Determination with Local Zoning Regulations
Edwards Wood Products, Inc., Peachland, NC Plant
Air Permit Application
Dear Ms. Huntley:
On behalf of Edwards Wood Products, Inc. (EWPI), I am writing to inform you that EWPI intends
to modify their plant located at 160 Pulpwood Yard Road, Anson County, Peachland, NC. This
modification involves adding a new natural gas-fired boiler for producing steam to the plants
lumber drying kilns. Modification also includes the removal of two existing lumber drying kilns,
which are planned for relocation to EWPI's Laurinburg facility.
To make these changes, EWPI is required by the North Carolina Department of Environmental
Quality (NCDEQ) to apply for a modification to their current air quality permit No. 10146R03.
The air permit covers boiler, lumber drying kiln, and insignificant sawing operations.
Before an air permit application can be considered complete by NCDEQ, a zoning consistency
determination for the affected facility is required from the local zoning office. Therefore, in
accordance with § 143-215.108(f of the North Carolina General Statutes (enclosed), we hereby
request that you issue a determination as to whether your municipality has in effect a zoning or
subdivision ordinance that is applicable to the proposed facility. Additionally, please issue a
determination as to whether the proposed use would be consistent with applicable zoning or
subdivision ordinances. For your convenience, I have included a form with which you may remit
your determination. A copy of the air permit application is included for your review. As a means
of demonstrating proof of transmittal, please sign, title, stamp, and date the enclosed form and
mail to both the facility mailing address and the checked air quality office at your earliest
convenience.
If there are problems with providing the zoning consistency determination, please contact me as
soon as possible. If there are no problems with this request, please provide me with a copy of
the consistency determination you send to NCDEQ for our files.
If you have any questions or require additional information concerning the above matter, please
contact Mr. Daryl Grassick ([e-mail]) at 919.602.4662 or Mr. Chris Harrington,
Director Environmental Health and Safety ([e-mail]), of Edwards Wood
Products, Inc. (EWPI) at 704.624.3611. Thank you for your assistance.
EWP-Peachland Air Permit Modification Page 2 of 2 March 22, 2022
Project EWP-P01

5504 Shadowbrook Drive
Raleigh,NC 27612
919-602-4662
Sincerely,
L
Daryl H. Grassick
Senior Air Consultant
919.602.4662
[e-mail]
cc, Jeffrey D. Cole, NC Division of Air Quality
Chris Harrington, Director Environmental Health and Safety, EWPI
Appendices
N.C.G.S. § 143-215.108(f)
Zoning Consistency Determination Form
Procedural memo from Laura Butler dated July 31, 2000
Air Permit Application
EWP-Peachland Air Permit Modification Page 2 of 2 March 22, 2022
Project EWP-P01

ZoningCo I'Consistency Determination
Facility Name Edwards Wood Products, Inc.
Facility Street Address 160 Pul wood lZoad
Facility City Peachland,NC
Description of Process Wood products manufacturin
SIC/NAICS Code 2421
Facility Contact Chris Harrin ton/ Director Environmental Health and Safet
Phone Number 704-624-3611
Mailing Address P. O. Box 219
Mailing City, State Zip Marshville,NC 28103
Based on the information� o,iven above:
I have received a copy of the air permit application(draft or final) AND...
f There are no applicable zoning ordinances for 66s facility at this time
The proposed operation IS consistent with applicable zoning ordinances
F The-proposed operation IS NOT co-nsiste_nt with applicable zoning ordinances
(please include a copy of the rules in the package sent to the air quality office)
r A he determination is pending further information and can not be made at this time
of-her:
Agency ANSON COI. 9Ty PLANNIWG E -ZoN 14G
Name of Designated Official
Title of Designated Official L A NN►NG
Signatureo```'`'1�- V1\
Date
3. 2� -22
Please forward to the facility mailing address listed above and the air quality office
at the appropriate address as checked on the back of this form.
Courtesy of the Small Business Environmental Assistance Program
sb.ncdenr. ov 877-623-6748

All PSD and Title V Applications
F Attn: Supervisor
DAQ—Permitting Section
1641 Mail Service Center
Raleigh,NC 27699-1641
Local Programs
r Attn: Air Quality Director
Asheville-Buncombe Air Quality Agency
P.O. Box 2749
Asheville,NC 28802
[phone]
F_ Attn: Air Quality Director F_ Attn: Air Quality Director
Mecklenburg County Air Quality Forsyth County Office of Environmental
2145 Suttle Avenue Assistance and Protection
Charlotte,NC 28208 201 N. Chestnut Street
[phone] Winston-Salem,NC 27101
[phone]
Division of Air Quality Regional Offices
f Attn: Regional Supervisor F_ Attn: Regional Supervisor
Asheville Regional Office Washington Regional Office
2090 U.S. Highway 70 943 Washington Square Mall
Swannanoa, N,C12 28778 Washington,NC 27889
[phone] [phone]
x Attn: Regional Supervisor F_ Attn: Regional Supervisor
Fayetteville Regional Office Wilmington Regional Office
225 Green Street, Suite 714 127 Cardinal Drive Extension
Fayetteville,NC 28301 Wilmington,NC 28405
[phone] [phone]
F Attn': Regional Supervisor r- Attn: Regional Supervisor
Mooresville Regional Office Winston-Salem Regional Office
610 East Center Avenue, Suite 301 450 West Hanes Mill Road, Suite 300
Mooresville,NC 28115 Winston-Salem,NC 27105
[phone] [phone]
F Attn: Regional Supervisor
Raleigh Regional Office
1628 Mail Service Center
Raleigh,NC 27699-1628
[phone]
Courtesy of the Small Business Environmental Assistance Program
sb.ncdenr.gov 877-623-6748

i
i
NORTH CAROLINA GENERAL STATUTE 143-215.108(f)
(f) An applicant for a permit under this section for a new facility or for the expansion of a facility
permitted under this section shall request each local government having jurisdiction over any part
of the land on which the facility and its appurtenances are to be located to issue a determination
as to whether the local government has in effect a zoning or subdivision ordinance applicable to
the facility and whether the proposed facility or expansion would be consistent with the
ordinance. The request to the local government shall be accompanied by a copy of the draft
permit application and shall be delivered to the clerk of the local government personally or by
certified mail. The determination shall be verified or supported by affidavit signed by the official
designated by the local government to make the determination and, if the local government
states that the facility is inconsistent with a zoning or subdivision ordinance, shall include a copy
of the ordinance and the specific reasons for the determination of inconsistency. A copy of any
such determination shall be provided to the applicant when it is submitted to the Commission.
The Commission shall not act upon an application for a permit under this section until it has
received a determination from each local government requested to make a determination by the
applicant. If a local government determines that the new facility or the expansion of an existing
facility is inconsistent with a zoning or subdivision ordinance, and unless the local government
makes a subsequent determination of consistency with all ordinances cited in the determination
or the proposed facility is determined by a court of competent jurisdiction to be consistent with
the cited ordinances, the Commission shall attach as a condition of the permit a requirement that
the applicant, prior to construction or operation of the facility under the permit, comply with all
lawfully adopted local ordinances, including those cited in the determination, that apply to the
facility at the time of construction or operation of the facility. If a local government fails to submit
a determination to the Commission as provided by this subsection within 15 days after receipt of
the request, the Commission may proceed to consider the permit application without regard to
local zoning and subdivision ordinances. This subsection shall not be construed to affect the
validity of any lawfully adopted franchise, local zoning, subdivision, or land-use planning
ordinance or to affect the responsibility of any person to comply with any lawfully adopted
franchise, local zoning, subdivision, or land-use planning ordinance. This subsection shall not be
construed to limit any opportunity a local government may have to comment on a permit
application under any other law or rule. This subsection shall not apply to any facility with respect
to which local ordinances are subject to review under either G.S. 104E-6.2 or G.S. 130A-293.

July 31, 2000
To: Permit Engineers
Regional Supervisors
Regional Permit Coordinators
Chiefs
Local Programs
DAQ Webpage
From: Laura S. Butler, P.E.
Chief
Through: B. Keith Overcash
Deputy Director
Subject: Zoning Consistency Determination
Background
North Carolina General Statute § 143-215.108(f) requires that applications for air quality permits
for new or expanded facilities include a request for a zoning consistency determination. Under
this requirement the applicant must identify each local government having jurisdiction over any
part of the land on which the facility and its appurtenances are to be located and must request a
determination (zoning consistency determination) as to whether the local government has in
effect a zoning or subdivision ordinance applicable to the facility and whether the proposed
facility would be consistent with the ordinance. The request to the local government, to be
delivered to the clerk of the local government personally or by certified mail, must include a copy
of the draft permit application. The statute prohibits the Division from acting upon the application
until it has received a zoning consistency determination from each local government agency
requested to make a determination, or the applicant submits a certified (or clerk stamped and
signed) request and 15 days have passed since the application was received by the clerk.
Discussion
In the past the General Statute requirement has been implemented primarily by reviewing the
determination provided by the local government. In many cases the Division considered the
statutory provision to be satisfied by a statement from the local government that there were no
zoning ordinances for the property on which the new or expanded facility was to be located. In
such cases it was felt that the intent of the Statute was satisfied; that is, the permittee did not rely
simply on the air quality permit for permission to construct, but that the company had contacted
the local government with respect to any potential zoning ordinances in effect prior to
construction. It is interesting to note that even if the local government has zoning ordinances in
effect that would prohibit the source from constructing or operating, the Division may still issue
the air quality permit. In those instances the statute simply requires that a condition be placed in
the permit stating that prior to construction or operation of the facility the permittee will comply
with all lawfully adopted ordinances.

Zoning Consistency Determination July 31,2000 Page 1
New Procedure
On March 9, 2000 the Environmental Management Commission (EMC) decided that failure to
make a written request to the local government and include a copy of the application, despite a
written response from the local government stating that there were no zoning ordinances in
effect, failed to satisfy requirements of N.C.G.S. § 143-215.108(f) and as a result a permit should
not have been issued. Consistent with this approach, the Division is now implementing three
procedural changes to ensure compliance with the statutory requirement. First, as part of an
application the applicant must identify, and certify in writing, all local governments having
jurisdiction over any part of the land on which the facility and its appurtenances are to be located.
Second, the statute prohibits the Division from acting upon an application until the zoning
consistency determination requirements are satisfied. Consistent with the plain language of the
statute, when an application is submitted without satisfying this requirement, the application will
be deemed incomplete. The application will be entered into the ATS and an incompleteness
letter will be sent to the applicant allowing 30 days to cure the defect. Third, consistent with the
statutory language, we will remove the consistency determination condition from the general
conditions of the permit and place it in the permit as a specific condition only if the local
government states that the facility is inconsistent with a zoning or subdivision ordinance.
Zoning Consistency Requirements
The following are the general items to review to determine if the applicant has satisfied the
statutory requirements for zoning consistency and to determine if the Division can begin to
process the permit application, information that must be submitted with the application, and what
conditions should go into the permit:
1. North Carolina General Statute 143-215.180(f) requires that applications for air quality permits for
new or expanded facilities include a request for a zoning consistency determination.
2. To prevent unnecessary delays in the review process, all applications received by DAQ, except for
renewals without modifications, name/ownership changes, administrative changes, initial Title V
applications without modifications, etc. will be required to include a zoning consistency
determination.
3. The applicant shall identify and certify in writing, all local governments having jurisdiction over any
part of the land on which the facility and its appurtenances are to be located.
4. The applicant is required to send a zoning consistency determination request to each and every
local government entity identified.
5. The zoning consistency request must be delivered to the clerk of the local government personally
or by certified mail. Personal delivery should be evidenced by a transmittal letter from the facility
stamped received by the local government, dated, and signed by the official designated by the
local government to make such a determination.
6. The zoning consistency determination request from the applicant to the local government shall
include a copy of the permit application.
7. The required zoning consistency determination in response to the request by the applicant must
be signed by the official designated by the local government to make such a determination. If the
local Bove:;,-,lent states that the facility is inconsistent with a zoning or subdivision ordinance, the
General SrG -yes requires -:hat a copy of such a determination shall be submitted to the applicant

and the DAQ with a copy of the ordinance and the specific reasons for the determination of
inconsistency.
8. Unless the local government makes a subsequent determination of consistency with all ordinances
cited in the determination or the proposed facility is determined by a court of competent jurisdiction
to be consistent with the cited ordinances, the DAQ shall attach as a condition of the permit a
requirement that the applicant, prior to construction or operation of the facility under the permit,
comply with all lawfully adopted local ordinances, including those cited in the determination, that
apply to the facility at the time of construction or operation of the facility.
Zoning Consistency Determination July 31,2000 Page 2
9. The DAQ shall not act upon an application for a permit until it has received a determination from
each local government having jurisdiction to make a determination. If the local government fails to
make such a determination within 15 days after receipt of the zoning consistency request, the
DAQ may proceed without regard to local zoning. However, if we have not heard from the local
government after the 15 day period, the review engineer shall make one last attempt to
contact tM,1- local government authority by phone to make sure that the determination
sir.,iply has riot be misplaced or delayed.
Application Content (the application will he considered incomplete without the following
information and subject to being returned if not completed within 30 days after receipt of
an incompleteness letter)
1. A statement signed by the applicant listing any and all local governments having jurisdiction over
any part of the land on which the facility and its appurtenances are to be located (e.g., I hereby
certify that xyz local zoning board is the zoning authority for which my facility must obtain a zoning
consistency determination).
2. A copy of the request from the applicant for zoning consistency determination. The request must
be stamped received by the local government, dated, signed, and title specified by the official
designated by the local government. Furthermore, a statement is required by the local government
stating they also received a copy of the air permit application.
3. A zoning consistency determination from the local government indicating that all zoning or
subdivision ordinances are met by the facility. This determination must also include the information
required in number 2 above. The determination shall be verified or supported by affidavit signed
and title specified by the official designated by the local government to make the determination.
4. If the local government states that the facility is inconsistent with a zoning or subdivision
ordinance, the determination shall include a copy of the ordinance and the specific reasons for the
determination of inconsistency. This determination must also include the information required in
number 2 above. The determination shall be verified or supported by affidavit signed and title
specified by the official designed by the local government to make the determination.
5. A statement that there is no local zoning ordinance applicable to the proposed facility. This
determination must also include the information required in number 2 above.
Permit Content
1. Future permits will not contain a general condition relating to a zoning consistency determination.
2. If the local government provides a consistency determination stating that the facility is inconsistent
with a zoning or subdivision ordinance, the permit shall contain the following specific condition (not
general) language:
Prior to construction and operation of the facility under this permit, the Permittee shall
comply with all lawfully adopted local ordinances, including those cited in the
determination, that apply to the facility at the time of construction or operation of the
facility. The local zoning authority shall have the responsibility of enforcing all lawfully
adopted local zoning or subdivision ordinances.

It is the responsibility of the local zoning authority, and not the DAQ, to determine compliance
with the local zoning or subdivision ordinances. The DAQ does not plan to use this condition to
force the local government to enforce their own ordinances. This is still their responsibility, and
hopefully we will not be faced with a situation where we will need to take enforcement action for
a violation of this condition.
If you have any questions regarding this procedure, please call Laura S. Butler, P.E., Chief,
Permits Section in Raleigh.
Zoning Consistency Determination July 31,2000 Page 3

APPENDIX D
EQUIPMENT SPECIFICATIONS

REGISTER Q L
rODks
PACKAGED 1301LER
SER IA L NO.
PRESSURE PSI
DATE
BTU/MR �
GAS [-.=Cpt, O f L
."14�KT,,RICAL REQUIREMENTS
L u Ir L y
a
L mp.
Amp:

EWPI - Peachland
CB Package Boiler(NG Only)
Model CB 700-400
Serial No. L-90141
Date 10/16/1991
Input 16,739,000 BTU/Hour
GAS NAT
Max Pressure 150 PSI

I
To: NCDENR DIVISION OF AIR QI NCAIR Check Number: 004692
Invoice Number Date Description Amount Discount Paid Amount
032222 Mar 22, 2022 $50.00 $0.00 $50.00
m
i
W I
A
O
V
TOTALS: $50.00 $0.00 $50.00
L
First National Bank
004692
v
60-0251/412
Edw��odIns
PO Box 219
Marshville,NC 28103 DATE AMOUNT
03/22/2022 $50.00
Fifty Dollars and 00 Cents
Pay to the Order of:
NCDENR DIVISION OF AIR QUALITY
BUDGET OFFICE
1641 MAIL SERVICE CENTER
RALEIGH',NC 27699-1641 _
r
F
*See Reverse Side For Easy Opening instructions*
RECEIVED
CD
%%aw'ards MAR 2 8 2022
�.y�L�dt�D�ttf��Jt�YPrtldh�tnc. �- N
PO Box 219
Marshville, NC 28103 DEQ-FAYEITEVILLLEE RE&ONAL OFFICE
1!5
OgCW 5?
NCDENR DIVISION OF AIR QUALITY
BUDGET OFFICE
1641 MAIL SERVICE CENTER
RALEIGH, NC 27699-1641 � II