HomeMy WebLinkAboutDEQp00022048S44 REV 12-7t <
AVP �
ESTA9 �i 51:i G:ft O:
C,enVrv� `4�
E. I. DU PONT DE NEMOURS & COMPANY
INCORPORATED
P. O. DRAWER Z
FAYETTEVILLE, N. C. 28302
POLYMER PRODUCTS DEPARTMENT
NO
P RMIgS ti
7
November 29, 1988
Permits & Engineering Unit
N.C. Dept. of Natural Resources
and Community Development
Division of Environmental Management
P.O. Box 27687
Raleigh, N.C. 27611-7687
Dear Sirs:
In accordance with the instruction in the Authorization
to Construct issued by R. Paul Wilms on 3/28/88 (attached), I
have enclosed the engineering certification attesting that the
construction of the wastewater treatment modification at
Fayetteville Works of E.I. du Pont de Nemours & Co., Inc. in
Bladen County, Permit No. NC003573, was completed in accordance
with approved plans and specifications by the Division.
At the present time, the new aeration tank is operating
under test procedures with the former aeration basin as an
operational standby (i.e. available for aeration service in case
of problems with the new tank system.) Barring problems, this
test status will continue until the end of January, when the
basin will be converted to a sludge digester.
Sincerely,
Thomas W. Olcott
Environmental Coordinator
TWO: mm
(8.13)
CC: (Cover Letter)
Bladen County Health Department
Fayetteville Regional Supervisor, M.J. Nola
Ms. Babette McKemie, Permit Branch
BETTER THINGS FOR BETTER LIVING
4
FLUOR DANIEL
IN T E R O F F I C E C OR RES P ON D E N C E
TO: Riley Hammond
FROM: C. R. Green
SUBJECT: DuPont Fayetteville Works
Waste Treatment Facilities
DATE: November 1, 1988
This memo is in response to DuPont's request for an Engineer's Certification
of the Waste Treatment Addition on Project 5262. The applicable documents
which have been submitted to the State of North Carolina and hence are the
basis of the construction certification are as follows:
DuPont
Drawing
W388407
DuPont
Drawing
W945772
DuPont
Drawing
W992699
DuPont
Drawing
W993519
Paragraph "Expanded System" of Attachment A - Description and Design
Basis of Expanded Wastewater Treatment Facilities, DuPont Fayetteville
Works, Bladen County, North Carolina.
I inspected the permitted facilities on October 26, 1988. The facilities were
constructed in accordance with the approved plans and specifications as
defined above.
This construction certification does not cover:
a)
Design or suitabi I ity thereof.
'ii;T`�4`r~"'"-.
b)
Operation of system.
,
c)
Control logic of Network 90 system.
,yo
d)
Equipment, piping, ingtrument or electrical
component lec
,A
e)
Compliance with codes or standards.
^r;�",:sl
CRG:bmc
M,
QUALITY IS THE KEY FO�PRIN PRINTED USA.
STATt
04
41 i_
State of North Carolina
Department of Natural Resources and Community Development
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
R. Paul Wilms
~James G. Martin, Governor
March 28, 1988
S. Thomas Rhodes, Secretary - Director
Mr. Thomas Olcott
E.I. DuPont de Nemours & Company - Fayetteville
P.O. Drawer Z
Fayetteville, NC 28302
SUBJECT: Permit No. NC0003573
E.I. DuPont de Nemours & Company
Fayetteville Plant
Wastewater Treatment Pianr Ilodii`icaLio .s
Bladen County
Dear Mr. Olcott:
A letter of request for an Authorization to Construct was received March
11, 19883 by the Division and final plans and specifications for the subject
project have been reviewed and found to be satisfactory. Authorization is
hereby granted for the construction of modifications to an existing 1.1 MGD .
wastewater treatment facility consisting of a 1.5 million gallon aeration tank
with two 4,000 CFM blowers and the conversion of the existing aeration basin to
an aerobic digester.
This Authorization to Construct is issued in accordance with Part III
paragraph B of the NPDES Permit No. NC0003573 issued March 13, 1987, and
shall be subject to revocation unless the wastewater treatment facilities are
constructed in accordance with the conditions and limitations specified in
Permit No. NC0003573.
The Permittee must employ a certified wastewater operator in accordance
with Part III paragraph C of the referenced permit.
The sludge generated from these treatment facilities } t be disl5 'd of
in accordance with G.S. 143-215.1 and in a manner approv e NortiY,
onmental Management.
Carolina Division of Envirement. 1
g ,Q� ' •� 4
, az ej A4
In event the facilities fail to perform satisfacto i i II
NPDES permit effluent limits, the permittee shall take s im e
corrective action as may be required by this Division, inc' "c#lin e .Z•
construction of additional wastewater -treatment and disposal'facilitize:``
Pollution Prevention Pays
P_O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone 919.733-7015
An Equal opportunity Affirmative Action Employer
Upon completion of construction and prior to operation of this permitted
facility, a certification must be received from a professional engineer
certifying that the permitted facility has been installed in accordance with
the approved plans and specifications. Mail the Certification to the Permits
and Engineering Unit, P.O. Box 27687, Raleigh, N.C. 27611-7687.
One (1) set of approved plans and specifications is being forwarded to
you. If you have any questions or need additional information, please contact
Ms. Babette McKemie, telephone number 919/733-5083, ext 177.
Sincerely,
R. Paul Wilms
cc Bladen County Health Department
Fayetteville Regional Supervisor
Mr. Dennis R. Ramsey
John Campbell
Engineer's Certification
I , as a duly registered Professional Engineer in
the State of North Carolina, hereby certify that construction of these permitted
facilities has. been completed in accordance with the approved plans and
specifications.
Signature
Date
NC0003573
Registration Number