AQ_F_0400033_20120612_CMPL_InspRpt

NORTH CAROLINA DIVISION OF Fayetteville Regional Office
AIR QUALITY Martin Marietta Aggr Pee Dee Quarry
NC Facility ID 0400033
Inspection Report County/FIPS: Anson/007
Date: 06/13/2012
Facility Data Compliance Data
Martin Marietta Aggr Pee Dee Quarry Inspection Date 06/12/2012
2710 Wycliff Road Inspector's Name Cindy Grimes
Pee Dee,NC 28091 Operating Status Operating
Lat: 34d 56.2500m Long: 79d 53.0000m Compliance Code Compliance- inspection
SIC: 1423/Crushed And Broken Granite Action Code FCE
NAICS: 212313/Crushed and Broken Granite Mining and Quarrying On-Site Inspection Result Compliance
Contact Data Permit Data
Facility Contact Authorized Contact Technical Contact Permit 06334/R05
Richard Broughton Paxton Badham Richard Broughton Issued 10/19/2007
Expires 9/30/2012
Environmental Services VP Land/Environmental Enviromnental Services Classification Small
Manager Services Manager Permit Status Active
[phone] [phone] [phone]
Inspector's Signature: Comments:
Date of Signature:
MACT/GACT Applicability: None(Facility has not broken ground on site yet,thus is not operating; with
the permit information DAQ FRO has been given thus far,facility should not be subject to any MACTs).
1) Location
Martin Marietta Aggregate-Pee Dee Quarry is located at 2710 Wycliff Road in Pee Dee(just west of the
Pee Dee River),NC,Anson County.
Directions
From FRO,take Hwy 401 South to Wagram.Turn right at Old Wire Road(Hwyl44)and go— 11 %2 miles to
Laurel Hill.Turn right at Hwy 74,and go west—24 miles until Hwy 145 (— 1 mile after crossing the Pee Dee
River).Turn left onto Hwy 145 South and drive about'/4 mile. Planned site is on the right hand side.
Safety Considerations: Standard DAQ safety equipment required.When facility starts operating, be alert to
large equipment on site.
2) Facility and Process Description
Martin Marietta Aggregate Pee Dee Quarry is a rock quarry that is permitted to produce gravel and
aggregate used in construction. This facility is permitted under Air Permit No. 63341105,effective from
19 October 2007 until 30 September 2012. Cindy Grimes conducted the last compliance inspection on
20 April 2011.Note: This facility has not broken ground or been constructed yet.
This facility is(will be)a quarry which extracts mainly granite from the earth.The granite and crushed stone
products are loosened by drilling and blasting,and then are loaded by power shovel or front-end loader into
large haul trucks that transport the material to the processing operations. Primary operations include a jaw,
which is used for initial crusher reduction, and a series of conveyors.This crusher product is next fed through
a grizzly feeder for undersize material,and then is discharged onto a conveyor,where it goes through more
screening processes, until it is conveyed to a surge pile for temporary storage or sold as coarse aggregate.
N+

a) Throughputs for 2011
Employees: 0(same in 2010)
Hours: 0 (same in 2010)
Production: 0 (same in 2010)
b) Permitted Sources
Emission Emission Source Control Control System
Source ID I Description System ID Description
Non-Metallic Mineral Processing Plant,800 tons per hour rating,utilizing water suppression with no other
control devices,including:
Crushers(NSPS) lCrushing Operations
Conveyors(NSPS) lConveying Operations WS Wet suppression water spray system
Screens(NSPS) Iscreening Operations
3) Inspection Summary
This facility has not begun operations at its proposed site. I drove by the site on 12 June 2012 and did not
observe any equipment or evidence of ground-breaking.
Note: On 29 May 2012,FRO DAQ received the permit application and emissions inventory certification
form from Paxton Badham,the Authorized Contact and Vice President of Land/Environmental Services
for this facility. Even though this facility has never started operations since it,was originally issued a
permit in 1988, corporate offices of Martin Marietta wish to continue the renewal of its permit.
4) Permit Stipulations
Per permit.
5) Reporting Requirements
Within 15 days after start-up of the rock crushing operation,the Permittee shall notify, in writing, the
Regional Supervisor of the start-up.
6) 112R Status
Unknown at this time. Facility has not been constructed to date.
7) DAQ Compliance History
This facility has not started operations since its initial permit; it has had no prior DAQ violations.
8) Comments and Compliance Statement
This facility has not been established on site as of the date of this inspection.FRO has been informed that the
company still plans on developing the site sometime in the future.
Martin Marietta Aggregate Pee Dee Quarry appeared to be in compliance on 12 June 2012.
/clg