The URL can be used to link to this page

Home My WebLink AboutNC0065706_Draft Permit_20171213Water Resources ENVIRONMENTAL QUALITY ROY COOPER Gove, na MICHAEL S REGAN Secretary LINDA CULPEPPER Interim Director December 13, 2017 Mrs Lucille Crosby Ginsberg Crosby Utilities Inc 7536 NC Hwy 39 Zebulon, N.0 27597 Subject Draft NPDES Permit NCO065706 Baywood/Cottonwood WWTP/WW-3 Wake County Dear Ms Ginsberg - The Division has reviewed your request to renew the subject permit Please review this draft carefully to ensure your thorough understanding of the information, conditions, and requirements it contains. The draft permit includes the following significant changes from the existing permit: ➢ Section A (6.) has been updated to reflect current language regarding electronic submission of effluent data Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) ➢ Components list has been amended to include one clarifier, one tertiary filter, and one sludge holding tank with a volume of 13,000 gallons. Two offsite pump stations have been removed from the list ➢ Regulatory citations have been added to the permit. ➢ Updated outfall map included With this notification, the Division will solicit public comment on this draft permit by publishing a notice in newspapers having circulation in the general Wake County area, per EPA requirements Please provide your comments, if any, to me no later than 30 days after receiving this draft permit. Following the 30 -day public comment period, the Division will review all pertinent comments and take appropriate action prior to issuing a final permit If you have questions concerning the draft, please contact me at 919-807-6393, or via e-mail [Anjah.Orlando@ncdenr.gov]. Sincerely, Anjali Orlando Compliance & Expedited Permitting Unit cc NPDES Files Raleigh Regional Office State of North Carolina I Environmental Quality I Water Resources 1617 Mail Service Center I Raleigh, NC 27699-1617 919 807 6300 919-807-6389 FAX https //deq nc gov/about/divisions/water-resources/water-resources-permits/wastewater-branch/npdes-wastewater-permits Permit NCO065706 STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENTAL QUALITY DIVISION OF WATER RESOURCES TO DISCHARGE WASTEWATER UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water Pollution Control Act, as amended, Crosby Utilities, Inc. is hereby authorized to discharge wastewater from a facility located at the Cottonwood/ Saywood W ffP Bethlehem Road Knightdale Wake County to receiving waters designated as Poplar Creek in subbasin 03-04-02 of the Neuse River Basin in accordance with effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III and IV hereof. This permit shall become effective This permit and authorization to discharge shall expire at midnight on February 28, 2023. Signed this day DRAFT Linda Culpepper, Interim Director Division of Water Resources By Authority of the Environmental Management Commission Page 1 of 9 Permit NC0065706 SUPPLEMENT TO PERMIT COVER SHEET All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked. As of this permit issuance, any previously issued permit bearing this number is no longer effective. Therefore, the exclusive authority to operate and discharge from this facility arises under the permit conditions, requirements, terms, and provisions included herein. Crosby Utilities, Inc. is hereby authorized to: 1. Continue to operate an existing 0.0575 MGD wastewater treatment system with the following components: Manual bar screen Flow equalization basin Extended aeration (2) Clarifiers with a volume of 22,084 gallons (2) Tertiary filters Chlorination Dechlorination Post -aeration Sludge holding tank with a volume of 13,000 gallons Effluent flow measurement The facility is located in Knightdale at the Cottonwood / Baywood WWTP on Bethlehem Road in Wake County. 2. After receiving an Authorization to Construct from the Division, construct and operate a 0.115 MGD wastewater treatment system. 3. Discharge from said treatment works at the location specified on the attached map into Poplar Creek, currently classified C -NSW waters in sub -basin 03-04-02, Stream Index 27-35, Hydrologic Unit 030202011103, of the Neuse River Basin. Page 2 of 9 Permit NCO065706 A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS [0.0575 MGD] [15A NCAC 02B.0400 et seq.,15A NCAC 0213.0500 et seq.] (a.) During the period beginning on the effective date of this permit and lasting until expansion above 0.0575 MGD, the Permittee is authorized to discharge from Outfall 001. Such discharges shall be limited, monitored, and reported' by the Permittee as specified below: PARAMETER DISCHARGE LIMITAIONS MONITORING REQUIREMENTS [PCS Code] Monthly Daily Measurement Sample Sample Average Maximum Frequency Type Location2 Flow[50050]0.0575 MGD Continuous RecordingInfluent or Effluent Total Monthly Flow [82220] Monitor & Report Monthly Calculated Influent or Effluent BOD, 5 -day (200C) [00310] 10.0 mg/L 15.0 mg/L Weekly Composite Effluent (April 1— October 31 BOD, 5 -day (200C) [00310] 20.0 mg/L 35.0 mg/L Weekly Composite Effluent November 1— March 31 Total Suspended Solids 30.0 mg/L 45.0 mg/L Weekly Composite Effluent 00530 NH3 as N [00610] 4.0 mg/L 20.0 mg/L 2/Month Composite Effluent (April 1— October 31 NH3 as N [00610] 8.0 mg/L 35.0 mg/L 2/Month Composite Effluent November 1— March 31 Dissolved Oxygen r003001 Dailv avera e > 6.0 m L Weekly Grab Effluent Dissolved Oxygen r003001 Weekly Grab U & D Fecal Coliform [31616] 200/ 100 ml 400 / 100 ml Weekly Grab Effluent (geometric mean Total Residual Chlorine 28 pg/L 2/Week Grab Effluent [50060] Temperature OC 00010 Daily Grab Effluent Temperature °C) r000101 Weekly Grab U & D TKN (mg/L) [006301 Monitor & Report 2/Month Composite Effluent NO27N + NO3-N (mg/L) Monitor & Report 2/Month Composite Effluent 00625 TN (mg/L [00600 ]4 Monitor & Report 2/Month Composite Effluent Monitor & Report Month' y Calculated Effluent TN Load [00600]5 (pounds/month) Calculated Effluent Monitor & Report(pounds/year)Annually Total Phosphorus r006651 Monitor & Report 2/Month composite Effluent H 00400 > 6.0 and < 9.0 standard units WeeklyGrab Effluent Notes: 1. The permittee shall submit discharge monitoring reports electronically using the NC DWXs eDMR application system. See A. (2.). 2. U: at least 50 feet upstream from the outfall. D: approximately 0.1 miles downstream from the outfall. 3. The facility shall report all effluent TRC values reported by a NC certified laboratory including field certified. However, effluent values < 50 µg/L will be treated as zero for compliance purposes. 4. For a given wastewater sample, TN = TKN + NO2-N + NO3-N, where TN is Total Nitrogen and TKN is Total Kjeldahl Nitrogen. 5. TN Load is the mass load of Total Nitrogen discharged in a given period of time. See A. (3), Calculation of TN Loads. There shall be no discharge of floating solids or foam visible in other than trace amounts. Page 3 of 9 Permit NCO065706 A. (2.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS [0.115 MGD] [15A NCAC 02B.0400 et seq.,15A NCAC 02B.0500 et seq.] (a.) Durmg the period beginning upon expansion above 0.057 MGD and lasting until expiration, the Permittee is authorized to discharge from outfall 001. Such discharges shall be limited, monitored, and reported' by the Pernuttee as specified below: PARAMETER LIMITS MONITORING REQUIREMENTS [PCS Code] Monthly Daily Measurement Sample Sample Average Maximum Frequency Type Location2 Flow [50050] 0.115 MGD Continuous Recording Influent or Effluent Total Monthly Flow [82220] Monitor & Report Monthly Calculated Influent or Effluent BOD, 5 -day (200C) [00310] 5.0 mg/L 7.5 mg/L Weekly Composite Effluent (April 1— October 31 BOD, 5 -day (200C) [00310] 10.0 mg/L 15.0 mg/L Weekly Composite Effluent November 1— March 31 Total Suspended Solids 30 0 mg/L 45.0 mg/L Weekly Composite Effluent 00530 NH3 as N [00610] 2.0 mg/L 10 mg/L 2/Month Composite Effluent (April 1— October 31 NH3 as N [00610] 4.0 mg/L 20 mg/L 2/Month Composite Effluent November 1 — March 31 Dissolved Oxygen [003001 Daily average > 6 0 m L Weekly Grab Effluent Dissolved Oxygen 00300 Weekly Grab U & D Fecal Coliform [31616] 200 / 100 rrl 400 / 100 ml Weekly Grab Effluent (geometric mean Total Residual Chlorine 28 pg/L 2/Week Grab Effluent [50060] Temperature OC) [000101 Daily Grab Effluent Temperature OC) [000101 Weekly Grab U & D TKN (mg/L 00630 Monitor & Report 2/Month Composite Effluent NO2-N + NO3-N (mg/L) Monitor & Report 2/Month Composite Effluent 00625 TN (mg/L F0060014 Monitor & Report 2/Month Composite Effluent TN Load [00600]5 Monitor & Report (pounds/month) Monthly Calculated Effluent Monitor & Report (pounds/year) Annually Calculated Effluent Total Phosphorus 00665 2/Month Composite Effluent H 00400 > 6.0 and < 9.0 standard units I Weekly Grab I Effluent Notes: 1. The pernuttee shall submit discharge monitoring reports electronically using the NC DWXs eDMR application system. See A. (6.). 2. U: at least 50 feet upstream from the outfall. D: approximately 0.1 miles downstream from the outfall. 3. The facility shall report all effluent TRC values reported by a NC certified laboratory including field certified. However, effluent values < 50 gg/L will be treated as zero for compliance purposes. 4. For a given wastewater sample, TN = TKN + NOz-N + NO3-N, where TN is Total Nitrogen and TKN is Total Kjeldahl Nitrogen. 5. TN Load is the mass load of Total Nitrogen discharged in a given period of time. See A. (3), Calculation of TN Loads. There shall be no discharge of floating solids or foam visible in other than trace amounts. Page 4 of 9 Permit NCO065706 A. (3.) CALCULATION OF TOTAL NITROGEN LOADS [G.S.143-215.1(b)] (a.) The Permittee shall calculate monthly and annual TN Loads as follows: (i.) Monthly TN Load (pounds/month) = TN x TMF x 8.34 where: TN = the average Total Nitrogen concentration (mg/L) of the composite samples collected during the month TMF = the Total Monthly Flow of wastewater discharged during the month (MG/month) 8.34 = conversion factor, from (mg/L x MG) to pounds (ii.) Annual TN Load (pounds/year) = Sum of the 12 Monthly TN Loads for the calendar year (b.) The Permittee shall report monthly Total Nitrogen results (mg/L and pounds/ month) m the appropriate discharge monitoring report for each month and shall report each year's results (pounds/year) with the December report for that year. A. (4.) TOTAL NITROGEN ALLOCATIONS [G.S.143-215.1(b)] The following table lists the Total Nitrogen (TN) allocation(s) assigned to, acquired by, or transferred to the Permittee in accordance with the Neuse River nutrient management rule (T15A NCAC 0213.0234) and the status of each as of permit issuance. For compliance purposes, this table does not supercede any TN limit(s) established elsewhere in this permit or in the NPDES permit of a compliance association of which the Permittee is a Co -Permittee Member. Note: (1.) Transport Factor= 50% a. Any addition, deletion, or modification of the listed allocation(s) (other than to correct typographical errors) or any change m status of any of the listed allocations shall be considered a major modification of this permit and shall be subject to the pubhc review process afforded such modifications under state and federal rules. Page 5 of 9 ALLOCATION AMOUNT ALLOCATION TYPE SOURCE DATE STATUS Estuary Discharge (pounds/year) (pounds/year) Base Assigned by Rule 12/7/1997; 1,163 2,325 Active (T15A NCAC 02B 4/1/2003 0234) TOTAL 1,163 2,325 Active Note: (1.) Transport Factor= 50% a. Any addition, deletion, or modification of the listed allocation(s) (other than to correct typographical errors) or any change m status of any of the listed allocations shall be considered a major modification of this permit and shall be subject to the pubhc review process afforded such modifications under state and federal rules. Page 5 of 9 Permit NCO065706 A. (5.) OUTFALL SIGNAGE [N.C.G.S.143-215.1 (b)] The Permittee shall maintain permanent signage identifying Outfall 001 as a wastewater discharge pomt. Unless approved otherwise by the Director, the signage shall conform to the following specifications: It shall be located in reasonable proximity to the outfall. It shall be clearly visible to persons on the adjoining property and in or near the surrounding waters and, toward that end, shall: be two-sided be located at least 3 feet above ground level at least two feet by two feet (2ft x 2ft) in size consist of black letters on a white field; the word "notice" to be at least 3 inches tall and the remaining words to be at least 21/4 inches tall The signage shall contain, at a minimum, the following mformation: NOTICE THIS IS A WASTEWATER DISCHARGE POINT CROSBY UTILITIES, INC — COTTONWOOD / BAYWOOD WASTEWATER TREATMENT PLANT NPDES PERMIT NCO065706 < local contact number for the facility > NORTH CAROLINA DIVISION OF WATER QUALITY RALEIGH REGIONAL OFFICE A. (2.) ELECTRONIC REPORTING OF MONITORING REPORTS [NCGS 143-215.1 (b)] Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) and program reports. The final NPDES Electronic Reporting Rule was adopted and became effective on December 21, 2015. NOTE: This special condition supplements or supersedes the following sections within Part II of this permit (Standard Conditions for NPDES Permits): • Section B. (11.) Signatory Requirements • Section D. (2.) Reporting • Section D. (6.) Records Retention Page 6 of 9 Permit NC0065706 • Section E. (5.) Monitoring Reports 1. Reporting Requirements [Supersedes Section D. (2.) and Section E. (5.) (a)1 The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic Discharge Monitoring Report (eDMR) internet application. Monitoring results obtained during the previous month(s) shall be summarized for each month and submitted electronically using eDMR. The eDMR system allows permitted facilities to enter monitoring data and submit DMRs electronically using the internet. Until such time that the state's eDMR application is compliant with EPA's Cross -Media Electronic Reporting Regulation (CROMERR), permittees will be required to submit all discharge monitoring data to the state electronically using eDMR and will be required to complete the eDMR submission by printing, signing, and submitting one signed original and a copy of the computer printed eDMR to the following address: NC DEQ / Division of Water Resources / Water Quality Permitting Section ATTENTION: Central Files 1617 Mail Service Center Raleigh, North Carolina 27699-1617 If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility being physically located in an area where less than 10 percent of the households have broadband access, then a temporary waiver from the NPDES electronic reporting requirements may be granted and discharge monitoring data may be submitted on paper DMR forms (MR 1, 1.1, 2, 3) or alternative forms approved by the Director. Duplicate signed copies shall be submitted to the mailing address above. See "How to Request a Waiver from Electronic Reporting' section below. Regardless of the submission method, the first DMR is due on the last day of the month following the issuance of the permit or in the case of a new facility, on the last day of the month following the commencement of discharge. Starting on December 21, 2020, the permittee must electronically report the following compliance monitoring data and reports, when applicable: Sewer Overflow/ Bypass Event Reports; Pretreatment Program Annual Reports; and Clean Water Act (CWA) Section 316(b) Annual Reports. The permittee may seek an electronic reporting waiver from the Division (see "How to Request a Waiver from Electronic Reporting" section below). 2. Electronic Submissions In accordance with 40 CFR 122.41(1)(9), the permittee must identify the initial recipient at the time of each electronic submission. The permittee should use the EPA's website resources to identify the initial recipient for the electronic submission. Page 7 of 9 Permit NCO065706 Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity (EPA or the state authorized by EPA to implement the NPDES program) that is the designated entity for receiving electronic NPDES data [see 40 CFR 127.2(b)]. EPA plans to establish a website that will also link to the appropriate electronic reporting tool for each type of electronic submission and for each state. Instructions on how to access and use the appropriate electronic reporting tool will be available as well. Information on EPA's NPDES Electronic Reporting Rule is found at: http://www2.epa.gov/compliance/final-national- pollutant-discharge-elimination-system-npdes-electronic-reporting-rule. Electronic submissions must start by the dates listed in the "Reporting Requirements" section above. 3. How to Request a Waiver from Electronic Reporting The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an electronic reporting waiver, a permittee must first submit an electronic reporting waiver request to the Division. Requests for temporary electronic reporting waivers must be submitted in writing to the Division for written approval at least sixty (60) days prior to the date the facility would be required under this permit to begin submitting monitoring data and reports. The duration of a temporary waiver shall not exceed 5 years and shall thereupon expire. At such time, monitoring data and reports shall be submitted electronically to the Division unless the permittee re -applies for and is granted a new temporary electronic reporting waiver by the Division. Approved electronic reporting waivers are not transferrable. Only permittees with an approved reporting waiver request may submit monitoring data and reports on paper to the Division for the period that the approved reporting waiver request is effective. Information on eDMR and the application for a temporary electronic reporting waiver are found on the following web page: http://deq,.nc.gov/about/divisions/w-ater-resources/edmr 4. Signatory Requirements [Supplements Section B. (11.) (b) and Supersedes Section B. (11.) c All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II, Section B. (11.)(a) or by a duly authorized representative of that person as described in Part II, Section B. (11.)(b). A person, and not a position, must be delegated signatory authority for eDMR reporting purposes. For eDMR submissions, the person signing and submitting the DMR must obtain an eDMR user account and login credentials to access the eDMR system. For more information on North Carolina's eDMR system, registering for eDMR and obtaining an eDMR user account, please visit the following web page: htt2://deq..nc.gov/about/divisions/water-resources/edmr Certification. Any person submitting an electronic DMR using the state's eDMR system shall make the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION WILL BE ACCEPTED: Page 8 of 9 Permit NCO065706 "I certify, under penalty of law, that this document and all attachments were prepared under my direction or supervision in accordance with a system designed to assure that qualified personnel properly gather and evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or those persons directly responsible for gathering the information, the information submitted is, to the best of my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for submitting false information, including the possibility of fines and imprisonment for knowing violations." 5. Records Retention [Supplements Section D. (6.)j The permittee shall retain records of all Discharge Monitoring Reports, including eDMR submissions. These records or copies shall be maintained for a period of at least 3 years from the date of the report. This period may be extended by request of the Director at any time [40 CFR 122.41]. Page 9 of 9