NCG110056_COMPLETE FILE - HISTORICAL_20140806

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V CCU lIOorJlo //Pv,5-7
DOC TYPE
HISTORICAL FILE
0 MONITORING REPORTS
DOC DATE
❑ ,201� a S O to
YYYYMMDD

Y71NULYWMW�
S
We are TR U to our customers!
August 5, 2014
Mr. Ryan Kormanik
Division of Energy Management and Land Resources
Land Quality Section
Mooresville Regional Office
610 East Center Ave. - Suite 301
Mooresville, NC 28115
`J11I kNU QUOF A ITOY SECTION ES
-+e—^Mll1C1ti
AUG 6 2014
'I risk
A'r'li
C(-eve(a-vJ�oi
Re: Follow up to 5/13/14 and 5/15/14 Stormwater Permit Inspections
Crowders Creek Wastewater Treatment Plant — Certificate of Coverage NCG130055
Long Creek Wastewater Treatment Plant — Certificate of Coverage NCG110056
As a follow up to the inspections performed 5/13/14 and 5/15/14, we wish to provide you information on the
status of each item addressed in the summary section of your inspection reports.
At the Crowders Creek WWTP (Certificate of Coverage NCG110055), three items
were noted in the Inspection Summary:
1. Please add drainage flows from the chemical secondary storage area on the
Stormwater Drainage Map.
Status: This has been included on the Stormwater Drainage Map. An
updated copy of this map is included with this letter.
2. A hole was observed at Outfali #9 approximately halfway up the slope and
in line with the drainage pipe. Please have this evaluated and repaired.
Please add armoring to the end of this pipe to prevent any scouring.
Status: This pipe was evaluated and it was determined that the hole was a
result of water flowing over the curb during heavy rains when this valve
was closed along with the ground being recently disturbed for the
installation of a new generator nearby. Valve will be kept open during rains
when no land application loading is occurring. Riprap has been added at
the end of the pipe.
Outfoll0 following
installation of Rlprop
3. Conversations with staff indicated that some work may be done in the area of inlets 21 & 22. These . .
inlets are located on the top of a jurisdictional dam. Any work in the area will need to have a repair plan
submitted to the Central Office and have approval from Dam Safety before work can begin.
s: No work will be done without prior approval.

At the Long Creek WWTP (Certificate of Coverage NCG110056), four items
were noted in the Inspection Summary:
1. There was erosion noted at the fence line near Outfall #4. This area
appears to have concentrated stormwater flow from the main lift
building and the backwash holding tank. Please stabilize the area of
erosion and begin monitoring this site per the Qualitative Monitoring
requirements within the permit.
Status: Rip Rap has been added to stabilize this area and regrading
has occurred. This area has been identified as Outfall #2 in the
Stormwater Drainage Plan and will be monitored in all future
qualitative monitoring events. A copy of the updated map is included
2. There were two areas of erosion at the fence line between
Outfall #9 & #10. These areas appear to have concentrated
stormwater flow exiting the site. Please develop a plan to either
include these areas as new outfalls with appropriate
stabilization or direct the stormwater flow to Outfall #9.
Status: This area has been regraded to direct flow on the
southern portion of the area to Outfall #9 and to prevent areas
of concentrated flow on the northern portion.
New Outfall #2 following
riprop and regrading
3. Between the generator area and the concrete flume there Area between outfalls #9 & #10
appeared to be a stormwater conveyance which appears to following regrading
discharge into the concrete flume. Please investigate this area
and update the stormwater maps if it is determined to be a part of the stormwater system.
Status: Water was flushed down the inlet north of the entry road and was observed coming out of at the
location shown to the east of the concrete flume. The original layout on the Stormwater Drainage Map is
correct.
4. Please update the Stormwater Drainage Plan maps to include the drainage features from the chemical
secondary containment area and the generator secondary containment area.
Status: The Stormwater Drainage Plan Map has been updated and is included with this letter.
We believe this addresses all the issues identified during your inspection. if you have any questions or if I may
provide any additional information, please call me at 704-866-6028 or email me at [e-mail].
Sincerely,
Dale Denton
Division Manager of Public Works
Certified Mail: 7014 0150 0002 0276 0708
CC: Michael Graham, Chief Senior Plant Operator— Long Creek WWTP
Sibyl Brotherton, Senior Plant Operator—Crowders WWTP
David Shellenbarger, Assistant Division Manager —Compliance
Stephanie Scheringer, Assistant Division Manager - Operations

i 4'k K`�: +.\ ?' • � >t'=S'T••-.3 -� 1w�'3- � � .:}-+r i � 1K� x �q,.�,�� �� � ,.,�,p,�,�,,,,
t� �f � ` i � r' _.' r' ! • ,' i r a >x3it'• � i� � j i"'F � o a - � � J � �LJU9S�5 Jam'• l.Zl�y � � o '
-12
<�� ��,�-r�• •,`- "�'f.•y�}rtif���.-'Y}• ,, �y � t�`�`�r•� L;�'i('}' r •�tr� F' �l?1Sl.SP11;t%�r'!1[VS u a Lh C'.e1 llJtib(/ iSV • 1-
'N_ /k'�
n 4 ��' i Ya fir'`Kty c t Diu. X rite.A'r�� s 'ti yK= Si h 7Rr� r•k y 4y� r eya �` t3 + 1 I I !
K�� %�r ' 7� � i .'�`t � "�', il 1) +r' �. Y,s .. ►.;r• t�., ,�.,, PY pn� �- d r # �,"•.�� a
c� � � 'r'ti �+ .-a- .�,� � t, ;''r• a ���� Rt���lr•+ ""� 4r= ' �-»'y�,-�.,ti�,t-.. t� � ° B � I �
_�j� sir 4xZT s+?E
:-?rr '--t��'�� Sa � i��� � � �Y � ' * ,t.c` Y� �:,t��jiay •may• �� ��_ � l �}+��,.7, �j] I • I 1 II
o � D � . _ D � Qa u � u �.� f }ti_±L%,�� .�.7t r. � �"µj:. � �� �yx� r � Y �� ''�t irs� ��� �•.e" � .�+ � � ^ � ,.4 !' - �;.'Z"' �f {� rcA fri r�u ��.•�-�,�
h � �.�.L4SS � � ` `,:r +: �� c - ..Ft � - -•_. � �� r� ?� x i:�,� V �•w�-i � a �� ' r + -- - � =t -�'� S � � ' � �'S' :1' �� ; 2J�J-7lL°•L°•F>ZS �- Iir%
yam, o o aI [S:.Cr5i7 1,� t y';`_}--.Y=�' �+.'�..r;•K':.r�., _fY _re••-wy-'t' s n� ice.•}•' .`o`l`?� 2 Gyl •� 1•
'.' u-""`•.fJ _"zJ _ � �-,�' '� ` �' c �:-� _. - 1�. ra .� ��� �,`:di�'tr `r �x -2•i is': �y��,r C �, ' , � 4jJjJ ��
+. o m '� � i'. ±.�,t : 1`_" s ' ;'��� -y'� :.ice= ..•��-qC �. Y��,�S,p- : �Y �;,; • yti �'� r =' .�--y � �� 1. � .., _ ., ?s� =: � � �, i.`?' _`�"> �:3� �rS! •cs... t 3".iY : Y-: � ' � - � - � / ! � t"•'r t.'r -a+ r
k.y ..s�r'�.I;.f: �r-'�'ra ,i�' ;TA_'l� ,. ►'4.,.r� - z ---. �:.• •a-.. - .sy--- - -.��•, 4_- �"i •�- j'�{_- - --.-^'^'r�� �y'�w.--•z..`"^.�. "� .�.. ��x
-y •±:��.it � Y4"�'�y f'� . �_'-� r-• � �-•� � , ' � _t,.6 -� ''l. ..t�� F- 'L sir .r''' _ ./_ �: ,l ti t - �, ,_t�' . ' ` N'rr _�'Q.�; :';;,,J ,�:✓_z t. i`•y', -cy� e'�i 3: +' r..z.. "`--% - •mot::_.`*•-;..''�'•.•'k - ^st.�-� rw,� o-��s.,�" �7�•; `-�-^ � ct�' i�* r-� ...!, J• f r:•
t; •,Z::y -r< .,.6~ ''T r �.� ;�•!
M s#�.$ Y+ ::'- C. -{. F. •e"S,: C.r,.r ax r2�a _7;.• 4�:` _? •.►.c "'•^.^" ♦° 1 is 't i ,� fv C' o �[r*7
^-f"i :- .�Y' ):. Jr i. -_- _ r �.( .y � .b _� � - 3"'i - - *� + • is �-! s, �i • � ! . ,,.1� -�! . . w - - �. r � .%a� s. ��' ! "au{,>> � .•.�? 3.�ya". i� ro. •` •i')�• i "{� - ".� 1 R :i:,)h ' � �� =.- -_4� �t � = � "•. `�_ d _- �^.S` t •�'• . ��$� � 3.. ij? i r _ �". , r: � d '�" = �% : { a, r�''�.
•,•-,, 5.!y:. • i .'i,... , •.' v _ - i _ �• •: y.•"�__` - a. x_-r ..YS -'� 1}- ,. w_ �: 'r.•".:,'k Y w- f,. - t• _
- ..t?��,� •.?', �t ,'1� '^,t'i. Ls �,P, .a
`Y�a. ,.. �'` .i• ri`i �. .L-. _ ,�y - w--fi t`• �`- `r .at•r ,• _ ,tK� _ -�`'r 'tl�i• ], i�,►'
Y.ui. 'V •! •• :..1 `+1\ L. `i
_ ` r-�•. ..a - -� �' -z-�'.. =`f; s - .• r, +:! i� -'y '. a .. i...r-. i'- �..�' \ I r--, i "•�-f..
. 1'f �_ r s ,:r'fK t i r-x.,. _;,,: c . , S'� ram- ♦YZ s _' � �.. »ar: rt �.. .r i` �r & ."h,' •" :a ~-.ice-`-' _ -`-s.. wti _�- . r' `-�-. .r... •. yr"
_r,' - .. .. �;� i�,. r rY ' !x - is r :s r-... ',+ , a- -['- ' Sht+;s.£y s', - �,t/♦j([}��>
b,•
x'L: S
Jjf/ �'� R "L• � '�-"' i w �i-.�'� 11� \ I i 1 Y i�. i�� � �'I •f `JAM- �.5�. �.fp 4$
-:�. e+<s --- . _ :..� _•:L_� __._ � �'-� - - "�b.rL'_e''c�n '!•5=•* ' • ;�;, .�� � C�sr•-%, -. �.' - �_ Jjj ��, a : 'tt' ;-t.• i�.- -.�) .5 I
.. "` ,e. t��� - ^ �, `-��::: - - r. �"`i .���� ,.•: �R, i. �x�'""` '_,_,�'$ �... �' � `11' �J . t ��_'_=*• r.!' .r`' .e-vJ � i'� � •r"•`''�'` ���'.�'- .f.�, .. �r �'=r� o , � �J
rti'_s..t �� >_4• _ :� r':s:-'�a ,,77 f,� ,�^ `•`a^' ri '�•-:.?T-i'•,.i'Y'"` '� c:�"' - ,5 j � -�':•f _ C,r i` .- ^R4><F� -� - ...•�.� _ _�;
� :.l ;�. ti .:.3 i 'f, '��?-� t. i *w�,.M=�Lc.�`-'t��s•- - v � � � � < �� � s-r s F. ,.�. +;,�*!:. �v Tr. ,.. k, � { �:. � .�. a :•t!a r. ,,
❑ Flared End Section Outlet
�� � _ � i 'i�•st.��� '�- • �- � »- c: 3 .s., � _ �.�.i.r �� _ � �r „ :t r � ,� :r� _ _ y � •l�l. ,sue ', i; z i� ': 1� r ;•` L` .�
._-`Ci.;'S'�7' \r-.1',"C,iT _- •*:S:4-.?�4 ti ix-....s"t mod' _ .:^ ,.-,,/i¢' ";-s..�'?f'� fr: -1 _�,:_.•x.y ` r Yr 'f' s?:. . 2 ,T` R�.r 2
Q i 9 -�., ;tea,_ - r'' r �' ✓s �:� r ,� _r f i 1
Head Wall Outlet `��:. � r , _ -< - �= ���.�•�-�+:•-��.:r' _ :�: J /_ - � ,�_ t�:•.s; �tr t �� `� _��.�,:+� ,, -
Open Ended Pipe Outlet �.s � _'- �'.}-," � f"''`'rr�-�- —=r -�"` _ ",.. Y-•-,s� ; s _.;, �, � i-, .� r_ �_ ;_,
Storm Drain Manhole
•r- -»z-,�,+'.::y`F _ _� , �: -:,r '� "�� Lsi f� ��: ♦� '( � 'F� + = * �x {� "j•�' }y _ � c 'I- � 2 p. . J "' rr� •�' t .�+` •'�' spy `�Y
ye . i � elf ..;x R,,��,.�.�F.: Y� fir._ � _ _ •� � ��- !1 - j./� ! . �yt�•��-�,,,�+�.` �14 - - '�' t � w�a .. �.•1 y��pf�
ill Junction Box 1zL� _ : -"• ^:iG f� / s•-l�` /cY �y't'.f't''*! ''_: i'.1 ._ •f.. f1 '�'rrf±''. ,"'�C' t.,� •f�j ;fir y�•°�S'
�'�=_ � �� � • �-s, . fi. � � •f - % t' 1/ �' F,� rat �,.r+ ��" t � t •, r �-!� �, � � e� �,
Drop Inlet .;�=i,,��„ r- �,,�',���� ���,�i �i4_ ,�� ♦ .\ /�_ � .� •� ;r 4}• ;.� � �' -
T'3±'�f 'i�'__ = -_, a���� •'Y'�; �* �y •.L fi � J ♦` - � � f= � �� *• tYb� _�� �-tk�.f� i-- k��. y� ' I �-F- f r' _ •.� J •�, y���
Catch Basin _ ay �?F-)i�. ♦ ;��� ti l s' �tc�,f f ,+F: tt ?
Open Throat Catch Basin
iG WC'`*' i �_r�� - T[. ,. s'S J- _ '� .�. ,' f% Sa' a r• •N
Flared End Section Inlet "¢�,� .;c ,, , r _ •_ s r s "��,�:F 'c:. = -�, - ,,t. _ - i g _` •n a , 1 t
_ ••L,.r • �• --. �-�" f — - a . _ . • ��`1��j�. �'_• " ty� _ ?`:.�•� • }.i` : "`�t.1r- A :r� rr� •�3 °�'r. , �Z -eT7 {$ > a� i �. e _ , �r �r fi'•
t� -ati:. �. '., � ' F� ���,► • - � ` +... _- ,; ?= ,Y ,..�.,, 't.�� .i?i�$ �7.� t +yam . �'}i:,�`� >v- jf -
® t `t . •ti-.y�'•7.J - - 2 t . , + ♦ r,K...w•�,�,• "" .t Y . •? t T.7-." _ t t'1 .'r r. :. •`' 1 A ;^. 1� - S �-�, Sz°
Open Ended Pipe Inlet _ r ,.. a _ L �, - _ _ _ 3.;dru i,� �• �:_ r;., ,,,} _' s,-
--�: y " ,".' .?-' ! �p. r � -,.' r �-i �-..+_.• ..aR' �� x....;; _ iY. i} .� YY - �:Y: '`' � • ty �T .. •L v'
• t Manhole 1 �` 3j. :-,T- `,!". i,-r. Ttf -. .. dE. #'�•. �i�'•+�,i-',;cr- f C„5 •-°. �1 ,Yv, , _ `i•'i F-;E>,•� I�•
Internal Drain a ho e ,?��, -:.. _ o o - _ r cn �[�; .:
' +:• may-
LI
Internal Pipe `. y!_SYI.
-v* .3M,ik•/•-t-: •d'%�,ie'y '` � :' '`' •. -�' w: -,.a-- -�✓. ' ..��. ._--'"' _ ',•--.Si -•t ,� ,� f � %± , fl� ! s _ ;Q�. _ �
' '�:�` - �r -. s'� -: 3"' S 'J - '` ' to ,�.• tY-,= s 'I
p Q Abandoned Pipe
Storm Pipe �'r-•+:t}c» Tt'� .i ri''.r''r"'i~ i. L - � `p. r:r-k��_'st. 7�'�-T�-srs==- - •J"4" 1�C4 'Tii '�•�=� •� - -
<' `7 - ?'1.�._ a ' �y� V-.`'.` � . 1 _ ~, �yl�' _ i ., r.' �' . �' 1 :� tir'_�"��.:'..E'-�=�.' rr •' ~r � : ' - . y ��`'ir • L1 f'
« y
O •� �. �' � -r''�. �`Ft3 � � � ` / • � - � -}:- � i'� IIII r �- � � i �'� ''�.. [-�ys,'-. ice. �-� = S ,t.: �� �'�.• '�i4, f � 2` `•'� �s
Fire Hvdram `}_Y
Nonpotable Hvdrant
��. Rip Rap Channel
Freshwater Wetland ` �� ' " � '��, 4 0 _ \tom _' s t � � �� 1` < : f r - , N{ , , - i
t V r L i i tF r F't 4�a '
�"` r;. -_ '} - t _ � Ills � _ ,:a-• ;�sa.�X f; ` J �'•' Y � '-o- �,t � ♦ r
Rain Gau-e r_ s,t IIII i i�• s, 'u t
© Property Boundary '�" �• . � 5` _ - = _ = * _ - j t t ' ,�, ',TZ
rri,s N'. .�r��Xrildlife And Industry Together St isy���
'I:��. ''q '� -� •t �P•t y Q i , 'i « - r._ - xf _ .:r f -- - f�c ;� /
- - -' - -r-- - - - - T t
� Y C .` T! ::iZ* -'rp. I . • �l+),. , sf ff f `' �i�.. ' w
1 gt
ram'
�•A � - �. ��+ ., �j i ;': r , - _� p�� �` � � r try � I "S
'^�'- i ;:r ti �... �,a•�,ssL_-�` i iL- i� 11- -'i;- ':}.T'`< i o ��f f[ t p,. e,F.!'�" 3.'- i O �;. - l�`, aF.�,
�� �� _ - -ter � `"-•.:f'�+�r - �y - � .e E� l: �s +� ��.f�i ' '
ly+,,,i�pls�,,����
�A1� / ,'.t�S-c' 3•-ixiKi'l•i�'...! _ f' yr`- W !j/�F'1.2')r f i!! +'�yC r 'y �- ` - ti -
r[� �'�r,� � - �^; 1.� - 7'; � i'fy� V _ ��__ f is :` �8?' Ci� 4 � 1•• `J♦ 'T 7 S_?
q,,,.{ [' fl "^it+ L.� R t,.3u��t ,"r'•c.� - :rt:: F.. ,.$. �5;ci -
Zz
'��d ��� j •.yx'�'4: .>.��•,t f _ {'�w.»,,,�� _ ;�� t t f ^v _ r `',.'!� .w��9,,. .I is Lr? - rc..wk-r _,xi- ::rF -#�-"' .3-•�,.�.. ''4-s" '�L. _ " 1.
le.2
'Hart' \\ ,,.may..•, d" ��.'� �� ail
A
{ ---i' -.li _ �Y •�.?..,?r, •-'�_ - •` - f _ f -J - r 'I}' :an'.`�-. {1 F i
4i� --:
J - ; `y 'f' -'s f I. �,�{ ` �` � .c�`"•� _ .,r^..�_ f�- yf� •' -� �'� � iyz ��: �,�r. t_ fir• ��s `, • { �'-:.�,�,3� ��`i �s
N� P' J� I_ - � '_{�- "+Y �. �t��/' � -�} � _ - f • � 4-" � �. +�, .`1• ] V-f' �!:- C:�.; � � '..�.r f� ,�'q.�y �� a.�.
�'^•• �� � .Y �. � � `�• ti 1 � f _'�l' - .�' 'f ►:ILs.1.j'�. ,. �.'� yt _' .�['. a'1�.'�. ��,�r lr _�- �'�t' � ;� �1 � "r '?'t�, 7� " rs •�i. ��..�` � i ���� � �. - �� _tr� ,�.. _ _+k�_ �, a.! � yr 'F"" V r j ems• �> �:�.♦.a� �1 5`,'' % N �`"'6,t :r' �'
r �� ;� «r. s! y '�.: •."-..`3. � `�' r •'• � f :.S' \ gip...• � �� _ - ��=4.ti- , , r ' ! ,: c�. 'aL�x� , t' - ...+.dde'L,�-.�.:< ... YE k.�..,� ri 9
c �__ .R.'x. `� ;.• _, f'� 0 125 250 500 750 1000
Ortb
South Carolina % y - - Carolina
ap
—"t ; � T' J �- `�`•"� 'mot^-•�'. y�.' �,r� { .`� _ �3'

co PY
NCDENR
Pat McCrory
Governor
John E. Skvada, III
Secretary
May 16, 2014
Dale Denton
Acting Stormwater Manager
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28054
Subject: Compliance Evaluation Inspection
Crowders Creek WWTP
NPDES Stormwater Permit NCG 110055
Gaston County, North Carolina
Dear Mr. Denton:
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on May 15, 2014 by Ryan Kormanik, of this Office. Please inform the
facility's Operator -in -Responsible Charge of our findings by forwarding a copy of the enclosed report.
During the inspection it was noted that no Stormwater Pollution Prevention Plan had been
developed. This should be addressed immediately.
The report should be self-explanatory; however should you have any questions concerning this
report, please do not hesitate to contact me at (704) 663- 1699.
Sincerely,
�yanKormanik
Environmental Senior Specialist
Enclosure - -- -
Cc: Stormwater Permitting
RK
Division of Energy, Mineral, and Land Resources
Land Quality Section - Mooresville Regional Office
610 East Center Avenue, Suite 301, Mooresville, North Carolina 28115
Telephone: [phone] I FAX: [phone] • Internet: http://portal,ncdenr.org/webArl and -quality
An Equal Opportunity 1 Affirmative Action Employer — 50% Recycled 110% Post Consumer Paper

H
V
Compliance Inspection Report
,. _ .. ...... ml4_NCG140055:--..Effective:,.06/01/13 E*p1ratFon:-05/91./48• 'Owner--Cityot.C3astoniar ,.-­,--._.._..,--,-.. `,K;., .... n ..I.._,.
SOC: Effective: Expiration: Facility: Crowders Creek WWTP
County: Gaston
5642 S York Rd
Region: Mooresville
Contact Person: fthi�s DALI DG"- or3 Title:
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site 1Representative(s):
Related Permits:
Inspection Date: 05/15/2014 Entry Time: 08:45 AM
Primary Inspector: Ryan C Kormanik
Secondary Inspector(s):
Gastonia NC 28054
Phone: [phone]
Certification:
Exit Time: 10:30 AM
Phone:
Phone:
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

4
Permit; NCG110055 Owner - Facility: City of Gastonia
Inspection Date: 05E15�2414„_!nspectian»Typni.'7(ni?ii�e:�ys�ivatior�:......y- . _.. Fi��7sk4�:fofvisl ...Ro�tiil... .........ti r:�..:H•,,.
Inspection Summary:
1. Please add drainage flows from the chemical secondary storage area on the Stormwater Drainage Map.
2. A hole was observed at Outfall #9 approximately half way up the slope and in line with the drainage pipe. Please have
this evaluated and repaired. Please add armoring to the end of this pipe to prevent any scouring.
3. Converations with staff indicated that some work may be done in the area of inlets 21 & 22. These inlets are located
on the top of a jurisdictional dam. Any work in the area will need to have a repair plan submitted to the Central Office and
have approval from Dam Safety before work can begin.
Page: 2

I
Permit: NCG110055 Owner -Facility: City of Gastonia
Inspection. [1at�: ,Q 11 il�nt4,. tnsPoc(19n Typa:. Cpmpliancu EY.aivatiorl:: ,., r - ,_. �.... ..,
Reasgn fgr.VPeit ,. F2qutin� , :• ., Ki�c:::s.... .
Stormwater Pollution Prevention Plan
Yes
No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑ ❑ ❑
# Does the Plan include a General Location (USGS) map?
■
❑ ❑ ❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑ ❑ ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑ ❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
❑ ❑ ❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑ ❑ ❑
# Does the facility provide all necessary secondary containment?
■
❑ ❑ ❑
# Does the Plan include a BMP summary?
■
❑ ❑ ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
❑ ❑ ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑ ❑ ❑
# Does the facility provide and document Employee Training?
■
❑ ❑ ❑
# Does the Plan include a list of Responsible Party(s)?
■
❑ ❑ ❑
# Is the Plan reviewed and updated annually?
■
❑ ❑ ❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑ ❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑ ❑ ❑
Comment: Employee training occurred via video training in November 2013. The
SPPP was updated on 5/9/2014.
Qualitative Monitoring Yes No NA NE
Has the facility conducted its Qualitative Monitoring semi-annually? ■ ❑ ❑ ❑
Comment: The last monitoring event occurred on April 7, 2014. Slight turbidity was
noted at Outfall #1 due to unstabilized soil around a new dumpster pad. Ground cover
had been provided, just had not established by the time of the rain event.
Analytical Monitoring Yes No NA NE
Has the facility conducted its Analytical monitoring? ❑ ❑ ■ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? ❑ ❑ ■ ❑
Comment: No analytical monitoring is required by the facility at this time.
Permit and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ROOD
# Were all outfalls observed during the inspection? ■ ❑ ❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division? ❑ ❑ ■ ❑
Page: 3

Permit: NCGI 10055 Owner - Facility: City or Gastonia
-- ...InsPectign�Date;617�9;! - .:,InsRgct+on.TYRO,;,:g9.mplianca,Euatuatioia:•... .. ;. i -.� -,, Reason for,Vialt:., Routine,
.....,.,.,?..�_...,.:.. �.
# Has the facility evaluated all illicit (non stormwater) discharges? 0000
Comment: All storm drains have been marked around the facility. Drains painted red
indicate stormwater flow which leaves the site and enters a receiving waterway. Drains
painted yellow indicate flow which returns to the facility for treatment.
Page: 4

Y
NCDENR
ova fii arolifta' Depa tmont.of Eiivir~orimefi't'afi
Pat McCrory
Governor
Dale Denton
Acting Stormwater Manager
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28054
Dear Mr. Denton:
John E, Skvarla, fll
Secretary
May 16, 2014
Subject: Compliance Evaluation Inspection
Long Creek WWTP
NPDES Stormwater Permit NCG 110056
Gaston County, North Carolina
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on May 13, 2014 by Ryan Kormanik, of this Office. Please inform the
facility's Operator -in —Responsible Charge of our findings by forwarding a copy of the enclosed report.
During the inspection it was noted that no Stormwater Pollution Prevention Plan had been
developed. This should be addressed immediately.
The report should be self-explanatory; however should you have any questions concerning this
report, please do not hesitate to contact me at [phone].
Sincerely,
eyanKormanik
Environmental Senior Specialist
Enclosure - _-----_ --- _
Cc: Stormwater Permitting
RK
Division of Energy, Mineral, and Land Resources
Land Quality Section - Mooresville regional Office
610 East Center Avenue, Suite 301, Mooresville, North Carolina 28115
Telephone: [phone] FAX: [phone] • Internet: h#tp://portal.rlcdenr.org/webBrAand-quality
An Equal Opportunity 1 Affirmative Action Employer— 50% Recycled / 10% Post Consumer Paper

C
Compliance Inspection Report
Effective .'06/d1Y-i3 .:.-Expiration:'.0513-1111S::: :Owner:`City'cif'GaStdniaM
SOC: Effective: Expiration: Facility: Long Creek WWTP
County: Gaston 3000 Long Creek Disposal Plant Rd
Region: Mooresville
Contact Person: A#KHW*4;1w% DA►+=_ DetaTOn1 Title:
Directions to Facility:
System Classifications. -
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection Date: 05/13/2014 Entry Time: 08:30 AM
Primary inspector: Ryan C Kormanik
Secondary Inspector(s):
Dallas NC 28034
Phone: [phone]
Certification:
Exit Time. 11:00 AM
Phone:
Phone:
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

eiuer Yll.AtMWMw-..siWW�Y�M1.�a/4MMNbtR.Y`i:L.-. �.1t+...N •!♦ V. �.w /. ..F M .,. r . •. wtN.., Jt1 t..t ■'..MM-: •..,,.,wJ. t./.. r•Y...'. �. .,./•ala ., ..Y^"�+t:a.ir '�G A+�
'M� « '
� ,.
i t

Permit: NCG110056 Owner -Facility: City of Gastonia
Inspection O, trs: 06Ei 3120•?A -.. .?n�pacNcn,Typo:• Compliance Evelualaon�: , ' ' Reason for Visit.-Routi�a.
Inspection Summary:
During the inspection of the facility, there were a couple of items which needs to be addressed.
1. There was erosion noted at the fence line near Outfall #4. This area appears to have concentrated stormwater flow
from the main lift building and the backwash holding tank. Please stabilize the area of erosion and begin monitoring this
site per the Qualititive Monitoring requirements within the permit.
2. There were two areas of erosion at the fence line between Outfall #9 & #10. These areas appear to have
concentrated stormwater flow exiting the site. Please develop a pin to either include these areas as new outfalls with
appropriate stabilization or direct the stormwater flow to Outfall #9.
3. Between the generator area and the concrete flume there appeared to be a stormwater conveyance which appears to
discharge into the concrete flume. Please investigate this area and update the stormwater maps if it is determined to be a
part of the stormwater system.
4. Please update the Stormwater Drainage Plan maps to include the drainage features from the chemical secondary
containment area and the generator secondary containment area.
Please have the above actions performed within 90 days of receiving this inspection report.
An evaluation of Outfall #2 indicates that any stormwater from this area discharges onto grass and flows for approximately
300' before combining with flow from Outfall #1. At this time, it is appropriate to no longer monitor Outfall #2 as a
separate Outfall and can be removed from the Stormwater Drainage Map.
Page: 2

Permit: NC0110056 Owner - Facility: City of Gastonia
::,..., !ns*? �tit►crDatc; 050Q/2014:...... Inspoat;on Tvbe:- Gemplianc-_ Favktation_
.3 _. _ .. ..... -
Stormwater Pollution Prevention Plan
Yes No NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■ ❑ ❑
❑
# Does the Plan include a General Location (USGS)'map?
■ ❑ ❑
❑
# Does the Plan include a "Narrative Description of Practices"?
■ ❑ ❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■ ❑ ❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■ ❑ ❑
❑
# Has the facility evaluated feasible alternatives to current practices?
■ ❑ ❑
❑
# Does the facility provide all necessary secondary containment?
■ ❑ ❑
❑
# Does the Plan include a BMP summary?
■ ❑ ❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■ ❑ ❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■ ❑ Q
❑
# Does the facility provide and document Employee Training?
■ ❑ ❑
❑
# Does the Plan include a list of Responsible Party(s)?
■ ❑ ❑
❑
# Is the Plan reviewed and updated annually?
■ ❑ ❑
Q
# Does the Plan include a Stormwater Facility Inspection Program?
■ ❑ ❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■ ❑ ❑
❑
Comment: Employee training provided by video in December 2013.
Qualitative Monitoring
Yes No NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■ ❑ ❑
❑
Comment: The last Qualitative Monitoring was performed in April 2014.
Analytical Monitoring
Yes No NA
NE
Has the facility conducted its Analytical monitoring?
❑ ❑ ■
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑ ❑ ■
❑
Comment: Analytical Monitoring is not required by the facility at this time.
Permit and Outfalls
Yes No NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■ ❑ ❑
❑
- - #.Were-aT ouifa-ls obserG-e-d-�ing-the- inspection? -- — ---
■-❑-❑_❑ ------
# If the facility has representative outfall status, is it properly documented by the Division?
0 ❑ ■
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
■ ❑ ❑
❑
Page: 3

Permit: NCGlI O056 Owner -Facility: City of Gastonia
- •-1..�-fsectiaa±-�at� •.0E;�13�2ais�.. .ins�ws!'o�.FyQ3;.,�mpliai�e^ 5ve1L^tire_... _ .. .. ,..�... ..R�acsr. far.�It�ft:'..P.auu^A.,......_... ....... .
_ __ _. �rnuiiiii�r.�unm�r`r .• ...• i�i�inwrru.ni' _ -- - n�>.�` �..�••
1
Comment: The evalutation of illicit discharges was last updated in April 2014. All plant
drains have been marked to indicate where the flow of stormwater discharges to. Red
painted drains direct stormwater flow to the receiving stream. Yellow painted drains are
internal drains leading back to the wastewater treatment facility.
Page: 4

A7LA. FILE
- CCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Charles Wakild, P. E. Dee Freeman
Governor Director Secretary
Mr. Adrian Sims
-Stormwater Utility Administrator
P.O. Box 1748
Gastonia, NC 28054
Dear Mr. Sims:
August 13, 2012
Subject: Compliance Evaluation Inspection
General Stormwater Permit
Long Creek WWTP
General NPDES Permit NCG110056
Gaston County, North Carolina
Enclosed please find a copy -of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on July 27, 2012 by Ms. Donna Hood of this Office. Please inform the
facility's Operator -in -Responsible Charge of our findings by forwarding a copy of the enclosed report.
The report should be self-explanatory; however, should you have any questions concerning this
report, please do not hesitate to contact Ms. Hood or me at [phone].
Sincerely,
Robert B. Krebs
Surface Water Protection Regional Supervisor
Enclosure
DH
Mooresville Regional office
Location; 610 East Center Ave., Suite301 Mooresvitte, NC 28115
Phone: [phone] Fax: (704) 66MO401 Customer Service: 1-877-623.6748
Internet: www.ncwatergualltv,ora
Ar Equai Opportunity 1 Affirmative Action Employer— 501f6 RecyrledilO% Post Consurner paper
None hCarolhia

}
Permit: NCG110056
SOC:
County: Gaston
Region: Mooresville
Compliance Inspection Report
Effective: 06101/08 Expiratio : 05/31/13 Owner: City of Gastonia
Effective: Expiration: Facility: Long Creek WWTP
3000 Long Creek Disposal Plant Rd
Contact Person: David Vance Morgan
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Title: ORC
Certification:
Dallas NC 28034
Phone:[phone]
Phone:
Inspection Date: 07127/2012 •Entry Time: 09:4AM , Exit Time: 02:00 PM
Primary Inspector: Donna Mood �,�?I�,�� �r7(`�f Phone: 704-fi63-1fi99
v Ext.2193
Secondary Inspector(s):
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 07/27/2012 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
Page: 2

I
I
Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 07/27/2012 Inspection Type: Compliance Evaluation
Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USGS) map?
■
❑
❑
❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
❑
❑
❑
# Has the facility evaluated feasible alternatives to current practices?
■
Cl
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include a BMP summary?
■
❑
❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
0.0
❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
❑
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# boes the Plan include a Stormwater Facility Inspection Program?
■
❑
❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The stormwater pollution prevention plan (SPPP) was last updated on
7/19/2012. Employee training was in June and July of 2012. The SPPP should be
revised to include the area on -top of the hill where used oil and hydraulic fluid is stored.
Some housekeeping issues should be addressed in this area. A spreadsheet should be
developed to document the discharge from any secondary containment.
Qualitative Monitoring
Yes
No
NA NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑ ❑
Comment: Qualitative monitoring was last performed on 3/9/2012 and 10/11/2011.
Documentation of the monitoring includes photographs of the discharge.
Analytical Monitoring
Yes
No
NA NE
Has the facility conducted its Analytical monitoring?
❑
❑
■ ❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑
❑
■ ❑
Comment: Analytical monitoring is not required by the facility at the time.
Permit and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ■ Cl ❑ ❑
# Were all outfalls observed during the inspection? ■ ❑ ❑ Cl
Page: 3 .

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Data: 07/27/2012 Inspection Type: Compliance Evaluation Reason for Visit: Routine
# If the facility has representative outfall status, is it properly documented by the Division? ❑ ❑ 0 ❑
# Has the facility evaluated all illicit (non stormwater) discharges? ■ ❑ ❑ ❑
Comment: The evaluation for illicit discharges was last updated on 4/12/2012.
Overall, the City has developed and implemented a comprehensive SPPP. For ease of
response to unexpected spill incidents it is recommended to mark or paint all plant
drains/yard grates as storm water, and thereby leading to the receiving stream, or as
plant drain, and thereby leading back into the wastewater treatment system.
Page: 4

AGAII,
NCDENR FILE
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue
Governor
Mr. Adrian Sims
Stormwater Utility Administrator
P.O. Box 1748
Gastonia, NC 28054
Dear Mr. Sims:
Charles Wakild, P. E.
Director .
August 13, 2012
Dee Freeman
Secretary
Subject: Compliance Evaluation Inspection
General Stormwater Permit
Crowders Creek WWTP
General NPDES Permit NCG110055
Gaston County, North Carolina
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on July 26, 2012 by Ms. Donna Hood of this Office. Please inform the
facility's Operator -in -Responsible Charge of our findings by forwarding a copy of the enclosed report.
The report should be self-explanatory; however, should you have any questions concerning this
report, please do not hesitate to contact Ms. Hood or me at [phone].
Sincerely,
.� Robert B. Krebs
Surface Water Protection Regional Supervisor
Enclosure
DH
Mooresville Regional Office
Location: 610 East Center Ave., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: (704) 66N0401 Customer Service:1-877-623.6748
Internet: www,ncwsterouall1v.orq
on On
e
) aftfrallif
An Equal Opportunity 4 Affulriabve Action Employer - 50% Recycled110% Post Consumer paper

r
Compliance Inspection Report
Permit: NCG110055 Effective: 05/08/09 Expiration: 05/31/13 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Crowders Creak WWTP
County: Gaston 5642 S York Rd
Region: Mooresville
Gastonia NC 28054
Contact Person: Adrian Sims Title: SW Administrator Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Certification: Phone:
Inspection Date: 07/26/2012 E try Tim 0 0 AM Exit Time: 02:00 PM
f
Primary Inspector: Donna Hood � �!'(�'z Phona: 704 663-i699
Ext.2193
Secondary Inspector(s):
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWT'P > 1 MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
E Storm Water
(See attachment summary)
Page: 1

Permit: NCG110055 Owner • Facility: City of Gastonia
Inspection Date: '07126/2012 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
The Crowders Creek facility has two storm drains in the sludge loading area of the facility. Both have valves and those
valves are kept closed. Because this area is routinely receives stormwater comingled with sludge, it is always pumped
back into the wastewater treatment system. The second storm drain has a valve that is opened for road drainage during
severe rain events. It is recommended that this drainage be documented to ensure stormwater is not comingled with
sludge before it is released.
It was also noted during the inspection that the non -potable water was leaking near Outfall #9 and could potentially cause
a bypass of partially treated wastewater. This should be repaired as soon as possible.
Page: 2

Permit: NCG110055 Owner - Facility: City of Gastonia
Inspection Date: 07/26/2012 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USGS) map?
■
❑
❑
Cl
# Does the Plan include a "Narrative Description of Practices"?
■
Cl
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
❑
❑
❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include a BMP summary?
■
❑
❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
❑
❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
❑
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The Stormwater Pollution Prevention Plan (SPPP) was last updated on
12/5/2011. Employee training was performed on various days in July 2012 as well as
December 2011. A spreadsheet should be developed to document the discharge from
any secondary containment.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑
❑
Comment: Qualitative monitoring was last performed on10/11/2011 and 3/9/2012.
Analytical Monitoring
Yes
No
NA
NE
Has the facility conducted its Analytical monitoring?
❑
❑
■
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑
❑
■
❑
Comment: No analytical monitoring is required by the facility at this time.
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■
❑
❑
❑
# Were all outfalls observed during the inspection?
■
Cl
❑
❑
# If the facility has representative outfall status, is it properly documented by the Division?
❑
❑
■
❑
Page: 3

Permit: NCG110055 Owner - Facility: City of Gastonia
t
Inspection Date: 07/26/2012 Inspection Type: Compliance Evaluation Reason for Visit: Routine
# Has the facility evaluated all illicit (non stormwater) discharges?
Comment. The storm drains were last evaluated for illicit discharges on 4/12/2012.
For ease of response to unexpected spill incidents it is recommended to mark or paint
all plant drains/yard grates as storm water, and thereby leading to the receiving stream,
or as plant drain, and thereby leading back into the wastewater treatment system.
■ ❑ ❑ 0
Page: 4

g- V. -e
i.
Beverly `eaves Perdue
Governor
A "
NCDENR
North Carolina Department of Environment anti Natural Resour
Division of Water Quality
Coleen 11. Sullins
Director
July 20, 2011
Mr. Adrian Sims, Stormwater Utility Administrator
Public Works and Utilities
City of Gastonia
PO Box 1748 -
Gastonia, North Carolina 28053-1748
Subject: Compliance Evaluation Inspection
City of Gastonia Long; Creek W WTI'
Stormwater Permit No. NCGI 10056
Gaston County, NC
Dear Mr. Sims:
F I L E �
CUS
Dee Freeman
Secretary
Enclosed is a copy of the Compliance Evaluation Inspection Report for the inspection conducted at the
subject facility on July 19, 2011 by John Lesley of this Office.
The: report should be self-explanatory; however, should you have any questions concerning; this'report,
please do not hesitate to contact Mr. Lesley at 704-663-1699.
Enclosure
cc: Central ]Niles
NPS-ACO
ill
Sincerely,
Robert B. Krebs
SLUTC-tce Water Protection
Regional Supervisor
MoorosviHe Regional Office 011C
Location: 610 East Center Ave., Suite 301 Mooresville, NC 2811li Nnt-thCarolina
Phone: [phone] Fax: (704) f363.6040 1 Customer Service: 1-&77-623.6748 ntll!`itlli/
Internet: www,ncwaterquality.org
An Equal Opportunity %Affirmative Action Employer— 50% Recycledlto% Post Consumer paper

a
Compliance Inspection Report
Permit: NCG110056 Effective: 06/01/08 Expiration: 05/31/13 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Long Creek WWfP
County: Gaston 3000 Long Creek Disposal Plant Rd
Region: Mooresville
Dallas NC 28034
Contact Person: David Vance Morgan Title: ORC Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):.
On -Site Representative(s):
24 hour contact name David Vance Morgan Phone: [phone]
Related Permits:
Inspection Date: 07/19/2011 Entry Time: 10:00 AM, Exit Time: 12:10 PM
Primary Inspector: John E Lesley= �!it L ` %" �. ' %� Zol Phone: [phone]
Secondary Inspector(s): 4._ l _-
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
E Storm Water
(See attachment summary)
Page: 1

{�
1
Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 07119/2011 Inspection Type: Compliance Evaluation Reason for Visit. Routine
C+nrm%untnr Pnlln}inn Pravan+inn Plnn Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plwi?
Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 07119/2011 Inspection Type: Compliance Evaluation Reason for Visit. Routine
C+nrm%untnr Pnlln}inn Pravan+inn Plnn Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plwi?
®❑
❑ Cl
# Does the Plan include a General Location (USGS) map?
®❑
❑ ❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑ ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑ ❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑
❑
■ ❑
# Has the facility evaluated feasible alternatives to current practices?
Cl
❑
■ ❑
# Does the facility provide all necessary secondary containment?
■
❑
❑ ❑
# floes the Plan include a 6MP summary?
■
❑
Q ❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
Q
Cl ❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
Q
❑ ❑
# Does the facility provide and document Employee Training?
®
D
❑ n
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑ ❑
# Is the Plan reviewed and updated annually?
■
❑
Cl ❑
# Does the'Plan include a Stormwater Facility Inspection Program?
■
❑
❑ ❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑ Q
Comment: The annual review certification is dated 7/18/2011.
The semi-annual inspection was last completed on 411812011.
Comprehensive records are maintained for the facility's Stormwater Pollution
Preventation Plan.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
e
❑
❑
❑
Comment: Qualitative monitoring was conducted on 3/10/11. The facility documents
all monitoring events with photographs of the outfalls.
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■
❑
Cl
❑
# Were all outfalls observed during the inspection?
■
❑
❑
❑
# If the facility has representative outfall status, is it properly documented by the Division?
n
❑
®
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
W
Q
❑
❑
Comment: The facility's stormwater collection system is evaluated weekly by WWiTP
(documented on the WWTP Operations Log).
Page: 3

FIL
NCDENR E19W
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H, Sullins Dee Freeman
Governor Director Secretary
October 26, 2010
Mr. Adrian Sims, Stormwater Administrator
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28053-1748
Subject: Compliance Evaluation Inspection
Crowders Creek W WTP
Stormwater Permit No. NCG110055
Gaston County, NC
Dear Mr, Sims:
Enclosed is a copy of the Compliance Evaluation Inspection Report for the inspection conducted at
the subject facility on October 12, 2010 by Mr. Wes Bell of this Office. Please advise the facility's
Operator -in -Responsible Charge by forwarding a copy of the enclosed report.
The report should be self-explanatory; however, should you have any questions concerning this report,
please do not hesitate to contact Mr. Bell at [phone].
Sincerely,
Y Robert B. Krebs
Surface Water Protection Regional Supervisor'
Enclosure:
Inspection Report
cc: Gaston County Health Department
mm
Mooresville Regional Office
Location: 610;ast Center Ave., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: [phone] l Customer Service: 1 .877-623-6748
Internet: hfp://portal,ncdenr,org/weblwq
An Equal Opportunity 4 Affirmative Action Ernplover— 50;4 RezycleC113% Post Consumer paper
On
e
NCarolina
aturallil

Q
Compliance Inspection Report
Permit: NCG110C55 Effective: 0.5/06109 Expiration: 05/31/13 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Crcwders Creek MVTP
County: Gaston 5642 S York Rd
Region: Mooresville
Gastonia NC 28054
Contact Person: Adrian Sims Title: SW Administrator Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
On -site representative David Shellenbarger Phone: [phone]
On -site representative Michael Charles Graham Phone: 7C4-854-6657
Related Permits:
Inspection Date: 10/12/2010 Entry Time :50 AM Exit Time, 02:30 PM
Primary Inspector: Wesley N 5eli (Z7,t,., f%5 /O Phone: [phone]
Secondary Inspector(s): Ext.2192
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
E storm Water
(See attachment summary)
Page: 1

Permit: NCG110055 Owner - Facility: City of Gastonia
Inspection Date: 10/12/2010 Inspection Type: Comohance Evaluation Reason for Visit: Routine
Inspection Summary:
Page: 2

K
Permit: NCG110055 owner - Facility: City of Gastonia
Inspection Data: 10/12/2010 Inspection Type: Compliance Evaluation
Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■
n
n n
# Does the Plan include a General Location (USGS) map?
■
n
❑ n
# Does the Plan include a "Narrative Description of Practices"?
■
n
n ❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
n
n n
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
Q
n ❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑ n
# Does the facility provide aA necessary secondary containment?
■
❑
n ❑
# Does the Plan include a BMP summary?
■
n
n n
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
n
Cl 0
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
!�
❑ ❑
# Does the facility provide and document Employee Training?
■
n
n ❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑ ❑
# Is the Plan reviewed and updated annually?
■
n
n n
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
n ❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑ ❑
Comment: The Stormwater Pollution Prevention Plan (SPPP) was organized and well
maintained. The SPPP was last updated on 10/6/10 and employee training was last
performed on 11/1/09. Facility stormwater inspections were performed on 9/8/10. The
SPPP Coordinator must ensure the following: all monitoring (qualitative) and
inspections (facility stormwater) are performed according to the specified time periods in
the permit, a three year history of significant spills (even if none occurred) is
documented, overall SPPP updates are performed annually, the lattitude and longitude
are documented for each stormwater outfall, and a copy of the SPPP (with all required
documentation) is kept and maintained at the treatment plant site.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
n
n
n
Comment: The last qualitative monitoring event was performed on 9/27/10.
Analytical Monitoring
Yes
No
NA
NE
Has the facility conducted its Analytical monitoring?
❑
❑
■
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
n
n
■
n
Comment:
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■
n
n
n
Page: 3

Permit: NCG110055 Owner - Facility: City of Gastonia
Inspection Date: 10/12/2010 Inspection Type: Compliance Evaluation Reason for Visit: Routine
# Were all outfalls observed during the inspection?
■nnn
# If the facility has representative eutfall status, is it properly documented by the Division? ❑ Cl ■ n
# Has the facility evaluated all illicit (non stormwater) discharges?
Comment: The facility has designated nine stormwater outfalls. No discharges were
observed during the inspection. The site grounds were well maintained. The
stormwater outfalls were last evaluated for non-stormwater discharges on 1017110. The
stormwater outfalls are visually evaluated on a monthly basis by the operations staff;
however, these evaluations were not documented (in the daily operation log) until
October 10.
Page: 4

4�
A7iA.
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
UUYtrrl {Ut Dii';r%i0r Secretan,l
DIVISION OF WATER QUALITY
August 27, 2009
Long Creek WWTP
c/o City of Gastonia ;
P.O. Box 1748
Gastonia, North Carolina 28101
Subject: Long Creek WWTP
Permit No. NCG110056
Gaston County, N.C.
- Dear Mr. Morgan:
Attached is a copy of the subject stormwater permit inspection conducted on August 19, 2009 by
Mr. Samar Bou-Ghazale of this Office.
The report should be self-explanatory; however, should you have any questions concerning the
report, please do not hesitate to contact Mr. Bou-Ghazale or me at [phone].
Sincerely,
Rob B. Krebs
Surface Water Protection Regional Supervisor
Attachment
Mooresville Regional Office
Location: 610 East Center Ave., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: [phone] Customer Service: 1-877-623-6748
Internet: www.ncwate uali .o
An Equal Opportunity 1 Affirmative Action Employer — 50% Recycled110% Post Consumer paper
Wile hCaro ina
I/ atural�ly

h.
Compliance Inspection Report
Permit: NCG110066 Effective: 06/01/08 Expiration: 05/31/13 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Long Creek VWVrP
County: Gaston 3000 Long Creek Disposal Plant Rd
Region: Mooresville
Dallas NC 28034
Tide: ORO Phone: 70_854-6655
Contact arson: Davie Vance iviuryari 4 _
Directions to Facility:
System Classifications:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Inspection . ............•----._ ,._...,..,; ............._... ...- ---......._ ..
Date: 08/1912009 Entry Time: 11:00 PM Exit Time: 12:00 PM
Primary Inspector: Samar E Bou Ghazale Phone: [phone]
Ext-2199
Secondary lnspector(s):
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Slormwater Discharge, COO
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
0 storm water
(See attachment summary)
Page: i

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 08119/2009 Inspection Type: Compliance Evaluation
Reason for Visit: Routine
Inspection Summary:
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
_
r,
! ''
"
! -)
n
# Does the Plan include a General Location (USGS) map?
■
❑
Q
11
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
0
0
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
n
Cl
Cl
# Has the facility evaluated feasible alternatives to current practices?
■
Q
Q
❑
# Does the facility provide all necessary secondary containment?
■
Q
❑
# Does the Plan include a BMP summary?
■
❑
❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?.__—.
■
❑
❑
rl
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
0
Q
# Does the facility provide and document Employee Training?
■
# Does the Pl.an include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
fl
Q
# Does the Plan include a Stormwater Facility Inspection Program?
■
Cl
❑
Q
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
Cl
Q
Comment:
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
00
Y
Comment:
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■
D
D
Q
# Were all outfalls observed during the inspection?
■
Cl
Q
# If the facility has representative outfall status, is it properly documented by the Division?
110
■
❑
# Has the facility evaluated all illicit (non Stormwater) discharges?
■
n
❑
n
Comment. No Representative outfall at the facility.
Page: 2

•
.Y
Beverly Eaves Perdue
Governor
NCDENR
North Carolina Department of Environment and Natural Resources
. Division of Water Quality .
RE C F IV
F'r ""eman
Danny O'Crew
City of Gastonia
PO Box 1748
Gastonia, NC 28053
Dear Permittee:
Coleen H. Sullins
Director
May 8, 2009
MAY 1 3 2009
�t3�.� i,Jlwlvs� IYii'
DWQ-Surface Water Prciet;iian
Subject: NPDES Stormwater Permit Coverage Renewal
Crowders Creek WWTP
COC Number NCG 110055
Gaston County
1n response to your renewal application for continued coverage under stormwater General Permit NCG 110000, the
Division of Water Quality (DWQ) is forwarding herewith the reissued stormwater General Permit. This permit is
reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between the state of North Carolina and the U.S. Environmental Protection Agency, dated October 15,
2007 (or as subsequently amended.)
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of stormwater General Permit NCG 110000
• A copy of a Technical Bulletin for the General Permit
• Five copies of the Discharge Monitoring Report (DMR) Form
• Five copies of the Qualitative Monitoring Report Form
The General Permit authorizes discharges of stormwater only, and it specifies your obligations with respect to
stormwater discharge controls, management, monitoring, and record keeping. Please review the new permit to
familiarize yourself with all the changes in the reissued permit.
The more significant changes in the General Permit since your last Certificate of Coverage include the following:
• Permit cover page — Coverage is expanded to include industrial activities similar to the categorically identified
industries.
• Part I Section A — This part explains that the No Exposure Exclusion from permitting option may be available to
the permittee.
Wetlands and Stormwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604 One
Phone: [phone]FAX: 919.8C7-64941Customer Service-.1-877-623-6748 Carol-ina
Internet: www.ncwaterqLtaJ!�.org NOh
. fCar
An Equal OpportunllylAffiirmativeAclicnEmployer atU Lt11!1

14
• Part 11 Section A — Several minor expansions and clarifications of the required content of the Stormwater
Pollution Prevention Plan have been added. Please be sure that your plan is updated to comply with the new
requirements.
• Part 11 Section B —Qualitative monitoring must now be conducted during a representative storm event.
• Part II Section B —The permittee is required to keep a written record of his response to problems identified by his
rqualitat veajiop' or' �abEjer ons.
Part�ll,Sectior For facilities.with vehicle maintenance activities using more than 55 gallons of new motor oil
per month, new.provisions require that discharges from the vehicle maintenance areas be sampled twice per year,
and that the sampling results be compared to new numerical benchmark values. (The previous cutoff
concentrations have been eliminated.) .
• Part 1f9ection C, :F For facilities with vehicle maintenance activities using more than 55 gallons of new motor oil
per month, new provisions require the permittee to execute Tier One and Tier Two response actions, based on the
first benchmark exceedence (Tier One) and the second consecutive benchmark exceedence (Tier Two). Tier Two
requires that the-permittee institute monthly monitoring instead of twice -per -year monitoring, until three
consecutive moniWing'irVMI low no benchmark exceedences.
"i " `Part il'Seciion C' This part contains a new provision that four exceedences of any particular benchmark will
trigger increased DWQ involvement in the permittee's stormwater management .and control actions. DWQ may
direct the permittee to apply for an individual permit, or may direct the implementation or installation of specific
stormwater control measures.
Your coverage under the General Permit is transferable only through the specific action of DWQ.
This permit does not affect the legal requirements to obtain other permits which may be required by DENR, nor does
it relieve the permittee from responsibility for compliance with any other applicable federal, state, or local law, rule,
standard, ordinance, order; judgment, or decree.
If you have any questions regarding this permit package please contact Sarah Young of the DWQ Stormwater
Permitting Unit at [phone].
Sincerely,
for Coleen H. Sullins
cc: DWQ Central Files
Stormwater Permitting Unit Files
Mooresville Regional Office

STATE OF NORTH CAROLINA .
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG110000
CERTIFICATE OF COVERAGE No. NCGI10055
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.I, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
CITY OF GASTONIA
is hereby authorized to discharge stormwater from a facility located at
CROWDERS CREEK WWTP
5642 SOUTH YORK ROAD
SOUTH OF CROWDERS
GASTON COUNTY
to receiving waters designated as Crowders Creek, a class C water, in the Catawba River Basin in
accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I,
II, III, IV, V, and VI of General Permit No. NCG 110000 as attached.
This certificate of coverage shall become effective May 8, 2009.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day. May 8, 2009.
for Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission

IN
WATFRQ Michael F. Easley, Governor �Lw
�O G William G. Ross Jr., Secretary
rNorth Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
October 13, 2008
Mr. Larry Cummings
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28053-1748
Subject: Compliance Evaluation Inspection
City of Gastonia Crowder's Creek WWTP
Stormwater Permit No. NCG110055
Gaston County, NC
Dear Mr. Cummings:
Enclosed is a copy of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on October 10, 2008 by John Lesley of this Office.
The report should be self-explanatory; however, should you have any questions
concerning this report, please do not hesitate to contact Mr. Lesley or me at 704-663-1699.
Sincerely,
A�,r Robert B. Krebs
Surface Water Protection
Regional Supervisor
Enclosure
cc: Central Files
Gaston County Health Department
APS-NCO
JL
Mailing Address Phone [phone] Location
610 East Center Avenue, Suite 301 Fax [phone] East Center Avenue, Suite 301
Mooresville, NC 28115 Mooresville, North Carolina
Nona ' hCaro na
Xrrttur fill/
Internet: wwwmcwaterguality.ore Customer Scrvice 1-877-623.6748
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper

R
Compliance Inspection Report
Permit: NCG110055 Effective: 06/27/03 Expiration: 04/30/08 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Crowders Creek WWTP
County: Gaston 5642 S York Rd
Region: Mooresville
Gastonia NC 28054
Contact Person: Jon Anthony Page Title: ORC Phone: [phone]
Directions to Facility:
'System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
24 hour contact name
Related Permits:
Joseph E Bieker
Certification:
Phone:
Phone: [phone]
Inspection date: 1011012008 Entry Time: 03:00 PM Exit Time: 04:00 PM
Primary Inspector: John E Lesley �� �r� /b/131 d Phone: [phone]
Ext.2198
Secondary Inspector(s):
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1MGD, Stormwater Discharge, COC
Facility Status: TCompliant ❑ Not Compliant
Question Areas:
E Storm Water
(See attachment summary)
Page: 1

Permit: NCG110055 owner - Facility: City of Gastonia
Inspection Date: 10l10/2008 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USGS) map?
■
❑
❑
Cl
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑
❑
■
❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include:a BMP summary?
■
❑
Cl
❑
# Does the Plan include 'a Spill Prevention and Response Plan (SPRP)?
■
❑
Cl
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
❑
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The plan is reviewed annually. The last changes to the plan were made
5/01/2007.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑
❑
Comment: Qualitative monitoring was suspended during 2007 and first half of 2008.
The facility requested a nonexposure status and were instructed to hault monitoring until
the request could be processed. The facility does not meet the criteria for nonexposure;
therefore, qualitive must begin during September - November period, Be advised that
all Qualitative Monitoring Reports must be completely filled out and signed by the
inspector.
Permit and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ■ ❑ ❑ ❑
# Were all outfalls observed during the inspection? ■ ❑ ❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division? ■ ❑ ❑ ❑
# Has the facility evaluated all illicit (non stormwater) discharges? ■ ❑ ❑ ❑
Comment: All outfalls are indicated on the site map. Stormwater from the sludge
loading area is conveyed to the influent pump station,
Page: 3

OF W A rE9
4 'C
Mr. Joe Bicker
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina
Dear Mr. Bicker:
Michael F. Easley, Governor &l
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
August 6, 2008
28053-1748
Subject: Compliance Evaluation Inspection
City of Gastonia Long Creek WWTP
Stormwater Permit No. NCG 110056
Gaston County, NC
Enclosed is a copy of the Compliance Evaluation Inspection Report for the inspection
conducted at the subject facility on August 5, 2008 by John Lesley of this Office.
The report should be self-explanatory; however, should you have any questions
concerning this report, please do not hesitate to contact Mr. Lesley or me at 704-663-1699.
Sincerely,
for Robert B. Krebs
Surface Water Protection
Regional Supervisor
Enclosure
cc: Central Files
Gaston County Health Department
APS-NCO
Mailing Address Phone [phone] Location OM `
610 East Center Avenue, Suite 301 Fax [phone]W East Center Avenue, Suite 301 Nord ClfCarna.
Mooresville, NC 28i 15 Mooresville, North Carolina ,U
Internet: www.newateraualily.ore Customer Service 1-877-623-6748
An Equal OppertunitylAffirmalive Action Employer — 50% Recycled110% Post Consumer Paper

Permit: NCG110056
SOC:
County: Gaston
Region: Mooresville
Compliance Inspection Report
Effective: 06/01/08 Expiration: 05/31/13 Owner: City of Gastonia
Effective: Expiration: Facility: Long Creek WWTP
3000 Long Creek Disposal Plant Rd
Contact Person: David Vance Morgan
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
Title: ORC
On -Site Representative(s):
24 hour contact name David Shellenbarger
Related Permits:
Certification:
Dallas NC 28034
Phone: [phone]
Phone:
Phone: [phone]
Inspection Date: 08/05/2008 'Entry Time: 10:00 AM Exit Time: 12:00 PM
Primary Inspector: John E LesleK Phone: [phone]
Ext.2198
Secondary Inspector(s):
Marcia Allocco Phone: [phone] Ext.2204
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1 MGD, Stormwater Discharge, COC
Facility Status: IN Compliant ❑ Not Compliant
Question Areas:
■ Storm Water
(See attachment summary)
Page: 1

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 08/05/2008 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
Page: 2

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 08105/2008 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USGS) map?
■
❑
❑
❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑
❑
■
❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include a BMP summary?
■
❑
❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
❑
❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
Cl
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The Stormwater Pollution Prevention Plan was last updated on 517108
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑
❑
Comment: Please ensure that all information is included on the monitoring report form,
such as outfall number, date, etc.
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and the Certificate of Coverage available at the site?
■
❑
❑
❑
# Were all outfalls observed during the inspection?
■
❑
❑
❑
# If the facility has representative outfall status, is it properly documented by the Division?
❑
❑
■
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
■
❑
❑
❑
Comment: The facility had requested non exposure status. Outfalls 1 and 2 convey
stormwater from the facility to surface waters and do not met the criteria of non
exposure. Stormwater collected in the area of the screw pump station may also be
considered as exposed although the stormwater conveyance appears to stop on the
facility property and sheet flow to surface waters. It is recommended that all stormwater
outfalls in the Stormwater Pollution Plan be monitored as required by the permit.
Page: 3

c OF W A rFR
� r
o �c
May 14, 2007
Mr. Matthew W. Jordan, P.E.
Director of Public Works and Utilities
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28053-1748
t
Michael F. Easley, Go nor
William G. Ross Jr., Secretary Skt
North Carolina Department of Fnvironment and Natural Resources
Alan W. Klimek, P, E„ Director
Division of Water Quality
Subject: Compliance Evaluation Inspection
City of Gastonia- Long Creek WWTP
Stormwater Permit No. NCG 110056
Gaston County, North Carolina
Dear Mr. Jordan,
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the
inspection conducted at the subject facility on May 11, 2007 by Mrs. Sonja Basinger of this
Office.
The report should be self-explanatory; however, should you have any questions
concerning the report, please do not hesitate to contact Mrs. Basinger or me at [phone].
Sincerely,
for Robert B. Krebs
Surface Water Protection Regional Supervisor
Enclosure
cc: Gaston County Health Department
David Shellenbarger, City of Gastonia, PO Box 1748, Gastonia, NC 28053
SWB
N. C. Division of Water Quality, Mooresville Regional Office, 610 East Center Avenue, Suite 301, Mooresville NC 28115 [phone] Customer Service
1-877-623-6748

Permit: NCG110056
SOC:
County: Gaston
Region: Mooresville
Compliance Inspection Report
Effective:06106/03 Expiration:04/30108
Effective: Expiration:
Contact Person: David Vance Morgan
Directions to Facility:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
On -site representative David Shellenbarger
Related Permits:
Certification:
Owner: City of Gastonia
Facility: Long Creek WWTP
3000 Long Creek Disposal Plant Rd
Dallas NC 28034
Phone: [phone]
Phone:
Phone: [phone]
Inspection Date: 06/11/2007 Entry Time: 09:30 AM Exit Time: 10:30 AM
Primary Inspector: Sonja Basinger Phone: [phone]
Secondary Inspector(s):
Marcia Allocco ��� -t-� -� �', �`� Phone:
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWiP > 1MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
0 Storm Water
(See attachment summary)
Page: 1

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 05/11/2007 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USES) map?
■
❑
Cl
❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑
❑
■
❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include a BMP summary?
■
❑
Cl
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
❑
❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
❑
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
Q
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
Cl
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The facility has not had any significant spills in the last 3 years.
The facility utilizes the Hansen workorder system for preventative maintenance
(including corrective actions).
David Morgan (VWVTP ORC) and Joe Bieker (Stormwater Utility Administrator) are
included in the Plan as the Responsible Party.
The facility has current documentation of employee stormwater training (January 2007).
The Plan was last updated on May 4, 2007.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑
❑
Comment: The facility conducted its semi-annual monitoring on March 2006 and
November 2006.
Analytical Monitoring
Yes
No
NA
NE
Has the facility conducted its Analytical monitoring?
❑
❑
■
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑
❑
■
❑
Comment: The facility doesn't have any vehicle maintenance areas.
Page: 3

Permit: NCG110056 Owner - Facility: City of Gastonia
Inspection Date: 05/11/2007 Inspection Type: Compliance Evaluation
Permit and Outfalls
# Is a copy of the Permit and the Certificate of Coverage available at the site?
# Were all outfalls observed during the inspection?
# If the facility has representative outfall status, is it properly documented by the Division?
Reason for Visit: Routine
# Has the facility evaluated all illicit (non stormwater) discharges?
Comment: All non-stormwater discharges are evaluated by the operators during their
daily routine,
The facility has six stormwater outfalls. The outfalls appeared to be properly maintained
at the time of the inspection.
Yes No NA NE
■❑❑❑
■ ❑ ❑ ❑
■ ❑ ❑ ❑
■ ❑ ❑ ❑
Page: 4

APP.r �' `� _ ,.. _ _ - Date Docunmt #: wi.C-0102.002$
�. JeRPege, Senior Plant Operator DA,,l i V) " OPGAA! Effective 12/06/04
Revision Long Creek Wastewater Treatment Plant Schematic Revision #g0 12/06/04
Long
- - - SCAOA , • �,' _ 6 sroizhnc�ar
ANTENNA - 1STOFPM
EMERGENCY LAMM
BLOWER
BLDG.
I - ,
i
�• r
#1 + 6
' r
} 3
1
------- ---1-----�_�
__! I n o a o I
A I
, � j sASr�
IL JL JL JL _J}j (7
M.H. � -- a
AERATION C M W G
BASINS
(9 MGD) See Attachment for
ILAS /CONTROL
lBURDING t -
_ S+CpiQA S1tSTEM
-
/' 1
r ,
r _
4
CHEMICAL _ -
` FINAL CLAREF RS
tzchment for
de
Z. 2
SCA
� i' TI=RS T/ '�. 1 •
®y M_HU
GAS #8
INTERMEDA
�UFT PUMPS
1.
S A G ID
HOLDER M.H.
(00
:5e`e']Rttachroont forCONTACT
�LO� #9
SIPHON ____� - S1 A l
- INF. M.H. 4 - - - - F �-•,
DENI1RI116 'f'ION - -
,I a D - BASIN
TREATMENT r t! " `—Sm-Aft�Ch - — - — - —
r , detailed locations BACJCtNASH ^� • `
HOLDING
;� TANK A- Primary Effluent Composite
1 - Effluent Composite 2 - Effluent Grab�j� B - Raw Sludge Well
3 - Influent Composite 4 - Influent Grab ` LAYOUT PLAN C - New Aeration Basin
D - Old Aeration Basin
E - Denitrification Basin
F - Dissolved Air Floatation
G -- Anaerobic Digesters
H - RASMAS
'THIS IS AN UNCONTROLLED COPY OF A CONTROLLED DOCUMENT PRINTED 4/27/06 AT 11:32 AM"'Page I of 3
_C"RtNATIoN /
DECHLORINATION
STATIC
AERATOR
►2
STAGE 1
STAGE 2

Approval
Date
Jon Page, Senior Plant Operator
Aeration Basins
TYPICAL 7.0 & 9.0 MGD Trains
Ana 1 B
Ana 1 A
Oxic 3B
Oxic 2B
Oxic 2A
Oxic 3A
Ana 2B
Ana 2A
•
Ana 3B
Ana 3A
Anox
Anox
1B
1A
Oxic 4B
Oxic 1 B
Oxic 1 A
Oxic 4A
Anox
Anox
2B
2A
To Denitrification
Documeatom# -01 .002B
Effective
Revision Date: 121
Revision #: 0
• Sample Points
'THIS IS AN UNCONTROLLED COPY OF A CONTROLLED DOCUMENT PRINTED 4/27106 AT 11:32 AM"'Page 2 of 3

Approval _, -� Date
t -Jon Page, Senior Plant Operator
Denitrification Basin
From
Aeration
Basins
Anoxic 1
Anoxic 4
OXIC 1
Anoxic 2
Anoxic 3
Oxic 2
•
1
To Secondary Clarifiers
Document M wLC-0102.002E
Effective Date: 12/06/04
Revision Date: 12/06/04
Revision #: 0
*"*THIS IS AN UNCONTROLLED COPY OF A CONTROLLED DOCUMENT PRINTED 4/27/06 AT 11:32 AM***Page 3 of 3

t'110
O�v1 A ]' Michael F. Easley, Govern
FRQG William G. Ross Jr., SecretaryO.
y North Carolina Department of Environment and Natural Resources
r
Alan W. Klimek, P. E., Director
p Division of Water Quality
May 14, 2007
Mr. Matthew W. Jordan, P.E.
Director of Public Works and Utilities
City of Gastonia
Post Office Box 1748
Gastonia, North Carolina 28053-1748
Subject: Compliance Evaluation Inspection
City of Gastonia- Crowders Creek WWTP
Stormwater Permit No. NCG110055
Gaston County, North Carolina
Dear Mr. Jordan,
Enclosed please find a copy of the Compliance Evaluation Inspection Report for the
inspection conducted at the subject facility on May 9, 2007 by Mrs. Sonja Basinger of this
Office.
Please note comments under the Inspection Summary and Permit and Outfalls sections
of the inspection report.
The report should be self-explanatory; however, should you have any questions
concerning the report, please do not hesitate to contact Mrs. Basinger or me at [phone].
Sincerely,
for Robert B. Krebs
Surface Water Protection Regional Supervisor
Enclosure
cc: Gaston-(ounty Health Department
David She r cr 1 y alto ia, P ox 1748, Gastonia, NC 28053
W:
N.C. Division of Water Quality, Mooresville Regional Office, 610 East Center Avenue, Suite 301, Mooresville NC 28115 [phone] Customer Service
1-877-623.6748

r
Compliance Inspection Report
Permit: NCG110055 Effective: 06/27/03 Expiration: 04/30/08 Owner: City of Gastonia
SOC: Effective: Expiration: Facility: Crowders Creek WWTP
County: Gaston 5642 S York Rd
Region: Mooresville
Gastonia NC 28054
Contact Person: Jon Anthony Page Phone: [phone]
Directions to Facility:
Primary ORC: Certification: Phone:
Secondary ORC(s):
On -Site Representative(s):
On -site representative David Shellenbarger Phone: [phone]
Related Permits:
Inspection Date: 05/0912007 - Entry Time: 10:15 AM Exit Time: 11:30 AM
Primary Inspector: Sonja Basinger Phone: [phone]
Secondary Inspector(s): 11
Marcia Allocco Gk _ kt4C-3Phone:
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: Municipal WWTP > 1MGD, Stormwater Discharge, COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
0 Storm Water
(See attachment summary)
Page: 1

Permit: NCG110055 Owner • Facility: City of Gastonia
Inspection Date: 05/09/2007 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Inspection Summary:
The secondary containment of the facility's chemicals is earthen berm and grass covered slope. The divider between the
caustic and alum has a large vertical crack in the wall, This needs to be repaired immediately to prevent possible cross
contamination of chemicals if a spill should occur.
Page: 2

Permit: NCGI 10055 Owner - Facility: City of Gastonia
Inspection Date: 05/09/2007 Inspection type: Compliance Evaluation
Reason for Visit: Routine
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
❑
❑
❑
# Does the Plan include a General Location (USGS) map?
■
❑
❑
❑
# Does the Plan include a "Narrative Description of Practices"?
■
❑
❑
❑
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
❑
❑
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
❑
❑
■
❑
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
❑
# Does the facility provide all necessary secondary containment?
■
❑
❑
❑
# Does the Plan include a BMP summary?
■
❑
❑
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
❑
❑
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
❑
❑
❑
# Does the facility provide and document Employee Training?
■
❑
❑
❑
# Does the Plan include a list of Responsible Party(s)?
■
❑
❑
❑
# Is the Plan reviewed and updated annually?
■
❑
❑
❑
# Does the Plan include a Stormwater Facility Inspection Program?
■
❑
❑
❑
Has the Stormwater Pollution Prevention Plan been implemented?
■
❑
❑
❑
Comment: The facility has not had any significant spills in the last 3 years.
The facility utilizes the Hansen workorder system for preventative maintenance (which
includes corrective actions).
Jon Page (VWVfP ORC) and Joe Bieker (Stormwater Utility Administrator) are included
in the Plan as the Responsible Party.
The facility has current documentation of employee stormwater training (January 2007).
Tha Plan was last updated on May 4, 2007.
Qualitative Monitoring
Yes
No
NA
NE
Has the facility conducted its Qualitative Monitoring semi-annually?
■
❑
❑
❑
Comment: The facility conducted its semi-annual monitoring on March 2006 and
November 2006.
Analytical Monitoring
Yes
No
NA
NE
Has the facility conducted its Analytical monitoring?
❑
❑
■
❑
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas?
❑
❑
■
❑
Comment: The facility has no vehicle maintenance areas
Page: 3

Permit: NCG110055 Owner - Facility: City of Gastonia
Inspection Date: 05/09/2007 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Permit and Outfalls
Yes
No
NA
NE
# Is a copy of the Permit and.the Certificate of Coverage available at the site?
■
❑
❑
❑
# Were all outfalls observed during the inspection?
Cl
■
❑
❑
# If the facility has representative outfall status, is it properly documented by the Division?
■
❑
❑
❑
# Has the facility evaluated all illicit (non stormwater) discharges?
❑
❑
Cl
Comment: All non-stormwater discharges are evaluated by the operators during their
daily routine.
The facility has three stormwater outfalls. Only #1 and # 2 outfalls were observed during
the inspection. The #3 outfall could not be located by the ORC on the day of the
inspection. The facility staff must ensure that all outfalls are located, accessible and
maintained.
Page: 4

EKE Mmmi
1342625
1343125
1343625
1344125
1344625
14
n
M
N
n
N
N
Lin
n
r-+
M
N
LO
n
N
N
1342125 1342625 1343125
1343625
1344125
1344625

WA7-6RMichael F. Easley
Q
G Governor
r William G. Ross Jr., Secretary
Department of Environment and Natural Resources
+ ='KEPT. OF EM, % 1..gWMjk P E Director
A40 fdAPORAL RJftof Water Quality
:Mom 4wil
JUL 0 7 2003 w
June 27, 2003 ;
Mr. Larry W. Cummings, Division Manager of Wastewater
City of Gastonia Wastewater Treatment Division PO Box 1748 �VATER QUALITY SECTION' Gastonia, NC 28053
Subject: General Permit No. NCG110000
Crowders Creek Wastewater Treatment Plant
COC NCG110055
Gaston County
Dear Mr. Cummings:
In accordance with your application for discharge permit received on March 10.2003, we are forwarding herewith
the subject certificate of coverage to discharge under the subject state - NPDES general pernut. This permit is issued
pursuant to the requirements of North Carolina General Statute 143-215 .1 and the Memorandum of Agreement between
North Carolina and the US Environmental Protection agency dated December G, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you,
you have the right to request an individual permit by submitting an individual permit application. Unless such demand is
made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division of Water
Quality. The Division of Water Quality may require modification or revocation and reissuance of the certificate of
coverage.
This permit does not affect the legal requirementsto obtain other permits which may be required by the Division
of Water Quality or permits required by the Division of Land Resources, Coastal Area Management Act or any other
Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mack Wiggins at telephone number 919n33-
5083 ext. 542.
cc: C-Monresviile-RegionalOffice
Central Files
Stormwater and General Permits Unit Files
G�IrI�PiL' SIGNED BY
' WILLIAM G. MILLS
Alan W. Klimek, P.E.
Rifb
Customer Service
1 800 623-7748
Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]

<,
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG110000
CERTIFICATE OF COVERAGE No. NCGI10055
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
City of Gastonia
is hereby authorized to discharge stormwater from a facility located at
Crowders Creek Wastewater Treatment Plant
5642 South York Road
south of Crowders
Gaston County
to receiving waters designated as Crowders Creek, a class C water in the Catawba River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1, I1,1II,
IV, V, and Vl of General Permit No. NCG110000 as attached.
This certificate of coverage shall become effective June 27, 2003
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 27, 2003 . f ORIGINAL SIGNED BY
WILLIAM C. MILLS
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

of VATEq
O� QG
� 1
� Y
June 6, 2003
Mr. Larry W. Cummings
Division Manager of Wastewater Treatment
City of Gastonia -Wastewater Treatment Division
P.O. Box 1748
Gastonia, NC 28053
Michael F. Easley, Govemor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Kllmeck, P.E.
Director
Division of Water Quality
Subject: General Permit No. NCGI 10000
Long Creek Wastewater Treatment Plant
COC NCGI 10056
Gaston County
Dear Mr. Cummings:
In accordance with your application for a discharge permit received on March 10, 2003 we are
forwarding herewith the subject certificate of coverage to discharge under the subject state — NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated May
9, 1994 (or as subsequently amended). .
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Water Quality. The Division of Water Quality may require modification or revocation and reissuance of the
certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Water Quality or permits required by the Division of Land Resources, Coastal Area Management
Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Aisha Lau at telephone number (919)
733-5083 ext. 578.
W, ,;, .,t I �IySIGNED BY
,'WILLIAM C. MILLS
Alan W. Klimek, P.E.
cc: Mooresville Regional Office
Central Files
Stormwater and General Permits Unit Files
NC DEPT. OF ENVIRONMENT
AND NATURAL RESOURCES
MOORESVIII '�KXMOFFICE
JUN 1 G 2003
WATE VALffif SECIN
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699.1617 [phone] Customer Service
1 800 623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG110000
CERTIFICATE OF COVERAGE No. NCGI10056
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
City of Gastonia — Wastewater Treatment Division
is hereby authorized to discharge stormwater from a facility located at
Long Creek Wastewater Treatment Plant
300 Long Creek Disposal Plant Road
Dallas
Gaston County
to receiving waters designated as Long Creek, a class C stream in the Catawba River Basin in accordance with the
effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, IV, V and VI of
General Permit No. NCG110000 as attached.
This Certificate of Coverage shalt become effective June 6, 2003.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 6, 2003. J r ORIGINAL SIGNED BY
;<
WILLIAM C. MILLS
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

,r
� �>�x•�'` -' ir�.I � at 'h'�XkI�' r•' � �.-3"� � ,,r„��sr r11.: -��� R� � . . ' ��1s7.+ ��„�+ _�``'+�-fit` �F �
�d 'a �y \. �f ���' 11 / �- 4'k ��. •..r t •j, � -fk �i' h' � �-[+ •1
i %~(
• ,r�' 1 �j
16
�� �-• • . e_ .� I'a^ � S �. ,fr ��Y. •u. r� g " 41t �t'�r •r Y,f� 4+, ..1.. . J; � r � �.
.r t S ' �1� r .�FrR t �f -F r t � `� ' f.. � , i � ` _ � ♦ ,rYk J ��
f -y57 F •-tt is �+ I r sa ' '�`�y � �kj' � v . :
� � j}a { i ,�. � •'�:rs,�, •'<� fir. � �� ,I � ,{�r� ? :�
}`{� r �',. r ,� �x�rr a 3, .k•,:�y��,� } t ��, ,� ,�,• TM 1.� k'`Y t r• ; < r:
r, •_f-.. t2 � r r r,�...�.f4� ` Y ^•�- �� Ly� -_u„r `} s aK :' y'J ,� r . -� . i 1-s
-f .kt� ti�' tt«-�l� i � � T �:•°r' r �W._ --�:�i ..Yk �� '��� � k. P I:
_ .. 1 � fir •� i a. °j
��, +�' r�'• r Fi � '�.I� 3 AYl�. 5���-�Nr �\S iF_: Sri �`���+�'1FF , � �' � R .k
� `
n
• 111. r r :%� + Y?1 F ,("�,1 ` {!F Y�,`. .�I i � +`,�f\.i_n. i + q >
„, � 5�"f ,\. �V ••f-_. ' F � rr ��. o �. � M9 1` � , � '. �� ; � � t� S-e e ?��d.l s,
fx. r•
s� i �15 S �� `2' �^ ,`, .k n 4. �"'+ � / �`! 1 i � � . 7 ""� , e s Pd!`� ce L ! "•V , ',y�yy
Copy�lpht {C) 1997, Maptech, Inc.