AQ_F_0400053_20090720_ST_RvwLtr

t ®�
NCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue, Governor Division of Air Quality Dee Freeman., Secretary
B. Keith Overcash, P.E., Director
20 July 2009
Mr. Drew Boggs
President
Boggs Paving, Inc. - Anson Plant
Post Office Box 1609
Monroe,NC 28110
SUBJUCT: Central Office Review of Source Test Results
Boggs Paving, Inc.—Anson Plant, Air Permit No. 09882R00
Lilesville,Anson County,North Carolina
Facility ID No, 04-00053
Dear Mr.Boggs:
The Division has reviewed your source test report that was received by our Central Office on 3 November
2008. There was one report submitted for the Total Particulate and Visible Emissions Testing on One Hot Drum
Mix Asphalt Plant. The test was performed on 23 September 2008, On 2 July 2009, this Division determined that
the subject test performed at your facility was an acceptable source test. The review indicates that compliance with
Air Permit No. 09882R00 is indicated for this source. A copy of the detcrmination memorandum issued by Mr.
David Hughes, of the N.C.Division of Air Quality, Stationary Source Compliance Branch,is attached.
Should you have any questions regarding this matter,please contact Neil Joyner,Environmental Specialist at
[phone], in the Fayetteville Regional Office.
ii]ccrely,
/''Steven F. Vozzo /I +
Regional Air Quality Supervisor
Fayetteville Regional Office
Attaclanenls-DAQ RCO review(1)dated 2 July 2009 [2008-222ST]
SFV\cttj
cc: 1-Shannon Vogel,RCO-Stationary Source Compliance(w/o attachment) -
F DAQ Central Files(w/attachment)
1�F'RO Files(w/attachment)
Fayetteville Regional Office—Division of Air Quality TTaa��One
225 Green Street,Suite 714,Fayetteville,North Carolina 28301-5043 NOrthCarohna
Phone: [phone] Pax: 910-485-7467 1 Internet: htlp://www.ncair.org pq�q p�
An Equal OppodunitylAffirmativeAction Employer—50%Recycled/10%o Post Consumer Paper atlg p.�. /�

IV
DIVISION OF AIR QUALITY
July 2, 2009
MEMORANDUM
Fo: Steven Vozzo, Fayetteville Regional Office
From: David 11.Ifighes, Stationary Source Compliance Branch (SSCB) v�
Subject: Boggs Paving, Inc. —Anson Plant
hilesville, Anson County,North Carolina
Total Particulate and Visible Emissions Testing on One Iiot Drum Mix Asphalt Plant
Air Permit No. 09882R00,Facility ID 06/04/00053
Conducted September 23, 2008
The report of the subject testing has been reviewed. The testing was performed by Trigon Engineering
Consultants, Inc. on Septembe 23, 2008 in accordance with the requirements of Air Permit No. 098821W0
Stipulation A.3 and A.7.
The emission source is one portable hot mix aspbalt plant(385 tons per hour maximum capacity) consisting of
one horizontal cyclone (1D No. CD2)in series with a baghouse (ID No. CDI) installed on a natural gas/No. 2
fuel oil/No. 2 recycled fuel oil/No. 4 fuel oil/No. 4 recycled fuel oil-fired aggregate drum dryer/mixer(ID No.
ESI). The asphalt plant is subjeel to 40 CFR Subpart I Standards ofPerformanee for[lot Mix Asphalt Facilities
and 15ANCAC2D .05061'artieulatesfom11olMixAsphaltPlantr, Subpart] In nits part icu late mat lei,(PM)to
90 milligrams per dry standard cubic meter (mg/dscm) and limits visible emissions (VE)to 20 % opacity. 21)
0506 limits total PM based on production rate. The average production rate during the testing period was 327
tons per]tour,for which the allowable total PM emissions is 60 pounds per hour(lb/la). The results of USEPA
Method 5/202 and Method 9 source testing are listed in the table below:
Bo—s Pa in ,Inc As shalt Plant 11) No LSl Method 5/202 and Method 9 Emissions
Pollutant Test Result§ Emission Limit Emission Standard ,. Compliance
Filterable PM 8.2 mg/dsenn 90 ntg/dsem NSPSSSSubpart I Yes
Visible F,ntissions 0.8 %* 20% Yes
Filterable PM _ _ 0.85 Ib/li
Condensible PM 1.43 lb/hr 60 15A NCAC 2D.0506 Yes
-- — — --
Total PM 2.29 1b/hr
* Highest Six-mnmtte average opacity
The subject test results are considered aii acceptable demonstration of compliance witb the applicable filterable
particulate and visible emission limits in NSPS 60 Subpart I. The test results are also considered an acceptable
compliance demonstration for the total PM emission limit in 15A NCAC .0506. If I can provide further
assistance on this matter, please contact me at David B.Htghes a ncdenr. rov or(919)715-2966.
ec: SSCB Pile through Michael Pjetraj Central Files -- Anson County R E C E W D
I13EAM Documents—0400053 (09/23/08)
Tracking No. 2008-222ST J'14, 09 2009-
DEN y
i°-AYEl E'7VIj_L.E� Fit`:t31ONALOrFICE